Text preview for : Pioneer-RSP90 dig preamp.pdf part of Pioneer RSP90 digital preamplifier
Back to : Pioneer-RSP90 dig preamp. | Home
ORDER NO.
CRT3658
RS-P90/EW5
OPTICAL DIGITAL REFERENCE SYSTEM UNIVERSAL DIGITAL PREAMP
RS-P90
/EW5
For details, refer to "Important Check Points for Good Servicing".
PIONEER CORPORATION
4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2006
K-ZZW. OCT. 2006 Printed in Japan
1
2
3
4
SAFETY INFORMATION
A
This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair can the and reliability of the product and may void the . If you are not qualified to the repair of this product properly and , you should not risk trying to do so and refer the repair to a qualified service technician.
- Service Precautions
1. You should conform to the regulations governing the product (safety, radio and noise, and other regulations), and should keep the safety during servicing by following the safety instructions described in this manual. 2. Be careful in handling ICs. Some ICs such as MOS type are so fragile that they can be damaged by electrostatic induction.
B
C
D
E
F
2
RS-P90/EW5
1 2 3 4
5
6
7
8
[Important Check Points for Good Servicing]
In this manual, procedures that must be performed during repairs are marked with the below symbol. Please be sure to confirm and follow these procedures.
1. Product safety
Please conform to product regulations (such as safety and radiation regulations), and maintain a safe servicing environment by following the safety instructions described in this manual. 1 Use specified parts for repair. Use genuine parts. Be sure to use important parts for safety. 2 Do not perform modifications without proper instructions. Please follow the specified safety methods when modification(addition/change of parts) is required due to interferences such as radio/TV interference and foreign noise. 3 Make sure the soldering of repaired locations is properly performed. When you solder while repairing, please be sure that there are no cold solder and other debris. Soldering should be finished with the proper quantity. (Refer to the example) 4 Make sure the screws are tightly fastened. Please be sure that all screws are fastened, and that there are no loose screws. 5 Make sure each connectors are correctly inserted. Please be sure that all connectors are inserted, and that there are no imperfect insertion. 6 Make sure the wiring cables are set to their original state. Please replace the wiring and cables to the original state after repairs. In addition, be sure that there are no pinched wires, etc. 7 Make sure screws and soldering scraps do not remain inside the product. Please check that neither solder debris nor screws remain inside the product. 8 There should be no semi-broken wires, scratches, melting, etc. on the coating of the power cord. Damaged power cords may lead to fire accidents, so please be sure that there are no damages. If you find a damaged power cord, please exchange it with a suitable one. 9 There should be no spark traces or similar marks on the power plug. When spark traces or similar marks are found on the power supply plug, please check the connection and advise on secure connections and suitable usage. Please exchange the power cord if necessary. 0 Safe environment should be secured during servicing. When you perform repairs, please pay attention to static electricity, furniture, household articles, etc. in order to prevent injuries. Please pay attention to your surroundings and repair safely.
A
B
C
D
2. Adjustments
To keep the original performance of the products, optimum adjustments and confirmation of characteristics within specification. Adjustments should be performed in accordance with the procedures/instructions described in this manual.
3. Lubricants, Glues, and Replacement parts
Use grease and adhesives that are equal to the specified substance. Make sure the proper amount is applied.
E
4. Cleaning
For parts that require cleaning, such as optical pickups, tape deck heads, lenses and mirrors used in projection monitors, proper cleaning should be performed to restore their performances.
5. Shipping mode and Shipping screws
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual.
F
RS-P90/EW5
5 6 7 8
3
1
2
3
4
CONTENTS
A
B
SAFETY INFORMATION ..................................................................................................................................... 2 1. SPECIFICATIONS ............................................................................................................................................ 5 2. EXPLODED VIEWS AND PARTS LIST ............................................................................................................ 6 2.1 PACKING ................................................................................................................................................... 6 2.2 EXTERIOR................................................................................................................................................. 8 3. BLOCK DIAGRAM AND SCHEMATIC DIAGRAM .......................................................................................... 10 3.1 BLOCK DIAGRAM ................................................................................................................................... 10 3.2 CONTROL UNIT(1/2), CONNECTOR PCB(GUIDE PAGE) ..................................................................... 14 3.3 CONTROL UNIT(2/2)(GUIDE PAGE)....................................................................................................... 20 3.4 DSP PCB(1/2)(GUIDE PAGE).................................................................................................................. 26 3.5 DSP PCB(2/2)(GUIDE PAGE).................................................................................................................. 32 4. PCB CONNECTION DIAGRAM ..................................................................................................................... 38 4.1 CONTROL UNIT ...................................................................................................................................... 38 4.2 DSP PCB ................................................................................................................................................. 42 4.3 CONNECTOR PCB.................................................................................................................................. 46 5. ELECTRICAL PARTS LIST ............................................................................................................................ 47 6. ADJUSTMENT ............................................................................................................................................... 63 6.1 JIG CONNECTION DIAGRAM................................................................................................................. 63 6.2 MASTER CLOCK ADJUSTMENT............................................................................................................ 64 7. GENERAL INFORMATION ............................................................................................................................. 65 7.1 DIAGNOSIS ............................................................................................................................................. 65 7.1.1 DISASSEMBLY ..................................................................................................................................... 65 7.1.2 CONNECTOR FUNCTION DESCRIPTION .......................................................................................... 67 7.2 IC ............................................................................................................................................................. 68 7.3 OPERATIONAL FLOW CHART ............................................................................................................... 80 8. OPERATIONS ................................................................................................................................................ 81
C
D
E
F
4
RS-P90/EW5
1 2 3 4
5
6
7
8
1. SPECIFICATIONS
GENERAL
Power Source ............. DC 14.4 V (10.8 to 15.1 V allowable) Grounding system .......................................... Negative type Max. Current consumption .............................................. 1 A Backup Current ................................................ 3 mA or less Fuse ................................................................................ 4 A Dimensions ........... 240 (W) mm x 59 (H) mm x 240 (D) mm Weight ........................................................................ 3.6 kg
A
DSP/PREAMP
Tone controls (parametric) Bass frequency ........... 63 Hz, 100 Hz, 160 Hz, 250 Hz Treble frequency ......... 4 kHz, 6.3 kHz, 10 kHz, 16 kHz Gain ................................................................. ± 12 dB 31-band graphic equalizer (L/R independent) Frequency ............................. 20 Hz to 20 kHz, 1/3 oct. Gain .................................................... ± 12 dB (0.5 dB) 3-band parametric equalizer (L/R independent) Frequency ............................. 20 Hz to 20 kHz, 1/3 oct. Gain .................................................... ± 12 dB (0.5 dB) Crossover network (L/R independent) SUBWOOFER ..................... HPF frequency: 20 Hz to 100 Hz, 1/3 oct. ...................... LPF frequency: 40 Hz to 250 Hz, 1/3 oct. ................................... Gain: +10 dB to 24 dB (0.5 dB) LOW ............ HPF frequency: 25 Hz to 250 Hz, 1/3 oct. .................... LPF frequency: 250 Hz to 10 kHz, 1/3 oct. ....................................... Gain: 0 dB to 24 dB (0.5 dB) MID ............ HPF frequency: 160 Hz to 10 kHz, 1/3 oct. ...................... LPF frequency: 2 kHz to 20 kHz, 1/3 oct. ....................................... Gain: 0 dB to 24 dB (0.5 dB) HIGH .................. HPF frequency: 1.6 kHz to 20 kHz, 1/3 oct. ...................... LPF frequency: 8 kHz to 20 kHz, 1/3 oct. ....................................... Gain: 0 dB to 24 dB (0.5 dB) Slope ........... PASS, 6, 12, 18, 24, 36, 48, 72 dB/oct. ..............................(PASS: no pass HPF-High channel) Phase ......................................... NORMAL/REVERSE Time alignment (H/M/L ch) ......................... 0 cm to 192.5 cm (0.77 cm) (SW ch) ................................ 0 cm to 385 cm (1.54 cm) Position adjustment ...................... DISTANCE: 0 cm to 192.5 cm (0.77 cm) ...................................... Level: 0 dB to 30 dB (0.5 dB) Sampling frequency ............................................... 44.1 kHz Digital input ...................................................... Optical input Analog Output ........................................ RCA output (4 line)
B
C
D
E
RCA OUTPUT
Frequency responce ............... 10 Hz to 20 kHz, (1, +0 dB) Max. output level/impedance ................................4 V/220 Distortion.................................. 0.002% (1 kHz, 20 kHz LPF) Signal-to-noise ratio ........................ 115 dB (IHF-A network) Separation ............... 80 dB (100 Hz to 10 kHz, 20 kHz LPF)
F
RS-P90/EW5
5 6 7 8
5
1
2
3
4
2. EXPLODED VIEWS AND PARTS LIST
NOTES : · Parts marked by " * " are generally unavailable because they are not in our Master Spare Parts List.
A
· The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. · Screw adjacent to mark on the product are used for disassembly. · For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.)
2.1 PACKING
10 23 2 32 18 19 21 22 31 28
B
16 17 20
3 7 4 4
8
C
25 25 26 12
15
D
11
E
F
6
1
"
6
30 29 27 1
5 24 9
15
13
14
RS-P90/EW5
2 3 4
5
6
7
8
PACKING SECTION PARTS LIST
Mark No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 Description Cord Cord Assy Screw Assy Screw Shaft Screw Polyethylene Bag Polyethylene Bag Polyethylene Bag Polyethylene Bag Polyethylene Bag Sub Carton Carton Contain Box Protector Owner's Manual(English) Owner's Manual(Spanish) Owner's Manual(German) Owner's Manual(French) Owner's Manual(Italian) Owner's Manual(Dutch) Owner's Manual(Russian) Warranty Card Clamper Bracket Cover Cable Cord Cord Cord Polyethylene Bag Caution Card Part No. CDE4167 CDE6642 CEA5484 BYC40P120FTB CLP1246 CMZ40P080FTC E36-613 CEG-020 CEG1101 CEG1116 CEG1364 CHG5726 CHG5898 CHL5898 CHP3188 CRB2199 CRB2200 CRB2201 CRB2202 CRB2203
C B
A
* * *
*
CRB2204 CRB2205 CRY1157 CNV1443 CND3195 CNS2726 CDE6690 CDE6314 CDE6315 CDE6641 CEG-145 CRP1343
* * * * *
D
E
F
RS-P90/EW5
5 6 7 8
7
1
2
3
4
2.2 EXTERIOR
2
A
16 4 6 3 44 6 6 55 50 46 12 51 6 22 5 17 22 15 22 1
A B
58 56
47 48 49 2
B
1
C
B
52 53 54
45
2 57 2
18
C
18 21 23 35 10
22
24 38 42 38 25 26 27 34 36 41 43 29 33 32 31 40 28 57
D
37 1 40 40 1 14 1 39
30
A
57
19 13
E
8
20
B
A
11 9 20
F
13
15% 8 RS-P90/EW5
1 2 3 4
5
6
7
8
EXTERIOR SECTION PARTS LIST
Mark No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 Description Screw Screw Badge Badge Screw(M3 x 4.5) Screw(M3 x 8) ····· Cord Assy Fuse(4 A) FFC Chassis Panel Panel Panel Case Holder Holder Holder Insulator Tape Sheet Insulator Control Unit Cord(CN302) Cord(CN101) Cord(CN102) Cord(CN801) Fuse(4 A) Pin Jack(CN103) Pin Jack(CN104) Terminal(CN901) Fuse Holder(CN902) Connector(CN301) Connector(CN651) Connector(CN601) Connector(CN701) Holder Holder Screw Screw Terminal(CN501) Terminal(CN502) Terminal(CN503) DSP Unit Plug(CN513) Connector(CN2101) Connector(CN2402) Connector(CN2403) Connector(CN2401) Part No. BMN30P080FTB BMZ30P060FCU CAH1871 CAH1951 CBA1937 CBA1993 CDE6642 CEK1001 CDE8046 CNA2874 CNB3236 CNB3237 CNB3238 CNB3239 CND3097 CND3474 CND3476 CNM9879 CNM9880
C
Mark No. 50 51 52 53 54 55 56 57 58
Description Connector(CN3201) Connector(CN4951) Connector(CN514) Holder Holder Holder Spacer Screw LED(D2601)
Part No. CKS5091 CKS5091 CKS5643 CND3095 CND3098 CND3099 CNN1169 ISS30P050FTC NSPW315BS-0359
B A
* *
>
CNN1170 CNN1171 CWN1434 CDE8047 CDE8048 CDE8048 CDE8049 CEK1001 CKB1072 CKB1072 CKE1060 CKR1021 CKS2600 CKS3561 CKS5071 CKS5325 CND3093 CND3094 PPZ20P060FTB PPZ30P080FTB VNF1084 VNF1084 VNF1084 CWX3288 CKS3533 CKS4977 CKS4985 CKS4985 CKS4989
>
D
E
F
RS-P90/EW5
5 6 7 8
9
1
2
3
4
3. BLOCK DIAGRAM AND SCHEMATIC DIAGRAM
3.1 BLOCK DIAGRAM
A
A
OPT-IN
4 2
CONTROL UNIT
5V3V IC304 TC7SH32FUS1
1 INB OUTY 4
CN301
VD5R0 Q304
CN302
DATA IN 1
B
CN2101
CN514 CN513
1 2 3 4 RESET S401 1 2 3 4 6 1 2 3 4 6
CN651
D- US+5V USBDM
FULL SPEED USB PERIPHERAL IC651 CY7C68013A-100AXC
18 DMINUS RXD0 TXD0 PB3/FD3 PB5/FD5 41 40 37 45
AUDIO CONTROL IC601 PEG169A
24 25 27 6 TXD1 RXD1 P64 CNVSS P00 P01 CLK4 SOUT4 SIN4 P05 P06 P26 P40 P30 P02 P04 P31 P32 P35 P36 P37 P34 P33 P41 67 68 1 80 79 62 61 53 43 51 65 63 50 49 46 45 44 47 48 42
CN601
PLDSEL0 PLDSEL1 PLDCLK PLDOUT PLDIN nSTATUS nCONFIG1 nCONFIG2 DSPSTOP DSPERR PLDRST CONFDONE DIREMFLG DIRADFLG DIRBRATE0 DIRBRATE1 DIRRST DITRST DIRUNLOCK UMUTE 32 30 28 26 24 22 20 18 16 14 12 10 8 7 6 5 4 3 9 2
B
D+ RST
USBDP
17 10
DPLUS XOUT
B
X651 24MHz 11 Q700 N33V XIN AVCC1,2 VCC1-9 RXD1 X601 10MHz
10
XOUT
C
CONNECTOR PCB
12
XIN
B
CN3201
US+5V Q699 M3.3V
POWER ON RESET IC751 S-80827CNUA-B8M
2 VDD OUT 1 9 RESET
B
3
IC752 TC7SET04FUS1 CN701 IP-BUS IN
BUS- 7 BUS+ 11 ASENB 4 BMUTE 8 5 6
IC150 TC7WH04FU
5 4 3 2 1 3 7 5 CLR CLKIN ELDATA EVOLENB EVOLSTB BATT VBUM
IC701 HA12241FP
BUS- BUS+ ROUT DIN1 2 1
4 RX TX
18 22 23
CLK3 P81 P71 P70 SOUT3 P93 P94
CN902
2 4.0A 1
C
STBY 8 Q971 ASENS Q973 BATT Q974 BSENS 16 P83 15 P84 IPPW 21 P76
Q932 BATT
IC935 TPD1018F
6 IN OUT 1
CN901
B.U BREM 2 3
P43
40 Q931
SWBU
P80
19
Q911 VBUM Q982 SWBU ASENM Q912
I S-812C
2 VIN
D
Q941 Q983 VBUM
DLMN
Q972
I S-812C
2 VIN
Q984
MUTE
BATT
DC-DC CONV. IC851 AN8011S
SWBU 9 3 VCC ON/OFF Q851
Q853
T851
IC899 TA78L12F
1 IN OUT 3 +12VL SWBU
DC-DC CONV. IC801 AN8011S
9 3 VCC ON/OFF Q802
Q804
IC934 S-812C50AU
2 VIN VO
IC898 TA78L12F
1 IN OUT 3 +12VR
IC933 S-812C50AU
2 VIN VO
OUT2
7
OUT1
10
IC932 S-812C50AU
2 VIN VO
E
IN-2 4 Q854 T852 2
IC897 TA79L12F
IN OUT 3 -12VL
IN-1
13
IC931 S-812C50AU
2 VIN VO
Q852 2 OUT1 10
IC896 TA79L12F
IN OUT 3 -12VR
Q803 Q811
Q812
Q814 Q801
OUT2
7
Q815
IN-2
4
F
10
RS-P90/EW5
1 2 3 4
5
6
7
8
A
+12VL
302
IN 1
B
CN2101
4 3 1 2 8 7 5 6
CN101
HLP HLM MLP MLM LLP LLM SLP SLM HLP 6
12bit DACx4 IC101 AD7564BRS
VREFC IOUT 1D 8
IC105 LT1358CS8 2 - 1 3 +
6 5
Hi-Lch
Q109 HLO Q110 2 3 Q101 MLO MRO HLO HRO
CN103
Mid Lch Mid Rch Hi Lch Hi Rch 1 3 5 7
601
EL0 EL1 CLK UT DIN US G1 G2 OP RR ST NE LG LG TE0 TE1 ST ST CK TE 32 30 28 26 24 22 20 18 16 14 12 10 8 7 6 5 4 3 9 2
ELDATA CLKIN
15 16
SDIN CLKIN
RFBD RFBC
9 5
IC107(1/2) LT1358CS8 IC106 LT1358CS8 6 - 7 5 +
2 3
+12VL -12VL SLO SRO LLO LRO
CN104
SW Lch SW Rch LOW Lch LOW Rch 1 3 5 7
CN102
Mid-Lch
Q117 MLO Q118 6 5 Q102
MLP
23
B
CN3201
B
CN2403
4 3 1 2 8 7 5 6
HRP HRM MRP MRM LRP LRM SRP SRM
VREFB
IOUT 1A
21
RCA OUT
B
CN2402
HLM
10
VREFD
IOUT 1C
4
- +
7
- +
1
B
MLM EVOLENB EVOLSTB CLR
19 13 14 12
VREFA LDAC FSIN CLR
IOUT 1B
25
- +
1
- +
7
RFBA RFBB
20 24
IC107(2/2) LT1358CS8
+12VR
-12VL -12VL -12VR +12VL +12VR DAC5V D5V D3.3V
CN801
1 2 4 5 7 11 13 14
12bit DACx4 IC102 AD7564BRS
HRP 6 VREFC IOUT 1D 8
IC108 LT1358CS8 2 - 1 3 +
6 5
Hi-Rch
Q111 HRO Q112 2 3 Q103
902
2 4.0A 1
HRM
10
VREFD
IOUT 1C
4
- +
7
- +
1 +12VR -12VR
ELDATA CLKIN
15 16
SDIN CLKIN
RFBD RFBC
9 5
IC110(1/2) LT1358CS8 IC109 LT1358CS8 6 - 7 5 +
2 3
B
C D E F
901
B.U EM 2 3 MRP 23 VREFB IOUT 1A 21
Mid-Rch
Q119 MRO Q120 6 5 Q104
MRM EVOLENB EVOLSTB CLR
19 13 14 12
VREFA LDAC FSIN CLR
IOUT 1B
25
- +
1
- +
7
RFBA RFBB
20 24
IC110(2/2) LT1358CS8
+12VL
-12VR
Q911
12
IC921 S-812C33AMC-C2N
2 VIN VOUT 3
VDD5 LLP N3.3V LLM M3.3V ELDATA CLKIN 15 16 10 6
12bit DACx4 IC103 AD7564BRS
VREFC IOUT 1D 8
IC111 LT1358CS8 2 - 1 3 +
6 5
Low-Lch
Q113 LLO Q114 2 3 Q105
Q972
IC922 S-812C33AMC-C2N
2 VIN VOUT 3
VREFD
IOUT 1C
4
- +
7
- +
1 +12VL -12VL
MUTE
SDIN CLKIN
RFBD RFBC
9 5
IC113(1/2) LT1358CS8 IC112 LT1358CS8 6 - 7 5 +
2 3
Sw-Lch
Q122 SLO Q123 6 5 Q106
SLP
23
VREFB
IOUT 1A
21
IC934 S-812C50AUA-C3E
2 VIN VOUT 3 D5V VD5RO
SLM EVOLENB EVOLSTB CLR
19 13 14 12
VREFA LDAC FSIN CLR
IOUT 1B
25
- +
1
- +
7
IC933 S-812C50AUA-C3E
2 VIN VOUT 3
RFBA RFBB
20 24
IC113(2/2) LT1358CS8
+12VR
-12VL
DAC5V
IC932 S-812C50AUA-C3E
2 VIN VOUT 3 V5DAVOR
12bit DACx4 IC104 AD7564BRS
LRP 6 VREFC IOUT 1D 8
IC114 LT1358CS8 2 - 1 3 +
6 5
Low-Rch
Q115 LRO Q116 2 3 Q107
IC931 S-812C50AUA-C3E
2 VIN VOUT 3 V5DAVOL
LRM
10
VREFD
IOUT 1C
4
- +
7
- +
1 +12VR -12VR
Q812 Q811 Q814
FU801 D3.3V
ELDATA CLKIN
15 16
SDIN CLKIN
RFBD RFBC
9 5
IC116(1/2) LT1358CS8 IC115 LT1358CS8 6 - 7 5 +
2 3
Q810
Sw-Rch
Q124 SRO Q125 6 5 Q108
SRP
23
VREFB
IOUT 1A
21
Q815 Q813 N33V
SRM EVOLENB EVOLSTB CLR
19 13 14 12
VREFA LDAC FSIN CLR
IOUT 1B
25
- +
1
- +
7
RFBA RFBB
20 24
IC116(2/2) LT1358CS8
-12VR
RS-P90/EW5
5 6 7 8
CN2401
11
1
2
3
4
B
A
CN302
1
DSP PCB
DIR IC2001 DIR1703ES1
20 DIN DOUT 12 BCKO 21
CN2101
DATA IN
A
7
XTO
BCKO
11
A
IC3015 TC7WZ34FU
1 7 20
PLDDATA
PLD IC3201 EPF6016ATI144-3S1
JTTD1 148
PLDBCK
8 X2001 11.2896MHz
LRCKO
XTI
LRCKO UNLOCK CKSEL
10 27 28
B
IC3016 TC7WZ34FU
1 DIRUNLOCK 7 17 59 PLDLRCK OUTL DIRUNLOCK OUTR DSP0ERR DSP0RST DSP0STP DSP0DR1B DSP0DR1A DSP0RFS1 DSP0CS DSP0WR DSP0HBG DSP0HBR DSP0TFS1 37 38 48 107 44 80 81 82 85 95 88 99 68
DSP0 IC4001(2/2) ADSP-21065LCS240S1
SDCLK0 RAS CAS SDWE DQM
SDCKE SDA10 MS3
IC4201, IC4202 MSM56V16160F8TKFM
35 17 16 15 14 36 34 20 18 CLK RAS CAS WE LDQM UDQM CKE A10 CS A0-9 A11
IDAT(0-15)0 IC4202 IDAT(16-31)0 IC4201
TDI OUTL OUTR DS0ER DS0RST DS0STP DS0DR1B DS0DR1A DS0RFS1 DS0CS DS0WR DS0HBG DS0HBR 5 6 197 157 201 206 17 16 13 55 58 52 40 18 145 147 149 151 30 19 15 DROA DROB FLAG0 RESET FLAG3 IRQ1 DR1B DR1A RFS1 CS WR HBG HBR TFS1 EMU TRST TMS TCK CLKIN TCLK1 RCLK1 37 42 43 44 46
47 48 75
CN3201
4 DIRRST 21 RST BRATE1 BRATE0 ADFLG EMFLG BRSEL 3 2 1 17 19 DIRBRATE1 DIRBRATE0 DIRADFLG DIREMFLG
DSP0 IC4001(1/2) ADSP-21065LCS240S1
79 80 78 76 FLAG9 FLAG8 FLAG10 FLAG11
ISDCLK0 IRAS0 ICAS0 ISDWE0 IDQM0
ISDCKE0 ISDA100 IMS30
ADDR0-9 ADDR13 DATA0-31 DT1A DT1B TDOB DTOA TDO 146
(IAD0-9)0,IAD130 (IDAT0-31)0
22 DS0DT1A 23 DS0DT1B 12 11
B
5 6 7 8 9
DIRBRATE1 DIRBRATE0 DIRADFLG DIREMFLG DIRUNLOCK DITRST C
1
7
4 8 1 7 2 7 205
RCLK0 TCLK0 RFS0 TFS0 IRQ0
DS0TFS1
JTEMU JTTRST JTTMS JTTCK DSP0CLK
CN601
3
IC4151 TC74LCX541FTS1 (IDAT0-7)0
Y1 | Y8 A1 | A8
IC3202 TC7SH32FUS1
2 1 4 nCONFIG 3 5
18 20 2 10 12 14 16 22 24 26 28 30 32
nCONFIG2 nCONFIG1 UMUTE CONFDONE PLDRST DSPERR DSPSTOP nSTATUS PLDIN PLDOUT PLDCLK PLDSEL1 PLDSEL0
A
DSP1 IC4301(1/2) ADSP-21065LCS240S1
4 8 19 2 7 18 205 RCLK0 TCLK0 TCLK1 RFS0 TFS0 TFS1 IRQO
OE2 OE1 19 1
3
5
148 TDI 5 6 197 157 201 206 17 16 13 55 58 52 40 145 147 149 151 30 15
DSP1 IC4301(2/2) ADSP-21065LCS240S1
37 42 43 44 46
47 48 75
IC4501, IC4502 MSM56V16160F8TKFM
35 17 16 15 14 36 34 20 18 CLK RAS CAS WE LDQM UDQM CKE A10 CS A0-9 A11
IDAT(0-15)1 IC4502 IDAT(16-31)1 IC4501
DSP2 IC4601(1/2) ADSP-21065LCS240S1
6 2 4 8 19 2 7 18 205 RCLK0 TCLK0 TCLK1 RFS0 TFS0 TFS1 IRQO 53 63 UMUTE CONFDONE 105 89 PLDRST 62 60 56 123 124 PLDOUT 125 128 PLDCLK 129 130 131 13 27 73 34 JTTD4 JTEMU
DSP1ERR DSP1RST DSP1STP DSP1DR1B DSP1DR1A DSP1RFS1 DSP1CS DSP1WR nCONFIG DSP1HBG DSP1HBR MUTERQ CONF_DONE RESET DSPERR DSPSTOP nSTATUS PLDIN PLDOUT1 PLDOUT2 PLDCLK1 PLDCLK2 PLDSEL1 PLDSEL0 TDI TMS TDO TCK
49 106 46 74 75 79 84 94 87 98
DS1ER DS1RST DS1STP DS1DR1B DS1DR1A DS1RFS1 DS1CS DS1WR DS1HBG DS1HBR JTEMU JTTRST JTTMS JTTCK DSP1CLK
6
2
C
IC3005 TC7WZ34FU IC3008 TC7WZ34FU
SDCLK0 DROA RAS DROB CAS FLAG0 SDWE RESET DQM FLAG3 IRQ1 SDCKE DR1B SDA10 DR1A MS3 RFS1 CS ADDR0-9 ADDR13 WR HBG DATA0-31 HBR EMU DTOA TRST TDOB TMS DT1A TCK DT1B CLKIN RCLK1 TDO 146
ISDCLK1 IRAS1 ICAS1 ISDWE1 IDQM1
ISDCKE1 ISDA101 IMS31
(IAD0-9)1,IAD131 (IDAT0-31)1
11 12 22 23 INHL INML INLL INSL
IC4451 TC74LCX541FTS1 (IDAT0-7)1
Y1 | Y8 A1 | A8
OE2 OE1 19 1
CN4951
TDI 2 TMS 6 TDO 8 TCK 10 JTD4 19 JEMU 31
148 5 6 197 157 201 206 17 16 13 55 58 52 40 145 147 149 151 30 15 DROA DROB FLAG0 RESET FLAG3 IRQ1 DR1B DR1A RFS1 CS WR HBG HBR EMU TRST TMS TCK CLKIN RCLK1
DSP2 IC4601(2/2) ADSP-21065LCS240S1
37 42 43 44 46
47 48 75
IC4803, IC4804 MSM56V16160F8TKFM
35 17 16 15 14 36 34 20 18 CLK RAS CAS WE LDQM UDQM CKE A10 CS A0-9 A11 IDAT(0-15)2 IC4804 IDAT(16-31)2 IC4803
D
IC4951 TC7WZ34FU
7 3 1 6
IC4902 TC7SZU04FU
2 4
IC4901 TC74VHC541FTS1
6 7 8 9 A5 A6 A7 A8 11 Y8 14 Y5 13 Y6 12 Y7 PLD30 DSP2CLK DSP1CLK DSP0CLK 92 CLK30
DSP2ERR DSP2RST DSP2STP DSP2DR1B DSP2DR1A DSP2RFS1 DSP2CS DSP2WR DSP2HBG DSP2HBR
51 101 47 69 71 72 83 93 86 96
DS2ER DS2RST DS2STP DS2DR1B DS2DR1A DS2RFS1 DS2CS DS2WR DS2HBG DS2HBR JTEMU JTTRST JTTMS JTTCK DSP2CLK
TDI SDCLK0 RAS CAS SDWE DQM
SDCKE SDA10 MS3
ISDCLK2 IRAS2 ICAS2 ISDWE2 IDQM2
ISDCKE2 ISDA102 IMS32
IC4953 TC7SH04FUS1
4 JTAG 2 4
IC4952 TC74VHC08FTS1
2 1 5 4 10 9 13 12 3 JTTD1
X4901
ADDR0-9 ADDR13 DATA0-31 DTOA TDOB DT1A DT1B TDO 11 12 22 23
(IAD0-9)2,IAD132 (IDAT0-31)2
INHR INMR INLR INSR
21
JTD1
23
JRST
6
JTTRST
IC4751 TC74LCX541FTS1 (IDAT0-7)2
Y1 | Y8 A1 | A8
25
JTCK
8
JTTCK
146 11 JTTMS JTTD4
27
JTMS
B33V
OE2 OE1 19 1
E
5 7
F
12
RS-P90/EW5
1 2 3 4
5
6
7
8
SRC IC2201 SRC4184IPAG
OUTHLR OUTMLR 22 24 HDATA MDATA 58 55 SDINA SDINB SDOUTA SDOUTB 64 49 SCK1 DMUTE DITRST 5 7 10 14 6 4
DAC-Hi IC2301 PCM1798DB
DATA SCK MUTE RST IOUTR BCK LRCK IOUTR+ 18 17 2 6 IOUTL IOUTL+ 26 25 2 6
A
IC2501 LT1358CS8
-IN_A OUT_A -IN_B OUT_B 1 7 HLP HLM
CN2402
HLP 7 HLM 8 MLP 10 MLM 9 LLP 3 LLM 4 SLP 6 SLM 5
IC3011 TC7WZ34FU IC4201, IC4202 SM56V16160F8TKFM
35 7 6 5 4 6 34 20 8 CLK RAS CAS WE LDQM UDQM CKE A10 CS A0-9 A11
IDAT(0-15)0 IC4202 IDAT(16-31)0 IC4201
LRCK5 RCKIA RCKIB
RST
IC3012 TC7WZ34FU
B LRCKO 1 3 7 5 59 54 LRCKIA LRCKIB
-IN_A OUT_A -IN_B OUT_B
1 7
HRP HRM
20 29
21
SCK5 SCK6
DITRST
CN2403
HRP 7 HRM 8 MRP 10 MRM 9 LRP 3 LRM 4 SRP 6 SRM 5
LRCK2 BCK2
51 50
LRCKOB BCKOA BCKOB LRCKOA
63 62
BCK
DAC-Mid IC2302 PCM1798DB
5 DATA SCK MUTE RST IOUTR BCK LRCK IOUTR+ 18 17 2 6 SCK2 DMUTE DITRST 7 10 14 6 4 IOUTL IOUTL+ 26 25 2 6
IC2503 LT1358CS8
-IN_A OUT_A -IN_B OUT_B 1 7 MLP MLM
IC3017 TC7WZ34FU
DS0DT1A 67 DS0DT1B 66 LRCK2 LRCK3 LRCK4 7 2 5 1,3.6
IC3019 TC7WZ34FU
3,1 5 7
A
B C D
IC4151 TC74LCX541FTS1 )0
Y1 | Y8 A1 | A8
DSP0DT1A DSP0DT1B
IC2504 LT1358CS8
-IN_A OUT_A -IN_B OUT_B 1 7 MRP MRM
IC3018 TC7WZ34FU
BCK2 BCK3 BCK4 7 5 2 1,3,6
LRCK6
BDAT0-7
BDATA0-7
OE2 OE1 19 1 DS0BFEN 110 DSP0BFEN 25 26 LDATA SDATA 58 55
IC3020 TC7WZ34FU SRC IC2202 SRC4184IPAG
SDINA SDINB SDOUTA SDOUTB 64 49 SCK3 DMUTE DITRST 3,1 5 7
IC4501, IC4502 SM56V16160F8TKFM
35 7 6 5 4 36 34 20 8 CLK RAS CAS WE LDQM UDQM CKE A10 CS A0-9 A11
IDAT(0-15)1 IC4502 IDAT(16-31)1 IC4501
DAC-Low IC2303 PCM1798DB
5 7 10 14 6 4 DATA SCK MUTE RST IOUTR BCK LRCK IOUTR+ 18 17 2 6 IOUTL IOUTL+ 26 25 2 6
IC2505 LT1358CS8
-IN_A OUT_A -IN_B OUT_B 1 7 LLP LLM
OUTLLR OUTSLR
LRCK3 LRCK4 BCK3 BCK4
62 51 63 50
LRCKOA LRCKOB BCKOA BCKOB RCKIA RCKIB RST 20 29 21 SCK7 SCK8 DITRST
IC2506 LT1358CS8
-IN_A OUT_A -IN_B OUT_B 1 7 LRP LRM
LRCK7
IC3013 TC7WZ34FU
A BCKO 1 3 7 5 60 53 BCKIA BCKIB
IC3014 TC7WZ34FU
8 10 12 15 INHL INML INLL INSL B LRCKO 1 3 7 5 59 54 LRCKIA LRCKIB SCK4 DMUTE DITRST 5 7 10 14 6 4
DAC-SW IC2304 PCM1798DB
DATA SCK MUTE RST IOUTR BCK LRCK IOUTR+ 18 17 2 6 IOUTL IOUTL+ 26 25 2 6
IC2507 LT1358CS8
-IN_A OUT_A -IN_B OUT_B 1 7 SLP SLM
IC4451 TC74LCX541FTS1
Y1 | Y8 A1 | A8
IC2508 LT1358CS8
-IN_A OUT_A -IN_B OUT_B 1 7 SRP SRM
OE2 OE1 19 1 DS1BFEN 109 DSP1BFEN MUTE 64 DITRST DMUTE
LRCK8
IC4803, IC4804 SM56V16160F8TKFM
35 7 6 5 4 36 34 20 8 CLK RAS CAS WE LDQM UDQM CKE A10 CS A0-9 A11 IDAT(0-15)2 IC4804 IDAT(16-31)2 IC4803 9 11 14 16 INHR INMR INLR INSR
C
Q3002 D5V
Q3001 3
X3001 24.576MHz
IC3053 IC3001 TC7SH04FUS1 TC7WH04FU
2 5 1,3 7 5 SCK1 SCK2
1
CN2401
B33V 3.3V D5V A5V +12VR +12VL -12VR -12VL
1 2
IC3003 NJM431U
Q3003 3.3V
IC3052 TC7WH04FU
1,3 7 5 SCK5 SCK6
IC4751 TC74LCX541FTS1 2
Y1 | Y8 A1 | A8
1.65V
OE2 OE1 3 19 1 DS2BFEN 108 DSP2BFEN
Q3005 1
A
E F
3
Q3004
1 2 4 8 10 11 13 14
2
IC3004 NJM431U
RS-P90/EW5
5 6 7 8
CN801
CN102
A
A
BCKO
1 3
7 5
60 53
BCKIA BCKIB
IC2502 LT1358CS8
CN101
13
1
2
3
4
3.2 CONTROL UNIT(1/2), CONNECTOR PCB(GUIDE PAGE)
Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or "ELECTRICAL PARTS LIST".
A
A-a A-b
Large size SCH diagram
A-a 1/2
C
CONNECTOR PCB
A-a
A-b
Guide page
A-a
A-b
Detailed page
B
C
DSP UNIT Consists of DSP PCB CONNECTOR PCB
D
>
FUSE
B 1/2 CN2101
B 1/2 CN3201
E
FUSE
>
F
A 1/2 C
14 RS-P90/EW5
1 2 3 4
5
6
7
8
A-b 1/2
A 1/2 CONTROL UNIT(1/2)
A
NOTE : Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors.
Decimal points for resistor and capacitor fixed values are expressed as : 2.2 2R2 0.022 R022
B
A 2/2
The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation.
C
>
D
B 1/2 CN2401
E
F
A 1/2
RS-P90/EW5
5 6 7 8
15
F
E
B
A
D
C
16
A-a A-b
A-b 1/2
1
NOTE : Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors. Decimal points for resistor and capacitor fixed values are expressed as : 2.2 2R2 0.022 R022
1
A 1/2 CONTROL UNIT(1/2)
1
2
2
RS-P90/EW5
A 2/2
The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation.
3
3
2
4
4
3
5
6
7
8
A
B
C
A-a A-b
D
>
E
B 1/2 CN2401
F
3
4
5
6
A-b 1/2
8
RS-P90/EW5
5 6 7
17
F
E
B
A
D
C
18
A-b 1/2
A-a A-b
A-a 1/2 C
1 2 3
C
CONNECTOR PCB
1
1
2
2
RS-P90/EW5
3 4
3
4
DSP UNIT Consists of DSP PCB CONNECTOR PCB
3
Consists of DSP PCB CONNECTOR PCB
4
5
5
5
6
6
>
B 1/2 CN2101
B 1/2 CN3201
B 1/2 C
FUSE
RS-P90/EW5
A-a A-b
FUSE
>
7
7
6
8
8
A-b 1/2
A-a 1/2
E D
19
A
C
F
B
1
2
3
4
3.3 CONTROL UNIT(2/2)(GUIDE PAGE)
A
A-a 2/2
B
A 1/2
C
B 1/2
CN2402
B 1/2
CN2403
D
E
F
A 2/2
20 RS-P90/EW5
1 2 3 4
5
6
7
8
A-b 2/2
A
A 2/2 CONTROL UNIT(2/2)
B
C
D
E
F
A 2/2
RS-P90/EW5
5 6 7 8
21
1
2
3
4
A
B
C
D
E
F
A-b 2/2
22
1 2
A-a A-b
A 2/2 CONTROL UNIT(2/2)
1
2
RS-P90/EW5
3 4
5
6
7
8
A
B
C
A-a A-b
D
E
F
3
4
5
A-b 2/2
8
RS-P90/EW5
5 6 7
23
1
2
3
4
A
A-b 2/2
1
2
B
C
D
E
A-a A-b
F
A-a 2/2
24 RS-P90/EW5
1 2 3 4
CN2402
A 1/2
B 1/2
5
6
7
8
A
3
4
5
A-b 2/2
B
C
A-a A-b
D
E
CN2402
CN2403
B 1/2
F
A-a 2/2
RS-P90/EW5
5 6 7 8
25
1
2
3
4
3.4 DSP PCB(1/2)(GUIDE PAGE)
A
B-a 1/2
B 2/2 B 2/2 B 2/2 B
A 1/2
CN302
B
C
D
B 2/2
E
F
B 2/2
A 1/2 CN601
B 1/2
26 RS-P90/EW5
1 2 3 4
5
6
7
8
B-b 1/2
B 2/2 A 1/2 CN801
DSP UNIT Consists of DSP PCB CONNECTOR PCB
A
B 1/2 DSP PCB(1/2)
B
A 2/2
CN101
C
A 2/2
CN102
D
E
F
B 1/2
RS-P90/EW5
5 6 7 8
27
F
E
B
A
D
C
28
B-a B-b
B-b 1/2
DSP UNIT Consists of DSP PCB CONNECTOR PCB
1
1
B 2/2
A 1/2 CN801
1
B 1/2 DSP PCB(1/2)
2
2
2
3
RS-P90/EW5
3
A 2/2
CN101
4
4
A 2/2
CN102
3
5
6
7
8
CN102
A
B
C
B-a B-b
D
E
F
3
4
5
7 8
B-b 1/2
29
RS-P90/EW5
5 6
1
2
3
4
A
B-b 1/2
B 2/2
1
2
3
B
C
D
E
B-a B-b
B 2/2
B 2/2
F
B-a 1/2
30 RS-P90/EW5
1 2 3 4
CN302
A 1/2
5
6
7
8
A
3
4
5
B-b 1/2
B
A 1/2 CN601
C
B 2/2
B-a B-b
D
E
B 2/2
F
B-a 1/2
RS-P90/EW5
5 6 7 8
31
1
2
3
4
3.5 DSP PCB(2/2)(GUIDE PAGE)
A
B-a 2/2
B 1/2
B
B 1/2
C
B
B 1/2
D
B 1/2
B 1/2
E
F
B 2/2
32 RS-P90/EW5
1 2 3 4
5
6
7
8
B-b 2/2
B 1/2 B 1/2
A
B 2/2 DSP PCB(2/2)
B
B 1/2
B 1/2
C
B 1/2
D
B 1/2
E
DSP UNIT Consists of DSP PCB CONNECTOR PCB
F
B 2/2
RS-P90/EW5
5 6 7 8
33
F
E
B
A
D
C
34
B-a B-b
B-b 2/2
B 1/2
1
1
1
B 2/2 DSP PCB(2/2)
B 1/2
2
2
RS-P90/EW5
B 1/2
3
3
B 1/2
B 1/2
4
4
2
2
5 6 7
5
B 1/2
6
3
RS-P90/EW5
B-a B-b
7
DSP UNIT Consists of DSP PCB CONNECTOR PCB
8
8 E A D C B
B-b 2/2
35
F
1
2
3
4
A
B-b 2/2
1
B
2
B
C
D
E
B-a B-b
F
B-a 2/2
36 RS-P90/EW5
1 2 3 4
B 1/2
5
6
7
8
B1
A
2
3
B-b 2/2
B
C
B-a B-b
D
E
B 1/2
B 1/2
F
B-a 2/2
RS-P90/EW5
5 6 7 8
37
1
2
3
4
4. PCB CONNECTION DIAGRAM
4.1 CONTROL UNIT
NOTE FOR PCB DIAGRAMS
1.The parts mounted on this PCB include all necessary parts for several destination. For further information for respective destinations, be sure to check with the schematic diagram. 2.Viewpoint of PCB diagrams
A
A
CONTROL UNIT
230
B B
CN2402 CN2403
220 210
Connector
Capacitor
SIDE A
B
P.C.Board Chip Part
200 190 180 170 160 150
SIDE B
C
140 130 120 110
D
100 90 80 70 60
E
50
B B C
CN2101 CN3201
40 30
CN513
20 10
1 2 5 9 3 6 10 4 7 11
1
2 1 4 3
3 4
2
IP-BUS IN
F
Y
DIGITAL IN
SUBWOOFE LOW OUT
A
38
1 2
0
X 10
20
3
30
40
50
60
70
4
80
90
100
RS-P90/EW5
5
6
7
8
A
SIDE A
B
CN2401
B
C
D
E
1 2 4
3 6
5 8
7 2
1 4
3 6
5 8
7 3 2 1
SUBWOOFER OUT LOW OUT
MID OUT HIGH OUT
POWER SUPPLY
F
90
100
110
5
120
130
140
150
160
6
170
180
190
200
210
7
220
8
A
39
RS-P90/EW5
1
2
3
4
A
A
CONTROL UNIT
B
C
D
E
1 1
F
A
40
1 2
220
210
200
190
3
180
170
160
150
140
4
130
120
110
RS-P90/EW5
5
6
7
8
A
230 220 210 200 190 180 170 160 150
SIDE B
B
C
140 130 120 110 100 90 80 70 60 50 40 30
1 1 1 1
D
E
20 10
Y
0 120 110 100
5
F
90
80
70
60
50
6
40
30
20
10
X
7
0
8
A
41
RS-P90/EW5
1
2
3
4
4.2 DSP PCB
A
B
DSP PCB
170
A
CN101
A
CN102
160
150
B
140
130
120
110
C
100
90
80
D
70
60
50
E
40
30
A
CN302
20
A
F
CN601
10
Y
0
B
42
1
X 10
2
20
30
RS-P90/EW5
40
50
3
60
70
80
4
90
100
11
5
6
7
8
A
CN102
A
CN801
SIDE A
A
B
C
D
E
F
100
110
120
5
130
140
150
6
160
170
180
190
7
200
8
B
43
RS-P90/EW5
1
2
3
4
A
B
DSP PCB
B
C
D
E
F
B
44
1
200
190
180
170
160
150
140
130
120
110
100
RS-P90/EW5
2 3 4
5
6
7
8
SIDE B
A
170
160
150
B
140
130
120
110
C
100
90
80
D
70
60
50
40
E
30
20
10
Y
0 100 90 80 70 60 50 40 30
RS-P90/EW5
5 6 7 8
F
20
10
X
0
B
45
1
2
3
4
4.3 CONNECTOR PCB
C
A
CONNECTOR PCB
SIDE A
C
CONNECTOR PCB
SIDE B
A
40
CN651
40
B
30
30
20
C
20
10
10
Y
0
RESET
Y
20 30 30 20 10
D
X
10
X
0
E
F
C
46 RS-P90/EW5
1 2 3 4
5
6
7
8
5. ELECTRICAL PARTS LIST
NOTE: · Parts whose parts numbers are omitted are subject to being not supplied. · The part numbers shown below indicate chip components. Chip Resistor RS1/_S___J,RS1/__S___J Chip Capacitor (except for CQS.....) CKS....., CCS....., CSZS..... · The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. · Meaning of the figures and others in the parentheses in the parts list. Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding PC board. IC 301 (A, 91, 111) IC NJM2068V
Circuit Symbol and No. Part No. Circuit Symbol and No.
IC 898 IC 899 IC 921 IC 922 IC 931 IC 932 IC 933 IC 934 IC 935 Q 101 Q 102 Q 103 Q 104 Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120 122 123 124 125 304 699 700 801 802 (A,154,161) IC (A,141,143) IC (A,33,75) IC (A,71,74) IC (A,156,203) IC (A,156,215) IC (A,161,215) IC (A,161,203) IC (A,187,62) IC (A,100,47) Transistor (A,96,47) Transistor (A,119,47) Transistor (A,115,47) Transistor (A,108,47) (A,104,47) (A,128,47) (A,123,47) (A,59,114) Transistor Transistor Transistor Transistor Transistor
A
B
Part No.
TA78L12F TA78L12F S-812C33AMC-C2N S-812C33AMC-C2N S-812C50AUA-C3E S-812C50AUA-C3E S-812C50AUA-C3E S-812C50AUA-C3E TPD1018F 2SC3326 2SC3326 2SC3326 2SC3326 2SC3326 2SC3326 2SC3326 2SC3326 2SC1845 2SA992 2SC1845 2SA992 2SC1845 2SA992 2SC1845 2SA992 2SC1845 2SA992 2SC1845 2SA992 2SC1845 2SA992 2SC1845 2SA992 2SC2412K DTC144EU 2SA1162 UMZ1N UMZ1N
F
Unit Number : Unit Name : Unit Number : Unit Name :
CWN1434 Control Unit CWX3288 DSP Unit
C
A Number : CWN1434 Unit
Unit Name : Control Unit
MISCELLANEOUS
IC 101 IC 102 IC 103 IC 104 IC 105 IC 106 IC 107 IC 108 IC 109 IC 110 IC 111 IC 112 IC 113 IC 114 IC 115 IC 116 IC 150 IC 304 IC 601 IC 651 IC 701 IC 751 IC 752 IC 801 IC 851 IC 896 IC 897 (A,51,183) IC (A,91,183) IC (A,71,183) IC (A,111,183) IC (A,56,160) IC (A,46,160) (A,51,124) (A,96,160) (A,86,160) (A,91,124) IC IC IC IC IC AD7564BRS AD7564BRS AD7564BRS AD7564BRS LT1358CS8 LT1358CS8 LT1358CS8 LT1358CS8 LT1358CS8 LT1358CS8 LT1358CS8 LT1358CS8 LT1358CS8 LT1358CS8 LT1358CS8 LT1358CS8 TC7WH04FU TC7SH32FUS1 PEG169A CY7C68013A-100AXC HA12241FP S-80827CNUA-B8M TC7SET04FUS1 AN8011S AN8011S TA79L12F TA79L12F
6
D
(A,63,102) Transistor (A,99,114) Transistor (A,103,102) Transistor (A,79,114) Transistor (A,83,102) Transistor (A,119,114) Transistor (A,123,102) Transistor (A,49,114) Transistor (A,54,103) Transistor (A,89,114) Transistor (A,94,103) Transistor (A,69,114) Transistor (A,74,103) Transistor (A,109,114) Transistor (A,114,103) Transistor (A,67,23) Transistor (A,17,51) Transistor (A,20,68) Transistor (B,189,159) Transistor (B,178,176) Transistor (B,195,166) Transistor (B,177,168) Transistor (A,199,230) Transistor
(A,76,160) IC (A,66,160) IC (A,71,124) IC (A,116,160) IC (A,106,160) IC (A,111,124) IC (A,31,177) IC (A,69,27) IC (A,49,65) IC (A,29,98) IC (A,33,52) IC (A,79,76) IC (A,85,77) IC (A,171,156) IC (A,201,111) IC (A,140,110) IC (A,135,110) IC
5
E
Q 803 Q 804 Q 810
2SJ529S 2SJ529S 2SK1485
RS-P90/EW5
7 8
47
1
2
3
4
Circuit Symbol and No.
Q 811 Q 812
A
Part No.
2SK1485 2SB1708 2SC2712 2SC2712 2SC2712 UMZ1N UMZ1N 2SJ529S 2SJ529S 2SD1760F5 DTA124EUA DTC114EK 2SA1163 2SC2412K 2SC2412K DTC114EK 2SC2412K 2SC2412K 2SC2712 2SC2712 IMD2A DAP202U DAP202U DAP202U DAP202U DA204U DA204U DA204U DA204U DA204U DA204U DA204U DA204U 1SS352 DAN202U DAP202U DAN202U MA111 MA111 UDZS18(B) UDZS18(B) RB083L-20 RB060L-40 RB160M-60 RB160M-60 ERA15-02VH ERA15-02VH ERA15-02VH UDZS5R6(B) ERA15-02VH ERA15-02VH UDZS8R2(B) DAN202U UDZS6R8(B) DAN202U DAN202U LCTC1R8K2125 LCTC120K2125 LCTC1R8K2125 CTF1410
Circuit Symbol and No.
L 710 L 801 L L L L L L L L L L L L L T T 802 803 804 805 811 812 813 821 822 851 901 921 922 851 852 (A,35,47) Inductor (A,186,161) Inductor (A,197,173) (A,175,173) (B,185,119) (B,202,136) (A,175,185) (A,162,136) (A,162,110) (A,147,110) (A,153,145) (A,197,137) Inductor Inductor Inductor Inductor Inductor Coil Coil Inductor Inductor Inductor
Part No.
LCTC4R7K1608 CTH1285 CTH1285 CTH1255 CTF1379 CTF1379 CTH1255 CTH1110 CTH1110 CTF1473 CTF1473 CTH1255
(A,183,204) Transistor (A,193,217) Transistor (A,188,227) (A,189,211) (A,188,201) (B,205,138) (B,183,123) Transistor Transistor Transistor Transistor Transistor
Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q D D D D D D D D D D D D D D D D D D D D D D D D D D D D D D D D D D D L
813 814 815 851 852 853 854 911 912 931 932 941 971 972 973 974 982 983 984 101 102 103 104 105 106 107 108 109 110 111 112 301 601 651 652 653 751 777 778 801 802 851 852 901 902 903 911 912 921 943 944 972 981 982 310
(B,194,134) Transistor (B,195,121) Transistor (A,172,70) Transistor (A,169,62) Transistor (A,181,90) Transistor (A,190,89) Transistor (A,83,47) Transistor (A,57,23) Transistor (A,162,61) Transistor (A,176,87) Transistor (A,176,83) Transistor (A,84,70) Transistor (A,68,48) Transistor (A,162,86) Transistor (A,98,42) Diode (A,117,42) (A,106,42) (A,125,42) (A,59,106) (A,99,106) Diode Diode Diode Diode Network Diode Network
B
(A,170,40) Choke Coil 160 µH CTH1103 (A,32,72) Inductor LCTC4R7K2125 (A,65,75) Inductor LCTC4R7K2125 (A,180,132) Transformer CTT1111 (A,180,114) Transformer CTT1111 (A,47,79) Crystal Resonator 10 MHz CSS1613 (A,17,104) Crystal Resonator 24.000 0 MHz CSS1712 (A,210,230) Fuse 4 A CEK1288 (A,171,193) EMI Filter CCG1083 (A,194,192) EMI Filter CCG1083 (A,152,110) EMI Filter (A,154,141) EMI Filter (A,189,38) EMI Filter Fuse 4 A CCG1083 CCG1083 CCG1109 CEK1001
X 601 X 651 >FU801 EF801 EF803 EF851 EF852 EF901 >
C
RESISTORS
(A,79,106) Diode Network (A,119,106) Diode Network (A,54,109) Diode Network (A,94,109) Diode Network (A,74,109) Diode Network (A,114,109) Diode Network (A,72,23) Diode (A,45,27) Diode (B,15,29) Diode (B,21,98) Diode (A,19,48) Diode (A,82,74) Diode (A,27,49) Diode (A,27,47) Diode (A,195,166) Diode (A,177,166) Diode (A,168,111) Diode (A,168,135) Diode (A,217,38) Diode (A,178,22) Diode (A,185,51) Diode (A,163,76) Diode (A,190,51) Diode (A,85,64) Diode (A,74,48) Diode (A,85,61) Diode (A,185,86) Diode (A,88,70) Diode (A,80,59) Diode (A,75,21) Inductor (B,65,29) Inductor (A,18,81) Inductor (B,51,24) Inductor
1
R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R
101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128 129 130
(A,59,133) (A,57,133) (A,46,133) (A,44,133) (A,99,133) (A,97,133) (A,86,133) (A,84,133) (A,79,133) (A,77,133) (A,66,133) (A,64,133) (A,119,133) (A,117,133) (A,106,133) (A,104,133) (A,101,56) (A,97,56) (A,118,56) (A,114,56) (A,109,56) (A,105,56) (A,126,56) (A,122,56) (A,101,42) (A,95,42) (A,120,43) (A,114,42) (A,109,42) (A,104,42) (A,128,43)
RN1/10SE2701D RN1/10SE2701D RN1/10SE2701D RN1/10SE2701D RN1/10SE2701D RN1/10SE2701D RN1/10SE2701D RN1/10SE2701D RN1/10SE2701D RN1/10SE2701D RN1/10SE2701D RN1/10SE2701D RN1/10SE2701D RN1/10SE2701D RN1/10SE2701D RN1/10SE2701D RN1/10SE2200D RN1/10SE2200D RN1/10SE2200D RN1/10SE2200D RN1/10SE2200D RN1/10SE2200D RN1/10SE2200D RN1/10SE2200D RS1/16S222J RS1/16S222J RS1/16S222J RS1/16S222J RS1/16S222J RS1/16S222J RS1/16S222J
D
E
F
L 316 L 651 L 701
R 131
48
RS-P90/EW5
2 3 4
5
6
7
8
Circuit Symbol and No.
R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R 132 133 134 135 136 137 138 139 140 141 142 143 144 145 146 147 148 149 150 151 152 153 154 155 156 157 158 171 173 174 175 176 177 178 179 180 181 182 183 184 185 186 187 188 189 190 191 192 193 194 195 196 197 198 199 200 201 202 203 (A,122,43) (A,100,52) (A,96,52) (A,119,52) (A,115,52) (A,108,52) (A,104,52) (A,127,52) (A,123,52) (A,59,123) (A,58,128) (A,43,125) (A,48,130) (A,99,123) (A,98,128) (A,84,125) (A,88,130) (A,79,123) (A,78,128) (A,64,125) (A,68,130) (A,119,123) (A,118,128) (A,104,125) (A,108,130) (B,140,128) (B,140,126) (B,31,176) (B,101,12) (B,109,13) (B,137,14) (B,105,9) (B,118,14) (B,141,9) (A,63,110) (A,63,108) (A,55,114) (A,60,103) (B,60,108) (B,60,105) (A,59,108) (A,103,110) (A,103,108) (A,95,114) (A,100,103) (B,100,108) (B,100,105) (A,99,108) (A,83,110) (A,83,108) (A,75,114) (A,80,103) (B,80,108) (B,80,105) (A,79,108) (A,123,110) (A,123,108) (A,115,114) (A,120,103) (B,120,108)
5
Part No.
RS1/16S222J RN1/10SE2202D RN1/10SE2202D RN1/10SE2202D RN1/10SE2202D RN1/10SE2202D RN1/10SE2202D RN1/10SE2202D RN1/10SE2202D RN1/10SE5601D RN1/10SE5601D RN1/10SE5601D RN1/10SE5601D RN1/10SE5601D RN1/10SE5601D RN1/10SE5601D RN1/10SE5601D RN1/10SE5601D RN1/10SE5601D RN1/10SE5601D RN1/10SE5601D RN1/10SE5601D RN1/10SE5601D RN1/10SE5601D RN1/10SE5601D RS1/16S104J RS1/16S104J RS1/10S0R0J RS1/10S0R0J RS1/10S0R0J RS1/10S0R0J RS1/10S0R0J RS1/10S0R0J RS1/10S0R0J RN1/10SE4700D RN1/10SE4700D RN1/10SE4701D RN1/10SE4701D RN1/10SC22R0D RN1/10SC22R0D RN1/10SE1001D RN1/10SE4700D RN1/10SE4700D RN1/10SE4701D RN1/10SE4701D RN1/10SC22R0D RN1/10SC22R0D RN1/10SE1001D RN1/10SE4700D RN1/10SE4700D RN1/10SE4701D RN1/10SE4701D RN1/10SC22R0D RN1/10SC22R0D RN1/10SE1001D RN1/10SE4700D RN1/10SE4700D RN1/10SE4701D RN1/10SE4701D RN1/10SC22R0D
6
Circuit Symbol and No.
R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R 205 206 207 208 209 210 211 212 213 214 215 216 217 218 219 220 221 222 223 224 225 226 227 228 229 230 231 232 233 234 307 308 309 310 312 601 602 603 605 606 608 609 610 611 613 614 616 631 640 650 652 655 656 657 658 659 660 661 662 (B,120,105) (A,119,108) (A,50,108) (A,50,106) (A,53,114) (A,58,103) (B,50,108) (B,50,105) (A,54,111) (A,90,108) (A,90,106) (A,93,114) (A,98,103) (B,90,108) (B,90,105) (A,94,111) (A,70,108) (A,70,106) (A,73,114) (A,78,103) (B,70,108) (B,70,105) (A,74,111) (A,110,108) (A,110,106) (A,113,114) (A,118,103) (B,110,108) (B,110,105) (A,114,111) (A,71,21) (A,68,21) (A,72,24) (B,64,26) (A,67,30) (A,37,83) (A,73,79) (A,44,76) (A,36,72) (A,36,70) (A,39,64) (B,63,70) (B,59,70) (B,56,62) (A,38,62) (A,36,62) (A,22,34) (B,63,59) (A,52,54) (A,25,81) (A,40,107) (A,19,96) (A,31,84) (A,17,94) (A,29,84) (A,18,90) (A,18,89) (A,26,84) (A,34,112) (A,18,92)
7
Part No.
RN1/10SC22R0D RN1/10SE1001D RN1/10SE4700D RN1/10SE4700D RN1/10SE4701D RN1/10SE4701D RN1/10SC22R0D RN1/10SC22R0D RN1/10SE1001D RN1/10SE4700D RN1/10SE4700D RN1/10SE4701D RN1/10SE4701D RN1/10SC22R0D
B
A
RN1/10SC22R0D RN1/10SE1001D RN1/10SE4700D RN1/10SE4700D RN1/10SE4701D RN1/10SE4701D RN1/10SC22R0D RN1/10SC22R0D RN1/10SE1001D RN1/10SE4700D RN1/10SE4700D RN1/10SE4701D RN1/10SE4701D RN1/10SC22R0D RN1/10SC22R0D RN1/10SE1001D RS1/16S102J RS1/16S102J RS1/16S473J RS1/16S102J RS1/16S470J RS1/16S103J RS1/16S102J RS1/16S103J RS1/16S472J RS1/16S472J RS1/16S103J RS1/16S103J RS1/16S103J RS1/16S103J RS1/16S103J RS1/16S103J RS1/16S101J RS1/16S104J RS1/16S104J RS1/16S103J RS1/16S103J RS1/16S220J RS1/16S101J RS1/16S220J RS1/16S101J RS1/16S222J RS1/16S222J RS1/16S101J RS1/16S103J RS1/16S103J
8 D C
E
F
R 204
R 663
RS-P90/EW5
49
1
2
3
4
Circuit Symbol and No.
R R R R R R R R R R R R R R
B
Part No.
RAB4C101J RAB4C101J RAB4C101J RAB4C101J RS1/16S101J RS1/16S101J RS1/16S101J RS1/16S103J RS1/16S103J RS1/16S103J RS1/16S102J RS1/16S102J RS1/16S222J RS1/16S472J RS1/16S101J RS1/16S101J RS1/16S102J RS1/16S104J RS1/16S3901D RS1/16S1002D RS1/16S3302D RS1/16S2702D RS1/16S471J RS1/16S471J RS1/16S152J RS1/16S152J RS1/16S2001D RN1/16SE2702D RN1/16SE1002D RN1/16SE1002D RN1/16SE1002D RN1/16SE1001D RS1/16S472J RS1/16S472J RS1/16S223J RS1/16S223J RS1/16S101J RS1/16S2002D RS1/16S101J RS1/16S2202D RS1/16S224J RS1/16S224J RS1/16S1802D RS1/16S1502D RS1/16S103J RS1/16S6801D RS1/16S473J RS1/16S473J RS1/16S473J RS1/16S473J RS1/16S104J RS1/16S104J RS1/16S103J RS1/16S101J RS1/8S101J RN1/16SE2201D RS1/16S4301D RS1/16S4302D RS1/16S1501D RS1/16S2400D R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R
Circuit Symbol and No.
857 863 864 865 866 867 868 869 870 871 872 873 874 875 876 877 911 912 913 932 933 934 941 942 943 944 971 972 974 975 976 977 978 979 980 981 984 985 986 (B,164,129) (B,202,132) (B,206,132) (B,188,126) (B,184,126) (A,194,107) (A,197,118) (A,197,116) (B,195,107) (A,201,116) (A,201,106) (A,206,117) (A,201,103) (A,203,117) (A,200,102) (A,199,233) 1.5 (A,169,75) (A,172,61) (A,176,61) (A,187,89) (A,185,90) (A,190,68) (A,83,58) (A,73,50) (A,73,52) (A,88,61) (B,55,22) (A,57,20) (A,64,68) (A,89,61) (B,59,75) (A,179,83) (A,180,86) (A,181,82) (A,182,86) (B,31,60) (A,88,73) (A,64,48) (A,65,48) (A,165,87) (A,73,53) (A,78,64)
Part No.
RS1/16S3002D RS1/16S472J RS1/16S472J RS1/16S472J RS1/16S472J RS1/16S101J RS1/16S3002D RS1/16S101J RS1/16S3002D RS1/16S224J RS1/16S224J RS1/16S1802D RS1/16S1502D RS1/16S103J RS1/16S6801D CCN1150 RS1/16S223J RS1/10S102J RS1/10S102J RS1/16S473J RS1/16S103J RS1/16S102J RS1/16S473J RS1/16S103J RS1/16S473J RS1/16S683J RS1/16S683J RS1/16S683J RS1/16S333J RS1/16S104J RS1/16S333J RS1/16S473J RS1/16S104J RS1/16S473J RS1/16S473J RS1/16S333J RS1/16S103J RS1/16S103J RS1/16S473J RS1/16S102J RS1/16S473J RS1/10S101J
A
664 666 669 670 671 672 681 689 690 691 692 693 699 700 703 704 705 752 801 802 804 806 807 808 809 810 813 814 815 816 817 818 819 820 821 822 823 824 825 826 827 828 829 830 831 832 840 841 842 843 844 845 846 847 848 849 851 853 854
(A,56,39) (A,52,47) (A,48,39) (A,44,47) (A,40,40) (A,39,29) (B,42,39) (A,40,98) (A,40,96) (A,40,94) (B,63,68) (B,63,66) (A,18,64) (A,20,65) (B,36,25) (B,36,23) (A,37,50) (A,75,77) (A,162,157) (A,179,153) (A,179,156) (B,165,175) (B,187,157) (B,178,179) (B,202,141) (B,180,126) (A,207,193) (A,193,201) (A,191,201) (A,194,227) (A,191,227) (A,189,208) (B,186,166) (B,186,164) (B,183,175) (B,183,177) (A,170,164) (A,178,158) (A,176,160) (A,164,158) (A,176,156) (A,166,156) (A,177,152) (A,166,153) (B,174,154) (A,164,154) (B,190,162) (B,180,173) (B,202,134) (B,185,121) (A,197,226) (A,178,202) (A,193,214) (A,190,214) (A,192,204) (A,193,206) (A,203,102) (A,168,107) (B,167,129) (A,206,102)
1
R R R R R R R R R R
C
R R R R R R R R R R
D
R R R R R R R R R R R R R R R R R R R R R R R R R
R 987 R 989 R 991
CAPACITORS
C C C C C C C C C C C C C C C 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 (A,56,213) (A,56,205) (A,46,213) (A,46,205) (A,96,213) (A,96,205) (A,86,213) (A,86,205) (A,76,213) (A,76,205) 10 µF/50 V 10 µF/50 V 10 µF/50 V 10 µF/50 V 10 µF/50 V 10 µF/50 V 10 µF/50 V 10 µF/50 V 10 µF/50 V 10 µF/50 V CCH1543 CCH1543 CCH1543 CCH1543 CCH1543 CCH1543 CCH1543 CCH1543 CCH1543 CCH1543 CCH1543 CCH1543 CCH1543 CCH1543 CCH1543
E
F
(A,66,213) 10 µF/50 V (A,66,205) 10 µF/50 V (A,116,213) 10 µF/50 V (A,116,205) 10 µF/50 V (A,106,213) 10 µF/50 V
R 855
50
RS-P90/EW5
2 3 4
5
6
7
8
Circuit Symbol and No.
C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C 116 133 134 135 136 137 138 139 140 141 142 143 144 145 146 147 148 149 150 151 152 153 154 155 156 157 158 159 160 161 162 163 164 165 174 175 176 177 178 179 180 181 182 183 184 185 186 187 188 189 190 191 192 193 194 195 196 197 198 199 (A,106,205) 10 µF/50 V (A,56,151) 47 µF/25 V (A,56,173) 47 µF/25 V (A,56,141) 100 µF/16 V (A,46,141) 100 µF/16 V (A,46,151) (A,46,173) (A,96,151) (A,96,173) (A,96,141) (A,86,141) (A,86,151) (A,86,173) (A,76,151) (A,76,173) 47 µF/25 V 47 µF/25 V 47 µF/25 V 47 µF/25 V 100 µF/16 V 100 µF/16 V 47 µF/25 V 47 µF/25 V 47 µF/25 V 47 µF/25 V
Part No.
CCH1543 CCH1538 CCH1538 CCH1702 CCH1702 CCH1538 CCH1538 CCH1538 CCH1538 CCH1702 CCH1702 CCH1538 CCH1538 CCH1538 CCH1538 CEAT331M10 CCH1702 CCH1538 CCH1538 CCH1538 CCH1538 CEAT331M10 CCH1702 CCH1702 CCH1538 CCH1538 CCH1643 CCH1643 CCH1643 CCH1643 CCH1643 CCH1643 CCH1643 CCH1643 CCSQCH220J50 CCSQCH220J50 CKSQYB104K50 CKSQYB104K50 CKSQYB104K50 CCSQCH470J50 CCSQCH470J50 CCSQCH470J50 CCSQCH470J50 CCSQCH220J50 CCSQCH220J50 CKSQYB104K50 CKSQYB104K50 CKSQYB104K50 CKSQYB104K50 CCSQCH220J50 CKSQYB104K50 CEAT331M10 CCSQCH470J50 CKSQYB104K50 CCSQCH470J50 CCSQCH470J50 CKSQYB104K50 CCSQCH220J50 CKSQYB104K50 CCSQCH220J50 C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C
Circuit Symbol and No.
200 201 202 203 204 205 206 207 208 209 210 211 212 213 214 215 216 217 218 219 220 221 222 223 224 225 226 227 228 229 230 231 232 233 234 235 236 237 238 239 240 241 242 249 250 251 252 253 254 255 256 257 264 265 271 272 273 274 275 276 (B,86,164) (A,81,165) (B,76,164) (A,76,165) (A,76,141) 100 µF/16 V (B,71,128) (B,74,179) (A,77,123) (B,71,121) (A,78,126) (A,66,125) (A,68,128) (A,71,165) (A,66,165) (B,66,157) (B,66,164) (B,116,157) (B,116,164) (A,116,165) (B,114,179) (A,117,123) (A,118,126) (B,111,128) (A,106,125) (B,111,121) (A,108,128) (A,111,165) (A,106,165) (B,106,157) (B,106,164) (A,27,178) (A,165,83) (A,98,126) (B,51,121) (B,56,157) (A,121,165) (A,101,165) (B,76,157) (A,56,195) (B,54,181) (B,94,181) (B,74,181) (B,114,181) (A,147,124) (B,143,13) (B,121,17) (B,147,13) (B,129,13) (B,107,20) (B,89,13) (B,114,19) (B,93,18) (A,149,21) (A,159,21) (A,80,93) (A,82,93) (A,84,93) (A,89,93) (A,91,93) (A,93,93)
Part No.
CKSQYB104K50 CCSQCH220J50 CKSQYB104K50 CCSQCH220J50 CCH1702 CKSQYB104K50 CKSQYB104K50 CCSQCH470J50 CKSQYB104K50 CCSQCH470J50 CCSQCH470J50 CCSQCH470J50 CCSQCH220J50 CCSQCH220J50 CKSQYB104K50 CKSQYB104K50 CKSQYB104K50 CKSQYB104K50 CCSQCH220J50 CKSQYB104K50 CCSQCH470J50 CCSQCH470J50 CKSQYB104K50 CCSQCH470J50 CKSQYB104K50
C
A
B
(A,76,195) (A,66,141) 100 µF/16 V (A,66,151) 47 µF/25 V (A,66,173) 47 µF/25 V (A,116,151) 47 µF/25 V (A,116,173) (A,116,195) (A,116,141) (A,106,141) (A,106,151) 47 µF/25 V 100 µF/16 V 100 µF/16 V 47 µF/25 V
(A,106,173) 47 µF/25 V (A,98,64) 47 µF/25 V (A,98,74) 47 µF/25 V (A,117,64) 47 µF/25 V (A,117,74) 47 µF/25 V (A,107,64) (A,107,74) (A,126,64) (A,126,74) (A,61,165) (A,56,165) (B,56,164) (B,51,128) (B,54,179) (A,57,123) (A,58,126) (A,45,125) (A,48,128) (A,51,165) (A,46,165) (B,46,157) (B,46,164) (B,96,157) (B,96,164) (A,96,165) (B,94,179) (A,96,195) (A,97,123) (B,91,128) (A,88,128) (A,86,125) (B,91,121) (A,86,165) (B,86,157) (A,91,165) 47 µF/25 V 47 µF/25 V 47 µF/25 V 47 µF/25 V
CCSQCH470J50 CCSQCH220J50 CCSQCH220J50 CKSQYB104K50 CKSQYB104K50 CKSRYB104K16 CKSRYB472K50 CCSQCH470J50 CKSQYB104K50 CKSQYB104K50 CCSQCH220J50 CCSQCH220J50 CKSQYB104K50 CEAT331M10 CCSQCH102J50 CCSQCH102J50 CCSQCH102J50 CCSQCH102J50 CEJQ4R7M35 CCSQCH102J50 CCSQCH102J50 CCSQCH102J50 CCSQCH102J50 CCSQCH102J50 CCSQCH102J50 CCSQCH102J50 CCSQCH102J50 CCSQCH390J50 CCSQCH390J50 CCSQCH390J50 CCSQCH101J50 CCSQCH102J50 CCSQCH390J50 CCSQCH101J50 CCSQCH102J50
E D
F
RS-P90/EW5
5 6 7 8
51
1
2
3
4
Circuit Symbol and No.
C C C C C C C C C C C C C C C C C C C C C C C C C
C
Part No.
CKSRYB104K50 CKSRYB104K50 CKSRYB104K50 CCSRCH220J50 CKSRYB104K50 CEAL4R7M35 CKSRYB104K50 CCSRCH120J50 CCSRCH120J50 CKSRYB104K16 CCSRCH101J50 CEJQ4R7M35 CCSRCH102J50 CCSRCH120J50 CCSRCH120J50 CKSRYB105K10 CKSRYB104K16 CKSRYB104K16 CCSRCH102J50 CKSRYB103K50 CKSRYB104K16 CKSRYB104K50 CCSRCH102J50 CCSRCH102J50 CKSRYB104K16 CKSRYB103K50 CKSRYB104K16 CKSRYB104K50 CEHAZL680M16 CEHAZL680M16 CCH1631(P35) CKSRYB104K50 CKSRYB104K50 CEHAZL331M6R3 CEHAZL680M16 CEHAZL680M16 CCH1184 CCSRCH471J50 CKSRYB104K50 CKSRYB105K10 CKSRYB105K10 CEAL4R7M35 CEAL4R7M35 CCSRCH101J50 CKSRYB104K16 CKSRYB104K16 CEHAZA221M6R3 CCH1631(P35) CCH1631(P35) CCH1631(P35) CCH1631(P35) CKSRYB104K50 CEAT470M35 CEHAZL680M16 CEHAZL680M16 CKSRYB104K50 CKSRYB104K50 CEHAZL101M25 CEHAZL101M25 CKSRYB104K50 C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C
Circuit Symbol and No.
859 860 863 864 865 866 867 868 869 870 871 872 877 878 879 880 881 887 888 889 890 894 895 896 897 898 899 901 902 903 911 912 913 914 921 922 923 926 927 928 929 930 931 932 933 934 935 936 937 938 939 940 941 942 943 944 945 946 971 981 (A,165,127) (A,166,119) (B,206,130) (B,184,128) (B,193,99) (B,195,104) (A,199,119) (A,201,117) (A,201,105) (A,210,111) (A,210,105) (A,206,116) (A,200,191) (B,210,108) (A,209,102) (A,193,102) (A,152,104) (A,155,170) 100 µF/16 V (A,140,165) 100 µF/16 V (A,140,147) (A,137,142) (B,153,170) (A,140,119) 100 µF/16 V (B,140,117) (A,140,102) 100 µF/16 V (A,140,130) 100 µF/16 V (A,133,114) (B,194,30) (A,208,27) 4 700 µF/16 V (A,176,19) (A,23,160) 0.47 F/5.5 V (A,159,76) (A,165,76) (A,182,71) (A,27,75) (A,31,69) (A,35,78) (A,64,73) (A,70,63) (A,70,69) (A,68,74) (A,71,78) (A,183,61) (A,181,61) (B,145,203) (A,147,205) 22 µF/16 V (A,156,208) (A,155,189) 47 µF/25 V (B,145,214) (A,147,211) 22 µF/16 V (B,169,213) (A,204,79) 3 300 µF/16 V (A,85,52) (A,176,209) 47 µF/25 V (B,169,205) (A,169,203) 100 µF/16 V (A,169,215) 100 µF/16 V (B,176,211) (B,56,24) (A,79,52)
Part No.
CEHAZL560M50 CEHAZL560M50 CCSRCH331J50 CCSRCH331J50 CKSRYB104K50 CKSQYB475K10 CKSQYB475K10 CKSRYB473K50 CKSRYB473K50 CEAL4R7M35 CEJQ330M10 CCSRCH101J50 CEHAZA221M6R3 CKSRYB103K50 CKSRYB103K50 CEAT470M35 CEHAZL101M25 CCH1631(P35) CCH1631(P35) CKSRYB104K50 CKSRYB104K50 CKSRYB104K50 CCH1631(P35) CKSRYB104K50 CCH1631(P35) CCH1631(P35) CKSRYB104K50 CKSRYB104K50 CCH1694 CCSRCH102J50 CCL1016 CEJQ101M6R3 CKSRYB473K50 CEAT470M35 CEAT470M10 CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 CEJQ4R7M35 CEAT470M10 CKSRYB104K16 CKSRYB104K16 CCSRCH101J50 CKSRYB103K50 CKSRYB104K16 CCH1577 CKSRYB104K50 CCH1544 CKSRYB104K16 CCH1577 CKSRYB104K16 CCH1583 CEAT470M35 CCH1544 CKSRYB104K16 CCH1702 CCH1702 CKSRYB104K50 CCSCH101J50 CEAT470M35
A
316 317 318 324 328 333 351 601 602 603 604 605 607 651 652 653 660 661 666 670 671 701 704 705 706 710 751 752 801 802 803 804 805 806 807 808 809 812 814 815 816 819 820 821 830 831 840 845 846 847 848 849 850 851 852 853 854 855 856 857
(A,79,17) (A,79,19) (B,70,27) (A,68,36) (B,70,25) (A,80,24) (A,79,21) (A,49,76) (A,47,76) (A,32,69) (B,47,75) (A,32,64) (A,75,80) (A,18,108) (A,18,100) (A,40,106) (A,20,84) (B,47,73) (A,64,70) (A,15,31) (A,21,80) (A,57,13) (B,27,47) (B,27,49) (A,28,51) (A,28,52) (A,84,74) (A,85,79) (A,185,172) (A,188,150) (A,130,218) 100 µF/16 V (B,192,181) (A,175,193) (A,200,183) (A,165,189) (A,192,183) (A,164,178) 1 000 µF/10 V (B,186,162) (B,164,162) (A,164,160) (A,178,160) (A,168,147) (A,173,147) (A,177,151) (B,188,226) (A,193,210) (A,185,216) (A,141,218) 100 µF/16 V (A,141,230) 100 µF/16 V (A,155,152) 100 µF/16 V (A,130,230) 100 µF/16 V (B,140,104) (A,164,164) (A,195,128) (A,202,128) (A,154,131) (A,154,114) (A,158,127) (A,158,119) (B,165,124)
B
C C C C C C C C C C
D
C C C C C C C C C C
E
C C C C C C C C C C C C C C C
F
52
RS-P90/EW5
1 2 3 4
5
6
7
8
Circuit Symbol and No.
C 991 C 992 (A,77,69) (A,152,76)
Part No.
CEAT470M10 CEAT470M10
Circuit Symbol and No.
IC 4804 IC 4901 IC 4902 IC 4951 IC 4952 IC 4953 Q 3001 Q 3002 Q 3003 Q 3004 Q D D D D 3005 2201 2202 2203 2204 2205 2206 2251 2252 2253 2254 2255 2256 2257 2258 2301 2303 2305 2307 2601 3201 3202 4001 4002 4301 4302 4601 4602 2001 2201 2202 2301 2302 2303 2304 2305 2306 2307 2308 2471 2472 2473 3002 3003 3006 3009 3010 3011 3012 3013 (A,198,110) IC (A,120,80) IC (A,114,79) IC (A,13,21) IC (A,11,15) IC (A,15,46) IC (A,118,95) Transistor (A,134,102) Transistor (A,119,111) Transistor (A,134,97) Transistor (A,123,113) Transistor (B,74,89) Diode Network (B,61,104) Diode Network (B,62,100) Diode Network (B,68,89) Diode Network (A,65,102) Diode Network (A,69,105) Diode Network (A,53,105) Diode Network (A,56,102) Diode Network (B,55,89) Diode Network (B,37,89) (B,44,89) (B,49,89) (B,58,95) (A,52,92) Diode Network Diode Network Diode Network Diode Network Diode Network
Part No.
MSM56V16160F8TKFM TC74VHC541FTS1 TC7SZU04FU TC7WZ34FU TC74VHC08FTS1
TC7SH04FUS1 2SC4226 2SD1767 2SD1767 2SC2412K 2SC2412K DA204U DA204U DA204U DA204U DA204U DA204U DA204U DA204U DA204U DA204U DA204U DA204U DA204U DA204U
C
A
DSP Unit Consists of DSP PCB Connecter PCB
BC : CWX3288 Unit Number
Unit Name : DSP Unit
MISCELLANEOUS
IC 2001 IC 2201 IC 2202 IC 2301 IC 2302 IC 2303 IC 2304 IC 2501 IC 2502 IC 2503 IC 2504 IC 2505 IC 2506 IC 2507 IC 2508 IC 3001 IC 3003 IC 3004 IC 3005 IC 3008 IC 3011 IC 3012 IC 3013 IC 3014 IC 3015 IC 3016 IC 3017 IC 3018 IC 3019 IC 3020 IC 3052 IC 3053 IC 3201 IC 3202 IC 4001 IC 4151 IC 4201 IC 4202 IC 4301 IC 4451 IC 4501 IC 4502 IC 4601 IC 4751 IC 4803 (A,22,62) IC (A,78,99) IC (A,43,99) IC (A,114,139) IC (A,83,139) IC (A,52,139) IC (A,21,139) IC (A,107,152) IC (A,122,152) IC (A,76,152) IC (A,91,152) (A,45,152) (A,60,152) (A,14,152) (A,29,152) IC IC IC IC IC DIR1703ES1 SRC4184IPAG SRC4184IPAG PCM1798DB PCM1798DB PCM1798DB PCM1798DB LT1358CS8 LT1358CS8 LT1358CS8 LT1358CS8 LT1358CS8 LT1358CS8 LT1358CS8 LT1358CS8 TC7WH04FU NJM431U NJM431U TC7WZ34FU TC7WZ34FU TC7WZ34FU TC7WZ34FU TC7WZ34FU TC7WZ34FU TC7WZ34FU TC7WZ34FU TC7WZ34FU TC7WZ34FU TC7WZ34FU TC7WZ34FU TC7WH04FU TC7SH04FUS1 EPF6016ATI144-3S1 TC7SH32FUS1 ADSP-21065LCS240S1 TC74LCX541FTS1 MSM56V16160F8TKFM MSM56V16160F8TKFM ADSP-21065LCS240S1 TC74LCX541FTS1
B
D D D D D D D D D D D D D D D D D D D D D D D L L L L L L L L L L L L L L L L L L L L L L
(A,107,129) Diode Network (A,76,129) Diode Network (A,45,129) Diode Network (A,14,129) Diode Network (A,107,81) LED (B,53,45) Diode Network (B,50,49) Diode Network (B,109,67) Diode Network (B,105,65) Diode Network (B,168,66) Diode Network
DA204U DA204U DA204U DA204U NSPW315BS-0359 DA204U DA204U DA204U DA204U DA204U
D
(A,105,114) IC (A,121,103) IC (A,127,110) IC (A,44,80) IC (A,44,74) IC (A,17,88) IC (A,17,104) IC (A,17,94) IC (A,17,99) IC (A,44,64) IC (A,44,69) IC (A,60,98) IC (A,60,91) IC (A,69,114) IC (A,61,114) IC (A,93,99) IC (A,99,100) IC (A,50,33) IC (A,29,23) IC (A,98,50) IC (A,126,11) IC (A,132,43) IC (A,94,19) IC (A,166,50) IC (A,191,11) IC (A,198,43) IC (A,162,19) IC (A,166,99) IC (A,196,92) IC (A,177,132) IC
(B,174,66) Diode Network DA204U (B,160,83) Diode Network DA204U (B,154,83) Diode Network DA204U (B,20,75) Chip Ferrite Bead CTF1399 (A,85,111) Chip Ferrite Bead CTF1399 (A,41,110) Chip Ferrite Bead CTF1399 (A,129,144) Chip Ferrite Bead CTF1399 (B,120,130) Chip Ferrite Bead CTF1399 (A,98,144) Chip Ferrite Bead CTF1399 (B,88,130) Chip Ferrite Bead CTF1399 (A,67,144) Chip Ferrite Bead CTF1399 (B,57,130) Chip Ferrite Bead CTF1399 (A,36,144) Chip Ferrite Bead CTF1399 (B,26,130) Chip Ferrite Bead CTF1399 (A,172,164) Inductor CTF1650 (A,178,165) Inductor CTF1453 (A,156,148) Inductor CTF1453 (A,100,105) Chip Ferrite Bead CTF1399 (A,53,81) Chip Ferrite Bead CTF1399 (A,53,75) Chip Ferrite Bead CTF1399 (A,25,90) Chip Ferrite Bead CTF1399 (A,25,105) Chip Ferrite Bead CTF1399 (A,25,95) Chip Ferrite Bead CTF1399 (A,25,100) Chip Ferrite Bead CTF1399 (A,53,65) Chip Ferrite Bead CTF1399
E
MSM56V16160F8TKFM MSM56V16160F8TKFM ADSP-21065LCS240S1 TC74LCX541FTS1 MSM56V16160F8TKFM
F
RS-P90/EW5
5 6 7 8
53
1
2
3
4
Circuit Symbol and No.
L L L L L L L L L L L L L L L L L L L L 3014 3015 3016 3017 3018 3019 3202 4001 4151 4201 4202 4301 4451 4501 4502 4601 4751 4802 4803 4901
Part No.
R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R
Circuit Symbol and No.
2219 2221 2240 2241 2242 2251 2252 2253 2254 2255 2256 2257 2258 2259 2260 2262 2263 2265 2266 2267 2268 2270 2271 2274 2280 2281 2282 2301 2302 2303 2304 2311 2312 2313 2314 2315 2316 2317 2318 2319 2320 2321 2322 2331 2332 2334 2335 2336 2337 2338 2339 2471 2475 2501 2502 2503 2504 2505 2506 2507
3
Part No.
RS1/16S103J RS1/16S0R0J RS1/16S103J RS1/16S0R0J RS1/16S0R0J RN1/16SC47R0D RN1/16SC47R0D RN1/16SC47R0D RN1/16SC47R0D RN1/16SC47R0D RN1/16SC47R0D RN1/16SC47R0D RN1/16SC47R0D RN1/16SC47R0D RN1/16SC47R0D RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16S101J RS1/16S103J RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16S103J RS1/16S0R0J RS1/16S0R0J RN1/10SE1002D RN1/10SE1002D RN1/10SE1002D RN1/10SE1002D RN1/16SC47R0D RN1/16SC47R0D RS1/10S0R0J RN1/16SC47R0D RN1/16SC47R0D RS1/10S0R0J RN1/16SC47R0D RN1/16SC47R0D RS1/10S0R0J RN1/16SC47R0D RN1/16SC47R0D RS1/10S0R0J RS1/16S101J RS1/16S101J RS1/16S101J RS1/16S101J RS1/16S101J RS1/16S101J RS1/16S101J RS1/16S101J RS1/16S0R0J RS1/10S0R0J RN1/10SE1801D RN1/10SE1801D RN1/10SE1801D RN1/10SE1801D RN1/10SE1801D RN1/10SE1801D RN1/10SE1801D
4
A
(A,53,70) Chip Ferrite Bead CTF1399 (A,62,102) Chip Ferrite Bead CTF1399 (A,62,95) Chip Ferrite Bead CTF1399 (A,65,116) Chip Ferrite Bead CTF1399 (A,57,116) Chip Ferrite Bead CTF1399 (A,68,93) Inductor CTF1386 (B,39,58) Inductor CTF1488 (B,84,76) Inductor CTF1488 (A,133,17) Chip Ferrite Bead CTF1399 (A,130,58) Chip Ferrite Bead CTF1399 (B,109,19) (B,132,67) (B,197,16) (B,198,61) (B,182,18) Chip Ferrite Bead CTF1399 Inductor CTF1488 Chip Ferrite Bead CTF1399 Chip Ferrite Bead CTF1399 Chip Ferrite Bead CTF1399
(A,81,89) (B,76,94) (A,87,100) (A,78,107) (B,79,94) (A,55,105) (A,54,102) (B,52,88) (B,35,88) (B,41,88) (B,46,88) (B,55,95) (A,49,92) (A,53,98) (A,53,99) (A,43,90) (A,38,90) (B,38,96) (A,34,101) (A,34,100) (B,37,100) (B,39,104) (B,41,104) (B,45,104) (A,34,97) (A,44,90) (B,43,104) (B,115,143) (B,84,143) (B,53,143) (B,22,144) (A,109,129) (A,110,129) (B,111,130) (A,78,129) (A,79,129) (B,81,130) (A,47,129) (A,48,129) (B,50,130) (A,16,129) (A,17,129) (B,19,130) (A,118,125) (A,119,125) (A,87,125) (A,88,125) (A,56,125) (A,57,125) (A,25,125) (A,26,125) (A,180,165) (A,33,79) (A,102,153) (A,112,151) (A,117,153) (A,126,151) (A,71,153) (A,81,151) (A,86,153)
B
(B,138,83) Inductor CTF1488 (B,197,87) Chip Ferrite Bead CTF1399 (B,188,134) Chip Ferrite Bead CTF1399 (B,199,134) Chip Ferrite Bead CTF1399 (B,127,83) Chip Ferrite Bead CTF1399 (A,11,52) Chip Ferrite Bead CTF1399 (A,109,93) Trimmer CCL1048 (A,35,63) Crystal Resonator 11.289 6 MHz CSS1610 (A,114,97) Crystal Resonator 24.576 MHz CSS1611 (A,117,87) Crystal Resonator 30.0 MHz CSS1612 (A,7,6) Switch(RESET) (A,133,151) EMI Filter (A,164,153) EMI Filter CSG1082 CCG1030 CCG1030
L 4951 TC3001 X 2001 X 3001 X 4901
C
S 401 EF2401 EF2407
RESISTORS
R R R R R
D
2001 2002 2003 2004 2005 2006 2007 2008 2013 2014 2015 2016 2017 2018 2019 2201 2202 2203 2204 2205 2206 2207 2208 2210 2211 2213 2214 2215 2216 2218
(A,21,54) (A,14,63) (A,14,58) (A,26,54) (A,24,71) (B,29,66) (B,29,71) (B,31,71) (A,30,60) (A,24,54) (B,20,57) (A,22,54) (A,14,60) (A,24,69) (A,30,63) (B,71,89) (B,63,105) (B,60,100) (B,65,89) (A,67,102) (A,67,105) (A,68,99) (A,68,98) (B,79,103) (B,81,103) (B,84,103) (A,87,96) (A,87,98) (B,83,94) (B,81,94)
RS1/16S101J RN1/10SE1201D RS1/16S103J RAB4CQ101J RS1/16S103J RN1/16SC47R0D RN1/16SC47R0D RN1/16SC47R0D RS1/16S105J RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RN1/16SE3301D RN1/16SC47R0D RN1/16SC47R0D RN1/16SC47R0D RN1/16SC47R0D RN1/16SC47R0D RN1/16SC47R0D RN1/16SC47R0D RN1/16SC47R0D RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16S101J RS1/16S103J RS1/16S0R0J RS1/16S0R0J
R R R R R R R R R R
E
R R R R R R R R R R R R R R R
F
54
RS-P90/EW5
1 2
5
6
7
8
Circuit Symbol and No.
R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R 2508 2509 2510 2511 2512 2513 2514 2515 2516 2551 2552 2553 2554 2555 2556 2557 2558 2559 2560 2561 2562 2563 2564 2565 2566 2601 3001 3003 3004 3005 3006 3007 3008 3009 3010 3011 3012 3013 3014 3015 3016 3017 3018 3019 3020 3021 3022 3024 3026 3028 3029 3031 3032 3034 3035 3036 3037 3039 3040 3041 (A,95,151) (A,40,153) (A,50,151) (A,55,153) (A,64,151) (A,9,153) (A,19,151) (A,24,153) (A,33,151) (A,102,157) (A,112,155) (A,119,157) (A,127,155) (A,71,157) (A,82,155) (A,88,157) (A,96,155) (A,40,157) (A,50,155) (A,57,157) (A,65,155) (A,9,157) (A,19,155) (A,