Text preview for : M39q Roof.pdf part of Daewoo Matiz Service Manual, Wiring Diagram - 16 Part File - 62 File
Back to : 796cc (My 2003).part01.ra | Home
SECTION 9Q
ROOF
TABLE OF CONTENTS
Description and Operation . . . . . . . . . . . . . . . . . . Roof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Manual SunRoof . . . . . . . . . . . . . . . . . . . . . . . . . . Sun Visors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Passenger Assist Handles . . . . . . . . . . . . . . . . . . Coat Hook . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Component Locator . . . . . . . . . . . . . . . . . . . . . . . . Roof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9Q-2 9Q-2 9Q-2 9Q-2 9Q-2 9Q-2 9Q-3 9Q-3 On-Vehicle Service . . . . . . . . . . . . . . . . . . . . . . . . . . Formed Headliner . . . . . . . . . . . . . . . . . . . . . . . . . Manual SunRoof . . . . . . . . . . . . . . . . . . . . . . . . . . Sun Visors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9Q-4 9Q-4 9Q-5 9Q-6
Passenger Assist Handle and the Coat Hook . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9Q-6 Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9Q-8 Fastener Tightening Specifications . . . . . . . . . . . 9Q-8
Repair Instructions . . . . . . . . . . . . . . . . . . . . . . . . . 9Q-4
DAEWOO M-150 BL2
9Q 2 ROOF
DESCRIPTION AND OPERATION
ROOF
The roof is a one-piece painted metal unit which incorporates a single, solid headliner and two moldings, one on each side of the vehicle's roof. The moldings, which enclose and hide the roof rail seams, are serviceable as individual units. The one-piece formed headliner, common to both the notchback and the hatchback, consists of a molded substrate covered with a foam-backed cloth facing. The one-piece construction requires servicing the headliner as a complete assembly.
SUN VISORS
The sun visors swing down or side in order to block out glare. They also swing to the side when they are released from the support.
PASSENGER ASSIST HANDLE
There is a passenger assist handle for the front passenger seat. Passengers can use these handles to assist in keeping their balance over rough roads or during sharp turns.
MANUAL SUNROOF
The sunroof is D Intended to provide light and air through the roof of the vehicle during the driving. D Built into the roof. D Made of glass.
COAT HOOK
The coat hook is fastened to the headliner above the left-hand rear passenger seat for LeftHand Drive or right hand rear passenger seat for RightHand Drive. This position has a coat hook in the place of a passenger assist handle.
DAEWOO M-150 BL2
ROOF 9Q 3
COMPONENT LOCATOR
ROOF
D19C402B
1. 2. 3. 4. 5. 6. 7.
Sunroof Handle Sunroof Screen Sunroof Screen Seal Sunroof Upper Frame Roof Seal Sunroof Lower Frame Sunroof Cover
8. 9. 10. 11. 12. 13. 14.
Roof Rail Rear Spoiler Roof Molding Roof Rack Bracket Roof Rack Pad Cap Roof Rack
DAEWOO M-150 BL2
9Q 4 ROOF
REPAIR INSTRUCTIONS ONVEHICLE SERVICE
FORMED HEADLINER
Removal Procedure
1. Disconnect the negative battery cable. 2. Remove the sun visors. Refer to "Sun Visors" in this section. 3. Remove the interior courtesy lamp. Refer to Section 9B, Lighting Systems. 4. Pry off the Apillar trim panel. Refer to Section 9G, Interior Trim. 5. Pry off the upper Bpillar trim panel. Refer to Section 9G, Interior Trim.
D109C555
6. Pry off the Cpillar trim panel. Refer to Section 9G, Interior Trim. 7. Remove the passenger assist handle and the coat hook. Refer to "Passenger Assist Handle and The Coat Hook" in this section. 8. Remove the sunroof molding, if equipped with. Refer to "Manual Sunroof" in this section. 9. Take off the tailgate opening weatherstrip. Refer to Section 9P, Doors. 10. Remove the headliner. D Remove the clips (1). D Remove the headliner (2).
Installation Procedure
1. Install in the reverse order of removal.
D109C556
DAEWOO M-150 BL2
ROOF 9Q 5
MANUAL SUNROOF
Removal Procedure
1. Remove the sunroof screen. D Remove the clips (1). D Remove the lock (2). D Remove the screen (3).
D109C557
2. Remove the inside sunroof molding in the passenger compartment. a. Inside sunroof molding.
D109C558
3. Remove the lower sunroof frame. D Remove the screws (1). D Remove the lower sunroof frame (2).
D109C559
4. Remove the upper sunroof frame. a. Upper sunroof frame.
D109C560
DAEWOO M-150 BL2
9Q 6 ROOF Installation Procedure
1. Install the upper sunroof frame. 2. Install the lower sunroof frame with the screws (a). 3. Install the inside sunroof molding. 4. Install the screen with the clips and the lock.
Tighten
Tighten the screws to 3 NSm (27 lb-in). Notice: When installing the lower sunroof frame, make sure to tighten the screws previously as shown the figure and tighten all the screws.
D19C561A
SUN VISORS
Removal Procedure
1. Remove the sun visors. D Remove the screws (1). D Remove the sun visors (2).
D109C562
Installation Procedure
1. Install the sun visors with the screws.
D109C563
PASSENGER ASSIST HANDLE OR THE COAT HOOK
Removal Procedure
1. Remove the passenger assist handle or the coat hook from the headliner. D Remove the screws (1). D Remove the coat hook or the assist handle (2).
D109C564
DAEWOO M-150 BL2
ROOF 9Q 7 Installation Procedure
1. Install the passenger assist handle or the coat hook to the headliner with the screws.
D109C565
DAEWOO M-150 BL2
ÁÁÁÁÁÁÁ Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á
9Q 8 ROOF
Sunroof Frame Screws Application
FASTENER TIGHTENING SPECIFICATIONS
SPECIFICATIONS
NSm
3
Lb-Ft
Lb-In
27
DAEWOO M-150 BL2