Text preview for : SONY STR-DE915, TA-V909, VE910 SERVICE MANUAL VER 1.2 2003.07 (9-920-940-13).pdf part of SONY STR-DE915 SONY STR-DE915, TA-V909, VE910
FM STEREO/FM-AM RECEIVER.
SERVICE MANUAL VERSION 1.2 2003.07
PART#(9-920-940-13)
Back to : SONY STR-DE915, TA-V909, | Home
STR-DE915/TA-V909/VE910
SERVICE MANUAL
Ver 1.2 2003. 07
US Model Canadian Model
STR-DE915
AEP Model UK Model E Model
TA-VE910
Australian Model
STR-DE915
Chinese Model
TA-V909
Photo : STR-DE915
PX Model
STR-DE915
Dolby Laboratories Licensing Corporation. "DOLBY" the double-D symbol a "AC-3" and "PRO LOGIC" are trademarks of Dolby Laboratories Licensing Corporation.
SPECIFICATIONS
-- Continued on next page --
STR-DE915
FM STEREO/FM-AM RECEIVER
TA-V909/VE910
INTEGRATED AV AMPLIFIER
9-920-940-13
2003G16-1 © 2003.07
Sony Corporation
Home Audio Company Published by Sony Engineering Corporation
--2--
SAFETY CHECK-OUT
After correcting the original service problem, perform the following safety checks before releasing the set to the customer: Check the antenna terminals, metal trim, "metallized" knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below.
TABLE OF CONTENTS 1. 2.
2-1. 2-2. 2-3. 2-4. 2-5. 2-6. 2-7. 2-8. 2-9. 2-10. 2-11. 2-12. 2-13. 2-14. 2-15. 2-16.
GENERAL ······································································ 4 DIAGRAMS
Circuit Boards Location ····················································· 6 Block Diagram -- Main Section -- ··································· 7 Block Diagram -- Video In/Out Section -- ····················· 11 Block Diagram --Power Section -- ································ 13 Schematic Diagram -- Video Section -- ························· 16 Printed Wiring Board -- Video Section -- ······················ 19 Printed Wiring Board -- Surround Section -- ················· 22 Schematic Diagram -- Surround Section -- ··················· 25 Printed Wiring Board -- Digital Section -- ···················· 30 Schematic Diagram -- Digital Section -- ······················· 33 Schematic Diagram -- AMP, Power Supply Section -- ·· 38 Printed Wiring Board -- AMP, Power Supply Section -- ··································· 43 Schematic Diagram -- Display Section -- ······················ 48 Printed Wiring Board -- Display Section -- ··················· 53 IC BLOCK DIAGRAMS ················································· 57 IC PIN FUNCTION ························································· 61
LEAKAGE
The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microampers). Leakage current can be measured by any one of three methods. 1. A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers' instructions to use these instruments. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The "limit" indication is 0.75 V, so analog meters must have an accurate low-voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2V AC range are suitable. (See Fig. A) To Exposed Metal Parts on Set
2.
3.
3.
EXPLODED VIEWS
3-1. FRONT PANEL SECTION ·············································· 72 3-2. BACK PANEL SECTION ················································ 73 3-3. CHASSIS SECTION ························································ 74
4.
ELECTRICAL PARTS LIST ··································· 75
0.15µF
1.5k
AC voltmeter (0.75V)
Earth Ground Fig. A. Using an AC voltmeter to check AC leakage.
SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉCURITÉ! LES COMPOSANTS IDENTIFÉS PAR UNE MARQUE ! SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈSES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPÉMENTS PUBLIÉS PAR SONY.
--3--
SECTION 1 GENERAL
LOCATION AND FUNCTION OF CONTROLS
[FRONT PANEL]
1
2
3
4
5
67
8
@· @¶
9
@ @£ @¡
!·
@§ @¢ @TM
@º
!ª
!¶
!§
! !¢ !£ !TM
!¡
!º
Photo : STR-DE915 (US) 1 2 3 4 5 6 7 8 9 !º !¡ !TM !£ !¢ ! DPC MODE button POWER switch SUR, TONE, INDEX indicators Digital processing control buttons Function indicators DIRECT PASS indicator DISCRETE indicator MASTER VOLUME control BALANCE control VIDEO 3 INPUT jack BASS BOOST button/indicator SOUND FIELD ON/OFF button MODE button GENRE button DIRECT PASS, SET UP, INPUT MODE buttons !§ !¶ !· !ª @º @¡ @TM @£ @¢ @¢ @ @§ @¶ @· AUDIO FUNCTION buttons VIDEO FUNCTION buttons DIRECT button (STR-DE915) SHIFT button (STR-DE915) Numeric buttons (STR-DE915) PRESET TUNING +, buttons (STR-DE915) MEMORY button (STR-DE915) DISPLAY button FM/AM button (STR-DE915) DIMMER button (TA-V909/VE910) FM MODE button (STR-DE915) TUNING +, buttons (STR-DE915) PHONES jack SPEAKERS switch
--4--
[REAR PANEL]
STR-DE915 MODEL
1 2 3 5 4 6 7 9 8 !º !¡ !TM !£ !¢
!§ Australian Model
@¢ PX Model
@TM @º !ª !· @£ 1 2 3 4 5 5 6 7 8 9 !º !¡ !TM @¡
!¶
!§
US, Canadian, PX Model
!
Photo : STR-DE915 (US)
LD/DVD IN AC-3 RF LD/DVD IN/CD/IN/DAT/MD IN/OUT OPTICAL S-LINK CTRL A1 (US, Canadian model) TV/DBS (US, Canadian model) LD/DVS (US, Canadian model) LD (PX, Australian model) VIDEO 2 (US, Canadian model) VIDEO 1 CTRL S (US, Canadian model) MONITOR WOOFER SURROUND SPEAKERS (REAR) SURROUND SPEAKERS (CENTER)
!£ !¢ ! !§ !¶ !· !ª @º @¡ @TM @£ @¢
WIRELESS REAR SPEAKER IMPEDANCE SELECTOR AC power cord AC OUTLET (Outlet shape and position varies according to destination) FRONT SPEAKERS (A/B) TAPE DAT/MD CD PHONO y SIGNALGND ANTENNA (AM/FM) VOLTAGE SELECTOR (PX model)
TA-V909/VE910 MODEL
VE910 Model
@TM E Model
V909 Model
1 2 3 4 5 6 7 8 9 !º !¡
DVD/LD IN AC-3 RF DVD/LD IN/CD IN/DAT/MD IN/OUT OPTICAL y SIGNALGND TV LD/DVD VIDEO 2 VIDEO 1 MONITOR WOOFER SURROUND SPEAKERS (REAR) SURROUND SPEAKERS (CENTER)
!TM !£ !¢ ! !§ !¶ !· !ª @º @¡ @TM
--5--
WIRELESS REAR SPEAKER AC OUTLET AC power cord FRONT SPEAKERS (A/B) TAPE DAT/MD CD TUNER PHONO DVD/LD IN COAXIAL VOLTAGE SELECTOR (E model) * : DVD (STR-DE915/TA-V909 Model)
SECTION 2 DIAGRAMS
2-1. CIRCUIT BOARDS LOCATION
VOL SEL BOARD (E, PX model) DISPLAY BOARD SP SW BOARD
S VIDEO BOARD
VIDEO BOARD
JOINT (VIDEO) BOARD
AUDIO (2F) BOARD HEADPHONE BOARD SUR AUDIO (2F) BOARD SW BOARD L.B BOARD
VOLUME BOARD BALANCE BOARD
S-A-P BOARD
SP (2F) BOARD
PS BOARD
REAR AMP BOARD
AMP JOINT (B) BOARD
DIGITAL BOARD
SECONDARY BOARD
AMP BOARD
SUR BOARD
AMP JOINT (F) BOARD
VIDEO (3) BOARD
--6--
STR-DE915/TA-V909/VE910
2-2. BLOCK DIAGRAM -- MAIN SECTION --
DE915 MODEL TM401 ANTENA FM ANT (75) AM ANT 2 4 TU401 AUDIO SELECTOR IC301 V3O 75 AM
STEREO
VIDEO 3 XCOM 6 4 8
A
TO (3/3)
L OUT 17 R OUT 9 R CH
3 2 1 7
TUNER PHONO COM CD DAT COM
COM 11 MUTE Q401
CLOCK
ASTOP
10 TAPE
CLOCK DATA
BUFFER IC304 1 3 OSC IC3107 3 X3501 12.288MHz 5 1 7
EQ AMP IC3101 IC3102 7 6 6 2 7 1 4 5
AUDIO SW. IC3104 AL+ SDATA 15 AL
DATA
SELECT SW. IC3414 11 10 2 3 5 6 1 7 1 2 5 6 PHASE DETECTOR 3 8 IC3409 7 VCO Q3403-3405 VCO D3401 BUFFER Q3401,3402 13 12 1 2 3 IC3408 4 11 10 DAT CLK LAT INT 4 13 9 INV. IC3417 12 9 NOISE SHAPER D/A(F) IC3401 8 39 LACK1 38 BCK1 40 DATA1 9 XO 10 XI 34 ATT 35 SHIFT 36 LATCH 37 INIT NOISE SHAPER D/A(C/W) IC3402 IC3425 1 7 IC3417 11 10 3 4 DSP IC3410 57 SDI0 56 SDI1 55 WST 51 SCKT 27 EXTAL CLOCK 26 SCK/SCL 35 MISO 41 MOSI 36 RESET 42 SS 43 HREQ SDO0 SDO1 WST SCKT 47 46 50 49 CLOCK MISO MOSI RESET SS HREQ 57 SDI0 56 SDI1 55 WSR 51 SCKR MA15 26 SCK/SCL 35 MISO 41 MOSI 36 RESET 42 SS 43 HREQ MWR 78 MRD 77 29 R/W 24 OE IC3408 6 5 MD7 MD0 8 D0 D7 MA16 80 MA0 16 A15 12 A16 NOISE SHAPER D/A(S) IC3403 39 LACK1 38 BCK1 40 DATA1 9 DAT CLK LAT INT XO L1() 61 L2(+) 2 6 7 GM BUFFER Q3519,3520 10 XI 34 ATT 35 SHIFT 36 LATCH 37 INIT L1(+) 63 L2() 4 LPF IC3510 2 1 6 5 IC3511 7 3 1 EQ AMP IC3515 5 7 AMP IC3517 DSP IC3412 27 EXTAL 50 WST 49 SCKT DSC0 47 DSC1 46 DSC2 45 RAM IC3411 A0 IC3408 10 11 DAT CLK LAT INT 47 128F2O 39 LACK1 38 BCK1 40 DATA1 9 XO 10 XI 34 ATT 35 SHIFT 36 LATCH 37 INIT R1(+) 21 R2() 16 R1() 23 R2(+) 18 2 1 GM BUFFER Q3517,3518 IC3508 6 7 2 3 IC3509 1 5 7 3 1 LPF L1() 61 L2(+) 2 6 7 GM BUFFER Q3515,3516 AMP IC3516 L1(+) 63 L2() 4 IC3506 2 1 6 5 IC3507 7 3 1 L1() 61 L2(+) 2 6 7 GM G8 G4 G2 EQ SW Q3501-3403 BUFFER Q3511,3512 RELAY DRIVE Q410 L1(+) 63 L2() 4 LPF IC3501 2 1 6 5 IC3502 7 3 1 EQ AMP IC3505 5 7 6 RY401 RV402 BALANCE RV401 MASTER VOLUME
TMT
IFD
CE
9 21 22 20
6
7
8
12 14 15
AUTO STOP
CE
17 MCLK 13 LRCK 14 SCLK CLOCK DIV. IC3108 RST 10 8 4
STEREO
T MUTE
SDATA
SDATA
SCLK
DATA
SLAT
SCLK
SLAT
FL
V909/VE910 MODEL J301 L PHONO R DE915 MODEL PHONO J302 L R CH
EQ AMP IC302 3 1
F MUTE Q411
6
2
1
6
13
+5VA
LD/DVR IR LINK 3 DETECTOR 1 IC3301 CD 4 3 2 SELECT SWITCH 15 IC3313 14 13 12 A B C 11 10 9 A B C 1 5
IR LINK DRIVER IC3311 2 D IN D OUT 23 LRCK 22 10 XMODE SCLK XLAT SWDT SRDT 14 SCLK 15 XLAT 16 SWDT 17 SRDT E/D OUT 3 EROR 24 AVOCK 11 BCK 21
LPF EQ AMP IC3514 5 7
V909/VE910 MODEL DE915 MODEL TUNER R L INPUT CD R R CH R CH
IR LINK 3 DETECTOR 1 IC3302 DATA/MD IR LINK 3 DETECTOR 1 IC3303 LD/DVR
2
5dB
5
7
1dB
8 C
F
TO (2/3)
J303 L DAT/MD R L TAPE R R CH R CH
29 5dB 26
24 1dB 23 SW
IR LINK 2 DETECTOR 3 IC3304
MISO MOSI RESET SS HREQ
EQ AMP IC3514
V909/VE910 MODEL J3301 LD 3 IC3314 5 6 2
2
5dB
5
7
1dB
8 SL
J3302 LD/DVR BUFFER Q3301
AMP IC3305 6 7 BUFFER Q3302
FL3001 LPF BUFFER Q3303
AMP IC3305 2 1 BUFFER Q3306 AMP IC3306 1
DSP D/A CONVERTER IC3308 82 CP IN DA OUT 70
76 GPIO1
UP
M
DOWN 2 3 88 D OUT 89 D OUT B 78 MUT 1 63 PD0 A B C 55 V IN MUT O 66 56 V OUT PDDI 5 65 D101-111, DE915:AUS/V909/VE910 D115-117,135 MODEL
SCLK SWDT XLAT SRDT DAT CLK MISO MISO MOSI CLOCK CLOCK HREQ MOSI RESET RESET HREQ LAT INT SS SS
RESET
3
D3410 LED VOL D3402 D3409 OR SW Q3407 SWITCH Q3406 D3404 BUFFER Q3307,3308 D3407 GM LED DRIVE Q103
JACK CONNECT DETECTOR Q3304,3305
+5VA
IC3306 6 7 5
D3303
X3302 18.432MHz RAM IC3309 A0 15 A14 D0 8 D7 OE 22 WE 27 16 CE 20
S135 BASS BOOST S136 DPC 3 MOTOR DRIVER 2 IC106 8 7 UP DOWN
D119 +5V STANDBY
A0 A14 D0 D7 42 OE 36 WE A B C 2 RF RESET
7
DIR CLK
6
DIR LAT
5
WDATA
4
RDATA
8 10
A/D INT DIR ERR
1
PRE ERR
9
ANG DIG
74
SURR MUTE
76
RF MUT
94
RY DIR PASS
24 22 20 21 19 18
SS CLOCK MISO MOSI HREQ RESET
17 16 14 15 13 12
CLOCK MISO MOSI SS HREQ RESET
38
LOW FRQ IEQ
29 28 26 25
D/A DAT D/A LAT D/A CLK D/A INT
RESET SWITCH Q101
LED DRIVE LED DRIVE Q105 Q106-108, Q110-122 LED DRIVE Q123
FUNCTION KEY S101-122
FUNCTION KEY S101-122
100 DIG IN0 99 DIG IN1 98 DIG IN2
FL101 BUFFER Q3309,3310 G8 62
RESET
7
LED STANDBY
74
BASS B
37
KEY5
36
KEY4
35 33 32
KEY3 KEY2 KEY1
39 40 19
DOMN LED VOL
72 F MUTE SLAT TO (3/3) SLAT SDAT SCLK DATA A STOP STEREO T MUTE 58 LAT 59 DATA 60 CLK 61 DATA 62 AU STOP 63 STEREO 73 TU MUTE 68 VIDEO A
RY CENTER RY POWER RY FRONT PROTECT AC MUTE RY REAR
Signal path : FM : CD(ANALOG) : CD(DIGITAL) : LD(VIDEO)
GAIN FRONT 4dB
40
B
SDAT SCLK
BUFFER Q3311,3314
G4
65 XI X101 4MHz 64 XO
UP
GAIN FRONT 8dB
39
LED SIGNAL
FL DISPLAY DRIVER IC107 FL CLEAR 23 FL LAT 26 FL CLK 25 24 CLR 26 LAT 34 CLK D IN 29 3 F2 P1-P35
FLOURESCENT INDICATOR TUBE
F1
SYSTEM CONTROL IC3413
GAIN FRONT 2dB 41
BUFFER Q3312,3313
G2
MODE CONTROL IC103
49 UDATA
MBUS STATS
DISP DATA DISP CLK DISP MR SREQ RESET
STOP STOP
55 57 54 56 77
PW SW
XO
INH
71 VIDEO INH
XI
RY HP
TO (3/3)
C
VB VE
69 VIDEO B 70 VIDEO E
46 URESET
SIRCS
VA
47 USREQ
STOP
AU BUS IN
MBUS V2
MBUS V1
48 UMREQ
SP A SP B
AU BUS OUT
50 UCLOCK
MBUS MON
D OUT 29 CLK FL DAT 24 30 D IN FL DISPLAY DRIVER IC108 BUFFER Q124 1 1G-19G
45
77 S151
75
76
2
3
1 80 53 52 27
IC101 REMOTE CONTROL RECEIVER 2 3
+5.6V
BUS V2
PROTECT
RY PW
RY HP
STOP
POWER
RY C
RY S
RY F
SP A
SP B
V909/VE910 MODEL
PW RY+
PW RY-
X3401 4MHz
AC MUTE
S151
DE915 MODEL
BUS V1
POWER
BUS IN SIRCS 2
MBUS TV
BUS OUT
POWER SWITCH Q104
STATS OUT
82
83
90 87 86 80 88 67 75
48 3
D E
TO (2/3)
TO (3/3)
--7--
--8--
--9--
STR-DE915/TA-V909/VE910
2-3. BLOCK DIAGRAM -- VIDEO IN/OUT SECTION --
VIDEO SELECTOR IC303 V909/VE910 DE915 MODEL MODEL TV/DBS TV R L LD/DVD LD R R CH V2 OUT 6 R CH 10 VIDEO 1 R CH 7 R CH VIDEO 2 COM COM 4 8 V3 OUT COM SLAT SDATA SCLK R CH R CH 2 DVD/LD TV/LD R CH R J305 L 1 TV/DBS SATL V1 OUT 9 J304 L VIDEO 1 OUT
DE915:US,Canadian MODEL
J201 CTRL S TV/DBS CTRL S STATUS IN J214 MONITOR L CTRL S IN SWITCH Q225,226 3 2 LEVEL CONTROL Q205,209 J213 VIDEO 2 CTRL S OUT LEVEL CONTROL Q222,223 LEVEL CONTROL Q212 5 6 11 4 ST-I/O IC223 6 STATUS OUT BUFFER Q213
MBUS TV
J305 VIDEO 2
J304 L VIDEO 1 IN R L VIDEO 2 IN R
R
OUT
J212 VIDEO 1
SIRCS-2 1 MBUS V1
J299
L
CTRL S OUT IC201 7
D
MBUS V2
VIDEO 3
R OUT
TO (1/3)
COM 11 SLAT SDATA SCLK 13 14 15
A
TO (1/3)
B
TO (1/3) J202 S-LINK CTRL A1
BUS IN
IN/OUT BUFFER Q220
BUS OUT
VIDEO SWITCH IC211 J210 VIDEO 1 IN J209 VIDEO 2 IN J211 TV/DBS VIDEO IN LD/DVD 3 LD V3 OUT 15 A 9 C 11 B 8 D 6 E 7 5 TV V2 OUT 10 VIDEO BUFFER Q216,219 J299 12 V2 IN M OUT 1 VIDEO BUFFER Q214,217 J209 MONITOR OUT J205 LD VIDEO IN 16 V1 I 15 A 9 8 6 C MO 1 V3 O 7 C BUFFER Q1 Y D E 11 B C Y 16 V1 IN V1 OUT 14 VIDEO BUFFER Q215,218 J210 VIDEO 1 OUT Y
EXCEPT DE915:US, Canadian MODEL
Y SWITCH IC204 3 LD V1 O 14 BUFFER Q208,211 Y
J207 VIDEO 1
OUT
VIDEO 2
OUT
C
J204
MONITOR
VIDEO 3
OUT J207 VIDEO 1 IN C 3 Y C SWITCH IC203 LD V1 O 14
J299 VIDEO 3
OUT
16 V1 I MO 1 15 A 9 8 6 C V3 O 7 D E BUFFER Q206 C
VA VB VE INH +B SW Q201 +5V
11 B TO (1/3)
C
Signal path : LD(VIDEO)
-- 10 --
-- 11 --
-- 12 --
STR-DE915/TA-V909/VE910
2-4. BLOCK DIAGRAM --POWER SECTION --
POWER AMP IC501 +VDD -VDD 13 VCC 14 VCC +VE 15 VEE LIMITER Q504 FL 6 IN NF 5 S155 MUTE Q503,504 1 MUT VE 3 LIMITER Q505 BOOSTER Q507 CUR DET Q508 Q511 PROTECTOR Q509,510 SPEAKERS A+B OFF A B POWER AMP IC601 +VDD -VDD 9 7 VCC +VE VEE LIMITER Q604 C TO (1/3) 1 IN NF 2 LIMITER Q605 VE 5 BOOSTER Q607 CUR DET Q608 Q611 PROTECTOR Q609,610 C 6 BOOSTER Q606 RY502 RELAY DRIVE Q596 R CH RY501 RELAY DRIVE Q546 R L 2 BOOSTER Q506 RELAY DRIVE Q410 R CH RY602
J701 PHONS
TM501 FRONT SPEAKER
Signal path : FM : CD(ANALOG)
E, PX MODEL TM701 SURROUND SPEAKER T901 120V S902 VOLTAGE SELECTOR 120V 240V 220V
F
RY601
RELAY DRIVE Q645
S(L) S(R) R CH
0V 120V
RY701
WOOFER AMP IC602 SW POWER AMP IC701 AVCC AVEE 13 VCC 14 VCC +VE 15 VEE LIMITER Q704 SL 6 IN NF 5 LIMITER Q705 VE 3 BOOSTER Q706 CUR DET Q708 2 BOOSTER Q706 R CH CNJ701 WIRELESS REAR SPEAKER AVCC VDD AVEE SWITCH Q612,615 SWITCH Q613,616 INV SW Q617 +12V SWITCH Q614,618 F951 VCC VEE 35V REG Q801 D802-805 3 1 RELAY DRIVE Q745 J501 WOOFER 100V 0V
120V
RY503
RELAY DRIVE Q544 +VDD 120V 240V 220V REG Q748 D801,851 F950 240V T901 220V
MUTE Q701,703
1
MUT
REG IC801
PROTECTOR Q547-549 S501 AC MUTE 8 4
12V
REG IC803
D806
F2 F1
PROTECT RY H RY F SP B SP A RY C RY S RY PW
TO (1/3)
IMPEDANCE SELECTOR
5V/A
REG IC401 RECT D402
5V/D
REG IC402
F901 E, PX F903 MODEL
RY901
D142 +5V +5.6V DELAY +B SW Q902 D901-904 3 8 POWER CONT IC901 6 5 T902 EXCEPT E, PX MODEL JW901 E, PX MODEL RELAY DRIVE Q901 F902 EXCEPT US, Canadian, PX, Chinese MODEL
CNJ909
E
EXCEPT US, Canadian, PX, Chinese MODEL
CNJ901 US, Canadian, PX, Chinese MODEL
PY RY + PW RY STOP
CNP901 AC IN
-- 13 --
-- 14 --
-- 15 --
STR-DE915/TA-V909/VE910
2-5. SCHEMATIC DIAGRAM -- VIDEO SECTION --
Note :
· All capacitors are in µF unless otherwise noted. pF: µµF 50WV or less are not indicated except for electrolytics and tantalums. · All resistors are in and 1/4W or less unless otherwise specified. · : panel designation. · B+ : B+ Line. · B : B Line. · Voltage is measured with respect to ground under no-signal conditions. · Voltages are reference value measured by a VOM (10M/V). · Signal path : LD (VIDEO) · Abbreviation CND : Canadian
-- 16 --
-- 17 --
-- 18 --
STR-DE915/TA-V909/VE910
2-6. PRINTED WIRING BOARD -- VIDEO SECTION --
1 A
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
B
C
D
E
· Semiconductor
Location
Ref. No. Location D-4 C-2 C-3 C-9 C-9 I-4 C-1 C-10 D-10 D-4 C-3 D-11 D-11 C-10 C-3 D-11 C-11 C-3 D-2 I-6 H-6 H-5 H-7 H-8 H-5 C-2 C-3 C-3 C-2 C-2 D201 D210 IC201 IC203 IC204 IC211 IC223
F
G
H
I
J
Q1 Q201 Q201 Q205 Q206 Q207 Q208 Q209 Q210 Q211 Q212 Q213 Q214 Q215 Q216 Q217 Q218 Q219 Q220 Q222 Q223 Q225 Q226
Note :
· : parts extracted from the component side. · : pattern on the side which is seen. · Abbreviation CND : Canadian
-- 19 --
-- 20 --
-- 21 --
STR-DE915/TA-V909/VE910
1 A 2
Ver 1.2 2003.07 2-7. PRINTED WIRING BOARD -- SURROUND SECTION --
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
B
C
D
E
F
· Semiconductor
Q504
G
E C B
Location
Ref. No. Location D401 D402 D403 I-9 J-13 I-6 G-4 H-4 B-4 H-8 H-12 H-13 G-11 F-6 J-11 H-7 I-8 I-7 H-7 G-10 G-10
H
I
IC301 IC302 IC303 IC304 IC401 IC402 IC501 IC601 IC602 Q401 Q410 Q411 Q451 Q503 Q504
J
Note :
K
· : parts extracted from the component side. · : pattern on the side which is seen. · Abbreviation CND : Canadian AUS : Australian CH : Chinese G : German AED : North European EE : East European MY : Malaysia SP : Singapore
-- 22 --
-- 23 --
-- 24 --
STR-DE915/TA-V909/VE910
2-8. SCHEMATIC DIAGRAM -- SURROUND SECTION --
Note :
· All capacitors are in µF unless otherwise noted. pF: µµF 50WV or less are not indicated except for electrolytics and tantalums. · All resistors are in and 1/4W or less unless otherwise specified. · : non flammable resistor. · : panel designation. · B+ : B+ Line. : B Line. · B · Voltage is measured with respect to ground under no-signal conditions. · Voltages are reference value measured by a VOM (10M/V). · Signal path : FM : CD (ANALOG) : LD (VIDEO) · Abbreviation CND : Canadian AUS : Australian CH : Chinese G : German AED : North European EE : East European MY : Malaysia SP : Singapore
-- 25 --
-- 26 --
-- 27 --
-- 28 --
STR-DE915/TA-V909/VE910
2-9. PRINTED WIRING BOARD -- DIGITAL SECTION --
· Semiconductor Location
Ref. No. D3303 D3401 D3402 D3404 D3407 D3409 D3410 IC3101 IC3102 IC3103 IC3104 IC3105 IC3106 IC3107 IC3108 IC3301 IC3302 IC3303 IC3304 IC3305 IC3306 IC3307 IC3308 IC3309 IC3311 IC3313 IC3314 IC3401 IC3402 IC3403 IC3407 IC3408 IC3409 IC3410 IC3411 IC3412 IC3413 IC3414 IC3417 IC3425 IC3501 IC3502 IC3503 IC3504 IC3505 IC3506 IC3507 IC3508 IC3509 Location H-4 G-8 D-4 C-4 G-5 C-4 D-4 G-6 H-6 H-7 I-6 E-6 G-7 I-7 C-6 D-2 D-2 C-2 C-2 G-3 H-3 G-4 I-3 I-4 J-4 J-3 J-3 G-9 I-9 J-9 I-8 H-8 C-8 J-5 J-7 J-6 H-5 J-8 J-8 I-5 G-10 H-11 G-10 G-11 G-11 I-10 I-11 H-10 H-11 Ref. No. IC3510 IC3511 IC3512 IC3513 IC3514 IC3515 IC3516 IC3517 Q3301 Q3302 Q3303 Q3304 Q3305 Q3306 Q3307 Q3308 Q3309 Q3310 Q3311 Q3312 Q3313 Q3314 Q3315 Q3401 Q3402 Q3403 Q3404 Q3405 Q3406 Q3407 Q3501 Q3502 Q3503 Q3504 Q3505 Q3506 Q3511 Q3512 Q3513 Q3514 Q3515 Q3516 Q3517 Q3518 Q3519 Q3520 Q3521 Q3522 Location J-10 J-11 J-10 J-11 I-11 J-11 I-12 J-12 G-3 G-3 G-4 G-3 G-3 H-3 G-6 B-11 H-5 D-12 H-5 D-12 H-5 D-12 G-5 G-8 H-8 H-7 H-7 H-7 G-6 D-4 H-12 H-12 H-12 G-12 G-12 G-12 G-11 H-11 G-11 G-11 I-11 I-11 H-11 H-11 J-11 J-11 J-11 J-11
· ·
: parts extracted from the component side. : pattern on the side which is seen.
-- 29 --
-- 30 --
-- 31 --
-- 32 --
2-10. SCHEMATIC DIAGRAM -- DIGITAL SECTION --
· Waveforms
1 IC3107 3
3.5Vp-p
12.288MHz
2 IC3108 4
5.4Vp-p 3.072MHz
3 IC3108 8
4.6Vp-p 48kHz
4 IC3308 %§ VOUT
5.8Vp-p
18.432MHz
5 IC3408 !£
2.2Vp-p
49.152MHz
6 IC3413 *TM X IN
4.6Vp-p 4MHz
Note :
· All capacitors are in µF unless otherwise noted. pF: µµF 50WV or less are not indicated except for electrolytics and tantalums. · All resistors are in and 1/4W or less unless otherwise specified. : panel designation. · · B+ · B : B+ Line. : B Line. · Voltage is measured with respect to ground under no-signal conditions. · Voltages are reference value measured by a VOM (10M/V). · Signal path : FM : CD (ANALOG) : CD (DIGITAL)
-- 33 --
-- 34 --
-- 35 --
-- 36 --
-- 37--
STR-DE915/TA-V909/VE910
2-11. SCHEMATIC DIAGRAM -- AMP, POWER SUPPLY SECTION --
Note :
· All capacitors are in µF unless otherwise noted. pF: µµF 50WV or less are not indicated except for electrolytics and tantalums. · All resistors are in and 1/4W or less unless otherwise specified. · : non flammable resistor. · : panel designation. · B+ · B : B+ Line. : B Line.
Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
· Voltage is measured with respect to ground under no-signal conditions. · Voltages are reference value measured by a VOM (10M/V). · Signal path : FM : CD (ANALOG) · Abbreviation CND : Canadian CH : Chinese
-- 38 --
-- 39 --
-- 40 --
-- 41 --
-- 42 --
STR-DE915/TA-V909/VE910
2-12. PRINTED WIRING BOARD -- AMP, POWER SUPPLY SECTION --
· Semiconductor Location
Ref. No. D501 D502 D503 D504 D505 D506 D507 D508 D512 D543 D545 D546 D547 D548 D549 D551 D552 D553 D554 D555 D556 D601 D602 D603 D604 D605 D606 D607 D608 D611 D647 D648 D649 D651 D701 D702 D703 D704 D705 D706 D707 D711 D716 D749 D751 D752 D753 D754 D801 D802 D803 D804 D805 D806 D807 D851 D901 D902 D903 D904 D905 D906 D907 Location I-5 I-5 I-6 I-6 I-4 I-3 G-12 G-12 G-13 D-4 F-3 I-2 H-13 I-12 H-12 I-10 I-10 I-11 I-11 I-4 I-3 I-7 I-7 I-9 I-9 C-5 C-6 C-5 F-10 G-13 G-11 G-6 B-3 G-13 K-3 K-4 K-4 L-4 D-3 C-3 C-6 G-13 G-13 B-2 K-7 K-8 L-8 L-8 B-15 B-13 B-13 B-14 B-14 C-13 H-12 B-15 G-17 G-17 G-17 G-17 G-17 G-17 H-17 Ref. No. IC701 IC801 IC803 IC901 Q504 Q505 Q506 Q507 Q508 Q509 Q510 Q511 Q544 Q546 Q547 Q548 Q549 Q554 Q555 Q556 Q557 Q558 Q559 Q560 Q561 Q596 Q604 Q605 Q606 Q607 Q608 Q609 Q610 Q610 Q611 Q612 Q613 Q614 Q615 Q616 Q617 Q618 Q645 Q701 Q703 Q704 Q705 Q706 Q707 Q708 Q709 Q710 Q745 Q748 Q754 Q755 Q756 Q757 Q758 Q801 Q901 Q902 Location L-5 F-5 G-6 G-18 I-6 I-6 I-5 I-6 I-7 I-4 I-3 I-3 C-4 F-4 I-13 H-13 H-12 I-11 I-11 I-10 I-11 I-12 I-4 I-3 I-3 F-4 I-8 I-8 I-8 I-9 I-9 B-6 F-10 C-6 C-5 G-6 G-6 H-11 G-6 G-6 H-11 H-11 B-5 K-5 K-5 K-4 L-3 L-3 L-4 K-2 C-3 C-3 C-3 C-7 K-7 L-7 L-7 L-8 K-8 H-12 H-17 G-18
Note :
· : parts extracted from the component side. · : pattern on the side which is seen. · Abbreviation CND : Canadian CH : Chinese
-- 43 --
-- 44 --
-- 45 --
-- 46 --
-- 47 --
STR-DE915/TA-V909/VE910
2-13. SCHEMATIC DIAGRAM -- DISPLAY SECTION --
· Waveforms
1 IC103 @ FLCLK
4.8Vp-p
3.5µsec
2 IC103 ^¢ DX
4.8Vp-p 4MHz
Note :
· All capacitors are in µF unless otherwise noted. pF: µµF 50WV or less are not indicated except for electrolytics and tantalums. · All resistors are in and 1/4W or less unless otherwise specified. · : non flammable resistor. · : panel designation. · B+ · B : B+ Line. : B Line.
Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
· Voltage is measured with respect to ground under no-signal conditions. · Voltages are reference value measured by a VOM (10M/V). · Signal path : FM : CD (ANALOG) · Abbreviation CND : Canadian CH : Chinese
-- 48 --
-- 49 --
-- 50 --
-- 51 --
-- 52 --
STR-DE915/TA-V909/VE910
2-14. PRINTED WIRING BOARD -- DISPLAY SECTION --
1 A
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
· Semiconductor
Location
Ref. No. D101 D102 D103 D104 D105 D106 D107 D108 D109 D110 D111 D115 D116 D117 D118 D119 D133 D134 D135 D142 D143 D144 D152 D153 IC101 IC103 IC106 IC107 IC108 Location B-7 B-8 B-9 B-10 B-11 B-11 B-12 B-13 B-14 B-15 C-8 B-18 B-17 B-17 E-6 C-15 B-15 B-15 D-7 C-5 E-16 E-16 D-19 D-19 D-14 D-9 C-6 D-11 C-10 C-8 D-6 C-16 C-16 B-16 B-16 B-16 D-7 C-7 B-15 B-15 B-13 B-13 B-11 B-11 B-9 B-9 B-8 B-7 D-6 D-15
B
C
D
E
F
Q101 Q103 Q104 Q105 Q106 Q107 Q108 Q111 Q112 Q113 Q114 Q115 Q116 Q117 Q118 Q119 Q120 Q121 Q122 Q123 Q124
G
Note :
H
· : parts extracted from the component side. · : pattern on the side which is seen. · Abbreviation CND : Canadian CH : Chinese
-- 53 --
-- 54 --
-- 55 --
-- 56 --
2-15. IC BLOCK DIAGRAMS
IC106 BA6208
SWITCH MOTOR DRIVE
IC223
VCC2 VCC1
NJM2129D
INHIBIT1 INHIBIT2 REG-SW OUT2 IN1
IC601
STK350-230
TR3 TR1 R1
IC3401, 3402, 3403
201x16 XSEL
CXD8505BQ
SPLM DFVDD1 DVDDR VSUB(D)R VSUB(C)R VDD2 VDD R1(-) VSS R1(+) VSS2
IC501, 701
uPC2581V
BIAS CIRCUIT
14
SWITCH MOTOR DRIVE REG 1 2 3 4 5 6 7 8 9
13
12
11
10
9
8
INPUT NF
1 2 3 4
TR2 TR4 R2
32 31 SYSM 33 ATT SHIFT LATCH XINT 34 35 36 37
30 29 28 27 26 25 24 23 22 21 20
PROTECTOR REG DRIVE PRE DRIVE 4 5 6 7 PRE DRIVE 8 9 10 DRIVE
REGULATOR + INHIBIT
INHIBIT
"O" DETECT MUTE CIRCUIT
INPUT 1
OUTPUT 2
OUTPUT1
GND
Vcc
NC
NC
NC
INPUT 2
-VEOUT
5 6 7 8 9 R9 TR8 R4 TR5 R3 D4 D1 D2 R5 R8 R7 D3 TR7 TR6 R6
+
+VEOUT VSS
MODE PLM
1
2 3
4
GND
5
6
7
REG OUT
GND NC
IN2
IN3
OUT1
IN4
VCC
XDCK XLRCK DATA1 VSUD(D)R DF VSS VSUB(D)L INAF
38 39 40 41 42 43 44
SUB
S/P
ATT
FIR1 FIR2 IIR FIR3
L. I. P. (x 8)
3RD ORDER NOISE SHAPER CLOCK GENERATOR
AC, DC DITHER ATT FIR1 IIR TIMING CIRCUIT 3RD ORDER NOISE SHAPER
FIR2
FIR3
L. I. P. (x 8)
PLM
IC107
TD62C950RF
IC901
NJM2103D
D OUT1 1 Q ST H VCC 21 P GND 22 L GND 23 CL 24 NC 25 STB 26 NC 27 NC 28 S IN 29 VDD 30 D Q
CK Q CK D
ST D Q 60 OUT40 41 OUT21 40 39 38 37 H VCC P GND L GND NC
VSC 2 + VREF + 7 VSA CR 1 8 RESET
512FS0 45 256FS0 46 128FS0 47 I NV1 48 I NV01 49 I NV02 50 MUTE R 51
19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
VSS2 R2(+) VSS R2(-) VDD VDD2 VSUB(A)R XVSS XVSS X IN X OUT XVDD VSUB(A)L VDD2 VDD L2(-) VSS L2(+) VSS2
1
2
3
11
12
13 14 15
VOUT2
+ VOUT1
VOUT1
+ VOUT2
MUTE
COMP1
GND
COMP2
MF1
IN1
IN2
NF2
IC3104 CXD8681M-TP
VREF+ 1 VREF- 2 VCOML 3 AINL+ 4 VOLTAGE REFERENCE VOLTAGE REFERENCE 28 VREF+ 27 VREF26 VCOMR DELTA-SIGMA MODULATOR DELTA-SIGMA MODULATOR 25 AINR+ 24 AINR23 VA DECIMATOR DGND 8 CAL 9 DECIMATION FILTER CALIBRATION SRAM 22 AGND 21 BGND 20 TEST 19 SEL24 18 CMODE SERIAL OUTPUT INTERFACE 17 MCLK 16 FSYNC 15 SDATA
OUT20 20
52 53 54 55 56 57 58 59 60
61 62 63 64
MUTE L TEST 1 TEST 2 DFVDD2 DV DDL VSUB(D)L VSUB(C)L VDD2 VDD
L1(-) VSS L1(+)
VSS2
AINL- 5 ZCAL 6 VD 7
36 CHG 35 NC 34 CK 33 NC 32 S OUT 31 VDD PHASE COMPARATOR
OUTC
3
6
VSB/SESIN
IC3409 TC5081AP
CONTROLLER RST 10 SMODE 2 11 SMODE 1 12 LRCK 13 SCLK 14
GND
4 Q R S + +
5
V+
1 AOUT
2 AIN
3 PDOUT
4 PHASE OUT
5 VDD
6 N. C.
7 S
8 R
9 GND
IC203, 204, 211 SN761200
IC301, 303
1
LC7822
30
IC3313 TC74HC151AF-TP1
D3 1 16 VCC D2 D3 D4 D1 D0 Y W S C D5 D6 D7 A B 15 D4 14 D5 13 D6 12 D7 11 A 10 B 9 C D2 2
IC108
NC CHG DIN
MSC1164GS-K
HVO1 HVO2 HVO3 HVO4 HVO5 HVO6 HVO7 HVO8 HVO9 HVO10 GND CLK Vhv
6dB MONITOR OUT GND 1 2 DECODER
16 15 14
IN1 CTL A V OUT1 VCC IN2 CTL B
32 31 30
29
28
27
26 25 24 23 22 21 20 19 18 17
IN
2 3
29 IN D1 3 28 D0 4 27 OUT Y 5
OUT
4 5
GND IN4 CTL E IN3
5 6
13 12 11
XY 6 IN 6 7 OUT 8 9 IN 10 21 25 IN OE 7 24 GND 8 23 OUT 22 IN
20 BIT SHIFT REGISTER
CK
D
IN5
3 4
26
20 BIT LATCH
GATE CIRCUIT
OUTPUT CIRCUIT
7 6dB
10
V OUT2
1 2
3
CK
Q
4
5
6
7 8 9 10 11 12 13 14 15 16
NC NC
DOUT
CTL D
8
DECODER
9
CTL C
LEVEL SHIFT
VEE
12
CONTROL
19 VDD LATCH 18 RESET 17 S SHIFT RESISTOR 16 VSS
CE 13 DI 14
CL 15
-- 57 --
-- 58 --
HVO20 HVO19 HVO18 HVO17 HVO16 HVO15 HVO14 HVO13 HVO12 HVO11
VCC
LS
CL
OUT
11
20 OUT
-- 59 --
-- 60 --
VCC2 VEE
VCC1
2-16. IC PIN FUNCTION
· IC103 MB90673PF-G-206-BND (MODE CONTROL)
Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 Pin Name MBUS-V2 MBUS-MON STATUS-OUT N.C. N.C. N.C. LED-STBY LED-SURR LED-TONE LED-INDEX Vss LED-CD LED-DAT/MC LED-TAPE LED-TV LED-LD LED-V3 LED-V2 LED-V1 RX TX BUSY FLCLR FLDAT FLCLK FLLAT SIRCS AVcc AVR + AVR AVss ADKIN1 ADKIN2 Vss ADKIN3 ADKIN4 ADKIN5 AD-VERSION VOLUP VOLDOWN MD0 MD1 MD2 STANDBY STOP U-RESET U-SREQ U-MREQ U-DATA U-CLOCK I/O I I O -- -- -- O O O O -- O O O O O O O O -- -- -- O O O O I -- -- -- -- I I -- I I I I O O I I I I I O I O O O M-BUS (VIDEO2) input. M-BUS (MONITOR) input. M-BUS status output. Not used. Not used. Not used. LED output (STANDBY). LED output (DPC: SUR). LED output (DPC: EQ). LED output (DPC: INDEX). Ground. LED output (CD). LED output (DAT/MD). LED output (TAPE). LED output (TV). LED output (LD). LED output (VIDEO3). LED output (VIDEO2). LED output (VIDEO1). Not used. Not used. Not used. FL clear output (FL tube). FL data output (FL tube). FL clock output (FL tube). FL latch output (FL tube). SIRCS remote control signal input. 5V.(Backup power supply) 5V. Ground. Ground. AD KEY input 1 [Open drain] AD KEY input 2 [Open drain] Ground. AD KEY input 3 [Open drain]. AD KEY input 4 [Open drain]. AD KEY input 5 [Open drain]. AD VERSION input [Open drain]. VOLUME UP. VOLUME DOWN. Mode setting, High (Backup power supply). Mode setting, High (Backup power supply). Mode swetting, Low. STOP input. Hardware standby, High. Reset signal. (Control microprocessor). Salve request & data. (Control microprocessor). Master request. (Control microprocessor). Master data. (Control microprocessor). Master clock. (Control microprocessor). Description
-- 61 --
Pin No. 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80
Label Name GND AUBUS IN AUBUS OUT GND EN-FNC.B EN-FNC.A UP/DOWN-B UP/DOWN-A LEFT/RIGHT-B LEFT/RIGHT-A GND RESET Vss X0 X1 Vcc LED- TUNER LED-PHONO LED-MUTE LED-LEARN LED-DIRECT LED-INPUT LED-VOL LED-BASSB SP-A SP-B PW-SW LED-TV (V) LED-LD (V) MBUS-V1
I/O -- I O -- I I -- -- -- -- -- I -- O I -- O O O O O O O O I I I O O I L: HiFi, H: ES. Control-A1. Control-A1. Ground. Encoder input (Function-B). Encoder input (Function-A). Not used. Not used. Not used. Not used. Ground. Reset. Ground. Ceramic oscillator, 4 MHz. Ceramic oscillator, 4 MHz. 5V (Backup power supply). LED output (TUNER). LED output (PHONO). LED output (MUTE). LED output (IR-LEARN). LED output (DIRECT PASS). LED output (DISCRETE). LED output (VOLUME). LED output (BASS BOOST). SPEAKER A signal input. SPEAKER B signal input. POWER key input. LED output (TV) for video. LED output (LD) for video. M-BUS (VIDEO 1) input.
Description
-- 62 --
· IC3413 MB90641APF-G-104BND (SYSTEM CONTROL)
Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 Pin Name RF-ERR RF-RESET STOP RDATA WDATA DIRLAT DIRCLK DIRERR ANA/DIG A/DINT Vss HREQ SS MOSI RESET MISO CLOCK HREQ SS MOSI RESET MISO Vcc CLOCK D/AINT D/ALAT C D/ACLK D/ADATA N.C N.C N.C N.C Vcc Vcc Vss Vss LOW-FRQ-IED GAIN-FRONT-8DB GAIN-FRONT-4DB GAIN-FRONT-2DB Vss N.C N.C N.C N.C N.C STOP MD0 MD1 I/O I O I I O O O I O O -- I O O O I O I O O O I -- O O O -- O O -- -- -- -- -- -- -- -- I O O O -- -- -- -- -- -- I I I RF demodulater error signal. RR demodulater reset. Stop in. DIR LC8905V data. DIR LC8905V write data. DIR LC8905V latch. DIR LC8905V clock. DIR LC8905V error. Analog/Digital. A/D Converter AK5390 init. Ground. DSP56009 SHI HREQ. DSP56009 SHI SS. DSP56009 SHI MOSI. DSP56009 SHI reset. DSP56009 SHI MISO. DSP56009 SHI clock. DSP56009 SHI HREQ. DSP56009 SHI SS. DSP56009 SHI MOSI. DSP56009 SHI reset. DSP56009 SHI MISO. +5V. DSP56009 SHI clock. DF+DA CX8505BQ init. DF+DA CX8505BQ latch. Connect to capacitor. DF+DA CX8505BQ clock. DF+DA CX8505BQ data. Not used. Not used. Not used. Not used. +5V. +5V. Ground. Ground. Low frequency signal. Front out +8db. Front out +4db. Front out +2db. Ground. Not used. Not used. Not used. Not used. Not used. Power check. Mode setting, HIGH. Mode setting, HIGH. Description
-- 63 --
Pin No. 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100
Pin Name MD2 STANDBY N.C DISPMR DISPDATA SLVDATA/REQ DISPCLK LAT DATA CLK DATA IN AU STOP STEREO N.C N.C HIFI/ES PROTEC VIDE-A VIDE-B VIDE-E VIDEO-INH FUN-MUTE TUNER-MUTE SURR-MUTE AC-MUTE RM-MUTE RESET RY-FRONT/A RY-FRONT/B RY FRONT Vss X IN X OUT Vcc RY-PRE AMP RY-CENTER RY-REAR RY-HP RY-4/8 RY-POWER N.C N.C N.C RY-DIRECT-PASS N.C N.C N.C DIG-IN2 DIG-IN1 DIG-IN0
I/O I I -- I I O I O O O I I I -- -- I I O O O O O O O O O I O O O -- I O -- O O O O O O -- -- -- O -- -- -- O O O Mode setting, LOW. Standby swtch. Not used. display master request. display data. Slave Data/Request. Display clock. LC latch. LC data. LC clock. PLL data. PLL auto stop. PLL stereo. Not used. Not used. Hifi/ES select. Protector. Video select A. Video select B. Video select E. Video output inhibit. Function mute. Tuner mute. Surround mute. All mute. "20db" mute. Reset. Front speakers B relay. Front speakers A relay. Front speakers relay. Ground. 4MHz OSC out. 4MHz OSC in. +5V. Pre amplifier relay. Center speaker relay. Rear speaker relay. Headphone relay. Speaker 4/8 relay. Power relay. Not used. Not used. Not used. Direct pass. Not used. Not used. Not used. Digital input select 2. Digital input select 1. Digital input select 0.
Description
-- 64 --
· IC3308 DOLBY AC-3 demodulator (SN-PM4007A)
Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 Pin Name GND VDD RESET OSCON DATA MCK MLTB IDST IDCK IDO TM0 ECCK DEN DRY MSYC TM1 A0 A1 A2 A3 A4 A5 TM2 TM3 XOUT XIN XENT GND VDD A6 A7 GND VDD A12 A14 WE A13 A8 A9 GND A11 OE A10 D7 D6 D5 D4 D3 D2 D1 I/O -- -- I I I I I O O O I O O O O I O O O O O O I I O I I -- -- O O -- -- O O O O O O -- O O O I/O I/O I/O I/O I/O I/O I/O Ground +5V power supply System reset input "L" : reset Oscillation control signal input "H" : ON Test pin (Connected to ground) Test pin (Connected to ground) Test pin (Connected to ground) Test pin (Open) Test pin (Open) Test pin (Open) Test pin (Connected to ground) Test pin (Open) Test pin (Open) Test pin (Open) Test pin (Open) Test pin (Connected to ground) Address data output to SRAM Address data output to SRAM Address data output to SRAM Address data output to SRAM Address data output to SRAM Address data output to SRAM Test pin (Connected to ground) Test pin (Connected to ground) Test pin (Open) Test pin (Connected to ground) Test pin (Connected to ground) Ground +5V power supply Address data output to SRAM Address data output to SRAM Ground +5V power supply Address data output to SRAM Address data output to SRAM Write enable signal output to SRAM "L" : active Address data output to SRAM Address data output to SRAM Address data output to SRAM Ground Address data output to SRAM Output enable output to SRAM Address data output to SRAM Data bus input/output with SRAM Data bus input/output with SRAM Data bus input/output with SRAM Data bus input/output with SRAM Data bus input/output with SRAM Data bus input/output with SRAM Data bus input/output with SRAM Description
-- 65 --
Pin No. 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100
Pin Name D0 VDD GND TI1 VIN VOUT TI2 TI3 TLD8 TCK TRP TD0 PD0 TI4 PDDIS MUTO TI5 VLDY DASYO DAOUT DAIN DASEL TI8 C2F1 C2F0 C1F1 C1F0 MUTI VDD GND AVDD CPIN CMIN AGND TM4 VDD DIN DOUT DOUTB C9M GND WINGT SYST0 SYST1 ADST0 ADST1 TM5 BUNRI AGND AVDD
I/O I/O -- -- I I O I I I I O O O I I O I O O O I I I O O O O I -- -- -- I I -- I -- I O O O -- O O O O O I I -- -- Data bus input/output with SRAM +5V power supply Ground Test pin (Connected to VDD) VCXO input (18.432MHz) VCXO output (18.432MHz) Test pin (Connected to Ground) Test pin (Connected to Ground) Test pin (Connected to Ground) Test pin (Connected to Ground) Test pin (Open) Test pin (Open) Output of internal phase comparator (3 state) Test pin (Connected to Ground) PDO output control input "L" : output ON Mute signal output "H" : mute Test pin (Connected to Ground) Test pin (Open) Test pin (Open)
Description
Digital-out signal output (Serial data stream output) Dgital external input Through out to DAOUT when DASEL is "H" (Not used)
Digital-out selection input (Not used) Test pin (Connected to Ground) C2 error correction state display Outputs if corrected properly (Not used) C2 error correction state display Outputs number of errors at C2 (Not used) C2 error correction state display Outputs whether error is present at C1 (Not used) C2 error correction state display Outputs number of errors at C1 (Not used) Muting input "H" mute +5V power supply Ground +5V power supply (Analog) Comparator input (+) (QPSK input) Comparator input () Ground (Analog) Test pin (Connected to ground) +5V power supply Test pin (Connected to ground) Comparate output Comparate inverted output 9.216MHz output (Open) Ground Test pin (Connected to ground) Test pin (Connected to ground) Test pin (Connected to ground) Test pin (Connected to ground) Test pin (Connected to ground) Test pin (Open) Test pin (Open) Ground (Analog) +5V power supply (Analog)
-- 66 --
· IC3311 Digital Audio Interface Receiver (CXD8521M)
Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 Pin Name DIN1 DIN2 E/DOUT VDD R VIN VCO GND CKSEL XMODE AVOCK TST1 TST2 SCLK XLAT SWDT SRDT DQSY CKOUT FS128 BCK LRCK DATAO EROR I/O I I O -- I I O -- I I I I I I I I O O O O O O O O Microcomputer IF clock input Microcomputer IF latch/chip enable input Microcomputer IF write data input Microcomputer IF read data output Microcomputer IF Sub-Q sync and ID sync output (Not used) VCO clock output (Freerunning, 384fs, 512fs) (Not used) 128fs clock output (Not used) Bit clock output L/R clock output Audio data output PLL lock error mute output Description Data input with built-in amplifier (Responding to the coaxial optical module) Data input (Responding to the optical module) Emphasis, input bi-phase, validity flag output Power supply (+5V) VCO gain control input (Fixed at "H") VCO freerunning frequency setting input LPF setting of PLL (Fixed at "L") Ground System clock select input (384fs, 512fs) (Connected to the power supply.) Reset input Clock input for preventing PLL lock failure Test input (Normally "L")
-- 67 --
· IC3410 Digital Signal Processor (DSP56009FJ88F)
Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 Pin Name AGND MCS0 MCS3 MA14 MA13 AVCC MA12 AGND QVCC QGND MA11 MA10 MA9 MA8 AGND MA7 AVCC MA6 MA5 MA4 AGND MA3 MA2 MA1 MA0 SCK EXTAL QVCC QGND PINIT PGND PCAP PVCC SGND MISO RESET MODA MODB MODC SVCC I/O -- O O O O -- O -- -- -- O O O O -- O -- O O O -- O O O O I I -- -- I -- I -- -- I I I I I -- SPI serial clock signal input from system controller External frequency input (3 MHz) Power supply for internal logic (+5V) Ground for internal logic PLL initialize input (Fixed at "L") Ground for PLL PLL filter input (Connected to 0.01 µF capacitor) Power supply for PLL (+5V) Ground for serial port Master data signal input from system controller Reset signal input from system controller Mode select A (Fixed at "H") Mode select B (Fixed at "L") Mode select C (Fixed at "H") Power supply for serial port (+5V) Address data output to S-RAM (Not used) Ground for address bus buffer Address data output to S-RAM (Not used) Ground for address bus buffer Address data output to S-RAM (Not used) Power supply for address bus buffer (+5V) Address data output to S-RAM (Not used) Address buffer ground Chip select 0 output to S-RAM (Not used) Chip select 3 output to S-RAM (Not used) Address data output to S-RAM (Not used) Address bus buffer power supply (+5V) Address data output to S-RAM(Not used) Ground for address bus buffer Power supply for internal logic (+5V) Ground for internal logic Description
-- 68 --
Pin No. 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80
Pin Name MOSI SS HREQ SGND SDO2 SDO1 SDO0 SVCC SCKT WST SCKR QGND QVCC SGND WSR SDI1 SDI0 DSO DSI DSCK DR MD7 MD6 MD5 MD4 DGND MD3 MD2 MD1 DVCC MD0 DGND GPIO3 GPIO2 GPIO1 GPIO0 MRD MWR MRAS MCAS
I/O O I I -- O O O -- O O I -- -- -- I I I O I I I I/O I/O I/O I/O -- I/O I/O I/O -- I/O -- I/O I/O I/O I/O O O O O Write strobe signal output to S-RAM (Not used) Read strobe signal output to S-RAM (Not used) General DSP input/output (Not used) Power supply for data bus buffer (+5V) Data input/output with S-RAM (Not used) Ground for data bus buffer Data input/output with S-RAM (Not used) Ground for data bus buffer Data input/output with S-RAM (Not used) Master data signal output to system controller
Description
SPI slave select signal input from system controller Host request signal input from system controller Ground for serial port Audio serial data 2 signal output (Not used) Audio serial data 1 signal output Audio serial data 0 signal output Power supply for serial port (+5V) Serial clock transmission Word select transmission Serial clock reception Ground for internal logic Power supply for internal logic (+5V) Ground for serial port Word select reception Audio serial data 1 signal input Audio serial data 0 signal input Debug serial signal output (Not used) Debug serial signal input (Not used) Debug serial clock signal input (Not used) Debug request input (Fixed at "H")
Low address strobe signal output to S-RAM (Not used) Column address strobe signal output to S-RAM (Not used)
-- 69 --
· IC3412 Digital Signal Processor (SSP424023FJ88)
Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 Pin Name AGND MCS0 MCS3 MA14 MA13 AVCC MA12 AGND QVCC QGND MA11 MA10 MA9 MA8 AGND MA7 AVCC MA6 MA5 MA4 AGND MA3 MA2 MA1 MA0 SCK EXTAL QVCC QGND PINIT PGND PCAP PVCC SGND MISO RESET MODA MODB MODC SVCC I/O -- O O O O -- O -- -- -- O O O O -- O -- O O O -- O O O O I I -- -- I -- I -- -- I I I I I -- SPI serial clock signal input from system controller External frequency input (3 MHz) Power supply for internal logic (+5V) Ground for internal logic PLL initialize input (Fixed at "L") Ground for PLL PLL filter input (Connected to 0.01 mF capacitor) Power supply for PLL (+5V) Ground for serial port Master data signal input from system controller Reset signal input from system controller Mode select A (Fixed at "H") Mode select B (Fixed at "L") Mode select C (Fixed at "H") Power supply for serial port (+5V) Address data output to S-RAM Ground for address bus buffer Address data output to S-RAM Ground for address bus buffer Address data output to S-RAM Power supply for address bus buffer (+5V) Address data output to S-RAM Address buffer ground Chip select 0 output to S-RAM (Not used) Chip select 3 output to S-RAM Address data output to S-RAM Address bus buffer power supply (+5V) Address data output to S-RAM Ground for address bus buffer Power supply for internal logic (+5V) Ground for internal logic Description
-- 70 --
Pin No. 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80
Pin Name MOSI SS HREQ SGND SDO2 SDO1 SDO0 SVCC SCKT WST SCKR QGND QVCC SGND WSR SDI1 SDI0 DSO DSI DSCK DR MD7 MD6 MD5 MD4 DGND MD3 MD2 MD1 DVCC MD0 DGND GPIO3 GPIO2 GPIO1 GPIO0 MRD MWR MRAS MCAS
I/O O I I -- O O O -- O O I -- -- -- I I I O I I I I/O I/O I/O I/O -- I/O I/O I/O -- I/O -- I/O I/O I/O I/O O O O O General DSP input/output with system controller Write strobe signal output to S-RAM Read strobe signal output to S-RAM Low address strobe signal output to S-RAM Column address strobe signal output to S-RAM General DSP input/output (Not used) Power supply for data bus buffer (+5V) Data input/output with S-RAM Ground for data bus buffer Data input/output with S-RAM Ground for data bus buffer Data input/output with S-RAM Master data signal output to system controller
Description
SPI slave select signal input from system controller Host request signal input from system controller Ground for serial port Audio serial data 2 signal output Audio serial data 1 signal output Audio serial data 0 signal output Power supply for serial port (+5V) Serial clock transmission Word select transmission Serial clock reception Ground for internal logic Power supply for internal logic (+5V) Ground for serial port Word select reception Audio serial data 1 signal input Audio serial data 0 signal input Debug serial signal output (Not used) Debug serial signal input (Not used) Debug serial clock signal input (Not used) Debug request input (Fixed at "H")
-- 71 --
SECTION 3 EXPLODED VIEWS
Note: · -XX, -X mean standardized parts, so they may have some differences from the original one. · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · The mechanical parts with no reference number in the exploded views are not supplied. · Hardware (# mark) list and accessories and packing materials are given in the last of this parts list. Color Indication of Appearance Parts Example: KNOB, BALANCE (WHITE) . . . (RED) Parts of Color Cabinet's Color ·
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.
·
3-1.
FRONT PANEL SECTION ·A : L.B Board 13
12
12
Abbreviation CND : Canadian AUS: Australian CH : Chinese G : German AED : North European EE : East European MY : Malaysia SP : Singapore
#1
14
12 11
#1
16
22 16 20
9
(including ·A)
21
19 18 16 17
8 10
SO NY
23
FL101
14
24 23
·A
16 15
not supplied
7
6 5 4 25
#1 #1 not supplied
#1
DE915 MODEL
26 3 2
Description
1
#1 supplied with RV401
Remarks Ref. No. 12 12 * 13 13 13 14 * 15 16 * 17 * 18 19 20 * 21 * 21 * 21 * 21 22 * 23 * 24 * 25 26 26 26 FL101
Ref. No. 1 1 2 2 2 3 3 3 3 3 4 4 5 6 6 7 8 8 8 9 9 9 10 10 * 11
Part No. 4-980-639-01 4-980-639-31 X-4947-074-1 X-4948-458-1 X-4948-464-1 X-4948-455-1 X-4948-456-1 X-4948-463-1 X-4948-602-1 X-4948-603-1 4-989-850-01 4-989-850-11 4-989-842-01 4-989-852-01 4-989-852-11 4-989-846-01 3-008-600-11 4-979-587-01 4-979-587-11 4-980-109-01 4-980-109-41 4-989-843-01 4-957-383-01 4-957-383-21 1-665-775-11
Part No. 3-704-366-01 3-704-366-11 4-982-682-01 X-4947-722-1 X-4947-723-1 4-985-642-01 4-989-878-01 4-951-620-01 1-665-815-11 1-665-774-11 1-773-174-11 1-773-057-11 A-4398-225-A A-4398-246-A A-4398-281-A A-4398-284-A 1-773-107-11 4-921-941-01 4-990-797-01 1-665-780-11 4-989-864-41 4-991-019-01 4-991-019-11 1-517-671-11
Description
Remarks
KNOB (R14) (BLACK)(DE915/VE910) KNOB (R14) (GOLD)(V909) KNOB (R48) ASSY (BLACK)(DE915) KNOB (ZN) ASSY (BLACK)(VE910) KNOB (ZN) ASSY (GOLD)(V909) PANEL ASSY, FRONT (BLACK)(DE915:US,CND) PANEL ASSY, FRONT (GOLD)(V909) PANEL ASSY (C9), FRONT (BLACK)(VE910) PANEL ASSY, FRONT (BLACK)(DE915:PX) PANEL ASSY, FRONT (BLACK)(DE915:AUS) BUTTON (BB) (BLACK)(DE915/VE910) BUTTON (BB) (GOLD)(V909) INDICATOR (BB) RING (SUR) (BLACK)(DE915/VE910) RING (SUR) (GOLD)(V909) BUTTON (12)(BLACK)(DE915) EMBLEM (5-AR), SONY (BLACK)(DE915) EMBLEM (NO.5), SONY (BLACK)(VE910) EMBLEM (NO.5), SONY (GOLD)(V909) BUTTON (P-M) (BLACK)(VE910) BUTTON (P-M) (GOLD)(V909) BUTTON (P-T) (BLACK)(DE915) KNOB (F14) (BLACK)(DE915/VE910) KNOB (F14) (GOLD)(V909) SP SW BOARD
SCREW (CASE) (M3X8)(BLACK)(DE915/VE910) SCREW (CASE) (M3X8) (GOLD)(V909) CASE (414532) (BLACK)(DE915) CASE ASSY (BLACK)(VE910) CASE ASSY (GOLD)(V909) CUSHION BRACKET (VOL) SCREW (2.6X8), +BVTP BALANCE BOARD VOLUME BOARD WIRE (FLAT TYPE) (21 CORE)(46cm) WIRE (FLAT TYPE) (17 CORE) DISPLAY BOARD, COMPLETE (DE915:US,CND) DISPLAY BOARD, COMPLETE (DE915:AUS) DISPLAY BOARD, COMPLETE (DE915:PX) DISPLAY BOARD, COMPLETE (V909/VE910) WIRE (FLAT TYPE) (19 CORE)(17cm) CUSHION (FL) HOLDER (FL) SW BOARD ESCUTCHEON (COVER)(BLACK)(DE915) ESCUTCHEON (COVER)(BLACK)(VE910) ESCUTCHEON (COVER)(GOLD)(V909) INDICATOR TUBE, FLUORESCENT
-- 72 --
3-2. 60
BACK PANEL SECTION
E, PX MODEL US, CND MODEL AUS MODEL
CH MODEL
58
EXCEPT US, CND, PX, CH MODEL
CNJ909
69
60
60 57 59
61
AUS MODEL
60
EXCEPT US, CND, AUS, CH MODEL #1 #1 #1 #1 #1 #1 #1
70
72
#1 #1 #1 #1 #1 #1 #1 #1 #1 #1 #1
UK MODEL #1 not supplied
55 56
not supplied Q748
71
#2
supplied with J701
54 53
64
62
51 52
#1
66 65
#1 #1 #1
not supplied
67
Ref. No. * * * * 51 52 53 54 Part No. 1-665-786-11 1-665-776-11 1-665-787-11 A-4398-235-A Description Remarks Ref. No. * * * * * * * * * * * * * * * 62 62 62 62 62 62 62 63 63 64 65 66 66 66 67
68
Part No. 4-989-882-01 4-989-882-11 4-989-882-21 4-989-885-01 4-989-885-11 4-989-885-21 4-989-885-31 A-4398-274-A A-4403-423-A 1-665-784-11 1-667-185-11 A-4398-229-A A-4398-251-A A-4398-285-A 1-665-777-11 4-954-051-41 1-569-008-11 1-770-019-11 1-665-788-11 4-947-010-01 Description
63
Remarks
* 54 * 54 * 54 * 55 * 56 * 56 * 56 * 56 57 58 * 59 ! 60 ! 60 ! 60 ! 60 61
AUDIO (2F) BOARD SUR-AUDIO (2F) BOARD S-A-P BOARD SP (2F) BOARD, COMPLETE (VE910:AEP,UK,G,AED,EE) A-4398-250-A SP (2F) BOARD, COMPLETE (DE915:AUS) A-4398-262-A SP (2F) BOARD, COMPLETE (DE915:US,CND,PX) A-4398-295-A SP (2F) BOARD, COMPLETE (V909/VE910:E,SP,MY) 1-665-779-11 HEADPHONE BOARD A-4398-236-A SUR BOARD, COMPLETE (VE910:AEP,UK,G,AED,EE) A-4398-266-A SUR BOARD, COMPLETE (DE915:US,CND,PX) A-4398-279-A SUR BOARD, COMPLETE (V909/VE910:E,SP,MY) A-4398-287-A SUR BOARD, COMPLETE (DE915:AUS) 1-773-116-11 WIRE (FLAT TYPE) (19 CORE)(23cm) 1-773-174-11 WIRE (FLAT TYPE) (21 CORE)(9cm) 3-703-244-00 BUSHING (2104), CORD 1-696-847-11 1-769-743-11 1-769-744-11 1-782-464-21 4-956-370-12 CORD, POWER (AUS) CORD, POWER (US,CND) CORD, POWER (EXCEPT US,CND,AUS,CH) CORD, POWER (CH) BAND, PLUG FIXED (AUS)
PANEL, BACK (VE910:EXCEPT E) PANEL, BACK (VE910:E) PANEL, BACK (V909) PANEL, BACK (DE915:US) PANEL, BACK (DE915:CND) PANEL, BACK (DE915:AUS) PANEL, BACK (DE915:PX) DIGITAL BOARD, COMPLETE (DE915) DIGITAL BOARD, COMPLETE (V909/VE910) VIDEO BOARD JOINT (VIDEO) BOARD S VIDEO BOARD, COMPLETE (DE915:US,CND) S VIDEO BOARD, COMPLETE (DE915:AUS,PX) S VIDEO BOARD, COMPLETE (V909/VE910) VIDEO (3) BOARD HOLDER, PC BOARD ADAPTOR, CONVERSION 2P (E,PX) ADAPTOR, CONVERSION 3P (UK) VOLSEL BOARD (DE915:PX/VE910:E) SCREW, FEEDER FIXED
* 68 ! 69 ! 70 * 71 72
! CNJ909 1-251-416-11 OUTLET, AC (AUS) ! CNJ909 1-526-794-11 OUTLET, AC (EXCEPT US,CND,AUS,PX,CH)
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.
-- 73 --
3-3.
CHASSIS SECTION
not supplied IC801 #1
#1 #1 #1 IC803
Q706, 707 Q756, 757
105
Q506, 507, 556, 557 Q606, 607 not supplied #1
104
#1
102
#1
106
#1
108
#1
108
#3 T901 #1 #3
107
not supplied #1
109
#1
not supplied
#1 not supplied
not supplied
101
#1 not supplied
103
#1 #1
#1
101
#1
103
#1
#1 #1 not supplied
Ref. No. 101 101 101 101 * 102 * 102 * 102 * 102 103 * 104 * 105 * 105 * 105
Part No.
Description
Remarks
Ref. No. * 105 * 106 * 107 108 * 109 * 109 * 109 ! T901 ! T901 ! T901 ! T901 ! T901 ! T901
Part No. A-4398-288-A 1-665-792-11 1-665-791-11 3-905-609-01 A-4398-234-A
Description
Remarks
X-4947-025-1 FOOT ASSY (BLACK)(VE910) X-4947-207-1 FOOT ASSY (F50150S)(BLACK)(DE915:AUS,PX) X-4947-208-1 FOOT ASSY (F50150S)(BLACK) (DE915:US,CND) X-4948-848-1 FOOT ASSY (GOLD)(V909) A-4398-249-A PS BOARD, COMPLETE (DE915:AUS/VE910:AEP,UK,G,AED,EE) A-4398-261-A PS BOARD, COMPLETE (DE915:US,CND) A-4398-278-A PS BOARD, COMPLETE (V909/VE910:E,SP,MY) A-4398-282-A PS BOARD, COMPLETE (DE915:PX) 4-977-358-11 CUSHION (8X12.5) (DE915:US,CND) 1-665-783-11 SECONDARY BOARD A-4398-230-A AMP BOARD, COMPLETE (DE915:US,CND,PX) A-4398-280-A AMP BOARD, COMPLETE (V909/VE910:E,SP,MY) A-4398-286-A AMP BOARD, COMPLETE (VE910:AEP,UK,G,AED,EE)
AMP BOARD, COMPLETE (DE915:AUS) AMP JOINT (B) BOARD AMP JOINT (F) BOARD SCREW (TRANSISTOR) REAR AMP BOARD, COMPLETE (V909/VE910)
A-4398-248-A REAR AMP BOARD, COMPLETE (DE915:AUS) A-4398-258-A REAR AMP BOARD, COMPLETE (DE915:US,CND,PX) 1-431-281-11 TRANSFORMER, POWER (US) 1-431-282-11 TRANSFORMER, POWER (CND) 1-431-283-11 TRANSFORMER, POWER (AUS) 1-431-284-11 TRANSFORMER, POWER (PX) 1-431-285-11 TRANSFORMER, POWER (E,SP,MY,CH) 1-431-286-11 TRANSFORMER, POWER (AEP,UK,G,EE,AED)
-- 74 --
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.
SECTION 4 ELECTRICAL PARTS LIST
Note:
When indicating parts by reference number, please include the board naame. The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.
AMP
· · COILS uH: µH SEMICONDUCTORS In each case, u: µ, for example: uA...: µA... , uPA... , µPA... , uPB... , µPB... , uPC... , µPC... , uPD..., µPD... Abbreviation CND : Canadian AUS: Australian CH : Chinese G : German AED : North European EE : East European MY : Malaysia SP : Singapore
· ·
· ·
·
Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. Ref. No. Part No. Description * * * *
-XX, -X mean standardized parts, so they may have some difference from the original one. Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. CAPACITORS: uF: µF RESISTORS All resistors are in ohms. METAL: metal-film resistor METAL OXIDE: Metal Oxide-film resistor F: nonflammable Remarks Ref. No. Part No.
·
Description < CONNECTOR >
Remarks
A-4398-230-A AMP BOARD, COMPLETE (DE915:US,CND,PX) ******************** A-4398-280-A AMP BOARD, COMPLETE (V909/VE910:E,SP, ********************* MY) A-4398-286-A AMP BOARD, COMPLETE (VE910:AEP,UK,G, ********************* AED,EE) A-4398-288-A AMP BOARD, COMPLETE (DE915:AUS) ******************** 1-537-738-21 TERMINAL, EARTH 7-685-872-09 SCREW +BVTT 3X8 (S) < CAPACITOR > C520 C521 C522 C523 C524 C525 C526 C570 C571 C572 C573 C574 C575 C576 C590 C598 C620 C621 C622 C623 C803 C803 C804 C804 1-126-967-11 1-107-597-11 1-107-597-11 1-162-286-31 1-126-964-11 1-136-157-00 1-136-153-00 1-126-967-11 1-107-597-11 1-107-597-11 1-162-286-31 1-126-964-11 1-136-157-00 1-136-153-00 1-126-935-11 1-126-965-11 1-126-967-11 1-107-597-11 1-107-597-11 1-162-286-31 ELECT CERAMIC CERAMIC CERAMIC ELECT FILM FILM ELECT CERAMIC CERAMIC CERAMIC ELECT FILM FILM ELECT ELECT ELECT CERAMIC CERAMIC CERAMIC 47uF 22PF 22PF 220PF 10uF 0.022uF 0.01uF 47uF 22PF 22PF 220PF 10uF 0.022uF 0.01uF 470uF 22uF 47uF 22PF 22PF 220PF 10000uF 10000uF 10000uF 10000uF 20% 10% 10% 10% 20% 5% 5% 20% 10% 10% 10% 20% 5% 5% 20% 20% 20% 10% 10% 10% 16V 500V 500V 50V 50V 50V 50V 16V 500V 500V 50V 50V 50V 50V 6.3V 50V 16V 500V 500V 50V
CNP701 CNP702 CNS502 CNS602 CNS701
1-564-320-00 1-695-091-11 1-770-404-11 1-770-404-11 1-569-323-11
PIN, CONNECTOR (B2P-VH) 2P PIN, CONNECTOR (PC BOARD) 15P HOUSING,CONNECTOR(PC BOARD)11P HOUSING,CONNECTOR(PC BOARD)11P SOCKET, CONNECTOR 19P < DIODE >
*
D501 D502 D503 D504 D505 D506 D507 D508 D512 D545 D546 D547 D548 D549 D551 D552 D553 D554 D555 D556 D601 D602 D603 D604 D608 D611 D647 D648 D651 D711 D716 D807
8-719-987-63 8-719-010-06 8-719-010-06 8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63 8-719-815-85 8-719-815-85 8-719-987-63 8-719-010-06 8-719-010-06 8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63 8-719-010-06 8-719-010-06 8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63
DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE
1N4148M UZ-2.2BS UZ-2.2BS 1N4148M 1N4148M 1N4148M 1N4148M 1N4148M 1N4148M 1N4148M 1N4148M 1N4148M 1S1585 1S1585 1N4148M UZ-2.2BS UZ-2.2BS 1N4148M 1N4148M 1N4148M 1N4148M UZ-2.2BS UZ-2.2BS 1N4148M 1N4148M 1N4148M 1N4148M (DE915) 1N4148M (DE915) 1N4148M 1N4148M
1-117-950-11 ELECT(SOLID) 1-109-932-11 ELECT 1-117-950-11 ELECT(SOLID) 1-109-932-11 ELECT
20% 63V (V909/VE910) 20% 71V (DE915) 20% 63V (V909/VE910) 20% 71V (DE915) 20% 20% 20% 20% 20% 20% 20% 16V 16V 16V 35V 35V 50V 50V
C807 C808 C810 C811 C812 C817 C818
1-126-967-11 1-126-967-11 1-126-967-11 1-126-952-11 1-126-951-11
ELECT ELECT ELECT ELECT ELECT
47uF 47uF 47uF 1000uF 470uF 47uF 47uF
8-719-987-63 DIODE 1N4148M 8-719-002-73 DIODE UZL-36M < IC >
IC801 IC803
8-759-391-87 IC BA78M12P 8-759-604-45 IC M5F79M12
1-126-967-11 ELECT 1-126-967-11 ELECT
-- 75 --
AMP
Ref. No. Part No. Description < COIL > L501 L501 L551 L551 1-411-906-11 1-420-872-00 1-411-906-11 1-420-872-00 COIL, AIR-CORE (V909/VE910) COIL, AIR-CORE (DE915) COIL, AIR-CORE (V909/VE910) COIL, AIR-CORE (DE915) < TRANSISTOR > Q504 Q505 Q506 Q507 Q508 Q509 Q510 Q511 Q546 Q547 Q548 Q549 Q554 Q555 Q556 Q557 Q558 Q559 Q560 Q561 Q596 Q604 Q605 Q606 Q607 Q608 Q610 Q612 Q613 Q614 Q615 Q616 Q617 Q618 Q801 8-729-119-76 8-729-209-15 8-749-010-25 8-749-010-26 8-729-140-82 8-729-281-53 8-729-900-63 8-729-900-63 8-729-119-79 8-729-140-84 8-729-119-79 8-729-140-82 8-729-119-76 8-729-209-15 8-749-010-25 8-749-010-26 8-729-140-82 8-729-281-53 8-729-900-63 8-729-900-63 8-729-119-79 8-729-119-76 8-729-209-15 8-749-010-25 8-749-010-26 8-729-140-82 8-729-119-79 8-729-281-53 8-729-281-53 8-729-201-53 8-729-900-36 8-729-900-36 8-729-900-36 8-729-900-63 8-729-209-15 TRANSISTOR 2SA1175-HFE TRANSISTOR 2SD2012 IC MN2488-OPY-M IC MP1620-OPY-M TRANSISTOR 2SA988-PAFAEA TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC1815-GR DTA124ES DTA124ES 2SC2785-FEK 2SC1841-PAFAEA R539 R540 R541 R547 R548 ! R549 R550 R571 R572 R572 TRANSISTOR 2SC2785-FEK TRANSISTOR 2SA988-PAFAEA TRANSISTOR 2SA1175-HFE TRANSISTOR 2SD2012 IC MN2488-OPY-M IC MP1620-OPY-M TRANSISTOR 2SA988-PAFAEA TRANSISTOR 2SC1815-GR TRANSISTOR DTA124ES TRANSISTOR DTA124ES TRANSISTOR 2SC2785-FEK TRANSISTOR 2SA1175-HFE TRANSISTOR 2SD2012 IC MN2488-OPY-M IC MP1620-OPY-M TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR < RESISTOR > R521 R522 R522 R523 ! R524 ! R525 ! R526 R527 R528 R529 R530 R531 R532 1-249-437-11 CARBON 1-247-840-00 1-249-421-11 1-249-414-11 1-249-408-11 1-249-408-11 1-233-352-41 1-247-850-11 1-249-419-11 1-247-866-11 1-249-421-11 1-249-433-11 1-249-437-11 1/4W (DE915) CARBON 2.4K 5% 1/4W (V909/VE910) CARBON 2.2K 5% 1/4W F (DE915) CARBON 560 5% 1/4W F CARBON 180 5% 1/4W F CARBON 180 5% 1/4W F ENCAPSULATED COMPONENT CARBON 6.2K 5% 1/4W CARBON CARBON CARBON CARBON CARBON 1.5K 30K 2.2K 22K 47K 5% 5% 5% 5% 5% 1/4W F 1/4W 1/4W F 1/4W 1/4W 47K 5% 2SA988-PAFAEA 2SC2785-FEK 2SC1815-GR (DE915) 2SC1815-GR 2SA1015-GR (DE915) DTC124ES (DE915) DTC124ES DTC124ES (DE915) DTA124ES (DE915) 2SD2012 R573 ! R574 ! R575 ! R576 R577 R578 R579 R580 R581 R582 ! R583 ! R584 R585 R586 R587 ! R588 R621 1-249-427-11 1-249-417-11 1-249-429-11 1-249-425-11 1-249-429-11 1-249-393-11 1-249-429-11 1-249-437-11 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 6.8K 1K 10K 4.7K 10K 10 10K 47K 2.4K 2.2K 560 180 5% 5% 5% 5% 5% 5% 5% 5% Remarks Ref. No. ! R533 ! R534 R535 R536 Part No. 1-249-393-11 1-249-389-11 1-249-431-11 1-249-439-11 Description CARBON CARBON CARBON CARBON 10 4.7 15K 68K 5% 5% 5% 5% Remarks 1/4W F 1/4W F 1/4W 1/4W (V909/VE910) 1/4W (DE915) 1/4W F 1/4W F 1/4W 1/4W F
R536
1-249-441-11 CARBON
100K
5%
1-247-840-00 CARBON 1-249-421-11 CARBON 1-249-414-11 CARBON 1-249-408-11 CARBON 1-249-408-11 1-233-352-41 1-247-850-11 1-249-419-11 1-247-866-11 1-249-421-11 1-249-433-11 1-249-437-11 1-249-393-11 1-249-389-11 1-249-431-11 1-249-429-11 1-249-425-11 1-249-393-11 1-249-437-11
1/4W 1/4W F 1/4W 1/4W (DE915) 5% 1/4W (V909/VE910) 5% 1/4W F (DE915) 5% 1/4W F 5% 1/4W F
CARBON 180 5% 1/4W F ENCAPSULATED COMPONENT 0.22X2 2W CARBON 6.2K 5% 1/4W CARBON 1.5K 5% 1/4W F CARBON 30K 5% 1/4W CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 2.2K 22K 47K 10 4.7 15K 10K 4.7K 10 47K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W F 1/4W 1/4W 1/4W F 1/4W F 1/4W 1/4W 1/4W F 1/4W F 1/4W (DE915)
R622 R622 R623 ! R624 ! R625 ! R626 R627 R628 R632 R640
1-247-840-00 CARBON 1-249-421-11 1-249-414-11 1-249-408-11 1-249-408-11 1-233-352-41 1-247-850-11
1/4W (V909/VE910) CARBON 2.2K 5% 1/4W F (DE915) CARBON 560 5% 1/4W F CARBON 180 5% 1/4W F CARBON 180 5% 1/4W F ENCAPSULATED COMPONENT 0.22X2 2W CARBON 6.2K 5% 1/4W 1.5K 47K 82 5% 5% 5% 1/4W F 1/4W 2W F (DE915)
2.4K
5%
1-249-419-11 CARBON 1-249-437-11 CARBON 1-216-450-00 METAL OXIDE
R641 R642 R642 R643 R644
1-249-441-11 CARBON 1-216-454-11 METAL OXIDE 1-215-889-00 METAL OXIDE 1-249-441-11 CARBON 1-215-890-11 METAL OXIDE
100K 390 330 100K 470
1/4W (DE915) 5% 2W F (V909/VE910) 5% 2W F (DE915) 5% 1/4W 5% 2W F (DE915)
5%
-- 76 --
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.
AMP
AMP JOINT (F)
AMP JOINT (B) DIGITAL
Remarks
AUDIO (2F)
Ref. No. R645 R650 R651 ! R652 R739 R789 ! R802 R803 Part No. Description 100K 4.7K 10K 10 680 680 1 3.3K 5% 5% 5% 5% 5% 5% 5% 5% Remarks 1/4W (DE915) 1/4W F 1/4W 1/4W F 1W F 1W F 1/4W F 1/4W Ref. No. Part No. 1-249-441-11 CARBON 1-249-425-11 CARBON 1-249-429-11 CARBON 1-249-393-11 CARBON 1-215-868-00 1-215-868-00 1-249-381-11 1-247-843-11 METAL OXIDE METAL OXIDE CARBON CARBON < RELAY > RY501 RY502 RY602 1-515-920-11 RELAY (24V) 1-515-920-11 RELAY (24V) 1-515-793-11 RELAY < TERMINAL > * TM501 1-537-699-11 TERMINAL BOARD (SP) (FRONT SPEAKERS) ************************************************************ * 1-665-791-11 AMP JOINT (F) BOARD ******************* < CONNECTOR > CNP501 1-770-553-11 CONNECTOR, BOARD TO BOARD 11P CNP502 1-770-553-11 CONNECTOR, BOARD TO BOARD 11P ************************************************************ * 1-665-792-11 AMP JOINT (B) BOARD ******************* < CONNECTOR > CNP601 1-770-553-11 CONNECTOR, BOARD TO BOARD 11P CNP602 1-770-553-11 CONNECTOR, BOARD TO BOARD 11P ************************************************************ * 1-665-786-11 AUDIO (2F) BOARD ************** < CAPACITOR > C398 C399 CC08 CC09 CC10 100PF 10% 50V 0.001uF 10% 50V 100PF 10% 50V (DE915:AUS/VE910:AEP,UK,G,AED,EE) 1-162-282-31 CERAMIC 100PF 10% 50V (DE915:AUS/VE910:AEP,UK,G,AED,EE) 1-162-282-31 CERAMIC 100PF 10% 50V (DE915:AUS/VE910:AEP,UK,G,AED,EE) 1-162-282-31 CERAMIC 1-162-282-31 1-162-282-31 1-162-282-31 1-162-282-31 100PF 10% 50V (DE915:AUS/VE910:AEP,UK,G,AED,EE) CERAMIC 100PF 10% 50V (DE915:AUS/VE910:AEP,UK,G,AED,EE) CERAMIC 100PF 10% 50V (DE915:AUS/VE910:AEP,UK,G,AED,EE) CERAMIC 100PF 10% 50V (DE915:AUS/VE910:AEP,UK,G,AED,EE) CERAMIC 100PF 10% 50V (DE915:AUS/VE910:AEP,UK,G,AED,EE) 1-162-282-31 CERAMIC 1-162-294-31 CERAMIC 1-162-282-31 CERAMIC
BALANCE
Description < CONNECTOR >
CNS302 1-695-093-11 SOCKET, CONNECTOR 9P < IC > IC303 8-759-805-14 IC LC7822 < JACK > J304 J305 1-766-394-11 JACK, PIN 6P (VIDEO 1 IN OUT,VIDEO 2 IN) 1-766-394-11 JACK, PIN 6P (VIDEO 2 OUT,LD/DVD,TV/DBS) < RESISTOR > R318 R319 R320 R321 R322 R323 R368 R369 R370 R371 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 1K 1K 1K 1K 1K 1K 1K 1K 1K 1K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F F F F F F F F F F
R372 1-249-417-11 CARBON 1K 5% 1/4W F R373 1-249-417-11 CARBON 1K 5% 1/4W F R398 1-249-417-11 CARBON 1K 5% 1/4W F R399 1-249-425-11 CARBON 4.7K 5% 1/4W F ************************************************************ * 1-665-815-11 BALANCE BOARD ************* < VARIABLE RESISTOR > RV402 1-225-447-11 RES, VAR, CARBON 100K/100K (BALANCE) ************************************************************ * * A-4398-274-A DIGITAL BOARD, COMPLETE (DE915) ************************ A-4403-423-A DIGITAL BOARD, COMPLETE (V909/VE910) ************************ < CAPACITOR > C3101 C3102 C3103 C3104 C3105 C3106 C3107 C3108 C3110 C3111 C3112 C3113 C3114 C3115 C3116 1-126-964-11 1-126-964-11 1-130-467-00 1-130-467-00 1-126-964-11 1-165-319-11 1-106-351-00 1-165-319-11 1-104-665-11 1-164-222-11 1-126-964-11 1-126-964-11 1-164-222-11 1-126-967-11 1-165-319-11 ELECT ELECT MYLAR MYLAR ELECT CERAMIC CHIP MYLAR CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP 10uF 10uF 470PF 470PF 10uF 0.1uF 2200PF 0.1uF 100uF 0.22uF 10uF 10uF 0.22uF 47uF 0.1uF