Text preview for : KS-AX3300.pdf part of JVC KS-AX3300 Service manual for CAR POWER AMPLIFIER



Back to : KS-AX3300.rar | Home

SERVICE MANUAL
POWER AMPLIFIER
3 2005 MA171

KS-AX3300
Area suffix J ------------- Northern America E ------------- Southern Europe U -------------------- Other Areas

TABLE OF CONTENTS
1 2 3 4 5 PRECAUTION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . SPECIFIC SERVICE INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . DISASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . TROUBLESHOOTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3 1-4 1-5 1-6 1-7

COPYRIGHT © 2005 Victor Company of Japan, Limited

No.MA171 2005/3

SPECIFICATION
Power Output Signal-to-Noise Ratio Maximum Power Output Load Impedance Frequency Response Input Sensitivity/Impedance Distortion Power Requirement Grounding system Dimensions (W/H/D) Mass (approx.) 65 W RMS × 2 channels at 4 and [< or =] 1% THD + N 86 dBA (reference: 1 W into 4 ) 320 W 4 (2 to 8 allowance) 4 (4 to 8 allowance) (Bridge mode) 5 Hz to 50,000 Hz ( +0, -3 dB) 1 V/20 k (0.3 V to 6 V, variable) Less than 0.005% (at 1 kHz) DC 14.4 V (11 V to 16 V allowance) Negative ground 259 mm × 54 mm × 172 mm (10-1/4 in. × 2-3/16 in. × 6-13/16 in.) 1.6 kg (3.6 lbs.)

Design and specifi cations are subject to change without notice.

1-2 (No.MA171)

SECTION 1 PRECAUTION
1.1 Safety Precautions

!

Burrs formed during molding may be left over on some parts of the chassis. Therefore, pay attention to such burrs in the case of preforming repair of this system.

(No.MA171)1-3

SECTION 2 SPECIFIC SERVICE INSTRUCTIONS This service manual does not describe SPECIFIC SERVICE INSTRUCTIONS.

1-4 (No.MA171)

SECTION 3 DISASSEMBLY
3.1 Main board 3.1.1 Removing the main board (See Fig.1 ~ 4) (1) From the bottom of the amplifier, remove the five screws A attaching the cover. (2) From the main body of the amplifier, remove the nine screws B attaching the main board. (3) Remove the two screws C on top of the rear cover. (4) Remove the screw D and the two screws E on the front side of the rear cover.

A

A B B

Fig.1

B

Fig.2

C

Fig.3

E

D

Fig.4

(No.MA171)1-5

SECTION 4 ADJUSTMENT This service manual does not describe ADJUSTMENT.

1-6 (No.MA171)

SECTION 5 TROUBLESHOOTING This service manual does not describe TROUBLESHOOTING.

(No.MA171)1-7

Victor Company of Japan, Limited AV & MULTIMEDIA COMPANY CAR ELECTRONICS CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan

(No.MA171)

Printed in Japan VPT

KS-AX3500 KS-AX3300
LVT1329-001A [J/E/U]

POWER AMPLIFIER: INSTRUCTIONS AMPLIFICATEUR DE PUISSANCE: MANUEL D'INSTRUCTIONS
ENGLISH
POWER SUPPLY

1204MNMMDWASH EN, FR © 2004 Victor Company of Japan, Limited

KS-AX3500

KS-AX3300

Thank you for purchasing a JVC product. Please read all instructions carefully before operation, to ensure your complete understanding and to obtain the best possible performance from the unit.

For safety....
· Do not raise the volume level too much, as this will block outside sounds, making driving dangerous. · Stop the car before performing any complicated operations.

CAUTIONS AND NOTES
This unit is designed to operate on 12 V DC, NEGATIVE ground electrical systems. · This unit uses BTL (Balanced Trans-formerless) amplifier circuitry, i.e., floating ground system, so please comply with the following: Do not connect the "·" terminals of the speakers to each other. Do not connect the "·" terminals of the speakers to the metal body or chassis. · Cover the unused terminals with insulating tape to prevent them from short circuiting. · When an extension lead is used, it should be as thick and short as possible; connect it firmly with insulating tape. · Be sure to leave an appropriate space between the antenna (aerial) and the wires of this unit. · When replacing the fuse, only use a 25 A fuse for KS-AX3500 and 30 A fuse for KS-AX3300. · Do not let pebbles, sand or metallic objects get inside the unit. · To keep the heat dissipation mechanism running effectively, wipe the accumulated dust off periodically. · Listening to the tape, radio, CD or MD, etc. with the volume on loud for a long period of time will exhaust the battery, while the engine is turned off or while the engine is idling. DO NOT disassemble the units since there are no user serviceable parts inside. For Customer Use: Enter below the Model No. and Serial No. which are located on the top or bottom of the cabinet. Retain this information for future reference.

CAUTION To prevent short circuits while making connections, keep the battery's negative terminal disconnected. · When using a power cord, be sure to place the 30 A fuse near the battery as shown. · Connect the lead wire (purchased separately) through which power is supplied directly to the battery's "ª" terminal only after all the other connections have been made. The lead wire connected to the + B terminal of this unit should have a cross-section of more than 5 mm2. Be sure to use a ring terminal (optional) for secure connection. · If you have any questions regarding the thickness of the power cord, etc., consult your nearest "JVC IN-CAR ENTERTAINMENT" car audio dealer. When connecting a unit without a remote lead (.), connect to the accessory circuit of the car which is activated by the ignition switch. In this case, noise may occur when the car receiver is turned on or off. To avoid this noise, do not turn on or off the car receiver itself. You can turn on or off the car receiver along with the on/off operation of the ignition switch. If you use JVC car receiver with a remote lead (), connect to the REM terminal on this unit. If the POWER/PROTECTOR lamp lights in red, it indicates incorrect speaker wiring or connections. In normal status, the POWER/PROTECTOR lamp lights in green. Make sure to correct speaker wiring and other connections.

Model No. Serial No.

INSTALLATION
The following illustration shows a typical installation. However, you should make adjustments corresponding to your specific car. If you have any questions or require information regarding installation kits, consult your "JVC IN-CAR ENTERTAINMENT" car audio dealer or a company supplying kits.

CONTROLS
KS-AX3500 KS-AX3300

Å Mount on a firm surface, such as in the trunk room or under the front seat. · Since heat is generated in this unit, do not mount near inflammable objects. In addition, mount in an area that will not prevent the unit from dissipating heat. · Do not mount the unit in the places subject to heat such as near a radiator, in a glove compartment or in insulated areas such as under a car mat that will prevent the unit from dissipating heat. i When mounting this unit, be sure to use the screws provided. If any other screws are used, there is a risk of loosening the unit or damaging parts inside it.

Å Crossover filter switch OFF: Normally, set to this position. (Preset to this position at the factory.) ON: (For LPF switch) Set to this position when you want to turn on the LPF (Low-pass filter) switch. You can use the following terminals for a subwoofer system. KS-AX3500: REAR SPEAKER OUTPUT KS-AX3300: SPEAKER OUTPUT (For HPF switch--only for KS-AX3500) Set to this position when you want to turn on the HPF (High-pass filter) switch. The low frequency signals are not applied to the left/ right speaker when a subwoofer is connected. i Input LEVEL controller The input level can be adjusted with this control when this unit is connected to other source equipments. Turn it in the clockwise direction when the output level of the car audio seems low.

TERMINAL CONNECTIONS
When making the terminal connections... Properly fix the terminal with the screw provided by turning it in the direction as illustrated.

SPEAKER SYSTEMS
This amplifier provides two types of speaker connections: Normal mode and Bridge mode. You can choose either type of connections depending on the speakers configuration equipped on your car. Make sure to comply with the following notes: · Be sure not to connect the "·" terminals of the speakers to a common point. · If the ground wire is common to both left/right and front/rear speaker wirings, this unit cannot be used. Always use the independent lead wires for the speakers to be used. In this case, redo the wirings. · Use the speakers with an impedance of 2 to 8 (4 to 8 : when used in Bridge mode). · Use the speakers which have sufficient power to the unit.

Note
When you tighten the screw, make sure that the screw is securely fixed in place to prevent disconnection of the terminal. Avoid over-tightening as it may cause damage to the screw or its head slot.

1

SPEAKER CONNECTIONS
Connection varies depending on the number of the speakers used in your car. Select the appropiate connection referring to the diagrams below. Before connecting: Securely connect all the parts. If the connections are loose, due to contact resistance etc., heat will break out and may cause an accident. Secure and cover the cords with insulating tape and run them under the car mats.

· Depending on the manufacturer and model of the car, speaker wiring may have been finished when purchased. If the ground wire is common to both left and right speakers, this unit cannot be used. In this case, redo the speaker wiring. å When your receiver is equipped with Line Output, connect the Line Output (through the receiver) to the LOW INPUT jacks on this unit. When your receiver is NOT equipped with Line Output, connect the speaker connector (through the receiver) to the HIGH INPUT terminal on this unit.

KS-AX3500
4-speaker system

KS-AX3300
2-speaker system

Subwoofer system--BRIDGE MODE*2

2-speaker system plus subwoofer--BRIDGE MODE*2

L

R

L

R

L

R

L

R

1-speaker system--BRIDGE MODE*2

L

R

2-speaker system--BRIDGE MODE*2
R

L

*1 Not supplied for this unit.
TROUBLESHOOTING
For more details, consult your "JVC IN-CAR ENTERTAINMENT" car audio dealer. The POWER/PROTECTOR lamp does not light. · Confirm if the fuse is blown. · Confirm if the ground lead is connected securely to a metal part of the car. · Make sure that the equipment connected to this unit is turned on. · Use a relay if your system employs too many amplifiers. · Confirm the battery voltage (11 V to 16 V). The POWER/PROTECTOR lamp lights in red and/or the unit heats up abnormally. · Confirm if the impedance of the connected speaker is suitable. · Confirm if the speaker wirings are short-circuited. · Leave the unit turned off for a while as it cools down. No sound is heard. · Confirm if the POWER/PROTECTOR lamp lights in green (see "POWER SUPPLY" on page 1). · Is the remote turn-on line lead connected correctly? · Are RCA pin cords connected to the LOW INPUT jacks? · Is the speaker input connector from the receiver connected to the HIGH INPUT terminal? · Is this amplifier grounded? Alternator noise is heard. · Keep the power connecting leads away from the RCA pin cords. · Keep the RCA pin cords away from other electrical cables in the car. · Confirm if the ground lead is connected securely to a metal part of the car. · Confirm if the negative speaker leads are touching the car chassis. · Confirm if the noise originates in the receiver. · Replace the plugs or use plugs with load resistors. · Connect a bypass capacitor across the accessory switches (horn, fan, etc.). Noise when connected to AM (MW/LW) tuner. · Move the speaker and power leads away from the antenna (aerial) lead.

*2 BRIDGE MODE: Be sure to connect the line output
from the receiver to the left (L) jack on this unit.

SPECIFICATIONS
Power Output Signal-to-Noise Ratio KS-AX3500: 55 W RMS × 4 channels at 4 and 1% THD + N KS-AX3300: 65 W RMS × 2 channels at 4 and 1% THD + N 86 dBA (reference: 1 W into 4 )

Maximum Power Output Load Impedance Frequency Response Input Sensitivity/Impedance Distortion Power Requirement Grounding system Dimensions (W/H/D)

Mass (approx.) Supplied Accessories

KS-AX3500: 580 W KS-AX3300: 320 W 4 (2 to 8 allowance) 4 (4 to 8 allowance) (Bridge mode) 5 Hz to 50,000 Hz (+0, ­3 dB) 1 V/20 k (0.3 V to 6 V, variable) Less than 0.005% (at 1 kHz) DC 14.4 V (11 V to 16 V allowance) Negative ground KS-AX3500: 347 mm × 54 mm × 222 mm (13-11/16 in. × 2-3/16 in. × 8-3/4 in.) KS-AX3300: 259 mm × 54 mm × 172 mm (10-1/4 in. × 2-3/16 in. × 6-13/16 in.) KS-AX3500: 2.8 kg (6.2 lbs.) KS-AX3300: 1.6 kg (3.6 lbs.) Speaker input connector × 1 Mounting Screw ( 4.0 × 20 mm (13/16 in.)) × 4

Design and specifications are subject to change without notice.

2

SCHEMATIC DIAGRAMS
POWER AMPLIFIER

KS-AX3300
CD-ROM No.SML200503
Area suffix J ---------- Northern America E ---------- Southern Europe U ----------------- Other Areas

Contents
Block diagram Standard schematic diagram Printed circuit board 2-1 2-2 2-3

COPYRIGHT

2005 Victor Company of Japan, Limited.

No.MA171SCH 2005/3

Safety precaution
! Burrs formed during molding may be left over on some parts of the chassis. Therefore, pay attention to such burrs in the case of preforming repair of this system.

Block diagram

HIGH INPUT

CN901

L+,LR+,R-

SW301 LPF ON/OFF LEVEL

IC301

IC302

VR 301

IC303

CN904

SPEAKER OUTPUT

LOW INPUT

CN902

L+,LR+,R-

F901 30A BATT REMOTE GND

T901
LED901

CN903 IC901

2-1

Standard schematic diagram

2-2

Printed circuit board
Main board

2-3

Victor Company of Japan, Limited AV & MULTIMEDIA COMPANY CAR ELECTRONICS CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan

(No.MA171SCH)

Printed in Japan VPT

PARTS LIST
[ KS-AX3300 ]

* All printed circuit boards and its assemblies are not available as service parts.

Area suffix J ------------- Northern America E ------------- Southern Europe U -------------------- Other Areas

- Contents Exploded view of general assembly and parts list (Block No.M1) Electrical parts list (Block No.01) Packing materials and accessories parts list (Block No.M3)

3-2 3-4 3-8

MA171

3-1

Exploded view of general assembly and parts list
Block No. M 1 M M
7 7 11

4

7

7

7 7 7 7 9 8 2 7 7 9 7 8 2 7
Amp board

8 10 10 7 7 7

8 7

12
F901

9 2

8

6

3

8 7 10 10

1 5

3-2

General Assembly
Block No. [M][1][M][M]
Symbol No. 1 2 3 4 5 6 7 8 9 10 11 11 11 12 Part No. A4265359-001-0 A1265343-001-0 A3146065-001-0 A2146066-001-0 A3247033-001-A A3292008-004-2 A3293008-032-2 A2285199-003-0 A2285195-002-0 A3293008-002-7 A1236255-003-0 A1236255-001-0 A1236255-002-0 A151-5190-030 Part Name HEAT SINK HEAT SINK SUB FRONT CHASSIS BOTTOM COVER PLATE SCREW SCREW SCREW SCREW SCREW RATING LABEL RATING LABEL RATING LABEL FUSE Description Local

(x3)

2x8(x2) 3x8(x17) 3x8(x6) 3x8.5(x8) 3x8(x5) E J U 30A F901



3-3

Electrical parts list
AMP board
Block No. [0][1]
Symbol No. IC301 IC302 IC303 IC901 IC902 Q101 Q102 Q103 Q104 Q105 Q106 Q107 Q108 Q109 Q110 Q111 Q112 Q201 Q202 Q203 Q204 Q205 Q206 Q207 Q208 Q209 Q210 Q211 Q212 Q301 Q302 Q303 Q304 Q305 Q306 Q307 Q308 Q309 Q310 Q311 Q901 Q902 Q903 Part No. NJM4565M NJM4565M NJM4565M UPC494GS-E1-A PS2501-1 2SC3326 2SA1618 2SC4207 2SA988F 2SC1841F 2SD637 2SA1037AK 2SC2235 2SA965 2SC5100 2SA1908 DTC114EKA 2SC3326 2SA1618 2SC4207 2SA988F 2SC1841F 2SD637 2SA1037AK 2SC2235 2SA965 2SC5100 2SA1908 DTC114EKA DTA114EKA 2SC2412K 2SC1815 2SC1815 2SA1015 2SA1015 2SC2412K 2SC2412K 2SC1815 2SA1015 DTA114EKA DTC114EKA 2SB1132 2SC2412K Part Name IC IC IC IC IC TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR Description AC08-086-002 TE1 AC08-086-002 TE1 AC08-086-002 TE1 AC08-004-002 A149-5233-008 AC04-083-003 TE85R F AC04-178-003 TE85L F AC04-177-004 TE85R F AT04-095-005 AT04-094-005 A148-5484-002 AC04-051-005 T146 AT04-219-004 TPE6 F AT04-220-004 TPE6 F A148-5363-005 LF719 A148-5364-005 LF719 AC04-311-003 T146 AC04-083-003 TE85R F AC04-178-003 TE85L F AC04-177-004 TE85R F AT04-095-005 AT04-094-005 A148-5484-002 AC04-051-005 T146 AT04-219-004 TPE6 F AT04-220-004 TPE6 F A148-5363-005 LF719 A148-5364-005 LF719 AC04-311-003 T146 AC04-310-003 T146 AC04-050-005 T146 AT04-075-006 TPE2 F AT04-075-006 TPE2 F AT04-101-006 TPE2 F AT04-101-006 TPE2 F AC04-050-005 T146 AC04-050-005 T146 AT04-075-006 TPE2 F AT04-101-006 TPE2 F AC04-310-003 T146 AC04-311-003 T146 AC04-044-003 T100 AC04-050-005 T146 Local Q904 Q905 Q906 Q907 Q908 Q909 Q910 Q911 D101 D102 D201 D202 D301 D302 D303 D304 D305 D306 D307 D901 D902 D903 D904 C101 C102 C103 C104 C105 C106 C107 C108 C109 C110 C111 C112 C113 C114 C115 C116 C201 C202 C203 C204 C205 C206 C207 C208 C209 C210 C211 C212 C213 C214 C215 C216 C301 C302 DTC114EKA DTA144EKA DTC114EKA DTC114EKA 2SC3326 2SC3326 FKV550N FKV550N DAN202K DAN202K DAN202K DAN202K UDZS6.8B DAN202K FCH08A15 FRH08A15 UDZS13B UDZS15B DAN202K DAN202K DAN202K DAN202K UDZS16B AC03-430-101 AC03-430-101 AC03-430-470 AC03-430-101 AC03-430-101 AT03-B80-105 AC03-428-474 AC03-432-104 AT03-B77-107 AC03-430-101 AT03-B80-105 AC03-430-470 AC03-430-220 AC03-432-104 AC03-432-104 AC03-432-104 AC03-430-101 AC03-430-101 AC03-430-470 AC03-430-101 AC03-430-101 AT03-B80-105 AC03-428-474 AC03-432-104 AT03-B77-107 AC03-430-101 AT03-B80-105 AC03-430-470 AC03-430-220 AC03-432-104 AC03-432-104 AC03-432-104 AC03-433-224 AT03-B77-227 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR FET FET DIODE ARRAY DIODE ARRAY DIODE ARRAY DIODE ARRAY Z DIODE DIODE ARRAY DIODE ARRAY DIODE ARRAY Z DIODE Z DIODE DIODE ARRAY DIODE ARRAY DIODE ARRAY DIODE ARRAY Z DIODE C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR Symbol No. Part No. Part Name Description AC04-311-003 T146 AC04-310-005 T146 AC04-311-003 T146 AC04-311-003 T146 AC04-083-003 TE85R F AC04-083-003 TE85R F A148-5560-001 A148-5560-001 AC04-053-002 T146 AC04-053-002 T146 AC04-053-002 T146 AC04-053-002 T146 AC04-312-068 TE17 AC04-053-002 T146 A148-5550-002 A148-5551-002 AC04-312-130 TE17 AC04-312-150 TE17 AC04-053-002 T146 AC04-053-002 T146 AC04-053-002 T146 AC04-053-002 T146 AC04-312-160 TE17 100pF 50V 100pF 50V 47pF 50V 100pF 50V 100pF 50V 1uF 50V 0.47uF 10V 0.1uF 25V 100uF 16V 100pF 50V 1uF 50V 47pF 50V 22pF 50V 0.1uF 25V 0.1uF 25V 0.1uF 25V 100pF 50V 100pF 50V 47pF 50V 100pF 50V 100pF 50V 1uF 50V 0.47uF 10V 0.1uF 25V 100uF 16V 100pF 50V 1uF 50V 47pF 50V 22pF 50V 0.1uF 25V 0.1uF 25V 0.1uF 25V 0.22uF 16V 220uF 16V Local

3-4

Symbol No. C303 C304 C305 C306 C307 C308 C309 C310 C311 C312 C313 C314 C315 C316 C317 C318 C901 C902 C903 C904 C905 C906 C907 C908 C909 C910 C911 C914 C915 R101 R102 R103 R104 R105 R106 R107 R108 R109 R110 R111 R112 R113 R114 R115 R116 R117 R118 R119 R120 R121 R122 R123 R124 R125 R126 R127 R128 R129 R130 R131 R132 R133 R134 R135 R137 R138 R139 R201 R202 R203 R204 R205 R206 R207 R208 R209

Part No. AC03-432-104 AC03-432-104 AT03-B80-226 A116-6405-158 A116-6405-158 AC03-431-103 AC03-431-103 AC03-432-104 AC03-432-104 AT03-B77-107 AT03-B77-107 AC03-432-104 AC03-431-103 AC03-431-102 AT03-B75-477 AC03-431-103 AT03-B82-474 AC03-432-104 AC03-431-102 AC03-431-103 AT03-B77-107 AC03-432-104 AT03-B77-107 AC03-431-102 AC03-431-103 AC03-431-102 AC03-429-105 AC03-432-104 A116-6419-228 AC02-083-222 AC02-081-223 AC02-081-223 AC02-081-224 AC02-081-224 AC02-081-153 AC02-081-153 AC02-081-182 AC02-081-103 AC02-081-103 AC02-081-182 AC02-081-681 AC02-081-682 AC02-083-103 AC02-081-472 AC02-081-222 AC02-083-103 AC02-081-333 AC02-081-333 AC02-081-152 AC02-081-152 AC02-081-101 AC02-081-101 AC02-081-104 AC02-081-104 AC02-081-152 AC02-081-471 AC02-081-133 AC02-083-221 AC02-083-2R2 AC02-083-2R2 A142-5470-R10 AC02-081-103 AC02-083-2R2 AC02-081-473 AC02-081-152 AC02-081-152 AC02-081-472 AC02-083-222 AC02-081-223 AC02-081-223 AC02-081-224 AC02-081-224 AC02-081-153 AC02-081-153 AC02-081-182 AC02-081-103

Part Name C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR M CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR

Description 0.1uF 25V 0.1uF 25V 22uF 50V 1500uF 35V 1500uF 35V 0.01uF 50V 0.01uF 50V 0.1uF 25V 0.1uF 25V 100uF 16V 100uF 16V 0.1uF 25V 0.01uF 50V 1000pF 50V 470uF 6.3V 0.01uF 50V 0.47uF 50V 0.1uF 25V 1000pF 50V 0.01uF 50V 100uF 16V 0.1uF 25V 100uF 16V 1000pF 50V 0.01uF 50V 1000pF 50V 1uF 10V 0.1uF 25V 2200uF 16V 2.2K 1/4W 22K 1/10W 22K 1/10W 220K 1/10W 220K 1/10W 15K 1/10W 15K 1/10W 1.8K 1/10W 10K 1/10W 10K 1/10W 1.8K 1/10W 680 1/10W 6.8K 1/10W 10K 1/4W 4.7K 1/10W 2.2K 1/10W 10K 1/4W 33K 1/10W 33K 1/10W 1.5K 1/10W 1.5K 1/10W 100 1/10W 100 1/10W 100K 1/10W 100K 1/10W 1.5K 1/10W 470 1/10W 13K 1/10W 220 1/4W 2.2 1/4W 2.2 1/4W 0.1k+0.1kS/ L3.5 10K 1/10W 2.2 1/4W 47K 1/10W 1.5K 1/10W 1.5K 1/10W 4.7K 1/10W 2.2K 1/4W 22K 1/10W 22K 1/10W 220K 1/10W 220K 1/10W 15K 1/10W 15K 1/10W 1.8K 1/10W 10K 1/10W

Local

Symbol No. R210 R211 R212 R213 R214 R215 R216 R217 R218 R219 R220 R221 R222 R223 R224 R225 R226 R227 R228 R229 R230 R231 R232 R233 R234 R235 R237 R238 R239 R301 R302 R303 R304 R305 R306 R307 R308 R309 R313 R314 R315 R316 R317 R318 R319 R320 R901 R902 R903 R904 R905 R906 R907 R908 R909 R910 R911 R912 R913 R914 R915 R916 R917 R918 R919 R920 R921 R922 R923 R924 R925 R926 R927 R928 R931 R932 VR301

Part No. AC02-081-103 AC02-081-182 AC02-081-681 AC02-081-682 AC02-083-103 AC02-081-472 AC02-081-222 AC02-083-103 AC02-081-333 AC02-081-333 AC02-081-152 AC02-081-152 AC02-081-101 AC02-081-101 AC02-081-104 AC02-081-104 AC02-081-152 AC02-081-471 AC02-081-133 AC02-083-221 AC02-083-2R2 AC02-083-2R2 A142-5470-R10 AC02-081-103 AC02-083-2R2 AC02-081-473 AC02-081-152 AC02-081-152 AC02-081-472 AC02-083-102 AC02-083-222 AC02-081-475 AC02-081-104 AC02-081-823 AC02-083-103 AC02-083-332 AC02-083-332 AC02-081-475 AC02-081-100 AC02-081-100 AC02-081-100 AC02-081-100 AC02-083-222 AC02-081-102 AC02-081-100 AC02-081-100 AC02-083-103 AC02-081-103 AC02-081-103 AC02-081-102 AC02-081-271 AC02-083-222 AC02-081-472 AC02-081-223 AC02-081-681 AC02-081-102 AC02-081-102 AC02-081-104 AC02-081-183 AC02-081-682 AC02-081-472 AC02-081-472 AC02-081-221 AC02-081-471 AC02-083-471 AC02-083-471 AC02-081-102 AC02-081-102 AC02-081-102 AC02-081-102 AC02-083-220 AC02-083-220 AC02-081-2R2 AC02-081-2R2 AC02-081-473 AC02-083-222 A142-5461-001

Part Name C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR VOLUME

Description 10K 1/10W 1.8K 1/10W 680 1/10W 6.8K 1/10W 10K 1/4W 4.7K 1/10W 2.2K 1/10W 10K 1/4W 33K 1/10W 33K 1/10W 1.5K 1/10W 1.5K 1/10W 100 1/10W 100 1/10W 100K 1/10W 100K 1/10W 1.5K 1/10W 470 1/10W 13K 1/10W 220 1/4W 2.2 1/4W 2.2 1/4W 0.1k+0.1kS/ L3.5 10K 1/10W 2.2 1/4W 47K 1/10W 1.5K 1/10W 1.5K 1/10W 4.7K 1/10W 1K 1/4W 2.2K 1/4W 4.7M 1/10W 100K 1/10W 82K 1/10W 10K 1/4W 3.2K 1/4W 3.2K 1/4W 4.7M 1/10W 10 1/10W 10 1/10W 10 1/10W 10 1/10W 2.2K 1/4W 1K 1/10W 10 1/10W 10 1/10W 10K 1/4W 10K 1/10W 10K 1/10W 1K 1/10W 270 1/10W 2.2K 1/4W 4.7K 1/10W 22K 1/10W 680 1/10W 1K 1/10W 1K 1/10W 100K 1/10W 18K 1/10W 6.8K 1/10W 4.7K 1/10W 4.7K 1/10W 220 1/10W 470 1/10W 470 1/4W 470 1/4W 1K 1/10W 1K 1/10W 1K 1/10W 1K 1/10W 22 1/4W 22 1/4W 2.2 1/10W 2.2 1/10W 47K 1/10W 2.2K 1/4W 14T 5461 10K C X2

Local

3-5

Symbol No.

Part No.

Part Name

Description

Local

L301 L901 T901 CN901 CN902 CN903 CN904 JR1 JR2 JR3 LED901 SW301 TH901 TH902 TH903 XXXXX

A118-5259-002 A118-5423-001 A118-5414-003 A121-5461-004 A321-5529-001 A321-5531-001 A321-5532-001 AC01-015-000 AC01-015-000 AC01-015-000 L-489EGW A151-5181-001 AC04-219-223 AC04-219-224 AC04-219-225 AC06355-301-0

COIL COIL TRANS CONNECTOR PIN JACK TERMINAL TERMINAL C RESISTOR C RESISTOR C RESISTOR LED SWITCH THERMISTOR THERMISTOR THERMISTOR AMP PWB

BL01RN1A2A2B EI-28 DC/DC 6:13 CONN 5569-04A1 2P 3P 4P 0 0 0 A148-5559-001 SSAA22-4 NCP18XW223K03 RB NCP18XW223K03 RB NCP18XW223K03 RB

3-6



3-7

Packing materials and accessories parts list
Block No. M 3 M M No additional / supplemental order of WARRANTY CARDs are available.

A1 A2 A7 A8 A11 P3 KS-AX3300_J KS-AX3300_E

A1 A2 A3 A4 A9 A10 P3 KS-AX3300_U

A1 A5 A6

P3

P6

P2

P7

P6 P7

P4 A13 A12 P5

P1

3-8

Packing and Accessories
Block No. [M][3][M][M]
Symbol No. A A A A A A A A A A A A A P P P P P P P 1 2 3 4 5 6 7 8 9 10 11 12 13 1 2 3 4 5 6 7 Part No. A1935592-001-0 A1935592-002-0 A1935592-003-0 A1935592-004-0 A1935592-005-0 A1935592-006-0 --------------------------------------------A1935596-001-0 A1285217-001-0 A160-6911-001 A2506769-001-A A1506777-001-0 A1506778-001-0 A1505666-005-0 A1505666-001-0 A2506771-001-0 A2506771-002-0 Part Name INST BOOK INST BOOK INST BOOK INST BOOK INST BOOK INST BOOK WARRANTY CARD WARRANTY CARD WARRANTY CARD WARRANTY CARD LABEL REGIST CARD SCREW SP-IN CODE CARTON POLY BAG POLY BAG POLY BAG POLY BAG PACKING TRAY A PACKING TRAY B Description LVT1329-001A ENG FRE LVT1329-002A GER SPA LVT1329-003A ITA DUT LVT1329-004A SWE RUS LVT1329-005A CHI(TAIWAN) THA LVT1329-006A ARA PER BT-51080-4 BT-52006-2 BT-54023-1 BT-51034-2 (x4) 4P CN901 Local

E,J E E U U J J E E J

(x2) (x2)

3-9