Text preview for : Sharp DV-SL10x.pdf part of Sharp DV-SL10 2 389 908 B, 2 files, 42 pages
Back to : Sharp DV-SL10x.part1.rar | Home
DV-SL10S(G)/DV-SL10W/DV-SL10/DV-SL10X/DV-SL10S(Q)/DV-SL10S(S)/DV-SL10(RU)
SERVICE MANUAL
S63C5DV-SL10S
SERVICE MANUAL DVD VIDEO PLAYER MODELS DV-SL10S(G)/DV-SL10W/DV-SL10/DV-SL10X/DV-SL10S(Q)/DV-SL10S(S)/DV-SL10(RU)
DVD VIDEO PLAYER
DV-SL10S(G) DV-SL10W DV-SL10 DV-SL10X DV-SL10S(Q) DV-SL10S(S) DV-SL10(RU)
MODELS
In the interests of user-safety (Required by safety regulations in some countries) the set should be restored to its original condition and only parts identical to those specified be used.
This service manual supplement (DV-SL10S(G)/DV-SL10W/DVSL10/DV-SL10X/DV-SL10S(Q)/DV-SL10S(S)/DV-SL10(RU)) contains only the difference from the original model. For all other data, see each original service manual for DV-SL10H/DV-SL10S(Y)/DV-SL10S(R).
CONTENTS
Page OPERATING CONTROLS AND FUNCTIONS .................................................................................. 1-1-1 BLOCK DIAGRAMS ........................................................................................................................... 1-2-1 SCHEMATIC DIAGRAMS/ CBA'S AND TEST POINTS .................................................................... 1-3-1 WAVEFORMS .................................................................................................................................... 1-4-1 WIRING DIAGRAM ............................................................................................................................ 1-5-1 LEAD IDENTIFICATIONS .................................................................................................................. 1-6-1 EXPLODED VIEWS ........................................................................................................................... 1-7-1 DIFFERENT PARTS FROM ORIGINAL MODEL (DV-SL10H) .......................................................... 1-8-1
SHARP CORPORATION
1
This document has been published to be used for after sales service only. The contents are subject to change without notice.
OPERATING CONTROLS AND FUNCTIONS
[ DV-SL10S(G)/DV-SL10S(Q) ]
FRONT PANEL
1
OPERATE OPEN/CLOSE PLAY STOP REV SKIP FWD
2 3 4 5
6
7
8
9
REAR VIEW
R
L
AV (TV)
DIGITAL VIDEO S-VIDEO AUDIO OUT VIDEO OUT
1. 2. 3. 4. 5.
OPERATE to switch the player to ON or OFF OPEN/CLOSE to open/close the disc tray PLAY to start or resume disc playback STOP to stop playback SKIP H / REV h
10
11 12
13 14
15
10. MAIN (AC Power Cord) connect to a standard AC outlet 11. AUDIO OUT (Left/Right) 12. DIGITAL (Digital audio out)
connect to AUDIO inputs of an amplifier, receiver or stereo system connect to AUDIO inputs of a digital (coaxial) audio equipment
6. SKIP G / FWD g
goes to previous chapter or track during playback; press and hold for 1.5 seconds for a reverse search
7. Disc tray 8. Remote sensor window 9. Display
goes to next chapter or track during playback; press and hold for 1.5 seconds for a forward search
13. VIDEO OUT connect to the Video Input of a TV 14. S-VIDEO OUT connect to a TV with S-Video inputs 15. AV (TV)
connect SCART cable to a TV
Caution: Do not touch the inner pins of the jacks on the rear panel. Electrostatic discharge may cause permanent damage to the player. 10. 11. 12. 13. 14. 15. 16. 17. 18. CLEAR Button Resets a setting. REV Button Fast reverse playback to a desired point. PLAY Button Starts playback of the disc contents. DIRECT SKIP Button Press to locate a desired point. STOP Button Stops operation of the disc. OPEN/CLOSE Button Press to insert discs into or remove them from the tray. SETUP Button Press to enter the setup mode or to change setup items. MARKER Button Press to call back the Marker display. MODE Button
REMOTE CONTROL
1 2 3 4 5 6 7 8 9 10 11 12 13 14
OPERATE ON SCREEN SETUP OPEN/ CLOSE DIMMER GAMMA ZOOM TITLE SUBTITLE MODE ANGLE MARKER AUDIO MENU
RETURN
ENTER REPEAT A-B REPEAT
1 4
CLEAR
2 5 8 0
3 6 9
+10
7
SKIP
C
15 16 17 18 19 20 21 22 23 24 25 26 27 28
REV PLAY
DIRECT SKIP
FWD
STILL/PAUSE
STOP
29
1. OPERATE Button Press to turn the power on and off. 2. ON SCREEN Button 3. 4. 5. 6. 7. 8.
19. AUDIO Button Press to select a desired audio language or sound mode. 20. ANGLE Button 21. MENU Button 22. 23. 24. 25. 26. 27. 28. 29.
Displays the DVD menus.
Activates programme playback or random playback mode.(CD/MP3) Activates the 3D sound.(DVD) Press to change the camera angle to see the sequence being played back from a different angle.
DIMMER Button Press to change the Panel Display settings. GAMMA Button Press to adjust the black parts of the picture brighter. ZOOM Button Enlarges part of a DVD-reproduced image. SUBTITLE Button Press to select a desired subtitle language. TITLE Button Displays the title menu. RETURN Button
Returns to the previous operation.
Displays the current status on the TV screen for checking purposes.
9. 0-9 numerical key pad select numbered items in a menu +10
use this button to enter number 10 and above
Arrow Buttons (L / K / B / s) (left/right/up/down) select an item in the menu ENTER Button Press to accept a setting. REPEAT Button Repeats playback of the current disc, title, chapter or track. A-B REPEAT Button Repeats playback of a selected section. SKIP UP Button Plays back from the beginning of the next chapter or track. SKIP DOWN Button Plays back from the beginning of the current chapter or track. FWD Button Fast forwards playback to a desired point. STILL/PAUSE Button
Pause playback temporarily/frame-by-frame playback.
1-1-1
E5753IB
Display
Stays on when the repeat function is on. Stays on when the A-B repeat function is on. Stays on when the inserted disc is being played back. Lights up when a playback control is activated. Stays on when repeat title function is on. Stays on when repeat chapter function is on. Stays on when repeat track function is on. Lights up when a DVD is inserted on the tray. CD: Lights up when a CD is inserted on the tray. VCD: Lights up when a Video CD is inserted on the tray.
Lights up when the inserted disc comes to a pause.
Displays how long a current title or track has been played back. When a chapter or track has switched, the number of a new title, chapter or track is displayed.
Displays During Operation
Power on No disc inserted or playing DVD Menu Tray open Tray closed
Loading the Batteries
1. Open the battery compartment cover.
2. Insert two AA batteries, with each one oriented correctly.
3. Close the cover.
Loading the Disc
NOTES
Power off
Do not mix alkaline and manganese batteries. Do not mix old and new batteries.
1-1-2
E5753IB
[ DV-SL10W ]
FRONT PANEL
1 2 3 4 5 6 7 8 9
OPERATE OPEN/CLOSE PLAY STOP SKIP
REV
FWD
REAR VIEW
L Y CR
COMPONENT
DIGITAL
R
VIDEO
CB
S-VIDEO
AUDIO OUT
VIDEO OUT
10
11
12 1314
15
1. OPERATE to switch the player to ON or OFF 2. OPEN/CLOSE to open/close the disc tray 3. PLAY to start or resume disc playback 4. STOP to stop playback 5. SKIP H / REVh goes to previous chapter or track during playback; press and hold for 1.5 seconds for a reverse search 6. SKIP G / FWD g goes to next chapter or track during playback; press and hold for 1.5 seconds for a forward search 7. Disc tray 8. Remote sensor window 9. Display
10. MAIN (AC Power Cord) connect to a standard AC outlet 11. DIGITAL AUDIO OUT (coaxial) connect to AUDIO inputs of a digital (coaxial) audio equipment 12. AUDIO OUT (Left/Right) connect to AUDIO inputs of an amplifier, receiver or stereo system 13. VIDEO OUT connect to the Video Input of a TV 14. COMPONENT VIDEO OUT connect to a TV with Component video in jacks 15. S-VIDEO OUT connect to a TV with S-Video inputs Caution: Do not touch the inner pins of the jacks on the rear panel. Electrostatic discharge may cause permanent damage to the player. 11. REV Button Fast reverse playback to a desired point. 12. PLAY Button Starts playback of the disc contents. 13. DIRECT SKIP Button Press to locate a desired point. 14. STOP Button Stops operation of the disc. 15. OPEN/CLOSE Button Press to insert discs into or remove them from the tray. 16. SETUP Button Press to enter the setup mode or to change setup items. 17. MARKER Button Press to call back the Marker display. 18. MODE Button Activates programme playback or random playback mode.(CD/MP3) Activates the 3D sound.(DVD) 19. AUDIO Button Press to select a desired audio language or sound mode. 20. ANGLE Button Press to change the camera angle to see the sequence being played back from a different angle. 21. MENU Button Displays the DVD menus. 22. Arrow Buttons (L K B s) (left/right/up/down) select an item in the menu 23. ENTER Button Press to accept a setting. 24. REPEAT Button Repeats playback of the current disc, title, chapter or track. 25. A-B REPEAT Button Repeats playback of a selected section. 26. SKIP UP Button Plays back from the beginning of the next chapter or track. 27. SKIP DOWN Button Plays back from the beginning of the current chapter or track. 28. FWD Button Fast forwards playback to a desired point. 29. STILL/PAUSE Button Pause playback temporarily/frame-by-frame playback.
REMOTE CONTROL
OPERATE
1 2 3 4 5 6 7 8 9
ON SCREEN
SETUP
OPEN/ CLOSE
DIMMER GAMMA
MODE
MARKER
ZOOM
SUBTITLE
ANGLE
AUDIO
TITLE
MENU
RETURN
ENTER
REPEAT
1 4 7
CLEAR
2 5 8 0
3
A-B REPEAT
6 9
+10
FWD PLAY
SKIP
15 16 17 18 19 20 21 22 23 24 25 26 27 28
10 11 12 13 14
C
REV
DIRECT SKIP
STILL/PAUSE
STOP
29
1. OPERATE Button Press to turn the power on and off. 2. ON SCREEN Button Displays the current status on the TV screen for checking purposes. 3. DIMMER Button Press to change the Panel Display settings. 4. GAMMA Button Press to adjust the black parts of the picture brighter. 5. ZOOM Button Enlarges part of a DVD-reproduced image. 6. SUBTITLE Button Press to select a desired subtitle language. 7. TITLE Button Displays the title menu. 8. RETURN Button Returns to the previous operation. 9. 0-9 numerical key pad select numbered items in a menu +10 use this button to enter number 10 and above 10. CLEAR Button Resets a setting.
1-1-3
E5753IB
Display
Stays on when the repeat function is on. Stays on when the A-B repeat function is on. Stays on when the inserted disc is being played back. Lights up when a playback control is activated. Stays on when repeat title function is on. Stays on when repeat chapter function is on. Stays on when repeat track function is on. Lights up when a DVD is inserted on the tray. CD: Lights up when a CD is inserted on the tray. VCD: Lights up when a Video CD is inserted on the tray.
Lights up when the inserted disc comes to a pause.
Displays how long a current title or track has been played back. When a chapter or track has switched, the number of a new title, chapter or track is displayed.
Displays During Operation
Power on No disc inserted or playing DVD Menu Tray open Tray closed
Loading the Batteries
1. Open the battery compartment cover.
2. Insert two AA batteries, with each one oriented correctly.
3. Close the cover.
Loading the Disc
NOTES
Power off
Do not mix alkaline and manganese batteries. Do not mix old and new batteries.
1-1-4
E5753IB
[ DV-SL10 ]
FRONT PANEL
1 2 3 4 5 6 7 8 9
OPERATE OPEN/CLOSE PLAY STOP SKIP
REV
FWD
REAR VIEW
L Y CR
COMPONENT
DIGITAL
R
VIDEO
CB
S-VIDEO
AUDIO OUT
VIDEO OUT
12 10 11 13
14 15
1. OPERATE to switch the player to ON or OFF 2. OPEN/CLOSE to open/close the disc tray 3. PLAY to start or resume disc playback 4. STOP to stop playback 5. SKIP H / REVh goes to previous chapter or track during playback; press and hold for 1.5 seconds for a reverse search 6. SKIP G / FWD g goes to next chapter or track during playback; press and hold for 1.5 seconds for a forward search 7. Disc tray 8. Remote sensor window 9. Display
10. MAIN (AC Power Cord) connect to a standard AC outlet 11. DIGITAL AUDIO OUT (coaxial) connect to AUDIO inputs of a digital (coaxial) audio equipment 12. AUDIO OUT (Left/Right) connect to AUDIO inputs of an amplifier, receiver or stereo system 13. VIDEO OUT connect to the Video Input of a TV 14. COMPONENT VIDEO OUT connect to a TV with Component video in jacks 15. S-VIDEO OUT connect to a TV with S-Video inputs Caution: Do not touch the inner pins of the jacks on the rear panel. Electrostatic discharge may cause permanent damage to the player. 11. REV Button Fast reverse playback to a desired point. 12. PLAY Button Starts playback of the disc contents. 13. DIRECT SKIP Button Press to locate a desired point. 14. STOP Button Stops operation of the disc. 15. OPEN/CLOSE Button Press to insert discs into or remove them from the tray. 16. SETUP Button Press to enter the setup mode or to change setup items. 17. MARKER Button Press to call back the Marker display. 18. MODE Button Activates programme playback or random playback mode.(CD/MP3) Activates the 3D sound.(DVD) 19. AUDIO Button Press to select a desired audio language or sound mode. 20. ANGLE Button Press to change the camera angle to see the sequence being played back from a different angle. 21. MENU Button Displays the DVD menus. 22. Arrow Buttons (L K B s) (left/right/up/down) select an item in the menu 23. ENTER Button Press to accept a setting. 24. REPEAT Button Repeats playback of the current disc, title, chapter or track. 25. A-B REPEAT Button Repeats playback of a selected section. 26. SKIP UP Button Plays back from the beginning of the next chapter or track. 27. SKIP DOWN Button Plays back from the beginning of the current chapter or track. 28. FWD Button Fast forwards playback to a desired point. 29. STILL/PAUSE Button Pause playback temporarily/frame-by-frame playback.
REMOTE CONTROL
OPERATE
1 2 3 4 5 6 7 8 9
ON SCREEN
SETUP
OPEN/ CLOSE
DIMMER GAMMA
MODE
MARKER
ZOOM
SUBTITLE
ANGLE
AUDIO
TITLE
MENU
RETURN
ENTER
REPEAT
1 4 7
CLEAR
2 5 8 0
3
A-B REPEAT
6 9
+10
FWD PLAY
SKIP
15 16 17 18 19 20 21 22 23 24 25 26 27 28
10 11 12 13 14
C
REV
DIRECT SKIP
STILL/PAUSE
STOP
29
1. OPERATE Button Press to turn the power on and off. 2. ON SCREEN Button Displays the current status on the TV screen for checking purposes. 3. DIMMER Button Press to change the Panel Display settings. 4. GAMMA Button Press to adjust the black parts of the picture brighter. 5. ZOOM Button Enlarges part of a DVD-reproduced image. 6. SUBTITLE Button Press to select a desired subtitle language. 7. TITLE Button Displays the title menu. 8. RETURN Button Returns to the previous operation. 9. 0-9 numerical key pad select numbered items in a menu +10 use this button to enter number 10 and above 10. CLEAR Button Resets a setting.
1-1-5
E5753IB
Display
Stays on when the repeat function is on. Stays on when the A-B repeat function is on. Stays on when the inserted disc is being played back. Lights up when a playback control is activated. Stays on when repeat title function is on. Stays on when repeat chapter function is on. Stays on when repeat track function is on. Lights up when a DVD is inserted on the tray. CD: Lights up when a CD is inserted on the tray. VCD: Lights up when a Video CD is inserted on the tray.
Lights up when the inserted disc comes to a pause.
Displays how long a current title or track has been played back. When a chapter or track has switched, the number of a new title, chapter or track is displayed.
Displays During Operation
Power on No disc inserted or playing DVD Menu Tray open Tray closed
Loading the Batteries
1. Open the battery compartment cover.
2. Insert two AA batteries, with each one oriented correctly.
3. Close the cover.
Loading the Disc
NOTES
Power off
Do not mix alkaline and manganese batteries. Do not mix old and new batteries.
1-1-6
E5753IB
[ DV-SL10X ]
FRONT PANEL
1 2 3 4 5 6 7 8 9
OPERATE OPEN/CLOSE PLAY STOP SKIP
REV
FWD
REAR VIEW
L DIGITAL Y CR
COMPONENT
OPTICAL COAXIAL
R
VIDEO
CB
S -VIDEO
AUDIO OUT
VIDEO OUT
10
11 12
1314 15 16
1. OPERATE to switch the player to ON or OFF 2. OPEN/CLOSE to open/close the disc tray 3. PLAY to start or resume disc playback 4. STOP to stop playback 5. SKIP H / REV h goes to previous chapter or track during playback; press and hold for 1.5 seconds for a reverse search 6. SKIP G / FWD g goes to next chapter or track during playback; press and hold for 1.5 seconds for a forward search 7. Disc tray 8. Remote sensor window 9. Display 10. MAINS (AC Power Cord) connect to a standard AC outlet
11. OPTICAL (Digital audio out) connect to digital (optical) audio equipment 12. COAXIAL (Digital audio out) connect to AUDIO inputs of a digital (coaxial) audio equipment 13. AUDIO OUT (Left/Right) connect to AUDIO inputs of an amplifier, receiver or stereo system 14. VIDEO OUT connect to the Video Input of a TV 15. COMPONENT VIDEO OUT connect to a TV with Component video in jacks 16. S-VIDEO OUT connect to a TV with S-Video inputs Caution: Do not touch the inner pins of the jacks on the rear panel. Electrostatic discharge may cause permanent damage to the player. 11. REV Button Fast reverse playback to a desired point. 12. PLAY Button Starts playback of the disc contents. 13. DIRECT SKIP Button Press to locate a desired point. 14. STOP Button Stops operation of the disc. 15. OPEN/CLOSE Button Press to insert discs into or remove them from the tray. 16. SETUP Button Press to enter the setup mode or to change setup items. 17. MARKER Button Press to call back the Marker display. 18. MODE Button Activates programme playback or random playback mode.(CD/MP3) Activates the 3D sound.(DVD) 19. AUDIO Button Press to select a desired audio language or sound mode. 20. ANGLE Button Press to change the camera angle to see the sequence being played back from a different angle. 21. MENU Button Displays the DVD menus. 22. Arrow Buttons (L K B s) (left/right/up/down) select an item in the menu 23. ENTER Button Press to accept a setting. 24. REPEAT Button Repeats playback of the current disc, title, chapter or track. 25. A-B REPEAT Button Repeats playback of a selected section. 26. SKIP UP Button Plays back from the beginning of the next chapter or track. 27. SKIP DOWN Button Plays back from the beginning of the current chapter or track. 28. FWD Button Fast forwards playback to a desired point. 29. STILL/PAUSE Button Pause playback temporarily/frame-by-frame playback.
REMOTE CONTROL
OPERATE
1 2 3 4 5 6 7 8 9
ON SCREEN
SETUP
OPEN/ CLOSE
DIMMER GAMMA
MODE
MARKER
ZOOM
SUBTITLE
ANGLE
AUDIO
TITLE
MENU
RETURN
ENTER
REPEAT
1 4 7
CLEAR
2 5 8 0
3
A-B REPEAT
6 9
+10
FWD PLAY
SKIP
15 16 17 18 19 20 21 22 23 24 25 26 27 28
10 11 12 13 14
C
REV
DIRECT SKIP
STILL/PAUSE
STOP
29
1. OPERATE Button Press to turn the power on and off. 2. ON SCREEN Button Displays the current status on the TV screen for checking purposes. 3. DIMMER Button Press to change the Panel Display settings. 4. GAMMA Button Press to adjust the black parts of the picture brighter. 5. ZOOM Button Enlarges part of a DVD-reproduced image. 6. SUBTITLE Button Press to select a desired subtitle language. 7. TITLE Button Displays the title menu. 8. RETURN Button Returns to the previous operation. 9. 0-9 numerical key pad select numbered items in a menu +10 use this button to enter number 10 and above 10. CLEAR Button Resets a setting.
1-1-7
E5753IB
Display
Stays on when the repeat function is on. Stays on when the A-B repeat function is on. Stays on when the inserted disc is being played back. Lights up when a playback control is activated. Stays on when repeat title function is on. Stays on when repeat chapter function is on. Stays on when repeat track function is on. Lights up when a DVD is inserted on the tray. CD: Lights up when a CD is inserted on the tray. VCD: Lights up when a Video CD is inserted on the tray.
Lights up when the inserted disc comes to a pause.
Displays how long a current title or track has been played back. When a chapter or track has switched, the number of a new title, chapter or track is displayed.
Displays During Operation
Power on No disc inserted or playing DVD Menu Tray open Tray closed
Loading the Batteries
1. Open the battery compartment cover.
2. Insert two AA batteries, with each one oriented correctly.
3. Close the cover.
Loading the Disc
NOTES
Power off
Do not mix alkaline and manganese batteries. Do not mix old and new batteries.
1-1-8
E5753IB
[ DV-SL10S(S) ]
FRONT PANEL
1 2 3 4 5 6 7 8 9
OPERATE OPEN/CLOSE PLAY STOP SKIP
REV
FWD
REAR VIEW
R L
AV (TV)
DIGITAL AUDIO OUT
VIDEO S-VIDEO VIDEO OUT
11 12 10
13 14
15
1. OPERATE to switch the player to ON or OFF 2. OPEN/CLOSE to open/close the disc tray 3. PLAY to start or resume disc playback 4. STOP to stop playback 5. SKIP H / REV h goes to previous chapter or track during playback; press and hold for 1.5 seconds for a reverse search 6. SKIP G / FWD g goes to next chapter or track during playback; press and hold for 1.5 seconds for a forward search 7. Disc tray 8. Remote sensor window 9. Display
10. MAIN (AC Power Cord) connect to a standard AC outlet 11. AUDIO OUT (Left/Right) connect to AUDIO inputs of an amplifier, receiver or stereo system 12. DIGITAL (Digital audio out) connect to AUDIO inputs of a digital (coaxial) audio equipment 13. VIDEO OUT connect to the Video Input of a TV 14. S-VIDEO OUT connect to a TV with S-Video inputs 15. AV (TV) connect SCART cable to a TV Caution: Do not touch the inner pins of the jacks on the rear panel. Electrostatic discharge may cause permanent damage to the player. 11. REV Button Fast reverse playback to a desired point. 12. PLAY Button Starts playback of the disc contents. 13. DIRECT SKIP Button Press to locate a desired point. 14. STOP Button Stops operation of the disc. 15. OPEN/CLOSE Button Press to insert discs into or remove them from the tray. 16. SETUP Button Press to enter the setup mode or to change setup items. 17. MARKER Button Press to call back the Marker display. 18. MODE Button Activates programme playback or random playback mode.(CD/MP3) Activates the 3D sound.(DVD) 19. AUDIO Button Press to select a desired audio language or sound mode. 20. ANGLE Button Press to change the camera angle to see the sequence being played back from a different angle. 21. MENU Button Displays the DVD menus. 22. Arrow Buttons (L K B s) (left/right/up/down) select an item in the menu 23. ENTER Button Press to accept a setting. 24. REPEAT Button Repeats playback of the current disc, title, chapter or track. 25. A-B REPEAT Button Repeats playback of a selected section. 26. SKIP UP Button Plays back from the beginning of the next chapter or track. 27. SKIP DOWN Button Plays back from the beginning of the current chapter or track. 28. FWD Button Fast forwards playback to a desired point. 29. STILL/PAUSE Button Pause playback temporarily/frame-by-frame playback.
REMOTE CONTROL
OPERATE
1 2 3 4 5 6 7 8 9
ON SCREEN
SETUP
OPEN/ CLOSE
DIMMER GAMMA
MODE
MARKER
ZOOM
SUBTITLE
ANGLE
AUDIO
TITLE
MENU
RETURN
ENTER
REPEAT
1 4 7
CLEAR
2 5 8 0
3
A-B REPEAT
6 9
+10
FWD PLAY
SKIP
15 16 17 18 19 20 21 22 23 24 25 26 27 28
10 11 12 13 14
C
REV
DIRECT SKIP
STILL/PAUSE
STOP
29
1. OPERATE Button Press to turn the power on and off. 2. ON SCREEN Button Displays the current status on the TV screen for checking purposes. 3. DIMMER Button Press to change the Panel Display settings. 4. GAMMA Button Press to adjust the black parts of the picture brighter. 5. ZOOM Button Enlarges part of a DVD-reproduced image. 6. SUBTITLE Button Press to select a desired subtitle language. 7. TITLE Button Displays the title menu. 8. RETURN Button Returns to the previous operation. 9. 0-9 numerical key pad select numbered items in a menu +10 use this button to enter number 10 and above 10. CLEAR Button Resets a setting.
1-1-9
E5753IB
Display
Stays on when the repeat function is on. Stays on when the A-B repeat function is on. Stays on when the inserted disc is being played back. Lights up when a playback control is activated. Stays on when repeat title function is on. Stays on when repeat chapter function is on. Stays on when repeat track function is on. Lights up when a DVD is inserted on the tray. CD: Lights up when a CD is inserted on the tray. VCD: Lights up when a Video CD is inserted on the tray.
Lights up when the inserted disc comes to a pause.
Displays how long a current title or track has been played back. When a chapter or track has switched, the number of a new title, chapter or track is displayed.
Displays During Operation
Power on No disc inserted or playing DVD Menu Tray open Tray closed
Loading the Batteries
1. Open the battery compartment cover.
2. Insert two AA batteries, with each one oriented correctly.
3. Close the cover.
Loading the Disc
NOTES
Power off
Do not mix alkaline and manganese batteries. Do not mix old and new batteries.
1-1-10
E5753IB
[ DV-SL10(RU) ]
FRONT PANEL
1 2 3 4 5 6 7 8 9
OPERATE OPEN/CLOSE PLAY STOP SKIP
REV
FWD
REAR VIEW
L Y CR
COMPONENT
DIGITAL
R
VIDEO
CB
S-VIDEO
AUDIO OUT
VIDEO OUT
12 10 11 13
14 15
1. OPERATE to switch the player to ON or OFF 2. OPEN/CLOSE to open/close the disc tray 3. PLAY to start or resume disc playback 4. STOP to stop playback 5. SKIP H / REV h goes to previous chapter or track during playback; press and hold for 1.5 seconds for a reverse search 6. SKIP G / FWD g goes to next chapter or track during playback; press and hold for 1.5 seconds for a forward search 7. Disc tray 8. Remote sensor window 9. Display
10. MAIN (AC Power Cord) connect to a standard AC outlet 11. DIGITAL AUDIO OUT (coaxial) connect to AUDIO inputs of a digital (coaxial) audio equipment 12. AUDIO OUT (Left/Right) connect to AUDIO inputs of an amplifier, receiver or stereo system 13. VIDEO OUT connect to the Video Input of a TV 14. COMPONENT VIDEO OUT connect to a TV with Component video in jacks 15. S-VIDEO OUT connect to a TV with S-Video inputs Caution: Do not touch the inner pins of the jacks on the rear panel. Electrostatic discharge may cause permanent damage to the player.
REMOTE CONTROL
OPERATE
1 2 3 4 5 6 7 8 9
ON SCREEN
SETUP
OPEN/ CLOSE
DIMMER GAMMA
MODE
MARKER
ZOOM
SUBTITLE
ANGLE
AUDIO
TITLE
MENU
RETURN
ENTER
REPEAT
1 4 7
CLEAR
2 5 8 0
3
A-B REPEAT
6 9
+10
FWD PLAY
SKIP
15 16 17 18 19 20 21 22 23 24 25 26 27 28
10 11 12 13 14
C
REV
DIRECT SKIP
STILL/PAUSE
STOP
29
1. OPERATE Button Press to turn the power on and off. 2. ON SCREEN Button Displays the current status on the TV screen for checking purposes. 3. DIMMER Button Press to change the Panel Display settings. 4. GAMMA Button Press to adjust the black parts of the picture brighter. 5. ZOOM Button Enlarges part of a DVD-reproduced image. 6. SUBTITLE Button Press to select a desired subtitle language. 7. TITLE Button Displays the title menu. 8. RETURN Button Returns to the previous operation. 9. 0-9 numerical key pad select numbered items in a menu +10 use this button to enter number 10 and above 10. CLEAR Button Resets a setting.
11. REV Button Fast reverse playback to a desired point. 12. PLAY Button Starts playback of the disc contents. 13. DIRECT SKIP Button Press to locate a desired point. 14. STOP Button Stops operation of the disc. 15. OPEN/CLOSE Button Press to insert discs into or remove them from the tray. 16. SETUP Button Press to enter the setup mode or to change setup items. 17. MARKER Button Press to call back the Marker display. 18. MODE Button Activates programme playback or random playback mode.(CD/MP3) Activates the 3D sound.(DVD) 19. AUDIO Button Press to select a desired audio language or sound mode. 20. ANGLE Button Press to change the camera angle to see the sequence being played back from a different angle. 21. MENU Button Displays the DVD menus. 22. Arrow Buttons (L K B s) (left/right/up/down) select an item in the menu 23. ENTER Button Press to accept a setting. 24. REPEAT Button Repeats playback of the current disc, title, chapter or track. 25. A-B REPEAT Button Repeats playback of a selected section. 26. SKIP UP Button Plays back from the beginning of the next chapter or track. 27. SKIP DOWN Button Plays back from the beginning of the current chapter or track. 28. FWD Button Fast forwards playback to a desired point. 29. STILL/PAUSE Button Pause playback temporarily/frame-by-frame playback.
1-1-11
E5753IB
Display
Stays on when the repeat function is on. Stays on when the A-B repeat function is on. Stays on when the inserted disc is being played back. Lights up when a playback control is activated. Stays on when repeat title function is on. Stays on when repeat chapter function is on. Stays on when repeat track function is on. Lights up when a DVD is inserted on the tray. CD: Lights up when a CD is inserted on the tray. VCD: Lights up when a Video CD is inserted on the tray.
Lights up when the inserted disc comes to a pause.
Displays how long a current title or track has been played back. When a chapter or track has switched, the number of a new title, chapter or track is displayed.
Displays During Operation
Power on No disc inserted or playing DVD Menu Tray open Tray closed
Loading the Batteries
1. Open the battery compartment cover.
2. Insert two AA batteries, with each one oriented correctly.
3. Close the cover.
Loading the Disc
NOTES
Power off
Do not mix alkaline and manganese batteries. Do not mix old and new batteries.
1-1-12
E5753IB
Digital Signal Process Block Diagram ( DV-SL10W, DV-SL10, DV-SL10X, DV-SL10(RU) )
DATA(VIDEO/AUDIO) SIGNAL IC102 (SDRAM) VIDEO SIGNAL DATA(AUDIO) SIGNAL FOCUS SERVO SIGNAL IC101 (MICRO CONTROLLER)
BLOCK DIAGRAMS
*Note:
TRACKING SERVO SIGNAL
IC103 is not supplied separatery. Be sure to replace with the DVD Main CBA unit when servicing IC103.
SDRAM
60 66 2 13 31 56 74 85
~
235 2 13 184 205 247 256
124 125 122 123 128 129 126 127 131 130
~
24 27
SDRAM ADDRESS(0-10)
210
~
SDRAM ADDRESS(0-10)
EXTERNAL MEMORY I/F DATA ROM INST. ROM DATA ROM INST. ROM DATA ROM INST. ROM AUDIO I/F SERIAL INST. ROM DATA ROM READ MEMORY CPU I/F GENERAL I/O INTERRUPT CONTROLLER TIMER WATCH DOG TIMER VIDEO I/F NTSC/PAL ENCODER D/A D/A D/A
SDRAM DATA(0-31)
SDRAM DATA(0-31)
~
~
~
~
ECC
DECODER I/F
STREAM I/F
DSP DECODER
~
~
PIXEL OPERATION
DETECTOR
C D A B F E CD/DVD
CN201 6 7 8 5 10 2 9 Q253,Q254 CN201 12 AMP 14 AMP Q251,Q252 13 15 16 11
DMA RF SIGNAL PROCESS CIRCUIT DVD/CD FORMATTER I/O PROCESSOR
BCU
UMAC
SPDIF 181 PCM-BCK 175 PCM-DATA0 176 PCM-LRCLK 174
TO VIDEO /AUDIO BLOCK DIAGRAM
CD-LD DVD-LD PD-MONI GND(DVD-PD) GND(CD-PD) GND(LD)
135 133 132 134
32BIT CPU
D/A
Y C Cr Cb
158 164 161 160
VIDEO-Y VIDEO-C VIDEO-Cr VIDEO-Cb
INTERRUPT CONTROLLER 1 3 CD 4 DVD
TIMER
WATCH DOG TIMER
CPU I/F
TO VIDEO /AUDIO BLOCK DIAGRAM
BCU 6 78 CD/DVD
32BIT CPU
IC201 (SW)
DEBUG
INST CACHE
DATA CACHE
EXADT (0-15), EXADR (16-19)
TS FS FS(+) FS(-) TS(+) TS(-) CN201 18 19 20 17 FS(+) FS(-) TS(+) TS(-)
* IC103 (FLASH ROM)
EXADT (0-15)
EXADT (0-15), EXADR (16-19)
FROM SYSTEM CONTROL/SERVO BLOCK DIAGRAM IC105 (LATCH)
29 36 38 45
~
~
EXADT (0-7)
2 ~ 9
D TYPE LATCH IC104 (LATCH)
12 ~ 19
EXADR (0-7) EXADR (16-19)
FLASH ROM
PICK-UP UNIT
EXADT (8-15)
2 ~ 9
DVD MAIN CBA UNIT
1-2-1
D TYPE LATCH
12 ~ 19
EXADR (8-15)
EXADR (0-15)
1 9 16 25 48
1-2-2
~
~
E5754BLD
Video / Audio Block Diagram ( DV-SL10W, DV-SL10, DV-SL10X, DV-SL10(RU) )
VIDEO SIGNAL DATA(AUDIO) SIGNAL AUDIO SIGNAL
WF1 6 WF2 VIDEO-Y VIDEO-C VIDEO-Cb VIDEO-Cr CN601 5 7 3 1 CN1601 5 7 3 1 2
IC1402 (VIDEO DRIVER) 4dB AMP LPF 2dB AMP 2dB AMP 4dB AMP 4dB AMP 4dB AMP LPF 2dB AMP 2dB AMP 2dB AMP DRIVER DRIVER DRIVER 18 21 23 JK1404 DRIVER 15 COMPOSITE VIDEO OUT VIDEO-Y OUT VIDEO-Cb OUT VIDEO-Cr OUT Y WF3 3 1 2 4 C JK1401 S-VIDEO OUT
FROM DIGITAL SIGNAL PROCESS BLOCK DIAGRAM
VIDEO-Y VIDEO-C VIDEO-Cb VIDEO-Cr
9
LPF
11
LPF
DRIVER
13
DV-SL10X
IC1204 FIBER OPTIC TRANS MODULE
IC601 (AUDIO DAC) FROM DIGITAL SIGNAL PROCESS BLOCK DIAGRAM SPDIF PCM-BCK PCM-DATA0 PCM-LRCLK 1 2 3 SERIAL PORT 4X/8X OVERSAMPLING DIGITAL FILTER /FUNCTION CONTROLLER DAC LPF+AMP L-CH 7 Q1351 AMP IC1201 (AMP) 3 2 6 5 JK1404 1 AUDIO-L OUT JK1202 DIGITAL AUDIO OUT
ENHANCED MULTI-LEVEL DELTA-SIGMA MODULATOR
DAC
LPF+AMP
R-CH
8
ADAC-MD ADAC-MC ADAC-ML FROM/TO SYSTEM CONTROL /SERVO BLOCK DIAGRAM PCM-SCLK A-MUTE
ZERO DETECT 13 14 15 SERIAL CONTROL SYSTEM CLOCK
12 11
CN601 16 11 13 12 14 10
SPDIF AUDIO-L AUDIO-R A-L-MUTE A-R-MUTE A-MUTE
CN1601 16 11 13 12 14 10
WF6
WF4
WF5
7
AUDIO-R OUT
+5V Q1202
16
Q1204 Q1201 +3.3V Q1203
DVD MAIN CBA UNIT
1-2-3 1-2-4
+3.3V
AV CBA
E5754BLV
Power Supply Block Diagram ( DV-SL10W, DV-SL10, DV-SL10X, DV-SL10(RU) )
CAUTION ! Fixed voltage ( or Auto voltage selectable ) power supply circuit is used in this unit. If Main Fuse (F1001) is blown, check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply. Otherwise it may cause some components in the power supply circuit to fail.
CAUTION FOR CONTINUED PROTECTION AGAINST FIRE HAZARD, REPLACE ONLY WITH THE SAME TYPE FUSE.
NOTE : The voltage for parts in hot circuit is measured using hot GND as a common terminal.
HOT CIRCUIT. BE CAREFUL.
AC1001 AC CORD
F1001 L1001 T1.6A L 250V LINE FILTER
D1001, D1002 D1004, D1005 BRIDGE RECTIFIER
2
T1001
11
D1003 RECTIFIER D1006 SCHOTTKY BARRIER D1008 SCHOTTKY BARRIER D1030
14
IC1002 +1.5V REG. Q1010 Q1002 Q1012 Q1014
12
Q1003 SWITCHING CONTROL
Q1001 SWITCHING
4 13
-FL F1 F2 EV+3.3V P-ON+12V EV+5V P-ON+5V P-ON+3.3V
RECTIFIER
DV-SL10X Q1050
15
Q1011 J1003 Q1004
CN1001 1,2,3 4,5 14,15 13 17
FROM/TO CN401 EV+1.5V EV+3.3V EV+9V P-ON+5V P-ON+3.3V
16
D1016
7 17
Q1005 Q1015
RECTIFIER
6
18
Q1008 LATCH IC1001 ERROR VOLTAGE DET
4 1
FROM SYSTEM PWSW CONTROL/SERVO PWRCON BLOCK DIAGRAM
Q1016
DV-SL10W, DV-SL10, DV-SL10(RU)
HOT
AV CBA
1-2-5
3
2
Q1006 IC1006 REG (SHUNT REGULATOR)
1-2-6
E5754BLP
SCHEMATIC DIAGRAMS / CBA'S AND TEST POINTS
Standard Notes
WARNING
Many electrical and mechanical parts in this chassis have special characteristics. These characteristics often pass unnoticed and the protection afforded by them cannot necessarily be obtained by using replacement components rated for higher voltage, wattage, etc. Replacement parts that have these special safety characteristics are identified in this manual and its supplements; electrical components having such features are identified by the mark " ! " in the schematic diagram and the parts list. Before replacing any of these components, read the parts list in this manual carefully. The use of substitute replacement parts that do not have the same safety characteristics as specified in the parts list may create shock, fire, or other hazards. Notes: 1. Do not use the part number shown on these drawings for ordering. The correct part number is shown in the parts list, and may be slightly different or amended since these drawings were prepared. 2. All resistance values are indicated in ohms (K=103, M=106). 3. Resistor wattages are 1/4W or 1/6W unless otherwise specified. 4. All capacitance values are indicated in µF (P=10-6 µF). 5. All voltages are DC voltages unless otherwise specified. 6. Electrical parts such as capacitors, connectors, diodes, IC's, transistors, resistors, switches, and fuses are identified by four digits. The first two digits are not shown for each component. In each block of the diagram, there is a note such as shown below to indicate these abbreviated two digits.
Capacitor Temperature Markings
Mark (B) (F) (SR) (Z) Capacity Standard Temperature change rate temperature range ±10% +30 - 80% ±15% +30 - 80% 20°C 20°C 20°C 20°C -25~+85°C -25~+85°C -25~+85°C -10~+70°C
Capacitors and transistors are represented by the following symbols.
CBA Symbols
(Top View) (Bottom View) + Electrolytic Capacitor
Schematic Diagram Symbols
Digital Transistor
(Bottom View)
Transistor or Digital Transistor
E C B (Top View)
(Top View)
NPN Transistor
ECB ECB
PNP Transistor
(Top View)
(Top View)
NPN Digital Transistor
ECB ECB
PNP Digital Transistor
1-3-1
SC-FN2
LIST OF CAUTION, NOTES, AND SYMBOLS USED IN THE SCHEMATIC DIAGRAMS ON THE FOLLOWING PAGES: 1. CAUTION: FOR CONTINUED PROTECTION AGAINST FIRE HAZARD, REPLACE ONLY WITH THE SAME TYPE FUSE. 2. CAUTION: Fixed Voltage (or Auto voltage selectable) power supply circuit is used in this unit. If Main Fuse (F1001) is blown, first check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply. Otherwise it may cause some components in the power supply circuit to fail. 3. Note: (1) Do not use the part number shown on the drawings for ordering. The correct part number is shown in the parts list, and may be slightly different or amended since the drawings were prepared. (2) To maintain original function and reliability of repaired units, use only original replacement parts which are listed with their part numbers in the parts list section of the service manual. 4. Wire Connectors (1) Prefix symbol "CN" means "connector" (can disconnect and reconnect). (2) Prefix symbol "CL" means "wire-solder holes of the PCB" (wire is soldered directly). 5. Voltage indications for PLAY modes on the schematics are as shown below: PLAY mode 1 2 3 Unit: Volts 5.0 5.0
Indicates that the voltage is not consistent here.
6. How to read converged lines
1-D3 Distinction Area Line Number (1 to 3 digits) Examples: 1. "1-D3" means that line number "1" goes to area "D3". 2. "1-B1" means that line number "1" goes to area "B1".
3 AREA D3 2 1 A
1-B1
AREA B1 1-D3 B C D
7. Test Point Information : Indicates a test point with a jumper wire across a hole in the PCB. : Used to indicate a test point with a component lead on foil side. : Used to indicate a test point with no test pin. : Used to indicate a test point with a test pin.
1-3-2
SC-FN2
DVD Main 2/3 Schematic Diagram (DV-SL10W, DV-SL10, DV-SL10X, DV-SL10(RU))
1-3-3
1-3-4
E5754SCD2
DVD Main 3/3 Schematic Diagram (DV-SL10W, DV-SL10, DV-SL10X, DV-SL10(RU)) * Note:
IC103 is not supplied separately. Be sure to replace with the DVD Main CBA unit when servicing IC103.
DVD MAIN 3/3 Ref No. Position ICS IC102 O-4 IC103 O-3 IC104 N-3 IC105 N-1 IC451 P-3 IC601 Q-1 CONNECTOR CN601 R-1
1-3-5
1-3-6
E5754SCD3
AV 1/3 Schematic Diagram (DV-SL10W, DV-SL10, DV-SL10X, DV-SL10(RU))
CAUTION ! Fixed voltage ( or Auto voltage selectable ) power supply circuit is used in this unit. If Main Fuse (F1001) is blown, check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply. Otherwise it may cause some components in the power supply circuit to fail.
CAUTION FOR CONTINUED PROTECTION AGAINST FIRE HAZARD, REPLACE ONLY WITH THE SAME TYPE FUSE.
NOTE : The voltage for parts in hot circuit is measured using hot GND as a common terminal.
AV 1/3 Ref No. ICS
Position
IC1001 B-1 IC1002 D-4 IC1006 C-1 TRANSISTORS Q1001 B-3 Q1002 D-3 Q1003 B-2 Q1004 E-3 Q1005 D-2 Q1006 D-1 Q1008 A-1 Q1010 D-2 Q1011 D-1 Q1012 D-2 Q1014 E-3 Q1015 D-2 Q1016 E-2 Q1050 D-3 CONNECTOR CN1001 F-4
1-3-7
1-3-8
E5754SCAV1
AV 2/3 Schematic Diagram (DV-SL10W, DV-SL10, DV-SL10X, DV-SL10(RU))
AV 2/3 Ref No. ICS
Position
IC1201 H-1 IC1402 I-3 TRANSISTORS Q1201 J-1 Q1202 J-1 Q1203 I-2 Q1204 I-1 Q1351 K-4 Q1352 H-2 CONNECTOR CN1601 G-3
1-3-9
1-3-10
E5754SCAV2
AV 3/3 & Function Schematic Diagram (DV-SL10W, DV-SL10, DV-SL10X, DV-SL10(RU))
FL2001 MATRIX CHART
7G
7G 6G 5G 4G 3G 2G 1G
6G a b c d e f g
5G a b c d e f g
4G a b c d e f g
3G a b c d e f
2G a b c d e f
1G
a
1 3 5 2 4
STANDBY REPEAT
1 2 3 4 5
STANDBY REPEAT A-B
TITLE
CHP.
c f
TRK.
a d g b e
DVD VCD PBC
b c d e f g h i
A -B
TITLE
DVD PBC CHP. TRK. CD V
g g
AV 3/3 Ref No. ICS
Position
IC2001 O-3 IC2002 P-2 TRANSISTOR Q2007 P-2 CONNECTOR JP2001 P-3
1-3-11
1-3-12
E5754SCAV3
AV CBA Top View (DV-SL10W, DV-SL10, DV-SL10X, DV-SL10(RU))
CAUTION ! Fixed voltage ( or Auto voltage selectable ) power supply circuit is used in this unit. If Main Fuse (F1001) is blown, check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply. Otherwise it may cause some components in the power supply circuit to fail. NOTE : The voltage for parts in hot circuit is measured using hot GND as a common terminal.
CAUTION FOR CONTINUED PROTECTION AGAINST FIRE HAZARD, REPLACE ONLY WITH THE SAME TYPE FUSE.
AV CBA Ref No. ICS IC1001 IC1002 IC1006 IC1201 IC1204 IC1402
Position C-2 B-2 C-2 D-3 E-2 E-4
IC2001 A-2 IC2002 C-3 TRANSISTORS Q1001 Q1002 Q1003 Q1004 Q1005 Q1006 Q1008 Q1010 C-1 B-1 D-2 B-2 A-1 A-1 D-2 A-1
Q1011 A-1 Q1012 A-1 Q1014 B-2 Q1015 A-1 Q1016 A-1 Q1050 B-1 Q1201 E-3 Q1202 E-3 Q1203 E-3 Q1204 E-3 Q1351 E-2 Q1352 D-2 Q2007 C-3 CONNECTORS CN1001 CN1601 JP2001 B-4 D-4 A-4
1-3-13
1-3-14
BE5716F01011
AV CBA Bottom View (DV-SL10W, DV-SL10, DV-SL10X, DV-SL10(RU))
WF3 PIN 21 OF IC1402 WF1 WF2 WF4 WF5 WF6 PIN 5 OF PIN 7 OF PIN 11 OF PIN 13 OF PIN 16 OF CN1601 CN1601 CN1601 CN1601 CN1601
CAUTION ! Fixed voltage ( or Auto voltage selectable ) power supply circuit is used in this unit. If Main Fuse (F1001) is blown, check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply. Otherwise it may cause some components in the power supply circuit to fail. CAUTION FOR CONTINUED PROTECTION AGAINST FIRE HAZARD, REPLACE ONLY WITH THE SAME TYPE FUSE. NOTE : The voltage for parts in hot circuit is measured using hot GND as a common terminal.
1-3-15
1-3-16
BE5716F01011
FUNCTION CBA Top View (DV-SL10W, DV-SL10, DV-SL10X, DV-SL10(RU))
FUNCTION CBA Bottom View (DV-SL10W, DV-SL10, DV-SL10X, DV-SL10(RU))
1-3-17
1-3-18
BE5716F01011
WAVEFORMS ( DV-SL10W, DV-SL10, DV-SL10X, DV-SL10(RU) )
WF1
Pin 5 of CN1601
WF5
Pin 13 of CN1601
NOTE:
VIDEO-Y
0.2V
20µsec
AUDIO-R
1V
0.5msec
Input CD: 1kHz PLAY (WF4~WF6) DVD: POWER ON (STOP) MODE (WF1~WF3)
WF2
Pin 7 of CN1601
WF6
Pin 16 of CN1601
VIDEO-C
0.2V
20µsec
SPDIF
1V
0.1µsec
WF3
Pin 21 of IC1402
VIDEO-CVBS
0.5V
20µsec
WF4
Pin 11 of CN1601
AUDIO-L
1V
0.5msec
1-4-1
1-4-2
E5754WF
FG SENSOR
VIDEO-Y VIDEO-Cb VIDEO-Cr VIDEO OUT OUT OUT OUT
FG CBA
TRAY-OUT
TRAY-IN
AUDIO-L AUDIO-R OUT OUT
1-5-1
CN301
DRIVE CBA
CN1001 CN401 SLED MOTOR M SPINDLE MOTOR M
1 2 3 4 5 6 7 8 9 FG-IN P-ON+3.3V(D) SP(+) SP(-) TRAY-OUT TRAY-IN GND SL(-) SL(+)
DV-SL10X
DIGITAL AUDIO OUT
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22
W1001 EV+1.5V EV+1.5V EV+1.5V EV+3.3V EV+3.3V GND GND GND GND GND GND GND P-ON+5V EV+9V EV+9V FP-STB P-ON+3.3V FP-DIN PWRCON FP-DOUT FP-CLK REMOTE 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22
S-VIDEO OUT
OPTICAL AUDIO OUT
AV CBA (BE5716F01011)
WIRING DIAGRAM ( DV-SL10W, DV-SL10, DV-SL10X, DV-SL10(RU) )
DVD MECHA
11 2 3 5 6 4 7 DETECTOR CN201
DVD MAIN CBA UNIT
CN601 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16
AC CORD
CN1601
W1601 VIDEO-Cr GND VIDEO-Cb GND VIDEO-Y GND VIDEO-C GND GND A-MUTE AUDIO-L A-L-MUTE AUDIO-R A-R-MUTE AUDIO+5V SPDIF
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16
PICK UP UNIT
TS FS
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
GND E P-ON+5V VREF B C D A CD/DVD F GND(LD) CD-LD PD-MONI DVD-LD GND(DVD-PD) GND(CD-PD) TS(-) FS(+) FS(-) TS(+)
1-5-2 E5754WI
JP2001 1 2 3 4 5 6 7 8 K2 KEY-2 NU NU KEY-4 KEY-3 KEY-1 K1 JP2002 1 2 3 4 FUNCTION CBA (BE5716F01011) 5 6 7 8
LEAD IDENTIFICATIONS
2SA1015-Y (TPE2) KTA1266 (Y) KTC3198 (Y) 2SC2120-Y(TPE2) KTC3205 (Y) 2SC2236-Y-TPE6,C 2SA966(Y) 2SC2785 (H) KTC3199 (GR) KRA110M KTA1267 (Y) BN1L3Z (P) 2SK3566
E C B
E C B
G D S
MM1567AJ 34 18
PT6313-S-TP 28 15
MM1622XJBE 24 13
KIA431-AT
1
17
1
14
1
12 K A R
M34506M4-504FP 20 11
PQ070XF01SZ LTV-817(B,C)-F A 1: Vin 2: Vo 3: GND 4: Vc K C
E
1
10
1 2 34
0C-0805T*002 GP1FA513TZ
NJM4558D KIA4558P 8 5
1 1 2 3
4
Note: A: Anode K: Cathode E: Emitter C: Collector B: Base R: Reference G: Gate D: Drain S: Source
1-6-1
E5753LE
EXPLODED VIEWS
Cabinet
2L011 2L011
[D]
JK1404
2L011
JK1401
JK1202
IC1204
Comparison Chart of Models and Marks Model DV-SL10S(G) DV-SL10W DV-SL10 DV-SL10X DV-SL10S(Q) DV-SL10S(S) DV-SL10(RU) Mark A B C D E F G
2L105
A16 2L011
[ B,C,G ]
JK1404 JK1401 JK1202 DVD Main CBA Unit
W1601 2L031 2L011
[ A,E,F ]
JK1404 JK1401 JK1402 F1001
W1001 2L042 2B11
2L031
FUNCTION CBA
A2
2L021
[ B,C,G ]
2L101 2L021 2L031
AV CBA
1B1 2L021 2B3 A21
[D]
AC1001
See Electrical Parts List for parts with this mark. Some Ref. Numbers are not in sequence.
2L071 A17
2L041
[ B,C,G ]
[ A,E,F ]
A13
2B23
A1X
A13 A15
[ B,C,D,G ]
1-7-1
E5753EX
Packing
[ B,C,D,G ]
X5 X2 X10
Some Ref. Numbers are not in sequence.
X4 S2 X1
S4 S8
Unit
S2
Comparison Chart of Models and Marks Model DV-SL10S(G) DV-SL10W DV-SL10 DV-SL10X DV-SL10S(Q) DV-SL10S(S) DV-SL10(RU) Mark A B C D E F G
S5 A22 S1 A30
1-7-2
E5753EX
DIFFERENT PARTS FROM ORIGINAL MODEL (DV-SL10H)
PRODUCT SAFETY NOTE: Products marked with a ! have special characteristics important to safety. Before replacing any of these components, read carefully the product safety notice in this service manual. Don't degrade the safety of the product through improper servicing. NOTES: 1. Parts that not assigned part numbers (---------) are not available. 2. Tolerance of Capacitors and Resistors are noted with the following symbols. C.....±0.25% M.....±20% D.....±0.5% N.....±30% F.....±1% Z.....+80/-20% G.....±2% J......±5% K.....±10%
DV-SL10S(G)
Ref. No. A21! A22 A30 S1 S2 X10! X17 Description LABEL, RATING E5753ED LABEL, BAR CODE E5753ED CASE MARK LABEL E5753ED GIFT BOX CARTON E5753ED STYROFOAM E57S0UD OWNER'S MANUAL E5753ED Not Used Part No. ---------------------------9HS0VM306277 9HS0VM101231 9HS0VMN03661 Code ------AV AE AH
DV-SL10W
Ref. No. Description Part No. 9HS0VM415311 9HS0VM204230 ---------------------------9HS0VM306332 9HSX1E56B5-001 9HS0VMN03662 Code AE AK ------AN AL AG Mechanical Parts 2B23 SHEET, INSULATOR E57S7RD A17 REAR PANEL E5754HD A21! LABEL, RATING E5754HD A22 LABEL, BAR CODE E5754HD A30 CASE MARK LABEL E5754HD S1 GIFT BOX CARTON E5754HD X5 AV CORD X10! OWNER'S MANUAL E5754HD X17 Not used Electrical Parts DVD MAIN CBA UNIT CN601 FFC/FPC CONNECTOR, 16P 04 6232 116 103 800 CN601 FFC/FPC CONNECTOR, 16P 10008HR-16 IC102 IC(SDRM) P2V64S50DTP-75 IC102 IC(SDRM) 2X32Y3VTW-6 L616 CHIP BEAD MMZ1608Y121CT R608 Not Used AV CBA ASSEMBLY AV CBA FUNCTION CBA AV CBA HEATSINK E5717QD SCREW, S-TIGHT M3X8 BIND + CHROME ELECTROLYTIC CAP. 100µF/400V M ELECTOLYTIC CAP. 1000µF/6.3V M(105C) Not used Not used ELECTROLYTIC CAP. 470µF/16V M(105C) Not used
9HSN79SFGHP 9HSC62D16TM003 9HSCHRD16YEE02 9HSSZBA0R0M002 9HSSZBA0R3S001 9HSL06001TE004
AE --AZ AX ---
9HS0VSA14186 9HS0VSA14186A 9HS0VSA14186B 9HS0VSA14186A 9HS0VM415264 9HSGBMS3080 9HSA2H101NC084 9HSE0KMASDH102
BW ------AD -------
2B11 2L042 C1004 C1007 C1010 C1017 C1035 C1070
9HSE1CMASTH471
---
1-8-1
E5753PL
Ref. No. C1486 C1487 C1491 C1492 C1533 C1434 C1435 CN1601 CN1601 CN2101 D1070 D1070 D1072 D1073 D1073 D1074 D1075 D1201 D1202 D1203 D1204 D1401 D1402 D1501 D1502 D1503 D1504 D1505 D1506 D1507 IC1401 IC1402 JK1202 JK1402 JK1404 JP2001 L1405 L1441 L1461 L1462 L1481 L1482 L1492 L1522 L1522A Q1003 Q1003 Q1003 Q1050 Q1521 Q1522 R1005 R1006 R1008 R1011 R1011 R1015 R1016 R1023 R1023
Description Not used Not used Not used Not used CHIP CERAMIC CAP. F Z 0.1µF/50V Not used Not used FMN CONNECTOR, TOP 16P 16FMN-BTK FFC/FPC CONNECTOR, 16P 00 6232 016 000 800 Not used ZENER DIODE DZ-33BSDT265 ZENER DIODE MTZJT-7733D Not used SWITCHING DIODE 1N4148M SWITCHING DIODE 1SS133(T-77) Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used DRIVER FOR DVD MM1622XJBE RCA JACK(BLACK) MSP-251V-01 NI Not used RCA JACK MSD-246V-65NI/PBSN PARALLEL WIRE (8P)250MM WX1E57S0-003 Not used CHIP BEAD MMZ1608Y121CT CHIP BEAD MMZ1608Y121CT Not used CHIP BEAD MMZ1608Y121CT Not used Not used CHIP BEAD MMZ1608R102CT Not used TRANSISTOR KTC3199(BL) TRANSISTOR 2SC2785(K) TRANSISTOR 2SC1815-BL(TPE2) Not used Not used Not used CARBON RES. 1/4W J 2.7M CARBON RES. 1/4W J 2.7M CARBON RES. 1/4W J 910 METAL OXIDE FILM RES. 1W J 1.8 METAL OXIDE FILM RES. 1W J 1.8 Not used Not used CHIP RES. 1/16W F 3.9k CHIP RES.(1608) 1/10W F 3.9k
Part No.
Code
9HSHD1JZ30F104
---
9HSCFNG16JG001 9HSC62G16TM009 9HSDTD00DZ33BS 9HSDTD00MTZJ33 9HSDTZ01N4148M 9HSDTZ001SS133
AD -----------
9HSSZBA0TMM085 9HSXRL010LY070 9HSXRL060LY069 9HSX1E57S0-003 9HSL06001TE004 9HSL06001TE004 9HSL06001TE004
AL AC AG AF -------
9HSL06001TE002 9HSQS50KTC3199 9HSQSK02SC2785 9HSQS202SC1815
---------
9HSCX4JATZ0275 9HSCX4JATZ0275 9HSCX4JATZ0911 9HSN011R8ZU001 9HSN011R8KE009
-----------
9HSRXGFR5Z0392 9HSRXAFR5Z3901
-----
1-8-2
E5753PL
Ref. No. R1029 R1034 R1072 R1074 R1096 R1096 R1097 R1098 R1256 R1257 R1371 R1405 R1443 R1462 R1463 R1482 R1483 R1491 R1492 R1522 R1523 R1524 R1525 R1526 R1530 R1531 R1558 R1613 R1614 T1001! W1601 W2101
Description CARBON RES. 1/4W J 470k PCB JUMPER D0.6-P5.0 CHIP RES.(1608) 1/10W J 1k RECTIFIER DIODE 1N4005 METAL OXIDE FILM RES. 2W J 150k METAL OXIDE FILM RES. 2W J 150k Not used Not used Not used Not used CHIP RES.(1608) 1/10W 0 Not used CHIP RES.(1608) 1/10W J 75 CHIP RES.(1608) 1/10W J 75 Not used CHIP RES.(1608) 1/10W J 75 Not used Not used Not used Not used CHIP BEAD MMZ1608Y121CT CHIP INDUCTOR BK1608HS121-T CHIP INDUCTOR BK1608HS121-T Not used Not used Not used Not used CHIP RES.(1608) 1/10W J 2.2k Not used POWER TRANSFORMER CSA-SW0308A 16P FFC Not used FUNCTION CBA PCB JUMPER D0.6-P6.5
Part No. 9HSCX4JATZ0474 9HSJW5.0T 9HSRXAJR5Z0102 9HSDQZ001N4005 9HSN02154ZU001 9HSN02154KE010
Code -------------
9HSRXAZR5Z0000 9HSRXAJR5Z0750 9HSRXAJR5Z0750 9HSRXAJR5Z0750
---------
9HSL06001TE004 9HSLC121NTU017 9HSLC121NTU017
-------
9HSRXAJR5Z0222 9HSTT00ZPSA144 9HSX1E57S0-001
--AH AF
SW2007
9HS0VSA14186B 9HSJW6.5T
-----
DV-SL10
Ref. No. Description Part No. 9HS0VM415311 9HS0VM204230 ---------------------------9HS0VM306333 9HS0VM101231 9HSX1E56B5-001 9HS0VMN03662 Code AE AK ------AM AE AL AG Mechanical Parts 2B23 SHEET, INSULATOR E57S7RD A17 REAR PANEL E5754HD A21! LABEL, RATING E5755PD A22 LABEL, BAR CODE E5755PD A30 CASE MARK LABEL E5755PD S1 GIFT BOX CARTON E5755PD S2 STYROFOAM E57S0UD X5 AV CORD X10! OWNER'S MANUAL E5754HD X17 Not used Electrical Parts DVD MAIN CBA UNIT CN601 FFC/FPC CONNECTOR, 16P 04 6232 116 103 800 CN601 FFC/FPC CONNECTOR, 16P 10008HR-16 IC102 IC(SDRM) P2V64S50DTP-75 IC102 IC(SDRM) 2X32Y3VTW-6 L616 CHIP BEAD MMZ1608Y121CT R608 Not Used AV CBA ASSEMBLY
9HSN79SFGHP 9HSC62D16TM003 9HSCHRD16YEE02 9HSSZBA0R0M002 9HSSZBA0R3S001 9HSL06001TE004
AE --AZ AX ---
9HS0VSA14189
BW
1-8-3
E5753PL
Ref. No. AV CBA FUNCTION CBA
Description
Part No. 9HS0VSA14189A 9HS0VSA14189B 9HS0VSA14189A 9HSAE0162LW001 9HS0VM415264 9HSGBMS3080 9HSA2H101NC084 9HSE0KMASDH102
Code ------AG AD -------
AC1001! 2B11 2L042 C1004 C1007 C1010 C1017 C1035 C1070 C1486 C1487 C1491 C1492 C1533 C1434 C1435 CN1601 CN1601 CN2101 D1070 D1070 D1072 D1073 D1073 D1074 D1075 D1201 D1202 D1203 D1204 D1401 D1402 D1501 D1502 D1503 D1504 D1505 D1506 D1507 IC1401 IC1402 JK1202 JK1402 JK1404 JP2001 L1405 L1441 L1461 L1462 L1481 L1482 L1492 L1522 L1522A Q1003 Q1003
AV CBA AC CORD PE8G2CG9G0A-055 HEATSINK E5717QD SCREW, S-TIGHT M3X8 BIND + CHROME ELECTROLYTIC CAP. 100µF/400V M ELECTOLYTIC CAP. 1000µF/6.3V M(105C) Not used Not used ELECTROLYTIC CAP. 470µF/16V M(105C) Not used Not used Not used Not used Not used CHIP CERAMIC CAP. F Z 0.1µF/50V Not used Not used FMN CONNECTOR, TOP 16P 16FMN-BTK FFC/FPC CONNECTOR, 16P 00 6232 016 000 800 Not used ZENER DIODE DZ-33BSDT265 ZENER DIODE MTZJT-7733D Not used SWITCHING DIODE 1N4148M SWITCHING DIODE 1SS133(T-77) Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used DRIVER FOR DVD MM1622XJBE RCA JACK(BLACK) MSP-251V-01 NI Not used RCA JACK MSD-246V-65NI/PBSN PARALLEL WIRE (8P)250MM WX1E57S0-003 Not used CHIP BEAD MMZ1608Y121CT CHIP BEAD MMZ1608Y121CT Not used CHIP BEAD MMZ1608Y121CT Not used Not used CHIP BEAD MMZ1608R102CT Not used TRANSISTOR KTC3199(BL) TRANSISTOR 2SC2785(K)
9HSE1CMASTH471
---
9HSHD1JZ30F104
---
9HSCFNG16JG001 9HSC62G16TM009 9HSDTD00DZ33BS 9HSDTD00MTZJ33 9HSDTZ01N4148M 9HSDTZ001SS133
AD -----------
9HSSZBA0TMM085 9HSXRL010LY070 9HSXRL060LY069 9HSX1E57S0-003 9HSL06001TE004 9HSL06001TE004 9HSL06001TE004
AL AC AG AF -------
9HSL06001TE002 9HSQS50KTC3199 9HSQSK02SC2785
-------
1-8-4
E5753PL
Ref. No. Q1003 Q1050 Q1521 Q1522 R1005 R1006 R1008 R1011 R1011 R1015 R1016 R1023 R1023 R1029 R1034 R1072 R1074 R1096 R1096 R1097 R1098 R1256 R1257 R1371 R1405 R1443 R1462 R1463 R1482 R1483 R1491 R1492 R1522 R1523 R1524 R1525 R1526 R1530 R1531 R1558 R1613 R1614 T1001! W1601 W2101
Description TRANSISTOR 2SC1815-BL(TPE2) Not used Not used Not used CARBON RES. 1/4W J 2.7M CARBON RES. 1/4W J 2.7M CARBON RES. 1/4W J 910 METAL OXIDE FILM RES. 1W J 1.8 METAL OXIDE FILM RES. 1W J 1.8 Not used Not used CHIP RES. 1/16W F 3.9k CHIP RES.(1608) 1/10W F 3.9k CARBON RES. 1/4W J 470k PCB JUMPER D0.6-P5.0 CHIP RES.(1608) 1/10W J 1k RECTIFIER DIODE 1N4005 METAL OXIDE FILM RES. 2W J 150k METAL OXIDE FILM RES. 2W J 150k Not used Not used Not used Not used CHIP RES.(1608) 1/10W 0 Not used CHIP RES.(1608) 1/10W J 75 CHIP RES.(1608) 1/10W J 75 Not used CHIP RES.(1608) 1/10W J 75 Not used Not used Not used Not used CHIP BEAD MMZ1608Y121CT CHIP INDUCTOR BK1608HS121-T CHIP INDUCTOR BK1608HS121-T Not used Not used Not used Not used CHIP RES.(1608) 1/10W J 2.2k Not used POWER TRANSFORMER CSA-SW0308A 16P FFC Not used FUNCTION CBA PCB JUMPER D0.6-P6.5
Part No. 9HSQS202SC1815
Code ---
9HSCX4JATZ0275 9HSCX4JATZ0275 9HSCX4JATZ0911 9HSN011R8ZU001 9HSN011R8KE009
-----------
9HSRXGFR5Z0392 9HSRXAFR5Z3901 9HSCX4JATZ0474 9HSJW5.0T 9HSRXAJR5Z0102 9HSDQZ001N4005 9HSN02154ZU001 9HSN02154KE010
-----------------
9HSRXAZR5Z0000 9HSRXAJR5Z0750 9HSRXAJR5Z0750 9HSRXAJR5Z0750
---------
9HSL06001TE004 9HSLC121NTU017 9HSLC121NTU017
-------
9HSRXAJR5Z0222 9HSTT00ZPSA144 9HSX1E57S0-001
--AH AF
SW2007
9HS0VSA14186B 9HSJW6.5T
-----
DV-SL10X
Ref. No. Mechanical Parts 2B23 SHEET, INSULATOR E57S7RD A17 REAR PANEL E5756AD A21! LABEL, RATING E5756AD A22 LABEL, BAR CODE E5756AD A30 CASE MARK LABEL E5756AD S1 GIFT BOX CARTON E5756AD S2 STYROFOAM E5714BD Description Part No. 9HS0VM415311 9HS0VM204231 ---------------------------9HS0VM306334 9HS0VM101289 Code AE AR ------AV AE
1-8-5
E5753PL
Ref. No.
Description
Part No. 9HSX1E56B5-001 9HS0VMN03664
Code AL AH
X5 AV CORD X10! OWNER'S MANUAL E5756AD X17 Not used Electrical Parts DVD MAIN CBA UNIT CN601 FFC/FPC CONNECTOR, 16P 04 6232 116 103 800 CN601 FFC/FPC CONNECTOR, 16P 10008HR-16 IC102 IC(SDRM) P2V64S50DTP-75 IC102 IC(SDRM) 2X32Y3VTW-6 L616 CHIP BEAD MMZ1608Y121CT R608 Not Used AV CBA ASSEMBLY AV CBA FUNCTION CBA AV CBA AC CORD PS8B5S4980A-065 ELECTROLYTIC CAP. 33µF/400V M(L·Z) ELECTROLYTIC CAP. 33µF/400V M ELECTROLYTIC CAP. 33µF/400V M(105C) ELECTOLYTIC CAP. 1000µF/6.3V M(105C) CERAMIC CAP.(AX) CH J 560PF/50V Not used ELECTROLYTIC CAP. 470µF/16V M(105C) CHIP CERAMIC CAP. F Z 0.1µF/50V ELECTROLYTIC CAP. 22µF/6.3V M CHIP CERAMIC CAP. F Z 0.1µF/50V Not used Not used Not used Not used CHIP CERAMIC CAP. F Z 0.1µF/50V Not used Not used FMN CONNECTOR, TOP 16P 16FMN-BTK FFC/FPC CONNECTOR, 16P 00 6232 016 000 800 Not used ZENER DIODE DZ-10BSBT265 ZENER DIODE MTZJT-7710B PCB JUMPER D0.6-P5.0 Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used FIBER OPTIC TRANS.MODULE 0C-0805T*002 FIBER OPTIC TRANS.MODULE GP1FA513TZ Not used DRIVER FOR DVD MM1622XJBE
9HSN79SGGAP 9HSC62D16TM003 9HSCHRD16YEE02 9HSSZBA0R0M002 9HSSZBA0R3S001 9HSL06001TE004
AE --AZ AX ---
9HS0VSA14247 9HS0VSA14247A 9HS0VSA14247B 9HS0VSA14247A 9HSAA0192LW006 9HSE2HMZATH330 9HSA2H330S6021 9HSA2H330NC162 9HSE0KMASDH102 9HSA1J561TU008 9HSE1CMASTH471 9HSHD1JZ30F104 9HSE0KMASDL220 9HSHD1JZ30F104
BW ------AE -------------------
AC1001! C1004 C1004 C1004 C1007 C1010 C1017 C1035 C1070 C1361 C1362 C1486 C1487 C1491 C1492 C1533 C1434 C1435 CN1601 CN1601 CN2101 D1072 D1072 D1073 D1074 D1075 D1201 D1202 D1203 D1204 D1401 D1402 D1501 D1502 D1503 D1504 D1505 D1506 D1507 IC1204 IC1204 IC1401 IC1402
9HSHD1JZ30F104
---
9HSCFNG16JG001 9HSC62G16TM009 9HSDTB00DZ10BS 9HSDTB00MTZJ10 9HSJW5.0T
AD ---------
9HSWHHA00JD002 9HSWHHA00SH005 9HSSZBA0TMM085
AL AK AL
1-8-6
E5753PL
Ref. No. JK1202 JK1402 JK1404 JP2001 L1405 L1441 L1461 L1462 L1481 L1482 L1492 L1522 L1522A Q1003 Q1003 Q1521 Q1522 R1011 R1011 R1023 R1023 R1029 R1072 R1074 R1095 R1256 R1257 R1361 R1366 R1371 R1405 R1443 R1462 R1463 R1482 R1483 R1491 R1492 R1522 R1523 R1524 R1525 R1526 R1530 R1531 R1558 R1613 R1614 W1601 W2101
Description RCA JACK(BLACK) MSP-251V-01 NI Not used RCA JACK MSD-246V-65NI/PBSN PARALLEL WIRE (8P)250MM WX1E57S0-003 Not used CHIP BEAD MMZ1608Y121CT CHIP BEAD MMZ1608Y121CT Not used CHIP BEAD MMZ1608Y121CT Not used Not used CHIP BEAD MMZ1608R102CT Not used TRANSISTOR KTC3199(GR) TRANSISTOR 2SC2785(H) Not used Not used METAL OXIDE FILM RES. 1W J 2.2 METAL OXIDE FILM RES. 1W J 2.2 CHIP RES. 1/16W F 3.9k CHIP RES.(1608) 1/10W F 3.9k CARBON RES. 1/4W J 390k CHIP RES.(1608) 1/10W J 1k RECTIFIER DIODE 1N4005 CARBON RES. 1/4W J 1.5M Not used Not used CHIP RES.(1608) 1/10W 0 CHIP RES.(1608) 1/10W 0 CHIP RES.(1608) 1/10W 0 Not used CHIP RES.(1608) 1/10W J 75 CHIP RES.(1608) 1/10W J 75 Not used CHIP RES.(1608) 1/10W J 75 Not used Not used Not used Not used CHIP BEAD MMZ1608Y121CT CHIP INDUCTOR BK1608HS121-T CHIP INDUCTOR BK1608HS121-T Not used Not used Not used Not used CHIP RES.(1608) 1/10W J 2.2k Not used 16P FFC Not used FUNCTION CBA PCB JUMPER D0.6-P6.5
Part No. 9HSXRL010LY070 9HSXRL060LY069 9HSX1E57S0-003 9HSL06001TE004 9HSL06001TE004 9HSL06001TE004
Code AC AG AF -------
9HSL06001TE002 9HSQS10KTC3199 9HSQSH02SC2785
-------
9HSN012R2ZU001 9HSN012R2KE009 9HSRXGFR5Z0392 9HSRXAFR5Z3901 9HSCX4JATZ0394 9HSRXAJR5Z0102 9HSDQZ001N4005 9HSCX4JATZ0155
-----------------
9HSRXAZR5Z0000 9HSRXAZR5Z0000 9HSRXAZR5Z0000 9HSRXAJR5Z0750 9HSRXAJR5Z0750 9HSRXAJR5Z0750
-------------
9HSL06001TE004 9HSLC121NTU017 9HSLC121NTU017
-------
9HSRXAJR5Z0222 9HSX1E57S0-001
--AF
SW2007
9HS0VSA14186B 9HSJW6.5T
-----
1-8-7
E5753PL
DV-SL10S(Q)
Ref. No. Mechanical Parts A21! LABEL, RATING E5758FD A22 LABEL, BAR CODE E5758FD A30 CASE MARK LABEL E5758FD S1 GIFT BOX CARTON E5753ED S2 STYROFOAM E57S0UD X10! OWNER'S MANUAL E5758FD X17 Not used Electrical Parts AV CBA ASSEMBLY AV CBA FUNCTION CBA AV CBA AC CORD PE8G2CG9G0A-055 Description Part No. ---------------------------9HS0VM306277 9HS0VM101231 9HS0VMN03703 Code ------AV AE AG
9HS0VSA14106 9HS0VSA14106A 9HS0VSA14106B 9HS0VSA14106A 9HSAE0162LW001
BW ------AG
AC1001!
DV-SL10S(S)
Ref. No. Mechanical Parts A21! LABEL, RATING E57B2ED A22 LABEL, BAR CODE E57B2ED A30 CASE MARK LABEL E57B2ED S1 GIFT BOX CARTON E5753ED S2 STYROFOAM E57S0UD X10! OWNER'S MANUAL E57B2ED X17 Not used Electrical Parts AV CBA ASSEMBLY AV CBA FUNCTION CBA AV CBA AC CORD PE8G2CG9G0A-055 Description Part No. ---------------------------9HS0VM306277 9HS0VM101231 9HS0VMN03706 Code ------AV AE AG
9HS0VSA14106 9HS0VSA14106A 9HS0VSA14106B 9HS0VSA14106A 9HSAE0162LW001
BW ------AG
AC1001!
DV-SL10(RU)
Ref. No. Description Part No. 9HS0VM415311 9HS0VM204232 ---------------------------9HS0VM306336 9HS0VM101231 9HSX1E56B5-001 9HS0VMN03709 Code AE AR ------AV AE AL AH Mechanical Parts 2B23 SHEET, INSULATOR E57S7RD A17 REAR PANEL E57B5RD A21! LABEL, RATING E57B5RD A22 LABEL, BAR CODE E57B5RD A30 CASE MARK LABEL E57B5RD S1 GIFT BOX CARTON E57B5RD S2 STYROFOAM E57S0UD X5 AV CORD X10! OWNER'S MANUAL E57B5RD X17 Not used Electrical Parts DVD MAIN CBA UNIT CN601 FFC/FPC CONNECTOR, 16P 04 6232 116 103 800 CN601 FFC/FPC CONNECTOR, 16P 10008HR-16 IC102 IC(SDRM) P2V64S50DTP-75 IC102 IC(SDRM) 2X32Y3VTW-6 L616 CHIP BEAD MMZ1608Y121CT R608 Not Used
9HSN79SHGRP 9HSC62D16TM003 9HSCHRD16YEE02 9HSSZBA0R0M002 9HSSZBA0R3S001 9HSL06001TE004
AE --AZ AX ---
1-8-8
E5753PL
Ref. No. AV CBA ASSEMBLY AV CBA FUNCTION CBA
Description
Part No. 9HS0VSA14189 9HS0VSA14189A 9HS0VSA14189B 9HS0VSA14189A 9HSAE0162LW001 9HS0VM415264 9HSGBMS3080 9HSA2H101NC084 9HSE0KMASDH102
Code BW ------AG AD -------
AC1001! 2B11 2L042 C1004 C1007 C1010 C1017 C1035 C1070 C1486 C1487 C1491 C1492 C1533 C1434 C1435 CN1601 CN1601 CN2101 D1070 D1070 D1072 D1073 D1073 D1074 D1075 D1201 D1202 D1203 D1204 D1401 D1402 D1501 D1502 D1503 D1504 D1505 D1506 D1507 IC1401 IC1402 JK1202 JK1402 JK1404 JP2001 L1405 L1441 L1461 L1462 L1481 L1482 L1492 L1522 L1522A
AV CBA AC CORD PE8G2CG9G0A-055 HEATSINK E5717QD SCREW, S-TIGHT M3X8 BIND + CHROME ELECTROLYTIC CAP. 100µF/400V M ELECTOLYTIC CAP. 1000µF/6.3V M(105C) Not used Not used ELECTROLYTIC CAP. 470µF/16V M(105C) Not used Not used Not used Not used Not used CHIP CERAMIC CAP. F Z 0.1µF/50V Not used Not used FMN CONNECTOR, TOP 16P 16FMN-BTK FFC/FPC CONNECTOR, 16P 00 6232 016 000 800 Not used ZENER DIODE DZ-33BSDT265 ZENER DIODE MTZJT-7733D Not used SWITCHING DIODE 1N4148M SWITCHING DIODE 1SS133(T-77) Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used Not used DRIVER FOR DVD MM1622XJBE RCA JACK(BLACK) MSP-251V-01 NI Not used RCA JACK MSD-246V-65NI/PBSN PARALLEL WIRE (8P)250MM WX1E57S0-003 Not used CHIP BEAD MMZ1608Y121CT CHIP BEAD MMZ1608Y121CT Not used CHIP BEAD MMZ1608Y121CT Not used Not used CHIP BEAD MMZ1608R102CT Not used
9HSE1CMASTH471
---
9HSHD1JZ30F104
---
9HSCFNG16JG001 9HSC62G16TM009 9HSDTD00DZ33BS 9HSDTD00MTZJ33 9HSDTZ01N4148M 9HSDTZ001SS133
AD -----------
9HSSZBA0TMM085 9HSXRL010LY070 9HSXRL060LY069 9HSX1E57S0-003 9HSL06001TE004 9HSL06001TE004 9HSL06001TE004
AL AC AG AF -------
9HSL06001TE002
---
1-8-9
E5753PL
Ref. No. Q1003 Q1003 Q1003 Q1050 Q1521 Q1522 R1005 R1006 R1008 R1011 R1011 R1015 R1016 R1023 R1023 R1029 R1034 R1072 R1074 R1096 R1096 R1097 R1098 R1256 R1257 R1371 R1405 R1443 R1462 R1463 R1482 R1483 R1491 R1492 R1522 R1523 R1524 R1525 R1526 R1530 R1531 R1558 R1613 R1614 T1001! W1601 W2101
Description TRANSISTOR KTC3199(BL) TRANSISTOR 2SC2785(K) TRANSISTOR 2SC1815-BL(TPE2) Not used Not used Not used CARBON RES. 1/4W J 2.7M CARBON RES. 1/4W J 2.7M CARBON RES. 1/4W J 910 METAL OXIDE FILM RES. 1W J 1.8 METAL OXIDE FILM RES. 1W J 1.8 Not used Not used CHIP RES. 1/16W F 3.9k CHIP RES.(1608) 1/10W F 3.9k CARBON RES. 1/4W J 470k PCB JUMPER D0.6-P5.0 CHIP RES.(1608) 1/10W J 1k RECTIFIER DIODE 1N4005 METAL OXIDE FILM RES. 2W J 150k METAL OXIDE FILM RES. 2W J 150k Not used Not used Not used Not used CHIP RES.(1608) 1/10W 0 Not used CHIP RES.(1608) 1/10W J 75 CHIP RES.(1608) 1/10W J 75 Not used CHIP RES.(1608) 1/10W J 75 Not used Not used Not used Not used CHIP BEAD MMZ1608Y121CT CHIP INDUCTOR BK1608HS121-T CHIP INDUCTOR BK1608HS121-T Not used Not used Not used Not used CHIP RES.(1608) 1/10W J 2.2k Not used POWER TRANSFORMER CSA-SW0308A 16P FFC Not used FUNCTION CBA PCB JUMPER D0.6-P6.5
Part No. 9HSQS50KTC3199 9HSQSK02SC2785 9HSQS202SC1815
Code -------
9HSCX4JATZ0275 9HSCX4JATZ0275 9HSCX4JATZ0911 9HSN011R8ZU001 9HSN011R8KE009
-----------
9HSRXGFR5Z0392 9HSRXAFR5Z3901 9HSCX4JATZ0474 9HSJW5.0T 9HSRXAJR5Z0102 9HSDQZ001N4005 9HSN02154ZU001 9HSN02154KE010
-----------------
9HSRXAZR5Z0000 9HSRXAJR5Z0750 9HSRXAJR5Z0750 9HSRXAJR5Z0750
---------
9HSL06001TE004 9HSLC121NTU017 9HSLC121NTU017
-------
9HSRXAJR5Z0222 9HSTT00ZPSA144 9HSX1E57S0-001
--AH AF
SW2007
9HS0VSA14186B 9HSJW6.5T
-----
1-8-10
E5753PL
DV-SL10S(G)/DV-SL10W/DV-SL10/DV-SL10X/DV-SL10S(Q)/DV-SL10S(S)/DV-SL10(RU)
COPYRIGHT © 2003 BY SHARP CORPORATION ALL RIGHTS RESERVED.
No part of this publication may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, without prior written permission of the publisher.
Jul. 2003
Printed in JAPAN
SHARP CORPORATION AV Systems Group Quality & Reliability Control Center Yaita, Tochigi 329-2193, Japan
1