Text preview for : CTX 321 Rev.pdf part of AIWA CT-X311 car audio (22 pag) mod. X321, X411, X421, X4210, X4250.
Back to : 321.part1.rar | Home
CT-X311 CT-X321 CT-X411 CT-X421 CT-X4210 CT-X4250
YZ(ST) YZ(ST) YU(ST) YU(ST) YL(ST) YL(ST)
SERVICE MANUAL
STEREO CAR CASSETTE RECEIVER BASIC TAPE MECHANISM : CDS-363AG1-A
S/M Code No. 09-012-354-5N1
DA TA
SPECIFICATIONS
RADIO SECTION (FM)
Frequency Range: 87.5 MHz108 MHz (100-kHz steps) [Except YZ] 87.5 MHz108 MHz (50-kHz steps) 12.7 dBf 17.2 dBf 80 dB 30 Hz-15,000 Hz 63 dB 35 dB at 1 kHz 70 dB 3 dB
TAPE SECTION
Tape Speed: S/N Ratio: Frequency Response: Stereo Separation: 4.8 cm/sec. (17/8 ips) 50 dB 40 Hz14,000 Hz 40 dB
AUDIO SECTION
Max. Power Output: 40 W x 4 channels
Usable Sensitivity: 50 dB Quieting Sensitivity: IF Rejection: Frequency Response: S/N Ratio: Stereo Separation: Alternate Channel Selectivity: Capture Ratio:
AUX IN input
Input sensitivity (load impedance) AUX IN: 300 mV (10 k)
GENERAL
14.4 V (11 to 16 V allowable), DC, negative ground Load Impedance: 4 Tone Control: Bass ± 10 dB at 100 Hz Treble ± 10 dB at 10 kHz Preamp Output Voltage (load impedance): 2.2 V (10 k) Installation size: 182(W) x 53(H) x 155(D) mm (71/4(W) x 21/8(H) x 61/8(D) inches) Power-Supply Voltage:
(AM(MW)) [YU,YL]
Frequency Range: 530 kHz1,710 kHz (10-kHz steps) 531 kHz1,602 kHz (9-kHz steps) 30 µV (30 dB)
Usable Sensitivity:
(MW) [YZ]
Frequency Range: 531 kHz1,602 kHz (9-kHz steps) 530 kHz1,710 kHz (10-kHz steps) 30 µV (30 dB)
Usable Sensitivity:
· Design and specifications are subject to change without notice.
(LW) [YZ]
Frequency Range: Usable Sensitivity: 144 kHz288 kHz (1-kHz/9-kHz steps) 30 µV (30 dB)
-2-
ACCESSORIES LIST
REF. NO 1 1 1 1 2 2 3 4 5 6 7 8 9 10 11 12 13 14 15 KANRI DESCRIPTION NO. 8B-KTG-904-010 IB,YL(3L) 4210,4250 8B-KTG-902-010 IB,YU(3L) 411 8B-KTG-901-010 IB,YU(3L) 421 8B-KTG-903-010 IB,YZ(9L) 321,311 8B-KT9-902-010 IB,INST,YU,YL (3L,P)-C 8B-KT9-904-010 8Z-KC1-235-010 8Z-KC1-231-110 8B-KTG-608-010 8Z-KC1-030-010 8Z-KC1-232-010 87-B10-216-010 87-B10-141-010 8Z-KC1-244-010 8Z-KC1-250-010 8Z-KTG-951-010 87-B10-143-010 87-B10-144-010 87-B10-145-010 IB,INST,YZ,YV (9L,R)-C HLDR,REAR MTG HLDR,HALF -C CONN ASSY,16P SSS CASE,DFP -C KEY,REMOVE -C U+2.6-4.0 ZINC BLK (BH M2.6) NUT,5 TYPE-2 S-SCREW,5*6 TH+ TAPPING ST S-SCREW,HEXAGON SPKR,16CM ASSY UT1+5-15 W/O SLOT W,5.2-10-0.5 W-SPR,5.3-8.5-1.5 PART NO.
TYPE A B C D E F
MODEL NAME CT-X421 CT-X411 CT-X311 CT-X321 CT-X4210 CT-X4250
SUFFIX YU YU YZ YZ YL YL
-3-
ELECTRICAL MAIN PARTS LIST - 1/2
REF. NO IC 8Z-KT1-622-010 8Z-KTG-622-010 87-A21-191-010 87-A21-441-010 87-A21-929-030 TRANSISTOR 87-A30-476-010 87-A30-468-040 87-A30-470-040 87-A30-471-040 8Z-KTH-626-080 87-A30-487-080 87-A30-473-080 87-A30-467-040 87-A30-469-040 87-A30-295-080 87-A30-016-010 DIODE 87-020-465-080 87-A40-798-010 87-001-783-080 87-017-932-080 87-A40-509-080 87-A40-504-040 87-A40-624-080 87-070-136-080 87-A40-817-040 MAIN C.B ANT101 C101 C102 C103 C104 C105 C106 C107 C108 C109 C110 C111 C112 C113 C114 C115 C116 C121 C121 C122 C122 C123 C124 C151 C152 C201 C202 C203 C204 C205 C206 C207 C208 C209 C210 87-A92-038-010 87-018-119-080 87-A11-145-080 87-A11-128-080 87-010-263-040 87-010-787-080 87-010-263-040 87-010-263-040 87-010-757-080 87-A11-145-080 87-010-759-080 87-012-286-080 87-012-286-080 87-010-759-080 87-010-787-080 87-012-286-080 87-010-495-040 87-010-785-080 87-010-787-080 87-010-785-080 87-010-787-080 87-016-526-080 87-016-526-080 87-012-286-080 87-012-180-080 87-012-274-080 87-012-274-080 87-010-378-040 87-010-378-040 87-010-263-040 87-010-263-040 87-010-787-080 87-010-787-080 87-010-494-040 87-010-494-040 ANT,MSP-403 CAP, CER 100P-50V CAP,TC U 0.01-50 Z F CAP,TC U 4700P-50 K B CAP,E 100-10 CAP, U 0.022-25 CAP,E 100-10 CAP,E 100-10 C.CAP,U 0.047-25F CAP,TC U 0.01-50 Z F C-CAP,U, 0.1-25F CAP, U 0.01-25 CAP, U 0.01-25 C-CAP,U, 0.1-25F CAP, U 0.022-25 CAP, U 0.01-25 CAP,E 2.2-50 GAS C-CAP,U0.015-25BK CAP, U 0.022-25 C-CAP,U0.015-25BK CAP, U 0.022-25 C-CAP,S 0.47-16 BK C-CAP,S 0.47-16 BK CAP, U 0.01-25 C-CAP,U 22P-50 CH CHIP CAP,U 1000P-50B CHIP CAP,U 1000P-50B CAP,E 10-16 CAP,E 10-16 CAP,E 100-10 CAP,E 100-10 CAP, U 0.022-25 CAP, U 0.022-25 CAP,E 1-50 GAS CAP,E 1-50 GAS DIODE,1SS133 (110MA) DIODE,1N5402 (3A/200V) DIODE,1N4002 ZENER,MTJ6.2B ZENER,MTZJ6.8C C-DIODE,KDS184 ZENER,MTZJ10A ZENER,MTZJ5.1B C-ZENER,STZ6.8N TR,KTA1046Y C-TR,KRC102S-RTK C-TR,KTC3875SY-RTK C-TR,KTA1504SY-RTK TR,KTC3203Y TR,KRC111M-AT TR,KRC102M-AT C-TR,KRA111S-RTK C-TR,KRC111S-RTK TR,KRA226M TR,KTD2058Y C415 C416 C417 C418 C419 C420 C423 C424 C426 C427 C428 C429 C430 C431 C432 C433 C501 C502 C503 C504 C505 C506 C507 C508 C509 C510 C511 C512 C513 C514 C601 C602 C603 C606 C607 C609 C610 C611 C701 C702 C703 C704 C705 C706 C801 C802 C803 C804 C805 C806 87-010-498-040 87-010-498-040 87-010-072-040 87-010-495-040 87-010-072-040 87-010-495-040 87-010-759-080 87-010-553-040 87-010-379-040 87-012-358-080 87-012-358-080 87-010-831-080 87-012-286-080 87-010-759-080 87-010-759-080 87-010-553-040 87-016-526-080 87-016-526-080 87-016-526-080 87-016-526-080 87-012-273-080 87-012-273-080 87-012-273-080 87-012-273-080 87-010-378-040 87-010-759-080 8A-KC7-623-000 87-012-274-080 87-010-494-040 87-010-378-040 87-016-526-080 87-012-180-080 87-012-182-080 87-010-787-080 87-A10-189-040 87-018-134-080 87-018-209-080 87-018-209-080 87-012-278-080 87-010-759-080 87-018-205-080 87-010-263-040 87-010-759-080 87-010-935-040 87-010-378-040 87-010-075-040 87-012-271-080 87-012-271-080 87-010-378-040 87-010-378-040 CAP,E CAP,E CAP,E CAP,E CAP,E 10-16 GAS 10-16 GAS 2.2-50 5L 2.2-50 GAS 2.2-50 5L C-IC,LC75374E IC,TA8259H IC,KIA6225S C-IC,TC9297FB C-IC,TC9323F-027 PART NO. KANRI NO. DESCRIPTION REF. NO C211 C212 C301 C302 C303 C304 C401 C402 C403 C404 C405 C406 C407 C408 C409 C410 C411 C412 C413 C414 KANRI DESCRIPTION NO. 87-010-263-040 CAP,E 100-10 87-010-380-040 CAP,E 47-16 SME 87-010-401-040 CAP,E 1-50 SME 87-010-401-040 CAP,E 1-50 SME 87-012-274-080 CHIP CAP,U 1000P-50B 87-012-274-080 87-010-494-040 87-010-494-040 87-010-805-080 87-010-805-080 87-012-280-080 87-012-280-080 87-010-787-080 87-010-787-080 87-010-498-040 87-010-498-040 87-A11-177-080 87-A11-177-080 87-A11-177-080 87-A11-177-080 CHIP CAP,U 1000P-50B CAP,E 1-50 GAS CAP,E 1-50 GAS CAP, S 1-16 CAP, S 1-16 CAP, U 3300P-50 CAP, U 3300P-50 CAP, U 0.022-25 CAP, U 0.022-25 CAP,E 10-16 GAS CAP,E 10-16 GAS C-CAP,S 0.15-16 C-CAP,S 0.15-16 C-CAP,S 0.15-16 C-CAP,S 0.15-16 K K K K B B B B PART NO.
CAP,E 2.2-50 GAS C-CAP,U, 0.1-25F CAP,E 47-16 GAS CAP,E 22-16 M SME C-CAP,S 0.47-10 F Z C-CAP,S 0.47-10 F Z C-CAP,U,0.1-16F CAP, U 0.01-25 C-CAP,U, 0.1-25F C-CAP,U, 0.1-25F CAP,E 47-16 GAS C-CAP,S 0.47-16 C-CAP,S 0.47-16 C-CAP,S 0.47-16 C-CAP,S 0.47-16 C-CAP,U 820P-50 C-CAP,U 820P-50 C-CAP,U 820P-50 C-CAP,U 820P-50 CAP,E 10-16 BK BK BK BK B B B B
C-CAP,U, 0.1-25F CAP,E 2200U-16 BT(125C) CHIP CAP,U 1000P-50B CAP,E 1-50 GAS CAP,E 10-16 C-CAP,S 0.47-16 BK C-CAP,U 22P-50 CH C-CAP,U 27P-50 CH CAP, U 0.022-25 CAP,E 220-10 CAPACITOR,TC-U 0.01-16 CAP, CER 0.1-50V CAP, CER 0.1-50V C-CAP,U 2200P-50 B C-CAP,U, 0.1-25F CAP, CERA-SOL 0.022 CAP,E 100-10 C-CAP,U, 0.1-25F CAP,E 220-16 M VR CAP,E 10-16 CAP,E 10-16 5L CAP, U 560P-50 CAP, U 560P-50 CAP,E 10-16 CAP,E 10-16
-4-
ELECTRICAL MAIN PARTS LIST - 2/2
REF. NO C807 C808 CN201 CN202 CN601 CN701 CNA201 CNA202 CNA701 CNA702 D612 !F701 J801 J801 L101 L102 L103 L301 L601 L602 L701 S601 TU101 TU101 X601 FRONT C.B C1001 C1002 CN1001 D1007 D1008 D1009 D1010 D1010 D1011 D1011 87-012-358-080 87-012-286-080 88-KTA-602-010 87-A91-355-040 87-A91-355-040 87-A91-355-040 87-A92-042-090 87-A41-087-010 87-A92-042-090 87-A41-087-010 C-CAP,S 0.47-10 F Z CAP, U 0.01-25 CONN,15P CAM-B67 C-LED,BR1112H-TR-RED C-LED,BR1112H-TR-RED C-LED,BR1112H-TR-RED LED,KM2520MBC30 BLU LED,KM2520SEC04 AMB LED,KM2520MBC30 BLU LED,KM2520SEC04 AMB KANRI DESCRIPTION NO. 87-012-271-080 CAP, U 560P-50 87-012-271-080 CAP, U 560P-50 87-099-408-010 CONN,8P EH V WHT 87-A60-620-010 CONN,3P V 2MM JMT 88-KTA-603-010 CONN,15P CAM-B68 8Z-KT1-624-010 8Z-KTG-652-010 8Z-KTG-651-010 8A-KT1-645-010 8A-KT1-646-010 87-027-262-010 8Z-KC1-621-010 87-A61-225-110 87-A61-224-110 87-003-143-080 8Z-KT1-619-010 87-003-097-080 87-003-143-080 87-003-149-080 87-003-149-080 8B-KCF-615-010 87-A91-152-010 8B-KCF-622-010 8B-KCF-621-010 87-A70-325-010 CONN,16P SOC017 CONN ASSY,8P MOTOR CONN ASSY,3P HEAD CONN ASSY,8P ISO-BLACK-B CONN ASSY,8P ISO-WHITE-B LEDE,TLR-124(RED) FUSE,15A 32V JACK,PIN 2P XR-401 JACK,PIN 4P XR-401 COIL 4.7 UH COIL,68MH K7-D COIL,1UH COIL 4.7 UH COIL,47UH COIL,47UH FLTR,AMORPHOUS -CHOKE SW,SL 1-1-2 SSSS212-11-A TU UNIT, FAE347-A21 TU UNIT, FAE347-A22 VIB,XTAL 4.5MHZ HC-49/S PART NO. REF. NO D1012 D1012 LCD1001 PL1001 PL1001 PL1002 PL1002 S1001 S1002 S1003 S1004 S1005 S1006 S1007 S1008 S1009 S1010 S1011 S1012 S1013 S1015 S1016 S1017 AUX C.B J1001 W1001 HEAD C.B 85-HRL-623-010 8A-KC7-611-010 JACK,3.5 ST BLK F-CABLE,3P (AUX) PART NO. KANRI NO. DESCRIPTION
87-A92-042-090 87-A41-087-010 8B-KTG-610-010 8B-KTG-605-010 8B-KCF-631-010 8B-KTG-605-010 8B-KCF-631-010 87-036-339-080 87-A91-987-080 87-036-339-080 87-036-339-080 87-A91-987-080 87-A91-987-080 87-036-339-080 87-A91-987-080 87-036-339-080 87-A91-987-080 87-A91-987-080 87-036-339-080 87-A91-987-080 87-A91-987-080 87-036-339-080 87-A91-986-010
LED,KM2520MBC30 BLU LED,KM2520SEC04 AMB LCD,BKT-16-17 LAMP,9V-60MA W/CAP-B LAMP,9V-65MA LAMP,9V-60MA W/CAP-B LAMP,9V-65MA C-SW,TACT SKQM SW,TACT SKQCAB C-SW,TACT SKQM C-SW,TACT SKQM SW,TACT SKQCAB SW,TACT SKQCAB C-SW,TACT SKQM SW,TACT SKQCAB C-SW,TACT SKQM SW,TACT SKQCAB SW,TACT SKQCAB C-SW,TACT SKQM SW,TACT SKQCAB SW,TACT SKQCAB C-SW,TACT SKQM SW,RTRY EC12E24504-15MM
TYPE A B C D E F
MODEL NAME CT-X421 CT-X411 CT-X311 CT-X321 CT-X4210 CT-X4250
SUFFIX YU YU YZ YZ YL YL
· Regarding connectors, they are not stocked as they are not the initial order items. The connectors are available after they are supplied from connector manufacturers upon the order is received.
CHIP RESISTOR PART CODE
Chip Resistor Part Coding
8 8
A
Resistor Code Value of resistor Chip resistor
Dimensions (mm)
Figure
Wattage 1/16W 1/16W 1/10W 1/8W
Type 1005 1608 2125 3216
Tolerance 5% 5% 5% 5%
Symbol CJ CJ CJ CJ
Form
L W
L 1.0
t
W 0.5 0.8 1.25 1.6
t 0.35 0.45 0.45 0.55
:A Resistor Code : A
104 108 118 128
1.6 2 3.2
-5-
TRANSISTOR ILLUSTRATION
C
B E ECB KTC3203 ECB KRA226M KRC102M KRC111M BCE KTA1046 KTD2058 KRA111S KRC102S KRC111S KTA1504S KTC3875S
-6-
BLOCK DIAGRAM - 1/1
,
-7-
SCHEMATIC DIAGRAM - 1/2 (MAIN SECTION)
-8-
WIRING - 1/2 (MAIN C.B)
32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 A
B
C
15A
D
E
F
G
H
TO HEAD C.B CNA202
I
9
TU101
7
J
5 3 1
K
TO MAIN C.B CN202
L
M
40 30 2 23 5
JR107
44
34
33
N
1
20
22
IC401
5
O
11
80
1
12
15
10
75
P
70 65
15
5
Q
60 64
24
20
IC601
55
R
25 30
35
45
50
S
40
41
T
U
-9-
SCHEMATIC DIAGRAM - 2/2 (FRONT SECTION)
-10-
WIRING - 2/2 (FRONT C.B)
J
I
H
G
F
E
D
C
B
A 32 32 31 31 30 30 29 29 28 28 27 27 26 26 25 25 24 24 23 23 22 22 21 21 20 20 19 19 18 18 17 17 16 16 15 15 14 14 13 13 12 12 11 11 10 10 9 9 8 8 7 7 6 6 5 5 4 4 3 3 2 2 1 1 A
B
C
D
E
F
G
H
I
J
-11-
IC BLOCK DIAGRAM - 1/2
IC, TC9297FB
IC, LC75374E
-12-
IC BLOCK DIAGRAM - 2/2
IC, KIA6225S
IC, TA8259H
-13-
IC DESCRIPTION - 1/1 (TC9323F-027) - 1/2
Pin No. 1~4 5 6 7 8 9 10 11 12 13 14 15 16 Pin Name N.C
_______
I/O O O O O O O O O O O O Not connected. MS signal output Not connected. Standby muting output Muting output to power amp Loudness output
Description
APS N.C S-MUTE
______________
P-MUTE LOUD LOCAL MONO 20dB MUTE AGC CUT/IF REQ RADIO TAPE CD
Local/DX switching output. LOCAL: "H", DX: "L" MONO/STEREO switching output. MONO: "H", STEREO: "L" -20dB muting output. This function is enabled when the -20dB muting jumper is selected. Outputs "H" during searching of frequency. This is an IF count control signal or used to shut off the AGC circuit. RADIO output TAPE output CD output Band switching outputs
17
BAND 1
O FM MW
BAND1 H L L H
BAND2 L L H H
18
BAND 2
O
LW FM (L)
19 ~ 21 22 23 24 ~ 33 34 ~ 37 38 ~ 45 46 47 48 49 50 51 52 53 54 55 56
N.C RE1 RE2 N.C K0 ~ K3 T0 ~ T7 TAPE CD PANEL POWER PHONE MUTE LEVEL METER DIR FF/REW E-VOL DATA E-VOL CK E-VOL CE
I I I O I I I O I O I I
Not connected Rotary encoder input 1 Rotary encoder input 2 Not connected Key matrix inputs Diode matrix outputs TAPE input CD input. "H" CD input enables the CD key. Detects detachable panel (0.2-0.5 s chattering time is provided). Panel provided: "H", Panel not provided: "L" Power output The telephone signal automatically applies muting. The signal level is converted to a digital signal. This meter signal moves the LCD level bar according to the level. TAPE running direction indicator input TAPE FF/REW indicator input
O
Pins to control the LC75374E electronic VR.
-14-
IC DESCRIPTION - 1/1 (TC9323F-027) - 2/2
Pin No. 57 Pin Name V-REF I/O I Reference voltage pin This function is enabled when the ACC input is "L" and PANEL input is "L". "H" causes 58 LED FLASH O flashing for 0.1 s and "L" causes 0.9 s flashing. This output is disabled when the LED FLASH jumper is "H". 59 60 61 62 63 64 65 66 67 68 69 70, 71 72 73 74 75 76 77 78 79 80 DATA CLK CE BEEP T-MUTE REMO-IN INTR 2 TEST HOLD SD-IN IF-IN DO1, DO2 GND FMIN AMIN VDD
_____________
Description
I/O O O O O I I I I I I O I I O I GND For the connection of a crystal oscillator Buzzer output Tuner muting output Interrupt of remote control signal Not used. Test mode control input Monitors that the power is turned on with ignition switched on. SD signal input IF signal input DO outputs GND FM/AM local oscillator signal input VDD terminal Reset input For communications with LCD driver and key input IC TC9297F.
RESET XOUT XIN VXT GND
-15-
LCD DISPLAY
LCD Pin No. SEGMENT No. COM1 COM2 COM3 LCD Pin No. SEGMENT No. COM1 COM2 COM3
1 COM1
2 COM2
3 COM3
4 S1 FM MW AM
5 S2 1 LW PM
6 S3 2 3 ST
7 S4 1a 1f 1e
8 S5 1b 1g 1d
9 S6 VOL 1c 1h
10 S7 2a 2f 2e
11 S8 2b 2g 2d
12 S9 BAS 2c 2h
13 S10 : B2
14 S11 TRE B3
15 S12 3a 3f 3e
6 S13 3b 3g 3d
17 S14
18 S15 4a
19 S16 4b 4g 4d
20 S17 BAL 4e B4
21 S18
22 S19
23 S20 5a 5f 5e
24 S21 5b 5g 5d
25 S22 LO 5c B7
26 S23
27 S24
28 S25 H-BA
FAD MUTE 5 B5 ST B6
MY-IN AUX CH B8 B9
3c 3h
4f 4e
B10
-16-
MECHANICAL EXPLODED VIEW - 1/1
A PWB 10 9 11 12 G 4 16 1 2 3 6 25 5 8 7 19 18 17 20 42 21 PWB C 50 E 38 39 A 23 22 24 26 C 27 14 29 28 C B B 48 49 CHAS, SIDE L-T 44 PANEL HT-SINK C D F C 15 14 33 13 14 SH,LCD 32 LCD 30 31 34 C C 43 C C C 46 C 47 A 45 CDS-363AG1-A H
C
B
52
SH,PWB
H B 36 37 35 40 B 41 53
-17-
51
MECHANICAL MAIN PARTS LIST 1/1
REF. NO 1 2 3 4 5 6 7 7 7 7 7 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 PART NO. 8B-KT9-007-010 8B-KT9-008-010 8A-KC7-220-010 8B-KT9-005-010 8B-KT9-012-010 8B-KT9-006-010 8B-KTG-009-010 8B-KTG-001-010 8B-KTG-006-010 8B-KTG-011-010 8B-KTG-007-010 8B-KTG-008-010 8B-KTF-001-010 8B-KT9-009-010 8B-KT9-202-010 8B-KT9-011-010 8B-KTG-002-010 8B-KTF-004-010 8B-KTF-204-010 8B-KTF-010-010 8B-KTF-009-010 8B-KT9-018-010 8B-KT9-016-010 8B-KT9-014-010 8B-KT9-013-010 8B-KTG-004-010 8B-KTG-003-010 8B-KT9-015-010 8B-KT9-204-010 8B-KT9-203-010 8B-KT9-020-010 8Z-KC2-223-010 8B-KT9-201-010 8B-KT9-206-010 8B-KT9-205-010 KANRI NO. DESCRIPTION REF. NO 31 32 33 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 A B C D E F G H PART NO. KANRI NO. DESCRIPTION
KNOB,RTRY BK9 POINTER,RTRY SPR-C,ROTARY -AC LENS,ARC BTN,FAN CABI,RING WINDOW,X321 WINDOW,X421 WINDOW,X411 WINDOW,X311 WINDOW,X4210 WINDOW,X4250 CABI,FRONT BKF BTN,ARC LENS,L BTN,SEESAW BTN,UP/DN G BTN,EJECT BKF SPR-C,EJ/FF/REW BTN,REW BKF BTN,FF BKF BTN,P.SET 5 BTN,P.SET 3 BTN,P.SET 1 BTN,TWIN BTN,P.SET 6G BTN,P.SET 4G BTN,P.SET 2 HLDR,P.BTN 246 HLDR,P.BTN 135 BTN,DETACH SPR-C,DETACH -C2 LENS,R COVER, LCD R COVER, LCD L
8B-KT9-207-010 8B-KT9-208-010 8B-KTG-203-010 8B-KTG-204-010 8B-KTF-002-010 8B-KTF-003-010 8Z-KC2-203-210 8Z-KC2-221-110 8Z-KT1-244-010 8B-KT9-023-010 8Z-KC2-222-010 8Z-KC2-204-210 8B-KT9-211-010 8A-KC7-231-010 8B-KTF-201-010 8Z-KC1-211-010 8Z-KC7-201-010 8Z-KC3-201-010 8A-KCG-211-010 8A-KT5-204-010 8B-KC1-214-010 8Z-KC1-212-010 8Z-KC1-231-110 8A-KCF-020-110 8Z-KC1-253-010 8Z-KC1-251-010 87-251-073-410 87-251-097-410 87-432-903-010 87-B10-259-010 87-B10-334-010 87-B10-216-010
LENS,LCD BK9 REFLECTOR,LCD BK9 CAP,LAMP BLUE CAP,LAMP AMB CABI,REAR BKF CABI,BASE BKF LEVER,DFP HOOK -C2 SPR-C,DETACH HOOK-C2 SPR-T,DOOR Z DOOR,CASSETTE SPR-T,DETACH LOCK-C2 LEVER,DFP LOCK -C2 CHAS,FRONT BK9 HLDR,ISO-WIRE 2 -AC HLDR,DECK BKF COVER, TOP -C COVER, ISO BLIND -C COVER, CD BLIND -C HLDR,P-IC -AC16 HLDR,TR CHAS,SIDE R-BC COVER, BOTTOM -C HLDR,HALF -C CABI,TRIM -AC15 S-SCREW,PT 2*8 BH+ BLK S-SCREW,TH2.6-4.0-0.8 SCREW,U+2.6-6 U+3-12 WASHER,WTE 2.6 UT2+3.0-10.0 W/O SLOT (BH TAP) VTT+1.7-5 W/O U+2.6-4.0 ZINC BLK (BH M2.6)
TYPE A B C D E F
MODEL NAME CT-X421 CT-X411 CT-X311 CT-X321 CT-X4210 CT-X4250
SUFFIX YU YU YZ YZ YL YL
-18-
COLOR NAME TABLE
COLOR NAME TABLE
Basic color symbol Color Basic color symbol Color Basic color symbol Color B Black C Cream D Orange G Green H Gray L Blue LT Transparent Blue N Gold P Pink R Red S Silver ST Titan Silver T Brown V Violet W White WT Transparent White Y Yellow YT Transparent Yellow LM Metallic Blue LL Light Blue GT Transparent Green LD Dark Blue DT Transparent Orange GM Metallic Green YM Metallic Yellow DM Metallic Orange PT Transparent Pink LA Aqua Blue GL Light Green
-19-
MECHANISM EXPLODED VIEW - 1/1
8 A 9 11 24 12 5 6 15 26 4 B B 17 10 18 19 20 A 29 21 30 31 1 43 I 22 23 33 34 A 32 H G 28 F F C 27 E E E 25 16 13 14 25 C D A 7
3 2
35 40 39 38 N 41 42 68 67 69 66 65 64 63 46 62 C C 61 C 57 57 58 M 60 M M 59 51 50 52 49 A I 47 54 53 48 55 56 45 I M J J 37 K MAIN CHASSIS ASSY L M 44 HEAD C.B 36
-20-
MECHANISM MAIN PARTS LIST - 1/1
REF. NO 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 PART NO. KANRI NO. DESCRIPTION REF. NO 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 A B C D E F G H I J K PART NO. KANRI NO. DESCRIPTION
S1-013-810-100 SX-003-610-190 S1-003-220-070 S1-013-810-020 S1-003-640-070 S1-003-640-230 S1-003-610-180 S1-036-350-070 S1-003-670-570 S1-036-330-420 S1-003-630-320 S1-003-610-150 S1-003-640-100 S1-003-640-110 S1-036-370-040 S1-013-820-053 S1-013-810-060 S1-003-820-180 S1-036-320-060 SX-036-310-020 S1-003-640-060 SX-036-310-040 S1-003-640-170 S1-003-610-510 S1-003-640-010 S1-003-610-530 S1-003-610-290 S1-003-640-020 S1-003-610-230 S1-036-330-110 S1-003-640-080 SX-036-360-020 S1-036-350-030 SX-036-360-030 SX-036-360-050 S1-036-340-030 S1-036-370-010 S1-036-370-050 S1-036-340-050 S1-003-610-070 S1-036-340-060 S1-036-310-030 S1-036-330-070 S1-036-370-020 S1-005-820-215
HOLDER CASS(X) EJECT CAM LOCK ASSY TAPE HOOKER HANGER CASS(X) EJECT CAM LOCK SPG CENTER PLATE SPG(B) PLATE CENTER RETURN LINK MOTOR MOTOR PULLEY(MBC) ROLLER FF(A) PLATE SPG SUPPORT ADJUSTER ARM SPG(A) ADJUSTER ARM SPG(B) HEAD ADJUSTER ARM BLUE ADJUSTER SHIM(X) GUIDE TAPE LINK ADJUSTER(B) HEAD PLATE ASSY PLATE SPG HEAD FR CONVRT ARM ASSY(A) SW SELECT ARM SPG LEVER FF(AT) LEVER SPG FF/REW LEVER REW(AT) ARM LOCK(A) LEVER SPG LOCK LEVER CHANG(B) ROLLER PROGRAM ARM SPG PROGRAM LEVER BRACKET ASSY SELECTOR LINK(B) TU GEAR ARM ASSY PINCH ARM ASSY(F) PINCH ARM SPG(F) SW,MUTE SW POWER LEVER SPG EJECT LEVER EJECT CAM SPG EJECT CAM EJECT ROLLER HP(A) SW,SLIDE IDLE PULLEY(A)
S1-003-620-090 S1-003-620-010 S1-003-620-040 S1-036-360-100 S1-036-360-110 S1-003-650-040 S1-003-610-260 S1-036-320-030 S1-036-350-010 SX-036-360-040 S1-036-340-040 SX-036-320-050 SX-036-360-060 S1-013-840-010 SX-036-360-010 S1-003-620-140 S1-003-640-150 S1-003-620-100 S1-003-630-180 S1-003-640-030 S1-003-820-140 S1-003-840-140 S1-003-620-070 S1-003-620-030 S2-171-200-501 S2-103-200-25C S1-003-650-240 S2-101-200-40C S1-013-850-020 S2-103-200-70C S2-171-250-601 S2-133-200-40C S2-181-200-30D S2-181-600-32E S2-133-170-40C
ARM SENSOR GEAR IDLE GEAR REDUCTION(A) FLYWHEEL ASSY(F) CPL FLYWHEEL ASSY(R) CPL BELT MAIN ARM FR(B) GEAR PULLEY BELT SUB PINCH ARM ASSY(R) PINCH ARM SPG(R) REEL SPINDLE ASSY DETECTOR CAM ASSY(V) BACK TENSION SPG REEL BASE ASSY GEAR DETECTR DASH SPG GEAR SELECTOR COLLER(SELECTOR GEAR) GEAR LOCK ARM SPG GEAR LOCK ARM RATCHET SPG RATCHET GEAR REDUCTION(B) E-RING 2 SCREW,M2-2.5 PSW(REEL)B 1.5-3.2-0.25 SCREW,M2-4 SCREW,M2-5 SCREW,M2-7 E-RING 2.5 SCREW,S-TYPE M2-4 PSW-S 1.2-3.0-0.25 LMW-S 1.6-3.2-0.35 SCREW,S-TYPE M1.7-4 SCREW,FLAT M2-3 SCREW,B-TYPE M2-3 SCREW,S-TYPE M1.7-6
L 87-B10-255-010 M S2-138-200-30C N S2-133-170-60C
-21-
211, IKENOHATA 1CHOME, TAITO-KU, TOKYO 110-8710, JAPAN TEL:03 (3827) 3111
H251701 Printed in Singapore