Text preview for : RN15PS.pdf part of Samsung SyncMaster 570PTFT COLOR MONITOR SyncMaster 570PTFT SyncMaster 570P PLUS TFT (RN15P**) Service Manual



Back to : RN15PS.rar | Home

COLOR MONITOR
SyncMaster 570PTFT SyncMaster 570P TFT (RN15P**)

SERVICE
COLOR MONITOR

Manual
CONTENTS
1. Precautions 2. Product Specifications 3. Disassembly & Reassembly 4. Troubleshooting 5. Exploded View & Parts List 6. Electrical Parts List 7. Block Diagram

AUTO

EXIT

MENU

8. Wiring Diagram 9. Schematic Diagrams

1 Precautions
Follow these safety, servicing and ESD precautions to prevent damage and to protect against potential hazards such as electrical shock.

1-1 Safety Precautions
1-1-1 Warnings
1. 2. 3. For continued safety, do not attempt to modify the circuit board. Disconnect the AC power and DC Power Jack before servicing. When the chassis is operating, semiconductor heatsinks are potential shock hazards.
DEVICE UNDER TEST TEST ALL EXPOSED METAL SURFACES (READING SHOULD NOT BE ABOVE 0.5mA)

LEAKAGE CURRENT TESTER

1-1-2 Servicing the LCD Monitor
1. When servicing the LCD Monitor, remove the static charge by connecting a 10k ohm resistor in series with an insulated wire (such as a test probe) between the chassis and the anode lead. (Disconnect the AC line cord from the AC outlet.) It is essential that service technicians have an accurate voltage meter available at all times. Check the calibration of this meter periodically.

2-WIRE CORD

ALSO TEST WITH PLUG REVERSED (USING AC ADAPTER PLUG AS REQUIRED)

EARTH GROUND

2.

Figure 1-1. Leakage Current Test Circuit
4. With the unit completely reassembled, plug the AC line cord directly into a 120V AC outlet. With the unit's AC switch first in the ON position and then OFF, measure the current between a known earth ground (metal water pipe, conduit, etc.) and all exposed metal parts, including: metal cabinets, screwheads and control shafts. The current measured should not exceed 0.5 milliamp. Reverse the power-plug prongs in the AC outlet and repeat the test.

1-1-3 Fire and Shock Hazard
Before returning the monitor to the user, perform the following safety checks: 1. Inspect each lead dress to make certain that the leads are not pinched or that hardware is not lodged between the chassis and other metal parts in the monitor. Inspect all protective devices such as nonmetallic control knobs, insulating materials, cabinet backs, adjustment and compartment covers or shields, isolation resistor-capacitor networks, mechanical insulators, etc. Leakage Current Hot Check (Figure 1-1): WARNING: Do not use an isolation transformer during this test. Use a leakage current tester or a metering system that complies with American National Standards Institute (ANSI C101.1, Leakage Current for Appliances), and Underwriters Laboratories (UL Publication UL1410, 59.7).

2.

1-1-4 Product Safety Notices
Some electrical and mechanical parts have special safety-related characteristics which are often not evident from visual inspection. The protection they give may not be obtained by replacing them with components rated for higher voltage, wattage, etc. Parts that have special safety characteristics are identified by ! on schematics and parts lists. A substitute replacement that does not have the same safety characteristics as the recommended replacement part might create shock, fire and / or other hazards. Product safety is under review continuously and new instructions are issued whenever appropriate.

3.

SyncMaster 570PTFT / 570P Plus TFT

1-1

1 Precautions

1-2 Servicing Precautions
WARNING: Caution: Note: An electrolytic capacitor installed with the wrong polarity might explode. Before servicing units covered by this service manual, read and follow the Safety Precautions section of this manual. If unforeseen circumstances create conflict between the following servicing precautions and any of the safety precautions, always follow the safety precautions.

1-2-1 General Servicing Precautions
1. Always unplug the unit's AC power cord from the AC power source and disconnect the DC Power Jack before attempting to: (a) remove or reinstall any component or assembly, (b) disconnect PCB plugs or connectors, (c) connect a test component in parallel with an electrolytic capacitor. Some components are raised above the printed circuit board for safety. An insulation tube or tape is sometimes used. The internal wiring is sometimes clamped to prevent contact with thermally hot components. Reinstall all such elements to their original position. After servicing, always check that the screws, components and wiring have been correctly reinstalled. Make sure that the area around the serviced part has not been damaged. 4. Check the insulation between the blades of the AC plug and accessible conductive parts (examples: metal panels, input terminals and earphone jacks). Insulation Checking Procedure: Disconnect the power cord from the AC source and turn the power switch ON. Connect an insulation resistance meter (500 V) to the blades of the AC plug. The insulation resistance between each blade of the AC plug and accessible conductive parts (see above) should be greater than 1 megohm. 6. Always connect a test instrument's ground lead to the instrument chassis ground before connecting the positive lead; always remove the instrument's ground lead last.

5.

2.

3.

1-3 Electrostatically Sensitive Devices (ESD) Precautions
Some semiconductor (solid state) devices can be easily damaged by static electricity. Such components are commonly called Electrostatically Sensitive Devices (ESD). Examples of typical ESD devices are integrated circuits and some fieldeffect transistors. The following techniques will reduce the incidence of component damage caused by static electricity. 1. Immediately before handling any semiconductor components or assemblies, drain the electrostatic charge from your body by touching a known earth ground. Alternatively, wear a discharging wriststrap device. To avoid a shock hazard, be sure to remove the wrist strap before applying power to the monitor. After removing an ESD-equipped assembly, place it on a conductive surface such as aluminum foil to prevent accumulation of an electrostatic charge. Do not use freon-propelled chemicals. These can generate electrical charges sufficient to damage ESDs. Use only a grounded-tip soldering iron to solder or desolder ESDs. Use only an anti-static solder removal device. Some solder removal devices not classified as "anti-static" can generate electrical charges sufficient to damage ESDs. 8. 6. Do not remove a replacement ESD from its protective package until you are ready to install it. Most replacement ESDs are packaged with leads that are electrically shorted together by conductive foam, aluminum foil or other conductive materials. Immediately before removing the protective material from the leads of a replacement ESD, touch the protective material to the chassis or circuit assembly into which the device will be installed.

7.

2.

3.

Caution: Be sure no power is applied to the chassis or circuit and observe all other safety precautions.
Minimize body motions when handling unpackaged replacement ESDs. Motions such as brushing clothes together, or lifting your foot from a carpeted floor can generate enough static electricity to damage an ESD.

4. 5.

1-2

SyncMaster 570PTFT / 570P Plus TFT

2 Product Specifications
2-1 Specifications
Item LCD Panel Scanning Frequency Display Colors Maximum Resolution Input Video Signal Input Sync Signal Description TFT-LCD panel, RGB vertical stripe, normaly white, 15-Inch viewable, 0.297 (H) x 0.297 (V) pixel pitch Horizontal Vertical : : 30 kHz to 80 kHz (Automatic) 50 Hz to 85 Hz (Automatic) Except 1280 x 1024 @ 85Hz

16,772,216 colors Horizontal : 1024 Pixels Vertical : 768 Pixels Analog, 0.7 Vp-p ± 5% positive at 75 , internally terminated Type: Level: Seperate H/V sync, Composite H/V, Sync-on-Green, automatic synchronization without external switch of sync type TTL level

Maximum Pixel Clock rate Active Display Horizontal/Vertical

135 MHz 304.1 mm / 228.1 mm

AC power voltage & Frequency AC 90 to 264 Volts, 60/ 50 Hz ± 3 Hz Power Consumption Dimensions Unit (W x D x H) Carton (W x D x H) Weight (Net/Gross) Environmental Considerations 570PTFT : 25 W (normal) / 570P+TFT : 35 W (normal)

15.9 x 7.7 x 16.5 Inches (404 x 196 x 419 mm) 18.7 x 11.1 x 20.1 Inches (475 x 282 x 510 mm) 7.4 kg / 9.4 kg Operating Temperature : 50 °F to 104 °F (10 °C to 40 °C) Humidity : 10 % to 80 % Storage Temperature : -13 °F to 113 °F (-25 °C to 45 °C) Humidity : 5 % to 95 %

Audio Characteristics (optional)

· Audio Characteristics · Built-in Microphone: High-sensitivity condenser microphone (mono) · Audio input: Left/Right Stereo phone jack, 0.7 Vrms · Sound output: 16 W (left) + 16 W (right)/THD 1% at 16ohm · Frequency response: 80 Hz~20 kHz (at ­3dB) · Headphone: Max 50mW output (3.5-pi jack) · Speaker: Internal semi Dome (16ohm x 2)

· SyncMaster 570PTFT/570P Plus TFT complies with SWEDAC (MPR II) recommendations for reduced electromagnetic fields. · Designs and specifications are subject to change without prior notice.

SyncMaster 570PTFT / 570P Plus TFT

2-1

2 Product Specifications

2-2 Pin Assignments
Sync Type Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 Separate Red Green Blue GND GND (DDC Return) GND-R GND-G GND-B No Connection GND-Sync/Self Test GND DDC Data H-Sync V-Sync DDC Clock 15-Pin Signal Cable Connector Composite Red Green Blue GND GND (DDC Return) GND-R GND-G GND-B No Connection GND-Sync/Self Test GND DDC Data H/V-Sync Not Used DDC Clock Sync-on-green Red Green + H/V Sync Blue GND GND (DDC Return) GND-R GND-G GND-B Not Used GND-Sync/Self Test GND DDC Data Not Used Not Used DDC Clock

RCA Video Signal Cable Connector Pin No. 1 2 3 Composite GND CHK_Video Y/C Pin No. 1 2 3 4

S-Video Signal Cable Connector Separate GND GND Y C

2-2

SyncMaster 570PTFT / 570P Plus TFT

2 Product Specifications

2-3 Timing Chart
This section of the service manual describes the timing that the computer industry recognizes as standard for computer-generated video signals. Table 2-1. Timing Chart Mode
VGA1/ 70 Hz

IBM
VGA2/ 70 Hz VGA3/ 60 Hz

VESA
640/72 Hz 640/75 Hz 640/85 Hz 800/56 Hz 800/60 Hz 800/72 Hz 800/75 Hz 800/85 Hz 1024/60 Hz 640 x 480 640 x 480 640 x 480 800 x 600 800 x 600 800 x 600 800 x 600 800 x 600 1024 x 768

Timing fH (kHz) A µsec B µsec C µsec D µsec E µsec fV (Hz) O msec P msec Q msec R msec S msec Clock Frequency (MHz) Polarity H.Sync V.Sync Remark

640 x 350 720 x 400 640 x 480

31.469 31.778 3.813 1.589 26.058 0.318 70.086 14.268 0.064 1.716 11.504 0.985 25.175

31.469 31.469 31.777 31.778 3.813 1.589 3.813 1.589

37.861 26.413 1.270 3.810 20.825 0.508 72.809 13.735 0.079 0.528 13.100 0.026 31.500

37.500 26.667 2.032 3.810 20.317 0.508 75.000 13.333 0.080 0.427 12.800 0.027 31.500

43.269 35.156 23.111 28.444 1.556 2.222 2.000 3.556

37.879 26.400 3.200 2.200 20.000 1.000 60.317 16.579 0.106 0.607 15.840 0.026 40.000

48.077 20.800 2.400 1.280 16.000 1.120 72.188 13.853 0.125 0.478 12.480 0.770 50.000

46.875 53.674 21.333 18.631 1.616 3.232 1.138 2.702

48.363 20.677 2.092 2.462 15.754 0.369 60.004 16.666 0.124 0.600 15.880 0.062 65.000

26.058 26.058 0.318 0.318

17.778 22.222 1.556 0.667

16.162 14.222 0.323 0.569

70.087 59.940 14.268 16.683 0.064 0.858 0.064 0.794

85.008 56.250 11.764 17.778 0.671 0.578 0.057 0.626

75.000 85.061 13.333 11.756 0.064 0.448 0.056 0.503

13.155 15.761 0.191 0.064

11.093 17.067 0.023 0.028

12.800 11.179 0.021 0.019

28.322 25.175

49.500 36.000

49.500 56.250

Positive Negative

Negative Negative Negative Negative Negative

Positive

Positive Positive

Positive Positive

Positive Positive

Positive Negative Positive Negative

Positive Negative Negative Negative Negative Negative

Separate Separate Separate Separate Separate Separate Separate Separate Separate Separate Separate Separate Separate Sync H/V Composite Sync
A Q Vertical P
RR S S

Horizontal
Video Video
CC

VIDEO R

S

Vertical
Video Video DD E E
Q

Horizontal B

O

Q

Sync-on-Green
Sync Sync B B AA Sync Sync

Vertical
PP
O O

Green Horizontal P B Q O R S

A : Line time total C : Back porch E : Front porch

B : Horizontal sync width D : Active time

O : Frame time total Q : Back porch S : Front porch

P : Vertical sync width R : Active time

SyncMaster 570PTFT / 570P Plus TFT

2-3

2 Product Specifications

Table 2-1. Timing Chart Continued Mode 1024/70 Hz 1024 x 768 56.476 17.707 1.813 1.920 13.653 0.320 70.069 14.272 0.106 0.513 13.599 0.053 75.000 1024/75 Hz 1024 x 768 60.023 16.660 1.219 2.235 13.003 0.203 75.029 13.328 0.050 0.466 12.795 0.017 78.750 VESA 1024/85Hz 1024x768 68.677 14.561 1.016 2.201 10.836 0.508 84.997 11.765 0.044 0.524 11.183 0.015 94.500 1280/60Hz 1280x1024 63.981 15.630 1.037 2.296 11.853 0.444 60.020 16.661 0.047 0.594 16.004 0.016 108.000 1280/75Hz 1280x1024 79.976 12.504 1.067 1.837 9.481 0.119 75.025 13.329 0.038 0.475 12.804 0.013 135.000 MAC. 640/67 Hz 60 x 480 35.000 28.571 2.116 3.175 21.164 2.116 66.667 15.000 0.086 1.114 13.714 0.086 30.240 832/75 Hz 832 x 624 49.726 20.110 1.117 3.910 14.524 0.559 74.551 13.414 0.060 0.784 12.549 0.020 57.284

Timing fH (kHz) A µsec B µsec C µsec D µsec E µsec fV (Hz) O msec P msec Q msec R msec S msec Clock Frequency (MHz) Polarity H.Sync V.Sync Remark

Negative Negative Separate

Positive Positive Separate

Positive Positive Positive

Positive Positive Separate

Positive Positive Separate

Negative Negative Separate

Negative Negative Separate

Separate Sync
Horizontal
Video Video
CC

H/V Composite Sync
A Q Vertical P
RR S S

VIDEO R

S

Vertical
Video Video DD E E
Q

Horizontal B

O

Q

Sync-on-Green
Sync Sync B B AA Sync Sync

Vertical
PP
O O

Green Horizontal P B Q O R S

A : Line time total C : Back porch E : Front porch

B : Horizontal sync width D : Active time

O : Frame time total Q : Back porch S : Front porch

P : Vertical sync width R : Active time

2-4

SyncMaster 570PTFT / 570P Plus TFT

3 Disassembly and Reassembly
This section of the service manual describes the disassembly and reassembly procedures for the SyncMaster 570PTFT/570P Plus TFT monitors. WARNING: This monitor contains electrostatically sensitive devices. Use caution when handling these components.

3-1 Disassembly
Cautions:1. Disconnect the monitor from the power source before disassembly. 2. Follow these directions carefully; never use metal instruments to pry apart the cabinet.

3-1-1 Removing the Stand
1. Remove 4 screws in the hinge area. 2. Pry it off the back of the monitor. 3. Disconnect Power Cord and Signal Cable.

3. Remove Stand Front from the Stand assembly. 4. Remove 2 screws from the Stand assembly. 5. Remove the Stand Rear from the Stand assembly. 6. Remove 5 screws on the Vesa Brkt from the Stand assembly. 7. Remove cover hinge from the Stand assembly. 8. Remove Stand Base from the Stand assembly.

3-1-2 Main Body Disassembly
1. Remove the 4 screws on the four corner of the Rear Cover. 2. Remove Rear Cover from the Front Cover. 3. Remove 11 screws on the Shield and remove the shield. 4. Disconnect Inverter wire, Function PCB wire and Interface wire. Remove 4 screws on the Main PCB and remove 2 screws on the D sub shield. 5. Remove the Main PCB Assembly. 6. Remove 6 screws on the Inverter PCB Assembly and then remove it 7. Remove 6 screws on the Rear Panel Bracket. 8. Remove the Bracket Assembly from the Front Cover. 9. Remove 3 screws on the Function PCB from locking area of Function knob and remove Function PCB. 10. Remove 4 screws on the Shield of Panel. 11. Remove the Shield. 12. Remove Rear Bracket from Panel. 13. Remove 2 screws between Panel Rear and Inverter PCB. 14. Remove the Interface wire on the Rear Side of Panel.

3-1-4 Pivot Multi-media Stand Disassembly (option)
1. Stand the stand assembly with the base close to you. 2. Remove the 4 screws on the back cover of the stand and remove it. 3. Stand the stand assembly upside down. 4. Remove the 4 screws. 5. Disconnect CN805, CN806, CN807, CN808, CN809, CN812 and F1. 6. Remove the Back Cover of the Stand Front assembly. 7. Remove 4 screws on the external adaptor and remove the adaptor. 8. Remove 2 screws between hinge and Stand Body. 9. Remove the hinge 10. Remove 2 screws on Audio main PCB and remove it 11. Remove 2 screws on the Audio Function PCB and remove it.

3-1-5 Angle Pivot Stand Disassembly (option)
1. Remove the cap pivot from the stand assembly. 2. Remove the 4 screws on the hinge assembly. 3. Remove the 4 screws on the Stand Rear

3-1-3 Standard Stand Disassembly
1. Remove 5 screws from the Stand Rear 2. Remove 4 screws from the Stand Bottom.

SyncMaster 570PTFT / 570P Plus TFT

3-1

3 Disassembly and Reassembly 4. Remove the Stand Rear from the Stand assembly. 5. Remove the Stand Front from the Stand assembly. 6. Remove the Neck Rear from the Stand assembly. 7. Remove the 4 Rubbers on the four corner of the Stand Bottom and the 4 screws on the four corner of the Stand Bottom.

3-1-6 Wire frame stand Disassembly (option)
1. Carefully pull the cover hinge. 2. Remove the cover vesa from the Stand assembly. 3. Remove 4 screws on the assembly Bracket assembly.

8. Remove the 5 stopper hings from the Bracket Bottom. 9. Remove the Stand Base from the Stand Assembly.

3-2 Replacement Order of Lamp Assemblies
- RN15PSS (Samsung Panel)

3-2

SyncMaster 570PTFT / 570P Plus TFT

3 Disassembly and Reassembly

SyncMaster 570PTFT / 570P Plus TFT

3-3

3 Disassembly and Reassembly

3-4 Reassembly
Reassembly procedures are in the reverse order of Disassembly procedures.

3-4

SyncMaster 570PTFT / 570P Plus TFT

4 Troubleshooting
Notes: 1. Before troubleshooting, setup the PC's display as below. · Resolution: 1024 x 768 · H-frequency: 48 kHz · V-frequency: 60 Hz 2. If no picture appears, make sure the power cord is correctly connected. 3. Check the following circuits. · No raster appears: Audio PCB, SMPS PCB, Main PCB · 12V develop but no screen: Main PCB · 12V does not develop: Audio PCB, SMPS PCB 4. If you push and hold the "EXIT" button for more than 5 seconds, the monitor automatically turns back to the factory preset.

4-1 No Power
Does proper DC 12 V appear at DC jack connected to CN102? No Check DC Adaptor.

Yes

Does proper DC 5 V appear at Pin 4 of IC104?

No

Check FT101 and IC104.

Yes

Check IC101 and IC103.

SyncMaster 570PTFT / 570P Plus TFT

4-1

4 Troubleshooting

4-2 No Video
Power indicator is green

Does the clock pulse appear at output of CFT301?

No

1

Does the clock pulse appear at Pin 5 of IC146?

No

7

Does the pulse appear at Pin 4 of IC141? Yes

No

Yes Yes Replace IC301.

Replace IC146. Replace IC141 or X141. Yes
8 9

3

4

Does the sync pulses appear at Pins 27 and 28 of IC501?

No Is RGB port selected? No

Does the sync and clock pulse appear at Pins 115 and 117 of IC151? Yes Yes Replace IC301 or check its related circuit.

No

Check IC102 and IC541.

Yes

10

11

Does the sync and clock pulse appear at Pins 21 and 26 of IC211? No Check IC161 and IC541 or Replace IC211.

5

Do the sync pulses appear at FT509?

No

12

13

14

Do the sync pulses appear at Pins 30, 31 and 32 of IC501? Yes

No

Replace IC501 or check its related circuit.

Yes

Replace IC501 or check its related circuit.

Replace LCD Panel

4-2

SyncMaster 570PTFT / 570P Plus TFT

4 Troubleshooting

WAVEFORMS
1 IC146 #5 2 IC301 3 IC501 #27 4 IC501 #28

CH1 FREQ= 64.8 MHz

CH1 FREQ= 64.7 MHz

CH1 FREQ= 48.0 kHz

CH1 FREQ= 59.8 Hz

5 FT509

6 IC102

7 IC141 #4

8 IC151 #115

CH1 RMS = 500 mv

CH1 RMS = 2.0 V

CH1 FREQ= 19.5 MHz

CH1 FREQ= 32.4 MHz

9 IC151 #117

10 IC211 #21

11 IC211 #26

12 IC501 #30

CH1 FREQ= 48.0 kHz

CH1 FREQ= 13.4 MHz

CH1 FREQ= 15.6 kHz

CH1 RMS = 48.0 kHz

13 IC501 #31

14 IC501 #32

15 IC541 #5

16 IC161 #6

CH1 FREQ= 65.1 MHz

CH1 RMS = 2.0 V

CH1 RMS = 2.0 V

CH1 RMS = 2.0 V

SyncMaster 570PTFT / 570P Plus TFT

4-3

4 Troubleshooting

Memo

4-4

SyncMaster 570PTFT / 570P Plus TFT

5 Exploded View and Parts List
5-1 Multimedia Pivot-base RN15PSS (SAMSUNG PANEL)

SyncMaster 570PTFT / 570P Plus TFT

5-1

5 Exploded View & Parts List

5-2 Multimedia-base RN15PSS (SAMSUNG PANEL)

5-2

SyncMaster 570PTFT / 570P Plus TFT

5 Exploded View & Parts List

5-3 Pivot-base RN15PSS (SAMSUNG PANEL)

SyncMaster 570PTFT / 570P Plus TFT

5-3

5 Exploded View & Parts List

5-4 Simple-base RN15PSS (SAMSUNG PANEL)

5-4

SyncMaster 570PTFT / 570P Plus TFT

5 Exploded View & Parts List

5-5 Wire frame-base RN15PSS (SAMSUNG PANEL)

SyncMaster 570PTFT / 570P Plus TFT

5-5

5 Exploded View & Parts List

Memo

5-6

SyncMaster 570PTFT / 570P Plus TFT

6 Electrical Parts List
6-1 Main PCB Parts
Loc. No. BD495 BD496 BD497 BD498 BD499 C100 C101 C102 C103 C104 C106 C107 C108 C109 C110 C111 C112 C113 C114 C115 C116 C117 C118 C121 C122 C131 C132 C133 C134 C137 C138 C139 C141 C142 C143 C144 C145 C154 C155 C156 C161 C162 C169 C170 C171 Code No. 2703-001334 2703-001334 2703-001334 2703-001334 2703-001334 2409-001004 2203-000204 2402-000170 2203-000204 2402-000108 2203-000260 2203-000204 2402-000168 2409-001004 2409-001004 2203-000204 2203-000260 2203-000239 2203-000239 2203-000260 2203-000204 2402-000168 2409-001004 2203-000204 2203-000260 2203-000204 2203-000260 2402-000170 2203-000260 2203-002085 2203-002085 2203-002085 2203-000204 2203-000260 2203-000204 2203-000260 2402-000108 2203-000389 2203-000389 2203-000389 2402-000170 2402-000170 2203-000204 2203-000204 2203-000260 Description INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD C-ORGANIC C-CERAMIC,CHIP C-AL,SMD C-CERAMIC,CHIP C-AL,SMD C-CERAMIC,CHIP C-CERAMIC,CHIP C-AL,SMD C-ORGANIC C-ORGANIC C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-AL,SMD C-ORGANIC C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-AL,SMD C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-AL,SMD C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-AL,SMD C-AL,SMD C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP Specification 1.5uH,10%,2x1.25x0.85mm 1.5uH,10%,2x1.25x0.85mm 1.5uH,10%,2x1.25x0.85mm 1.5uH,10%,2x1.25x0.85mm 1.5uH,10%,2x1.25x0.85mm 100uF,20%,16V,LL,BK,8x10.5mm,3 100nF,10%,25V,X7R,TP,2012 1uF,20%,50V,GP,TP,4.3x4.3x5.4 100nF,10%,25V,X7R,TP,2012 10uF,20%,16V,WT,TP,4.3x4.3x5.4 10nF,10%,50V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100uF,20%,16V,GP,TP,8.3x8.3x6.3 100uF,20%,16V,LL,BK,8x10.5mm,3 100uF,20%,16V,LL,BK,8x10.5mm,3 100nF,10%,25V,X7R,TP,2012 10nF,10%,50V,X7R,TP,2012 0.1nF,5%,50V,NP0,TP,2012 0.1nF,5%,50V,NP0,TP,2012 10nF,10%,50V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100uF,20%,16V,GP,TP,8.3x8.3x6.3 100uF,20%,16V,LL,BK,8x10.5mm,3 100nF,10%,25V,X7R,TP,2012 10nF,10%,50V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 10nF,10%,50V,X7R,TP,2012 1uF,20%,50V,GP,TP,4.3x4.3x5.4, 10nF,10%,50V,X7R,TP,2012 56nF,10%,50V,X7R,TP,2012, 56nF,10%,50V,X7R,TP,2012, 56nF,10%,50V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 10nF,10%,50V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 10nF,10%,50V,X7R,TP,2012 10uF,20%,16V,WT,TP,4.3x4.3x5.4 0.015nF,5%,50V,NP0,TP,201 0.015nF,5%,50V,NP0,TP,201 0.015nF,5%,50V,NP0,TP,201 1uF,20%,50V,GP,TP,4.3x4.3x5.4 1uF,20%,50V,GP,TP,4.3x4.3x5.4 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 10nF,10%,50V,X7R,TP,2012 Remarks

SyncMaster 570PTFT / 570P Plus TFT

6-1

6 Electrical Parts List

Loc. No. C172 C173 C174 C175 C176 C177 C178 C179 C180 C181 C182 C183 C188 C189 C190 C191 C192 C193 C194 C195 C196 C197 C198 C199 C211 C212 C213 C280 C281 C282 C283 C284 C285 C286 C287 C288 C289 C290 C291 C292 C293 C294 C295 C296 C297 C298 C299

Code No. 2203-000204 2203-000204 2203-000204 2203-000204 2203-000260 2402-000108 2203-000204 2203-000260 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000555 2203-000555 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2402-000108 2203-000204 2203-000204 2203-000204 2402-000108 2203-000204 2203-000204 2203-000204 2203-000204

Description C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-AL,SMD C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-AL,SMD C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-AL,SMD C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP

Specification 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 10nF,10%,50V,X7R,TP,2012 10uF,20%,16V,WT,TP,4.3x4.3x5.4 100nF,10%,25V,X7R,TP,2012 10nF,10%,50V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 0.02nF,5%,50V,NP0,TP,2012 0.02nF,5%,50V,NP0,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 10uF,20%,16V,WT,TP,4.3x4.3x5.4 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 10uF,20%,16V,WT,TP,4.3x4.3x5.4 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012

Remarks

6-2

SyncMaster 570PTFT / 570P Plus TFT

6 Electrical Parts List

Loc. No. C370 C371 C372 C373 C374 C375 C376 C377 C378 C379 C380 C381 C382 C383 C384 C385 C386 C387 C388 C389 C390 C391 C392 C393 C394 C395 C396 C397 C398 C399 C401 C403 C404 C495 C496 C497 C498 C499 C501 C502 C509 C510 C511 C512 C541 C542 C546

Code No. 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2402-000108 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2203-000204 2402-000108 2203-000204 2203-000204 2203-000260 2203-000260 2203-000260 2203-000260 2203-000260 2203-000260 2402-000108 2203-000455 2402-000108 2203-000455 2402-000108 2203-000455 2402-000170 2402-000168 2402-000170

Description C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-AL,SMD C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-AL,SMD C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-AL,SMD C-CERAMIC,CHIP C-AL,SMD C-CERAMIC,CHIP C-AL,SMD C-CERAMIC,CHIP C-AL,SMD C-AL,SMD C-AL,SMD

Specification 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 10uF,20%,16V,WT,TP,4.3x4.3x5.4 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 10uF,20%,16V,WT,TP,4.3x4.3x5.4 100nF,10%,25V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 10nF,10%,50V,X7R,TP,2012 10nF,10%,50V,X7R,TP,2012 10nF,10%,50V,X7R,TP,2012 10nF,10%,50V,X7R,TP,2012 10nF,10%,50V,X7R,TP,2012 10nF,10%,50V,X7R,TP,2012 10uF,20%,16V,WT,TP,4.3x4.3x5.4 1nF,5%,50V,NP0,TP,2012 10uF,20%,16V,WT,TP,4.3x4.3x5.4 1nF,5%,50V,NP0,TP,2012 10uF,20%,16V,WT,TP,4.3x4.3x5.4 1nF,5%,50V,NP0,TP,2012 1uF,20%,50V,GP,TP,4.3x4.3x5.4, 100uF,20%,16V,GP,TP,8.3x8.3x6.3 1uF,20%,50V,GP,TP,4.3x4.3x5.4,

Remarks

SyncMaster 570PTFT / 570P Plus TFT

6-3

6 Electrical Parts List

Loc. No. C551 C552 C561 C562 C563 CFT301 CIS CIS CIS CL101 CL102 CN000 CN102 CN201 CN202 CN501 CN501+PAN CN503 CN503+INV CN505 CN802 D101 D102 D111 D112 D121 D122 D131 D132 D133 D161 D211 D212 D213 D221 D501 FT101 FT102 FT103 FT104 FT111 FT121 FT131 FT141 FT146 FT151 FT171

Code No. 2402-000108 2203-000260 2203-000260 2203-000204 2203-000260 2901-001112 BN70-00018B BN39-00030A BN70-00085A BN27-20001A BN27-20001C 3711-001465 3722-000117 3722-001178 3722-001100 3711-003161 BN39-00049A 3711-000556 BN39-00002A 3711-000056 3711-000556 0402-000553 0402-000553 0403-000277 0403-000277 0403-000277 0403-000277 0401-001056 0401-001056 0401-001056 0403-000277 0403-000277 0403-000277 0403-000277 0403-000277 0401-001056 3301-001145 3301-001145 3301-001145 3301-001145 2901-001114 2901-001114 2901-001114 2901-001114 2901-001114 2901-001114 2901-001114

Description C-AL,SMD C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP FILTER-EMISMD SHIELD-D/SUB CBF-SIGNAL SHIELD-PCB COIL-CHOKE COIL-SMD CONNECTOR-HEADER JACK-DCPOWER JACK-PIN JACK-DIN CONNECTOR-HEADER CBF-HARNESS CONNECTOR-HEADER CBF-HARNESS CONNECTOR-HEADER CONNECTOR-HEADER DIODE-RECTIFIER DIODE-RECTIFIER DIODE-ZENER DIODE-ZENER DIODE-ZENER DIODE-ZENER DIODE-SWITCHING DIODE-SWITCHING DIODE-SWITCHING DIODE-ZENER DIODE-ZENER DIODE-ZENER DIODE-ZENER DIODE-ZENER DIODE-SWITCHING CORE-FERRITEBEAD CORE-FERRITEBEAD CORE-FERRITEBEAD CORE-FERRITEBEAD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD

Specification 10uF,20%,16V,WT,TP,4.3x4.3x5.4 10nF,10%,50V,X7R,TP,2012 10nF,10%,50V,X7R,TP,2012 100nF,10%,25V,X7R,TP,2012 10nF,10%,50V,X7R,TP,2012 50VDC,1.0ADC,85pF+-20% RN15AS,SPTE,0.5 DETACHABLE,1830MM,15P/15P,2 RN15AS,SECC,0.8,HITACHIPANE 53.0UH,20%,DR10*5,TRAY 105UH,20%,SMD,TAPING NOWALL,3P,1R,2.54mm,STR 3P,3.5mm,AG,BLK,NO 1P,3.4mm,SN,YEL,#16-22 4P/2C,6mm,AG,BLK,NO BOX,20P,1R,1.25mm,ANGLE 20P/20P,100MM,BLU/WHT/GRY,UL BOX,12P,1R,1.25mm,SMD-A -,60,BLU/WHT,26 BOX,2P,1R,2.5mm,ANGLE,S BOX,12P,1R,1.25mm,SMD-A SS24,40V,2.0A,DO-214AA,T SS24,40V,2.0A,DO-214AA,T MMBZ5226B,3.3V,5%,225mW,SOT MMBZ5226B,3.3V,5%,225mW,SOT MMBZ5226B,3.3V,5%,225mW,SOT MMBZ5226B,3.3V,5%,225mW,SOT MMBD4148SE,75V,600mA,SOT MMBD4148SE,75V,600mA,SOT MMBD4148SE,75V,600mA,SOT MMBZ5226B,3.3V,5%,225mW,SOT MMBZ5226B,3.3V,5%,225mW,SOT MMBZ5226B,3.3V,5%,225mW,SOT MMBZ5226B,3.3V,5%,225mW,SOT MMBZ5226B,3.3V,5%,225mW,SOT MMBD4148SE,75V,600mA,SOT AB,4.5x1.6x1.6mm AB,4.5x1.6x1.6mm AB,4.5x1.6x1.6mm AB,4.5x1.6x1.6mm 25VDC,2.0ADC,100nF,3.2x 25VDC,2.0ADC,100nF,3.2x 25VDC,2.0ADC,100nF,3.2x 25VDC,2.0ADC,100nF,3.2x 25VDC,2.0ADC,100nF,3.2x 25VDC,2.0ADC,100nF,3.2x 25VDC,2.0ADC,100nF,3.2x

Remarks

6-4

SyncMaster 570PTFT / 570P Plus TFT

6 Electrical Parts List

Loc. No. FT181 FT291 FT292 FT293 FT295 FT301 FT302 FT402 FT500 FT501 FT502 FT503 FT504 FT505 FT506 FT507 FT508 FT509 FT521 FT529 FT531 FT551 FT561 IC101 IC102 IC103 IC104 IC111 IC121 IC131 IC132 IC141 IC146 IC151 IC171 IC211 IC301 IC401 IC402 IC501 IC601 IC603 JP381 JP382 JP384 L199 L299

Code No. 2901-001114 2901-001114 2901-001114 2901-001114 2901-001114 2901-001114 2901-001114 2901-001114 2901-001113 2901-001113 2901-001113 2901-001113 2901-001113 2901-001113 2901-001113 2901-001113 2901-001113 2901-001113 2901-001114 2901-001114 2901-001114 2901-001114 2901-001114 1203-001465 1203-001293 1203-001447 1203-001448 0801-002267 1103-001164 0801-002394 1203-001109 1205-001713 1205-001713 1002-001179 1204-000292 1204-001417 1003-001242 1103-001023 1107-001177 1205-001740 1002-001177 1001-001109 2007-000029 2007-000029 2007-000029 2703-001070 2703-001070

Description FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD FILTER-EMISMD IC-POSI.ADJUSTREG. IC-POSI.FIXEDREG. IC-POSI.FIXEDREG. IC-POSI.FIXEDREG. IC-CMOSLOGIC IC-EEPROM IC-CMOSLOGIC IC-VOL.DETECTOR IC-MULTIPLIER IC-MULTIPLIER IC-A/DCONVERTER IC-VIDEOSYSTEM IC-VIDEODECODER IC-LCDCONTROLLER IC-EEPROM IC-FLASHMEMORY IC-TRANSMITTER IC-D/ACONVERTER IC-ANALOGSWITCH R-CHIP R-CHIP R-CHIP INDUCTOR-SMD INDUCTOR-SMD

Specification 25VDC,2.0ADC,100nF,3.2x 25VDC,2.0ADC,100nF,3.2x 25VDC,2.0ADC,100nF,3.2x 25VDC,2.0ADC,100nF,3.2x 25VDC,2.0ADC,100nF,3.2x 25VDC,2.0ADC,100nF,3.2x 25VDC,2.0ADC,100nF,3.2x 25VDC,2.0ADC,100nF,3.2x 25VDC,0.2A,35pF+-20%,2x 25VDC,0.2A,35pF+-20%,2x 25VDC,0.2A,35pF+-20%,2x 25VDC,0.2A,35pF+-20%,2x 25VDC,0.2A,35pF+-20%,2x 25VDC,0.2A,35pF+-20%,2x 25VDC,0.2A,35pF+-20%,2x 25VDC,0.2A,35pF+-20%,2x 25VDC,0.2A,35pF+-20%,2x 25VDC,0.2A,35pF+-20%,2x 25VDC,2.0ADC,100nF,3.2x 25VDC,2.0ADC,100nF,3.2x 25VDC,2.0ADC,100nF,3.2x 25VDC,2.0ADC,100nF,3.2x 25VDC,2.0ADC,100nF,3.2x 317,TO-263,3P,PLAST 033,T0-252,3P,6.5MIL 2596,TO-263,5P,PLAS 2596,TO-263,5P,PLAS 74LCX14,SOIC,14P,150MIL 24LC21A,128X8BIT,SOP,8P,150MIL 74LCX32,ORGATE,SOIC,14P,150 7045,SOT-89,3P,PLASTI ICS502M,SOIC,8P,150MIL,PLA ICS502M,SOIC,8P,150MIL,PLA AD9884,8BIT,QFP,128P,1 LM1881M,SOP,8P,150MIL,PLA KS0127B,PQFP,100P,PLAS PW264P,TBGA,352P,1378M 24C08,1028x8BIT,SOP,8P,150MIL 29W400,512KX8OR256KX16BIT DS90C385,TSSOP,56P,240MIL AD5301B,8BIT,SOT-23,6P,6 FST3125M,BUSSWITCH&CMOS, 0OHM,5%,1/10W,DA,TP,2012 0OHM,5%,1/10W,DA,TP,2012 0OHM,5%,1/10W,DA,TP,2012 100uH,10%,4.5x3.2x3.2mm 100uH,10%,4.5x3.2x3.2mm

Remarks

SyncMaster 570PTFT / 570P Plus TFT

6-5

6 Electrical Parts List

Loc. No. L301 L302 L303 L304 L305 L306 MP1.0 Q146 Q161 Q162 Q441 Q443 Q541 Q546 R000 R101 R102 R103 R104 R111 R112 R121 R122 R123 R124 R125 R126 R127 R131 R132 R133 R134 R135 R136 R137 R138 R139 R141 R146 R147 R150 R151 R152 R153 R154 R156 R158

Code No. 2011-000002 2011-000002 2011-000002 2011-000002 2011-000002 2011-000002 BN41-00021A 0501-002080 0501-002080 0501-002080 0501-002080 0501-002080 0501-002080 0501-002080 2007-000872 2007-000931 2007-000931 2007-000872 2007-000872 2007-000290 2007-000290 2007-000290 2007-000290 2007-000572 2007-000572 2007-000686 2007-000300 2007-000300 2007-000947 2007-000947 2007-000872 2007-000872 2007-000931 2007-000931 2007-000468 2007-000468 2007-000572 2007-000947 2007-000947 2007-000300 2007-000872 2007-001166 2007-001166 2007-001166 2007-000300 2007-000947 2007-000947

Description R-NETWORK R-NETWORK R-NETWORK R-NETWORK R-NETWORK R-NETWORK P.C.B-MAIN TR-SMALLSIGNAL TR-SMALLSIGNAL TR-SMALLSIGNAL TR-SMALLSIGNAL TR-SMALLSIGNAL TR-SMALLSIGNAL TR-SMALLSIGNAL R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP

Specification 22ohm,5%,63mW,L,CHIP,8P,TP 22ohm,5%,63mW,L,CHIP,8P,TP 22ohm,5%,63mW,L,CHIP,8P,TP 22ohm,5%,63mW,L,CHIP,8P,TP 22ohm,5%,63mW,L,CHIP,8P,TP 22ohm,5%,63mW,L,CHIP,8P,TP RN15PSH,6,1.6 2SC2412K,NPN,200mW,SOT-2 2SC2412K,NPN,200mW,SOT-2 2SC2412K,NPN,200mW,SOT-2 2SC2412K,NPN,200mW,SOT-2 2SC2412K,NPN,200mW,SOT-2 2SC2412K,NPN,200mW,SOT-2 2SC2412K,NPN,200mW,SOT-2 4.7KOHM,5%,1/10W,DA,TP,2012 470OHM,5%,1/10W,DA,TP,2012 470OHM,5%,1/10W,DA,TP,2012 4.7KOHM,5%,1/10W,DA,TP,2012 4.7KOHM,5%,1/10W,DA,TP,2012 100OHM,5%,1/10W,DA,TP,2012 100OHM,5%,1/10W,DA,TP,2012 100OHM,5%,1/10W,DA,TP,2012 100OHM,5%,1/10W,DA,TP,2012 220OHM,5%,1/10W,DA,TP,2012 220OHM,5%,1/10W,DA,TP,2012 3.3KOHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 47OHM,5%,1/10W,DA,TP,2012 47OHM,5%,1/10W,DA,TP,2012 4.7KOHM,5%,1/10W,DA,TP,2012 4.7KOHM,5%,1/10W,DA,TP,2012 470OHM,5%,1/10W,DA,TP,2012 470OHM,5%,1/10W,DA,TP,2012 1KOHM,5%,1/10W,DA,TP,2012 1KOHM,5%,1/10W,DA,TP,2012 220OHM,5%,1/10W,DA,TP,2012 47OHM,5%,1/10W,DA,TP,2012 47OHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 4.7KOHM,5%,1/10W,DA,TP,2012 75OHM,5%,1/10W,DA,TP,2012 75OHM,5%,1/10W,DA,TP,2012 75OHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 47OHM,5%,1/10W,DA,TP,2012 47OHM,5%,1/10W,DA,TP,2012

Remarks

6-6

SyncMaster 570PTFT / 570P Plus TFT

6 Electrical Parts List

Loc. No. R161 R171 R172 R173 R174 R175 R181 R182 R183 R184 R185 R187 R188 R189 R211 R212 R213 R214 R215 R216 R217 R218 R219 R221 R222 R223 R224 R269 R270 R284 R285 R286 R301 R302 R303 R304 R305 R306 R307 R308 R309 R310 R321 R322 R323 R324 R406

Code No. 2007-000468 2007-000023 2007-001113 2007-000931 2007-001198 2007-000241 2007-000282 2007-000282 2007-000300 2007-000282 2007-000300 2007-000290 2007-000290 2007-000290 2007-001166 2007-001166 2007-001166 2007-000931 2007-000572 2007-000931 2007-000931 2007-000931 2007-000300 2007-000468 2007-000290 2007-000290 2007-000290 2007-000300 2007-000300 2007-001166 2007-001166 2007-001166 2007-000300 2007-000300 2007-000300 2007-000468 2007-000468 2007-000947 2007-000947 2007-000947 2007-000468 2007-000468 2007-000300 2007-000300 2007-000300 2007-000300 2007-000686 R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP

Description

Specification 1KOHM,5%,1/10W,DA,TP,2012 120OHM,5%,1/10W,DA,TP,2012 680KOHM,5%,1/10W,DA,TP,2012 470OHM,5%,1/10W,DA,TP,2012 820OHM,1%,1/10W,DA,TP,2012 1.5KOHM,5%,1/10W,DA,TP,2012 100KOHM,5%,1/10W,DA,TP,2012 100KOHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 100KOHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 100OHM,5%,1/10W,DA,TP,2012 100OHM,5%,1/10W,DA,TP,2012 100OHM,5%,1/10W,DA,TP,2012 75OHM,5%,1/10W,DA,TP,2012 75OHM,5%,1/10W,DA,TP,2012 75OHM,5%,1/10W,DA,TP,2012 470OHM,5%,1/10W,DA,TP,2012 220OHM,5%,1/10W,DA,TP,2012 470OHM,5%,1/10W,DA,TP,2012 470OHM,5%,1/10W,DA,TP,2012 470OHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 1KOHM,5%,1/10W,DA,TP,2012 100OHM,5%,1/10W,DA,TP,2012 100OHM,5%,1/10W,DA,TP,2012 100OHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 75OHM,5%,1/10W,DA,TP,2012 75OHM,5%,1/10W,DA,TP,2012 75OHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 1KOHM,5%,1/10W,DA,TP,2012 1KOHM,5%,1/10W,DA,TP,2012 47OHM,5%,1/10W,DA,TP,2012 47OHM,5%,1/10W,DA,TP,2012 47OHM,5%,1/10W,DA,TP,2012 1KOHM,5%,1/10W,DA,TP,2012 1KOHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 3.3KOHM,5%,1/10W,DA,TP,2012

Remarks

SyncMaster 570PTFT / 570P Plus TFT

6-7

6 Electrical Parts List

Loc. No. R411 R412 R413 R414 R441 R442 R443 R444 R445 R446 R541 R543 R546 R548 R561 R562 R564 R568 R569 R570 R571 R572 RA211 RA212 RA213 RA214 RA215 RA216 RA301 RA302 RA303 RA304 RA305 RA306 X141 X401

Code No. 2007-000686 2007-000686 2007-000686 2007-000686 2007-000822 2007-000468 2007-000931 2007-000468 2007-000931 2007-000931 2007-000300 2007-000282 2007-000300 2007-000282 2007-000947 2007-000300 2007-000300 2007-000029 2007-000029 2007-000300 2007-000300 2007-000300 2011-000770 2011-000770 2011-000770 2011-000770 2011-000770 2011-000770 2011-000585 2011-000585 2011-000585 2011-000585 2011-000585 2011-000585 2801-003844 2801-003804

Description R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-NETWORK R-NETWORK R-NETWORK R-NETWORK R-NETWORK R-NETWORK R-NETWORK R-NETWORK R-NETWORK R-NETWORK R-NETWORK R-NETWORK CRYSTAL-SMD CRYSTAL-SMD

Specification 3.3KOHM,5%,1/10W,DA,TP,2012 3.3KOHM,5%,1/10W,DA,TP,2012 3.3KOHM,5%,1/10W,DA,TP,2012 3.3KOHM,5%,1/10W,DA,TP,2012 390OHM,5%,1/10W,DA,TP,2012 1KOHM,5%,1/10W,DA,TP,2012 470OHM,5%,1/10W,DA,TP,2012 1KOHM,5%,1/10W,DA,TP,2012 470OHM,5%,1/10W,DA,TP,2012 470OHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 100KOHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 100KOHM,5%,1/10W,DA,TP,2012 47OHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 0OHM,5%,1/10W,DA,TP,2012 0OHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 10KOHM,5%,1/10W,DA,TP,2012 470ohm,5%,63mW,L,CHIP,8P,TP 470ohm,5%,63mW,L,CHIP,8P,TP 470ohm,5%,63mW,L,CHIP,8P,TP 470ohm,5%,63mW,L,CHIP,8P,TP 470ohm,5%,63mW,L,CHIP,8P,TP 470ohm,5%,63mW,L,CHIP,8P,TP 47ohm,5%,63mW,L,CHIP,8P,TP 47ohm,5%,63mW,L,CHIP,8P,TP 47ohm,5%,63mW,L,CHIP,8P,TP 47ohm,5%,63mW,L,CHIP,8P,TP 47ohm,5%,63mW,L,CHIP,8P,TP 47ohm,5%,63mW,L,CHIP,8P,TP 19.5MHz,30ppm,28-AAN,20pF,50 24.576MHZ,30PPM,28-AAN,20PF

Remarks

Others
Loc. No. LCD P/CORD S/CABLE PROCESS-PBA UNIT B/D ASS'Y CODE Code No. BN07-00005A BH39-10307X BN39-00030A BN94-00014F BN98-00005G Description LCD-PANNEL CBF-POWER/CORD CBF-SIGNAL ASSY,PCB-ST ASSY,PCB/MAIN-ST Specification LTM150XS-L02,331.3*257.9*15.9,TN VERTICAL STRIPE,0.297*0.297 DET,H05VV-F,250V/6A,IVY,1830MM DETACHABLE,1830MM,15P/15P,2990,D-SUB-MALE RN15PS-XGA1/0000,EDC,EUROPE RN15PSS-XGA1/0000,EDC,EUROPE

6-8

SyncMaster 570PTFT / 570P Plus TFT

7 Block Diagram

SyncMaster 570PTFT / 570P Plus TFT

P C B

R G B R G B R G

AD9884

H PW264 R G B H V

V

L V D S

Y

C H V

KS0127

V I D E O

Y/C

Flash Memory

7-1

7 Block Diagrams

Memo

7-2

SyncMaster 570PTFT / 570P Plus TFT

8 Wiring Diagram

INVERTER CN503 1: GND 2: BL_CNT 3: GND 4: BL_ON 5: GND 6: GND 7: +5V 8: GND 9: GND 10: 12V 11: 12V 12: 12V CN501 1: 3.3V 3:TX0-- 5: GND 7: TX1+ 9: TX2-- 11: GND 12: TX3-- 13: TX3+ 14: GND 15: TXC-- 16: TXC+ 17: GND 18: GND 19: 3.3V 20: 3.3V 2: GND 4: TX0+ 6: TX1-- 8: GND 10: TX2+

CN802 1: 3.3V 2: PORTC (0) 3: PORTC (1) 4: PORTC (2) 5: PORTC (3) 6: PORTC (4) 7: PORTC (5) CN102 1 2 3 Function PCB 12V GND 12V CN101 8: N.C 9: N.C 10: RED 11: GREEN 12: GND

MAIN PCB

1: RED 2: GREEN 9: N.C 10: SELF-TEST 12: DDC_DATA 13: H_SYNC 15: DDC_CLK

3: BLUE 4 ~ 8: GND 11: GND 14: V_SYNC
8-1

SyncMaster 570PTFT/570P Plus TFT

9 Schematic Diagrams
9-1 ADC & PLL Part Schematic Diagram
+5V_IN IS ALWAYS ACTIVE
+12V_IN +5V_IN +12V +5V_A +5V_D +5V +12V_IN +5V_IN +12V_IN

+3.3V IS ALWAYS ACTIVE
+3.3V +5V +3.3V_A

+2.5V IS ALWAYS ACTIVE
+5V_IN +2.5V

6 16
+3.3V +3.3V +3.3V +3.3V_A +3.3V +3.3V_D +3.3V_B

+3.3V_B

+3.3V_P

+3.3V_P

GRE(7:0) GVS GHS

GRO(7:0)

CHK_DSUB SDA SCL +5V_IN GREF GBLKSPL GHSFOUT ADPDNn GBE(7:0) GGO(7:0) GGE(7:0)

GCOAST RESET

GBO(7:0)

+3.3V

+3.3V

8
GCLK GFBK +3.3V

WR0n WR1n NMI

9
GSOG +3.3V ADPDNn MCKEXT

+5V_IN +3.3V_D

7
DCKEXT

1
9-1 SyncMaster 570PTFT/580P Plus TFT

9 Schematic Diagrams
1 IC146 #5 6 IC102 7 IC141 #4

CH1 FREQ= 64.8 MHz

CH1 RMS = 2.0 V

CH1 FREQ= 19.5 MHz

8 IC151 #115

9 IC151 #117

16 IC161 #6

CH1 FREQ= 32.4 MHz

CH1 FREQ= 48.0 kHz

CH1 RMS = 2.0 V

SyncMaster 570PTFT/580P Plus TFT

9-2

9 Schematic Diagrams

9-2 VIDEO DECODER Part Schematic Diagram

+5V_A

+3.3V_D

+3.3V_D

CHK_VIDEO +3.3V_D

VPEN

SCL SDA

RESET_V

ADPDNn

10 11

VCLK VFIELD VVS VHS

VR(3:0)

VB(7:0)

VG(7:0)

9-3

VR(7:4)

SyncMaster 570PTFT/580P Plus TFT

9 Schematic Diagrams
10 IC211 #21 11 IC211 #26

CH1 FREQ= 13.4 MHz

CH1 FREQ= 15.6 kHz

SyncMaster 570PTFT/580P Plus TFT

9-4

9 Schematic Diagrams

9-3 PW264 Part Schematic Diagram
ADDRESS(19:1) DATA(15:0)

+3.3V

+3.3V

+3.3V

+3.3V

+3.3V

ROMWEn ROMOEn

IRRCVR0 IRRCVR1

MCKEXT DCKEXT

RESET

WR1n WR0n

RXD TXD

NMI

+3.3V +3.3V

GCLK GVS GHS GSOG GRE(7:0) PORTC(5:0)

GGE(7:0)

GBE(7:0)

RESETn MAINPWB LVDS_EN CHK_SVIDEO CHK_VIDEO CHK_DSUB LEDGRN LEDRED LCPWON AUXPWON VPPEN BOOTWE SCL SDA ADPDNn +3.3V

GRO(7:0)

GGO(7:0)

DVS DHS DENG DRE(7:0)

DCLK

GBO(7:0)

2

DGE(7:0)

GFBK GREF GBLKSPL GCOAST GHSFOUT VCLK VPEN VVS VHS VFIELD VR(7:0)

DBE(7:0)

VG(7:0)

VB(7:0)

+2.5V

+3.3V

9-5

SyncMaster 570PTFT/580P Plus TFT

9 Schematic Diagrams
2 IC301 (CFT301 #3)

CH1 FREQ= 64.7 MHz

SyncMaster 570PTFT/580P Plus TFT

9-6

9 Schematic Diagrams

9-4 LVDS Part Schematic Diagram

+3.3V

+3.3V

+3.3V_D

12

LCPWON

15 14

MAINPWB

13

3 5 4
+5V_IN

+5V_D

SCL SDA

RESET_V RESETn AUXPWON

9-7

SyncMaster 570PTFT/580P Plus TFT

9 Schematic Diagrams
3 IC501 #27 4 IC501 #28 5 FT509 12 IC501 #30

CH1 FREQ= 48.0 kHz

CH1 FREQ= 59.8 Hz

CH1 RMS = 500 mv

CH1 RMS = 48.0 kHz

13 IC501 #31

14 IC501 #32

15 IC541 #5

CH1 FREQ= 65.1 MHz

CH1 RMS = 2.0 V

CH1 RMS = 2.0 V

SyncMaster 570PTFT/580P Plus TFT

9-8

9 Schematic Diagrams

9-5 MEMORY Part Schematic Diagram

+5V_IN +3.3V +3.3V

ROMWEn

BOOTWE ROMWEn ROMOEn

+3.3V

ROMOEn

+5V_IN +5V_IN +3.3V

+3.3V

PORTC(5:0)

LEDRED

+3.3V

LEDGRN

SDA SCL

9-9

SyncMaster 570PTFT/580P Plus TFT

Samsung Electronics Co., Ltd. January 2000 Printed in Korea Code No.: BN68-00098A-01