Text preview for : sm_S5x_lvl_25_V1[1].0.PDF part of siemens s5x service manual
Back to : sm_S5x_lvl_25_V1[1].0.rar | Home
Information and Communication Mobile www.spunlock.com
S55/S56/S57 (Bluetooth) Level 2.5
Repair Documentation
V 1.0
V 1.0 S55/S56/S57
Page 1 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
Table of Content
1 2 3 4 5 6 7 8 9 Introduction ........................................................................................................................3 I/O Connector (Slim Lumberg) ...........................................................................................4 Battery Connector..............................................................................................................8 Display Connector ...........................................................................................................11 Antenna Connector..........................................................................................................14 Card Reader ....................................................................................................................18 Board Connector..............................................................................................................21 IRDA ................................................................................................................................25 Bluetooth antenna............................................................................................................28
V 1.0 S55/S56/S57
Page 2 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
1 Introduction
S55 product family, consists of 2 tripleband (GSM900, GSM1800 and GSM1900) handsets named S55 and S57, which can be distinguished from the second block after the partnumber printed on the IMEI label, and the S56, a dualband mobilphone (GSM850 and GSM1900)
Partnumber on IMEI label: S55: S56: S57: S30880-S5720-#xxx S30880-S5350-#xxx S30880-S5700-#xxx
, while # may be any letter (A-Z) and xxx may be any number from 100, 101, 102....
This manual is intended to help you carry out repairs on level 2.5, meaning limited component repairs. The documented failure highlights should be repaired in the local workshops. All repairs have to be carried out in an environment set up according to the ESD (Electrostatic Discharge Sensitive Devices) regulations defined in international standards. If you have any questions regarding the repair procedures or technical questions about the spare parts do not hesitate to contact our technical support team in Kamp-Lintfort, Germany: Tel.: +49 2842 95 4666 Fax: +49 2842 95 4302 e-mail: [email protected]
V 1.0 S55/S56/S57
Page 3 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
2 I/O Connector (Slim Lumberg)
2.1 Affected Units
2.1.1 Type: 2.1.2 Affected IMEIs / Date Codes: 2.1.3 Affected SW Versions:
S55/S56/S57 All / All All
2.2 Fault Description
2.2.1 Fault Symptoms for customers:
- Charging problems. - Problems with external loudspeaker or microphone when using a car kit. - Problems with accessories connected at the I/O connector. - Problems with SW booting
2.2.2 Fault Symptoms on GSM Tester:
This fault cannot be detected with a GSM-Tester
2.3 Priority:
Mandatory Repair Optional Not Yet Defined
V 1.0 S55/S56/S57
Page 4 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
2.4 Repair Documentation:
2.4.1 Description of procedure:
2.4.1.1 Diagnosis:
Visually check the bottom connector. Watch for dry joints:
2.4.1.2 Repair by component change:
Use hot air blower remove defective I/O connector. Avoid excessive heat! Watch surrounding components! Resolder new I/O connector afterwards.
2.4.1.3 Repair by Software booting:
Not possible!
2.4.1.4 Test:
Retest handset after repair.
2.4.2 List of needed material:
2.4.2.1 Components:
I/O Connector S55/S56/S57 Part-Number: L36334-Z93-C303
2.4.2.2 Jigs and Tools:
Hot Air Blower Soldering Iron
V 1.0 S55/S56/S57
Page 5 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones 2.4.2.3 Special tools:
None
2.4.2.4 Working materials
Desolder Wick / Braid Solder
2.4.3 Drawings
Figure 1: S55/S56/S57 board I/O connector
Figure 2: S55/S56/S57 I/O connector placement (top view)
V 1.0 S55/S56/S57
Page 6 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
Table 1: S55/S56/S57 Bottom Connector Pin Description
Pin 1
Name POWER
IN/OUT I/O
Notes POWER is needed for charging batteries and for supplying the accessories
2 3 4 5 6 7 8 9 10 11 12
GND TX_1 RX_1 CTS_1 RTS_1 DCD_1 AUDIO_P O I I/O I/O I/O O Serial interface Serial interface Data line for accessory bus Use as RTS in data operation Clock line for accessory bus Use as DTC In data operation External loudspeaker
AUDIO_N GND_MIC EPP1
OI I O
External loudspeaker External microphone External microphone
V 1.0 S55/S56/S57
Page 7 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
3 Battery Connector
3.1 Affected Units
3.1.1 Type: 3.1.2 Affected IMEIs / Date Codes: 3.1.3 Affected SW Versions:
S55/S56/S57 All / All All
3.2 Fault Description
3.2.1 Fault Symptoms for customers:
Mobile does not switch on. Error message "WRONG BATTERY" on display.
3.2.2 Fault Symptoms on GSM Tester:
This fault cannot be detected with a GSM-Tester.
3.3 Priority:
Mandatory Repair Optional Not Yet Defined
V 1.0 S55/S56/S57
Page 8 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
3.4 Repair Documentation:
3.4.1 Description of procedure:
3.4.1.1 Diagnosis:
Visually check the status of the Battery connector. Watch for oxidation and dry solder joints.
3.4.1.2 Repair by component change:
Use hot air blower remove defective Battery connector. Avoid excessive heat! Watch surrounding components! Resolder new Battery connector afterwards.
3.4.1.3 Repair by Software booting:
Not possible!
3.4.1.4 Test:
Retest handset after repair.
3.4.2 List of needed material:
3.4.2.1 Components:
Battery Connector S55/S56/S57 Part-Number: L36334-Z97-C160
3.4.2.2 Jigs and Tools:
Hot Air Blower Soldering Iron
V 1.0 S55/S56/S57
Page 9 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones 3.4.2.3 Special tools:
None
3.4.2.4 Working materials
Desolder Wick / Braid Soldering Iron
3.4.3 Drawings
Figure 1: S55/S56/S57 board Battery connector
Figure 2: S55/S56/S57 Battery connector placement (top view)
V 1.0 S55/S56/S57
Page 10 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
4 Display Connector
4.1 Affected Units
4.1.1 Type: 4.1.2 Affected IMEIs / Date Codes: 4.1.3 Affected SW Versions:
S55/S56/S57 All / All All
4.2 Fault Description
4.2.1 Fault Symptoms for customers:
Display problems, like missing lines or columns on the LCD or display contrast problems.
4.2.2 Fault Symptoms on GSM Tester:
Display tests failed.
4.3 Priority:
Mandatory Repair Optional Not Yet Defined
V 1.0 S55/S56/S57
Page 11 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
4.4 Repair Documentation:
4.4.1 Description of procedure:
4.4.1.1 Diagnosis:
Visually check the status of the Display connector. Watch for oxidation
4.4.1.2 Repair by component change:
Use hot air blower remove defective Display connector. Avoid excessive heat! Watch surrounding components! Resolder new Display connector afterwards.
4.4.1.3 Repair by Software booting:
Not possible!
4.4.1.4 Test:
Retest handset after repair.
4.4.2 List of needed material:
4.4.2.1 Components:
Display Connector S55/S56/S57 Part-Number: L36334-Z97-C205
4.4.2.2 Jigs and Tools:
Hot Air Blower Soldering Iron
V 1.0 S55/S56/S57
Page 12 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
4.4.2.3 Special tools:
None
4.4.2.4 Working materials
Desolder Wick / Braid Soldering Iron
4.4.3 Drawings
Figure 1: S55/S56/S57 board Display connector
Figure 2: S55/S56/S57 Display connector placement (top view)
V 1.0 S55/S56/S57
Page 13 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
5 Antenna Connector
5.1 Affected Units
5.1.1 Type: 5.1.2 Affected IMEIs / Date Codes: 5.1.3 Affected SW Versions:
S55/S56/S57 All / All All
5.2 Fault Description
5.2.1 Fault Symptoms for customers:
Network Search No location update possible
5.2.2 Fault Symptoms on GSM Tester:
Output power problems on the external and internal antenna No location update possible
5.2.3 Component Information:
The Antenna Connector is a mechanical switch operated by the RF plug of a car kit. Normally the RF signal goes to and comes from the internal antenna. Whenever an RF plug is plugged into the antenna connector the connection to the internal antenna is opened and the connection to the external antenna socket is made. When the antenna connector is blocked without RF plug the connection to the internal antenna is also opened. See drawing below.
From Power Amplifier/ To Receiver
To/From Internal Antenna
V 1.0 S55/S56/S57
Page 14 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
5.3 Priority:
Mandatory Repair Optional Not Yet Defined
5.4 Repair Documentation:
5.4.1 Description of procedure:
5.4.1.1 Diagnosis:
Check the output power of the handset with the LSO test program. Especially watch the external antenna power!
5.4.1.2 Repair by component change:
Use hot air to remove defective antenna connector. Avoid excessive heat! Watch surrounding components!! Resolder new module afterwards
5.4.1.3 Repair by Software booting:
Not possible!
5.4.1.4 Test:
Retest handset after repair.
V 1.0 S55/S56/S57
Page 15 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
5.4.2 List of needed material:
5.4.2.1 Components:
Antenna Connector S55/S56/S57 Part-Number: L36334-Z93-C272
5.4.2.2 Jigs and Tools:
Hot Air Blower Soldering Iron
5.4.2.3 Special tools:
None
5.4.2.4 Working materials
Desolder Wick / Braid Soldering Iron
V 1.0 S55/S56/S57
Page 16 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
5.4.3 Drawings
Figure 1: S55/S56/S57 board Antenna connector
Figure 2: S55/S56/S57 Antenna connector placement (top view)
V 1.0 S55/S56/S57
Page 17 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
6 Card Reader
6.1 Affected Units
6.1.1 Type: 6.1.2 Affected IMEIs / Date Codes: 6.1.3 Affected SW Versions:
S55/S56/S57 All / All All
6.2 Fault Description
6.2.1 Fault Symptoms for customers:
Handset does not accept SIM.
6.2.2 Fault Symptoms on GSM Tester:
This fault cannot be detected with a GSM-Tester
6.3 Priority:
Mandatory Repair Optional Not Yet Defined
V 1.0 S55/S56/S57
Page 18 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
6.4 Repair Documentation:
6.4.1 Description of procedure:
6.4.1.1 Diagnosis:
Visually check the Card Reader. Watch for dry joints:
6.4.1.2 Repair by component change:
Use soldering iron to remove defective component. Avoid excessive heat! Watch surrounding components! Resolder new Card Reader afterwards.
6.4.1.3 Repair by Software booting:
Not possible!
6.4.1.4 Test:
Retest handset after repair.
6.4.2 List of needed material:
6.4.2.1 Components:
Card Reader S55/S56/S57 Part-Number: L36334-Z93-C204
6.4.2.2 Jigs and Tools:
Hot Air Blower Soldering Iron
V 1.0 S55/S56/S57
Page 19 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones 6.4.2.3 Special tools:
None
6.4.2.4 Working materials
Desolder Wick / Braid Soldering Iron
6.4.3 Drawings
Figure 1: S55/S56/S57 board Card Reader site
Figure 2: S55/S56/S57 Card Reader placement (top view)
V 1.0 S55/S56/S57
Page 20 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
7 Board Connector
7.1 Affected Units
7.1.1 Type: 7.1.2 Affected IMEIs / Date Codes: 7.1.3 Affected SW Versions:
S55/S56/S57 All / All All
7.2 Fault Description
7.2.1 Fault Symptoms for customers:
Problems with MMI function like: Keyboard malfunction Illumination problems
7.2.2 Fault Symptoms on GSM Tester:
This fault cannot be detected with a GSM Tester
7.3 Priority:
Mandatory Repair Optional Not Yet Defined
V 1.0 S55/S56/S57
Page 21 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
7.4 Repair Documentation:
7.4.1 Description of procedure:
7.4.1.1 Diagnosis:
Visually check the status of the board connector. Watch for oxidation and dry solder joints.
7.4.1.2 Repair by component change:
Use soldering iron to remove defective diode. Avoid excessive heat! Watch surrounding components!! Resolder new connector afterwards.
7.4.1.3 Repair by Software booting:
Not possible!
7.4.1.4 Test:
Retest handset after repair.
7.4.2 List of needed material:
7.4.2.1 Components:
Board connector S55/S56/S57 Part-Number: L36334-Z97-C162
V 1.0 S55/S56/S57
Page 22 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
7.4.2.2 Jigs and Tools:
Hot Air Blower Soldering Iron
7.4.2.3 Special tools:
None
7.4.2.4 Working materials
Desolder Wick / Braid Soldering Iron
V 1.0 S55/S56/S57
Page 23 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
7.4.3 Drawings
Figure 1: S55/S56/S57 board connector side
Figure 2: S55/S56/S57 board connector placement (top view)
12
7
1
6
V 1.0 S55/S56/S57
Page 24 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
8 IRDA
8.1 Affected Units
8.1.1 Type: 8.1.2 Affected IMEIs / Date Codes: 8.1.3 Affected SW Versions:
S55/S56/S57 All / All All
8.2 Fault Description
8.2.1 Fault Symptoms for customers:
No infrared connection possible
8.2.2 Fault Symptoms on GSM Tester:
This fault cannot be detected with a GSM Tester
8.3 Priority:
Mandatory Repair Optional Not Yet Defined
V 1.0 S55/S56/S57
Page 25 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
8.4 Repair Documentation:
8.4.1 Description of procedure:
8.4.1.1 Diagnosis: 8.4.1.2 Repair by component change:
Use soldering iron to remove defective diode. Avoid excessive heat! Watch surrounding components!! Resolder new connector afterwards.
8.4.1.3 Repair by Software booting:
Not possible!
8.4.1.4 Test:
Retest handset after repair.
8.4.2 List of needed material:
8.4.2.1 Components:
IRDA S55/S56/S57 Part-Number: L36810-U6030-D670
V 1.0 S55/S56/S57
Page 26 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
8.4.2.2 Jigs and Tools:
Hot Air Blower Soldering Iron
8.4.2.3 Special tools:
None
8.4.2.4 Working materials
Desolder Wick / Braid Soldering Iron
8.4.3 Drawings
Figure 1: S55/S56/S57 IRDA side
Figure 2: S55/S56/S57 IRDA placement (top view)
V 1.0 S55/S56/S57
Page 27 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
9 Bluetooth antenna
9.1 Affected Units
9.1.1 Type: 9.1.2 Affected IMEIs / Date Codes: 9.1.3 Affected SW Versions:
S55/S56 All / All All
9.2 Fault Description
9.2.1 Fault Symptoms for customers:
No Bluetooth connection possible
9.2.2 Fault Symptoms on GSM Tester:
This fault cannot be detected with a GSM Tester
9.3 Priority:
Mandatory Repair Optional Not Yet Defined
V 1.0 S55/S56/S57
Page 28 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
9.4 Repair Documentation:
9.4.1 Description of procedure:
9.4.1.1 Diagnosis:
Check the output power of the handset with the Bluetooth tester. Watch the antenna power!
9.4.1.2 Repair by component change:
Use soldering iron to remove defective antenna. Avoid excessive heat! Watch surrounding components!! Resolder new antenna afterwards.
9.4.1.3 Repair by Software booting:
Not possible!
9.4.1.4 Test:
Retest handset after repair.
9.4.2 List of needed material:
9.4.2.1 Components:
Bluetooth antenna S55 BLUETOOTH Part-Number: L36851-Z1901-A49
V 1.0 S55/S56/S57
Page 29 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02
Information and Communication Mobile Mobile Phones
9.4.2.2 Jigs and Tools:
Hot Air Blower Soldering Iron
9.4.2.3 Special tools:
None
9.4.2.4 Working materials
Desolder Wick / Braid Soldering Iron
9.4.3 Drawings
Figure 1: S55 BLUETOOTH Bluetooth antenna side
Figure 2: S55/S56/S57 Bluetooth antenna placement (top view)
V 1.0 S55/S56/S57
Page 30 of 30 Company Confidential Copyright 2002© Siemens AG
ICM MP CCQ GRM 12/02