Text preview for : Jbl-GTO5355 caramp.pdf part of JBL GTO5355 car amplifier
Back to : Jbl-GTO5355 caramp.rar | Home
GTO5355
5 CHANNEL POWER AMPLIFIER
SERVICE MANUAL
JBL Consumer Products 250 Crossways Park Dr. Woodbury, New York 11797
Released 2007 Discontinued XXXX
Rev1 1/2008
GTO5355
- CONTENTS SPECIFICATIONS ...............................................1 PACKING............................................................2 CONTROL/INSTALLATION DRAWINGS..................3 CONTROL/INSTALLATION INSTRUCTIONS.............4 BASIC TROUBLESHOOTING...................................5 EXPLODED VIEW.................................................6 EXPLODED VIEW PARTS LIST...............................7 AMPLIFIER BLOCK DIAGRAM...............................8 ELECTRICAL PARTS LIST ....................................9 P.C.B. DRAWINGS..............................................15 IC/TRANSISTOR PINOUTS...................................18 SCHEMATICS....................................................19
GTO 5355 Specifications
55W RMS x 4 channels + 225W RMS x 1 channel @ 4 ohms; 1% THD+N 75W RMS x 4 channels + 360W RMS x 1 channel @ 2 ohms; 1% THD+N 140W RMS x 2 channel (bridged) @ 4 ohms; 1% THD + N Signal-to-noise ratio: 85dBA (reference 1W into 4 ohms) 104dBA (reference rated power into 4 ohms) Dynamic power: 660W @ 2 ohms Frequency response: 10Hz 83kHz and 20Hz 250Hz (subwoofer) THD+N 1KHz LPF=22KHz 0.03% (rated power @ 4 ohms) Channel Separation 45db (full rated power) Input Impedance >20K ohms Maximum input signal: 6.0V Maximum sensitivity: 100mV Hi-Pass, Low Pass X-over Limits 32Hz 320Hz + 20Hz 200Hz ±20% Bass Boost @ 50Hz 0-12dB DC Offset <30mV Output regulation: .03dB @ 4 ohms Idle Current @ 4 ohms 1.9A Max Current Draw <80A @ 2 ohms both channels driven Remote Operating Voltages ON 5V OFF 4V Turn-on delay time 2-3 sec Circuit Protection Temperature (85±5C), Short circuit Operating voltage range (8-16V) Dimensions: 18 9/16 x 10 3/8 x 2 1/8" (470 x 263 x 53mm) Fuses: (2) x 40A
JBL continually strives to update and improve existing products, as well as create new ones. The specifications and details in this and related JBL publications are therefore subject to change without notice.
1
Output Power: (14.4V supply)
GTO5355
Item 1 2 3 4 5 6 7
Part Number CH5523221134 BZL311105120 GTO5355
Description Outer Carton Packing Foam Amplifier Plastic bag Plastic bag Owner's manual Accessory kit consisting of: Mounting Screws 30A Fuse Remote Level control Phone cable 4PIN Black L=6M, 6P4C
2
Qty 1 2 1 1 1 1 4 1 1 1
Visit www.jbl.com LS1AA0404501 1601-303G-00
REMOTE GTO AMP
2100-0009-04
GTO5355
4x 2x
1x 1x 1x
2x
10-3/8" 263mm
18-9/16" 470mm
0
1
±ÈÀý 1.000
2
2-1/8" 53mm
3 4 5 6 7 8 9 AB C
L
D E FG H I AB J A
1" 25mm
B
C
D
E
F
1-5/8" 40mm
K A
B
C
D
E
3
GTO5355
GTO5355 CAR AUDIO POWER AMPLIFIER OWNER'S MANUAL
Installation Warnings and Tips · Disconnect the negative () lead from your vehicle's battery. · At the installation sites, locate and make a note of all fuel lines, hydraulic brake lines, vacuum lines and electrical wiring. Use extreme caution when cutting or drilling in and around these areas. · Choose a safe mounting location away from moisture. · Make sure there is sufficient air circulation at the mounting location for the amplifier to cool itself. · Mount the amplifier, using the supplied hardware. Specifications · 55W RMS x 4 channels, plus 225W RMS x 1 channel, @ 4 ohms and 1% THD + N* · 75W RMS x 4 channels, plus 360W RMS x 1 channel, @ 2 ohms and 1% THD + N* · THD + N: 0.03% (rated power @ 4 ohms) · Signal-to-noise ratio: 85dBA (reference 1W into 4 ohms)* · Signal-to-noise ratio: 104dBA (reference rated power into 4 ohms) · Frequency response: 10Hz 83kHz and 20Hz 250Hz · Max power: 660 watts * CEA-2006A-compliant 0 Speaker Output Connectors · Connect the speakers to these terminals, observing proper polarity. · Five-channel operation: Connect the front left speaker to the Front L+ and L terminals and the front right speaker to the Front R+ and R terminals. Repeat for the rear speakers, using the Rear L+ and L terminals, and the Rear R+ and R terminals. Connect the subwoofer to the Sub+ and Sub terminals. · Four-channel operation: Connect the stereo speakers to the Front terminals, as above. Connect the single speaker into which the amplifier's rear channels will be bridged to the Rear R+ and Rear L terminals. Connect the subwoofer to the Sub+ and Sub terminals · Three-channel (bridged) operation: Connect one speaker to the Front R+ and Front L terminals. Connect the other speaker to the Rear R+ and Rear L terminals. Connect the subwoofer to the Sub+ and Sub terminals. · Minimum speaker impedance for stereo operation is 2 ohms. Minimum speaker impedance for bridged operation is 4 ohms. Minimum subwoofer impedance is 2 ohms. 1 Fuses · Replace only with same type and rating. 2 Power Input Connectors · +12V: Connect to the positive terminal of the vehicle's battery. 4 AWG wire is recommended. Install an appropriate fuse holder and fuse (80A minimum) within 18 inches of the battery. Make sure the wire is not damaged or pinched during installation. Install protective grommets when routing wires through the firewall or other sheet metal. · GND: Connect to the vehicle's chassis. Refer to the picture below. Factory Bolt Ring Connector Ground Wire · REM: Connect to the "Remote Out" lead from the source unit or to a source of switched 12V+ (ACC). 3 Front Input Connectors (RCA) · Connect to the front RCA outputs from the source unit or signal processor. 4 Front Input-Level Control · Used to match the front input level of the amplifier to the output level of the source unit. · See J for the adjustment procedure. 5 Front Crossover-Frequency Control · 12dB/octave crossover, variable from 32Hz to 320Hz. · See K for the adjustment procedure. 6 Front Crossover-Filter Selector · LPF: Select for subwoofer(s). · FLAT: Select for full-range speakers when no subwoofer will be used in the system. · HPF: Select for midrange speakers or full-range speakers when a subwoofer is used in the system. 7 Power On LED · Illuminated when the amplifier is on. 8 Subwoofer Input Connector (RCA) · Connect to the subwoofer RCA outputs from the source unit, or signal processor. 9 Rear Crossover-Filter Selector · LPF: Select for subwoofer(s). · FLAT: Select for full-range speakers when no subwoofer will be used in the system. · HPF: Select for midrange speakers or full-range speakers when a subwoofer is used in the system. A Rear Crossover-Frequency Control · 12dB/octave crossover, variable from 32Hz to 320Hz. · See the adjustment procedure in K. B Rear Input-Level Control · Used to match the rear input of the amplifier to the output of the source unit. · See J for adjustment procedures. C Rear Input Connectors (RCA) · Connect to rear RCA outputs from the source unit, or signal processor. D EXT/INT Switch · If the source unit has a subwoofer output and you have connected it to the SUB input, set this switch to the EXT position. Otherwise, set it in the INT position. E Subwoofer Remote Level Control Connector · Connect the Remote Level Control (RLC) here, using the supplied RJ-11 cable. F Subwoofer Level Control · Used to match the SUB input of the amplifier to the output of the source unit. · See J for adjustment procedures. G Protect LED · Illuminated under any of the following fault conditions: battery over/under voltage, short circuit in speaker wires, amplifier is too hot, amplifier's output circuit has failed (DC voltage present in the amplifier's output). H Subwoofer Low-Pass Filter Frequency Control · 12dB/octave low-pass filter, variable from 20Hz to 200Hz. · See the adjustment procedure in K. I DBO (Dynamic Bass Optimization) Variable Subsonic High-Pass Filter With Variable Boost (Q) · For woofers in tuned (vented) enclosures, set the Frequency control to a value 10Hz below the enclosure's resonance (tuned) frequency. · For woofers in sealed boxes, set the control to any value you prefer between 30Hz and 50Hz. · Set the Boost control according to your preference, being careful not to apply enough boost to damage your woofer(s). A DBO High-Pass Filter Frequency control, variable between 10Hz and 100Hz. See above for appropriate settings. B DBO Boost control provides up to 12dB of boost, slightly above the highpass filter's frequency. See above for appropriate settings. J Setting Input Level A Turn all Input-Level controls counterclockwise to 6V (minimum). B With a dynamic music track playing, turn the head unit's volume control to the 3/4 position. C Turn Front Input-Level control clockwise until the music is so loud that it no longer sounds clear (distortion is present in the output). D Turn Front-Input-Level control counterclockwise gradually, just until the music sounds clear, once again. E Front-Level input is now adjusted correctly. F Adjust the Rear and Sub Input-Level controls so that the level of the rear speakers and the level of the subwoofer are proportionate to the level of the front speakers, according to your preference. K Setting the Crossover A Crossover setting for 5" or larger full-range speakers when no subwoofer is included in the system. B Crossover setting for full-range speakers when a subwoofer is included in the system. C Crossover setting for subwoofers. D Crossover setting for systems that include separate mid-bass speakers driven by the rear channels, with the BP switch set to "BP." Note: Acceptable frequency ranges are indicated in gray. L Remote Level Control The Remote Level Control, if installed, will allow you to adjust the level of bass while seated in the listening position.
Note: Remove any paint below ring connector.
Star Washer
This product is designed for mobile applications and is not intended for connection to the mains. A valid serial number is required for warranty coverage. Features, specifications and appearance are subject to change without notice.
4
GTO5355
Amplifier Troubleshooting Guide
1. Status LED on Amplifier not Lit - Head Unit (Source) Turned ON Verify: A. Remote turn-on wire from source to amplifier has proper voltage B. Power (B+) connections at amplifier, terminal blocks, and battery are secure C. Ground (GND) connections at amplifier and vehicle chassis are secure D. Battery B+ fuse (if used) is OK E. Amplifier fuse is OK F. B+ at battery and B+ at amplifier has proper voltage
2. Status LED's Lit, No Output from Speakers in Normal Operating Condition Verify: A. RCA cables from amplifier to source are securely connected B. Volume adjustment on amplifier is correctly adjusted C. Source is ON and playing
3. Engine Noise From Speaker(s) Turn source OFF, Disconnect RCA cables at amplifier. If noise stops, check equipment & cables leading to amplifier. Verify: A. RCA cables are of good quality with no breakage to internal shields B. RCA cables from source to amplifier are not run alongside any power cables
4. Amplifier Output Distorted Music Verify: A. Source output music to amplifier is not distorted B. Source output sensitivity is correctly adjusted
5. Amplifier Shuts Down, Green LED's are Lit - Amplifier is in Thermal Protection Mode Verify: A. Amplifier is mounted with adequate air circulation around heatsinks or vents B. Amplifier is not mounted under carpet or sealed enclosure C. Speakers meet correct impedance for application (mono or stereo hookup)
6. Amplifier Does Not Turn ON, and Red LED is Lit Amplifier (and not Connected to a Shorted Speaker) Verify: A. Speaker crossover (if used) is not defective
5
GTO5355
LARGER VERSION OF CHART NEXT PAGE
RCA CAP (Red) RCA CAP (Wht) Front Plate
Standoff
Trans. Clamp
Trans. Clamp
Trans. Clamp
Standoff
6
GTO5355
7
GTO5355
1 2 3 4 5 6
INPUT L
1
1 2 3 4 2 2 3
A A
OP
3 4
10 OP
32
320
100K
10
50
100K AMP 4 ohm/2 ohm speaker
D
MODE:FRONT/REAR/SUB
MODE:RIGHT/STEREO/LEFT
1
A MODE HP/FLAT/LP VARIABLE LPF/HPF 32Hz-320Hz/12dB BASS BOOST VARIABLE 0dB-6dB/50Hz MAIN AMP FRONT L BTL-4ohm speaker MODE HP/FLAT/LP
3
D
4 3 2 1
BASS BOOST VARIABLE 0dB-6dB/50Hz MAIN AMP FRONT R
IMS INPUT MODE:FRONT/REAR/SUB
1
VARIABLE LPF/HPF 32Hz-320Hz/12dB
2
MODE:RIGHT/STEREO/LEFT
1
A
A
OP
3 4
A
2
3 4
2 1
10 OP
32
320
100K
10
50
100K AMP 4 ohm/2 ohm speaker
INPUT R
C
AUX OUT L
C
OP
+15V
+VCC
power supply
AUX OUT R
Battery
OP
-15V
-VCC
INPUT RL
1
1 2 3 4 2 2 3
A A
B
OP
3 4
10 OP
32
320
100K
10
50
100K AMP 4 ohm/2 ohm speaker
B
MODE:FRONT/REAR/SUB
MODE:RIGHT/STEREO/LEFT
1
A MODE HP/FLAT/LP VARIABLE LPF/HPF 32Hz-320Hz/12dB BASS BOOST VARIABLE 0dB-6dB/50Hz MAIN AMP REAR RL BTL-4ohm speaker MODE HP/FLAT/LP
3
4 3 2 1
BASS BOOST VARIABLE 0dB-6dB/50Hz MAIN AMP REAR RR
IMS INPUT MODE:FRONT/REAR/SUB
1
VARIABLE LPF/HPF 32Hz-320Hz/12dB
2
MODE:RIGHT/STEREO/LEFT
1
A
A
OP
A
INPUT RR
3 4
A
2
3 4
2 1
10 OP
32
320
100K
10
50
100K AMP 4 ohm/2 ohm speaker
A
8
1 2 3 4 5 6
GTO5355
GTO5355 Electrical Parts List
Part Number MAIN PCB Resistors 0702-24R7-02 0702-1220-02 Resistor Resistor 1/4W 4.7 ±5% 10MM 1/8W 22 ±5% 7.5MM 6 R152E R153E R154E R155E R166E R167E R135A R135B R135C R135D R135E R136A R136B R136C R136D R136E R137A R137B 20 R137C R137D R137E R138A R138B R138C R138D R138E R152A R152B R152C R152D R154A R154B 8 R154C R154D R150A R150B R150C R150D R150E R151A 10 R151B R151C R151D R151E R44 R58A R52 R52A R53A R53B R54A R56 11 R57 R56A R57A 2 R169E R170E 2 R161E R162E 4 R161A R161B R161C R161D 2 R146E R149E R133A R133B R133C R133D R133E R139A R139B R139C R139D R139E R140A R140B 28 R140C R140D R140E R143A R143B R143C R143D R143E R146A R146B R146C R146D R149A R149B R149C R149D 1 R15A 1 R148E R19 R20 R145 R145A R145C R145D R145E 8 R145B R141A R141B R141C R141D R141E R142A 10 R142B R142C R14D R142E 4 R148A R148C R148B R148D 1 R47 3 R48 R49 R50 1 R21 5 R160A R160B R160C R160D R160E R18A R37 R134A R134B R134C R134D 9 R134E R21B R101 R30A R163A R163B R163C R163D R163E 11 R164A R164B R164C R164D R164E 1 R17A R23A R24A R25A R26A R36A R23B R24B 10 R25B R26B R36B R156A R156B R156C R156D R156E R157E 7 R158E 2 R63 R64 6 R60 R60A R61 R61A R62 R62A 5 R165A R165B R165C R165D R165E 2 R64A R63A Description Qty Reference Designator
0702-1510-02 0702-1680-02 0702-1101-02 0702-2101-02 0702-2271-02 0702-1471-02 0702-1511-02
Resistor Resistor Resistor Resistor Resistor Resistor Resistor
1/8W 51 ±5% 7.5MM 1/8W 68 ±5% 7.5MM 1/8W 100 ±5% 7.5MM 1/4W 100 ±5% 10MM 1/4W 270 ±5% 10MM 1/8W 470 ±5% 7.5MM 1/8W 510 ±5% 7.5MM
0702-1102-02
Resistor
1/8W 1K ±5% 7.5MM
0702-1222-02 0702-1302-02 0702-1332-02 0702-1392-02 0702-1622-02 0702-1472-02 0702-1512-02 0702-1682-02 0702-1822-02 0702-1103-02 0702-1153-02 0702-1473-02 0702-1563-02 07051515X102 0704-7101-02 0702-3220-02 0702-34R7-02 0712-6472-02 Capacitors 06D211076001 06D211063000 06D211074100 06D211056001 06D212285101 06D212264103
Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor
1/8W 2.2K ±5% 7.5MM 1/8W 3K ±5% 7.5MM 1/8W 3.3K ±5% 7.5MM 1/8W 3.9K ±5% 7.5MM 1/8W 6.2K ±5% 7.5MM 1/8W 4.7K ±5% 7.5MM 1/8W 5.1K ±5% 7.5MM 1/8W 6.8K ±5% 7.5MM 1/8W 8.2K ±5% 7.5MM 1/8W 10K ±5% 7.5MM 1/8W 15K ±5% 7.5MM 1/8W 47K ±5% 7.5MM 1/8W 56K ±5% 7.5MM 5W 0.15*2 ±5% () 26*5*18MM 3W 100 ±5% 1/2W 22 ±5% 12.5MM 1/2W 4.7 ±5% 12.5MM 2W 4.7K ±5% 10MM
Cap electro Cap electro Cap electro Cap electro Cap electro Cap electro
100UF/50V ±20% 8*12 105 5mm 10UF/16V ±20% 5*7 105 5MM 100uF/25V ±20% 6.3*11 105 black5MM 1UF/50V ±20% 5*11 105 5.0mm 2200UF/35V 16*26MM ±20% 105 7.5MM 220uF/25V ±20% 8*12 105 black 5MM
5 C114A C114B C114C C114D C114E 1 C31 1 C32 5 C113A C113B C113C C113D C113E 4 C5 C5A C6 C6A 4 C39 C42 C29 C29B
9
GTO5355
Part Number MAIN PCB 06D212264102 06D213389001 06D213385001 06D231017000 06D231027000 06D231037000 06D231047000 06D232207000 06D236817000 06D321047200 Semiconductors 04WY-15BV104 04WY-10BV104 04PT-4148-04 04ZL-6A10-00 03P1-A940-02 03P1-B647-01 03N1-1815-01 03N1-2073-02 03N1-667A-01 03P1-5401-01 03N1-5551-01 03N1-SA06-01 03N1-SA13-01 03P1-B817-13 03P1-SA56-01 03N1-1047-13 03N1-35CW-26 03P1-36CW-26 03T1-Z48N-02 01TI-5532-01 2601-P817-00 2202-1620-05 2202-1602-05 Miscellaneous 1004-3000-10 1005-5R01-10 3000-5355-01 1601-403E-00 1401-0008-00 1501-1209-00 1501-0209-00 1505-1000-01 inductor 30UH 12 5 11.5mm toroidal inductor 5uH 10*24MM 2.0 Transformer fuse fuse holder socket socket terminal 40 4:15 L1=L2=0.8*12 4TS S1=S2=1.0*515TS 40A 2PIN BXS2-09 Pitch 2.54MM 12PIN Pitch 2.54MM 2PIN BTS10-26 2 L5 L5A 2 L1 L2 1 T2 2 1 1 4 1 F1 for F1 CON9 CON5 CON6 CON7 CON8 CON2 diode schotty diode schotty diode diode Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor 15V 0.5W 20MA 52MM DO-35 0.5W ASC SPA 20MA 10V 52MM DO-35 0.5W 1N4148 GSS 200MA 75V DO-35 6A10 1000V 2SA940 PNP TO-220 2SB647 1A 120V 0.9W PNP TO-92 2SC1815GR 150MA 60V 400MW NPN TO-92 2SC2073 NPN TO-220 2SD667AC 1A 120V 0.9W NPN TO-92 2N5401 PNP TO-92 2N5551 NPN TO-92 MPSA06 NPN TO-92 MPSA13 0.5A 30V NPN TO-92 KTB817 PNP TO-3P MPSA56 PNP TO-92 KTD1047 NPN TO-3P TIP35CW NPN T0-247 TIP36CW PNP T0-247 2 ZD4 ZD5 1 ZD3 D2A D3A D100A D100B D100C D100D D100E 18 D101A D101B D101C D101D D101E D102A D102B D102C D102D D102E D2B 1 D1A 3 Q20 Q103E Q104E Q102A Q102B Q102C Q102D Q102E Q103A 9 Q103B Q103C Q103D Q2A Q4 Q5 Q111A Q111B Q111C Q111D 10 Q111E Q4B Q5B 3 Q19 Q106E Q107E Q106A Q106B Q106C Q106D Q108A Q108B 9 Q108C Q108D Q108E 2 Q112E Q113E 2 Q100E Q101E Q100A Q100B Q100C Q100D Q101A Q101B 8 Q101C Q101D 5 Q105A Q105B Q105C Q105D Q105E 3 Q114E Q115E Q117E Q112A Q112B Q112C Q112D Q113A Q113B 8 Q113C Q113D 3 Q109E Q110E Q116E 4 Q109A Q109B Q109C Q109D 4 Q114A Q114B Q114C Q114D Q12 Q15 Q16 Q22 Q23 Q24 Q26 Q27 Q28 10 Q11 1 U3 1 PC2 2 D9 D9A 2 D8 D8A Cap electro Cap electro Cap electro porcelin Cap porcelin Cap porcelin Cap porcelin Cap porcelin Cap porcelin Cap Capacitor 22uF/25V ±20% 5*11 105 black 5MM 3300UF/63V ±20% 30*25 105 3300UF/35V ±20% 22*25 105 100pF/100V ±20% 5MM 1000pF/100V ±20% 5MM 0.01uF/100V ±20% 5MM 0.1uF/100V ±20% 5MM 22pF/100V ±20% 5MM 680pF/100V ±20% 5MM 104/100V ±5% green 5MM 5 C108A C108B C108C C108D C108E 2 C37A C38A 2 C37 C38 C110A C110B C110C C110D C110E C111A 10 C111B C111C C111D C111E 2 C35 C35A 4 C33 C33A C34 C34A C7 C8 C9 C15 C15A C23 C23A C28 C109E 16 C112A C112B C112C C112D C112E C21A C25A 5 C115A C115B C115C C115D C115E 4 C109A C109B C109C C109D 5 C116A C116B C116C C116D C116E Description Qty Reference Designator
MOS Transistor IRFZ48N TO-220 Dual Op-amp NE5532 TI photocoupler PC817 4 Rectifier MUR1620CTA KAD 16A/200V TO-220 Rectifier UF1602CT AKA 16/200V TO-220
10
GTO5355
Part Number MAIN PCB 1501-0300-02 1380-0211-00 PL-L0002-000 3000-LGTO-01 2100-0074-02 2100-0073-02 PL-A0056-000 PL-A0054-000 PL-A0053-000 terminal temp switch terminal Transformer cable BTS3-24 95 KSD-301 GND-3 37 6:12 L1=L2=0.8*10*6TS L3=L4=0.8*5*12TS 1 CON3 1 1 1 T1 1 1 2 4 2 Description Qty Reference Designator
2PIN P=2.54MM 1007#26AWG L=100MM (A2501TOP-2) 2PIN P=2.54MM 1007#26AWG L=85MM cable (A2501TOP-2) 14.0x7.0x64.0 Alum. Bar with Insulated paper 14.0x7.0x64.0 Alum. Bar with Insulated paper 14.0x7.0x88.0 Alum. Bar with Insulated paper
PREAMP/INPUT PCB Resistors 0702-1361-02 0702-1102-02 0702-1202-02 0702-1472-02 0702-1562-02 0702-1682-02 Resistor Resistor Resistor Resistor Resistor Resistor 1/8W 360 ±5% 7.5MM 1/8W 1K ±5% 7.5MM 1/8W 2K ±5% 7.5MM 1/8W 4.7K ±5% 7.5MM 1/8W 5.6K ±5% 7.5MM 1/8W 6.8K ±5% 7.5MM 4 R110D R110C R110B R110A R407 R307 R117C R117A R116C R116A 14 R115C R115A R114C R114B R207 R114D R114A R107 1 R132 6 R107D R107C R107A R107B R71 R72 4 R109D R109C R109B R109A 4 R106D R106B R106C R106A R406 R405 R403 R402 R306 R305 R303 R302 R206 R205 R203 R202 R133 R108D R108C 33 R108B R108A R106 R105D R105C R105B R105A R105 R104C R104B R103 R102D R102C R102B R102A R102 R104D R104A R101B R401 R301 R201 R111C R111B R101 16 R103A R103B R101C R101D R103C R103D R101A R111D R111A 2 VR102R VR102F 2 VR101R VR101F
0702-1103-02
Resistor
1/8W 10K ±5% 7.5MM
0702-1223-02 1204-5031-18 1204-2030-01 Capacitors 06D212274001 06D212264102 06D431046000 06D232206000 06D234707000 06D231006000 06D328236200 Semiconductors 03N1-1815-01 01JR-4558-01 2004-0014-00 2000-0017-00
Resistor potentiometer
1/8W 22K ±5% 7.5MM
A50K R0971G2B W=5 KQ L=15MM T=7.5MM M=1MM FREQ potentiometer B20K KQ L=15 ±10% ±3dB LEVEL
Capacitor Cap electro porcelin Cap porcelin Cap porcelin Cap porcelin Cap Capacitor
220UF/25V ±20% 8*16 105 5mm 22uF/25V ±20% 5*11 105 black 5MM 0.1uF/50V 80%/-20% 5MM 22pF/50V ±20% 5MM 47pF/100V ±20% 5MM 10pF/50V ±20% 5MM 823/50V ±5% 5MM
4 C401 C301 C101 C201 C403 C402 C303 C302 C203 C202 C103 C102 12 C101C C101A C101D C101B 4 C27A C26A C24 C21 8 C406 C405 C306 C305 C206 C205 C106 C105 4 C103D C103C C103B C103A C404 C304 C204 C104 C102D C102C C102A 8 C102B C105D C105C C105B C105A C104D C104C 8 C104B C104A
Transistor Dual Op-amp LED LED
2SC1815GR 150MA 60V 400MW NPN TO-92 NJM4558 3.0MM blue with blue light red with red light 3MM 2P
1 Q1E 11 U301 U201 U102D U102C U102B U102A U101D U101C U101B U101A U101 1 LED2 1 LED1
11
GTO5355
Part Number PREAMP/INPUT PCB Miscellaneous 1404-0027-02 2100-0009-12 1501-0205-00 1501-0609-03 1333-0204-00 1380-0004-00 2100-0073-02 2100-0075-02 RCA wire socket pin socket slide switch temp switch cable cable AV2-8.4-38 12PIN UL1007 AWG26 L=45mm 2.54 2.54 Pitch 2.5MM 2PIN 6PIN highness 8MM thickness2.55MM PITCH:2.54MM 3.2MM SSH-23D04-2P3T 9MM LPF/FLAT/HPF 65 KSD-301 2PIN P=2.54MM 1007#26AWG L=85MM (A2501TOP-2) 2PIN P=2.54MM 1007#26AWG L=150MM (A2501TOP-2)5MM 2 RCA1 RCA2 1 CON10 1 CON2A 1 CON4 2 SW103R SW103F 1 2 CN12 CN11 1 Description Qty Reference Designator
PHONE/SUB INPUT PCB Resistors 0702-1181-02 0702-1391-02 0702-1561-02 0702-1102-02 0702-1112-02 0702-1182-02 0702-1472-02 0702-1562-02 0702-1103-02 0702-1153-02 0702-1223-02 0702-1393-02 0702-1433-02 0702-1473-02 0702-1563-02 0702-1104-02 0702-1205-02 1204-2041-03 1204-5031-34 1204-2030-01 1204-5011-01 Capacitors 06D231006000 06D431046000 06D232206000 06D341849400 06D344749400 06D328236200 06D326837200 06D212264102 06D212274001 porcelin Cap porcelin Cap porcelin Cap MET Capacitor MET Capacitor Capacitor Capacitor Cap electro Capacitor 10pF/50V ±20% 5MM 0.1uF/50V 80%/-20% 5MM 22pF/50V ±20% 5MM 184/63V ±5% 5MM 474/63V ±5% 5MM 823/50V ±5% 5MM 683/100V ±5% green 5MM 22uF/25V ±20% 5*11 105 black 5MM 220UF/25V ±20% 8*16 105 5mm 3 2 4 1 1 1 1 7 2 C604 C504 C102E C19 C18 C606 C605 506 C505 C128E C107E C106E C105E C133E C101E C104E C603 C602 C503 C502 C601 C501 Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor 1/8W 180 ±5% 7.5MM 1/8W 390 ±5% 7.5MM 1/8W 560 ±5% 7.5MM 1/8W 1K ±5% 7.5MM 1/8W 1.1K ±5% 7.5MM 1/8W 1.8K ±5% 7.5MM 1/8W 4.7K ±5% 7.5MM 1/8W 5.6K ±5% 7.5MM 1/8W 10K ±5% 7.5MM 1/8W 15K ±5% 7.5MM 1/8W 22K ±5% 7.5MM 1/8W 39K ±5% 7.5MM 1/8W 43K ±5% 7.5MM 1/8W 47K ±5% 7.5MM 1 R129E 1 R101E 1 R110E R607 R507 R134 R124E R102E R307E R407E 9 R507E R607E 1 R105E 1 R112E 1 R123E 2 R109E R108E 2 R104E R122E 1 R132E 3 R601 R501 R119E R305E R405E R505E R605E R302E R402E 8 R502E R602E 1 R103E R606 R605 R603 R602 R506 R505 R503 R502 9 R121E 1 R111E 1 R128E 1 R131E 1 VR103E 1 VR102E 1 VR101E 1 VR104E
Resistor 1/8W 56K ±5% 7.5MM Resistor 1/8W 100K ±5% 7.5MM Resistor 1/8W 2M ±5% 7.5MM potentiometer A2K/A200K KQ L=15 ±10% A2K,A200K HP FREQ potentiometer C50K KQ L=15 ±10% LP FREQ potentiometer potentiometer B20K KQ L=15 ±10% ±1.5dB LEVEL B500 KQ L=15 ±10% BASS BOOST
12
GTO5355
Part Number PHONE/SUB INPUT PCB Semiconductors 03N1-1815-01 01JR-4558-01 2601-0202-00 Miscellaneous 1501-0209-00 1505-0609-00 1333-0203-00 1404-0024-02 1413-0001-00 PWM PCB Resistors 0701-2221-03 0701-2101-03 0701-2102-03 0701-2302-03 0701-2472-03 0701-2682-03 0701-2562-03 0701-2103-03 0701-2113-03 0701-2123-03 0701-2153-03 0701-2183-03 0701-2223-03 0701-2333-03 0701-2334-03 0701-2104-03 Capacitors 06D211054104 06D211074101 06D212273001 06D214764103 06S321026000 06S121046000 Semiconductors 04WY-39AV101 diode schottky SMD 3.9V DO-213AA 0.5W 04WY-15BV-01 diode schottky SMD 15V 1/2W ±2% DO-213AA 04PT-4148-01 diode SMD 1N4148 DO-213AA 03P1-1015-04 Transistor SMD 2SA1015 SOT-23 PNP 03P1-B649-07 Transistor 2SB649A 1.5A 180V 20W PNP TO-126 03N1-1815-04 Transistor SMD 2SC1815 SOT-23 NPN 1 1 6 1 1 4 ZD2 ZD1 D4 D1 D20 D3 D2 D13 Q10 Q6 Q3 Q2 Q7 Q1 Cap,Electro Cap,Electro Cap,Electro Cap,Electro 1uF/25V ±20% 4*7 105 100UF/25V 6.3*7mm 5mm ±20% 105 black 220UF/16V ±20% 8*7 105 5MM 47UF/25V ±20% 6*7 105 Black belt pin 5mm 1 1 1 2 C3 C27 C22 C1 C20 SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD 220 1/8W ±1% 0805 SMD 100 1/8W ±1% 0805 SMD 1K 1/8W ±1% 0805 SMD 3K 1/8W ±1% 0805 SMD 4.7K 1/8W ±1% 0805 SMD 6.8K 1/8W ±1% 0805 SMD 5.6K 1/8W ±1% 0805 SMD 10K 1/8W ±1% 0805 SMD 11K 1/8W ±1% 0805 SMD 12K 1/8W ±1% 0805 SMD 15K 1/8W ±1% 0805 SMD 18K 1/8W ±1% 0805 SMD 22K 1/8W ±1% 0805 SMD 33K 1/8W ±1% 0805 SMD 330K 1/8W ±1% 0805 SMD 100K 1/8W ±1% 0805 1 1 6 1 1 2 1 2 1 1 1 1 2 1 1 3 R17 R10 R31 R30 R29 R28 R26 R15 R13 R11 R5 R51 R14 R1 R23 R27 R24 R53 R7 R18 R9 R65 R3 R25 R12 R4 socket Pitch 2.54MM 2PIN pin socket 2.54spacing 6PIN 0.65*0.6516mm slide switch SSH-22H04-G9 2P2T 9MM EXT/INT dual RCA AV2-8.4-38 2PIN phone socket 6P4C RJ11 HPCB-3021-6P4C black 2 1 1 1 1 CON14 CON13 CON1 SW101E SUB RJ11 Transistor 2SC1815GR 150MA 60V 400MW NPN TO-92 1 Q3E 5 U503 U502 U501 U500 U505 1 LCR Description Qty Reference Designator
Dual Op-amp NJM4558 photocoupler LCR-0202
SMD Capacitor SMD 1000pF/50V 0805 NPO ±5% SMD Capacitor SMD 0.1uF/50V 0805 X7R ±10%
1 C26 2 C4 C25
01TI-L494-09 03P1-1015-01
PWM IC Transistor
SMD TL494C SO-16 2SA1015 150MA 60V 400MW PNP TO-92
1 U1 2 Q9 Q8
13
GTO5355
Part Number PWM PCB Miscellaneous 1501-0409-02 1501-0509-04 LED PCB 0701-3102-02 2100-0067-02 2100-0068-02 2005-0009-00 06S121046000 Resistor wire wire LED SMD 1K 1/4W ±5% 1206 2PIN UL1007 AWG26 L=70mm 5mm high temperature105wire 2PIN UL1007 AWG26 L=210mm 2.54 5mm,high temperature 105 wire LED 2*3*4mm 8 R1 R2 R3 R4 R5 R6 R7 R8 2 1 LED1 LED2 LED3 LED4 LED5 LED6 LED7 LED8 1 C1 8 pin socket pin socket PITCH 2.54mm 4PIN 90° PITCH 2.54mm 5PIN 90° 1 CN1 1 CN2 Description Qty Reference Designator
SMD Capacitor SMD 0.1uF/50V 0805 X7R ±10%
14
GTO5355
15
GTO5355
16
GTO5355
17
GTO5355
18
1
2
3
4
5
6
7
8
GTO5355
R103A 22K C103A 47P R108A 10K 823
CHD CHC CHB CHA PRO LED +VOP -VOP CH SUB CHA CON10 12 11 10 9 8 7 6 5 4 3 2 1 CON12
D CH1
R105A 10K C101A 22U/25V R101A 22K
4
C104A
6 1 5 7 3 2
823
5
C105A
D
U101AA
3 1 2
R104A 10K
4.7K
2 4 1
4558
B20K 6 VR101FB
5
VR102FA R107A 3 A50K U101AB 4558 R106A
6 R109A 6 7 5
U102AA 4558
VR102FB 5.6K C50K
U102AB LPF 4558
1
SW103FA
2 R114A
FLAT 3 HPF 4
R102A 10K C102A
R110A 360
102
6.8K
R111A 22K
1K
CON4 CH SUB 1 2
R103B 22K C103B 47P
R108B
+VOP
3 4
10K 823
-VOP
R105B 10K
C CH2 8
5 6
C104B
6 7 5 7 9
823
11
C105B
C101B 22U/25V R101B 22K
3
U101BA 4558
1 2 R102B 10K
R104B 10K
4.7k
2 10 1
CON6-1
C
VR102FC R107B 3 A50K U101BB 4558
R109B 6 12
7 5 LPF 5
R117A SW103FB
6
U102BA 4558 R106B 6.8K
VR102FD 5.6k C50K
1K R115A 1K
R116A 1K 2 3 U301A 4558 1 R114B 1K CHB
U102BB 4558
FLAT 7 HPF 8
C102B
2
102
R111B 22K
1 R110B 360
B20K 3 VR101FA
TEM
1
TH2 65 0C
2
+VOP
B CH1 RCA1B 4 R101 22K
C105 C102 22U/16V R105
R102 10K C104 10P R103 10K 3 2 3
22P 10K
U101A 4558 1 R107 1K CH1 R201 22K 1 CH2 RCA1A 2
C205 R205 22U/16V C202 C203 22U/16V
R202 10K C204 10P R203 10K 6 5
22P 10K
LED1 RED LED2 BLUE
R72 4.7K R71 4.7K
PRO LED +VOP +VOP
CON2A 1 2 CON2 +VOP
B
8
8
8
8
C103 22U/16V
4558
1K
C101 220U/25V NP
R106 10K
C106 22P C201 220U/25V NP
4
R206 10K
C206 22P
4
8
CH2
4
4
4
4
8
U101B 7
R207
-VOP U101BC 4558 U102AC 4558 U102BC 4558 U301C 4558
U101C 4558
U101AC 4558
A
A
DW GNO: PART NO: PART NAME: SCALE: UNIT: SIZE: REV: 1:1 MM A3 1.0 DRAWN BY: CHECKED BY: APPROVED BY: sheet of 1/7 DATA: DATA: DATA:
FRONT PRE
19
1 2 3 4 5 6
PRODUCT MODE:
GTO5355
7
8
1
2
3
4
5
6
7
8
GTO5355
R103C 22K
R108C C103C 47P 10K C105C C104C 823
5
D CH3
R105C 10K C101C 22U/25V
R101C 22K 3 2 2
823
D
U101CA lm833
1
R104C 10K
6 1 5 7 3
2
4.7K
2 4 1
VR102RA R107C 3 A50K U101CB lm833 R106C
6 R109C 6 7 5 LPF 1 3 FLAT 4 HPF
R102C 10K
1
B20K VR101RA
3
U102CA 4558
VR102RB 5.6K C50K
U102CB 4558
SW103RA
2 R114C
C102C
R110C 360
10P
6.8K
R111C 22K
1K
CHC
22K R101D
R108D 10K 823
C
C103D 47P R105D 10K
CH4
C104D
8 6 7 5 7 9
823
11
C105D
C
C101D 22U/25V
R101D 22K 3
U101DA lm833
1 2
R104D 10K
4.7K
2 10 1
VR102RC R107D 3 A50K U101DB lm833
R109D 6 12
7 5 LPF 5 FLAT7 8 HPF
R117C 1K SW103RB
6 U301B LM833 7 5 R114D 1K CHD
VR102RD 5.6k C50K U102DA 4558
R102D 10K
5
U102DB 4558
R115C 1K
R116C 1K
6
4 VR101RB B20K
6
R106D 6.8K
C102D R110D 360
10P
R111D 22K
B CH3 RCA2B 4 R301 22K
C305 C302 22U/16V R305
R302 10K C304 10P R303 10K 3 2 3 lm833
22P 10K
CH4 RCA2A 2 CH3 R401 22K 1
B
C405 C402 22U/16V R405
R402
22P 10K
+VOP 8 8 8 8 8 4
U201A 1 R307 1K
C303 22U/16V
10K C404 10P C403 22U/16V
6 5
U201B 7 lm833 4 R407 1K CH4
C301 220U/25V NP
R306 10K
4
C306 22P
R403 10K
8
4
4
4
-VOP U101DC 4558 U102CC 4558 U102DC 4558 U301C 4558
C401 220U/25V NP
R406 10K
C406 22P
U201C 4558
U101CC 4558
A
A
DW GNO: PART NO: PART NAME: SCALE: UNIT: SIZE: REV: 1:1 MM A3 1.0 DRAWN BY: CHECKED BY: APPROVED BY: sheet of 2/7 DATA: DATA: DATA:
REAR PRE
20
1 2 3 4 5 6
PRODUCT MODE:
GTO5355
7
8
1
2
3
4
5
6
7
8
GTO5355
D SUB SUB 1 1 3 SW2P2T 1 SW101EA 2
10P C102E C105E R105E 1.1K R103E 43K 683
D
C101E VR101EA B20K
3 2
1K R102E
6 7 5
C133E C104E 22U/25V
1 2 LCR 2 3
2
U502A
1
5
2 4
C107E
1
C128E
5
U503B
7 R134 6 1K CH SUB
22U/25V R101E 390
R108E
3
61
R109E 5.6K
3
R104E 10K
R131E 2M Q3E 4 3 2SC1815 R122E 10K R121E 47K
R128E 100K
20-200Hz
C106E 683
3
U502B 4558
5.6K 4558
22U/25V
VR102EA C50K
VR102EB C50K
U503A 4558
474
R110E 560
1
184
R111E 56K
4
4558
R119E 22K VR104EA B500
R132 3K Q1E R133 TEM
2
VR103EA A2K
5
VR103EB A200K
2
3
6
1
10K
R112E 1.8K
C
2SC1815
C
R124E 1K
C505 R505E
RJ11 1 2 3 1 2 3 4 CON4P-1 R129E 180 R123E 4.7K R602E 39K 6 5 R132E 15K CH1 +VOP R502E 39K 2 3
22P 47K
U501A 4558 1 R507 1K SUB
39K
SUBA 2 1 R507E 1K SUB 1 R501 22K 1
U500A 4558
C502 22U/16V
R505
R502 47K C504 2 3
10P C503 22U/16V 47K
R503
R605E
CH2
39K
U500B 4558 7 R607E 1K SUB 1
C501 220U/25V NP
R506 47K
C506 22P
8
8
8
8
8
8
8
8
B
+VOP
C605 R305E
CH3 R302E 39K 2 3
22P 47K
U501B 4558 7 R607 1K SUB
B
39K
SUBB 4
C602 22U/16V
R605
R602 47K 6 5
4
U505A 4558 1 R307E 1K SUB 1 R601 22K 3
4
4
4
4
4
4
4
-VOP U101BC 4558 U102AC 4558 U102BC 4558 U301C 4558 U500C 4558 U505C 4558
U101C 4558
U101AC 4558
C603 22U/16V
C604 10P R603 47K
CON1 6 5 4 3 2 1 A CON6-1 -VOP +VOP CH1 CH2 CH SUB CON14 1 2 CON2 CON2 CH3 CH4 CON13 1 2 CH4 R402E 39K 6 5
R606 R405E 39K C601 220U/25V NP 47K
C606 22P
U505B 4558 7 R407E 1K SUB 1
A
DW GNO: PART NO: SCALE: 1:1 MM A3 1.0 DRAWN BY: CHECKED BY: APPROVED BY: sheet of 3/7 DATA: DATA: DATA:
SUB PRE
UNIT: SIZE: REV:
21
1 2 3 4 5 6
GTO5355
7
8
1
2
3
4
5
6
7
8
GTO5355
+VAMP1
R150A 68 R139A 1K Q102A 2SB647A Q106A 2SD667A Q109A TIP35C
+VAMP1
PRO
PROT D102A IN4148 D
D
Q100A A06 C108A Q101A A06 C110A 101
+VEE
CHA
22U/25V
R133A 1K R134A 10K C109A 681 R135A 22
R152A 51
R146A Q105A A13 Q111A 2SC1815
R141A 3.9K R136A 22 R143A 1K
1K
R148A 4.3K R137A 22 R138A 22 C114A 100U/50V
C112A 104
R161A 470
SPA1
R145A 3.3K
R156AA 0.15/5W
C113A 1UF/25V
SPA
R156AB 0.15/5W R149A 1K C116A
R142A 3.9K
R165A 4.7/0.5W
-VEE
Q112A A56
Q113A A56
C111A 101
R154A 51
D100A IN4148
D101A IN4148
104M
C
R140A 1K
R160A 8.2K
C115A 22
Q108A 2SD667A R151A 68
Q103A 2SB647A
Q114A TIP36C
R163A 15K
R164A 15K
C
-VAMP1
-VAMP1
+VAMP1
R150B 68 R139B 1K Q102B 2SB647A Q106B 2SD667A Q109B TIP35C
+VAMP1
PRO
PROT D102B IN4148
C108B
+VEE
Q100B A06
Q101B A06
C110B 101
CHB
22U/25V
R133B 1K R134B 10K C109B 681 R135B 22
R152B 51
R146B Q105B A13 Q111B 2SC1815 R147B 3.3K
R141B 3.9K R136B 22 R143B 1K
1K
SPB1
R145B 3.3K
B
R156BA 0.15/5W
C112B 104
C113B 1UF/25V
B SPB
R148B 4.3K R137B 22 R138B 22 C114B
R161B 470
R156BB 0.15/5W
R142B 3.9K
R165B 4.7/0.5W
R149B 1K C116B
100U/50V
-VEE
Q112B A56 R140B 1K
Q113B A56
C111B 101
R154B 51
D100B IN4148
D101B IN4148
104M
R160B 8.2K
C115B 22
Q108B 2SD667A R151B 68
Q103B 2SB647A
Q114B TIP36C
R163B 15K
R164B 15K
-VAMP1
-VAMP1
A
A
DW GNO: PART NO: SCALE: 1:1 MM A3 1.0 DRAWN BY: CHECKED BY: APPROVED BY: sheet of 4/7 DATA: DATA: DATA:
22
1 2 3 4 5 6
FRONT AMP
UNIT: SIZE: REV:
GTO5355
7
8
1
2
3
4
5
6
7
8
GTO5355
+VAMP1
R150C 68
+VAMP1
D
R139C 1K
Q102C 2SB647A
Q106C 2SD667A
Q109C TIP35C
PROT D D102C IN4148
C108C
+VEE
Q100C A06
Q101C A06
C110C 101
CHC
22U/25V
R133C 1K R134C 10K C109C 681 R135C 22
R152C 51
R146C Q105C A13 Q111C 2SC1815
R141C 3.9K R136C 22 R143C 1K
1K
SPC1
R145C 3.3K
R156CA 0.15/5W
C112C 104
C113C 1UF/25V
R148C 4.3K R137C 22 R138C 22 C114C 100U/50V
R161C 470
SPC
R156CB 0.15/5W R149C 1K C116C
R142C 3.9K
R165C 4.7/0.5W
-VEE
Q112C A56
Q113C A56
C111C 101
R154C 51
D100C IN4148
D101C IN4148
104M
C
R140C 1K Q108C 2SD667A R151C 68 Q103C 2SB647A Q114C TIP36C
C R163C 15K R164C 15K
R160C 8.2K
C115C 22
-VAMP1
-VAMP1
+VAMP1
R150D 68 R139D 1K Q102D 2SB647A Q106D 2SD667A Q109D TIP35C
+VAMP1
PROT D102D IN4148
C108D
+VEE
Q100D A06
Q101D A06
C110D 101
CHD
22U/25V
R133D 1K R134D 10K C109D 681 R135D 22
R152D 51
R146D Q105D A13 Q111D 2SC1815
R141D 3.9K R136D 22 R143D 1K
1K
B
R148D 4.3K R137D 22 R138D 22 C114D 100U/50V
C112D 104
R161D 470
R156DB 0.15/5W
SPD1
R145D 3.3K
R156DA 0.15/5W
C113D 1UF/25V
B
SPD R165D 4.7/0.5W
R149D 1K C116D
R142D 3.9K
-VEE
Q112D A56 R140D 1K
Q113D A56
C111D 101
R154D 51
D100D IN4148
D101D IN4148
104M
R160D 8.2K
C115D 22
Q108D 2SD667A R151D 68
Q103D 2SB647A
Q114D TIP36C
R163D 15K
R164D 15K
-VAMP1
-VAMP1
A
A
DW GNO: PART NO: PART NAME: SCALE: UNIT: SIZE: REV: 1:1 MM A3 1.0 DRAWN BY: CHECKED BY: APPROVED BY: sheet of 5/7 DATA: DATA: DATA:
REAR AMP
23
1 2 3 4 5 6
PRODUCT MODE:
GTO5355
7
8
GTO5355
1 2 3 4 5 6 7 8
D
D
+VAMP2
R150E 68 R139E 1K Q102E 2SB647A Q106E 2SD669 Q107E 2SD669 Q109E 2SD1047 Q110E 2SD1047 Q116E 2SD1047
+VAMP2
PROT D102E IN4148
C108E
CH SUB
22U/25V
R133E 1K R134E 10K C109E 104 R135E 22
+VEE
Q100E 5551
Q101E 5551
C110E 101
R152E 4.7
R153E 4.7
R166E 4.7
R146E Q111E 2SC1815
C
R141E 3.9K R136E 22 R143E 1K 3.3K R145E Q105E A13 R148E 3K R137E 22 R142E 3.9K R138E 22 C114E 100U/50V C112E 104
500
C
R161E 270
R169E R156EA 0.15/5W 100
R158EA 0.15/5W
R157EA 0.15/5W
C113E 1UF/25V
SPE
R156EB R158EB 0.15/5W R157EB 0.15/5W R149E 500 C116E
R162E 270
R170E 100
0.15/5W
R165E 4.7/0.5W
-VEE
Q112E 5401
Q113E 5401
C111E 101
R154E 4.7
R155E 4.7
R167E 4.7
D100E IN4148
D101E IN4148
104M
B
R140E 1K
R160E .2K
C115E 22
Q108E 2SD667A R151E 68
Q103E 2SB649
Q104E 2SB649
Q114E 2SB817
Q115E 2SB817
Q117E 2SB817
R163E 15K
R164E 15K
B
-VAMP2
-VAMP2
A
PART NAME: SCALE: UNIT: SIZE: REV: 1:1 MM A3 1.0 DRAWN BY: CHECKED BY: APPROVED BY: sheet of 6/7
DW GNO: PART NO: DATA: DATA: DATA:
A
SUB AMP
24
1 2 3 4 5 6
PRODUCT MODE:
GTO5355
7
8
GTO5355
1 2 3 4 5 6 7 8
R7 18K
D20 4148 D1 4148 ZD1 5V6
C4 104
L1
CN1 CON4 R13 3K CN1A CON4
D
R10 30K
+12V
Q6 B649
Q1 C1815
R1 10K
ZD2 3V9
R8 NC V
R11 4.7K
V
1 2 3 4 5
REM DC12V 12V GND
REM DC12V 12V V
1 2 3 4 5
REM DC12V 12V GND
DC12V
1 C6A 2200U/35V1
2 5UH L1 2 5UH 4 2
F1 40A*2 1 3 C9 104 REM
J1 1 2 3 POWER PROT
D2A IN4148 Q4 2SC1815 Q5 2SC1815
R23A 56K R24A R21 6.8K C29 220U/16V 56K R25A 56K R26A 56K R36A 56K
SPA1
D
SPB1 SPC1 SPD1
C5A
R14 7K5 R25 100k Q2 C1815
C5
C6
R18A C28 10K 104
C2 NC
2200U/35V 2200U/35V 2200U/35V
C7 104
D1A MIC6A4
C8 104
C1 47UF/25V
+12
1K
C3 1U/50V Q10 A1015
R53 15K
D2 R26 4148 Q9 A1015 R28 1K R30 1K
CON9 CHD CHC CHB CHA PRO LED +VOP -VOP CH SUB 12 11 10 9 8 7 6 5 4 3 2 1 CON12 CON8 DC12V R15A 2.2K 1 4 8 PRO
SPE1
13
14
12
15
16
11
10
SPD
PRO
D4 4148 C22 R23 10K
10
9
8
7
6
5
4
3
2 2
+
E2
CON
REF
VCC
OP2
E1
-
5
4
3
Q3 C1815 R18 22K
R3 330K 220/16V
R24 12K
TL494CN
U1 TL494 R29 1K Q8 A1015 R31 1K
CON2 OUTPUT PROT
1
1
SPA
SPC
SPB
SPE
R5 6K8
9
D2B IN4148 Q4B 2SC1815 Q5B 2SC1815
R23B 56K R24B R21B 10K C29B 220U/16V 56K R25B 56K R26B 56K R36B 56K
SPA1
GND
FED
C
R17 220R
OP1
DT
C
R
+
-
R101 10K
1 2 CON2 CON7
1
2
3
4
5
6
7
8
U3A NE5532 Q2A 2SC1815 R37 10K PC2 P817 2 3 R30A 15K C31 10U/16V R47 4.7K +VOP ZD3 10V R44 100 R17A 47K 5.1K R48 3 1 2 R49 5.1K 5 6
SPB1 SPC1 SPD1
C
D3 C20 47/16V R65 33K R4 100K 4148 C25 104 R27 11K R12 100K C26 R9 102/M 22K C27 100/25V CN2 CON4
+VOP
D13 4148
U3B NE5532 7 -VEE -VEE
12V C32 100U/25V
R51 6K8
2 1 CON2
-VOP +VEE +VEE R50 5.1K 4
SPE1
PRO +12 R15 1K C1815 Q7
1 2 3 4
E2 E1 PRO LED PRO
E2 E1 PRO LED PRO
1 2 3 4
CON4 CN2A
E2 E1 PRO LED PRO
V
D3A IN4148
B
+VOP
B
E2 Q11 IRFZ48 Q12 IRFZ48 C33 103M D8 MUR1620C 6:12 T1 5 R52 100 R53B 100 R60 22/0.5W DC12V 1 R62 22/0.5W 3 2 R56 100 R57 100 R61 22/0.5W 7 6 1
L5A 2 30UH C15 104
+VAMP1 R63 100/3W C37 3300U/35V ZD4 15V/0.5W
Q19 2SC2073 +VOP +VOP
E2 Q22 IRFZ48 CON5 R52A 100 R53A 100 R54A 100 R60A 22/0.5W DC12V C39 220U/25V C18 104 C19 104 C21A 104 C21 104 1 2 CON2 CON6 1 Q23 IRFZ48 Q24 IRFZ48 C33A 103M T2 5 C35A D8A 1 MUR1620C L5AA 2 30UH C15A 104 C37A 3300U/63V +VAMP2
R19 2K
3 1 2 C42 C24 104 C25A 104 C26A 104 C27A 104 C34A 4:15 CON2 R56A 100 R57A 100 R58A 100 R61A 22/0.5W 2
7 6
ZD5 15V/0.5W
4 8 C34
C35 102M
4
C23 C38 104 L5B 3300U/35V R64 100/3W -VAMP1 Q20 2SA940 R20 2K 220U/25V
R62A 22/0.5W 8 L5AB D9A MUR1620CTR 3 30UH
102M
C23A C38A 104 3300U/63V
Q15 IRFZ48 A E1
Q16 IRFZ48
103M
D9 MUR1620CTR
3 30UH
4
-VOP
-VOP E1
Q26 IRFZ48
Q27 IRFZ48
Q28 IRFZ48
103M
4 -VAMP2 A
DW GNO: PART NO: PART NAME: SCALE: UNIT: SIZE: REV: 1:1 MM A3 1.0 DRAWN BY: CHECKED BY: APPROVED BY: sheet of 7/7 DATA: DATA: DATA:
POWER
25
1 2 3 4 5 6
PRODUCT MODE:
GTO5355
7
8