Text preview for : lg_42px3dbv_42px3dbv-uc_42px3dlv_42px3dlv-uc_chasis_af-044c_sm_[ET].pdf part of lg plasma lg_42px3dbv_42px3dbv-uc_42px3dlv_42px3dlv-uc free download service manual



Back to : lg_42px3dbv_42px3dbv-uc_4 | Home

CANADA : http//biz.lgservice.com USA : http//www.lgservice.com : http//lgservice.com/techsup.html

PLASMA TV SERVICE MANUAL
CHASSIS : AF-044C

MODEL : 42PX3DBV 42PX3DBV-UC MODEL : 42PX3DLV 42PX3DLV-UC
CAUTION
BEFORE SERVICING THE CHASSIS, READ THE SAFETY PRECAUTIONS IN THIS MANUAL.

TV/AV

MENU

OK

VOL

PR

SAFETY PRECAUTIONS
IMPORT ANT SAFETY NOTICE
Many electrical and mechanical parts in this chassis have special safety-related characteristics. These parts are identified by in the Schematic Diagram and Replacement Parts List. It is essential that these special safety parts should be replaced with the same components as recommended in this manual to prevent X-RADIATION, Shock, Fire, or other Hazards. Do not modify the original design without permission of manufacturer.

General Guidance
An lsolation Transformer should always be used during the servicing of a receiver whose chassis is not isolated from the AC power line. Use a transformer of adequate power rating as this protects the technician from accidents resulting in personal injury from electrical shocks. It will also protect the receiver and it's components from being damaged by accidental shorts of the circuitary that may be inadvertently introduced during the service operation. If any fuse (or Fusible Resistor) in this monitor is blown, replace it with the same specified type. When replacing a high wattage resistor (Oxide Metal Film Resistor, over 1W), keep the resistor 10mm away from PCB. Keep wires away from high voltage or high temperature parts.

Leakage Current Hot Check (See below Figure)
Plug the AC cord directly into the AC outlet. Do not use a line Isolation Transformer during this check. Connect 1.5K/10watt resistor in parallel with a 0.15uF capacitor between a known good earth ground (Water Pipe, Conduit, etc.) and the exposed metallic parts. Measure the AC voltage across the resistor using AC voltmeter with 1000 ohms/volt or more sensitivity. Reverse plug the AC cord into the AC outlet and repeat AC voltage measurements for each esposed metallic part. Any voltage measured must not exceed 0.75 volt RMS which is corresponds to 0.5mA. In case any measurement is out of the limits sepcified, there is possibility of shock hazard and the set must be checked and repaired before it is returned to the customer.

Leakage Current Hot Check circuit

AC Volt-meter
Leakage Current Cold Check(Antenna Cold Check)
With the instrument AC plug removed from AC source, connect an electrical jumper across the two AC plug prongs. Place the AC switch in the on positioin, connect one lead of ohm-meter to the AC plug prongs tied together and touch other ohm-meter lead in turn to each exposed metallic parts such as antenna terminals, phone jacks, etc. If the exposed metallic part has a return path to the chassis, the measured resistance should be between 1M and 5.2M. When the exposed metal has no return path to the chassis the reading must be infinite. An-other abnormality exists that must be corrected before the receiver is returned to the customer.
Good Earth Ground such as WATER PIPE, CONDUIT etc.
0.15uF

To Instrument's exposed METALLIC PARTS

1.5 Kohm/10W

CANADA: LG Electronics Canada, Inc. 550 Matheson Boulevard East Mississauga, Ontario L4Z 4G3 USA : LG Customer Interactive Center P.O.Box 240007, 201 James Record Road Huntsville, AL 35824 Digital TV Hotline 1-800-243-0000

- 2 -

TABLE OF CONTENTS
DESCRIPTION OF CONTROLS ...........................................4 SPECIFICATIONS.................................................................8 ADJUSTMENT INSTRUCTIONS ..........................................9 BLOCK DIAGRAM...............................................................14 EXPLODED VIEW...............................................................16 EXPLODED VIEW PARTS LIST .........................................17 REPLACEMENT PARTS LIST ............................................18 SCHEMATIC DIAGRAM.......................................................... PRINTED CIRCUIT BOARDS .................................................

- 3 -

DESCRIPTION OF CONTROLS

Controls
- This is a simplified representation of front panel. Image shown may be somewhat different from your TV.

Front Panel Controls

TV/VIDEO

MENU

ENTER

VOL

CH

CHANNEL (E, VOLUME (F , Remote Control Sensor ENTER Button MENU Button TV/VIDEO Button POWER Button Power Standby Indicator Illuminates red in standby mode, Illuminates green when the TV is turned on.
G)

D)

Buttons

Buttons

- 4 -

DESCRIPTION OF CONTROLS

Connection Options
Back Connection Panel

A/V 2

S-VIDEO

S-VIDEO Input A connection available to provide better picture quality than the video input. VIDEO Input Connects the video signal from a video device. AUDIO Input Use to connect to hear stereo sound from an external device.

R AUDIO

L / MONO

VIDEO

Remote Control Port Connect your wired remote control here.

DVI Input/Audio Input/RGB Input Connect the monitor output connector from a PC to the appropriate input port.

DVD/DTV Input (Component 1-2) Connect a component video/audio device to these jacks.

S-Video Input Connect S-Video out from an S-VIDEO device to the SVIDEO input.

DIGITAL AUDIO (OPTICAL)

COMPONENT 2 COMPONENT 1

DVD /DTV INPUT

A/V INPUT 1
R

(MONO)

RS-232C INPUT
(CONTROL/SERVICE)

REMOTE CONTROL

DVI COMPONENT1 INPUT INPUT OUTPUT

DVI INPUT (PC/DTV INPUT)

AUDIO INPUT

RGB INPUT (PC/DTV INPUT)

R

L

L

VIDEO

S-VIDEO

Antenna Analog/DTV AC INPUT

AUDIO INPUT

VIDEO INPUT

AUDIO

Digital Audio (DVI: Digital Visual Interface/Component1) Input/ Digital Audio Output Connect digital audio from various types of equipment. Note: In standby mode, these ports will not work. RS-232C INPUT (CONTROL/SERVICE) PORT Connect to the RS-232C port on a PC.

Antenna Inputs Audio/Video Input 1 Connect cable or antenna signals to the Connect audio/video outTV, either directly or through your cable put from an external box. device to these jacks. Power Cord Socket This TV operates on an AC power. The voltage is indicated on the Specifications page. Never attempt to operate the TV on DC power.

- 5 -

DESCRIPTION OF CONTROLS

Remote Control Key Functions
- When using the remote control, aim it at the remote control sensor on the TV.

COMP/RGB/DVI Selects: Component 1-2, RGB-DTV (or RGB-PC), DVI-DTV (or DVI-PC) input sources.

COMP/RGB/DVI

TV/VIDEO

MODE

MODE Selects the remote operating mode: TV, DVD, VCR, AUDIO, CABLE or STB. Select a mode other than TV, for the remote to operate an external device.
INFO

TV/VIDEO External input modes rotate in regular sequence: Antenna, Cable, Video, Front Video, Component 1-2 and RGB-DTV (or RGB-PC) input sources. (Video, Front Video, Component 1-2 input sources are linked automatically, only if these are connected )

MENU Brings up the main menu to the screen.

RATIO Changes the aspect ratio.

EXIT

EXIT Clears all on-screen displays and returns to TV viewing from any menu. SAP Selects MTS sound: Mono, Stereo, and SAP in Analog mode. Change the audio language in DTV mode.

SAP

TIMER

CC

TIMER Lets you select the amount of time before your TV turns itself off automatically.

SURF

SURF Scrolls the Favorite channels.

MUTE Switches the sound on or off.
XD

FLASHBK

FREEZE

FLASHBK Tunes to the recent channels.

EZ PIC Selects a factory preset picture mode depending on the viewing environment.

FREEZE Freezes the currently-viewed picture. Main picture is frozen.

- 6 -

DESCRIPTION OF CONTROLS
POWER Turns your TV or any other programmed equipment on or off, depending on mode.

COMP/RGB/DVI

TV/VIDEO

INFO When you watch the TV, information displays on top of the screen. Not available in Component 1-2 and RGB mode.

MODE

VCR/DVD BUTTONS · Control some video cassette recorders or DVD players. ("RECORD" button is not available for DVD players.)

INFO

THUMBSTICK (Up/Down/Left/Right/ENTER) Allows you to navigate the on-screen menus and adjust the system settings to your preference. CC Select a closed caption: Off, CC1~4, Text1~4.
EXIT

SAP

TIMER

CC

CHANNEL UP/DOWN Selects available channels found with EZ scan. PAGE UP/PAGE DOWN Moves from one full set of screen information to the next one.

SURF

VOLUME UP/DOWN Increases/decreases the sound level.

NUMBER buttons

EZ SOUND Selects the sound appropriate for the program's character.

FLASHBK

XD

FREEZE

XD Switches the XD function on or off.

ADJUST Adjusts screen position, size, and phase in PC mode.

LIGHT Illuminates the remote control buttons of selected mode.

- 7 -

SPECIFICATIONS

MODEL
Width (inches / mm) Height (inches / mm) Depth (inches / mm) Weight (pounds / kg) Resolution Power requirement Television System Program Coverage External Antenna Impedance Operating Temperature Range Operating Humidity Range

42PX3DBV-UC/42PX3DLV-UC
47.6 / 1210 27.6 / 701 11.6 / 295 66.1 / 30 852 x 480 (Dot) AC100-240V ~ 50/60Hz NTSC-M, ATSC, 64 & 256 QAM VHF 2 ~ 13, UHF 14 ~ 69, CATV 1 ~ 125, CADTV 1 ~ 135. DTV 2 ~ 69 75 32 ~ 104°F (0 ~ 40°C) Less than 80%

· The specifications shown above may be changed without prior notice for quality improvement.

- 8 -

ADJUSTMENT INSTRUCTIONS
1. Application Object
These instructions are applied to all of the PDP TV, AF-044C.

4. SUB MICOM Download
4-1. Select the MICOM Model

2. Notes
(1) Because this is not a hot chassis, it is not necessary to use an isolation transformer. However, the use of isolation transformer will help protect test instrument. (2) Adjustments must be done in the correct order. (3) The adjustments must be performed in the circumstance of 25±5°C of temperature and 65±10% of relative humidity if there is no specific designation. (4) The input voltage of the receiver be must kept 110V, 60Hz when adjusting. (5) The receiver must be operational for about 15 minutes prior to the adjustments. 1) After receiving 100% white pattern, the receiver must be operated prior to adjustment. (Or 5. White Pattern condition in EZ - Adjust) 2) Enter into White Pattern - Enter the Ez - Adjust by pressing ADJ Key on Service Remote Control (S R/C). - Select the 5. White Pattern using CH +/- Key and press the Enter(Y) Key. Display the 100% Full White Pattern. [ Set is activated HEAT-RUN without signal generator in this mode. If you turn on a still screen more than 20 minutes (Especially Digital pattern(13 CH), Cross Hatch Pattern), an afterimage may occur in the black level part of the screen.

3. EPLD Download
Select the MICOM Model.(M16C/6H Group --> M306H3FC) [ After setting, you need not set, again.
PC VSC B/D

4-2. JIG Connection
Connection to the Micom Port on the TV Board. (Spot of the red line(an arrow)is connected to the port 1.)

Connection Diagram of EPLD Download


(1) Test Equipment: PC, Jig for download (2) Connect the power of VSC B/D. (3) Execute download program( ) of PC. (4) After executing execution hot key (Programmer), icon click (5) End after confirming
Connection the Computer

- 9 -

ADJUSTMENT INSTRUCTIONS
4-3. Program Download
3. When the program is clicked, appear the window as below

Program Click

1. In performing the Download program, if it rightly connects to the board, it is appeared as upper red box. And it is appeared as lower dialog box.

2. Click the OPEN to select the download program. So appear the dialog box.

- 10 -

ADJUSTMENT INSTRUCTIONS
Each PCB Assy must be checked by Check JIG Set before assembly. (Especially, be careful Power PCB Assy which can cause Damage to the PDP Module.)

6. EDID(The Extended Display Identification Data)/DDC (Display Data Channel) download
This is the function that enables "Plug and Play".

5. POWER PCB Assy Voltage Adjustment (Va, Vs Voltage Adjustment)
5-1. Test Equipment : D.M.M 1EA 5-2. Connection Diagram for Measuring
Refer to Fig 1.

6-1. EDID DATA for DVI
Block(0) EDID table =

: EDID for DVI (DDC (Display Data Channel) Data)
00 01 02 03 04 05 06 07 08 09 0A 0B 0C 0D 0E 0F __________________________________________________ 00 | 00 FF FF FF FF FF FF 00 1E 6D 01 01 01 01 01 01 10 | 06 0E 01 03 98 5C 34 96 08 CF 72 A3 57 4C B0 23 20 | 09 45 5D EF CE 00 31 D9 31 59 45 59 01 01 01 01 30 | 01 01 01 01 01 40 C3 1E 00 20 41 00 20 30 10 60 40 | 13 00 98 08 32 00 00 18 00 00 00 FC 00 4C 47 20 50 | 54 56 0A 00 00 00 00 00 00 00 00 00 00 FD 00 30 60 | 4C 1E 64 0F 00 0A 20 20 20 20 20 20 00 00 00 FC 70 | 00 0A 00 00 00 00 00 00 00 00 00 00 00 00 01 1D

Block(1) EDID table =
00 01 02 03 04 05 06 07 08 09 0A 0B 0C 0D 0E 0F _______________________________________________ 00 | 02 01 04 00 01 1D 00 72 51 D0 1E 20 6E 28 55 00 10 | C4 8E 21 00 00 1E 8C 0A D0 8A 20 E0 2D 10 10 3E 20 | 96 00 C4 8E 21 00 00 18 01 1D 80 18 71 1C 16 20 30 | 58 2C 25 00 C4 8E 21 00 00 9E 00 00 00 00 00 00 40 | 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00 50 | 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00 60 | 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00 70 | 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00 BF

Connection Diagram of Power Adjustment for the Measuring (P/N: 6709V00010A)

5-3. Adjustment
(1) Va Adjustment
1) Connect + terminal of D.M.M to Va pin of P807 and connect ­ terminal to GND pin of P807. 2) Adjust RV501 voltage to match that of the label on the Top/Right of the panel. (Deviation : ±0.5V)

6-2. EDID DATA for RGB

(2) Vs Adjustment
1) Connect + terminal of D.M.M to Vs pin of P807 and connect ­ terminal to GND pin of P807. 2) Adjust RV401 voltage to match that of the label on the Top/Right of the panel. (Deviation : ±0.5V)

: EDID table =
00 01 02 03 04 05 06 07 08 09 0A 0B 0C 0D 0E 0F _________________________________________________ 00 | 00 FF FF FF FF FF FF 00 1E 6D 01 01 01 01 01 01 10 | 06 0E 01 03 18 5C 34 96 08 CF 72 A3 57 4C B0 23 20 | 09 45 5D EF CE 00 31 D9 31 59 45 59 01 01 01 01 30 | 01 01 01 01 01 40 C3 1E 00 20 41 00 20 30 10 60 40 | 13 00 98 08 32 00 00 18 00 00 00 FC 00 4C 47 20 50 | 54 56 0A 00 00 00 00 00 00 00 00 00 00 FD 00 30 60 | 4C 1E 64 0F 00 0A 20 20 20 20 20 20 00 00 00 FC 70 | 00 0A 00 00 00 00 00 00 00 00 00 00 00 00 00 9E

- 11 -

ADJUSTMENT INSTRUCTIONS
7. AD9883A-Set Adjustment
7-1. Synopsis
AD9883A-Set adjustment to set the black level and the Gain of optimum with an automatic movement from the analog => digital converter.

8. Adjustment of White Balance
8-1. Required Equipment
(1) Color analyzer (CA-100 or similar product) (2) Automatic adjustor (with automatic adjustment hour necessity and the RS-232C communication being possible) (3) AV Pattern Generator

7-2. Test Equipment
Service R/C, 801GF(802B, 802F, 802R) Pattern Generator (720P The Vertical 100% Color Bar Pattern output will be possible and the output level will accurately have to be adjusted to 0.7±0.1Vp-p)

8-2. Connection Diagram of Equipment for Measuring (Automatic Adjustment)
COLOR ANALYZER TYPE; CA-100 High Light Adjustment Low Light Adjustment CVBS Signal Input PDP MONITOR Window MSPG-2100 or MSTG-5200

Adjustment Pattern : 720P Vertical Color Bar

RS-232C

Connection Diagram of Automatic Adjustment

7-3. Adjustment
(1) Select Component1 or Component2 as the input with 100% Vertical Color Bar Pattern(TVBAR_100) in 720P Mode. (2) After receiving signal for at least 1 second, press the ADJ Key on the Service R/C to enter the `Ez - Adjust' and select the `1. AD9883A-Set'. Pressing the + Key to adjust with automatic movement. (3) When the adjustment is over, 'Complete Auto Configuration' is displayed. If the adjustment has errors, 'AD9883A Configuration Error' is displayed. (4) Readjust after confirming the case Pattern or adjustment condition where the adjustment had errors. (5) After adjustment is complete, exit the adjustment mode by pressing the ADJ KEY.

[ RS-232C Command (Automatic Adjustment)
RS-232C Command MIN [CMD ID DATA] R Gain G Gain B Gain R Cut G Cut B Cut ja 00 XX jb 00 XX jc 00 XX lj 00 XX lk 00 XX ll 00 XX 00 00 00 00 00 00 CENTER (DEFAULT) 7f 7f 7f(fix.) 3f(fix.) 3f 3f MAX ff ff ff 7f 7f 7f

- 12 -

ADJUSTMENT INSTRUCTIONS
8-3. Adjustment of White Balance
Operate the Zero-calibration of the CA-100, then attach sensor to PDP module surface when you adjust. O Manual adjustment is also possible by the following sequence.
O

(1) Enter `Ez - Adjust' by pressing ADJ KEY on the Service Remote Control. (2) Select "5. WHITE PATTERN" using CH +/- Key and HEAT RUN at least 15 minutes by pressing the ENTER Key. (3) Receive the Window pattern signal from DVI Pattern Generator. (DVI-DTV 720P/60Hz) (4) Set Picture condition to "CLEAR Image" and `XD' off (5) After attaching sensor to center of screen, select `3. WhiteBalance' of `Ez - Adjust' by pressing the ADJ KEY on the Service R/C. Then enter adjustment mode by pressing the Right KEY (G) . (6) Adjust the Hight Light using R Gain/G Gain and adjust the Low Light using G Cut/B Cut. (7) Adjust using Volume +/- KEY. (B Gain: 127/R Cut: 63 Fix.) High Light: Digital Gray 160Step Low Light: Digital Gray 55Step X; 0.290±0.003 Y; 0.285±0.003 Color temperature: 9,200°K±500°K (8) After adjustment is complete, move to Ez - Adjust screen by pressing the ENTER(Y) KEY. Then exit the adjustment mode by press ADJ KEY.

9. DVCO Adjustment
(1) After adjusting Main/Sub Contrast, receive a Digital Pattern. (2) Select `4. DVCO-Set' by pressing the ADJ KEY on the Service R/C and adjust by pressing the Right KEY (G) . (3) When adjustment is complete,"DVCO-Set" will appear. Exit the adjustment mode menu by pressing ADJ key.

- 13 -

BLOCK DIAGRAM

- 14 -

NOTES

- 15 -

EXPLODED VIEW

300 121

600

601 301

304 120

303 302 200

207 202 206

205 590 201 204 501 203 580 400 560 530 520 410

430

- 16 -

EXPLODED VIEW PARTS LIST
No.
120 121 200

Part No.
6401VD0032A 6401VD0033A 6348Q-E104B 6348Q-E107G

Description
SPEAKER ASSEMBLY,FULL RANGE(R) RZ-42PX30 FILM TYPE SPEAKER ASSEMBLY,FULL RANGE(L) RZ-42PX30 FILM TYPE PDP,42 852*480 PDP42V70652.AKLGG PDP,42 852*480 PDP42V70652.DDRSA C/SKD PCB ASSEMBLY,DISPLAY CTRL ASSY 42V7 FPGA PCB ASSEMBLY,DISPLAY YDRV ASSY 42V7 YDRV TOP B/D PCB ASSEMBLY,DISPLAY YDRV ASSY 42V7 YDRV BTM B/D PCB ASSEMBLY,DISPLAY XRLT ASSY 42V7 XL B/D PCB ASSEMBLY,DISPLAY XRRT ASSY 42V7 XR B/D PCB ASSEMBLY,DISPLAY YSUS ASSY 42V7 PCB ASSEMBLY,DISPLAY ZSUS ASSY 42V7 ZSUS ASSY CABINET ASSEMBLY,42PX3DBV-UC STEREO 3090V00676 FILM TYPE CABINET ASSEMBLY,42PX3DLV-UC STEREO COMMERCIAL SILVER CABINET ASSEMBLY,42PX3DLV-UC COMMERCIAL SILVER SKD SUPPORTER ASSY,AL FILTER TOP RZ-42PX30 SUPPORTER ASSY,AL FILTER TOP RZ-42PX30 C/SKD SUPPORTER ASSY,AL FILTER BOTTOM RZ-42PX30 SUPPORTER ASSY,AL FILTER BOTTOM RZ-42PX30 C/SKD SUPPORTER ASSY,AL FILTER RIGHT RZ-42PX30 SUPPORTER ASSY,AL FILTER RIGHT RZ-42PX30 C/SKD SUPPORTER ASSY,AL FILTER LEFT RZ-42PX30 SUPPORTER ASSY,AL FILTER LEFT RZ-42PX30 C/SKD BACK COVER ASSEMBLY,42PX3DBV-UC NON LGEUS D-BOX WITH LABEL BK BACK COVER ASSEMBLY,42PX3DLV-UC BACK COVER ASSEMBLY,C/SKD WITH PEM-NUT SUPPORTER ASSY,AL MODULE VER. RZ-42PX10 SUPPORTER ASSY,AL VERTICAL RZ-42PX10 SKD BOARD ASSEMBLY,STAND DU-42PX12X AF044A LGEUS BLACK W/O PACKING BOARD ASSEMBLY,DESK TOP STAND 42PX3DLV-UC BOARD ASSEMBLY,STAND RZ-42PX10 NF036B SKD PLATE ASSEMBLY,AV, VSC TUNER NON PLATE ASSEMBLY,AV VSC TUNER 42PX3DLV-UC PCB ASSEMBLY,MAIN AF044C 42PX3DBV-UC AUSLLAX D/B MANUAL PCB ASSEMBLY,SUB AF044C 42PX3DBV-UC AUSLLAX TUNNER B/D MANUAL PCB ASSEMBLY,SUB AF044C 42PX3DBV-UC AUSLLAX CONT MANUAL PCB ASSEMBLY,SUB AF044C 42PX3DBV/3DLV-UC CONTROL C/SKD POWER SUPPLY ASSEMBLY,350W YPSU-J006A LG INNOTEK PSU ASSY CHASSIS ASSEMBLY,SUB MF056A AC INET ASSY CHASSIS ASSEMBLY,SUB 42PX3DBV/3DLV-UC AC INET ASSY. SKD.RS PCB ASSEMBLY,SUB A/V AF044A DN-50PY10 SIDE A/V BRACKET ASSEMBLY,SIDE AV 42PX3DBV-UC AF044A BRACKET ASSEMBLY,DECO 42PX3DLV-UC SIDE AV BRACKET ASSEMBLY,AV RT-42PX10 RF043B SIDE AV SKD

201 202 203 204 205 206 207 300

6871QCH053A 6871QDH084A 6871QDH085A 6871QLH047A 6871QRH055A 6871QYH036A 6871QZH041A 3091V00816L 3091V00816Q 3091V00816S

301

4980V01203A 4980V01203B

302

4980V01204A 4980V01204B

303

4980V01205A 4980V01205B

304

4980V01206A 4980V01206B

400

3809V00610C 3809V00610B 3809V00610D

410

4980V01071A 4980V01071B

430

3501V00171F 3501V00171A 3501V00171B

501

3301900001A 3301V00023S

520 530 560

68719MM051A 68719SM081A 68719SM085A 68719SM085B

580 590

6709V00010A 3141VSN422A 31419SF091A

600 601

6871VSMF13A 4811V00118Q 4811V00118B 4811V00118D

- 17 -

REPLACEMENT PARTS LIST
For Capacitor & Resistors, the charactors at 2nd and 3rd digit in the P/No. means as follows; CC, CX, CK, CN : Ceramic CQ : Polyestor CE : Electrolytic RD : Carbon Film RS : Metal Oxide Film RN : Metal Film RF : Fusible

RUN DATE : 2005.8.29

LOCA. NO

PART NO

DESCRIPTION

LOCA. NO IC608 IC609

PART NO 0ICB533100A 0IMO330780B 0IPMGKE030A 0IPRPML001A 0IMCRSJ001A 0IMCRFA010A 0IPRPNS054A 0IPMGKE032A 0IPMGKE032A 0ICTMLG018A 0IPRPML001A 0IPRPAT002A 0IPMGSG018C 0IMMRAT006C

DESCRIPTION CS5331A-KSR 8SOIC TP ADC MC33078D 8/SOIC +-18V OP AMP KIA78R05F 5PIN 1A,5V MIC39100 3P SOT223 SC1565IST-1.8 3P SOT223 KA7809R 2P LM75CIMX-3 8P KIA78R09F 5PIN 1A,9V KIA78R09F 5PIN 1A,9V LGDP4410 176P MIC39100 3P SOT223 EP1C12F256C8N(PB FREE) 256P LD1086DT15TR 2P 1.5V 1.5A EPCS4S18N(PROGRAMED) 8PIN

IC
IC100 IC101 IC101 IC103 IC104 IC109 IC110 IC111 IC112 IC114 IC200 IC201 IC201 IC202 IC202 IC203 IC203 IC204 IC204 IC205 IC205 IC206 IC206 IC209 IC210 IC302 IC304 IC306 IC308 IC310 IC400 IC401 IC402 IC403 IC404 IC501 IC502 IC503 IC600 IC601 IC602 IC603 IC604 IC605 IC606 IC607 0IMMRNE002B 0ISO206900A 0IKE702900G 0IMCRSS016A 0IPH741400E 0IMMRSS041G 0IMMRSS041G 0IKE704200J 0IMMR00037A 0IMCRAL006A 0IMCRMN027D 0ILNR00015A 0IMCRPH026B 0ICTMLG013A 0IMCRTI028C 0IMCRCY002A 0IPMGKE030A 0IAL242561B 0IMCRSJ001A 0IMCRXL004A 0IPRPML001A 0IMCRSG010A 0IMCRFA010A 0IMCRRH001A 0IMCRPH026B 0IPRP00538A 0ICTMLG019A 0ILNRMN005A 0IPRPAD008B 0IMCRRH001A 0ICTMLG009C 0IMMRSS041G 0IMMRSS041G 0IMMRSS041G 0IMMRSS041G 0IMCRS5003B 0IMCRTH002A 0IMMRAL014B 0IMCRSO008A 0IMO140530D 0IPH740800M 0IMMRAL014B 0IMCRFA013A 0ICB841500B 0ITO741570C 0ITO741570C UPD64083GF3BA-A 100 CXA2069Q QFP64 BK I2C BUS AV S/W KIA7029AF SOT-89 TP 2.9V S3C44BOX01-EDRO LQFP-160 CPU 74HC14D 14SOP K4S641632H-UC75 54P K4S641632H-UC75 54P KIA7042AF SOT-89 TP 4.2V M306H3FCFP 116P AT24C16AN-10SU-2.7 8P EEPROM MSP4440K 80P MULTI SOUND NSP-2100A 64P DIGTAL AUDIO PA9516APW 16P LGDT1901A 24P TAS5122DCARG4 56P CY2309SXC-1HT 16P R/TP 3.3V KIA78R05F 5PIN 1A,5V AT24C256W-10SU-2.7V 8P SC1565IST-1.8 3P SOT223 XC95288XL-10TQG144C 144P MIC39100 3P SOT223 ST3232CDR SOP16 R/TP RS232 KA7809R 2P BA033FP-E2 3P-SOP,TO252-3 PA9516APW PHILIPS 16P FSA1156P6X-NL 6P LGDT3303 100P VPX3226E 44 VIDEO PIXEL DECODER AD9883AKST(Z)-110 80P BA033FP-E2 3P-SOP,TO252-3 LGDT1102C HD2.3 SBGA-432P K4S641632H-UC75 54P K4S641632H-UC75 54P K4S641632H-UC75 54P K4S641632H-UC75 54P SIL169CTG100 100P THC63LVD103 64P AT24C02N-10SI-2.7 8P CXA2151Q SONY 48P MC14053BDR2 16P 74F08D 14P AT24C02N-10SI-2.7 8P 74LCX244MTC 20P CS8415A-CZR 28P 96KHZ DIGITAL TC74LCX157FT 16P TC74LCX157FT 16P

IC701 IC702 IC703 IC704 IC705 IC706 IC707 IC800 IC801 IC900 IC901 IC902

TRANSISTOR
Q100 Q101 Q101 Q101 Q102 Q102 Q102 Q103 Q103 Q104 Q104 Q105 Q106 Q107 Q108 Q109 Q110 Q111 Q112 Q113 Q114 Q115 Q116 Q117 Q118 Q119 Q120 Q121 Q122 Q123 Q124 Q125 0TR150400BA 0TR387500AA 0TR102008AA 0TR150400BA 0TR387500AA 0TR387500AA 0TR150400BA 0TR387500AA 0TR387500AA 0TR150400BA 0TR150400BA 0TR150400BA 0TR150400BA 0TR150400BA 0TR387500AA 0TR150400BA 0TR150400BA 0TR387500AA 0TR150400BA 0TR387500AA 0TR150400BA 0TR150400BA 0TR387500AA 0TR387500AA 0TR387500AA 0TR150400BA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA CHIP 2SA1504S(ASY) BK KEC CHIP 2SC3875S(ALY) BK KEC KRA102S R/TP KEC SOT23 CHIP TR CHIP 2SA1504S(ASY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SA1504S(ASY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SA1504S(ASY) BK KEC CHIP 2SA1504S(ASY) BK KEC CHIP 2SA1504S(ASY) BK KEC CHIP 2SA1504S(ASY) BK KEC CHIP 2SA1504S(ASY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SA1504S(ASY) BK KEC CHIP 2SA1504S(ASY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SA1504S(ASY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SA1504S(ASY) BK KEC CHIP 2SA1504S(ASY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SA1504S(ASY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC

- 18 -

REPLACEMENT PARTS LIST
LOCA. NO Q128 Q129 Q130 Q131 Q132 Q133 Q200 Q200 Q201 Q204 Q303 Q304 Q305 Q305 Q306 Q306 Q307 Q307 Q308 Q309 Q501 Q502 Q503 Q600 Q601 Q602 Q605 Q606 Q607 Q613 Q614 Q615 Q616 Q701 PART NO 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR150400BA 0TR150400BA 0TR150400BA 0TR150400BA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR150400BA 0TR387500AA 0TR387500AA 0TR830009BA 0TR830009BA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR150400BA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR102009AG 0TR387500AA DESCRIPTION CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SA1504S(ASY) BK KEC CHIP 2SA1504S(ASY) BK KEC CHIP 2SA1504S(ASY) BK KEC CHIP 2SA1504S(ASY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SA1504S(ASY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC BSS83 BSS83 CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SA1504S(ASY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP 2SC3875S(ALY) BK KEC CHIP KRC102S SOT-23 NA NA CHIP 2SC3875S(ALY) BK KEC C103 C104 C105 C106 C117 C118 C1203 C121 C122 C1255 C1260 C1265 C127 C133 C138 C138 C139 C1400 C143 C144 C148 C148 C149 C150 C158 C1606 C1607 C161 C161 C1610 C165 C166 C167 C169 C170 C171 C172 C174 C202 C205 C206 C207 C208 C212 0CE4763F618 0CE1059K538 0CE1059K538 0CE106SF6DC 0CE106SF6DC 0CE105SK6DC 0CE226SF6DC 0CE106SF6DC 0CE106SF6DC 0CE476SF6DC 0CE108DJ618 0CE108DJ618 0CE107SF6DC 0CE107SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE226SF6DC 0CE476SF6DC 0CE105SK6DC 0CE105SK6DC 0CE226SF6DC 0CE226SF6DC 0CE476SF6DC 0CE105SK6DC 0CE226SF6DC 0CE226SF6DC 0CE107SF6DC 0CE105SK6DC 0CE226SF6DC 0CE106SF6DC 0CE106SF6DC 0CE106SF6DC 0CE106SF6DC 0CE106SF6DC 0CE106SF6DC 0CE106SF6DC 0CE106SF6DC 0CE226SF6DC 0CE476SF6DC 0CE226SF6DC 0CE477DJ618 0CE226SF6DC 0CE477SF6DC LOCA. NO LD101 ZD101 ZD102 ZD103 ZD110 PART NO 0DL200000CA 0DR050008AA 0DR050008AA 0DR050008AA 0DR050008AA DESCRIPTION LED,SAM5670(DL-2LRG) SD05.TC SOD323 5V 5A 15A SD05.TC SOD323 5V 5A 15A SD05.TC SOD323 5V 5A 15A SD05.TC SOD323 5V 5A 15A

CAPACITOR
47UF SRE,SE 16V 20% 1UF HI STABILITY 50V 10% 1UF HI STABILITY 50V 10% 10UF MVG 16V 20% 10UF MVG 16V 20% 1UF MVG 50V 20% 22UF MVG 16V 20% 10UF MVG 16V 20% 10UF MVG 16V 20% 47UF MVG 16V 20% 1000UF STD 35V M 1000UF STD 35V M 100UF MVG 16V 20% 100UF MVG 16V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 22UF MVG 16V 20% 47UF MVG 16V 20% 1UF MVG 50V 20% 1UF MVG 50V 20% 22UF MVG 16V 20% 22UF MVG 16V 20% 47UF MVG 16V 20% 1UF MVG 50V 20% 22UF MVG 16V 20% 22UF MVG 16V 20% 100UF MVG 16V 20% 1UF MVG 50V 20% 22UF MVG 16V 20% 10UF MVG 16V 20% 10UF MVG 16V 20% 10UF MVG 16V 20% 10UF MVG 16V 20% 10UF MVG 16V 20% 10UF MVG 16V 20% 10UF MVG 16V 20% 10UF MVG 16V 20% 22UF MVG 16V 20% 47UF MVG 16V 20% 22UF MVG 16V 20% 470UF STD 35V 20% 22UF MVG 16V 20% 470UF MVG 16V 20%

DIODE
D109 D200 D201 D202 D203 D204 D501 D701 D702 DL700 DL702 DL703 DL704 DL705 IC102 0DL233309AC 0DD226239AA 0DD226239AA 0DD226239AA 0DD226239AA 0DZRM00248A 0DD184009AA 0DD226239AA 0DD100009AM 0DL233309AC 0DL233309AC 0DL233309AC 0DL233309AC 0DL233309AC 0DD184009AA LED,SAM2333 KDS226 TP KEC KDS226 TP KEC KDS226 TP KEC KDS226 TP KEC ZENERS,RLZ8.2B-TE11 KDS184 85V 300MA KDS226 TP KEC EU1ZV(1) 200V 0.25A 15A LED,SAM2333 LED,SAM2333 LED,SAM2333 LED,SAM2333 LED,SAM2333 KDS184 85V 300MA

- 19 -

REPLACEMENT PARTS LIST
LOCA. NO C213 C214 C214 C215 C216 C217 C223 C224 C232 C233 C234 C235 C236 C236 C238 C239 C243 C244 C245 C251 C252 C253 C254 C260 C264 C265 C272 C274 C280 C295 C297 C298 C299 C305 C308 C309 C312 C315 C316 C317 C322 C323 C325 C325 C326 C328 C330 C330 C331 C332 C333 PART NO 0CE477SF6DC 0CE106SF6DC 0CE477SF6DC 0CE477DJ618 0CE477SF6DC 0CE477SF6DC 0CE477SF6DC 0CE107SF6DC 0CE476SF6DC 0CE476SF6DC 0CE107SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE106SF6DC 0CE226SF6DC 0CE226SF6DC 0CE477SF6DC 0CE477SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE107SF6DC 0CE107SF6DC 0CE476SF6DC 0CE226SF6DC 0CE335VK6DC 0CE335VK6DC 0CE107SF6DC 0CE106SF6DC 0CE106SF6DC 0CE476SF6DC 0CE476SF6DC 0CK105DF64A 0CE476SF6DC 0CK684DF56A 0CE476SF6DC 0CE226SF6DC 0CE106SF6DC 0CE226SF6DC 0CK105DF64A 0CE106SF6DC 0CK105DF64A 0CK105DF64A 0CE106SK6DC 0CE476SF6DC 0CE106SF6DC 0CE106SF6DC 0CE106SF6DC DESCRIPTION 470UF MVG 16V 20% 10UF MVG 16V 20% 470UF MVG 16V 20% 470UF STD 35V 20% 470UF MVG 16V 20% 470UF MVG 16V 20% 470UF MVG 16V 20% 100UF MVG 16V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 100UF MVG 16V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 10UF MVG 16V 20% 22UF MVG 16V 20% 22UF MVG 16V 20% 470UF MVG 16V 20% 470UF MVG 16V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 100UF MVG 16V 20% 100UF MVG 16V 20% 47UF MVG 16V 20% 22UF MVG 16V 20% 3.3UF MV 50V 20% 3.3UF MV 50V 20% 100UF MVG 16V 20% 10UF MVG 16V 20% 10UF MVG 16V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 1UF 2012 16V 20% 47UF MVG 16V 20% 0.68UF 2012 16V 10% 47UF MVG 16V 20% 22UF MVG 16V 20% 10UF MVG 16V 20% 22UF MVG 16V 20% 1UF 2012 16V 20% 10UF MVG 16V 20% 1UF 2012 16V 20% 1UF 2012 16V 20% 10UF MVG 50V 20% 47UF MVG 16V 20% 10UF MVG 16V 20% 10UF MVG 16V 20% 10UF MVG 16V 20% LOCA. NO C335 C343 C347 C348 C349 C350 C352 C353 C357 C367 C369 C370 C379 C380 C383 C391 C392 C394 C501 C512 C524 C601 C615 C622 C628 C629 C636 C639 C641 C654 C655 C656 C660 C663 C666 C667 C668 C673 C677 C716 C718 C721 C722 C723 C724 C726 C727 C728 C729 C730 C732 PART NO 0CE226SF6DC 0CK823DK56A 0CF4741L438 0CF4741L438 0CE226SF6DC 0CE106SF6DC 0CE226SF6DC 0CE106SF6DC 0CE476SF6DC 0CE105SK6DC 0CE105SK6DC 0CE105SK6DC 0CE226SF6DC 0CE106SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE106SH6DC 0CE476SF6DC 0CE106SF6DC 0CE106SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE105SK6DC 0CE476SF6DC 0CE476SF6DC 0CE106SF6DC 0CE106SF6DC 0CE106SF6DC 0CE476SF6DC 0CE106SF6DC 0CE476SF6DC 0CE107SF6DC 0CE226SF6DC 0CE226SF6DC 0CE107SF6DC 0CE107SF6DC 0CE476SF6DC 0CE476SF6DC 0CE477SF6DC 0CE477SF6DC 0CE477SF6DC 0CE477SF6DC 0CE477SF6DC 0CE476SF6DC 0CE477SF6DC 0CE477SF6DC 0CE477SF6DC 0CE476SF6DC DESCRIPTION 22UF MVG 16V 20% 82000PF 2012 50V 10% 0.47UF D 63V 5% 0.47UF D 63V 5% 22UF MVG 16V 20% 10UF MVG 16V 20% 22UF MVG 16V 20% 10UF MVG 16V 20% 47UF MVG 16V 20% 1UF MVG 50V 20% 1UF MVG 50V 20% 1UF MVG 50V 20% 22UF MVG 16V 20% 10UF MVG 16V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 10UF MVG 25V 20% 47UF MVG 16V 20% 10UF MVG 16V 20% 10UF MVG 16V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 1UF MVG 50V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 10UF MVG 16V 20% 10UF MVG 16V 20% 10UF MVG 16V 20% 47UF MVG 16V 20% 10UF MVG 16V 20% 47UF MVG 16V 20% 100UF MVG 16V 20% 22UF MVG 16V 20% 22UF MVG 16V 20% 100UF MVG 16V 20% 100UF MVG 16V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 470UF MVG 16V 20% 470UF MVG 16V 20% 470UF MVG 16V 20% 470UF MVG 16V 20% 470UF MVG 16V 20% 47UF MVG 16V 20% 470UF MVG 16V 20% 470UF MVG 16V 20% 470UF MVG 16V 20% 47UF MVG 16V 20%

- 20 -

REPLACEMENT PARTS LIST
LOCA. NO C733 C734 C735 C738 C739 C740 C743 C745 C748 C749 C751 C753 C815 C816 C822 C823 C826 C901 C906 C908 C910 C912 C915 PART NO 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE477SF6DC 0CE476SF6DC 0CE107SF6DC 0CE107SF6DC 0CE476SF6DC 0CE105SK6DC 0CE227VF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE476SF6DC 0CE106SF6DC 0CE107SF6DC 0CE477SF6DC 0CE106SF6DC 0CE476SF6DC 0CS335EFKDC 0CS335EFKDC DESCRIPTION 47UF MVG 16V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 470UF MVG 16V 20% 47UF MVG 16V 20% 100UF MVG 16V 20% 100UF MVG 16V 20% 47UF MVG 16V 20% 1UF MVG 50V 20% 220UF MV 16V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 47UF MVG 16V 20% 10UF MVG 16V 20% 100UF MVG 16V 20% 470UF MVG 16V 20% 10UF MVG 16V 20% 47UF MVG 16V 20% 3.3UF 3216 16V 20%,-20% 3.3UF 3216 16V 20%,-20% JK100 JK101 JK101 JK102 JK103 JK200 JK301 JK601 JK602 JK603 6612VJH020E 380-363G 380-068E 6612VJH020C 6613V00026A 6612VJH019B 380-068E 6612BBBHN4D 6612BBBHN4E 6612BBBHN4E C1 C10 C2 C3 C4 C5 C6 C7 C8 C9 JK102 JK501 JK600 387-J12L 6631V39023D 6631V12042L 6631V00020J 6631V10004Z 6631V00045D 6631V25083C 6631V25084C 6631V39013N 6631V39022D 6630VGA004B 6630GZ00724 6630VGA001C LOCA. NO P701 P702 P703 P706 PART NO 366-921L 6630VE00731 6630VE00731 366-921F DESCRIPTION CONNECTOR,WAFER 12PIN 2.54MM CONNECTOR,WAFER 10022HS-31A02 CONNECTOR,WAFER 10022HS-31A02 WAFER,IL-G-07 LGC 2.5mm S/T

CONNECTOR
CONNECTOR ASSEMBLY,12P 2.5MM 700MM CONNECTOR ASSEMBLY,10P 3.96MM 250MM CONNECTOR ASSEMBLY,13P 1.25MM 700MM CONNECTOR ASSEMBLY,3P 3.96MM 400MM CONNECTOR ASSEMBLY,31P 1.0MM 50MM CONNECTOR ASSEMBLY,10P 2.5MM 250MM CONNECTOR ASSEMBLY,7P 2.5MM 200MM CONNECTOR ASSEMBLY,12P 2.5MM 200MM CONNECTOR ASSEMBLY,8P 3.96MM 900MM CONNECTOR ASSEMBLY,4P 3.96MM 250MM CONNECTOR,D-SUB 9P 2.77MM CONNECTOR,D-SUB 24P 1.91MM CONNECTOR,D-SUB 15PIN 2.29MM

JACK
JACK,RCA PPJ122-40 6P JACK,DIN 6046B-01S JACK,PHONE UEJ-CV-018 JACK,RCA PPJ122C 6P JACK ASSEMBLY,UJB-03-28A JACK,RCA PPJ121B 4P JACK,PHONE UEJ-CV-018 JACK,DIN TOTX177 JACK,DIN TORX177 JACK,DIN TORX177

COIL
L201 L202 L203 L204 L234 L235 L236 L237 6140VB0004B 6140VB0004B 6140VB0004B 6140VB0004B 6140VB0032A 6140VB0032A 6140VB0032A 6140VB0032A COIL,CHOKE 26UH COIL,CHOKE 26UH COIL,CHOKE 26UH COIL,CHOKE 26UH COIL,CHOKE DBF-1015A 15.5UH COIL,CHOKE DBF-1015A 15.5UH COIL,CHOKE DBF-1015A 15.5UH COIL,CHOKE DBF-1015A 15.5UH

RESISTOR
AR102 AR103 AR300 AR301 AR302 AR303 AR304 AR305 AR306 AR307 AR308 AR309 AR501 AR502 AR503 AR504 AR505 AR506 0RRZVTA001C 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 4.7K OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5%

WAFER
C11 P100 P101 P101 P101 P102 P106 P200 P201 P202 P203 P204 P301 P301 P302 P501 366-036B 366-921L 6602T12002M 6630VE00731 366-922L 6602T12006M 6630V25002D 6630VE00731 366-921J 366-932E 366-932B 366-921C 6630VE00731 6630VE00731 366-932B 6602T12007D CONNECTOR,WAFER STAPLE CONNECTOR,WAFER 12PIN 2.54MM CONNECTOR,WAFER 13P 1.25MM CONNECTOR,WAFER 10022HS-31A02 WAFER,IL-G-12P LGC 2.5mm R/A CONNECTOR,WAFER 13P 1.25MM CONNECTOR,WAFER YFDW254 CONNECTOR,WAFER 10022HS-31A02 CONNECTOR,WAFER 10PIN 2.54MM CONNECTOR,WAFER 6PIN 2.54MM CONNECTOR,WAFER IL-G-03P CONNECTOR,WAFER IL-G-04 CONNECTOR,WAFER 10022HS-31A02 CONNECTOR,WAFER 10022HS-31A02 CONNECTOR,WAFER IL-G-03P CONNECTOR,WAFER GT121-31P-TD

- 21 -

REPLACEMENT PARTS LIST
LOCA. NO AR801 AR802 AR803 AR804 AR805 AR806 AR808 AR809 AR810 AR811 AR812 AR813 R631 R717 R742 VR301 VR302 VR303 PART NO 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RRZVTA001D 0RN1002F409 0RD0302A609 0RS0202K607 0RRZVTA001C 0RRZVTA001B 0RRZVTA001B DESCRIPTION 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 22 OHM 1 / 16 W 1608 5% 10K OHM 1/6 W 1.00% 30 OHM 1/2 W(7.0) 5.00% 20 OHM 2 W 5.00% 4.7K OHM 1 / 16 W 1608 5% MNR14-E0A-J-510 R OHM 51 OHM 5% MNR14-E0A-J-510 R OHM 51 OHM 5% LOCA. NO L201 L202 L203 L204 L205 L206 L207 L208 L210 L211 L212 L214 L215 L229 L230 L231 L232 L233 L302 L303 L304 L305 L306 L310 L311 L312 L400 L501 L503 L504 L600 L604 L605 L608 L609 L611 L612 L613 L702 L704 L707 L801 L802 L803 L804 L902 L903 L904 L905 L906 L907 PART NO 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0005A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A DESCRIPTION FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC BK2125 HS 750 FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT

SWITCH
SW101 SW101 SW102 SW103 SW104 SW105 SW106 SW107 SW108 140-315A 6600VR1004A 140-315A 140-315A 140-315A 140-315A 140-315A 140-315A 140-315A SWITCH,TACT SKHV17910B SWITCH,TACT SKHMPW 5P SWITCH,TACT SKHV17910B SWITCH,TACT SKHV17910B SWITCH,TACT SKHV17910B SWITCH,TACT SKHV17910B SWITCH,TACT SKHV17910B SWITCH,TACT SKHV17910B SWITCH,TACT SKHV17910B

FILTER & CRYSTAL
B1 B3 F1 F2 F3 F4 F5 IC102 IC103 IC104 IC105 IC303 IC304 IC311 IC312 IC313 L101 L103 L104 L200 6210VC0006A 6210VC0006A 6210VH0004A 6210VH0004B 6200JB8013A 6200JB8009T 6200JB8013A 6200C000010 6200C000010 6200C000009 6200C000009 6200C000012 6200C000012 6200VKR002A 6200VKR002A 6200VKR002A 6210VC0006A 6210VC0006A 6210VC0006A 6210VC0006A FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC ZCAT3035-1330-M-K FILTER,EMC ZCAT1518-0730-M-K FILTER,EMC BNF-1130 FILTER,EMC 06GEEG3Q-LG01 FILTER,EMC BNF-1130 FILTER,B.P. H354LAI-K5202 FILTER,B.P. H354LAI-K5202 FILTER,B.P. H354LAI-K5225 FILTER,B.P. H354LAI-K5225 FILTER,B.P. TH355LSK-K5218 FILTER,B.P. TH355LSK-K5218 FILTER,B.P. LPF 2EA TA355LSK-K5216 38MHZ FILTER,B.P. LPF 2EA TA355LSK-K5216 38MHZ FILTER,B.P. LPF 2EA TA355LSK-K5216 38MHZ FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT

- 22 -

REPLACEMENT PARTS LIST
LOCA. NO L908 L909 R102 R103 R106 R107 R108 X100 X101 X102 X103 X200 X301 X600 PART NO 6210VC0006A 6210VC0006A 6200JB8010L 6200JB8010L 6200JB8010L 6200JB8010L 6200JB8010L 6212AB2015B 6212AB2015E 6212AA2998A 156-A01T 156-A02M 6202VDB007B 6212AB2015A DESCRIPTION FILTER,EMC FBMH3216 HM501NT FILTER,EMC FBMH3216 HM501NT FILTER,EMC MLB-201209-1000L-N2 FILTER,EMC MLB-201209-1000L-N2 FILTER,EMC MLB-201209-1000L-N2 FILTER,EMC MLB-201209-1000L-N2 FILTER,EMC MLB-201209-1000L-N2 RESONATOR,CRYSTAL HC-49/SM5H 20MHZ RESONATOR,CRYSTAL HC-49/SM 10.0MHZ RESONATOR,CRYSTAL HLX-308 32.768KHZ RESONATOR,CRYSTAL HC49U 10.000MHZ RESONATOR,CRYSTAL HC49U 18.432MHZ RESONATOR,CRYSTAL HC49U 20.250MHZ RESONATOR,CRYSTAL HC-49/SM4H 4MHZ LOCA. NO PART NO DESCRIPTION

MISCELLANEOUS
C12 C13 IC107 IC108 IC109 PA101 TU301 X201 X302 X900 6850J00005C 6850VA0004K 692791020AB 692791021AB 692791060AA 6712000002B 6700AN0002C 6204B60001B 6204B47985K 6204B60001B CABLE,DVI LVDS UL20276 AWG30 600MM CABLE,COAXIAL(NTSC) UL1365#26 100MM SOFT WARE,3.00.0V A511 PDP AF044C SOFT WARE,3.00.0V 91FF PDP AF044C SOFT WARE,3.00V 0X0976 PDP AF044C REMOTE CONTROLLER RECEIVER,38KHZ TUNER,TDVS-H702P OSCILLATOR,27MHZ +/- 100 PPM 3.3V OSCILLATOR,BMS-873R 25MHZ OSCILLATOR,27MHZ +/- 100 PPM 3.3V

ACCESSORIES
A1 A2 A3 A4 A5 A7 3828VA0479J 6710V00151K 6410VUH005E 6850TD9007E 6851V00019A 4972V00178A MANUAL,USER AF044C REMOTE CONTROLLER POWER CORD,LP-31+LS-13 2800MM CABLE,D-SUB UL20276-9C(5.8MM) DT L1800 CABLE,COAXIAL RF 4AC208A0 3M FIXER,WALL NON ASSY

- 23 -

P/NO : 3828VD0177S

Sep., 2005 Printed in Korea

CANADA: LG Electronics Canada, Inc. 550 Matheson Boulevard East Mississauga, Ontario L4Z 4G3 USA : LG Electronics Alabama, Inc. P.O.Box 240007, 201 James Record Road Bldg 3 Huntsville, AL 35824

DIGITAL(TOP)

TUNER(TOP)

TUNER(BOTTOM)

DIGITAL(BOTTOM)

SIDE A/V(TOP)

CONTROL(TOP)

CONTROL(BOTTOM)

SIDE A/V(BOTTOM)