Text preview for : LG RF043A CHASSIS RU42PX10 PLASMA TV SM.pdf part of LG RU42PX SERVICE MANUAL



Back to : LG RF043A CHASSIS RU42PX1 | Home

This file is provided FREE OF CHARGE from the electromaniacs.com community You are free to distribute this file to other persons who needs it , but without of charge Also on http://electromaniacs.com you can find thousands of service manuals , schematics free of charge

CANADA : http//biz.lgservice.com USA : http//www.lgservice.com : http//lgservice.com/techsup.html

PLASMA TV SERVICE MANUAL
CHASSIS : RF-043A

MODEL : RU-42PX10/C RU-42PX11/H
CAUTION
BEFORE SERVICING THE CHASSIS, READ THE SAFETY PRECAUTIONS IN THIS MANUAL.

SAFETY PRECAUTIONS
IMPORT ANT SAFETY NOTICE
Many electrical and mechanical parts in this chassis have special safety-related characteristics. These parts are identified by in the Schematic Diagram and Replacement Parts List. It is essential that these special safety parts should be replaced with the same components as recommended in this manual to prevent X-RADIATION, Shock, Fire, or other Hazards. Do not modify the original design without permission of manufacturer.

General Guidance
An lsolation Transformer should always be used during the servicing of a receiver whose chassis is not isolated from the AC power line. Use a transformer of adequate power rating as this protects the technician from accidents resulting in personal injury from electrical shocks. It will also protect the receiver and it's components from being damaged by accidental shorts of the circuitary that may be inadvertently introduced during the service operation. If any fuse (or Fusible Resistor) in this monitor is blown, replace it with the specified. When replacing a high wattage resistor (Oxide Metal Film Resistor, over 1W), keep the resistor 10mm away from PCB. Keep wires away from high voltage or high temperature parts. Due to high vacuum and large surface area of picture tube, extreme care should be used in handling the Picture Tube. Do not lift the Picture tube by it's Neck.

Leakage Current Hot Check (See below Figure)
Plug the AC cord directly into the AC outlet. Do not use a line Isolation Transformer during this check. Connect 1.5K/10watt resistor in parallel with a 0.15uF capacitor between a known good earth ground (Water Pipe, Conduit, etc.) and the exposed metallic parts. Measure the AC voltage across the resistor using AC voltmeter with 1000 ohms/volt or more sensitivity. Reverse plug the AC cord into the AC outlet and repeat AC voltage measurements for each esposed metallic part. Any voltage measured must not exceed 0.75 volt RMS which is corresponds to 0.5mA. In case any measurement is out of the limits sepcified, there is possibility of shock hazard and the set must be checked and repaired before it is returned to the customer.

Leakage Current Hot Check circuit

AC Volt-meter

Leakage Current Cold Check(Antenna Cold Check)
With the instrument AC plug removed from AC source, connect an electrical jumper across the two AC plug prongs. Place the AC switch in the on positioin, connect one lead of ohm-meter to the AC plug prongs tied together and touch other ohm-meter lead in turn to each exposed metallic parts such as antenna terminals, phone jacks, etc. If the exposed metallic part has a return path to the chassis, the measured resistance should be between 1M and 5.2M. When the exposed metal has no return path to the chassis the reading must be infinite. An other abnormality exists that must be corrected before the receiver is returned to the customer.

To Instrument's exposed METALLIC PARTS

Good Earth Ground such as WATER PIPE, CONDUIT etc.
0.15uF

1.5 Kohm/10W

CANADA: LG Electronics Canada, Inc. 550 Matheson Boulevard East Mississauga, Ontario L4Z 4G3 USA : LG Customer Interactive Center P.O.Box 240007, 201 James Record Road Huntsville, AL 35824 Digital TV Hotline 1-800-243-0000

- 2 -

TABLE OF CONTENTS
DESCRIPTION OF CONTROLS ...........................................4 SPECIFICATIONS.................................................................7 ADJUSTMENT INSTRUCTIONS ..........................................8 TROUBLE SHOOTING GUIDE ...........................................12 BLOCK DIAGRAM...............................................................23 EXPLODED VIEW...............................................................26 EXPLODED VIEW PARTS LIST .........................................27 REPLACEMENT PARTS LIST ............................................28 SCHEMATIC DIAGRAM.......................................................... PRINTED CIRCUIT BOARD ...................................................

- 3 -

DESCRIPTION OF CONTROLS

Controls
- This is a simplified representation of front panel. Here shown may be somewhat different from your TV. - This manual explains the features available on the RU-42PX10 TVs.

Front Panel Controls

ON/OFF

TV/VIDEO

MENU

VOL

CH

ON/OFF Button Remote Control Sensor

MENU Button TV/VIDEO Button

CHANNEL (E,

D)

Buttons

VOLUME (F,G) Buttons

Power Standby Indicator Illuminates red in standby mode, Illuminates green when the TV is turned on.

- 4 -

DESCRIPTION OF CONTROLS

Connection Options

S-VIDEO Input A connection available to provide better picture quality than the video input.
S-VIDEO

L / MONO

VIDEO Input Connects the video signal from a video device. AUDIO Input Use to connect to hear stereo sound from an external device.

VIDEO

R AUDIO

DVD/DTV Input (Component 1-2) Connect a component video/audio device to these jacks. Remote Control Port Connect your wired remote control here.

Monitor Output Connect a second TV or Monitor. S-Video Input Connect S-Video out from an S-VIDEO device to the S-VIDEO input.

COMPONENT INPUT 2 COMPONENT INPUT 1

A/V INPUT2

MONITOR OUTPUT A/V INPUT 1
R L R L/MONO

REMOTE CONTROL

RS-232C INPUT
(CONTROL/SERVICE)

S-VIDEO

Antenna

AC INPUT

DVI INPUT

AUDIO INPUT

RGB INPUT VIDEO

AUDIO

AUDIO

VIDEO

Audio/Video Input 1 Connect audio/video output from an external device to these jacks. RGB Input/Audio Input/DVI Input Connect the monitor output connector from a PC to the appropriate input port. RS-232C INPUT (CONTROL/SERVICE) PORT Connect to the RS-232C port on a PC.

Antenna Input Connect cable or antenna signals to the TV, either directly or through your cable box.

Power Cord Socket This TV operates on AC power. The voltage is indicated on the Specifications page. Never attempt to operate the TV on DC power.

- 5 -

DESCRIPTION OF CONTROLS

Remote Control Key Functions
- When using the remote control, aim it at the remote control sensor on the TV.

MUTE Switches the sound on or off. TVVIDEO Selects: TV, Video 1-2, Component 1-2, RGB, and DVI input sources. MULTIMEDIA Selects: Component 1-2, RGB, and DVI input sources. CAPTION Selects CAPTION mode.

MUTE

POWER

POWER Turns your TV on or off. MTS Selects the MTS sound: Mono, Stereo, or SAP. MENU Brings up the main menu to the screen. ARC Changes the picture format.

TV/VIDEO MULTIMEDIA MTS

CAPTION ARC

MENU

CH

ENTER
VOL VOL CH

VOLUME UP/DOWN Increases/decreases the sound level. CHANNEL UP/DOWN Selects available channels found with Auto program. ENTER Accepts your selection or displays the current mode. FCR Use to scroll the favorite channel list. APC Adjusts the factory preset picture according to the room. PIP/DW Switches between PIP and Twin picture modes. SPLIT ZOOM Enlarges the picture with regular ration. WIN. SIZE Adjusts the sub picture size. POSITION Moves the sub picture in pip mode. SWAP Exchanges the main/sub images.

1 4 7
FCR

2 5 8 0

3 6 9
REVIEW

NUMBER buttons

REVIEW Tunes to the last channel viewed. DASP Selects the sound appropriate for the program's character. SLEEP Sets the sleep timer. PIPCH-/PIPCH+ Changes to next lower/higher PIP channel. PIP INPUT Selects the input source for the sub picture. A.PROG (AUTO PROGRAM) Searches for available channels. MEMORY/ERASE Memorizes or erases selected channel.

APC PIP/DW

DASP

SPLIT ZOOM PIP CH + SLEEP WIN.SIZE PIP CH - PIP INPUT POSITION SWAP A.PROG MEMORY/ERASE

- 6 -

SPECIFICATIONS

MODELS
Width (inches / mm) Height (inches / mm) Depth (inches / mm) Weight (pounds / kg) Resolution Power requirement Television System Program Coverage External Antenna Impedance Color Operating Temperature Range Operating Humidity Range Maximum Elevation

RU-42PX10/20
48.4 / 1210 27.6 / 701 11.4 / 290 66 / 22.9 852 x 480 (Dot) AC100-240V, 50/60Hz NTSC

RU-50PX10/20
56 / 1400 30.4 / 761.5 11.4 / 290 66 / 29.9 1366 x 768 (Dot)

VHF 2 ~ 13, UHF 14 ~ 69, CATV 1 ~ 125 75 16,770,000 (256 steps of each R, G and B) 32 ~ 104°F (0 ~ 40°C) Less than 80% 6561 feet (2000m)

· The specifications shown above may be changed without notice for quality improvement.

- 7 -

ADJUSTMENT INSTRUCTIONS
1. Application Object
These instructions apply to the RF-043A Chassis. (2) After installing the Gprobe, [Option -> Connection Setup] or click the icon indicated in the picture and then setup as below the picture. (In case of the port (second one), set to the serial port of the connected PC. The other only have to be set as below the picture.) (3) After finishing inputs, click the button [OK] to complete the connection setup.

2. Specification
(1) Because this is not a hot chassis, it is not necessary to use an isolation transformer. However, the use of isolation transformer will help protect test instrument. (2) Adjustment must be done in the correct order. (3) The adjustment must be performed in the circumstance of 25±5°C of temperature and 65±10% of relative humidity if there is no specific designation. (4) The input voltage of the receiver must keep 100~220V, 50/60Hz. (5) The receiver must be operated for about 15 minutes prior to the adjustment. After RGB Full white HEAT-RUN Mode, the receiver must be operated prior to adjustment. O Enter into HEAT-RUN MODE 1) Press the POWER ON KEY on R/C for adjustment. 2) OSD display and screen display 100% full WHITE PATTERN.
O

3-2. Confirming the G-prove
(1) Connect Rs232 cable and then turn on the power. If communication is correct, the message is showed like in the left output terminal. (2) If the message is not showed, push the [INSTART] button of the adjust remocon twice, and change the right selection of the [System Control -> RS-232 Host] from GProbe to PC. ** If it is impossible to check the OSD, push the [TILT] button of the adjust remocon. Then, the message which is "Starting Gprove..." comes up. From this time, communication is operated correctly. However, you have to push the [TILT] button again in case of turning on Main Power. ** If you want to check again whether commnunication is on or not, input "test" and push the Enter key on the right input terminal. If communication is on, the message of "Test passed." will come up

[ Set is activated HEAT-RUN without signal generator in this mode. [ Single color pattern(RED/BLUE/GREEN) of HEAT-RUN mode uses to check PANEL. Caution) If you turn on a still screen more than 20 minutes (Especially digital pattern, cross hatch pattern), a after image may be occur in the black level part of the screen.

3. Channel memory
3-1. Setting up the G-prove
(Fig 2)

3-3. Channel memory method
(1) Click [Command -> Batch]. (2) When the window of [Batch] is showed, enter the text file (Ch_Memory-RZ_PX10.txt) in the right blank of the File. (3) Click the button [OK] to write CH information in the EEPROM. (4) It means the completion of the CH memory download that the message of right output terminal is showed as below. (Fig 1) (1) Install the GProve. (GProve4.4.0.2.exe)

- 8 -

ADJUSTMENT INSTRUCTIONS
Each PCB assembly must be checked by check JIG set. (Because power PCB Assembly damages to PDP Module, especially be careful)

5. POWER PCB Assy Voltage Adjustments (Va, Vs Voltage Adjustments)
5-1. Test Equipment : D.M.M. 1EA 5-2. Connection Diagram for Measuring
(Fig 3) Refer to Fig 5.

4. HDCP download
4-1. Setting up & Confirming the G-prove
: Refer to 3-1 and 3-2.

4-2. HDCP download method
(1) Click [Command -> NVRAM Write] (2) When the window of [NVRAM Write] is showed, select "LGEKEY1.bin" to insert fill up in the File. (3) LGEKEY1 : first KEY value (4) Address : insert `0' (5) After finishing inputs, click the button [OK] to write HDCP key in the EEPROM. (6) It means the end of the HDCP key download that the message of Output terminal is showed as below.
< 3501V00180A >

< 3501V00182A >

(Fig 5) Connection Diagram of power adjustment for measuring

(Fig 4)

5-3. Adjustment Method for P/No. 3501V00180A B/D
(1) Va Adjustment
1) After receiving 100% Full White Pattern, HEAT RUN. 2) Connect + terminal of D.M.M to Va pin of P805, connect - terminal to GND pin of P805. 3) After turning RV501, voltage of D.M.M adjustment as same as Va voltage which on lable of panel right/top (Deviation; ±0.5V)

(2) Vs Adjustment
1) Connect + terminal of D.M.M to Vs pin of P805, connect ­ terminal to GND pin of P805.

- 9 -

ADJUSTMENT INSTRUCTIONS
2) After turning RV401, voltage of D.M.M adjustment as same as Va voltage which on label of panel right/top. (Deviation; ±0.5V) (2) Supply Gray Pattern (216 Level Full Size Pattern) signal to VIDEO input. (AV2 Input 60Hz) (Refer to Fig. 6) (3) To adjust, stick sensor to 216 Gray Level Pattern, press ADJ key twice(White Balance) on remote control. For adjustment and D, E on reomte control for adjustment mode to select Red Gain and Blue Gain, press VOL +, Key and adjust it until color coordination becomes as below. X; 0.283±0.003, Y; 0.297±0.003 Color Temperature; 9,300°K±500°K

5-4. Adjustment Method for P/No. 3501V00182A B/D
(1) Va Adjustment
1) After receiving 100% Full White Pattern, HEAT RUN. 2) Connect + terminal of D.M.M to Va pin of P805, connect - terminal to GND pin of P805. 3) After turning RV601, voltage of D.M.M adjustment as same as Va voltage which on lable of panel right/top (Deviation; ±0.5V)

(4) Exit adjustment mode using A Key.

(2) Vs Adjustment
1) Connect + terminal of D.M.M to Vs pin of P805, connect ­ terminal to GND pin of P805. 2) After turning RV401, voltage of D.M.M adjustment as same as Va voltage which on label of panel right/top. (Deviation; ±0.5V)

7. Auto RGB Color Balance
7-1. Pattern Equipment
PC Pattern Generator (VG828, VG854, 801GF, MSP3240A) (16 Gray Scale Pattrtn output(RGB output Level: 0.7Vp-p)

6. Adjustment of White Balance
6-1. Required Equipment
Color Analyzer (CA-100 or same product)

7-2. Method of Auto RGB Color Balance
(1) Input RGB Source : 16 Gray Scale Pattern output (RGB output Level : 0.7Vp-p) (2) Press ADJ KEY on R/C for adjustment. (3) Press Vol. + KEY and operate To SET. (4) Auto-RGB OK means completed adjustment.

6-2. Connection Diagram of Equipment for Measuring

8. Auto Component Color Balance
216 Gray Level Full Size Pattern 60Hz AV Signal Input

8-1. Pattern Equipment
MSP3240A or same product (16 Gray Scale Pattern output(Component output Level: 0.7Vp-p)

Window

8-2. Method of Auto RGB Color Balance
RS-232C Serial Communication

MSPG-2100 or MSTG-5200

(Fig 6) White Balance Adjustment

(1) Input RGB Source : Component 480p/576p 16 Gray Scale Pattern At this time, except Pb and Pr signal, only Y signal insert. (2) Press ADJ KEY on R/C for adjustment. (3) Press Vol. + KEY and operate To set. (4) Auto-RGB OK means completed adjustment.

6-3. Adjustment of White Balance
O O

Operate the Zero-calibration of the CA-100, then stick sensor to PDP module surface when you adjust. For manual adjustment, it is also possible by the following sequence.

(1) Select white pattern of heat-run mode by pressing power on key on remote control for adjustment then operate heat run more than 15 minutes. (Fig 7) Auto RGB/ Component Color Balance Test Pattern

- 10 -

ADJUSTMENT INSTRUCTIONS
9. Auto Adjustment Map(RS-232C)
RF-043A Type Baud Rate 115200 Data bit 8 RS232 Stop bit 1 Parity NONE 6) If Check Sum is not 53, repeat 3) ~ 4). 7) If Check Sum is 53, DDC data for Analog-RGB input is completed.

(2) DDC Data input for Digital-RGB(DVI)
1) Connect PC Serial to DVI Cable of jig for DDC adjustment to DVI terminal (DVI Jack). 2) Operate S/W for DDC record and select DDC data for digital RGB in model menu. 3) Operate EDID Write command. 4) Operate EDID Read command and check whether Check sum is D2(1page), BF(2page). 5) If Check sum is not D2(1page), BF(2page), repeat 3) ~ 4). 6) If Check sum is D2(1page), BF(2page), DDC data for Analog-RGB input is completed.

Index Cmd1 Cmd2 Data Min Value Max Value R Gain G Gain Protocol B Gain Setting R Offset G Offset B Offset j j j j j j a b c d e f 00(00) 00(00) 00(00) 00(00) 00(00) 00(00) 255(FF) 255(FF) 255(FF) 255(FF) 255(FF) 255(FF)

10. DDC Data Input
10-1. Required Test Equipment
(1) A jig for adjusting PC, DDC (PC serial to D-sub Connection equipment) (2) S/W for writing DDC (EDID Data Write & Read) (3) D-sub 15P Cable, D-Sub to DVI Connector (Connect to DVI Jack)

10-2. Setting of Device

10-3. Preparation for Adjustment
(1) Set devices as above and turn the PC, jig on. (2) Put S/W for writing DDC (EDID data Write & Read) into operation. (operated in DOS mode.)

10-4. Sequence of Adjustment
(1) DDC Data Input for Analog-RGB
1) Put the set on the table and turn the power on. 2) Connect PC Serial to D-sub 15P Cable of jig for DDC adjustment to RGB terminal (D-Sub 15Pin). 3) Operate S/W for DDC record and select DDC data for Analog RGB in Model Menu. 4) Operate EDID Write command. 5) Operate EDID Read command and check whether Check Sum is 53.

- 11 -

TROUBLE SHOOTING GUIDE
1. Power Board
1-1. The whole flowchart which it follows in voltage output state

Start check

Doesn't the screen whole come out?

Yes

It is identical with Power Off condition? Yes

No

Is the Interface signal operated?

Yes 2. Check the Interface signal condition.

No

1. Check the Power Off condition.

Doesn't the low pressure output come out?

Yes

Doesn't the St-by 5V signal come out? Yes

No

Doesn't the 5V Monitor signal come out? Yes 4. Check the 5V Monitor signal circuit.

No

Doesn't the VSC signal RL-ON come out? Yes 5. Check the VSC RL-ON signal.

No

3. Check the St-by 5V signal circuit.

Doesn't the high tension output come out?

Yes

Doesn't the VSC signal Vs-ON come out? Yes

No

Doesn't the Vs, Va voltage output come out? Yes 8. Check the Vs, Va voltage output circuit.

Doesn't the VSC low pressure output come out? Yes 6. Check the VSC low pressure output

No

No

7. Check the VSC Vs-ON signal

High tension output voltage Drop it occurs?

Yes

When remove the Y, Z B/D Module Input Connector, Power Board high tension output voltage Drop it occurs? Yes 9. Check the Power Board Output high tension circuit

No

When remove the Y B/D Module Input Connector, output voltage Drop it occurs? Yes 10. Check the Z B/D Module Coutput circuit

No

When remove the Z B/D Module Input Connector, output voltage Drop it occurs? Yes 11. Check the Y B/D Module Coutput circuit

No

Manufacture enterprise meaning of a passage

- 12 -

TROUBLE SHOOTING GUIDE
1-2. Sony Power Board Structure

T502: Vs Trans T702: Va Trans

1

2

3

T101: St-by Trans T103: Low Voltage Trans

- 13 -

TROUBLE SHOOTING GUIDE
1-3. Sanken Power Board Structure

T221: Vs Trans T271: Va Trans

1

2

3

T121: St-by Trans T201: Low Voltage Trans

- 14 -

TROUBLE SHOOTING GUIDE
2. No Power
(1) Symptom
¯ ¯

Does't minute discharge at module. Non does not come in into the front LED.

(2) Check follow
No Is plug in power cord? Yes No Connect Cable. Plug in power cord.

Is connect the Line Filter and Power Switch Cable? Yes

Is connect the Power Switch and Power Board Cable? Yes

No Connect Cable.

Is normal the Fuse(F101) on Power Board? Yes

No Replace Fuse.

Is connect the Power Board and 7P of VSC Board Cable? Yes

No Connect Cable.

Is connect the Power Switch and Power Board Cable? Yes

No Connect Cable.

After remove the cable connect to Power Board(except the CN101 connection cable), authorizes the AC voltage marking on manual. When ST-BY 5V does not operate, replace Power Board.

- 15 -

TROUBLE SHOOTING GUIDE
3. Protect Mode
(1) Symptom
After once shining, it does not discharge minutely from module ¯ The Rely falls(The sound is audible "click") ¯ It is converted with the color where the front LED is red from green.
¯

(2) Check follow
Is normal the Power Board? Yes Is normal the each connector? Yes Is normal the Y- Board? Yes Is normal the Z- Board? Yes Is normal the X- Board? Yes Is normal the Ctrl Board? Yes Is normal the VSC Board? Yes Is normal the COF of X, Y, Z? No After crisis COF of each board, check the normality operates. If in case normality operates, correspondence COF Fail is replace the module. No Is normal the output voltage after remove P1000, P1200? Yes After remove P1000 normal operation: Replace Analog Board After remove P1200 normal operation: Replace Digital Board No Is normal the output voltage after remove P1, 2, 101, 300, 701, 702 connector of Ctrl-B/D? Yes Replace X-Board. No Is normal the output voltage after remove P1, 2, 3, 4, 6, 7 connector of X-B/D? Yes After remove P1, P2, P3, P4 output voltage normality: Replace Right X-B/D After remove P6, P7 output voltage normality: Replace Left X-B/D No Is normal the Fuse(FS1, FS2) on ZB/D? (In case of open is replace) Yes Is normal the output voltage after remove P1 connector of Z-B/D? Yes Replace Z-Board. No Is normal the Fuse(F52) on Y-B/D? (In case of open is replace) Yes Is normal the output voltage after remove P5, P6 connector of Y-B/D? Yes Replace Y-Board. No After connecting well each connector, the normality it operates? No Replace connector. No Is output the normality Low/High voltage except Stand-by 5V? No Replace Power Board.

- 16 -

TROUBLE SHOOTING GUIDE
4. No Raster
(1) Symptom
¯ ¯

Does't minute discharge at module. It maintains the condition where the front LED is green.

(2) Check follow
Is normal the Power Board? Yes Is normal the each connector? Yes Is normal the Y- Board? Yes Is normal the Z- Board? Yes Is normal the X- Board? Yes Is normal the Ctrl Board? Yes Is normal the VSC Board? Yes Is normal the COF of X, Y, Z? No After crisis COF of each board, check the normality operates. If in case normality operates, correspondence COF Fail is replace the module. No Is normal the output voltage after remove P1000, P1200? Yes After remove P1000 normal operation: Replace Analog Board After remove P1200 normal operation: Replace Digital Board No Is normal the output voltage after remove P1, 2, 101, 300, 701, 702 connector of Ctrl-B/D? Yes Replace X-Board. No Is normal the output voltage after remove P1, 2, 3, 4, 6, 7 connector of X-B/D? Yes After remove P1, P2, P3, P4 output voltage normality: Replace Right X-B/D After remove P6, P7 output voltage normality: Replace Left X-B/D No Is normal the Fuse(FS1, FS2) on ZB/D? (In case of open is replace) Yes Is normal the output voltage after remove P1 connector of Z-B/D? Yes Replace Z-Board. No Is normal the Fuse(F52) on Y-B/D? (In case of open is replace) Yes Is normal the output voltage after remove P5, P6 connector of Y-B/D? Yes Replace Y-Board. No After connecting well each connector, the normality it operates? No Replace connector. No Is output the normality Low/High voltage except Stand-by 5V? No Replace Power Board.

- 17 -

TROUBLE SHOOTING GUIDE
5. In case of occur strange screen into specific mode
5-1. In case of does't display the OSD
(1) Symptom
¯ ¯

LED is green The minute discharge continuously becomes accomplished from module

(2) Check follow
Is normal the LVDS cable? No Is the LVDS cable connected well? No Yes Replace cable.

Yes

Cable inserts well.

Is normal the VSC Digital Board?

No

Operates the Thine Yes IC(IC1100)? No

Operates the IEP(IC500)? No

Yes

Operates the Scaler(IC700)? No

Yes

Replace VSC Digital B/D.

Yes

Replace Thine IC(IC1100).

Replace IEP(IC500).

Replace Scaler(IC700).

Is normal the Ctrl Board of Module?

No Replace Ctrl B/D.

- 18 -

TROUBLE SHOOTING GUIDE

5-2. In case of does't display the screen into specific mode
(1) Symptom
¯

The screen does not become the display from specific input mode (RF, AV, Component, RGB, DVI).

(2) Check follow
¯ ¯

Check the all input mode should become normality display. Check the Video(Main)/Data(Sub), Video(Main)/Video(Sub) should become normality display from the PIP mode or DW mode. (Re-Check it Swap)

(3) In case of becomes unusual display from RF mode
No Is normal the Tuner? Is the Tuner Cable connected well? No Yes Cable inserts well. No No Replace IC Replace Tuner Yes Is normal the Input voltage, IIC Communication and CVBS output? No

Is normal the CXA2069Q? Yes Is normal the VPC3230?

Is normal the Input voltage, IIC Communication and HV sync?

No

Is normal the Input voltage, IIC Communication and HV sync?

No Replace IC

(4) In the case of becomes unusual display from RF, AV mode
Is normal the CXA2069Q? Yes Is normal the VPC3230? No Is normal the Input voltage, IIC Communication and HV sync? No Replace IC No Is normal the Input voltage, IIC Communication and HV sync? No Replace IC

- 19 -

TROUBLE SHOOTING GUIDE
(5) In the case of becomes unusual display from RF, AV, Component 480i mode
Is normal the VPC3230? Yes No Is normal the S2300? Yes No Is normal the Scaler? Is normal the Input voltage, IIC Communication and HV sync? No Replace IC Is normal the Input voltage, IIC Communication and HV sync? No Replace IC No Is normal the Input voltage, IIC Communication and HV sync? No Replace IC

(6) In the case of becomes unusual display from Component DTV mode
Is normal the 74LS123? Yes Is normal the CXA2101? Yes Is normal the M52758? Yes No Is normal the Scaler? Is normal the Input voltage, IIC Communication and HV sync? No Replace IC No Is normal the Input voltage, IIC Communication and HV sync? No Replace IC No Is normal the Input voltage, IIC Communication and HV sync? No Replace IC No Is normal the Input voltage, IIC Communication and HV sync? No Replace IC

- 20 -

TROUBLE SHOOTING GUIDE
(7) In the case of becomes unusual display from RGB DTV mode
Is normal the CXA2101? Yes Is normal the M52758? Yes No Is normal the Scaler? Is normal the Input voltage, IIC Communication and HV sync? No Replace IC No Is normal the Input voltage, IIC Communication and HV sync? No Replace IC No Is normal the Input voltage, IIC Communication and HV sync? No Replace IC

(8) In the case of becomes unusual display from RGB PC mode
Is normal the M52758? Yes No Is normal the Scaler? Is normal the Input voltage, IIC Communication and HV sync? No Replace IC No Is normal the Input voltage, IIC Communication and HV sync? No Replace IC

(8) In the case of becomes unusual display from DVI mode
No Is normal the Scaler? Is normal the Input voltage, IIC Communication and HV sync? No Replace IC

- 21 -

TROUBLE SHOOTING GUIDE
6. In case of no sound
(1) Symptom
¯ ¯

LED is green Screen display but sound is not output

(2) Check follow
Is normal the SPK cable? No Is the SPK cable connected well? No Yes Cable inserts well. Yes Replace SPK cable

Is normal the RGB/DVI sound?

No

Is the Flat cable connected well? No Cable inserts well.

Yes Operates the IC800? No Replace IC800

Yes Operates the IC801? No Replace IC801

Yes

Yes Is normal the RF/AV/Component sound? No Replace VSC Analog B/D

Operates the IC802? No Replace IC802

- 22 -

WIRE IR
RS232_RX/ TX Co mp _480I/ P RGB PC RGB_Dat a ADC w/ PLL

TX IR TX_Out

74ACT253

Co mp / RGB_SW

RS232
ZHINE
RGB DTV Comp DTV CXA_RGB

RX0/1,TX0/1

ST3232C M52758F Sw it c h g m 1601 Sc aler ( Malib u)
24 24

RGB PC/ DTV

RGB (PC/DTV)
CXA2101 IEP
DVI RX w/ HDCP 10

RGB H/ V

74HCT08

SCL/ SDA DVI_Dat a Text Vid eo f o r Text

24LC21

Main_Vid eo / 24 Sub _Vid eo / Co mp / RGB_SW 8 Fro m Malib u

DVI (PC/DTV)
TX0/ 1/ 2/ 3/ C Disp _En SDATA SCLK, SLE

RX/ TX0/ 1/ 2,

RX/ TXC

SCL/ SDA

24LC21

Dig it al BOARD
Main_V Main_YC

Scart 1
VPC3230 (M ) Video Decoder
YCb Cr S2300 / DeInt erlac er 8

TV OUT Vin1 ( CVBS)

1H RGB

HY5DU283222A SDRAM ( 128MB)

Vin2 ( CVBS )

BLOCK DIAGRAM

- 23 Main_V

Scart 2
HY57V64322 SDRAM ( 8MB)

MNT OUT

Scart 3
CXA2069Q SWITCH
Main_YC

Vin3 (CVBS )

AM29LV F-ROM (1MB )

RF

Tuner (M)

VPC3230 (S) Video Decoder

TU_Main

Tuner ( S )
Text _V

TU_Sub

CVBS
SDA6001 Text Processor

Vin4

S-VHS

YCin4

AM29LV160 F-ROM

Po s-t p ro c es sing Blo c k is o m it t ed . so alled JEPICO, in this c ase -c TMDS TX is also req uired . So und Pro c es sing Blo c k Diag ram is sep arat ed . . RCA yp e Blo c k Diag ram is also -t sep arat ed . .

Co mp _480i Vin5 YCin5

Comp1 (DVD/DTV )

Co mp _Y

HYV641620 SRAM

74LS123

Analo g BOARD
CVBS S-VHS

Co mp _480I/ P To Malib u

Sid e - AV BOARD

Di gt a l BOARD IEP

WIRE IR
TMDS Transf er / Thine Analo g RGB DVI g m1501H TQFP 128K DDR Memo ry

Tx

74ACT253

RS232

IIS

ST3232C

HV RGB PC M52758FP IC202( MUX)

74HCT08

ZHINE

RGB ( PC/ DTV)

IIS

24LC21

RGB DTV CXA2101 RGB_DTV VPORT ( 24b it) SVPORT ( 16b it) Flash ROM 512K/ 1M

DVI ( PC/ DTV)

IIS

24LC21

LVDS 31PIN

M52758FP IC204 DAC_RGB DTV2_Co mp DTV_Co mp M37136 ( OTP) DVD_MAIN M52758FP IC400( MUX) ALT_Y_480I_MAIN ALT_Y2_480I_MAIN MAIN_YOUT CAB_VIN COMB_YOUT MAIN_COUT UPD64083 COMB_COUT VPC3230 ( MAIN) M656 8 Bit S/ DVD_Co mp CAB_Co mb FLI2300 RGB_24Bit

Analo g BOARD

HY57V64322 SDRAM ( 8MB)

Co m p 1
DVD2_MAIN

Co mp

BLOCK DIAGRAM

- 24 MAIN_VOUT MAIN_YOUT LA7151M SW CVBS/ Y ALT_Y_480I_SUB ALT_Y2_480I_SUB DVD_SUB DVD2_SUB SUB_YOUT SUB_COUT VPC3230 ( SUB) S656 8 Bit

( DVD/ DT V)

Co mp 2

Co m p 2

( DVD/ DTV)

CVBS IN

VIN1

CVBS OUT

MNT_OUT

S-VHS

Y/ CIN1

RF

Tuner ( M)

CXA2069Q

Tuner ( S)

Sid e A/ V

Side-CVBS

VIN2

M62320FP ( I2C Exp end er)

Sid e S-VHS

Y/ CIN2

NOTES

- 25 -

EXPLODED VIEW

300 121

600 305

601 301

304 120

303 302

200

207 202 206

530 201 490 402 531 203 204

205

580

560 410 520 570 400

401

430

- 26 -

EXPLODED VIEW PARTS LIST
No. 120 121 200 Part No. 6401VD0013H 6401VD0013G 6348Q-E058T 6348Q-E059C 6348Q-E058U 6348Q-E083J 201 202 203 204 205 206 207 300 6871QCH034A 6871QDH066A 6871QDH067A 6871QLH034A 6871QRH037A 6871QYH029A 6871QZH033A 3091V00684B 3091V00684E 3091V00684M 3091V00684S 3091V00684Z 3091V00763A 301 4980V01067A 4980V01067D 4980V01067E 4980V01067B 302 4980V01068A 4980V01068D 4980V01068B 4980V01068E 303 4980V01069A 4980V01069B 4980V01069D 4980V01069E 304 4980V01070A 4980V01070D 4980V01070B 4980V01070E 305 400 401 402 410 430 490 520 530 531 560 570 580 600 601 3790V00709B 3790V00709C 3809V00444C 3809V00444D 3301V00025D 3301V00025G 3301V00023D 4980V01071A 4980V01071B 3501V00171A 3501V00171B 4980V01057A 4980V01057B 6871VMMS16A 6871VSME92A 5020V00915A 5020V00915B 6871VSMS04A 6871VSMZ91A 3501V00182A 6871VSME91A 4811V00118B 4811V00118D SPEAKER ASSEMBLY,FULL RANGE(L) SPEAKER ASSEMBLY,FULL RANGE(R) PDP,42 16:9 852*480 PDP42V60000.AKLGG PDP,42 *42PX11H PDP LGERS PDP,42 852*480 PDP42V60001.DDRSA PCB ASSEMBLY,DISPLAY CTRL ASSY 42V6 NEW MCM(1222) LVDS PCB ASSEMBLY,DISPLAY YDRV ASSY 42V6 YDRV TOP ASSY PCB ASSEMBLY,DISPLAY YDRV ASSY 42V6 YDRV BTM ASSY PCB ASSEMBLY,DISPLAY XRLT ASSY 42V6_XL(4LAYER) PCB ASSEMBLY,DISPLAY XRRT ASSY 42V6_XR(4LAYER) PCB ASSEMBLY,DISPLAY YSUS ASSY 42V6 PCB ASSEMBLY,DISPLAY ZSUS ASSY 42V6 CABINET ASSEMBLY,RU-42PX10 STEREO RF043A NON CABINET ASSEMBLY *LGEUS CABINET ASSEMBLY,RU-42PX11(LGECI) CABINET ASSEMBLY,RU-42PX11(LGEUS) CABINET ASSEMBLY,RU-42PX10C(LGERS) CABINET ASSEMBLY,RU-42PX11 LGEUS SKD(LGERS) SUPPORTER ASSY,AL FILTER TOP RZ-42PZ10 SUPPORTER ASSY,AL FILTER TOP *42PX11H SUPPORTER ASSY,AL FILTER TOP RZ-42PX12X 7T SKD SUPPORTER ASSY,AL FILTER TOP LGERS SUPPORTER ASSY,AL FILTER BOTTOM RZ-42PX10 SUPPORTER ASSY,AL FILTER BOTTOM *42PX11H SUPPORTER ASSY,AL FILTER BOT LGERS SUPPORTER ASSY,AL FILTER BOT RZ-42PX12X 7T SKD SUPPORTER ASSY,AL FILTER RIGHT RZ-42PX10 SUPPORTER ASSY,AL FILTER RIGHT LGERS SUPPORTER ASSY,AL FILTER RIGHT *42PX11H SUPPORTER ASSY,AL FILTER RIGHT RZ-42PX12X 7T SKD SUPPORTER ASSY,AL FILTER LEFT RZ-42PX10 SUPPORTER ASSY,AL FILTER LEFT *42PX11H SUPPORTER ASSY,AL FILTER LEFT LGERS SUPPORTER ASSY,AL FILTER LEFT RZ-42PX12X 7T SKD FILTER(MECH),LGM42-01 MITSUI 42 ETCHING MESH GLASS FILTER FILTER(MECH),LGM42-09 BACK COVER ASSEMBLY BACK COVER ASSEMBLY LGERS PLATE ASSEMBLY,COVER VSC TUNER RU-42PX10 PRESS PLATE ASSEMBLY,VSC TUNER LGERS PLATE ASSEMBLY,AV VSC TUNER RU-42PX10 SUPPORTER ASSY,AL MODULE VER. RZ-42PX10 SUPPORTER ASSY,AL VERTICAL LGERS BOARD ASSEMBLY,BASE BOARD ASSEMBLY,STAND LGERS SUPPORTER,PCB EGI POWER SW. RZ-42PY20 SUPPORTER,PCB EGI POWER SW LGERS PCB ASSEMBLY,MAIN RF043A MALIBU RU MAIN DIGITAL MANUAL PCB ASSEMBLY,SUB PSW RF043A MAILBU BUTTON,POWER RZ-42PY20 ABS 1KEY . BUTTON,POWER LGERS PCB ASSEMBLY,SUB TUNER RF043A MALIBU RU SUB ANALOG MANUAL PCB ASSEMBLY,SUB CONT RF043A NEW HOLDER LOC BOARD ASSEMBLY,POWER RZ-42PX10 RF043A SRX-89 SONY PSU PCB ASSEMBLY,SUB A/V RF043A MALIBU SIDE AV BRACKET ASSEMBLY,DECO RU-42PX10 RF043A SIDE AV BRACKET ASSEMBLY,AV LGERS Description

- 27 -

REPLACEMENT PARTS LIST
For Capacitor & Resistors, the charactors at 2nd and 3rd digit in the P/No. means as follows; CC, CX, CK, CN : Ceramic CQ : Polyestor CE : Electrolytic RD : Carbon Film RS : Metal Oxide Film RN : Metal Film RF : Fusible

RUN DATE : 2004.6.11

LOCA. NO

PART NO

DESCRIPTION

LOCA. NO IC800 IC801

PART NO 0IMCRMN027B 0IMMRMR023A 0IMCRNL001A 0IMCRTI028C 0IKE704200J

DESCRIPTION MSP4440G QA C13 101 MX29LV800TTC 70 48PIN 8MBIT, 3.3V NSP 6241B 64P DIGITAL AUDIO TAS5122DCAR 56P/TSSOP R/TP 30W KIA7042AF SOT 89 TP 4.2V

IC
IC100 IC100 IC1000 IC1001 IC1002 IC1003 IC1004 IC101 IC102 IC103 IC104 IC1100 IC1100 IC1101 IC1200 IC1201 IC1202 IC1300 IC1301 IC1302 IC1303 IC1304 IC1305 IC1306 IC200 IC201 IC202 IC203 IC204 IC400 IC401 IC500 IC500 IC501 IC502 IC503 IC600 IC600 IC601 IC601 IC602 IC700 IC700 IC701 IC702 IC800 0IMMRAL014B 0IMI623200B 0IMCRFA010A 0IPRPML001A 0IMCRSH001A 0ITK118100B 0IMCRSH001A 0IMMRAL014B 0IMCRTI003A 0IMCRTI021A 0IMCRTI021A 0IMCRTH002A 0IMMRNE002A 0ISA715100D 0IMCRSJ001A 0IPRPML001A 0IMCRFA010A 0IMCRRH001A 0IMCRSH001A 0IMCRSH001A 0IMCRRH001A 0IMCRSJ001A 0IMCRRH001A 0IPRPML001A 0IFA742530B 0IMCRSG010A 0IMCRMI006A 0IFA741230A 0IFA741230A 0ISO206900A 0ISO210100B 0ICTMLG018A 0IZZVC0121A 0IMCRTI003A 0IMCRAL006A 0IKE703300E 0IMCRGN002C 0IMCRMI006A 0IMMRHY033A 0IIT323000E 0ISA715100D 0IPRPGN012A 0IIT323000E 0IMMRAL025A 0IKE704200J 0IMMRHY020B AT24C02N 10SI 2.7 8P M62320FP 16P KA7809R 2P MIC39100 3P SOT223 PQ05DZ1U SHARP 5 TK11840L 8P SOT23L DC DC CONVERTER PQ05DZ1U SHARP 5 AT24C02N 10SI 2.7 8P SN74HCT08D 16P SN74LVTH541PWR 20P SN74LVTH541PWR 20P THC63LVD103 64P 10BIT UPD64083GF3BA 100 3D YC LSI LA7151M 10SOP R/TP AUDIO SW SC1565IST 1.8 3P SOT223 MIC39100 3P SOT223 KA7809R 2P BA033FP E2 3P SOP,TO252 3 PQ05DZ1U SHARP 5 PQ05DZ1U SHARP 5 BA033FP E2 3P SOP,TO252 3 SC1565IST 1.8 3P SOT223 BA033FP E2 3P SOP,TO252 3 MIC39100 3P SOT223 74ACT253SC 16P ST3232CDR SOP16 RS232 M52758FP 36PIN DM74LS123MX 16SOP DM74LS123MX 16SOP CXA2069Q QFP64 BK I2C BUS AV S/W CXA2101AQ 80P VIDEO SIGNAL LGDT4410 LG IC 176P QFP TRAY IEP M37136EFSP DIP 52P BK RF 043A SN74HCT08D 16P AT24C16AN 10SI 2.7 8P KIA7033AF 3P SOT 89 FLI2300BD 208P DIGITAL VIDEO M52758FP 36PIN, R/TP PLL IC HY57V643220C(L)T 6 86P 64M VPC3230D C5 80P VIDEO LA7151M 10SOP R/TP AUDIO SW GM1501HBD 416P VPC3230D C5 80P VIDEO AT24C32AN 10SI 2.7 8PIN KIA7042AF SOT 89 TP 4.2V HY5DU283222AQ 5 100P

IC801 IC802 IC805

TRANSISTOR
Q001 Q002 Q100 Q100 Q1000 Q101 Q101 Q102 Q102 Q103 Q103 Q104 Q105 Q106 Q107 Q108 Q110 Q1100 Q1101 Q1102 Q1103 Q1104 Q1105 Q1106 Q1107 Q1108 Q1109 Q111 Q1110 Q1111 Q1112 Q1113 Q1114 Q1115 Q1116 Q1117 Q1118 Q1119 Q112 Q113 Q1200 0TR387500AA 0TR387500AA 0TR830009BA 0TR150400BA 0TRKE80038A 0TR830009BA 0TR387500AA 0TR830009BA 0TR387500AA 0TR830009BA 0TR150400BA 0TR387500AA 0TR387500AA 0TR150400BA 0TR387500AA 0TR150400BA 0TR830009BA 0TR387500AA 0TR150400BA 0TR387500AA 0TR150400BA 0TR150400BA 0TR150400BA 0TR387500AA 0TR387500AA 0TR150400BA 0TR150400BA 0TR830009BA 0TR150400BA 0TR150400BA 0TR150400BA 0TR387500AA 0TR387500AA 0TR150400BA 0TR387500AA 0TR387500AA 0TR387500AA 0TR102009AG 0TR830009BA 0TR830009BA 0TR387500AA CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC BSS83 CHIP 2SA1504S(ASY) KEC KTC3552T RTK SOT 23F 50V 3A BSS83 CHIP 2SC3875S(ALY) KEC BSS83 CHIP 2SC3875S(ALY) KEC BSS83 CHIP 2SA1504S(ASY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SA1504S(ASY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SA1504S(ASY) KEC BSS83 CHIP 2SC3875S(ALY) KEC CHIP 2SA1504S(ASY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SA1504S(ASY) KEC CHIP 2SA1504S(ASY) KEC CHIP 2SA1504S(ASY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SA1504S(ASY) KEC CHIP 2SA1504S(ASY) KEC BSS83 CHIP 2SA1504S(ASY) KEC CHIP 2SA1504S(ASY) KEC CHIP 2SA1504S(ASY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SA1504S(ASY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP KRC102S SOT 23 BSS83 BSS83 CHIP 2SC3875S(ALY) KEC

- 28 -

REPLACEMENT PARTS LIST
LOCA. NO Q1201 Q1202 Q207 Q208 Q209 Q210 Q211 Q214 Q215 Q216 Q217 Q218 Q219 Q300 Q301 Q302 Q303 Q304 Q305 Q306 Q307 Q308 Q309 Q310 Q311 Q312 Q313 Q314 Q315 Q316 Q317 Q318 Q319 Q320 Q321 Q400 Q400 Q401 Q401 Q402 Q402 Q403 Q404 Q405 Q406 Q600 Q601 Q602 Q603 Q800 Q801 PART NO 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR150400BA 0TR387500AA 0TR104009AF 0TR387500AA 0TR150400BA 0TR104009AF 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR150400BA 0TR387500AA 0TR150400BA 0TR387500AA 0TR150400BA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA DESCRIPTION CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SA1504S(ASY) KEC CHIP 2SC3875S(ALY) KEC CHIP KRC104S SOT 23 CHIP 2SC3875S(ALY) KEC CHIP 2SA1504S(ASY) KEC CHIP KRC104S SOT 23 CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SA1504S(ASY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SA1504S(ASY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SA1504S(ASY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC CHIP 2SC3875S(ALY) KEC D100 D100 D1000 D1001 D1002 D1003 D1004 D101 D101 D102 D102 D103 D103 D104 D105 D116 D117 D118 D119 D120 D1200 D1201 D1206 D121 D122 D123 D124 D125 D126 D127 D128 D129 D130 D1300 D1301 D1302 D1303 D1304 D1305 D1306 D131 D200 D201 D202 D203 D204 D205 D500 0DD226239AA 0DD226239AA 0DD226239AA 0DD184009AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD184009AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA LOCA. NO Q802 PART NO 0TR387500AA DESCRIPTION CHIP 2SC3875S(ALY) KEC

DIODE
CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 KDS184S CHIP 85V 300MA CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 KDS184S CHIP 85V 300MA CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 CHIP KDS226 SOT 23

- 29 -

REPLACEMENT PARTS LIST
LOCA. NO D501 D502 LD001 LD1000 LD1001 LD1002 LD1003 LD1100 LD1203 LD1204 LD1206 LD1207 LD500 LD501 LD502 LD503 ZD100 ZD101 ZD102 ZD103 ZD104 ZD105 ZD400 ZD401 ZD800 PART NO 0DD226239AA 0DD226239AA 0DL200000CA 0DL233309AC 0DL233309AC 0DL233309AC 0DL233309AC 0DL233309AC 0DL233309AC 0DL233309AC 0DL233309AC 0DL233309AC 0DL233309AC 0DL233309AC 0DL233309AC 0DL233309AC 0DR050008AA 0DR050008AA 0DR050008AA 0DR050008AA 0DR050008AA 0DR050008AA 0DR050008AA 0DR050008AA 0DZ820009AH DESCRIPTION CHIP KDS226 SOT 23 CHIP KDS226 SOT 23 LED,SAM5670(DL 2LRG) LED,SAM2333 LED,SAM2333 LED,SAM2333 LED,SAM2333 LED,SAM2333 LED,SAM2333 LED,SAM2333 LED,SAM2333 LED,SAM2333 LED,SAM2333 LED,SAM2333 LED,SAM2333 LED,SAM2333 SD05.TC SOD323 5V 5A 15A SD05.TC SOD323 5V 5A 15A SD05.TC SOD323 5V 5A 15A SD05.TC SOD323 5V 5A 15A SD05.TC SOD323 5V 5A 15A SD05.TC SOD323 5V 5A 15A SD05.TC SOD323 5V 5A 15A SD05.TC SOD323 5V 5A 15A ZENERS,MTZJ8.2B LOCA. NO C1058 C1059 C106 C1060 C1061 C1063 C1066 C1067 C107 C1072 C1074 C1077 C108 C1081 C1083 C1084 C1087 C110 C1108 C111 C112 C1128 C1129 C113 C114 C114 C1145 C1146 C1147 C1152 C1159 C1160 C120 C1201 C1202 C1204 C1205 C1206 C1207 C1209 C121 C121 C1211 C1212 C1215 C1216 C1218 C1220 C1229 C1230 C1232 PART NO 0CE107SF6DC 0CE477DJ618 0CE227VF6DC 0CE227VF6DC 0CE107SF6DC 0CE227VF6DC 0CE107SF6DC 0CE477DJ618 0CE477SF6DC 0CE107SF6DC 0CE107SF6DC 0CE107SF6DC 0CE477SF6DC 0CE107SF6DC 0CE107SF6DC 0CE107SF6DC 0CE107SF6DC 0CE227VF6DC 0CE106SF6DC 0CE475SK6DC 0CE477SF6DC 0CE106SF6DC 0CN105EJ56A 0CE106SF6DC 0CE474SK6DC 0CE475SK6DC 0CN105EJ56A 0CE106SF6DC 0CE106SF6DC 0CE106SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CH2103K516 0CE476SF6DC 0CH2103K516 0CE107SF6DC 0CE477SF6DC 0CH2103K516 0CH2103K516 0CE476SF6DC 0CE477SF6DC 0CE477SF6DC 0CE477SF6DC 0CE477SF6DC 0CE227VF6DC 0CE477SF6DC 0CE227VF6DC 0CE227VF6DC 0CH2103K516 0CH2103K516 DESCRIPTION 100UF MVG 16V M 470UF STD 35V 20% 220UF MV 16V 20% 220UF MV 16V 20% 100UF MVG 16V M 220UF MV 16V 20% 100UF MVG 16V M 470UF STD 35V 20% 470UF MVG 16V 20% 100UF MVG 16V M 100UF MVG 16V M 100UF MVG 16V M 470UF MVG 16V 20% 100UF MVG 16V M 100UF MVG 16V M 100UF MVG 16V M 100UF MVG 16V M 220UF MV 16V 20% 10UF MVG 16V 20% 4.7UF MVG 50V 20% 470UF MVG 16V 20% 10UF MVG 16V 20% 1.0UF 3216 35V 10% 10UF MVG 16V 20% 0.47UF MVG 50V M 4.7UF MVG 50V 20% 1.0UF 3216 35V 10% 10UF MVG 16V 20% 10UF MVG 16V 20% 10UF MVG 16V 20% 47UF MVG 16V M 47UF MVG 16V M 47UF MVG 16V M 10000P 50V K B 47UF MVG 16V M 10000P 50V K B 100UF MVG 16V M 470UF MVG 16V 20% 10000P 50V K B 10000P 50V K B 47UF MVG 16V M 470UF MVG 16V 20% 470UF MVG 16V 20% 470UF MVG 16V 20% 470UF MVG 16V 20% 220UF MV 16V 20% 470UF MVG 16V 20% 220UF MV 16V 20% 220UF MV 16V 20% 10000P 50V K B 10000P 50V K B

CAPACITOR
C002 C1001 C1002 C1003 C1004 C1006 C1016 C1017 C1018 C102 C102 C1020 C1022 C1025 C1027 C1031 C1037 C104 C1041 C1042 C1045 C1046 C105 C1052 0CE4763F618 0CE107SF6DC 0CE227VF6DC 0CE107SF6DC 0CE475SK6DC 0CE477SF6DC 0CE107SF6DC 0CE107SF6DC 0CE107SF6DC 0CE474SK6DC 0CE475SK6DC 0CE107SF6DC 0CE477SF6DC 0CE475SK6DC 0CE107SF6DC 0CE477SF6DC 0CE477SF6DC 0CE476DF618 0CE107SF6DC 0CE477SF6DC 0CE107SF6DC 0CE107SF6DC 0CE476DF618 0CE107SF6DC 47UF SRE 16V M 100UF MVG 16V M 220UF MV 16V 20% 100UF MVG 16V M 4.7UF MVG 50V 20% 470UF MVG 16V 20% 100UF MVG 16V M 100UF MVG 16V M 100UF MVG 16V M 0.47UF MVG 50V M 4.7UF MVG 50V 20% 100UF MVG 16V M 470UF MVG 16V 20% 4.7UF MVG 50V 20% 100UF MVG 16V M 470UF MVG 16V 20% 470UF MVG 16V 20% 47UF STD 16V M 100UF MVG 16V M 470UF MVG 16V 20% 100UF MVG 16V M 100UF MVG 16V M 47UF STD 16V M 100UF MVG 16V M

- 30 -

REPLACEMENT PARTS LIST
LOCA. NO C1233 C124 C1245 C1247 C1249 C1250 C1251 C1252 C1254 C1256 C1257 C1258 C1259 C1260 C127 C1271 C1273 C1274 C1275 C1277 C1279 C1304 C1305 C1310 C1311 C1313 C1314 C1315 C1317 C1331 C1333 C1340 C1341 C1342 C1343 C1344 C1345 C1353 C1355 C1359 C1362 C1366 C1368 C1371 C1372 C1373 C1374 C1384 C1388 C1390 C1391 PART NO 0CE477SF6DC 0CE107SF6DC 0CH2103K516 0CH2103K516 0CE227VF6DC 0CE227VF6DC 0CE477SF6DC 0CH2103K516 0CE227VF6DC 0CE227VF6DC 0CE227VF6DC 0CH2103K516 0CE227VF6DC 0CH2103K516 0CE475SK6DC 0CH2103K516 0CE476SF6DC 0CE107SF6DC 0CE107SF6DC 0CH2103K516 0CE107SF6DC 0CH2103K516 0CE107SF6DC 0CH2103K516 0CH2103K516 0CH2103K516 0CE476SF6DC 0CE107SF6DC 0CE107SF6DC 0CE477SF6DC 0CE477SF6DC 0CH2103K516 0CH2103K516 0CH2103K516 0CH2103K516 0CH2103K516 0CH2103K516 0CE477SF6DC 0CE477SF6DC 0CH2103K516 0CE107SF6DC 0CE227VF6DC 0CE227VF6DC 0CH2103K516 0CH2103K516 0CE107SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CH2103K516 0CE477SF6DC DESCRIPTION 470UF MVG 16V 20% 100UF MVG 16V M 10000P 50V K B 10000P 50V K B 220UF MV 16V 20% 220UF MV 16V 20% 470UF MVG 16V 20% 10000P 50V K B 220UF MV 16V 20% 220UF MV 16V 20% 220UF MV 16V 20% 10000P 50V K B 220UF MV 16V 20% 10000P 50V K B 4.7UF MVG 50V 20% 10000P 50V K B 47UF MVG 16V M 100UF MVG 16V M 100UF MVG 16V M 10000P 50V K B 100UF MVG 16V M 10000P 50V K B 100UF MVG 16V M 10000P 50V K B 10000P 50V K B 10000P 50V K B 47UF MVG 16V M 100UF MVG 16V M 100UF MVG 16V M 470UF MVG 16V 20% 470UF MVG 16V 20% 10000P 50V K B 10000P 50V K B 10000P 50V K B 10000P 50V K B 10000P 50V K B 10000P 50V K B 470UF MVG 16V 20% 470UF MVG 16V 20% 10000P 50V K B 100UF MVG 16V M 220UF MV 16V 20% 220UF MV 16V 20% 10000P 50V K B 10000P 50V K B 100UF MVG 16V M 47UF MVG 16V M 47UF MVG 16V M 47UF MVG 16V M 10000P 50V K B 470UF MVG 16V 20% LOCA. NO C1395 C1397 C1398 C1400 C1402 C1404 C1408 C1410 C1411 C1413 C1415 C1420 C1424 C1425 C1427 C207 C208 C209 C210 C212 C217 C222 C222 C223 C223 C224 C224 C227 C228 C229 C230 C251 C253 C254 C256 C258 C259 C260 C261 C262 C263 C270 C271 C272 C274 C276 C284 C285 C286 C288 C289 PART NO 0CH2103K516 0CH2103K516 0CH2103K516 0CE476SF6DC 0CE476SF6DC 0CE477SF6DC 0CH2103K516 0CE477SF6DC 0CH2103K516 0CH2103K516 0CE477SF6DC 0CH2103K516 0CH2103K516 0CE107SF6DC 0CH2103K516 0CH2103K516 0CE106SF6DC 0CE477SF6DC 0CE106SF6DC 0CH2103K516 0CH2103K516 0CE476XFKDC 0CE476SF6DC 0CE476XFKDC 0CE476SF6DC 0CE476XFKDC 0CE476SF6DC 0CH2103K516 0CH2103K516 0CH2103K516 0CE107SF6DC 0CE106SF6DC 0CH2103K516 0CN105EJ56A 0CH2103K516 0CE476SF6DC 0CH2103K516 0CH2103K516 0CE476SF6DC 0CH2103K516 0CE476SF6DC 0CH2103K516 0CH2103K516 0CE107SF6DC 0CE107SF6DC 0CE107SF6DC 0CH2103K516 0CH2103K516 0CH2103K516 0CE106SF6DC 0CN105EJ56A DESCRIPTION 10000P 50V K B 10000P 50V K B 10000P 50V K B 47UF MVG 16V M 47UF MVG 16V M 470UF MVG 16V 20% 10000P 50V K B 470UF MVG 16V 20% 10000P 50V K B 10000P 50V K B 470UF MVG 16V 20% 10000P 50V K B 10000P 50V K B 100UF MVG 16V M 10000P 50V K B 10000P 50V K B 10UF MVG 16V 20% 470UF MVG 16V 20% 10UF MVG 16V 20% 10000P 50V K B 10000P 50V K B 47UF MVK BP,CN 16V 20%, 20% 47UF MVG 16V M 47UF MVK BP,CN 16V 20%, 20% 47UF MVG 16V M 47UF MVK BP,CN 16V 20%, 20% 47UF MVG 16V M 10000P 50V K B 10000P 50V K B 10000P 50V K B 100UF MVG 16V M 10UF MVG 16V 20% 10000P 50V K B 1.0UF 3216 35V 10% 10000P 50V K B 47UF MVG 16V M 10000P 50V K B 10000P 50V K B 47UF MVG 16V M 10000P 50V K B 47UF MVG 16V M 10000P 50V K B 10000P 50V K B 100UF MVG 16V M 100UF MVG 16V M 100UF MVG 16V M 10000P 50V K B 10000P 50V K B 10000P 50V K B 10UF MVG 16V 20% 1.0UF 3216 35V 10%

- 31 -

REPLACEMENT PARTS LIST
LOCA. NO C290 C292 C300 C301 C303 C315 C316 C317 C322 C324 C334 C335 C400 C401 C402 C404 C406 C409 C410 C423 C424 C429 C435 C440 C442 C508 C520 C524 C526 C601 C605 C607 C608 C611 C612 C614 C626 C627 C632 C634 C637 C651 C671 C672 C673 C674 C702 C703 C710 C713 C720 PART NO 0CH2103K516 0CH2103K516 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE227VF6DC 0CE476SF6DC 0CE107SF6DC 0CE227VF6DC 0CE476SF6DC 0CH2103K516 0CE107SF6DC 0CE105SK6DC 0CH2103K516 0CE107SF6DC 0CE107SF6DC 0CE106SF6DC 0CE106SF6DC 0CN105EJ56A 0CE476SF6DC 0CE476SF6DC 0CE107SF6DC 0CE107SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE107SF6DC 0CE107SF6DC 0CE107SF6DC 0CE106SF6DC 0CE106SF6DC 0CE106SF6DC 0CE106SF6DC 0CE106SF6DC 0CE106SF6DC 0CE106SF6DC 0CE107SF6DC 0CE226SF6DC 0CE106SF6DC 0CE106SF6DC 0CE226SF6DC DESCRIPTION 10000P 50V K B 10000P 50V K B 47UF MVG 16V M 47UF MVG 16V M 47UF MVG 16V M 47UF MVG 16V M 47UF MVG 16V M 47UF MVG 16V M 47UF MVG 16V M 47UF MVG 16V M 47UF MVG 16V M 47UF MVG 16V M 220UF MV 16V 20% 47UF MVG 16V M 100UF MVG 16V M 220UF MV 16V 20% 47UF MVG 16V M 10000P 50V K B 100UF MVG 16V M 1UF MVG 50V M 10000P 50V K B 100UF MVG 16V M 100UF MVG 16V M 10UF MVG 16V 20% 10UF MVG 16V 20% 1.0UF 3216 35V 10% 47UF MVG 16V M 47UF MVG 16V M 100UF MVG 16V M 100UF MVG 16V M 47UF MVG 16V M 47UF MVG 16V M 47UF MVG 16V M 47UF MVG 16V M 47UF MVG 16V M 47UF MVG 16V M 100UF MVG 16V M 100UF MVG 16V M 100UF MVG 16V M 10UF MVG 16V 20% 10UF MVG 16V 20% 10UF MVG 16V 20% 10UF MVG 16V 20% 10UF MVG 16V 20% 10UF MVG 16V 20% 10UF MVG 16V 20% 100UF MVG 16V M 22UF MVG 16V 20% 10UF MVG 16V 20% 10UF MVG 16V 20% 22UF MVG 16V 20% L1004 6140VB0004B JK103 JK200 JK201 JK202 P101 P102 P200 P201 6613V00026A 6612VJH020B 6612VJH020C 6612VJH019B 380-068E 6612BBBHN6A 380-363G 380-068E LOCA. NO C723 C727 C737 C744 C752 C757 C762 C769 C777 C778 C785 C800 C801 C802 C803 C812 C817 C821 C822 C825 C827 C828 C829 C834 C834 C837 C840 C841 C847 C851 C852 C862 C863 C872 C873 C874 R112 R113 PART NO 0CE226SF6DC 0CE106SF6DC 0CE226SF6DC 0CE226SF6DC 0CE226SF6DC 0CE226SF6DC 0CE226SF6DC 0CE226SF6DC 0CE226SF6DC 0CE226SF6DC 0CE335SK6DC 0CE226SF6DC 0CE226SF6DC 0CE476SF6DC 0CE226VF6DC 0CE226VF6DC 0CE226SF6DC 0CH2103K516 0CE107SF6DC 0CE335SK6DC 0CE107SF6DC 0CE106SF6DC 0CE106SF6DC 0CE107SF6DC 0CE106SF6DC 0CE106SF6DC 0CE106SF6DC 0CE107SF6DC 0CN105EJ56A 0CE108DH618 0CE108DH618 0CF4741L438 0CF4741L438 0CE335SK6DC 0CN105EJ56A 0CE108DH618 0CH3104K566 0CH3104K566 DESCRIPTION 22UF MVG 16V 20% 10UF MVG 16V 20% 22UF MVG 16V 20% 22UF MVG 16V 20% 22UF MVG 16V 20% 22UF MVG 16V 20% 22UF MVG 16V 20% 22UF MVG 16V 20% 22UF MVG 16V 20% 22UF MVG 16V 20% 3.3UF MVG 50V 20% 22UF MVG 16V 20% 22UF MVG 16V 20% 47UF MVG 16V M 22UF MV 16V 20% 22UF MV 16V 20% 22UF MVG 16V 20% 10000P 50V K B 100UF MVG 16V M 3.3UF MVG 50V 20% 100UF MVG 16V M 10UF MVG 16V 20% 10UF MVG 16V 20% 100UF MVG 16V M 10UF MVG 16V 20% 10UF MVG 16V 20% 10UF MVG 16V 20% 100UF MVG 16V M 1.0UF 3216 35V 10% 1000UF STD 25V M 1000UF STD 25V M 0.47UF D 63V 5% 0.47UF D 63V 5% 3.3UF MVG 50V 20% 1.0UF 3216 35V 10% 1000UF STD 25V M 0.1UF 50V 10% 0.1UF 50V 10%

JACK
JACK ASSEMBLY,UJB 03 28A JACK,RCA PPJ122B 6P JACK,RCA PPJ122C 6P JACK,RCA PPJ121B 4P JACK,PHONE UEJ CV 018 JACK,DIN 440062 JACK,DIN 6046B 01S JACK,PHONE UEJ CV 018

COIL
COIL,CHOKE 26UH

- 32 -

REPLACEMENT PARTS LIST
LOCA. NO L1005 L1006 L1007 L1200 L1203 L1209 L1213 L803 L804 L805 L806 PART NO 6140VB0004B 6140VB0004B 6140VB0004B 6140VB0004B 6140VB0004B 6140VB0004B 6140VB0004B 6140VB0022A 6140VB0022A 6140VB0022A 6140VB0022A DESCRIPTION COIL,CHOKE 26UH COIL,CHOKE 26UH COIL,CHOKE 26UH COIL,CHOKE 26UH COIL,CHOKE 26UH COIL,CHOKE 26UH COIL,CHOKE 26UH COIL,CHOKE CPS 0810 GET 22UH COIL,CHOKE CPS 0810 GET 22UH COIL,CHOKE CPS 0810 GET 22UH COIL,CHOKE CPS 0810 GET 22UH LOCA. NO AR615 AR616 AR617 AR618 AR700 AR701 AR701 AR702 AR703 AR707 AR708 AR709 AR710 AR711 AR712 AR713 AR714 AR715 AR717 AR718 AR719 R801 R802 PART NO 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RKZVTA001L 0RKZVTA001L DESCRIPTION 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 1.0M OHM 1/2 W 5% 1.0M OHM 1/2 W 5%

RESISTOR
AR1101 AR1102 AR1103 AR1104 AR1105 AR1106 AR500 AR503 AR507 AR508 AR509 AR512 AR513 AR520 AR521 AR522 AR523 AR524 AR525 AR600 AR600 AR601 AR601 AR602 AR602 AR603 AR603 AR604 AR605 AR606 AR607 AR608 AR609 AR610 AR611 AR612 AR613 AR614 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5%

SWITCH
SW001 SW002 SW003 SW004 SW005 SW006 SW700 SW800 SW800 140-315A 140-315A 140-315A 140-315A 140-315A 140-315A 140-313B 6600VM2006A 140-275A SWITCH,TACT SKHV17910B 12V SWITCH,TACT SKHV17910B 12V SWITCH,TACT SKHV17910B 12V SWITCH,TACT SKHV17910B 12V SWITCH,TACT SKHV17910B 12V SWITCH,TACT SKHV17910B 12V SWITCH,TACT 2LEAD 160G(TA) SWITCH,PUSH SDDF3PATP011 SWITCH,PUSH JDPB21SA 30V 0.3A

FILTER & CRYSTAL
L100 L100 L1000 L1002 L1008 L1009 L101 L101 L1010 L1011 L1012 L1013 L1014 L1015 L1016 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT

- 33 -

REPLACEMENT PARTS LIST
LOCA. NO L1017 L1018 L1019 L102 L102 L1020 L1021 L103 L103 L104 L105 L105 L106 L107 L108 L1102 L1206 L1207 L1210 L1211 L1216 L1217 L1300 L1302 L1307 L1310 L1311 L1312 L1313 L1314 L1315 L1316 L1317 L1318 L1321 L1322 L1325 L1326 L1327 L1328 L1329 L1330 L1331 L1332 L1333 L200 L201 L202 L203 L204 L204 PART NO 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6200JB8010L 6200JB8010L 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6200JB8013L 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0005A DESCRIPTION FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC MLB 201209 1000L FILTER,EMC MLB 201209 1000L FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC 60 OHM TB201209U060 FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC BK2125 HS 750 LOCA. NO L205 L205 L206 L206 L207 L207 L208 L208 L209 L210 L211 L212 L213 L214 L214 L215 L215 L216 L216 L217 L300 L301 L302 L303 L304 L305 L400 L400 L401 L401 L402 L403 L404 L405 L406 L502 L503 L609 L610 L700 L800 L807 L808 LT1100 LT1101 LT1102 LT1103 R102 R103 R106 R107 PART NO 6210VC0006A 6210VC0005A 6210VC0006A 6210VC0005A 6210VC0006A 6210VC0005A 6210VC0006A 6210VC0005A 6210VC0005A 6200JB8010L 6200JB8010L 6200JB8010L 6200JB8010L 6200JB8010L 6200JB8010L 6200JB8010L 6200JB8010L 6200JB8010L 6200JB8010L 6200JB8010L 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0005A 6210VC0005A 6210VC0005A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6200JB8010L 6200JB8010L 6200C000010 6200C000010 6200C000009 6200C000009 6200JB8010L 6200JB8010L 6200JB8010L 6200JB8010L DESCRIPTION FILTER,EMC FBMH3216 HM501NT FILTER,EMC BK2125 HS 750 FILTER,EMC FBMH3216 HM501NT FILTER,EMC BK2125 HS 750 FILTER,EMC FBMH3216 HM501NT FILTER,EMC BK2125 HS 750 FILTER,EMC FBMH3216 HM501NT FILTER,EMC BK2125 HS 750 FILTER,EMC BK2125 HS 750 FILTER,EMC MLB 201209 1000L FILTER,EMC MLB 201209 1000L FILTER,EMC MLB 201209 1000L FILTER,EMC MLB 201209 1000L FILTER,EMC MLB 201209 1000L FILTER,EMC MLB 201209 1000L FILTER,EMC MLB 201209 1000L FILTER,EMC MLB 201209 1000L FILTER,EMC MLB 201209 1000L FILTER,EMC MLB 201209 1000L FILTER,EMC MLB 201209 1000L FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC BK2125 HS 750 FILTER,EMC BK2125 HS 750 FILTER,EMC BK2125 HS 750 FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC MLB 201209 1000L FILTER,EMC MLB 201209 1000L FILTER,B.P. H354LAI K5202 FILTER,B.P. H354LAI K5202 FILTER,B.P. H354LAI K5225 FILTER,B.P. H354LAI K5225 FILTER,EMC MLB 201209 1000L FILTER,EMC MLB 201209 1000L FILTER,EMC MLB 201209 1000L FILTER,EMC MLB 201209 1000L

- 34 -

REPLACEMENT PARTS LIST
LOCA. NO R108 X1100 X500 X600 X600 X700 X700 X800 PART NO 6200JB8010L 6212AB2015B 6202VDT002D 6202VDT002J 6202VDB007B 6202VDT002B 6202VDB007B 156-A02M DESCRIPTION FILTER,EMC MLB 201209 1000L RESONATOR,CRYSTAL HC 49/SM5H 20MHZ RESONATOR,CRYSTAL SX 1SMD 8.0MHZ RESONATOR,CRYSTAL SX 1 13.500000MHZ RESONATOR,CRYSTAL HC49U 20.250MHZ RESONATOR,CRYSTAL SX 1 SC14.3MHZ RESONATOR,CRYSTAL HC49U 20.250MHZ RESONATOR,CRYSTAL HC49U 18.432MHZ LOCA. NO PART NO DESCRIPTION

CONNECTOR
C10 C11 C12 C13 C14 C15 C4 C5 C6 C7 C8 C9 P100 P200 6631V25083C 6631V25084C 6631V39013Z 6631V39022D 6631V39023C 6631Q20003C 6631V10008A 6631V39021H 6631V00020F 387-J12M 387-J10K 6631V00045G 6630VGA001C 6630VGA004B CONNECTOR ASSEMBLY,7P 2.5MM 200MM CONNECTOR ASSEMBLY,12P 2.5MM 200MM CONNECTOR ASSEMBLY,8P 3.96MM 650MM CONNECTOR ASSEMBLY,4P 3.96MM 250MM CONNECTOR ASSEMBLY,10P 3.96MM 200MM CONNECTOR ASSEMBLY,2.0MM 8PIN 100MM CONNECTOR ASSEMBLY,31P 1.0MM 50MM CONNECTOR ASSEMBLY,4P 3.96MM 450MM CONNECTOR ASSEMBLY,3P 3.96MM 250MM CONNECTOR ASSEMBLY,12P 2.5MM 800MM CONNECTOR ASSEMBLY,10P 2.5MM 600MM CONNECTOR ASSEMBLY,10P 2.5MM 400MM CONNECTOR,D-SUB 15PIN 2.29MM CONNECTOR,D-SUB 9P 2.77MM

MISCELLANEOUS
C1 C2 F801 F801A F802A IC801 PA001 TU100 TU101 6850VA0004H 6851V00022C 0FS1002B53K 430-813A 430-813A 6927V1063AU 6712000002B 6700NF0010A 6700NF0010B CABLE,COAXIAL(NTSC PLUG) UL1365AWG26 CABLE,COAXIAL(150MM),UL1365#26 VW-1 FUSE,SLOW BLOW 10000MA 250V HOLDER,FUSE NON MC994C PAPING HOLDER,FUSE NON MC994C PAPING SOFT WARE,3.27V 83A0 PDP RF043A REMOTE CONTROLLER RECEIVER,38KHZ TUNER,TAUM H501P TUNER,TAFM H502P

ACCESSORIES
A1 " A2 " A3 " A4 A5 A6 A7 " 3828VA0470D 3828VA0470A 6710V00126S 6710V00137G 6410VUH005A 6410VEH003C 6850J00002B 6850J00004A 6866VA9001B 4810V00509A 4972V00178A MANUAL,OWNERS RF043A MANUAL,OWNERS *LGEUS REMOTE CONTROLLER,RF043A PIP REMOTE CONTROLLER POWER CORD,PS204 125V/13A 2800MM POWER CORD CABLE,DVI D TO DVI D UL20276 CABLE,DVI LVDS UL20276 AWG30 500MM CONNECTOR ,D SUB 2990 9C UL 1161 BRACKET,WALL FIXER,WALL

- 35 -

P/NO : 3828VD0179D

Sep., 2004 Printed in Korea

CANADA: LG Electronics Canada, Inc. 550 Matheson Boulevard East Mississauga, Ontario L4Z 4G3 USA : LG Electronics Alabama, Inc. P.O.Box 240007, 201 James Record Road Bldg 3 Huntsville, AL 35824

MAIN (TOP)

PRINTED CIRCUIT BOARD
MAIN (TOP) MAIN (BOTTOM )

TUNER(TOP)

TUNER(BOTTOM)

POWER S/W(TOP)

POWER S/W(BOTTOM)

SIDE A/V(TOP)

SIDE A/V(BOTTOM)

CONTROL(TOP)

CONTROL(BOTTOM)