Text preview for : CDC-R504MP,X504MP.pdf part of AIWA CDC-R504MP,X504MP Car avto audio CDC-R504MP,X504MP
Back to : CDC-R504MP,X504MP.part1.r | Home
CDC-R504MP/X504MP
SERVICE MANUAL
Ver 1.0 2004. 01
US Model Canadian Model
CDC-X504MP
AEP Model UK Model
CDC-R504MP/X504MP
Photo: CDC-X504MP
· The tuner and CD sections have no adjustments. AUDIO POWER SPECIFICATIONS (US MODEL) POWER OUTPUT AND TOTAL HARMONIC DISTORTION 23.2 watts per channel minimum continuous average power into 4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more than 5% total harmonic distortion.
Model Name Using Similar Mechanism CD Drive Mechanism Type Optical Pick-up Name
CDX-R3300/R3300T MG-611MA-186//Q KSS1000E
SPECIFICATIONS
Tuner section
FM Tuning range US, Canadian Model: 87.5 107.9 MHz AEP, UK Model: 87.5 108 MHz Antenna terminal External antenna connector Intermediate frequency 10.7 MHz/450 kHz Usable sensitivity 9 dBf Selectivity 75 dB at 400 kHz Signal-to-noise ratio 67 dB (stereo), 69 dB (mono) Harmonic distortion at 1 kHz 0.5% (stereo), 0.3% (mono) Separation 35 dB at 1 kHz Frequency response 30 15,000 Hz AM (US, Canadian Model) Tuning range 530 1,710 kHz Antenna terminal External antenna connector Intermediate frequency 10.7 MHz/450 kHz Sensitivity 30 µV MW/LW (AEP, UK Model) Tuning range MW: 531 1,602 kHz LW: 153 279 kHz Antenna terminal External antenna connector Intermediate frequency 10.7 MHz/450 kHz Sensitivity MW: 30 µV LW: 40 µV
Power amplifier section
Outputs Speaker outputs (sure seal connectors) Speaker impedance 4 8 ohms Maximum power output 52 W × 4 (at 4 ohms)
General
Outputs Audio outputs terminal (rear/sub switchable) Power antenna relay control terminal Power amplifier control terminal Telephone ATT control terminal (AEP, UK Model) Antenna input terminal Low: ±10 dB at 60 Hz (HIP-HOP) Mid: ±10 dB at 1 kHz (HIP-HOP) High: ±10 dB at 10 kHz (HIP-HOP) 12 V DC car battery (negative ground) Approx. 178 × 50 × 176 mm (7 1/8 × 2 × 7 in.) (w/h/d) Approx. 182 × 53 × 161 mm (7 1/4 × 2 1/8 × 6 3/8 in.) (w/h/d) Approx. 1.2 kg (2 lb. 10 oz.) Parts for installation and connections (1 set) Front panel case (1) Card remote control RM-Z304
Inputs Tone controls
Power requirements Dimensions Mounting dimensions Mass Supplied accessories
Design and specifications are subject to change without notice.
FM/AM COMPACT DISC PLAYER
US, Canadian model
CD player section
Signal-to-noise ratio Frequency response Wow and flutter 120 dB 10 20,000 Hz Below measurable limit
FM/MW/LW COMPACT DISC PLAYER
AEP, UK model
9-877-518-01
2004A04-1 © 2004. 01
Sony Corporation
e Vehicle Company Published by Sony Engineering Corporation
1
CDC-R504MP/X504MP
SERVICE NOTES
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT The laser diode in the optical pick-up block may suffer electrostatic breakdown because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic breakdown and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care. NOTES ON LASER DIODE EMISSION CHECK The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens. Notes on Chip Component Replacement · Never reuse a disconnected chip component. · Notice that the minus side of a tantalum capacitor may be damaged by heat. TEST DISCS This set can playback CD-R and CD-ROM discs. The following test discs should be used to check the capability: CD-R test disc TCD-R082LMT (Part No. J-2502-063-1) CD-RW test disc TCD-W082L (Part No. J-2502-063-2)
· US, Canadian model
CAUTION
Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure. · AEP, UK model
CAUTION
Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure. This compact disc player is classified as a CLASS 1 LASER product. The CLASS 1 LASER PRODUCT label is located on the exterior.
This label is located on the bottom of the chassis. If the optical pick-up block is defective, please replace the whole optical pick-up block. Never turn the semi-fixed resistor located at the side of optical pick-up block.
optical pick-up
semi-fixed resistor
SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉCURITÉ!! LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
2
CDC-R504MP/X504MP
Notes on CD-Rs (recordable CDs)/CD-RWs (rewritable CDs) This unit can play the following discs: Type of discs Label on the disc
z
UNLEADED SOLDER
Boards requiring use of unleaded solder are printed with the lead free mark (LF) indicating the solder contains no lead. (Caution: Some printed circuit boards may not come printed with the lead free mark due to their particular size.)
: LEAD FREE MARK
Audio CD Unleaded solder has the following characteristics. · Unleaded solder melts at a temperature about 40°C higher than ordinary solder. Ordinary soldering irons can be used but the iron tip has to be applied to the solder joint for a slightly longer time. Soldering irons using a temperature regulator should be set to about 350°C. Caution: The printed pattern (copper foil) may peel away if the heated tip is applied for too long, so be careful! · Strong viscosity Unleaded solder is more viscous (sticky, less prone to flow) than ordinary solder so use caution not to let solder bridges occur such as on IC pins, etc. · Usable with ordinary solder It is best to use only unleaded solder but unleaded solder may also be added to ordinary solder.
MP3 files
· Some CD-Rs/CD-RWs (depending on the equipment used for its recording or the condition of the disc) may not play on this unit. · You cannot play a CD-R/CD-RW that is not finalized. · You can play MP3 files recorded on CD-ROMs, CD-Rs, and CD-RWs. · A CD-R/CD-RW to which a session can be added can be played. A process necessary for a recorded CD-R/CD-RW disc to be played on the audio CD player. EXTENSION CABLE AND SERVICE POSITION When repairing or servicing this set, connect the jig (extension cable) as shown below. · Connect the MAIN board (CN301) and the SERVO board (CN2) with the extension cable (Part No. J-2502-076-1).
MAIN BOARD CN301
J-2502-076-1
SERVO BOARD CN2
3
CDC-R504MP/X504MP
TABLE OF CONTENTS 1. GENERAL
Location of Controls ................................................................ 5 Connections (US, Canadian Model) ........................................ 6 Connections (AEP, UK Model) ............................................... 7
2. DISASSEMBLY
2-1. Sub Panel Assy .................................................................... 9 2-2. CD Mechanism Block ......................................................... 9 2-3. Main Board ....................................................................... 10 2-4. Chassis (T) Sub Assy ........................................................ 10 2-5. Roller Arm Assy ................................................................ 11 2-6. Chassis (OP) Assy ............................................................. 11 2-7. Optical Pick-up ................................................................. 12 2-8. SL Motor Assy (M902) ..................................................... 12 2-9. LE Motor Assy (M903) ..................................................... 13 2-10. Servo Board ....................................................................... 13
3. DIAGRAMS
3-1. 3-2. 3-3. 3-4. 3-5. 3-6. IC Pin Descriptions ........................................................... 14 Block Diagram CD Section ........................................... 19 Block Diagram Main Section ........................................ 20 Block Diagram Display Section .................................... 21 Circuit Boards Location .................................................... 21 Note for Printed Wiring Boards and Schematic Diagrams .......................................................... 22 3-7. Waveforms ......................................................................... 22 3-8. Printed Wiring Boards CD Mechanism Section ............ 23 3-9. Schematic Diagram CD Mechanism Section (1/2) ....... 24 3-10. Schematic Diagram CD Mechanism Section (2/2) ....... 25 3-11. Schematic Diagram Main Section (1/2) ........................ 26 3-12. Schematic Diagram Main Section (2/2) ........................ 27 3-13. Printed Wiring Board Main Section .............................. 28 3-14. Printed Wiring Boards Display Section ........................ 29 3-15. Schematic Diagram Display Section ............................. 30 3-16. IC Block Diagrams ............................................................ 31
4. EXPLODED VIEWS
4-1. 4-2. 4-3. 4-4. 4-5. 4-6. Main Section ..................................................................... 35 Front Panel Section ........................................................... 36 CD Mechanism Section (1) ............................................... 37 CD Mechanism Section (2) ............................................... 38 CD Mechanism Section (3) ............................................... 39 CD Mechanism Section (4) ............................................... 40
5. ELECTRICAL PARTS LIST ........................................ 41
4
CDC-R504MP/X504MP SECTION 1 GENERAL
LOCATION OF CONTROLS
This section is extracted from instruction manual.
5
CDC-R504MP/X504MP
CONNECTIONS (US, Canadian Model)
6
CDC-R504MP/X504MP
CONNECTIONS (AEP, UK Model)
7
CDC-R504MP/X504MP SECTION 2 DISASSEMBLY
Note : This set can be disassemble according to the following sequence.
SET 2-1. SUB PANEL ASSY (Page 9) CD MECHANISM BLOCK (Page 9)
2-2.
2-3.
MAIN BOARD (Page 10)
2-4.
CHASSIS (T) SUB ASSY (Page 10) ROLLER ARM ASSY (Page 11) CHASSIS (OP) ASSY (Page 11)
2-10. SERVO BOARD (Page 13)
2-5.
2-6.
2-8.
SL MOTOR ASSY (M902) (Page 12) 2-9. LE MOTOR ASSY (M903) (Page 13)
2-7.
OPTICAL PICK-UP (Page 12)
8
CDC-R504MP/X504MP
Note : Follow the disassembly procedure in the numerical order given.
2-1. SUB PANEL ASSY
3 two claws
2 two claws
1 two screws (+PTT 2.6 x 6)
4 sub panel assy
2-2. CD MECHANISM BLOCK
7 bracket (CD)
5 CD mechanism block
6 two screws (+PTT 2.6 x 4)
2 screw (+PTT 2.6 x 6)
3
1 screw (+PTT 2.6 x 6)
4 CN301
9
CDC-R504MP/X504MP
2-3. MAIN BOARD
1 three ground point screws (+PTT 2.6 x 6)
2 two screws (+PTT 2.6 x 6) 3 MAIN board
insulating sheet
2-4. CHASSIS (T) SUB ASSY
4 claw 2 two screws (+P 1.7 x 2.2) 1 two screws (+P 1.7 x 2.2)
6 chassis (T) sub assy
5 SENSOR board
3 claw
10
CDC-R504MP/X504MP
2-5. ROLLER ARM ASSY
3 washer (0.8-2.5)
5 roller arm assy
4 worm wheel (RA)
2 spring (RAR)
1 spring (RAL)
2-6. CHASSIS (OP) ASSY
8 qa chassis (OP) assy
0 coil spring (damper)
lever (D)
4 washer 1 CN1 6 5 gear (LE1) 9 two coil springs (damper)
7
slider (R)
3 tension coil spring (KF) 2 Remove the six solderings.
11
CDC-R504MP/X504MP
2-7. OPTICAL PICK-UP
2 chucking arm sub assy
5 claw
1 tension coil spring (CHKG)
7 optical pick-up
6 main shaft
4 rack (SL) 3 screw (+B 1.4 x 5)
2-8. SL MOTOR ASSY (M902)
1 screw (+P 1.4 x 1.8)
2 SL motor assy (M902)
12
CDC-R504MP/X504MP
2-9. LE MOTOR ASSY (M903)
0 woam (LEB) assy
8 screw (+M 1.7 x 2.5) 9 bearing (LEB)
qf two toothed lock screws (+M 1.4 )
qa screw (+M 1.7 x 2.5)
2 washer 3 gear (LE1)
lever (D)
4
bracket (LEM)
qs screw (+M 1.7 x 2.5) qg LE motor assy (M903) 5
qd
6 screw (+P 1.7 x 2.2)
slider (R)
7 leaf spring (LE) 1 Remove the soldering.
2-10. SERVO BOARD
1 Remove the eight solderings.
6 SERVO board
2 Remove the three solderings. 4 toothed lock screw (M 1.7)
5 claw
3 CN1
13
CDC-R504MP/X504MP SECTION 3 DIAGRAMS
3-1. IC PIN DESCRIPTIONS
· IC3 CXD3059AR (DIGITAL SERVO/DIGITAL SIGNAL PROCESSOR) (SERVO BOARD (1/2)) Pin No. Pin Name I/O Pin Description 1 MIRR I/O Mirrer signal input/output 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 DFCT FOK VSS LOCK MDP SSTP IOVSS1 SFDR SRDR TFDR TRDR FFDR FRDR IOVDD1 AVDD0 AVSS0 NC E F TEI TEO FEI FEO VC A B C D NC AVDD4 RFDCO PDSENS AC SUM EQ IN LD PD NC RFC AVSS4 RFACO RFACI AVDD3 BIAS ASYI ASYO VPCO VCTL AVSS3 I/O I/O -- I/O O I -- O O O O O O -- -- -- -- I I I O I O I/O I I I I -- -- I/O I O I O I -- I -- O I -- I I O O I -- Defect signal input/output Focus OK signal input/output Ground pin Not used in this set. (Open) Spindle motor servo control signal output Disc most inner detection signal input Digital ground pin for I/O Sled drive signal output Sled drive signal output Tracking drive signal output Tracking drive signal output Focus drive signal output Focus drive signal output Digital power supply pin for I/O Analog power supply pin for I/O Analog ground pin Not used. (Open) E signal input F signal input Tracking error signal input from the DSSP block Tracking error signal output to the RF amp block Focus error signal input from the DSSP block Focus error signal output form the RF amp block VC voltage output to the RF amp block Center voltage input from the DSSP block by command select A signal input B signal input C signal input D signal input Not used. (Open) Analog power supply pin RFDC signal output RFDC signal input from the DSSP block by command select Reference voltage input for PD RFAC suming amp signal output Equalizer circuit signal input APC amp signal output APC amp signal input Not used. (Open) EQ cut off frequency adjustment input Analog ground pin RFAC signal output RFAC signal input or EFM signal input Analog power supply pin Asymmetry circuit constant current input Asymmetry comparate voltage input EFM full swing signal output Charge pomp output for wideband EFM PLL VCO2 control voltage input for wideband EFM PLL Analog ground pin
14
CDC-R504MP/X504MP
Pin No. 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72, 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103
Pin Name CLTV FILO FILI PCO AVDD5 DDVROUT DDVRSEN AVSS5 DDCR NC BCKI PCMDI LRCKI LRCK VSS PCMD BCK VDD EMPH EMPHI IOVDD2 DOUT TEST IOVSS2 NC XVSS XTAO XTAI XVDD AVDD1 AOUT1 VREFL AVSS1 AVSS2 VREFR AOUT2 AVDD2 NC IOVDD0 RMUT LMUT NC XTSL IOVSS0 XTACN SQSO SQCK SBSO EXCK XRST SYSM DATA VSS
I/O I O I O -- O I -- I -- I I I O -- O O -- O I -- O I -- -- -- O I -- -- O O -- -- O O -- -- -- O O -- I -- I O I O I I I I --
Pin Description VCO1 control voltage input Filter signal output for master PLL Filter signal input for master PLL Charge pomp output for master PLL Analog power supply pin DC/DC converter output DC/DC converter output voltage monitor signal input Analog ground pin Reset signal input for DC/DC converter Not used. (Open) D/A interface bit clock signal input D/A interface serial data signal input D/A interface LR clock signal input D/A interface LR clock signal output Digital ground pin for internal D/A interface serial data signal output D/A interface bit clock signal output Digital power supply pin for internal Not used in this set. (Open) Not used in this set. (Fixed at "L".) Digital power supply pin for I/O Digital out signal output Test pin Normally "L". Digital ground pin for I/O Not used in this set. (Open) Ground pin for master clock Crystal oscillation circuit output (16.9344 MHz) Crystal oscillation circuit input (16.9344 MHz) Power supply pin for master clock Analog power supply pin L channel analog signal output L channel reference voltage output Analog ground pin Analog ground pin R channel reference voltage output R channel analog signal output Analog power supply pin Not used. (Open) Digital power supply pin for I/O R channel "O" detection flug output L channel "O" detection flug output Not used. (Open) X'tal select signal input 16.9344 MHz: "L", 33.8688 MHz: "H" Digital ground pin for I/O Oscillation circuit control input "H": Oscillation start, "L": Oscillation stop Sub 80 bit and PCM peak, level data signal output CD text data signal output Clock signal input for SQSO read out Sub P-W serial data signal output Not used in this set. (Open) Clock signal input for SBSO read out Not used in this set. (Open) System reset signal input "L": reset Mute signal input "H": mute Serial data signal input Digital ground pin for internal Not used in this set. (Fixed at "L".)
15
CDC-R504MP/X504MP
Pin No. 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120
Pin Name XLAT CLOK VDD SENS SCLK ATSK WFCK XUGF XPCK GFS C2PO SCOR VDD C4M WDCK COUT NC
I/O I I -- O I I/O O O O O O O -- O O I/O --
Pin Description Latch signal input Serial data transfer clock signal input Digital power supply pin for internal SENS signal output Clock signal input for SENS serial data read out Input/output for anti-shock WFCK signal output Not used in this set. (Open) XUGF signal output XPCK signal output GFS signal output C2PO signal output Sub cord sync signal output Digital power supply pin for internal 4.2336 MHz signal output Not used in this set. (Open) Word clock signal output Not used in this set. (Open) Track count signal input/output Not used. (Open) Not used in this set. (Open) Not used in this set. (Open) Not used in this set. (Open)
16
CDC-R504MP/X504MP
· IC501 MN101E01KSH (SYSTEM CONTROL) (MAIN BOARD (1/2)) Pin No. Pin Name I/O Pin Description 1 DAVDD -- Power supply pin for D/A output converter (+3.3 V) 2 3 4 to 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29, 30 31 32 to 35 36 37 38 39 to 41 42 43 to 46 47 48 49, 50 51 52 53 54 55, 56 57 58 59 60 61, 62 63 64 65 BBE-MP DAVSS NCO UNISO UNISI UNICKO VDD1 MMOD OSCOUT OSCIN VSS1 XIN XOUT VDD2 MOD1 RESET NCO ACC IN TEST IN TEL ATT ATT XKEYON NCO KEYACK TU ATTIN NCO BUIN NCO BUSON SYSRST EJECT OK NCO Z MUTE NCO CD ON CDM ON NCO AREASEL1 AREASEL2 AREASEL3 LCD CTL NCO DSSA PANEL SW DIAG VOLATT NCO VSS2 TU ATT NCO O -- O O I O -- I O I -- I O -- -- I O I I I O O O I I O I O O O O O I O I I O I I I O O O I I O O -- O O Not used in this set. (Open) Ground pin for D/A output converter Not used in this set. (Open) SONY-BUS data signal output SONY-BUS data signal input SONY-BUS clock signal output Power supply pin for internal core (+3.3 V) Flash microcomputer write detection signal input High speed operation clock signal output (27 MHz) High speed operation clock signal input (27 MHz) Ground pin for internal core Low speed operation clock signal input (32.768 kHz) Low speed operation clock signal output (32.768 kHz) Power supply pin for internal core (+3.3 V) Pull up: "H" Reset signal input Not used in this set. (Open) Accessory power supply detection signal input Test mode detection signal input Telephone attenuate detection signal input Audio mute control signal output Key power supply control signal output Not used in this set. (Open) Not used in this set. (Open) Key acknowledge detection signal input Tuner mute ZERO cross detection signal input Not used in this set. (Open) Back up power supply detection signal input Not used in this set. (Open) BUS on signal output System reset signal output CD servo IC eject OK signal output Not used in this set. (Open) Mechadeck mute zero cross detection signal input L/R Not used in this set. (Open) CD mechanism power supply control signal input ("H": Power on) CD mechanism deck power supply control signal input ("H": Power on) Not used in this set. (Open) Destination function setting input 1 Destination function setting input 2 Destination function setting input 3 "H" output: LCD unit and key confusion, power off "L" output: LCD unit and key confusion, power on Not used in this set. (Open) DSSA on/off change signal output (Cut off rear) Front panel attachment detection signal input "L": with panel, "H": without panel Condition signal input from the power IC Electronic volume attenuate control signal output Not used in this set. (Open) Ground pin for I/O port Tuner mute control signal output Not used in this set. (Open) Not used in this set.
17
CDC-R504MP/X504MP
Pin No. 66 67 68 69 70 71 to 73 74 75 76 77 78 79 80 81 82 83 84 85 86 to 88 89 90 91 92 93 94 95 96 97 98 99 100
Pin Name NS MASK EEP CKO EEP SIO NCO AMPSTB NCO NCO NCO LCDSO LCDCE LCDCKO I2C SIO NCO I2C CKO DAVN SIRCS NCO BEEP NCO VDD3 NCO VSS3 QUALITY VSM KEYIN1 KEYIN0 NCO KEYIN2 RE L METER VREF+
I/O O O I/O O O O O O O O O I/O O O I I O O O -- O -- I I I I O I I I --
Pin Description Noise mask signal output Serial clock signal output for EEPROM communication Serial data signal input/output for EEPROM communication Not used in this set. (Open) Power regulator IC standby signal output Not used in this set. (Open) Not used in this set. Not used in this set. (Open) Serial data signal output to the LCD driver Chip enable signal output to the LCD driver Serial clock signal output to the LCD driver I2C BUS serial data signal input/output Not used in this set. (Open) I2C BUS serial clock signal output RDS data block synchronization detection signal input Remote control signal input Not used in this set. (Open) Beep signal output to the power amp Not used in this set. (Open) Power supply pin for I/O port (+3.3 V) Not used in this set. (Open) Ground pin for I/O port Noise detection signal input S meter voltage detection signal input Key signal input 1 Key signal input 0 Not used in this set. Key signal input (EJECT, OFF, SOURCE switch) Rotary encoder signal input Level meter voltage detection signal input Power supply pin for A/D input converter
18
CDC-R504MP/X504MP
3-2. BLOCK DIAGRAM -- CD SECTION --
· R-ch is omitted due to same as L-ch. · Siganal Path
DETECTOR PD1 PD2 PD2 PD1 26 A 27 B 28 C
I-V AMP
: CD PLAY
RFACO 41 42 RFACI ASYO 46 45 ASYI AOUT1 81 AOUT2 86 R-CH CD-L
A
MAIN SECTION
(Page 20)
29 D
RF AMP,DIGITAL SERVO, DIGITAL SIGNAL PROCESSOR IC3 FEO 24 TEO 22 23 FEI 21 TEI
LMUTE 89 RMUTE 90
22 CD LMUT 23 CD RMUT UNISI RXD UNISO TXD UNICLK BUS ON BU IN RSTX A ATT 56 25 57 26 58 50 51 75 60 UNI SI UNI SO UNI SCK BUS ON BU IN SYS RST ATT SYSTEM CONTROL IC501 (1/3) EJECT OK 61 MECON 63 CDON 64 ZMUT 66 38 EJECT OK 48 CDM ON 47 CD ON 42 Z MUTE
E F
E F
19 E 20 F
B
LASER DIODE AUTOMATIC POWER CONTROL Q1
LD PD LD
36 LD
PD 37
PD
FOK SQSO SQCK XRST DATA XLAT CLOK SENS SCLK GFS C2POT SCOR
3 96 97 100 102 104 105 107 108 113 114 115
19 16 18 15 14 13 12 11 10 8 7 52
CD FOK CD SQSO CD SQCK CD XRST CD DATA CD XLAT CD CLOK CD SENS CD SCLK CD GFS CD C2PO CD SCORT
MAIN SECTION
(Page 20)
OPTICAL PICK-UP BLOCK (KSS1000E)
CD SYSTEM CONTROL IC4 MECON CHK 67 FOCUS/TRACKING COIL DRIVE, SLED/SPINDLE/LOADING MOTOR DRIVE IC1 XTAI 78 FCS+ FCS 11 VO2 10 VO2+ VIN2+ 22 VIN2 21 13 FFDR 14 FRDR XTAO 77 X1 16.934MHz X2 18.43MHz 80 X0 +1.5V 81 X1
MECHA+6V
CDON CHK 68
SERVO+3.3V +1.5V REG IC7 +1.5V CONTROL Q2,3 5 VOUT VDD 1 CE 3 U COM+3.3V
2-AXIS DEVICE
(FOCUS) (TRACKING) TRK+ TRK 13 VO1 12 VO1+ VIN1+B 19 VIN1B 18 11 TFDR 12 TRDR SW1 (DOWN) 46 MEC_DSW
+3.3V BCK BCKI PCMDI LRCK LRCKI PCMD 66 60 61 63 62 65 SW2 (SELF) 53 MEC_SELFSW DECON 65 SW3 (DISC IN) 45 MEC_INSW
+3.3V CONTROL Q5,6
M902 (SLED)
M
6 VO4+ 7 VO4
VIN4+ 31 VIN4 32
9 SFDR 10 SRDR
AUDIO INTERFACE IC8 DEC XMUTE DEC SSTBY DEC XRST DEC STBY DEC INT DEC SCL DEC SDA EMPH 37 27 28 29 30 31 32 69 22 41 2 3 36 7 6 28 CLCK SRMSTB RESET STANDBY BUCK I2C SCL I2C SDA BUSO
M901 (SPINDLE)
M
8 VO3+ 9 VO3
VIN3+ 25
6 MDP
SW4 (LIMIT)
42 MEC_LIMIT
MUTE 34 M903 (LOADING)
41 DRON 43 MEC LOAD 44 MEC EJECT
M
5 VOL+ 4 VOL
FWD 1 REV 2
15 18 11 16 19 14
BCK1A BCK1B SD0O LRCK1A LRCK1B SD1O
19
19
CDC-R504MP/X504MP
3-3. BLOCK DIAGRAM -- MAIN SECTION --
SOUND CONTROL, ELECTRONIC VOLUME IC401 J601 (AUX IN) 5 AUX-LCH 3 AUX-RCH OUT SUB L 17 OUT SUB R 18 L R-CH MUTE Q481 POWER AMP MULTIPLE VOLTAGE REGULATOR IC750 12 IN-FL 11 IN-RL R-CH (FRONT) R-CH (REAR) SCL SDA REAR L/R CUT OFF SWITCH Q403 DSSA ON/OFF SWITCH Q402 MUTE DRIVE Q491,492 MUTE Q431 MUTE Q451 OUT-FL+ 5 OUT-FL 3 OUT-RL+ 9 OUT-RL 7 R-CH R J331 AUDIO OUT REAR
R-CH
R-CH
CD SECTION TU1 (TUNER UNIT) J1 (ANTENNA)
A
CD-L R-CH
(Page 19)
9 CD-LCH 8 CD-RCH
1 ANT
L 4 R 3
7 TU-LCH 6 TU-RCH
OUT-FL 23 OUT-RL 22 OUT-FR 25 OUT-RR 24
CN601 1 FL+ 9 FL 2 10 RL+ RL
VCC 10 TU VDD 11 E2P VDD 15
AUDIO+8.3V TU+5V BACK UP+3.3V
LEVEL METER VOLTAGE DETECT D401,402,Q401
15 OUT-SEL-R 16 OUT-SEL-L
MUTE 29 SCL 30 SDA 31
D492 BATT
R-CH
4 FR+ 12 FR 3 RR+ 11 RR 5 AMP-REM 6 ANT-REM FU601
TU-SCL 13 TU-SDA 14
SCL SDA SYSTEM CONTROL IC501 (2/3) I2C CKO 81 99 L METER I2C SIO 79 VOL ATT 60 ATT BEEP AMPSTB DIAG 82 DAVM 24 85 70 59 BATT DSSA 57 ACC IN 21 B+ SWITCH Q51,52 BACK UP +3.3V TEL ATT 23 R504MP/X504MP: AEP,UK MODEL SCL SDA D503 SDA SCL
AMP-REM 29 ANT-REM 27 R504MP RDS DEMODULATOR IC51 2 SDA 4 SCL BATT
16
BATT
RDS 9
16 MPX 9 XTI 10 XTO INTN 15 VDDA VDDD 1 7 SCL 11 SDA 12 SCL SDA
X51 8.664MHz
16 BEEP 22 STB 25 DIAG 35 VP
AUDIO+8.3V B.UP+B SERVO+3.3V MECHA+6V PANEL+B
30 37 31 33 34
AUDIO+8.3V BACK UP+3.3V SERVO+3.3V MECHA+6V PANEL+10V
ACC CHECK Q631
7
ACC
TEL ATT Q651
13 15
ATT TEST
MULTI 8 CONDITION QUALITY 5
28 TU ATTIN TEST IN 22 R504MP 92 QUALITY NS MASK SWITCH Q3 TU+5V TU+5V REG Q1 AUDIO+8.3V
66 NS MASK BUIN 31 BATTERY CHECK Q582 LOW VOLTAGE DETECT Q581 OVER VOLTAGE DETECT Q580 D580 BATT
S-METER 6 TU MUTE 7 E2P SCL 16 E2P SDA 17
93 VSM 64 TU ATT 67 EEP CKO 68 EEP SIO
D581 · R-CH is omitted due to same as L-CH. · Signal Path : CD PLAY : FM
UNI SO UNI SI UNI SCK CD SECTION
B
BUS ON SYS RST
7 8 9 36 37
UNI SO UNI SI UNI SCK BUS ON SYS RST
: AM/MW/LW : AUX
(Page 19)
BU IN ATT DISPLAY SECTION D301
C
RESET
(Page 21)
20
20
CDC-R504MP/X504MP
3-4. BLOCK DIAGRAM -- DISPLAY SECTION --
3-5. CIRCUIT BOARDS LOCATION
SYSTEM CONTROL IC501 (3/3) ROTARY ENCODER S911 (1/2)
LCD DRIVER IC901
SERVO board
LCD901 LIQUID CRYSTAL DISPLAY PANEL
SENSOR board
98 RE LCD SO 76 LCD CKO 78 LCD CE 77 64 DI 63 CLK CL 62 CE
SEG3 3 | | SEG50 50 COM1 54 | | COM4 51 DIMMER 1 DIMMER
KEY MATRIX S901-903
97 KEYIN2 27 KEYACK
KEY MATRIX S904-910 S911 (2/2)
94 KEYIN1 DIMMER CONTROL Q901 95 KEYIN0
KEY MATRIX S912-920
(
LED921,922 LCD BACK LIGHT
)
tuner unit (TU1)
PANEL+10V
KEY board
LCD CTL 54
RESET IC602
MAIN board
LED901-920 19 RESET S702 RESET PANEL+3.3V SWITCH Q503 1 VCC 2 OUT BUCK UP+3.3V
BACK UP+3.3V
2 IN
OUT 1
AUX board
MAIN SECTION
C
RESET SIRCS 83
IR
(Page 20)
REMOTE CONTROL SIGNAL RECEIVER IC971
X502 32.768kHz
15 XIN 16 XOUT
OSCIN 13 OSCOUT 12
X501 27MHz
21
21
CDC-R504MP/X504MP
3-6. NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) For schematic diagrams.
Note: · All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. · All resistors are in and 1/4 W or less unless otherwise specified. f : internal component. · · C : panel designation. Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. · · · · · · Note: Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
3-7. WAVEFORMS -- Servo Board --
(MODE: CD PLAY)
-- Main Board --
1
For printed wiring boards.
Note: · X : parts extracted from the component side. · Y : parts extracted from the conductor side. a : Through hole. · · : Pattern from the side which enables seeing. (The other layers' patterns are not indicated.) Caution: Pattern face side: (Side B) Parts face side: (Side A) Parts on the pattern face side seen from the pattern face are indicated. Parts on the parts face side seen from the parts face are indicated.
Approx. 100mVp-p 0V
1
2.2Vp-p
27MHz
IC3
wa
(TEI)
IC501
qs
(OSCOUT)
2
0V Approx. 100mVp-p
2
1.8Vp-p 32.768kHz
IC3
wd
(FEI)
IC501
qg
(XIN)
3
Approx. 150mVp-p
3
0.9Vp-p
C Q B E These are omitted
·
·
· ·
·
A : B+ Line. B : B Line. H : adjustment for repair. Voltages and waveforms are dc with respect to ground under no-signal (detuned) conditions. CD mechanism section no mark : CD PLAY Main (1/2), (2/2) and Display sections no mark : FM ( ) : AM < > : CD PLAY : Impossible to measure Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal production tolerances. Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. Circled numbers refer to waveforms. Signal path. J : CD PLAY F : FM f : AM/MW/LW a : AUX Abbreviation CND : Canadian model.
IC3
wh
(A), wk (C)
IC51
q;
(XTO)
4
BE C These are omitted
Approx. 150mVp-p
IC3
wj
(B), wl (D)
5
ECB These are omitted
· Abbreviation CND : Canadian model.
Approx. 0.8Vp-p
IC3
ra
(RFACO)
6
2Vp-p
16.9344MHz
IC3
uj
(XTAO)
7
1Vp-p
18.43MHz
IC4
ia
(X1)
22
22
CDC-R504MP/X504MP
3-8. PRINTED WIRING BOARDS -- CD MECHANISM SECTION -- · Refer to page 21 for Circuit Boards Location.
: Uses unleaded solder.
1 A
Q6 C83
2
3
4
5
6
7
8
9
10
11
12
13
14
R107
Q5
R6
R13
BP2 BP3
R3 R2 R9 R19 R8 R20
R101
C22
C23 C24
R139 R106 Q2 R29 C28 C29
R22
C25
R23 R25
C27
C30
R28
C74
C33
C35 R38
C41
R116 R149
C91
R40
C6
C38 Q1
C85
R24
C39
C34
B
IC7
Q3
C37
R41
C79
C46
C42 R109 R77
C40 R43 R55 R54
IC3
BP1 C110
R44 R46 C47 C49 R49 R61 C44 C43
R45
R42
R12 R7
R53
R56
C50
C
C92 R111 C115
X1
R108
C10
R99 R144
C77
C65
R70 C54 C81 C57
R79
R76
C64
R68
C55
R78
R145
R110
R128
C75
C86
C58
C59 C48
R48
R126
R142
R140
R97 R119
R71
C107 R141
C4
R98
R67
R80
R1
R59
D
R64 R143
R52
R50
R62
R129
C53
C52
R127
R122
R72
C109
R60
IC8
C45
C5
FM B7 CN 1
SW3
IC4 C32
R73
E
R85 R92 R91 R47 R39
C1 C2
R37
FB2
R115
R74
C66
R81
R57 R65
R87
SW2
C51
R86
X2
R136
R124
C56
C36
R133
CN2
C60
FB5
F
R117
C67 FB1
R114 R148 R18 R123 C19 C8 R16
C63
R5
R147
R146
R26 R4 C26 C7
R27 R17
R21
C18
R69
FM B8
(Page 28)
G
R15 R14
IC1
C21 C3
C13 SW1 R10
C16
C14
H
· Semiconductor Location Ref. No. IC1 IC3 IC4 IC7 IC8 Q1 Q2 Q3 Q5 Q6 Location G-2 C-10 E-2 B-2 C-2 B-4 B-2 B-2 A-2 A-2
R11
C11
23
23
CDC-R504MP/X504MP
3-9. SCHEMATIC DIAGRAM -- CD MECHANISM SECTION (1/2) -- · Refer to page 22 for Waveforms.
C45
R149 R48
R50
R40
R52 C41
C33
R59 R56
R60
TP116
TP343
TP344
TP96
TP97
TP127
TP63 TP65
TP62
TP94
TP98
TP137
TP141
R67
R71 C54 TP59 TP60 R64 TP57 TP61 C52 R29 C53 C59 R98 CN2 TP129 C81 IC3 C28 TP140 R13 R22 R6 BP2 R24 BP3 R25 R23 C27 TP50 TP71 TP175 C57 R114 R78 R76 R133 R124 R79 R68 C4 TP167 C55 FB2 FB5 R70 X1 R77 TP56 TP72 TP123 TP128 TP139 TP53 R65 TP55 TP54 TP48 TP49 TP47 TP133 TP135 TP42 TP51 TP37 TP41 TP132 TP136 TP46 TP36 TP39 TP38 TP43 C50 R61 TP40 C58 TP180 C60 R97
TP181
C29
C22 C23 CN1 TP21 TP22 TP23 TP24 TP25 TP26 TP27 TP28 TP29 TP30 TP32 TP33 C24 C25
(Page 26)
R1
C6
R72
TP99
R42
C5 TP34 TP35
R43
R45
Q1
TP44
TP45
C34
C37
R54
C49 C48 C107
C39 C40
C42
C35
R38
R49
R7
R12
R41
R55 C47 R53
C30
R44
R46 C43
C44
C10 C38
C46 C64 C65
(Page 25)
24
24
CDC-R504MP/X504MP
· Refer to page 22 for Waveform. 3-10. SCHEMATIC DIAGRAM -- CD MECHANISM SECTION (2/2) -- · Refer to page 31 for IC Block Diagrams.
(Page 24)
FB1
R136
C36
R39
R47
R148 R147 R57
R146
R69
R73
C56 R81
C67
R91 R92
SW4
TP7 TP8
C63
R15
R14
R117 X2
SW3
TP9 TP11
C1
R85 R86
IC B/D
C2 SW2 TP12 IC1 C32 R37 R87
C3 SW1 TP19 TP20 C11 C19
C21 IC4 R18 R20 C66 R19 R140
TP17 M903 TP18
C18
R17 R123 TP58 R21 R145 R141 R142 R143 TP31 R28 R115
TP13 M901 TP14 TP15 M902 TP16 C16 R9 C8 R11 C14 C26
R26 R27 R16 C7 R4
R2
TP52
R74
R122
R126
R127 R128
R129
R3 R5
R62
R80 R119 C51
R8
R10
C13
C115
C86 R110 R111
C92
C77 C75
C109 R99 R144 R108 R109 TP230 TP231 Q5 C79 TP226 BP1 C110
IC8
IC B/D
IC7 C83 R101 R107 Q6
TP249
Q3
C85 R106
R139 Q2
R116
C74
C91
25
25
CDC-R504MP/X504MP
· Refer to page 22 for Waveforms. 3-11. SCHEMATIC DIAGRAM -- MAIN SECTION (1/2) -- · Refer to page 32 for IC Block Diagrams.
IC B/D
TU1
IC B/D
R428 C407 C402 C430 C404 C403 Q51 C406 C420 C419 D401 C7 R401 R418 C428 R61 R415 C425 R413 R417 R416 IC401 R411 R402 C426 R414 C409 C8 C408 C401 R12 R11 R422 R421 R405 C427 Q403 C416
R59 C51
R51 C53 C57
C52
J1
R52
C58
R406 R408 R407 R409 C411 C410 R410 C412 R429 C415 Q402
C54
C55
C56
R54
C405 Q52
R53 C3 Q3 R10 R8 C1 C2 R5 R4
R15 R16
C9
D402
Q401
R6
R7
R9
IC51
Q503
C4 C6
R1
L1
R57
R56
R55
R58 D1 Q1 C62
X51 C60 C59
C5
R540
R419 C429
R559 JC26 R539 R519 R530 R528 R532 D503 R534 R520
R573
R557
R564
R636 R531
R537
R538
R549
R563
R560
(Page 27)
C509
L304 L305 L306
R506 CN301 C301 C305 R556 R303 JW143 JW142 R544 R551 IC501 R552 X502 R547 R509 R508
C515 C508 C507
X501 D586
C302
C310
C303
C307 L302 R592
R579 R591
L310
(Page 24)
C503
C501 R510 R512 C510 C513
R511
C304
D301
R567
R558
R514
R513
C516
JC19
R541
C512
C514 C502
C517
R521
R522
R518 C511
R501
R502 R596
R503
R565 R543
R504
R595
R505
R566
L308 C308 C309 L309
JW144 JW145
26
26
D587
L303 L307
C504
R593
R535
CDC-R504MP/X504MP
3-12. SCHEMATIC DIAGRAM -- MAIN SECTION (2/2) -- · Refer to page 34 for IC Block Diagram.
C441 R441
C765
C766
C764
R442
Q441
C751
D751
D753 R462 C461 R461 Q461
C333 C334
J331
C750 D755
C431
R431 R432
Q431
D757
R452 C451 R451
Q451
D752 D754 CN601
C481 R481 R482
Q481 R443 C442
IC750 D756 D758 D761
R472 C471 R471 Q471 R463 C462
D759 D760 R433 C432 D762
R453
C452
R609
FU601
Q492
C626 C624
D491 R492 Q491 R491 C602 C491 C601 D601 C492 C753
IC B/D
D609 L601
C758
C701
(Page 26)
R752 R756 C756
C755
C754 C761
C759 C760
JC2 IC602
L502 C731 C732 R735 R731 R732 R734 R733
C703 C621
S702
C623
C622 D731
C617 C618
C630 C628
L501 D703
L373
C631 C629 C627
L374
C625
L372 L731
D492
R493
CN701
D702 R701 JW53 R633 Q631 R634 C632 R632 R631 Q651 R651 R654 D651 R653 R652
(Page 30)
Q581 R584 R585 D580 R582 D711 D712 C704
D581 Q582 Q580
R583
27
27
CDC-R504MP/X504MP
3-13. PRINTED WIRING BOARD -- MAIN SECTION -- · Refer to page 21 for Circuit Boards Location. : Uses unleaded solder.
1
J1
2
3
J331
4
5
6
7
8
9
10
11
12
13
14
A
Q431 R432
C333 C764
CN601 Q441 C765 C751 R442 C766 JW147
C627
X504MP:US,CND MODEL
C630
JW9
B
Q471
R482 IC750
C631
C629
C624
C626
C628
FU601
JW1 R433
R431 R443
C432
JC24 JW13 JW12 JW11 JW10
C625
JW141
C442 R463 R453
C753
JW3 C618
JW2
JW14 JW15 JW16
C462 C452
JW146
Q481
JC10
JW120
JW6
JW137
C431
C451 R481 R461
JW134
C
Q451 R452
JW17 JW18
D756 Q461 D758
JW8
R653
JW5 JW4
R651 D651 L601
C481
JW128
C334
JW7
R441
R471 C461
D759 D755
D761 D762
D752
D754
C758
D751 D757
C602 D601 JW31
C601
R451
C617
R472
C471
TU1
C407
R462
D760 R654
R504MP/X504MP:AEP,UK MODEL
JW22
C427 C412
JW28
JW20
JW102
C403 C8 R12
C401 R405
JW131 IC401
L502
C761
C760
JW118
C430
R652
JW29
C404
D
Q3
C7
C750
C402
C441
C759 Q651
D753
JW32 JW30 JW39 JW111
R428
Q403
JW59
JW24 JW23 JW112 JW25 JC2
JW132
C3
C416
JW114
JW115
R413 R421
Q401
C415
C2 C6 D1 R1
JW94
Q492
C4
C425
Q402
E
C426
R409 C411 C410 R410
C429
D492
C492 R493 D491 R491 JW95 Q503 C406
JW40
C1
R408 R414
R429
JW106
JW108 R401
JW42
R10
C409
L302
R407
R540
Q491 C491
C622
R11
R406
CN301
JW34 JW35 JW113 JW116 JW33
C408
L304
C623
R411 R402
R419 C755
JW93
R492
C302 C305 C310 L310
C301
JW43 L303 L305 JW107
R422
C428
R416
Q1
R752
C754 JW91
JC7
L1
R415
R417 D402
R557 R418
JW96
C420
C419
JW72
C405
C303
R15
JW97 R531
D503
JW127
L307 C307
C309 L308
L306 JW144
R609
R582 D580 R583 D581
JW83
R16 JW101 JC25
JW79
D401 JW90 JW81
JW92
JW38
JW27
JW26
JW61
F
C5
JC6
R537
R538
JW145
R7
C9
JW54
JW67
JW119
C308
JW130
L309 JW109
C304
JW57 JW117 Q580 D609
JW48 R6 JW100 R59
C54
JW85 JW86
R532
JW142
R303
D586
C51
R5
C55 C56
R56
JW123 JW122
JC26
G
JW143
R58 C52
JW45
R57
JW87
R534
JW110
Q52
JW88
R549
R530
FM B3
R528
C62
Q51
R544
R521
JW55
JW98
JW99
JW89
R522
R551 R520
· Semiconductor Location (Page 23) Ref. No. D1 D301 D401 D402 D491 D492 D503 D580 D581 D586 D587 D601 D609 D651 D702 D703 D711 D712 D731 D751 D752 D753 D754 D755 D756 D757 D758 D759 D760 D761 Location E-2 H-7 F-4 F-4 E-6 E-5 F-6 F-10 F-10 G-8 H-8 D-9 G-10 C-8 I-4 I-4 I-3 I-3 J-2 D-6 C-5 D-7 C-5 D-7 C-6 D-6 C-6 C-8 D-8 D-8 Ref. No. D762 IC51 IC401 IC501 IC602 IC750 Q1 Q3 Q51 Q52 Q401 Q402 Q403 Q431 Q441 Q451 Q461 Q471 Q481 Q491 Q492 Q503 Q580 Q581 Q582 Q631 Q651 Location D-9 G-2 E-3 H-6 H-8 B-6 F-2 D-2 G-2 G-3 E-3 E-4 E-4 A-3 B-3 C-4 C-4 B-3 C-3 E-5 E-5 E-6 G-10 G-10 G-10 G-9 D-8
Q582 R519 R631
JW47 JW46 R633
R4
JW121
JW69
JW73
JW80
JW56
R573
Q581 Q631 JW37 R632 JW36
JW84
JW124
R51 R52 R54 C58
X51
R9
C57 R53
IC51
R55 C59
JW49
IC501 R592
D301
JW138
C756 R61 R756
D587
JW51
JW52
JW53
JW50
R8
C53
C60
R514 R558
R513 R510
R560 R559
JC19
R539 JC13
R634 C632 R535
R593
JW136
C508
JW77
JW68 JW126
R552
C507
R556 X501
C621
JW133
JW76
JW75
JW70
JW71
R518
R733 C731 C704
JW74
R734 C732
C511 C501
C510 JC14
R547 R509 R565 R508
X502
IC602
JW60 L501 JW65 JW63
JW58 JW44 JW140
R543
C514 D702
R701 JC17
L372
C512
JW103
FMB4
JW82 R579 R591
JW135
C517
R731
R732
L731
L373
D712 D711 JC22
C701 D703
R505
JC20
JC11
R595 R503
R584
R596
JW125
R504
JW129
C513
R566
JW64
JW104
JW105
R585
JW66
L374 CN701 D731
S702
C703
J
(Page 29)
28
28
JW41
I
R502
JC18
JW139
C502
C503
R501
C516
C504
C509
R735
JW62
R636
R506
R564
H
JW78
R567
R511
R512 R541
R563
C515
CDC-R504MP/X504MP
3-14. PRINTED WIRING BOARDS -- DISPLAY SECTION -- · Refer to page 21 for Circuit Boards Location.
: Uses unleaded solder.
1 A
LED903
2
3
4
5
6
7
8
9
10
11
12
LED920 S901 IC971
13
14
S902 S910
LED902
S903
LE
17
D9
D9
S9
15
B
LED904
LE
LED901
14
13
LED921
LED922
LED906
C
LED908
LCD901
S908
LED907
S907 LED905 S906 LED911 S905 LED910 S904 LED909 LED912 S920 S919 S918 LED918 LED913
D
(Page 28)
E
R935
R984 R986 R985 R993 D992
R906
R905
R904
C995 C994 R992 C996 R996
R907
C993
R903
C992 R991
R917 R916
CN901
C902
C901
R919
JC903
R951
R995
R994
C906
R933
R950
R953 R952
R982
R981
R921
F
R934 R918 R908
R936
C991
D902
S9
12
S909
S916
S917
D991
R920
C903
D904
R915 R911
R914 R913 R912 R937
R983
R971
IC901
LED919
S9
LE D9
LE D9 16 S9 15
14
R988
R987
R922
R910
Q901 R931
J601
C905
JC905
D901 R972
S911
G
R932 R909
C904
R939
H
· Semiconductor Location Ref. No. D901 D902 D904 D991 D992 IC901 IC971 LED901 LED902 Location G-10 F-9 F-11 F-8 E-7 F-7 A-13 B-4 B-2 Ref. No. LED903 LED904 LED905 LED906 LED907 LED908 LED909 LED910 LED911 LED912 LED913 Location A-2 B-1 D-5 C-3 D-2 C-2 D-7 D-7 D-5 D-9 D-9 Ref. No. LED914 LED915 LED916 LED917 LED918 LED919 LED920 LED921 LED922 Q901 Location C-12 B-12 C-11 B-11 D-11 B-13 A-12 C-4 C-10 F-6
29
29
C971
R901
R902
R940
R938
CDC-R504MP/X504MP
3-15. SCHEMATIC DIAGRAM -- DISPLAY SECTION --
R931 CN901 R932
R933 R934 LED905
R935
C906
R937 R938 LED914
R939 R940 LED920
R921 R922
R987 R988 R972
R936 LED909
C904
C905 LED921 LED901 IC971 LED908 LED911 LED915 LED919 LED922 LED903 C971
R971
(Page 27)
R981 R982 R983 LED902 R953 LED906 LED910 LED913 LED917 Q901
R991 LED904 LED907 LED912 LED916 LED918 R951 D901 R950 R952 C992 C991 R993 C993 R992 C994 C995 C996 JC905 J601 JC903 R984 R986 R985 R994 R995 R996 IC901
C903
D904
D902
D991
R920 R901 R902 R919 C901 S901 S902 S903
R918
C902
S911
S904
S905
S906
S907
S908
S909
S910 LCD901
R903
R904
R905
R906
R907
R908
R909
R910
R911
R912
R913
R914
R915
R916
R917
S912
S913
S914
S915
S916
S917
S918
S919
S920
30
30
D992
CDC-R504MP/X504MP
3-16. IC BLOCK DIAGRAMS
IC1 LA6560-TE-L-E (SERVO Board)
FWD 1 INPUT REV 2 VCC2 3 VLO- 4 OUTPUT CONTROL
THERMAL SHUTDOWN
36 S-GND 35 VCONT BTL-AMP OUTPUT ON/OFF
MUTE
34 MUTE
33 VIN4
VLO+ 5
32 VIN4-
VO4+ 6
LEVEL SHIFT
31 VIN4+
VO4- 7
30 VREF-IN
VO3+ 8
LEVEL SHIFT
VIN1/VREF-SW
29 VIN1-SW
VO3- 9
28 VREF-OUT
GND
GND
27 REG-OUT VO2+ 10 LEVEL SHIFT
26 REG-IN VO2- 11 25 VIN3+ VO1+ 12 LEVEL SHIFT 24 VIN3-
VO1- 13
23 VIN3
VCC1 14 VIN1 15 AMP-A VIN1-A 16
22 VIN2+
21 VIN2-
20 VIN2
VIN1+A 17
L
H
VIN1-B 18 AMP-B 19 VIN1+B
31
CDC-R504MP/X504MP
IC7 R1114N151D-TR-FA (SERVO Board)
VDD 1
5 VOUT
GND 2 VREF CURRENT LIMIT
CE 3
4 NC
IC51 TDA7333-013TR (MAIN Board)
3 INTERPOLATOR VDDA 1 REF3 2 REF2 3 REF1 4 BAND PASS FILTER SINC4 FILTER SIGMA DELTA CONVERTER
16 MPX 15 INTN
VSS 5
RAM RDS RDSREG BUFFER INTN DEMODULATOR & & SYNCHRONIZATION CONTROL LOGIC
SDAOUT SDAIN TEST LOGIC SCK I C/SPI & INTERFACE SPI PIN MUX'S TESTREG
2
SINC4REG
MPX
14 13 12 11
CSN SA_DATAOUT SDA_DATAIN SCL_CLK
TM 6 VDDD 7 RESETN 8
2 10 XTO OSCILLATOR 9 XTI
32
CDC-R504MP/X504MP
IC401 BD3809FS (MAIN Board)
OUT-SUB-R OUT-SUB-L 17 15 OUT-SEL-R 16 OUT-SEL-L
OUT-RR
OUT-RL
OUT-FR
OUT-FL
DGND
MUTE
BP22
BP12
SDA
VCC
SCL
ADJ
SEL
32
31
30
29
28
27
26 VCC
25
24
23
22
21
20
19
NC
18
I2C BUS LOGIC
VCO
FADER (0~-58, -dB) EFFECT (0dB~ +20dB,2dB STEP)
FADER (0~-58, -dB)
FADER (0~-58, -dB) EFFECT (0dB~ +20dB,2dB STEP)
FADER (0~-58, -dB) 2ND ORDER LPF fc:OFF,80,120,160Hz Q: 0.707 MIX
GAIN+ATT (+10~-29, -dB) 2ND ORDER LPF
BASS fo:60,70,80,100,120,140,160,200Hz Q:0.5,0.75,1,1.25 MIDDLE fo:500Hz,1kHz Q:1
TONE PASS
TONE PASS BASS,TREBLE, MIDDLE (-15dB~+15dB,1dB STEP) BASS,TREBLE, MIDDLE (-15dB~+15dB,1dB STEP)
TABLE fo:5,7.5,10,12.5kHz
VOLUME (+23~-79dB,-dB 1dB STEP)
VOLUME (+23~-79dB,-dB 1dB STEP)
fc:40kHz ANTI-ALIASING FILTER
fc:40kHz ANTI-ALIASING FILTER
INPUT GAIN (0~15dB,1dB STEP) MUTE
INPUT GAIN (0~15dB,1dB STEP) MUTE
INPUT SELECTOR (4 STEREO INCLUDE 1 ISOLATION INPUT)
VCC/2
1 AGND
2 FIL
3 AUX-RCH
4 AN
5 AUX-LCH
6 TU-RCH
7 TU-LCH
8 CD-RCH
9 CD-LCH
10 BUS-RCH
11 BUS-LCH
12 BP11
13 BP21
14 NC
33
CDC-R504MP/X504MP
IC750 TDA8588BJ/N2 (MAIN Board)
TAB 1 2 SDA OUT-FL- 3 FL OUT-FL+ 5 6 VP2 OUT-RL- 7 RL OUT-RL+ 9 8 PGND3 10 SVR 12 IN-FL 14 IN-FR 16 BEEP 18 PGND2 I2C BUS 4 SCL
S-GND 13 IN-RR 15 OUT-RR+ 17
MUTE
PROTECTION/ DIAGNOSTIC
MUTE
IN-RL 11
VP RR
OUT-RR- 19
OUT-FR+ 21 FR OUT-FR- 23 CHIP DETECT/ DIAGNOSTIC DIAG 25 BATTERY DETECTION TEMPERATURE PROTECTION ENABLE LOGIC STANDBY/ MUTE
20 VP1 22 STB
24 PGND1
26 RST ANT-REM 27 SWITCH
28 CRES AMP-REM 29 SWITCH 30 AUDIO8.3V SERVO5V 31 MECH6V 33 VP 35
REGULATOR
32 GND 34 PANEL+B
REFERENCE VOLTAGE B.UP+B 37 REGULATOR LOADDUMP PROTECTION BACK-UP SWITCH
36 CBU
34
CDC-R504MP/X504MP SECTION 4 EXPLODED VIEWS
NOTE: · The mechanical parts with no reference number in the exploded views are not supplied. · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · -XX and -X mean standardized parts, so they may have some difference from the original one. · Color Indication of Appearance Parts Example : KNOB, BALANCE (WHITE) ... (RED) R R Parts Color Cabinet's Color · Accessories are given in the last of this parts list. · Abbreviation CND : Canadian model The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
4-1. MAIN SECTION
MG-611MA-186//Q #1
A
#2
not supplied
A B
7
FU601
4
not supplied #1
5 6
3
#1 TU1
not supplied not supplied
B
2
#1
#1
1
Ref. No. 1 2 3 4 5 5 5 6
Part No. X-3384-725-1 3-042-244-11 X-3383-739-1 3-376-464-11 A-3283-529-A
Description
Remark
Ref. No. 7 7 FU601 TU1 #1 #2
Part No.
Description
Remark
PANEL ASSY, SUB SCREW (T) LOCK ASSY (S) SCREW (+PTT 2.6X6), GROUND POINT MAIN BOARD, COMPLETE (X504MP:US,CND)
1-776-206-21 CORD (WITH CONNECTOR) (POWER) (US,CND) 1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER) (AEP,UK) 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A A-3220-959-A TUNER UNIT (TUX-032//Q) 7-685-792-09 SCREW +PTT 2.6X6 (S) 7-685-790-01 SCREW +PTT 2.6X4 (S)
A-3283-537-A MAIN BOARD, COMPLETE (X504MP:AEP,UK) A-3283-538-A MAIN BOARD, COMPLETE (R504MP) 3-246-481-01 PLATE (TU), GROUND
35
CDC-R504MP/X504MP
4-2. FRONT PANEL SECTION
63 62
not supplied (KEY board) #3
59 57 56
LCD901
58
#3
61 60
not supplied not
51
not supplied
not supplied not supplied not supplied
52 supplied
53
not supplied
55 54
not supplied
Ref. No. 51 51 52 53 54 55 55 56 57
Part No. X-3384-691-1 X-3384-708-1 3-246-479-01 3-262-376-01 3-262-377-01 3-262-353-21 3-262-353-71 1-780-113-11 3-262-382-01
Description BUTTON ASSY (S) (X504MP) BUTTON ASSY (S) (R504MP) SPRING (RELEASE) GUIDE (CD), LIGHT FILTER (IR) PANEL, FRONT (X504MP) PANEL, FRONT (R504MP) CONDUCTIVE BOARD, CONNECTION SHEET (LCD), REFLECTION
Remark
Ref. No. 58 59 60 61 62 63 63 LCD901 #3
Part No. 3-262-380-01 3-262-374-01 1-861-209-11 3-262-355-01 X-3384-688-1 A-3372-840-A A-3372-872-A 1-805-519-11 7-685-106-19
Description ILLUMINATOR (LCD) GUIDE (VOLUME), LIGHT AUX BOARD PANEL, FRONT BACK CASE ASSY (for FRONT PANEL)
Remark
PANEL COMPLETE ASSY, FRONT (X504MP) PANEL COMPLETE ASSY, FRONT (R504MP) DISPLAY PANEL, LIQUID CRYSTAL SCREW +P 2X10 TYPE2 NON-SLIT
36
CDC-R504MP/X504MP
4-3. CD MECHANISM SECTION (1) (MG-611MA-186//Q)
102 109
not supplied (SENSOR board)
101
#4
110
not supplied
not supplied
103
104 106
105 108 107
Ref. No. 101 102 103 104 105 106
Part No. A-3372-444-A 3-253-729-11 3-257-892-11 3-257-892-01 3-253-695-11
Description CHASSIS (T) SUB ASSY SPRING (LTR), TENSION COIL SPRING (DAMPER), COIL SPRING (DAMPER), COIL SPRING (KF), TENSION COIL
Remark
Ref. No. 107 108 109 110 #4
Part No. 3-352-758-31 A-3283-357-A X-3384-088-1 X-3384-089-1 7-627-552-87
Description SCREW (M1.7), TOOTHED LOCK SERVO BOARD, COMPLETE LEVER (L) ASSY LEVER (R) ASSY SCREW, PRECISION +P 1.7X2.2
Remark
3-259-033-01 DAMPER (S)
37
CDC-R504MP/X504MP
4-4. CD MECHANISM SECTION (2) (MG-611MA-186//Q)
155 156
157 154
(including M901)
#5 M902 not supplied
SW4
158
not supplied not supplied
not supplied
153
not supplied
151
152
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
Ref. No. 151 152 0 153 154 155 156
Part No. A-3372-445-A 3-316-938-91 8-820-207-02 A-3372-448-A A-3372-449-A
Description
Remark
Ref. No. 157 158 M902 SW4 #5
Part No. X-3384-090-2 3-264-165-12 A-3372-447-A 1-571-099-11 7-627-850-77
Description LEVER (SL) ASSY SCREW MOTOR ASSY, SL (SLED) SWITCH (1 KEY) (LIMIT) SCREW, PRECISION +P 1.4X1.8
Remark
CHASSIS (OP) COMPLETE ASSY SCREW (B1.4X5), TAPPING OPTICAL PICK-UP (KSS1000E/K1RP) CHASSIS (OP) SUB ASSY (including M901) ARM SUB ASSY, CHUCKING
A-3372-446-A LEVER (SL) SUB ASSY
38
CDC-R504MP/X504MP
4-5. CD MECHANISM SECTION (3) (MG-611MA-186//Q)
201 202
203
207 211 209 208 210 205 204
207 207
M903
#4
206
Ref. No. 201 202 203 204 205 206 207
Part No. 3-348-993-01 3-259-024-01 A-3372-441-A 3-259-455-11 3-253-713-11
Description WASHER WHEEL (RA), WORM ARM ASSY, ROLLER SPRING (RAL) SPRING (RAR)
Remark
Ref. No. 208 209 210 211 M903 #4
Part No. 3-259-467-11 3-345-648-91 A-3372-450-A 3-259-468-11 A-3372-443-A
Description BRACKET (LEM) SCREW (M1.4), TOOTHED LOCK WORM (LEB) ASSY BEARING (LEB) MOTOR ASSY, LE (LOADING)
Remark
3-259-469-11 SPRING (LE), LEAF 2-134-636-21 SCREW (M1.7X2.5)
7-627-552-87 SCREW, PRECISION +P 1.7X2.2
39
CDC-R504MP/X504MP
4-6. CD MECHANISM SECTION (4) (MG-611MA-186//Q)
254 252
255 252 256 251 253
257
Ref. No. 251 252 253 254
Part No. 3-259-429-11 3-344-223-01 3-259-470-11 3-253-755-11
Description WHEEL (LE), WORM WASHER GEAR (LE1) LEVER (D)
Remark
Ref. No. 255 256 257
Part No.
Description
Remark
3-899-829-01 WASHER (SLIT) 3-259-032-01 GEAR (LE2) A-3337-998-A CHASSIS (M) BLOCK ASSY
40
CDC-R504MP/X504MP SECTION 5 ELECTRICAL PARTS LIST
NOTE: · Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. · -XX and -X mean standardized parts, so they may have some difference from the original one. · RESISTORS All resistors are in ohms. METAL:Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F:nonflammable When indicating parts by reference number, please include the board. · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · SEMICONDUCTORS In each case, u : µ, for example: uA.. : µA.. uPA.. : µPA.. uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD.. · CAPACITORS uF : µF · COILS uH : µH · Abbreviation CND : Canadian model
AUX
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
KEY
Ref. No.
Part No.
Description
Remark
Ref. No. JC905
Part No.
Description 0 5%
Remark 1/10W
1-861-209-11 AUX BOARD ********** < JACK >
1-216-864-11 METAL CHIP
< LIQUID CRYSTAL DISPLAY > LCD901 1-805-519-11 DISPLAY PANEL, LIQUID CRYSTAL J601 1-817-308-11 JACK (AUX IN) ************************************************************* KEY BOARD ********** 1-780-113-11 CONDUCTIVE BOARD, CONNECTION 3-262-380-01 ILLUMINATOR (LCD) 3-262-382-01 SHEET (LCD), REFLECTION < CAPACITOR > C901 C902 C903 C904 C905 C906 C971 C991 C992 C993 C994 C995 C996 1-162-968-11 1-162-968-11 1-107-826-11 1-107-826-11 1-107-826-11 1-107-826-11 1-115-156-11 1-107-826-11 1-107-826-11 1-107-826-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.0047uF 0.0047uF 0.1uF 0.1uF 0.1uF 0.1uF 1uF 0.1uF 0.1uF 0.1uF 0.001uF 0.22uF 1uF 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 50V 50V 16V 16V 16V 16V 10V 16V 16V 16V 50V 16V 10V LED901 LED902 LED903 LED904 6-500-476-01 6-500-476-01 6-500-476-01 6-500-476-01 < DIODE > SML310BA1TT86 (MENU) SML310BA1TT86 (MENU) SML310BA1TT86 (OFF) SML310BA1TT86 (+ > M, m . ) LED905 6-500-476-01 LED SML310BA1TT86 (1) LED906 LED907 LED908 LED909 LED910 LED911 LED912 LED913 LED914 LED915 LED916 LED917 LED918 LED919 LED920 6-500-476-01 6-500-476-01 6-500-476-01 6-500-476-01 6-500-476-01 6-500-476-01 6-500-476-01 6-500-476-01 6-500-476-01 6-500-476-01 6-500-476-01 6-500-476-01 6-500-476-01 6-500-476-01 6-500-476-01 LED LED LED LED LED LED LED LED LED LED LED LED LED LED LED SML310BA1TT86 (MENU) SML310BA1TT86 (PTY,AF/TA) SML310BA1TT86 (MENU) SML310BA1TT86 (4) SML310BA1TT86 (3) SML310BA1TT86 (2) SML310BA1TT86 (5) SML310BA1TT86 (6) SML310BA1TT86 (ATT) SML310BA1TT86 (EQ) SML310BA1TT86 (DSPL) SML310BA1TT86 (H-BASS) SML310BA1TT86 (BTM/SENS) SML310BA1TT86 (SOURCE,MODE) SML310BA1TT86 (Z) LED LED LED LED
1-162-964-11 CERAMIC CHIP 1-127-715-11 CERAMIC CHIP 1-115-156-11 CERAMIC CHIP < CONNECTOR >
LED921 6-500-855-01 LED CL-490S-WF-SD-TS (LCD BACK LIGHT) LED922 6-500-855-01 LED CL-490S-WF-SD-TS (LCD BACK LIGHT) < TRANSISTOR >
CN901
1-817-332-11 PLUG, CONNECTOR 15P < DIODE > Q901 8-729-120-28 TRANSISTOR 2SC1623-L5L6 < RESISTOR > R901 R902 R903 R904 R905 R906 R907 R908 R909 R910 1-216-194-00 1-216-819-11 1-216-194-00 1-216-819-11 1-216-819-11 1-216-821-11 1-216-823-11 1-216-823-11 1-216-825-11 1-216-194-00 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 680 680 680 680 680 1K 1.5K 1.5K 2.2K 680 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/8W 1/10W 1/8W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/8W
D901 D902 D904 D991 D992
6-500-886-01 8-719-978-33 8-719-978-33 8-719-069-54 8-719-404-50
DIODE DIODE DIODE DIODE DIODE < IC >
RSA6.1ENTR DTZ-TT11-6.8B DTZ-TT11-6.8B UDZS-TE17-5.1B MA111-TX
IC901 IC971
6-705-180-01 IC LC75827W 6-600-163-01 IC RS-770 (IR) < JUMPER RESISTOR >
JC903
1-216-864-11 METAL CHIP
0
5%
1/10W
41
CDC-R504MP/X504MP KEY
Ref. No. R911 R912 R913 R914 R915 R916 R917 R918 R919 R920 R921 R922 R931 R932 R933 R934 R935 R936 R937 R938 R939 R940 R950 R951 R952 R953 R971 R972 R981 R982 R983 R984 R985 R986 R987 R988 R991 R992 R993 R994 R995 R996
MAIN
Part No. 1-216-819-11 1-216-819-11 1-216-821-11 1-216-823-11 1-216-823-11 1-216-825-11 1-216-827-11 1-218-867-11 1-216-825-11 1-216-825-11 1-216-017-00 1-216-295-11 1-216-033-00 1-216-033-00 1-216-033-00 1-216-033-00 1-216-033-00 1-216-033-00 1-216-033-00 1-216-033-00 1-216-033-00 1-216-033-00 1-216-808-11 1-216-821-11 1-216-824-11 1-216-824-11 1-216-049-11 1-216-821-11 1-216-295-11 1-216-295-11 1-216-295-11 1-216-801-11 1-216-801-11 1-216-801-11 1-216-811-11 1-216-811-11 1-216-864-11 1-216-840-11 1-216-857-11 1-216-827-11 Description METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP SHORT CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP SHORT CHIP SHORT CHIP SHORT CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 680 680 1K 1.5K 1.5K 2.2K 3.3K 6.8K 2.2K 2.2K 47 0 220 220 220 220 220 220 220 220 220 220 82 1K 1.8K 1.8K 1K 1K 0 0 0 22 22 22 150 150 0 39K 1M 3.3K 3.3K 3.3K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W Ref. No. S915 S916 S917 S918 S919 Part No. 1-771-884-31 1-771-884-31 1-771-884-31 1-771-884-31 1-771-884-31 Description SWITCH, TACTILE (ATT) SWITCH, TACTILE (MODE) SWITCH, TACTILE (BTM/SENS) SWITCH, TACTILE (6/ALBUM +) SWITCH, TACTILE (5/ALBUM ) Remark
S920 1-771-884-31 SWITCH, TACTILE (4/SHUF) ************************************************************* A-3283-529-A MAIN BOARD, COMPLETE (X504MP:US,CND) A-3283-537-A MAIN BOARD, COMPLETE (X504MP:AEP,UK) A-3283-538-A MAIN BOARD, COMPLETE (R504MP) ********************* 7-685-134-19 SCREW +P 2.6X8 TYPE2 NON-SLIT 7-685-793-09 SCREW +PTT 2.6X8 (S) 7-685-795-09 SCREW +PTT 2.6X12 (S) < CAPACITOR > C1 C2 C3 C4 C5 C6 C7 C8 C9 C51 1-162-964-11 CERAMIC CHIP 1-162-964-11 CERAMIC CHIP 1-126-963-11 ELECT 1-126-947-11 ELECT 1-126-947-11 ELECT 1-162-970-11 1-164-230-11 1-164-230-11 1-162-970-11 1-126-947-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT 0.001uF 0.001uF 4.7uF 47uF 47uF 0.01uF 220PF 220PF 0.01uF 47uF 10% 10% 20% 20% 20% 10% 5% 5% 10% 20% 50V (R504MP) 50V (R504MP) 50V (R504MP) 16V 16V 25V 50V 50V 25V 16V (R504MP) 16V (R504MP) 16V (R504MP) 16V (R504MP) 16V (R504MP) 16V (R504MP) 16V (R504MP) 16V (R504MP) 50V (R504MP) 50V (R504MP) 50V (R504MP) 25V 25V 25V 10V 50V 50V 25V 50V 50V 50V
C52 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W C53 C54 C55 C56
1-107-826-11 CERAMIC CHIP 1-107-826-11 CERAMIC CHIP 1-107-826-11 CERAMIC CHIP 1-107-826-11 CERAMIC CHIP 1-107-826-11 CERAMIC CHIP
0.1uF 0.1uF 0.1uF 0.1uF 0.1uF
10% 10% 10% 10% 10%
C57 1-216-827-11 METAL CHIP 1-216-827-11 METAL CHIP < SWITCH > S901 S902 S903 S904 S905 S906 S907 S908 S909 S910 S911 S912 S913 S914 1-771-884-31 1-771-884-31 1-771-884-31 1-771-884-31 1-771-884-31 1-771-884-31 1-771-884-31 1-771-884-31 1-771-884-31 1-771-884-31 1-478-474-11 1-771-884-31 1-771-884-31 1-771-884-31 SWITCH, TACTILE (Z) SWITCH, TACTILE (OFF) SWITCH, TACTILE (SOURCE) SWITCH, TACTILE (3/REP) SWITCH, TACTILE (2) SWITCH, TACTILE (1) SWITCH, TACTILE (AF/TA) SWITCH, TACTILE (PTY) SWITCH, TACTILE (SEEK m . ) SWITCH, TACTILE (SEEK + > M) ENCODER, ROTARY (VOLUME,PUSH-MENU) SWITCH, TACTILE (DSPL) SWITCH, TACTILE (H-BASS) SWITCH, TACTILE (EQ) C58 C59 C60 C62
1-107-826-11 CERAMIC CHIP 1-107-826-11 CERAMIC CHIP 1-162-918-11 CERAMIC CHIP 1-162-918-11 CERAMIC CHIP 1-162-959-11 CERAMIC CHIP
0.1uF 0.1uF 18PF 18PF 330PF
10% 10% 5% 5% 5%
C301 C302 C303 C304 C305 C307 C308 C309 C310 C333
1-128-551-11 1-128-551-11 1-128-551-11 1-104-665-11 1-164-230-11 1-164-230-11 1-128-551-11 1-164-230-11 1-164-230-11 1-163-251-11
ELECT ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
22uF 22uF 22uF 100uF 220PF 220PF 22uF 220PF 220PF 100PF
20% 20% 20% 20% 5% 5% 20% 5% 5% 5%
42
CDC-R504MP/X504MP MAIN
Ref. No. C334 C401 C402 C403 C404 C405 C406 C407 C408 C409 C410 C411 C412 C415 C416 C419 C420 C425 C426 C427 C428 C429 C430 C431 C432 C441 C442 C451 C452 C461 C462 C471 C481 C491 C492 C501 C502 C503 C504 C507 C508 C509 C510 C511 C512 C513 C514 C515 C516 C517 C601 C602 C617 C618 C621 C622 C623 Part No. 1-163-251-11 1-125-837-11 1-125-837-11 1-127-715-11 1-127-715-11 1-126-960-11 1-126-960-11 1-126-964-11 1-127-715-11 1-127-715-11 1-127-715-11 1-127-715-11 1-126-947-11 1-125-837-11 1-125-837-11 1-162-966-11 1-162-966-11 1-164-156-11 1-164-156-11 1-162-970-11 1-164-156-11 1-164-156-11 1-125-889-11 1-126-964-11 1-125-891-11 1-126-964-11 1-125-891-11 1-126-964-11 1-125-891-11 1-126-964-11 1-125-891-11 1-126-964-11 1-126-964-11 1-126-947-11 1-107-826-11 1-162-970-11 1-162-964-11 1-104-665-11 1-162-970-11 1-162-917-11 1-162-917-11 1-162-966-11 1-162-970-11 1-126-947-11 1-162-964-11 1-162-970-11 1-162-964-11 1-164-315-11 1-162-964-11 Description CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 100PF 1uF 1uF 0.22uF 0.22uF 1uF 1uF 10uF 0.22uF 0.22uF 0.22uF 0.22uF 47uF 1uF 1uF 5% 10% 10% 10% 10% 20% 20% 20% 10% 10% 10% 10% 20% 10% 10% Remark 50V 6.3V 6.3V 16V 16V 50V 50V 50V 16V 16V 16V 16V 16V 6.3V 6.3V 50V 50V 25V 25V 25V 25V 25V 10V 50V 10V 50V 10V 50V 10V 50V 10V 50V 50V 16V 16V 25V 50V 10V 25V 50V 50V 50V 25V 16V 50V 25V 50V 50V 50V (R504MP) 50V 16V 50V 50V 50V 16V 5.5V 10V Ref. No. C624 C625 C626 C627 C628 C629 C630 C631 C632 C701 C703 C704 C731 C732 C750 C751 C753 C754 C755 C756 C758 C759 C760 C761 C764 C765 C766 Part No. 1-164-161-11 1-164-161-11 1-164-161-11 1-164-161-11 1-164-161-11 1-164-161-11 1-164-161-11 1-164-161-11 1-126-961-11 1-164-156-11 1-164-156-11 1-126-934-11 1-162-965-11 1-162-965-11 1-115-340-11 1-115-340-11 1-128-551-11 1-126-961-11 1-162-923-11 1-127-715-11 1-126-964-11 1-126-964-11 1-104-665-11 1-126-964-11 1-165-822-11 Description CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT ELECT CERAMIC CHIP 0.0022uF 0.0022uF 0.0022uF 0.0022uF 0.0022uF 0.0022uF 0.0022uF 0.0022uF 2.2uF 0.1uF 0.1uF 220uF 0.0015uF 0.0015uF 0.22uF 0.22uF 22uF 2.2uF 47PF 0.22uF 10uF 10uF 100uF 10uF 1uF 1uF 1uF 10% 10% 10% 10% 10% 10% 10% 10% 20% Remark 100V 100V 100V 100V 100V 100V 100V 100V 50V 25V 25V 10V 50V 50V 25V 25V 25V 50V 50V 16V 50V 50V 10V 50V 25V 25V 25V
20% 10% 10% 10% 10% 20% 20% 5% 10% 20% 20% 20% 20%
0.0022uF 10% 0.0022uF 10% 0.1uF 0.1uF 0.01uF 10% 0.1uF 0.1uF 2.2uF 10uF 0.47uF 10uF 0.47uF 10uF 0.47uF 10uF 0.47uF 10uF 10uF 47uF 0.1uF 0.01uF 0.001uF 100uF 0.01uF 15PF 15PF 0.0022uF 0.01uF 47uF 0.001uF 0.01uF 0.001uF 470PF 0.001uF 0.001uF 3300uF 0.1uF 0.001uF 0.001uF 0.1uF
10% 20% 10% 20% 10% 20% 10% 20% 10% 20% 20% 20% 10% 10% 10% 20% 10% 5% 5% 10% 10% 20% 10% 10% 10% 5% 10% 10% 20% 10% 10% 10%
1-165-822-11 CERAMIC CHIP 1-165-822-11 CERAMIC CHIP < CONNECTOR >
CN301 CN601 CN701
1-817-536-11 CONNECTOR, BOARD TO BOARD 28P 1-774-701-21 PIN, CONNECTOR 16P 1-817-333-11 SOCKET, CONNECTOR 15P < DIODE >
D1 D301 D401 D402 D491 D492 D503 D580 D581 D586 D587 D601 D609 D651 D702 D703 D711 D712 D731 D751 D752 D753 D754 D755
8-719-069-55 8-719-041-79 8-719-062-51 6-500-697-01 8-719-069-55 8-719-404-50 8-719-040-04 8-719-056-84 8-719-083-66 8-719-050-84 8-719-050-84 8-719-049-38 8-719-978-33 8-719-083-66 8-719-109-97 8-719-109-97 6-500-886-01 6-500-886-01 8-719-062-51 8-719-970-02 8-719-970-02 8-719-970-02 8-719-970-02 8-719-970-02
DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE
UDZS-TE17-5.6B MA721WA-TX 1PS226-115 UDZS-TE17-3.3B UDZS-TE17-5.6B MA111-TX MA721WK-(TX) UDZ-TE-17-7.5B UDZS-TE17-18B RB441Q-40T-77 RB441Q-40T-77 1N5404TU DTZ-TT11-6.8B UDZS-TE17-18B (AEP,UK) RD6.8ES-B2 RD6.8ES-B2 RSA6.1ENTR RSA6.1ENTR 1PS226-115 1SR139-400 1SR139-400 1SR139-400 1SR139-400 1SR139-400
1-162-964-11 CERAMIC CHIP 1-131-868-81 1-165-319-11 1-163-009-11 1-163-009-11 1-107-826-11 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
1-125-710-11 DOUBLE LAYERS 0.1F 1-104-665-11 ELECT 100uF
20%
43
CDC-R504MP/X504MP MAIN
Ref. No. D756 D757 D758 D759 D760 D761 D762 Part No. 8-719-970-02 8-719-970-02 8-719-970-02 8-719-970-02 8-719-970-02 Description DIODE DIODE DIODE DIODE DIODE 1SR139-400 1SR139-400 1SR139-400 1SR139-400 1SR139-400 Remark Ref. No. Q51 Q52 Q401 Q402 Q403 Q431 Q441 Q451 Q461 Q471 Q481 Q491 Q492 Q503 Q580 Q581 Q582 Q631 Q651 Part No. 8-729-027-23 8-729-027-43 8-729-422-33 8-729-027-23 8-729-035-74 6-550-752-01 6-550-752-01 6-550-752-01 6-550-752-01 6-550-752-01 6-550-752-01 8-729-027-43 8-729-027-23 8-729-027-23 8-729-027-43 1-801-806-11 8-729-120-28 8-729-120-28 8-729-120-28 Description TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR < RESISTOR > JC2 JC6 JC7 JC10 JC11 JC13 JC14 JC17 JC18 JC19 JC20 JC22 JC24 JC25 JC26 1-216-864-11 1-216-296-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-864-11 1-216-864-11 1-216-296-11 1-216-864-11 1-216-296-11 METAL CHIP SHORT CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP METAL CHIP METAL CHIP SHORT CHIP METAL CHIP SHORT CHIP < COIL > L1 L302 L303 L304 L305 L306 L307 L308 L309 L310 L372 L373 L374 L501 L502 L601 L731 1-469-844-11 1-469-876-11 1-469-876-11 1-500-245-11 1-500-245-11 1-500-245-11 1-469-876-11 1-469-876-11 1-500-245-11 1-469-876-11 1-469-876-11 1-500-245-11 1-500-245-11 1-216-864-11 1-500-245-11 INDUCTOR 2.2uH INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD METAL CHIP 0 INDUCTOR, FERRITE BEAD 250uH 10uH R15 R16 R51 R52 R53 1-216-809-11 1-216-809-11 1-414-595-11 1-414-595-11 1-216-801-11 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R1 R4 R5 R6 R7 1-216-821-11 1-216-839-11 1-216-843-11 1-216-839-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1K 33K 68K 33K 68K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W (R504MP) 1/10W (R504MP) 1/10W (X504MP) 1/10W (R504MP) 1/10W (R504MP) 1/10W (X504MP) 1/10W (R504MP) Remark DTA114EKA-T146 (R504MP) DTC114EKA-T146 (R504MP) 2SD601A-Q-TX DTA114EKA-T146 FMG4AT148 DTC614TKT146 DTC614TKT146 DTC614TKT146 DTC614TKT146 DTC614TKT146 DTC614TKT146 DTC114EKA-T146 DTA114EKA-T146 DTA114EKA-T146 DTC114EKA-T146 DTC144EKA 2SC1623-L5L6 2SC1623-L5L6 2SC1623-L5L6 (AEP,UK)
8-719-970-02 DIODE 1SR139-400 8-719-970-02 DIODE 1SR139-400 < IC >
IC51 IC401 IC501 IC602 IC750
6-803-747-01 6-705-518-01 6-804-065-01 8-759-659-13 6-705-360-01
IC IC IC IC IC
TDA7333-013TR (R504MP) BD3809FS-FE2 MN101E01KSH PST3428UL TDA8588BJ/N2
< JACK > J1 J331 1-815-185-13 JACK (ANTENNA) 1-774-698-11 JACK, PIN 2P (AUDIO OUT REAR) < JUMPER RESISTOR >
1-216-843-11 METAL CHIP
R7 R8 5% 5% 5% 1/10W 1/10W 1/10W R9 R9 R10
1-216-845-11 METAL CHIP 1-216-839-11 METAL CHIP 1-216-843-11 METAL CHIP 1-216-845-11 METAL CHIP 1-216-809-11 METAL CHIP
100K 33K 68K 100K 100
5% 5% 5% 5% 5%
METAL CHIP 100 5% 1/10W METAL CHIP 100 5% 1/10W