Text preview for : 03.Alignment & Adjustment.pdf part of Samsung LE32R81_86 Full service manual for models:
LE23R86BD
LE23R87BD
LE23R88BD
LE23R86WD
LE26R86BD
LE32R86BD
LE32R81BX
LE37R86BD
LE37R81BX
LE40R86BD
LE40R81BHX
LE23R86BCX
LE26R86BCX
LE32R86BCX
LE37R86BCX
LE40R86BCX
Back to : LE32R81BHX_XEU.part1.rar | Home
3 Alignments and Adjustments
3 Alignments and Adjustments
3-1 Service Instruction
1. Usually, a color TV-VCR needs only slight touch-up adjustment upon installation. Check the basic characteristics such as height, horizontal and vertical sync. 2. Use the specified test equipment or its equivalent. 3. Correct impedance matching is essential. 4. Avoid overload. Excessive signal from a sweep generator might overload the front-end of the TV. When inserting signal markers, do not allow the marker generator to distort test result. 5. Connect the TV only to an AC power source with voltage and frequency as specified on the backcover nameplate. 6. Do not attempt to connect or disconnect any wire while the TV is turned on. Make sure that the power cord is disconnected before replacing any parts. 7. To protect aganist shock hazard, use an isolation transform.
3-1
3 Alignments and Adjustments
3-2 How to Access Service Mode
3-2-1 Entering Factory Mode
" "
Power OFF
INFO
MENU
MUTE
Power On
- If you have Factory remote - control
PICTURE ON
INFO
FACTORY
- The buttons are active in the service mode. 1. Remote - Control Key : Power, Arrow Up, Arrow Down, Arrow Left Arrow Right, Menu, Enter, Number Key(0~9) 2. Function - Control Key : Power, CH +, CH -, VOL +, VOL -, Menu, TV/VIDEO(Enter)
3-2-2 Panel Check
You have to check Panel Maker Because of different adjustments as follows. First of all, Check the label rating! 1) Label Rating File
- LCD PANEL MARK A:ACER(AUO) S : SEC
C : CMO
* If not printed you could consider S(sec) panel mark.
2) If Panel Mark is "A", Set the factory mode indicating as follows. * Option Byte 1. Inch Option 32" 2. Gamma 32"AUO 3. Panel Option AUO Others are same shown below.
3-2
3 Alignments and Adjustments
3-3 Factory Data
1. Calibration 2. Option Table (Service) 3. White Balance 4. SVP-UX 5. Option Block 6. SGTV5810/NTP3000 7. YC Delay 8. Adjust 9. I2C Check 10. W/B MOVIE 11. Checksum 12. Reset 13. Spread Spectrum T-BDPMPEUD-xxxx (Main Micom Ver) T-BDPMPEUS-xxxx BORD2_CALLA_TR-xxxx (Sub Micom Ver) Month / Day / Year / Hour / Min. / Sec. 1. Calibration 1) AV Calibration 2) COMP Calibration 3) PC Calibration 4) HDMI Calibration
3-3
3 Alignments and Adjustments 2. Option Table (Service)
LE23R86/87BD* AUO PANEL BN07-00365A T230XW01 5V (TN 72%) No 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 Item Ready Inch Option Panel Vender DDR Panel Type Model Option Anynet + Light Effect WM Calib Auto Power TTX Group LNA Menu TTX On/Off TTX List Carrier Mute High Devi. VOL.Curve HDMI Hotplug HDMI Clock Ct HDMI Hotplug Dly Hotel Option Shop Mode Color Space PC Ident Language Ch. Table TTX Group Nordic Off On On English Each Factory Auto Off Off On On English Each Factory Auto Off Off On On English Each Factory Auto Off Off On On English Each Factory Auto Off Model Name Off 23" AUO_INT ETRON 23" AUO TN BDP/TLP Off On Off On Auto On On Flof Off Off Small 1 1 9 AMLCD BN07-00258A LTA230W2-L01 5V (PVA ,ZPD) Model Name Off 23" AMLCD_INT ETRON 23" AMLCD BDP/TLP Off On Off On Auto On On Flof Off Off Small 1 1 9 AMLCD BN07-00367A LTA260W2-L13 5V (PVA 72%) Model Name Off 26" AMLCD_INT ETRON 26" AMLCD BDP/TLP Off On Off On Auto On On Flof Off Off Small 1 1 9 LE26R86/87BD* AUO BN07-00254A T260XW02 5V (MVA-VE) Model Name Off 26" AUO_EXT_P ETRON 26" AUO BDP/TLP Off On Off On Auto On On Flof Off Off Small 1 1 9
3-4
3 Alignments and Adjustments
LE32R81/82B* CMO PANEL BN07-00348A V315B1-L01 5V (SMVA 72%) No 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 Item Ready Inch Option Panel Vender DDR Panel Type Model Option Anynet + Light Effect WM Calib Auto Power TTX Group LNA Menu TTX On/Off TTX List Carrier Mute High Devi. VOL.Curve HDMI Hotplug HDMI Clock Ct HDMI Hotplug Dly Hotel Option Shop Mode Color Space PC Ident Language Ch. Table TTX Group Nordic Off On On English Each Factory Auto Off Off On On English Each Factory Auto Off Off On On English Each Factory Auto Off Off On On English Each Factory Auto Off Off On Flof Off Off Small 1 1 9 Off On Flof Off Off Small 1 1 9 Off On Flof Off Off Small 1 1 9 Off On Flof Off Off Small 1 1 9 Model Name On 32" CMO_INT ETRON/(Samsung) 32" CMO BDP/TLP On On Off On AMLCD BN07-00258A LTA230W2-L01 5V (PVA, ZPD) Model Name On 32" AMLCD_INT ETRON 32" AMLCD BDP/TLP On On Off On AMLCD VE BN07-00453A LTA320WT-L06 5V (SMVA 72%) Model Name On 32" AMLCD_INT ETRON 32" AMLCDV BDP/TLP On On Off On AUO BN07-00421A T315XW02(V9) 5V, AMVA 72% Model Name On 32" AMLCD_INT ETRON/(Samsung) 32" AUO BDP/TLP On On Off On
3-5
3 Alignments and Adjustments
LE32R86/87BD* CMO PANEL BN07-00348A V315B1-L01 5V (SMVA 72%) No 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 Item Ready Inch Option Panel Vender DDR Panel Type Model Option Anynet + Light Effect WM Calib Auto Power TTX Group LNA Menu TTX On/Off TTX List Carrier Mute High Devi. VOL.Curve HDMI Hotplug HDMI Clock Ct HDMI Hotplug Dly Hotel Option Shop Mode Color Space PC Ident Language Ch. Table TTX Group Nordic Off On On English Each Factory Auto Off Off On On English Each Factory Auto Off Off On On English Each Factory Auto Off Off On On English Each Factory Auto Off Model Name Off 32" CMO_INT ETRON 32" CMO BDP/TLP On On Off On Auto Off On Flof Off Off Small 1 1 9 AMLCD BN07-00385A LTA320WT-L07 5V,SPVA,72% Model Name On 32" AMLCD_INT ETRON 32" AMLCD BDP/TLP On On Off On Auto Off On Flof Off Off Small 1 1 9 AMLCD VE BN07-00453A LTA320WT-L06 5V,SMVA 72% Model Name On 32" AMLCD_INT ETRON 32" AMLCDV BDP/TLP On On Off On Auto Off On Flof Off Off Small 1 1 9 AMLCD-Refresh BN07-00482A LTA320WT-L08 5V,SPVA, 72%,HD Model Name On 32" AMLCD_INT ETRON/(Samsung) 32"AMLCD V BDP/TLP On On Off On Auto Off On Flof Off Off Small 1 1 9
3-6
3 Alignments and Adjustments
LE37R81/82B* AUO PANEL BN07-00393A T370XW02 12V (AMVA 72%) No 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 Ready Inch Option Panel Vender DDR Panel Type Model Option Anynet + Light Effect WM Calib Auto Power TTX Group LNA Menu TTX On/Off TTX List Carrier Mute High Devi. VOL.Curve HDMI Hotplug HDMI Clock Ct HDMI Hotplug Dly Hotel Option Shop Mode Color Space PC Ident Language Ch. Table TTX Group Nordic Off On On English Each Factory Auto Off Off On On English Each Factory Auto Off Off On On English Each Factory Auto Off Off On On English Each Factory Auto Off Off On On English Each Factory Auto Off Off On Flof Off Off Small 1 1 9 Item Model Name On 37" AUO_EXT_P ETRON/(Samsung) 37" AUO BDP/TLP On On Off On LE37R86BD* AMLCD BN07-00393A T370XW02 12V (AMVA 72%) Model Name Off 37" AUO_EXT_P ETRON 37" AUO BDP/TLP On On Off On Auto Off On Flof Off Off Small 1 1 9 Off On Flof Off Off Small 1 1 9 Off On Flof Off Off Small 1 1 9 Off On Flof Off Off Small 1 1 9 AMLCD BN07-00387A LTA400WT-L06 12V (SPVA 72%) Model Name On 40" AMLCD_INT ETRON/(Samsung) 40"AMLCD BDP/TLP On On Off On LE40R81/82B* AMLCD VE BN07-00451A LTA400WT-L07 12V (SMVA 72%) Model Name On 40" AMLCD_INT ETRON/(Samsung) 40"AMLCDV BDP/TLP On On Off On AUO VE BN07-00448A T400XW01 V1 5V, AMVA, 72% Model Name On 40" AMLCD_INT ETRON/(Samsung) 40"AUOV BDP/TLP On On Off On
3-7
3 Alignments and Adjustments
LE40R86/87BD* AMLCD PANEL BN07-00387A LTA400WT-L06 12V (SPVA 72%) No 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 Ready Inch Option Panel Vender DDR Panel Type Model Option Anynet + Light Effect WM Calib Auto Power TTX Group LNA Menu TTX On/Off TTX List Carrier Mute High Devi. VOL.Curve HDMI Hotplug HDMI Clock Ct HDMI Hotplug Dly Hotel Option Shop Mode Color Space PC Ident Language Ch. Table TTX Group Nordic Off On On English Each Factory Auto Off Off On On English Each Factory Auto Off Off On On English Each Factory Auto Off Off On On English Each Factory Auto Off Off On On English Each Factory Auto Off Item Model Name Off 40" AMLCD_INT ETRON 40"AMLCD BDP/TLP On On Off On Auto Off On Flof Off Off Small 1 1 9 AMLCD VE BN07-00451A LTA400WT-L07 12V, SMVA 72% Model Name Off 40" AMLCD_INT ETRON 40"AMLCDV BDP/TLP On On Off On Auto Off On Flof Off Off Small 1 1 9 AMLCD Refresh BN07-00489A LTA400WT-L09 12V,SPVA 72%,HD Model Name Off 40" AMLCD_INT ETRON 40"AMLCDV BDP/TLP On On Off On Auto Off On Flof Off Off Small 1 1 9 AUO VE BN07-00448A T400XW01 V1 5V,AMVA,72% Model Name Off 40" AUO_INT ETRON 40"AUO V BDP/TLP On On Off On Auto Off On Flof Off Off Small 1 1 9 AUO BN07-00370A T400XW01 5V (AMVA 72%) Model Name Off 40" AUO_INT ETRON 40"AUO BDP/TLP On On Off On Auto Off On Flof Off Off Small 1 1 9
3-8
3 Alignments and Adjustments 3. White Balance
No 1 2 3 4 5 6 7 8 Item Sub-Briteness R-offset G-offset B-offset Sub-Contrast R-Gain G-Gain B-Gain Range 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH TV/AV/Scart 128 128 128 128 128 128 128 128 Comp/iDTV 128 128 128 128 128 128 128 128 PC 128 128 128 128 128 128 128 128 HDMI 128 128 128 128 128 128 128 128
4. SVP-PX 1) ComB Filter
No 1 Item Y-Filter Range 00H~FFH
2) Sharpness
No 1 2 3 4 5 6 7 8 9 10 11 Item H2Gain H4Gain V2Gain V4Gain Sr2Gain Sr4Gain Sl2Gain Sl4Gain Peakth1 Peakth2 Peskth3 Range 00 ~ 1FH 00 ~ 1FH 00 ~ 1FH 00 ~ 1FH 00 ~ 1FH 00 ~ 1FH 00 ~ 1FH 00 ~ 1FH 00H~FFH 00H~FFH 00H~FFH RF 10H 0AH 10H 10H 04H 00H 04H 00H 06H 2FH 48H AV 05H 0AH 0CH 10H 00H 02H 00H 02H 02H 2FH 3FH Comp480i 05H 05H 0AH 0CH 00H 00H 00H 00H 03H 2FH 3FH Comp480p Comp720p Comp1080i 05H 05H 0CH 0CH 00H 00H 00H 00H 03H 2FH 3FH 04H 02H 0AH 0AH 00H 02H 00H 02H 03H 2FH 3FH 04H 02H 0AH 0AH 00H 02H 00H 02H 03H 2FH 3FH HDMI 0AH 0AH 10H 10H 00H 04H 00H 04H 03H 2FH 3FH PC 05H 05H 0AH 0AH 00H 02H 00H 02H 08H 2FH 3FH iDTV 05H 05H 0AH 0AH 00H 02H 00H 02H 04H 2FH 3FH
3) NR
No 1 2 3 4 Item Y_NR_OFF C_NR_OFF Y_NR_ON C_NR_ON Range 00H~FFH(Y_NR_OFF) 00H~FFH(C_NR_OFF) 00H~FFH(Y_NR_ON) 00H~FFH(C_NR_ON) 00H 00H 00H 00H
3-9
3 Alignments and Adjustments 4) RGB Calibration
No 1 2 3 4 5 6 Item R-Offset G-Offset B-Offset R-Gain G-Gain B-Gan Range 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH TV/AV/S_Video 3AH 3AH 3AH A0H A0H A1H Component 40H 40H 40H 92H 92H 92H PC 32H 32H 32H A9H A9H A9H HDMI 82H 82H 82H 6CH 6CH 6CH
5) ADC Calibration
No 1 2 3 4 5 6 7 8 9 10 11 12 13 Item TCD3 Contrast TCD3 Brightness TCD3 CR TCD3 CB TCD3 Delay Analog Y Offset Analog PB Offset Analog PR Offset Analog Y Gain Analog PB Gain Analog PR Gain Black Level Svp Brightness Range 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH TV/AV/S_Video 7AH 26H 80H 80H 00H 40H 80H 80H D6H 80H 80H 00H 00H Component 78H 20H 80H 80H 00H 3DH 80H 80H B3H B3H B3H 00H 00H PC 78H 20H 80H 80H 00H 44H 44H 44H A4H ACH A7H 00H 00H HDMI 78H 20H 80H 80H 00H 40H 80H 80H 80H 80H 80H 00H 00H
6) Caliration Target
No 1 2 3 4 Item AV ADC COMP ADC PC ADC ALL RGB Range 00H~FFH 00H~FFH 00H~FFH 00H~FFH low 10H 10H 10H 01H high DCH EBH DCH EBH Delta 02H 02H 04H 0AH
3-10
3 Alignments and Adjustments 7) Color Management
No 1 2 3 4 Item Skin Direction Skin Enhance Green Stretch Blue Stretch Range Reddish/Yellowish 00H~FFH 00H~FFH 00H~FFH Reddish 00H 00H 00H
8) Sync Control
No 1 2 3 4 5 Item HSync Tip End VSync AGC Min VSync AGC Max VSync Clamp Mode VSync Thresh 0FH 6CH 33H 1 B3H
5. Option Block 1) FRC(Micronas) 2) FRC2X
No 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 Item OUTCON GAMMA OCC_MODE FALLBACK DBG_MARK SPR_CBR BIT_EXPAND INV_BIT_EXPAND REPEAT_MODE DEMO_ON_OFF MMU_RD_START ME_RD_START MC_RD_START CMZL(0x36E) BLOL(0x2A7) LOGO(0x2A7) Range 1~3 1~7 0/1 0/1 0/1 0/1 0/1 0/1 0/1 0/1 00H~FFH 00H~FFH 00H~FFH 00H~0FH 00H~0FH 00H~0FH 0 0 0 0 0 0 0 0 0 0 00H 00H 00H 0H 0H 0H
3-11
3 Alignments and Adjustments 3) FBE2
AV/ No 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 Item Pattern Select BS-On B-Slope Gain B-Tilt Min B-Tilt Max B-Tilt Slope LFunc-Basis Hfunc-Basis Mean-Offset1 Mean Offset2 Mean Slope Input Offset Input Gain ACR Offset ACR Th1 ARC Th2 Skin Enable Skin Tu Skin Tv M Skin Tu M Skin TV Sub Color Range 0~20 0/1 0~255 0~255 0~255 0~255 0~255 0~255 0~255 0~255 0~255 0~255 0~255 0~128 0~255 0~255 0/1 0~255 0~255 0~255 0~255 0~255 0~255 0~255 0~255 0~255 RF 0 1 55 30 110 128 65 75 30 235 112 128 128 10 10 110 1 135 135 125 125 138 125 128 128 128 COMP COMP COMP
3 Alignments and Adjustments
S-VIDEO (480i/576i) (480p/576p) (720p/1080i/1080p) 0 1 44 20 120 128 20 40 100 200 56 128 128 15 30 130 1 165 140 128 128 128 128 128 128 128 0 1 44 20 120 128 20 40 100 200 56 128 128 15 30 130 1 165 140 128 128 128 128 128 128 128 0 1 64 20 120 128 40 40 75 155 45 128 128 15 30 130 1 150 140 128 128 135 128 128 128 128 0 1 64 20 120 128 70 75 75 225 85 128 128 15 30 130 1 165 128 128 128 140 128 128 128 128
HDMI 0 1 64 20 120 128 55 65 75 225 85 128 128 15 30 130 1 165 128 128 128 150 128 128 128 128
DTV 0 1 64 20 120 128 75 88 75 225 85 128 128 15 30 130 1 128 128 128 128 143 128 128 128 128
DTV 0 1 64 20 120 128 75 88 75 225 85 128 128 15 30 130 1 128 128 128 128 143 128 128 128 128
23 M-Au-Sub Color 24 M-Wi-Sub Color 25 26 MW-Skin-Tu MW-Skin-Tv
3-12
3 Alignments and Adjustments 4) Pdp Logic
No 1 2 3 4 5 6 7 8 9 10 11 12 13 Item Pattern Srlect Data updata Data Type CDC Sw CDC Strengh Th BRE Sw FRC Repeat Mode FRC CBG Mark On ERC Bypass Panel Type Panel Inch Panel Version Logic Sw Version Range 0~63 ON/OFF 42"EU MRT/42"EU MESH/..... ON/OFF 0~31 ON/OFF ON/OFF 0~15 ON/OFF 0H 0H 0H 0 OFF 42"EU MRT OFF 0 OFF OFF 0 OFF 0H SD
6. SGTV5810/NTP3000
No 1 2 3 4 5 6 7 Item ID Tone Shift ID Tone Thresh Demod Prescaler Master Volume PWM Modulation DRC Threshold Speaker EQ Range 1H~FH 00H~FFH 00H~20H 00H~30H 80H~F2H 00H~7FH ON/OFF 01H 7FH 13H 13H F1H 06H ON
7. YC Delay
No 1 2 3 4 5 6 7 8 9 10 11 12 13 Item RF PAL-B/G RF PAL - D/K RF PAL - I RF SECAM - B/G RF SECAM - D/K RF SECAM -L/L' RF NTSC 3.58 RF NTSC 4.43 AV PAL AV SECAM AV NTSC 3.58 AV NTSC 4.43 AV PAL60 Range 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH 00H~FFH 66H 88H 55H 88H 77H 77H 40H 77H 88H 33H 95H 00H 77H
3-13
3 Alignments and Adjustments 8. Adjust
No 1 2 3 4 5 Item Video Mute Time Dynamic Contrast Dynamic Dimming Dynamic CE LNA PLUS RFDB-1 Level RFDB-2 Level RFDB-3 Level RFDB-4 Level 6 7 8 9 10 11 Magazine LNA PixelShift Test Debug ACR D-Watchdog UART Select 0~255 0~255 0~255 0~255 ON/OFF ON/OFF ON/OFF ON/OFF ON/OFF MAIN / IDTV / PDP Lvds ON / PDP Lvds OFF 2 5 7 24 OFF OFF OFF OFF ON OFF Range 0~255 ON/OFF ON/OFF ON/OFF 10 ON ON OFF
9. I2C Check 10. W/B MOVIE
No 1 2 3 4 5 6 7 8 9 10 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 Item WB Movie Color Mode Color Tone Msub Brigh Msub Contr W1_RGAIN W1_BGAIN W1_R_OFFS W1_B_OFFS W2_RGAIN W2_BGAIN W2_R_OFFS W2_B_OFFS NO_RGAIN NO_BGAIN NO_R_OFFS NO_B_OFFS C2_RGAIN C2_BGAIN C2_R_OFFS C2_B_OFFS Movie Contr Movie Brigh Movie Color Movie Sharp 0~255 0~255 0~255 0~255 0~255 0~255 0~255 0~255 0~255 0~255 0~255 0~255 0~255 0~255 0~255 0~255 0~255 0~255 0~100 0~100 0~100 0~100 Range ON/OFF Movie TV/AV/S_Video OFF Movie Cool1 128 128 193 56 124 124 205 32 124 127 159 100 126 124 112 164 128 122 100 45 55 75 Component OFF Dynamic Cool1 128 128 161 74 119 140 143 47 127 145 139 102 125 133 122 141 129 127 100 45 55 75 PC OFF Dynamic Cool1 128 128 144 117 127 110 149 93 124 110 137 123 126 114 123 156 117 116 100 45 55 75 HDMI OFF Dynamic Cool1 128 128 161 76 118 141 142 51 128 143 141 104 121 133 125 143 128 128 100 45 55 75 Scart1/2 OFF Dynamic Cool1 128 128 157 76 119 138 142 48 129 143 141 104 126 136 124 142 128 128 100 45 55 75
3-14
3 Alignments and Adjustments 11. Checksum 12. Reset 13. Spread Spectrun
No 1 2 3 4 5 6 7 Item Spectrum Delta Positive Negative Speed Time FBE Spectrum Range ON/OFF -128 ~ +128 0~99 0~99 0~7 0~7 0~5 ON 0 8 2 0 0 1
7A72
3-15
3 Alignments and Adjustments
3-4 Service Adjustment
3-4-1 White Balance - Calibration
If picture color is wrong, do calibration first. Equipment : CA210, Patten : chess pattern Execute calibration in Factory Mode Source AV : PAL composite, Component : 1280*720/60Hz PC : 1024*768/60Hz
( chess patten )
3-4-2 White Balance - Adjustment
If picture color is wrong, check White Balance condition. Equipment : CA210, Patten : Flat W/B Pattern Adjust W/B in Factory Mode Sub brightness and R/G/B Offset controls low light region Sub contrast and R/G/B Gain controls high light region Source AV : PAL composite, Component : 1280*720/60Hz HDMI[DVI] : 1280*720/60Hz
[ Test Pattern : MIK K-7256 PAttern #92 ] *Color temperature 1500K +/-500, -6 ~-20 MPCD *Color coordinate H/L : 272/278 +/- 2 35.0 Ft +/- 2.0Ft L/L : 272/278 +/- 3 1.5 Ft +/- 0.2Ft
Flat W/B Pattern
3-16
3 Alignments and Adjustments
3-4-3 Conditions for Measurement
1. On the basis of toshiba ABL pattern : High Light level (57 IRE) - INPUT SIGNAL GENERATOR : MSPG-925LTH * Mode NO NO 2 : 744X484@60 Hz 6 : 1280X720@60 Hz
NO 21 : 1024X768@60 Hz * Pattern NO 36 : 16 Color Pattern NO 92 : Flat W/B Pattern 2. Optical measuring device : CA210 (FL) Please use the MSPG-925 LTH generator for model LE26M51B/LE32M51B/LE40M51B/LE46M51B.
3-4-4 Method of Adjustment
1. Adjust the white balance of AV, Component and DVI Modes. (AV (RF Component) DTV PC DVI).
a) Set the input to the mode in which the adjustment will be made * Input signal - VIDEO Mode : Model #2 (744*484 Mode), Pattern #92 - DTV,DVI Mode : Model #6 (1280*720 Mode), Pattern #92 - HDMI Mode: Model #6(1280*720 Mode), Pattern #92 b) Enter factory color control, confirm the data. c) Adjust the low light. (Refer to table 1, 2 in adjustment position by mode) - Adjust sub - Brightness to set the 'Y' value. - Adjust red offset ('x') and blue offset ('y') to the color coordinates. Picture 4-2 Flat W/B Pattern
Low light Measurement point
* Do not adjust green offset data. d) Adjust the high light. (Refer to table 1, 2 in adjustment position by mode) - Adjust red gain ('x') and blue gain ('y') to the color coordinates. * Do not adjust the green gain and sub-contrast (Y) data.
3-17
3 Alignments and Adjustments d) Adjust the high light. (Refer to table 1, 2 in adjustment position by mode) - Adjust red gain ('x') and blue gain ('y') to the color coordinates. * Do not adjust the green gain and sub-contrast (Y) data. Picture 4-3 Flat W/B Pattern
High light Measurement point
3-18
3 Alignments and Adjustments
3-5 Software Upgrade
3-5-1 ATV S/W
Order Description ETC.
1
Open the Flash Downloader.
2
Connect DDC Manager to the TV Set with D-SUB Cable.
3-19
3 Alignments and Adjustments
Order
Description
ETC.
3
1) Choose the ATV S/W. 2) Check the download port. (LPT1) 3) Click "Mstar" for Micom.
4
Click "Connect".
Before clicking the icon, TV shoud be turned on.
5
Click "Program".
3-20
3 Alignments and Adjustments
3-5-2 DTV S/W
Order Description ETC.
1
Connect PC and TV Set with Serial cable. TV should be turned on.
2
Open the Samsung Set-top Box upgrade Wizard.
3-21
3 Alignments and Adjustments
Order
Description
ETC.
3
1) Choose the DTV S/W by clicking "Browse". 2) After choosing the S/W, click the "Next" icon.
4
When it display "Scanning...", power off and on the TV set.
It doesn't matter soft or hard power off and on.
5
After scaning COM port, Model, and Version, click "Next".
3-22
3 Alignments and Adjustments
Memo
3-23