Text preview for : M39j Windnoise.pdf part of Daewoo Matiz Service Manual, Wiring Diagram - 16 Part File - 62 File
Back to : 796cc (My 2003).part01.ra | Home
SECTION 9J
WINDNOISE
TABLE OF CONTENTS
Diagnostic Information and Procedures . . . . . 9J-1 Windnoise Diagnosis . . . . . . . . . . . . . . . . . . . . . . . 9J-1 Repair Instructions . . . . . . . . . . . . . . . . . . . . . . . . . 9J-2 On-Vehicle Service . . . . . . . . . . . . . . . . . . . . . . . . . . 9J-2 Windnoise Repair . . . . . . . . . . . . . . . . . . . . . . . . . 9J-2
DIAGNOSTIC INFORMATION AND PROCEDURES
WINDNOISE DIAGNOSIS
Caution: An assistant should drive the vehicle while the technician checks for the location of the windnoise, in order to prevent personal injury or vehicle damage. A test drive in the vehicle is necessary to accurately determine the location of the windnoise. Often there is a primary leak and secondary leaks. Failure to repair all leaks will only reduce the windnoise, not eliminate it. During the test drive the technician should bring the following items to aid in determining the location of the windnoise. D D D D A mechanics stethoscope or vacuum hose Masking tape Strip caulk A china marking pencil 5. Internal windnoise is air leaving the vehicle and should be repaired in the following manner. D In order to locate the leak, tape off the body lock pillar pressure relief valves. This will cause air pressure to build up inside the vehicle and enhance the windnoise. D Use a stethoscope or a vacuum hose to locate the leak. D Temporarily repair the leak with masking tape.
D A screwdriver Perform the following steps in order to conduct the road test: 1. Choose a route that includes smooth straight streets that run in all four directions (north, south, east, and west). 2. Choose streets with little traffic or noise that would interfere with the test. 3. Drive the vehicle at the speeds at which the noise was noticed by the customer or until the noise is produced. Do not exceed legal speed limits. 4. The windnoise is external if any of the following conditions occur: D The windnoise is caused by the wind. D The windnoise can be heard with the door glass lowered and while the vehicle is being driven. D The windnoise is eliminated when tape is placed over various moldings and gaps.
D109A307
D Continue testing in order to determine if the noise has been eliminated or if other leaks exist. D When all leaks have been found, return to the shop and make permanent repairs with the proper alignment techniques and sealing materials.
DAEWOO M-150 BL2
9J 2 WINDNOISE
REPAIR INSTRUCTIONS ON-VEHICLE SERVICE
WINDNOISE REPAIR
Windnoise leak repairs are very similar to waterleak repairs. Refer to Section 9I, Waterleaks. The actual procedure depends on the type of seal being repaired. Leaks around the door opening weatherstrips do not always indicate a faulty weatherstrip. A door or window adjustment may resolve the condition. Refer to Section 9L, Glass and Mirrors.
DAEWOO M-150 BL2