Text preview for : DEH-P1Y,+DEH-P80MP,+DEH-P8MP.pdf part of Pioneer DEH-P1Y,+DEH-P80MP,+DEH-P8MP Service Manual - DEH-P1Y,+DEH-P80MP,+DEH-P8MP
Back to : DEH-P1Y,+DEH-P80MP,+DEH-P | Home
ORDER NO.
CRT3219
DEH-P8MP/XN/UC
MULTI-CD CONTROL HIGH POWER CD/MP3/WMA PLAYER WITH FM/AM TUNER
DEH-P8MP
DEH-P80MP/XN/UC DEH-P1Y/XN/ES
Model No.
CX-3098
/XN/UC
This service manual should be used together with the following manual(s):
Order No.
CRT3179
Mech.Module
S10WMAcode2
Remarks
CD Mech. Module:Circuit Description, Mech. Description, Disassembly
For details, refer to "Important symbols for good services".
PIONEER CORPORATION
4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2004
K-ZZD.MAY 2004 printed in Japan
1
2
3
4
SAFETY INFORMATION
CAUTION
A
This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer the repair to a qualified service technician. WARNING This product contains lead in solder and certain electrical parts contain chemicals which are known to the state of California to cause cancer, birth defects or other reproductive harm. Health & Safety Code Section 25249.6 - Proposition 65
B
- Service Precaution
1. You should conform to the regulations governing the 3. To protect the pickup unit from electrostatic discharge product (safety, radio and noise, and other regulations), during servicing, take an appropriate treatment and should keep the safety during servicing by following (shorting-solder) by referring to "the DISASSEMBLY" the safety instructions described in this manual. on page 63. 2. Before disassembling the unit, be sure to turn off 4. After replacing the pickup unit, be sure to check the the power. Unplugging and plugging the connectors grating. (See page 59.) during power-on mode may damage the ICs inside the unit.
C
[ Important symbols for good services ]
In this manual, the symbols shown-below indicate that adjustments, settings or cleaning should be made securely. When you find the procedures bearing any of the symbols, be sure to fulfill them:
1. Product safety
You should conform to the regulations governing the product (safety, radio and noise, and other regulations), and should keep the safety during servicing by following the safety instructions described in this manual.
2. Adjustments
To keep the original performances of the product, optimum adjustments or specification confirmation is indispensable. In accordance with the procedures or instructions described in this manual, adjustments should be performed.
D
3. Cleaning
For optical pickups, tape-deck heads, lenses and mirrors used in projection monitors, and other parts requiring cleaning, proper cleaning should be performed to restore their performances.
4. Shipping mode and shipping screws
To protect the product from damages or failures that may be caused during transit, the shipping mode should be set or the shipping screws should be installed before shipping out in accordance with this manual, if necessary.
E
5. Lubricants, glues, and replacement parts
Appropriately applying grease or glue can maintain the product performances. But improper lubrication or applying glue may lead to failures or troubles in the product. By following the instructions in this manual, be sure to apply the prescribed grease or glue to proper portions by the appropriate amount.For replacement parts or tools, the prescribed ones should be used.
F
2
DEH-P8MP/XN/UC
1 2 3 4
5
6
7
8
CONTENTS
SAFETY INFORMATION......................................................................................................................................2 1. SPECIFICATIONS .............................................................................................................................................4 2. EXPLODED VIEWS AND PARTS LIST.............................................................................................................8 2.1 PACKING(DEH-P8MP/XN/UC,DEH-P80MP/XN/UC) .................................................................................8 2.2 PACKING(DEH-P1Y/XN/ES) ....................................................................................................................10 2.3 EXTERIOR ...............................................................................................................................................12 2.4 CD MECHANISM MODULE .....................................................................................................................16 3. BLOCK DIAGRAM AND SCHEMATIC DIAGRAM ..........................................................................................18 3.1 BLOCK DIAGRAM....................................................................................................................................18 3.2 OVERALL CONNECTION DIAGRAM(GUIDE PAGE) ..............................................................................20 3.3 KEYBOARD UNIT ....................................................................................................................................26 3.4 CD MECHANISM MODULE(GUIDE PAGE) .............................................................................................28 4. PCB CONNECTION DIAGRAM ......................................................................................................................38 4.1 TUNER AMP UNIT ...................................................................................................................................38 4.2 SWITCH UNIT ..........................................................................................................................................42 4.3 KEYBOARD UNIT ....................................................................................................................................43 4.4 CD MECHANISM MODULE .....................................................................................................................44 5. ELECTRICAL PARTS LIST .............................................................................................................................46 6. ADJUSTMENT ................................................................................................................................................55 6.1 CONNECTION DIAGRAM........................................................................................................................55 6.2 OEL UNIT ADJUSTMENT ........................................................................................................................56 6.3 CD ADJUSTMENT ...................................................................................................................................57 6.4 CHECKING THE GRATING AFTER CHANGING THE PICKUP UNIT.....................................................59 6.5 ERROR MODE .........................................................................................................................................61 6.6 OEL SCREENSAVER STUDIO LKA TO LKD APPLICATION ..................................................................62 6.7 SYSTEM MICROCOMPUTER TEST PROGRAM ....................................................................................62 7. GENERAL INFORMATION .............................................................................................................................63 7.1 DIAGNOSIS..............................................................................................................................................63 7.1.1 DISASSEMBLY......................................................................................................................................63 7.1.2 CONNECTOR FUNCTION DESCRIPTION ..........................................................................................68 7.2 IC ..............................................................................................................................................................69 7.3 EXPLANATION .........................................................................................................................................81 7.3.1 OPERATIONAL FLOW CHART .............................................................................................................81 7.3.2 CIRCUIT DESCRIPTIONS ....................................................................................................................82 7.4 CLEANING ...............................................................................................................................................84 8. OPERATIONS .................................................................................................................................................85
A
B
C
D
E
F
DEH-P8MP/XN/UC
5 6 7 8
3
1
2
3
4
1. SPECIFICATIONS
A
B
C
D
E
F
4
DEH-P8MP/XN/UC
1 2 3 4
5
6
7
8
A
B
C
D
E
F
DEH-P8MP/XN/UC
5 6 7 8
5
1
2
3
4
A
B
C
D
E
F
6
DEH-P8MP/XN/UC
1 2 3 4
5
6
7
8
A
B
C
D
E
F
DEH-P8MP/XN/UC
5 6 7 8
7
1
2
3
4
2. EXPLODED VIEWS AND PARTS LIST
NOTES : · Parts marked by " * " are generally unavailable because they are not in our Master Spare Parts List.
A
· Screw adjacent to mark on the product are used for disassembly. · For the applying amount of lobricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.)
2.1 PACKING(DEH-P8MP/XN/UC,DEH-P80MP/XN/UC)
9 12 11 8
B
26 13 4 16
C
D
19 24 28
E
21
F
8
1
"
5 10 6 15 14 3
7
17 1 27 2
20
25 18
23
24
23 22
DEH-P8MP/XN/UC
2 3 4
5
6
7
8
(1) PACKING(DEH-P8MP/XN/UC,DEH-P80MP/XN/UC) SECTION PARTS LIST
Mark No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 Description Cord Assy Cord Assy Accessory Assy Spring Screw Assy Screw Bolt(M5x16) Polyethylene Bag Screw Screw Nut Screw Polyethylene Bag Handle Strap Part No. CDE7612 CDE7482 CEA4302 CBH1650 CEA4303 CBA1650 CBA1783 CEG-127 CRZ50P090FTC JPZ20P060FZK NF50FTC TRZ50P080FTC CEG-158 CNC5395 CNC5402 CNV3930 CEG1116 Mark No. Description Part No. See Contrast table(2) See Contrast table(2) CRP1307 CRP1310 See Contrast table(2) See Contrast table(2) CEG1173 See Contrast table(2) CHA3258 See Contrast table(2) CHP2546 CHP2539 CHP2538 CHP2541 CXC2665 CXC3572 CRP1311 17-2 Owner's Manual 17-3 Installation Manual 17-4 Caution Card 17-5 17-6 17-7 18 19 20 21 22 23 24 25 26 27 28 Caution Card Warranty Card Card Polyethylene Bag Carton Sub Carton Contain Box Protector Protector Protector Protector Remote Control Unit Case Assy Caution Card
*
A
* *
*
B
*
16 Bush 17-1 Polyethylene Bag
*
(2) CONTRAST TABLE DEH-P8MP/XN/UC and DEH-P80MP/XN/UC are constructed the same except for the following:
Mark NO
17-2 17-3 17-6 17-7 19 21
Description
Owner's Manual Installation Manual Warranty Card Card Carton Contain Box
DEH-P8MP/XN/UC
CRD3844 CRD3845 CRY1070 Not used CHG5212 CHL5212
DEH-P80MP/XN/UC
CRD3846 CRD3847 Not used ARY1048 CHG5211 CHL5211
C
* *
Owner's Manual,Installation Manual
Part No.
CRD3844 CRD3845 CRD3846 CRD3847 English, French English, French English, French English, French
Language
D
E
F
DEH-P8MP/XN/UC
5 6 7 8
9
1
2
3
4
2.2 PACKING(DEH-P1Y/XN/ES)
9
A
5 6 3 14
12 8
26 13 4 16
B
17 1 27 2
C
20
19 24
D
28
25 18
23
E
24
23 22
21
F
10
DEH-P8MP/XN/UC
1 2 3 4
5
6
7
8
PACKING(DEH-P1Y/XN/ES) SECTION PARTS LIST
Mark No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 Description Cord Assy Cord Assy Accessory Assy Spring Screw Assy Screw ····· Polyethylene Bag Screw ····· ····· Screw Polyethylene Bag Handle ····· Part No. CDE7612 CDE7482 CEA4301 CBH1650 CEA3849 CBA1650 CEG-127 CRZ50P090FTC Mark No. Description Part No. CRD3848 CRD3849 CRD3850 CRP1307 CRP1310 CEG-162 CHG5210 CHA3258 CHL5210 CHP2546 CHP2539 CHP2538 CHP2541 CXC2665 CXC3572 CRP1311 17-2 Owner's Manual 17-3 Owner's Manual 17-4 Installation Manual * 17-5 17-6 18 19 20 21 22 23 24 25 26 27 28 Caution Card Caution Card Polyethylene Bag Carton Sub Carton Contain Box Protector Protector Protector Protector Remote Control Unit Case Assy Caution Card
A
*
B
*
TRZ50P080FTC CEG-158 CNC5395
16 Bush 17-1 Polyethylene Bag
CNV3930 CEG1116
*
Owner's Manual,Installation Manual
Part No.
CRD3848 CRD3849 CRD3850 English, Spanish, Portuguese(B) Traditional Chinese, Arabic English, Spanish, Portuguese(B), Traditional Chinese, Arabic
Language
C
D
E
F
DEH-P8MP/XN/UC
5 6 7 8
11
1
2
3
4
2.3 EXTERIOR
A
B
C
D
E
F
12
DEH-P8MP/XN/UC
1 2 3 4
5
6
7
8
(1) EXTERIOR SECTION PARTS LIST
Mark No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 Description Screw Screw Screw(M2x2.5) Screw(M2.6x4) Flat Cable Cord Assy Fuse(10A) ····· Cap IC(IC201) Resistor Cord Assy Cord Assy Cord Assy Cap Case Holder Earth Plate Insulator Insulator Cushion Panel Tuner Amp Unit Screw Screw Antenna Cable Clamper Connector(CN361) Plug(CN981) Plug(CN871) Connector(CN571) Connector(CN704) Connector(CN101) Connector(CN701) Connector(CN801) Holder(CN402) Case Holder Holder Heat Sink Insulator Heat Sink Holder Drive Unit Screw Screw(M2x2) Spring Cord Holder Holder Insulator Gear Gear Gear Gear Part No. BMZ26P200FTC BSZ26P060FTC CBA1641 CBA1769 CDE7468 CDE7482 CEK1136 CNS1472 PAL008A RS1/2PMF102J See Contrast table(2) CDE7484 CDE7612 CNV6727 CNB2945 CNC8659 CND2171 CNM8638 CNM8790 CNM9126 CNS7772 See Contrast table(2) BMZ26P200FTC BSZ26P080FTC CDH1336 CEF1033 CKM1389 CKM1428 CKS-786 See Contrast table(2) CKS3125 CKS3408 CKS3837 CKS4811 CNC5399 CNC8138 CND2029 CND2030 CND2031 CNM6249 CNR1728 CND1054 See Contrast table(2) BMZ26P040FTC CBA1633 CBL1632 CDE7392 CND1848 CND1850 CNM8797 CNV7752 CNV7753 CNV7754 CNV7755 Mark No. 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109 110 Description Switch Unit Switch(S1) Spring Switch(S2) Holder Unit Holder Unit Arm Unit Arm Unit Arm Unit Arm Unit Chassis Unit Motor Unit(M871) FM/AM Tuner Unit Gear Unit Screw Washer Panel Unit Remote Control Unit Cover Screw(M2x2) Screw(M2x2) Screw(M2x3.5) Spring Connector Holder Flexible PCB Arm Guide Guide Case Unit Detach Grille Assy Screw Button(OPEN/RESET) Button(BAND) Button(ENT/EQ/EQ-EX) Button(CLOCK/DISP/LIST) Button(ATT/OFF/SRC) Cover Lighting Conductor Keyboard Unit Connector(CN1901) Holder Double-sided Seal Spacer Spacer Holder Part No. CWS1389 CSN1051 CSN1052 CXC2196 CXC2197 CXC2198 CXC2199 CXC2200 CXC2201 See Contrast table(2) CXC2204 CWE1646 CXC2205 JFZ20P025FTC YE15FTC CXC2603 CXC2665 CZN5357 CBA1561 CBA1633 CBA1754 CBH2530 CKS4796 CND2172 CNP7698 CNV6962 CNV6967 CNV6968 CXC2670 See Contrast table(2) BPZ20P060FZK CAC8442 CAC8443 CAC8444 CAC8450 CAC9003 CNS7770 CNV7966 CWM9290 CKS4795 CND2028 CNM8673 CNM9141 CNM9142 CNV7965
A
B
C
D
E
OEL Unit MXS8202 Sub Grille Assy See Contrast table(2) Knob Unit CXC3581 CD Mechanism Module(S10CODE2)CXK5666 Screw ISS26P055FTC ····· Diode(D241,242) Diode(D243,244) Transistor(Q241,242) Transistor(Q742,902,921)
FMG22 FMJ-2303 FKV550N 2SD2375
F
DEH-P8MP/XN/UC
5 6 7 8
13
1
2
3
4
(2) CONTRAST TABLE DEH-P8MP/XN/UC, DEH-P80MP/XN/UC and DEH-P1Y/XN/ES are constructed the same except for the following:
Mark
A
NO
12 23 31 44 65 85 102
Description
Cord Assy Tuner Amp Unit Connector(CN571) Drive Unit Chassis Unit Detach Grille Assy Sub Grille Assy
DEH-P8MP/XN/UC
CDE7483 CWM9287 CKS3125 CXC2206 CXC2203 CXC2695 CXC3235
DEH-P80MP/XN/UC
CDE7483 CWM9288 CKS3125 CXC2206 CXC2203 CXC2696 CXC3236
DEH-P1Y/XN/ES
Not used CWM9289 Not used CXC3562 CXC3561 CXC2697 CXC3237
B
C
D
E
F
14
DEH-P8MP/XN/UC
1 2 3 4
5
6
7
8
A
B
C
D
E
F
DEH-P8MP/XN/UC
5 6 7 8
15
1
2
3
4
2.4 CD MECHANISM MODULE
5 42
A
13 5 13 34 5 93 13
A B
81 15
E
22
F
92 82 83 68
G
26
44 5
1
C
13
D
86 86
54 53 37
52
B
28 4
I
H
28 45
J
4 55 4
1 1
71 87 50 72 10
23 38
36 4 18 29 51
1 2
73
23
K
2
64 47
75 59
C
I
1
76
B
24
7
49
E M
1
61
2
F A Q H
77
90 48
63
2 1
27 8 67 17 78 46 60 80 6
N
21
M
L
G N R
1 1
J
57
D
1
O
D
16
79
12
3
58
2
33
P
2
62
1
20
1
40
60 11 89 10
1GEM1024 2GEM1045 3GEM1035
56
E
1 1
39 69 30 14 25
L
43
K
P
19
70
74
R
41 31 85
C
Q
91
D
1 3 94 2
14 65 85 66 85
O
35 31
F
16
DEH-P8MP/XN/UC
1 2 3 4
5
6
7
8
CD MECHANISM MODULE PARTS LIST
Mark No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 Description Part No. Mark No. 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 Gear Gear Gear Gear Gear Gear Rack Arm Arm Guide Roller Gear Arm Arm Arm Damper Damper Arm Arm Guide Guide Holder Arm Gear Damper Motor Unit(M1) Chassis Unit Screw Unit Gear Unit Arm Unit Arm Arm Motor Unit(M2) Bracket ····· Screw(M2x5) Screw Screw ····· Washer Pickup Unit(P9.9MP3)(Service) Screw Spring Clamper Connector(CN902) Description Part No. CNV7207 CNV7208 CNV7209 CNV7210 CNV7211 CNV7212 CNV7214 CNV7215 CNV7216 CNV7217 CNV7218 CNV7219 CNV7221 CNV7220 CNV7222 CNV7313 CNV7314 CNV7341 CNV7342 CNV7360 CNV7361 CNV7437 CNV7805 CNV7595 CNV7618 CXB6007 CXC2318 CXB8729 CXC2397 CXC2316 CND1896 CND1894 CXB8933 CNC9985 EBA1028 JFZ20P020FTC JGZ17P022FTC YE20FTC CXX1805 IMS26P030FTC CBL1635 CNV7197 CKS2193
F A
CD Core Unit(S10WMACODE2) CWX2952 Connector(CN101) CKS4182 Connector(CN901) CKS4017 Screw BMZ20P035FTC Screw BSZ20P040FTC Screw(M2x4) Screw(M2x3) Screw(M2x3) ····· Washer Washer Spring Spring Spring Spring Spring Spring Spring Spring Spring Spring Spring Spring Spring Spring Spring Spring Spring Spring Spring Spring ····· Shaft Frame Frame Bracket Bracket Arm Arm Lever Lever Sheet Collar Guide Arm Rack Holder Holder Arm CBA1362 CBA1511 CBA1527 CBF1038 CBF1060 CBH2390 CBH2606 CBH2607 CBH2608 CBH2609 CBH2610 CBH2735 CBH2612 CBH2613 CBH2614 CBH2615 CBH2616 CBH2617 CBH2620 CBH2621 CBH2641 CBH2642 CBH2643 CBH2659 CBH2688 CLA4441 CNC9962 CNC9963 CNC9966 CND1895 CNC9968 CND1909 CND2032 CNC9984 CNM8134 CNV7798 CNV7799 CNV7800 CNV7199 CNV7201 CNV7202 CNV7203
B
C
D
E
DEH-P8MP/XN/UC
5 6 7 8
17
1
2
3
4
3. BLOCK DIAGRAM AND SCHEMATIC DIAGRAM
3.1 BLOCK DIAGRAM
A
A TUNER AMP UNIT
VDD
CN101
7 6
CE2
13
ROM_VDD
5
SL
10 9 8
CE1 DI CK
11
NC
14
DO
18 19 20 21
NC NC NC NC
Q101 8
BUS+L 7 BUS-L 11
FM/AM TUNER UNIT
WC
5 1
5V LPF
ANTENNA
1
CN401
1
AM ANT ATT
FMRF
OSC
B
2
IC 1 3.3V FM ANT 3 ATT MIXER, IF AMP
FMRF ANT adj RF adj T51 CF52 CF51
AUDIOGND
OSCGND
VDD_3.3
RFGND
DGND
VCC
2
12
15
22
16
NC
4
17
TUN 3.3V SYS+B
C
B
SWITCH UNIT
S1
PICKUP UNIT (P9.9MP3)(SERVICE)
LASER DIODE LDMD 15 5
D CD CORE UNIT(S10WMACODE2)
V3R3D
CN101
15 5 AC,BD F,E FO+ 1 TO+ 4 LD+ 14 1 4 14 FOP TOP TD/FD 12 FOP 13 TOP M1 SPINDLE MOTOR SD/MD X702 142 Q101 143 LD PD
IC 201 UPD63761GJ
D
HOLOGRAM UNIT FOCUS ACT. MONITOR TRACKING ACT. DIODE
RF AMP, CD DECODER, MP3 AND WMA DECODER DIGITAL SERVO/DATA PROCESSOR
LOUT
31
12 X1
13 X2 25 26
M
CD DRIVER
16 SOP 15 SOM 18 LCOP 17 LCOM LOEJ CONT 22 9 53 47
MICRO COMPUTER
LOEJ CONT
FTxD FRxD
M2 LOADING/CARRIAGE MOTOR
M
IC 301 BA5835FM
4 32
IC 701 PE5423A
CLAMP 12EJ 8EJ DSCSNS HOME VDCONT CD3VON 49 46
CROSSKEY
SWVDD
gdtc@
gdtc!
KYDT
DPDT
ROT1
4
20
E
31 30 97
47 43
VDCONT 19 5
34 33 38 87 35 36
VDCONT Q743
S902 CLAMP S904 12EJ S905 S901 S903 8EJ DSCSNS HOME CD3VON 1 23 CD3VON
ROT0
3.3V REGULATOR
3VDD V3R3D 3 3
IC 203 NJM2391DL1-33 3.3V REGULATOR
1
VD2
IC 703
S-812C33AUA-C2N
VDD VD2 2 22 VD2
V1R5
5
1,3 IC 501 S-L2980A15MC-C6A
V3R3D
1.5V REGULATOR
F
18
DEH-P8MP/XN/UC
1 2 3 4
3.3V
IC 4 2.5V 3.3V 2.5V
IC 3 EEPROM 5.0V
IC 5 3.3V
BUS5 BUS+
Rch IC 2 2.5V
IP-B
IC 10
8 I
6 HA122
24
DET, FM MPX
Lch
23
TUNER 3.3V REGULATOR
IC 451
3 1 SYS+B
Q871 B.UP Q872
BA033FP
M871 FLAP MOTOR
CN871
4 5 3 14 11
ASLIN
M
5
OUT1
4 OUT2
IC 871 BA6288FS
6
ELEC SO
15 TUN L NOIS 42 IN3-L 44 IN4-L 43 IN4+L 41 IN2-L 9 8 EVST,EVCK,EVDT
CLOSE
3
FCLSSW
BUSLBUSL+
S2
OPEN
2 1
FOPNSW
CD L
SP 601
BUZZER
LEVEL INDICATO CN902
TX RX 4 3 3 2
CN704
CDTX CDRX 51
fclssw fopnsw
22 PEE LVLINL MUTE SYSPW2 KEYAD KYDT
7 92 85 84 89 34 1 13 B 11 20 X601 SYSPW2 KEYAD KYDT
A
50
CN901
10 14
CN701
B
Q651
DEH-P8M DEH-P80M
SYSPW XIN RST1 2
RESET
IC 652 BD4835G
1 10
SYSTEM CONTROLLER
XOUT reset OELPW B.UP
VDD
IC 601(2/2) PD5925A
Q822 Q821
BRST,BRXEN,BSRQ BDATA,BSCK ILMPW 41
BRST,BRXEN,BSRQ BDATA,BSCK Q742
VD VD 3 21 VD
ejtin B.UP Q741 DSENS
42 91 R
C
Q744 VDD
Q831
2
VDD
5
19
VDD
B
A
GDTC1 GDTC2 CDTX GDTC1 11 CDRX 8 10 13 12 9
GDTC1
1 3 6 4
IC 801(1/2) 2 TC74VHCT125AFT
5
GDTC2
OEL
GDTC2
IC 801(2/2) TC74VHCT125AFT
5
6
7
8
A
Q881(1/2)
Q883
PL
VCC1 FL-
8
17
SWL Q361
CN361
9 10
SUB WOOFER L
01
Q101 8 5 1
80 ASENBO B.UP
Q885
FL+ RLRL+ Q882
RL
10
2 ICERORR
Q881(2/2)
IC 341 15 PA2028A
RL Q362
5 6
REAR L
BUS5 BUS+
IP-BUS DRIVER
IC 101
1 TX 28 27 79 ce@ CE1 DO DI CK TX RX IPPW
C
FL
12
13
FL Q363
6 HA12240FP 2 RX 8 IPPW
1 2
FRONT L
69 70 98 99 100 95
tunpce@
VDD Q901
TUNPCE1 TUNPDI TUNPDO TUNPCK SL DALMON 67
B.UP Q951
CN981
14
TELMUTE FUSE 10A
VDD
IC 601(1/2) PD5925A
TELIN bsens
8
BACKUP SENSE
73 72 Q931 AC Q941 isens 81 S421 60W/40W 4 81 VDD 40W SYS+B 5 60W 4 10 Q243 VCC1 B.UP 6 3 1 VCC2 Q244 21 VCC2 12 13 Q221 ACC FLIN RLIN MUTE 27 B.UP SYSPW2 5 7 2 FLFL+ RLRL+ 8 10 4 6 Q247 Q246 Q242 RLRL+ 4 2 8 5 FLFL+ RLRL+ Q241 9
TELEPHONE MUTE
B.UP
3A
Q902
FU351
SYSTEM CONTROLLER
VDD REGULATOR
B
15
BACKUP
asens
1k(1/2W)
ILM SENSE
13 ACC ACC
FUSE ILM
ACC SENSE
Q248
54 FLPPW 52 FLPCLS 53 FLPOPN ASLIN 93 sel^)w
17
ACC
10A
ASLIN ACCMON ddchk
IC 241 UPC494GS
9
C
16 18
GND
MIC 321 ELECTRONIC VOLUME/ MICROPHONE SOURCE SELECTOR
15 TUN L USLBUSL+ CD L 1 NOISEDET 42 IN3-L 44 IN4-L IC 131 43 IN4+L PML009A 41 IN2-L 9 8 EVST,EVCK,EVDT MICIN PL FL 13 12 10 11
3
88
NJM2406F IC 221
FLFL+
MIC
VCC1 MG1
IC 201 PAL008A
RL SEL_OUT_L 1
POWER AMP
C MUTE
Q364 BU
B.REMOTE
IC 561 1 TPD1018F
6 11
B.REM
LEVEL INDICATOR IC 171
7 92 85 84 89 34 1 13 B.UP 11 20 B.UP Q821 41 Q822 X601 6 Q841 Q842 SYSPW2 5
SYS +B REGULATOR
Q921 Q202 SYS+B Q922 BU SYS+B
MUTE
Q201
NJM4558MD
Q923
Q501 KEYAD KYDT
DEH-P8MP/XN/UC DEH-P80MP/XN/UC
SYS+B SYSPW
D
DEH-P8MP/XN/UC DEH-P80MP/XN/UC CN571
IC 841 NJM2360M
5
OEL+B
KEYAD KYDT
1 2 3
WIRED REMOTE CONTROL
CN801
IL+B 7 7
CN1901
IL+B
ILLUMINATION
S1902 OPEN
42 91 14 RST1 DSENS 15 EJSW 16 16 OPEN
C
Q1952 3.3V Q1951 16V
KEYBOARD UNIT
S1901 RESET
14 RST1 15 DSENS
SEL/VOL
ROT0 11 ROT1 10 CLOSSKEY 9 11 10 9 ROT0 ROT1 JOYST S1913
FLASH MEMORY
reset ce 12 26
E
IC 1953 A18 16 37 VCC PD6469A A19 9
Q1953 3.3V
Q831 VDD SWDVDD 8 8 SWVDD 5
3.3V REGULATOR
IC 1941 S-818A33AUC-BGN
1
KEY MATRIX
DTC1
1 3 6 4 KYDT 12 12 KYDT DPDT 13 13 DPDT
OPT IN
AVCC
REM
5
REMOTE CONTROL SENSOR 27
FL12PON
flstsy
/2) 2 5AFT
cs@
cs!
VDD
VDD
cs)
IC 1952 RS-140
4 1 5 97 14 60 46 47 48 93 96 KEY DATA XIN 13 X1940 11 OEL DATA IC1970 8,21
DPDT
DTC2
28
OEL CONTROLLER/ KEY CONTROLLER
KTDT
OEL UNIT
IC1971 2,8
XOUT
IC 1951 PD5933A
OEL+B
5
5
OELB
16V
16V Q1981 12V Q1982
F
DEH-P8MP/XN/UC
5 6 7 8
19
1
2
3
4
3.2 OVERALL CONNECTION DIAGRAM(GUIDE PAGE)
A
Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or "ELECTRICAL PARTS LIST".
A-a
CN902
A-a
A-b
Large size SCH diagram
WIRED REMOTE CONTROL
A-a
A-b
Guide page
CD CORE UNIT(S10WMACODE2)
A-a
A-b
Detailed page
CN901
P
B
P P
CD:0dBs
FM:-20.5dBs AM:-31.0dBs IP-BUS: +2.2dBs CD: 0dBs
D
FM:+2.6dBs AM: -7.9dBs IP-BUS:+8.3dBs CD:+8.1dBs
C
FM(100%):-19.5dBs AM(30%):-30.0dBs
FM/AM ANTENNA
P
FM/AM TUNER UNIT
P
D
60W/40W
E
C
IP-BUS:+2.2dBs
8 9 10 11 5 6 7 1 2 3 4
CN1901
P
P
S1 CLOSE CSN1051
S2 OPEN CSN1052
F
1
3
2
M
M871 FLAP MOTOR CXC2204
A B
20
1
B SWITCH UNIT
DEH-P8MP/XN/UC
2 3 4
5
6
7
8
A-b
TROL
A
A : DEH-P8MP/XN/UC B : DEH-P80MP/XN/UC C : DEH-P1Y/XN/ES
A
TUNER AMP UNIT
FM:+13.1dBs AM: +2.6dBs IP-BUS:+18.8dBs CD:+18.6dBs
SUB WOOFER R CH SUB WOOFER L CH REAR R CH REAR L CH FRONT R CH
B
FM:+2.6dBs AM: -7.9dBs BUS:+8.3dBs CD:+8.1dBs
FRONT L CH
>
C
D
GND P ACC P
>
CEK1136 10A
BACKUP
>CEK1136
10A
P
TEL MUTE ILL
B.REM P
1K(1/2W)
RLFRRL+ FR+ FLRRFL+ RR+
FM:+28.6dBs AM:+18.1dBs IP-BUS:+34.3dBs CD:+34.1dBs
E
NOTE : Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors.
Decimal points for resistor and capacitor fixed values are expressed as : 2.2 2R2 0.022 R022
The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation.
F
A
DEH-P8MP/XN/UC
7 8
5
6
21
F
E
B
A
D
C
CN902
CN901
DEH-P8MP/XN/UC
CD:0dBs
D
CD CORE UNIT(S10WMACODE2)
FM/AM ANTENNA
M TUNER UNIT
FM(100%):-19.5dBs AM(30%):-30.0dBs
22
WIRED REMOTE CONTROL
A-b
A-a
A-a A-b
1
1
1
P
2
P P
2
FM:-20.5dBs AM:-31.0dBs IP-BUS: +2.2dBs CD: 0dBs
FM:+2.6dBs AM: -7.9dBs IP-BUS:+8.3dBs CD:+8.1dBs
3
3
2
4
4
P
FM/AM AN
FM/AM TUNER UNIT
P
5
CN1901
C
S2 OPEN CSN1052
S1 CLOSE CSN1051
5
60W/40W
6
6
3
DEH-P8MP/XN/UC
P P
7
3 2
7
4
IP-BUS:+2.2dBs
8 9 10 11
5 6
7
1 2 3 4
1
M
8
A-a B
E
8
M871 FLAP MOTOR CXC2204
B SWITCH UNIT
A-a A-b
A-b
23
A
D
C
F
B
F
E
B
A
D
C
24
A-a A-b
L
A-b
A : DEH-P8MP/XN/UC B : DEH-P80MP/XN/UC C : DEH-P1Y/XN/ES
A
TUNER AMP UNIT
1
>
1
1
2
FM:+13.1dBs AM: +2.6dBs IP-BUS:+18.8dBs CD:+18.6dBs
SUB WOOFER R CH SUB WOOFER L CH REAR R CH REAR L CH FRONT R CH FRONT L CH
2
DEH-P8MP/XN/UC
2.6dBs 7.9dBs 8.3dBs 8.1dBs
3
3
2
4
4
5
5
GND P ACC P
>
CEK1136 10A
>CEK1136
10A
P
BACKUP
TEL MUTE ILL
B.REM P
1K(1/2W)
RLFRRL+ FR+ FLRRFL+ RR+
6
FM:+28.6dBs AM:+18.1dBs IP-BUS:+34.3dBs CD:+34.1dBs
6
3
Decimal points for resistor and capacitor fixed values are expressed as : 2.2 2R2 0.022 R022
A-a A-b
DEH-P8MP/XN/UC
E D C
7
7
4
The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation.
8 A B
8
NOTE : Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors.
A-b
25
F
1
2
3
4
3.3 KEYBOARD UNIT
A
REMOTE CONTROL SENSOR
B
A
CN801
VOL/SEL
OPEN
C
RESET
ENT
ATT
DISP
D
EQ
LIST
CLOCK
EQ-EX
BAND
SRC
E
F
C
26 DEH-P8MP/XN/UC
1 2 3 4
5
6
7
8
C
A
KEYBOARD UNIT
OL
B
C
OEL/KEY CONTROLLER FLASH MEMORY
A12
DQ15/A-1
D
E
OEL UNIT MXS8202
F
C
DEH-P8MP/XN/UC
5 6 7 8
27
1
2
3
4
3.4 CD MECHANISM MODULE(GUIDE PAGE)
A
D-a
S C T F F
S
C
T
L209
C217
B
R1
PICKUP UNIT(P9.9MP3)(SERVICE) %
F F F F T T T T
F
T
T
F T T
F
F
AND
T T T T F F F
C
F
# @
D
Pull-down
4.00MHz
3 2
T T
$
S
1
F
9
F
7
C
8 5
4
E
M1 CXB6007 SPINDLE MOTOR
S S S S F F C C C C T T
0
M2 CXB8933 LOADING/CARRIAGE MOTOR
CD DRIVER 3.3V REGULATOR
S
F
D
28 DEH-P8MP/XN/UC
1 2 3 4
C
C
S
5
6
7
8
D-b
D
CD CORE UNIT(S10WMACODE2)
A
B
!
AND
1.5V REGULATOR
SWITCHES: CD CORE UNIT(S10WMACODE2) S901 : HOME SWITCH.........ON-OFF S902 : CLAMP SWITCH.......ON-OFF S903 : DSCSNS SWITCH.....ON-OFF S904 : 12EJ SWITCH............ON-OFF S905 : 8EJ SWITCH..............ON-OFF The underlined indicates the switch position.
C
F T C S
16.934MHz
SIGNAL LINE FOCUS SERVO LINE TRACKING SERVO LINE CARRIAGE SERVO LINE SPINDLE SERVO LINE
A
CN704
D
Pull-down
MICRO COMPUTER
PE5423A
C906
R22
6
3.3V REGULATOR
^
E
A
R01
CN701
C722 1
470P
&
C910
2R2
F
D
DEH-P8MP/XN/UC
5 6 7 8
29
F
E
B
A
D
C
C
T
S
S
C
T
F
F
30
D-b
D-a
D-a D-b A-a
1
1
1
L209
C217
2
R1
2
PICKUP UNIT(P9.9MP3)(SERVICE) %
DEH-P8MP/XN/UC
F F F T T T F T T F T F T T F F
F
3
3
T
T
F
AND
T
T
F
F
# @
4
4
2
2
5
S
S
M2 CXB8933 LOADING/CARRIAGE MOTOR
CD DRIVER
3.3V REGULATOR
C
C
5
Pull-down
4.00MHz
6
6
3
3
2
T T
$
S
1
F F
9
7
C
8 5
4
M1 CXB6007 SPINDLE MOTOR
0
S S F F C T C T
S
4
DEH-P8MP/XN/UC
D-a D-b A-a
S
C
C
7 E D
7
5
8
8
D-b
D-a
31
A
C
F
B
F
E
B
A
D
C
32
D-a D-b
D-b
1
1
D
CD CORE UNIT(S10WMACODE2)
1
2
2
DEH-P8MP/XN/UC
!
3
3
AND
1.5V REGULATOR
SWITCHES: CD CORE UNIT(S10WMACODE2) S901 : HOME SWITCH.........ON-OFF S902 : CLAMP SWITCH.......ON-OFF S903 : DSCSNS SWITCH.....ON-OFF S904 : 12EJ SWITCH............ON-OFF S905 : 8EJ SWITCH..............ON-OFF The underlined indicates the switch position.
F T C S
16.934MHz
SIGNAL LINE FOCUS SERVO LINE TRACKING SERVO LINE CARRIAGE SERVO LINE SPINDLE SERVO LINE
4
4
A
CN704
2
A
CN704
2
5 6
C906 R22
R01
C722 1
470P
C910
2R2
5
Pull-down
6
MICRO COMPUTER
3
6
3.3V REGULATOR
PE5423A
^
4
7
DEH-P8MP/XN/UC
D-a D-b
7
A
CN701
&
5
8 E A D C B
8
D-b
33
F
1
2
3
4
- Waveforms
A
Note : 1. The encircled numbers denote measuring points in the circuit diagram. 2. Reference voltage REFO1(1.65V) 500ms/div 1 DSCSNS 5 CLCONT 4 LOEJ 6 VD 5V/div 5V/div 5V/div 10V/div 500ms/div 1 DSCSNS 2 8SNS 3 12SNS 4 LOEJ 5V/div 5V/div 5V/div 5V/div 500ms/div
1 DSCSNS 2 8SNS 3 12SNS 4 LOEJ
5V/div 5V/div 5V/div 5V/div
12 cm CD Loading operation
12 cm CD Loading operation
8 cm CD Loading operation
Ref.: GND Mode: Normal
Ref.: GND Mode: Normal
Ref.: GND Mode: Normal
B
7 SIN 8 CIN 9 TIN
1V/div 2s/div 500mV/div 500mV/div
7 SIN 8 CIN 9 TIN
1V/div 1s/div 500mV/div 500mV/div
7 SIN 8 CIN 9 TIN
1V/div 2s/div 500mV/div 500mV/div
12 cm CD-DA setup operation after loading
12 cm CD-ROM(1 session) setup operation after loading
12 cm CD-ROM(3 sessions) setup operation after loading
C
Ref.: REFO Mode: Normal
Ref.: REFO Mode: Normal
Ref.: REFO Mode: Normal
0 FIN ! RFOK 7 SIN
200mV/div 500ms/div @ TE 2V/div # FE 2V/div
500mV/div 200ms/div # FE 500mV/div 0 FIN @ TE 9 TIN
500mV/div 20ms/div 500mV/div 500mV/div 500mV/div
12 cm CD-DA Source On setup operation
Source On setup operation
CD-DA Play operation
D
Ref.: REFO Mode: Normal Ref.: REFO Mode: Normal Ref.: REFO Mode: Normal
E
# FE 0 FIN @ TE 9 TIN
500mV/div 20ms/div 500mV/div 500mV/div 500mV/div
$ MDX 7 SIN
1V/div 50ms/div 200mV/div
$ MDX 7 SIN
2V/div 1V/div
5µs/div
CD-ROM play operation(Regular track Jump)
Spindle waveform during play operation
Spindle waveform during play operation (Wider)
Ref.: REFO Mode: Normal
Ref.: REFO Mode: Normal
Ref.: REFO Mode: Normal
F
34
DEH-P8MP/XN/UC
1 2 3 4
5
6
7
8
0 FIN # FE
500mV/div 200ms/div @ TE 500mV/div % RFAGC
500mV/div 2ms/div 500mV/div
% RFAGC @ TE 9 TIN
1V/div 500µs/div 500mV/div 500mV/div
A
Focus Search waveform
Track Open waveform
1 Track Jump waveform
Ref.: REFO Mode: TEST
Ref.: REFO Mode: TEST
Ref.: REFO Mode: TEST
B
% RFAGC @ TE 9 TIN
1V/div 500µs/div % RFAGC 500mV/div @ TE 500mV/div 9 TIN
1V/div 1ms/div 500mV/div 500mV/div
% RFAGC @ TE 9 TIN
1V/div 2ms/div 500mV/div 500mV/div
4 Tracks Jump waveform
10 Tracks Jump waveform
32 Tracks Jump waveform
Ref.: REFO Mode: TEST
Ref.: REFO Mode: TEST
Ref.: REFO Mode: TEST
C
% RFAGC @ TE 8 CIN 7 SIN
200ms/div ^ LOUT 1V/div 1V/div & ROUT 500mV/div 2V/div
1V/div 1V/div
200µs/div 1 DSCSNS 2 8SNS 3 12SNS 4 LOEJ
5V/div 5V/div 5V/div 5V/div
500ms/div
Search operation(Outter to Inner)
Analog audio waveform
12 cm CD Eject operation
D
Ref.: REFO Mode: Normal Ref.: AGND Mode: Normal Ref.: GND Mode: Normal
1 DSCSNS 5V/div 5 CLCONT 5V/div 4 LOEJ 5V/div
12 cm CD Eject operation
500ms/div 1 DSCSNS 2 8SNS 3 12SNS 4 LOEJ
5V/div 5V/div 5V/div 5V/div
500ms/div 7 SIN 8 CIN 9 TIN
1V/div 500ms/div 500mV/div 500mV/div
E
8 cm CD Eject operation
CD-DA >> CD-ROM mode change(Band key)
Ref.: GND Mode: Normal
Ref.: GND Mode: Normal
Ref.: REFO Mode: Normal
F
DEH-P8MP/XN/UC
5 6 7 8
35
1
2
3
4
A
7 SIN 8 CIN 9 TIN
1V/div 500ms/div % RFAGC 500mV/div 9 TIN 500mV/div @ TE 0 FIN
1V/div 1V/div 1V/div 1V/div
500µs/div
CD-ROM >> CD-DA mode change(Band key)
Black dot(800µm) during play
Ref.: REFO Mode: Normal
Ref.: REFO Mode: Normal
B
C
D
E
F
36
DEH-P8MP/XN/UC
1 2 3 4
5
6
7
8
A
B
C
D
E
F
DEH-P8MP/XN/UC
5 6 7 8
37
1
2
3
4
4. PCB CONNECTION DIAGRAM
4.1 TUNER AMP UNIT
A
NOTE FOR PCB DIAGRAMS
1.The parts mounted on this PCB include all necessary parts for several destination. For further information for respective destinations, be sure to check with the schematic diagram. 2.Viewpoint of PCB diagrams
A
TUNER AMP UNIT
CORD ASSY (POWER SUPPLY, SPEAKER)
Connector
Capacitor
SIDE A
B
P.C.Board Chip Part
18 17
16 14 12 10 8 6 15 13 11 9 7 5
4 3
2 1
SIDE B
WIRED REMOTE CONTROL (DEH-P8MP/XN/UC, DEH-P80MP/XN/UC)
C
D
E
2 1 3
4 5
6 7
8 10 12 14 16 18 9 11 13 15 17
C
F
CN1901
A
38 DEH-P8MP/XN/UC
1 2 3 4
FRONT
5
6
7
8
A
CORD ASSY(PREOUT) PEAKER)
ANTENNA JACK
IC,Q
SIDE A
IP-BUS
12 10 8 11 9 7 6 5 4 3 2 1 473 2 61 5 8
FM/AM TUNER UNIT
B
11 10 9
C
D
60W/40W
40W
60W
D
CN902
E
D
CN901
M871 FLAP MOTOR
B
F
FRONT
DEH-P8MP/XN/UC
5 6 7 8
A
39
1
2
3
4
A
A
TUNER AMP UNIT
IC,Q
B
C
STEST1
D
PCL1
E
F
A
40 DEH-P8MP/XN/UC
1 2 3 4
5
6
7
8
A
SIDE B
B
C
D
E
1
F
A
DEH-P8MP/XN/UC
5 6 7 8
41
1
2
3
4
4.2 SWITCH UNIT
A
B
B
SWITCH UNIT
A
CN871
1
2
3
CLOSE OPEN
C
D
E
F
B
42 DEH-P8MP/XN/UC
1 2 3 4
5
6
7
8
4.3 KEYBOARD UNIT
C
IC,Q
KEYBOARD UNIT
RESET
SIDE A
C
KEYBOARD UNIT
SIDE B
A
ADJ
IC,Q
EQ-EX
OPEN
OEL UNIT
B
ENT
EQ
C
BAND
TP5 TP6
D
10 4 6 3 8 9 5 2
VOL/SEL
7
A
CN801
1
E
ATT
CLOCK
DISP
LIST
F
SRC
C
7 8
DEH-P8MP/XN/UC
5 6
43
1
2
3
4
4.4 CD MECHANISM MODULE
A
D
CD CORE UNIT(S10WMACODE2)
SIDE A
B
M2 LOADING /CARRIAGE MOTOR M1 SPINDLE MOTOR
C
A
CN701
D
PICKUP UNIT(P9.9MP3)(SERVICE)
HOME
E
A
F
CN704
D
44 DEH-P8MP/XN/UC
1 2 3 4
5
6
7
8
D
CD CORE UNIT(S10WMACODE2)
SIDE B
A
12EJ 8EJ
DSCSNS
CLAMP
B
C
D
E
F
D
DEH-P8MP/XN/UC
5 6 7 8
45
1
2
3
4
5. ELECTRICAL PARTS LIST
A
B
Circuit Symbol and No.
Part No.
Circuit Symbol and No.
Q 364 Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q Q D D D D D D D D D D D D D 501 651 741 742 743 744 821 822 831 841 842 861 871 872 881 882 883 884 885 901 902 921 922 923 931 941 951 171 172 173 174 221 222 241 242 243 244 245 246 321 Transistor (P80MP/XN/UC) Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Diode Network Diode Network Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode
Part No.
UMH3N UMD2N 2SC4081 2SC3052-12 UMD2N 2SD2375 2SD1760F5 UMD2N UMD2N 2SD1767 UMF23N UMD2N 2SD1760F5 2SC3052-12 2SD1760F5 UMD3N UMH9N 2SC4081 2SA1576 2SC4081 2SC4081 UMD2N 2SD2375 2SD2375 2SB1243 DTC114EU UMX1N DTC114EU 2SA1576 DA204U DA204U DAN202U DAP202U UDZS6R2(B) UDZS6R8(B) FMG22 FMG22 FMJ-2303 FMJ-2303 1SR154-400 1SS355 RB706F-40
A Number:CWM9287(P8MP/XN/UC) Unit
Unit Number:CWM9288(P80MP/XN/UC) Unit Number:CWM9289(P1Y/XN/ES) Unit Name:Tuner Amp Unit
MISCELLANEOUS
C
IC 101 IC 131 IC 171 IC 201 IC 221 IC 241 IC 341 IC 451 IC 561 IC 601
D
IC IC IC IC IC IC IC IC IC IC IC IC IC IC Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor
HA12240FP PML009A NJM4558MD PAL008A NJM2406F UPC494GS PA2028A BA033FP TPD1018F PD5925A BD4835G TC74VHCT125AFT NJM2360M BA6288FS UMF23N DTC124EU DTC114EU 2SC3052-12 FKV550N FKV550N 2SA933S DTC123EU 2SC1740S DTC143EU 2SC1740S
IC 652 IC 801 IC 841 IC 871 Q 101 Q Q Q Q Q Q Q Q Q Q 201 202 221 241 242 243 244 246 247 248
E
Q 361
Chip Transistor HN1C03FU (P8MP/XN/UC,P1Y/XN/ES) Transistor UMH3N (P80MP/XN/UC) Chip Transistor HN1C03FU (P8MP/XN/UC,P1Y/XN/ES) Transistor UMH3N (P80MP/XN/UC) Chip Transistor HN1C03FU (P8MP/XN/UC,P1Y/XN/ES)
Q 362
F
Q 363
D 341 D 361 D 451
Diode(P8MP/XN/UC,P1Y/XN/ES) 1SS396
Diode Diode
1SS133 1SR154-400
46
DEH-P8MP/XN/UC
1 2 3 4
5
6
7
8
Circuit Symbol and No.
D 501 D 502 D D D D D D D D D D D D D D D D D D D D D D D D D D D D D D 561 562 741 742 801 802 803 804 805 806 807 808 821 841 842 861 871 872 873 881 882 883 884 901 902 921 931 932 941 951 Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode LED Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Surge Protector Inductor Inductor Coil Coil Ferri-Inductor Ferri-Inductor Inductor Inductor Inductor Inductor Ferri-Inductor Ferri-Inductor Inductor Ferri-Inductor Inductor Inductor Chip-Inductor Chip-Inductor Radiator 10.00MHz Slide Switch(60W/40W) Semi-fixed 10k(B) Fuse 3A > Microphone
5
Part No.
DAN202U HZS9L(A2) MPG06G-6415G50 MPG06G-6415G50 HZS9L(B1) HZS6L(C1) DAN202U DAP202U DAP202U DAN202U DAP202U DAN202U DAP202U DAN202U HZS11L(A1) HZS11L(A1) RB411D SML311BBT(PQ) HZS6L(C3) 1SS133 1SS133 DAN202U DAN202U DAN202U DAN202U HZS6L(B2) MPG06G-6415G50 HZS9L(B3) HZS7L(C3) HZS7L(A1) MPG06G-6415G50 DAN202U MPG06G-6415G50 MPG06G-6415G50 MPG06G-6415G50 MPG06G-6415G50 RCCA-201Q31UA-PI LCTC2R2K1608 LCTA2R2J2520 CTH1310 CTH1310 LAU220K LAU220K LAU1R0K LAU2R2K LAU1R0K LCTA4R7J2520 LAU100K LAU100K CTF1379 LAU100K CTF1489 CTF1510 LCTA2R2J3225 LCTA2R2J3225 CSS1475 CSH1051 CCP1229 CEK1286 CPM1011
6
Circuit Symbol and No.
SP601 Buzzer FM/AM Tuner Unit
Part No.
CPV1062 CWE1646
A
RESISTORS
R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R 101 102 103 104 105 106 107 108 109 110 111 112 113 114 131 132 133 134 135 136 137 138 139 140 141 171 172 173 174 175 176 201 202 203 204 205 221 222 223 224 231 241 242 243 244 245 247 248 249 250 251 252 253 254 255 RS1/16S102J RS1/16S223J RS1/16S181J RS1/16S222J RS1/16S181J RS1/16S223J RS1/16S102J RS1/16S150J RS1/16S562J RS1/16S332J RS1/16S470J RS1/16S101J RS1/16S102J RS1/16S101J RS1/16S821J RS1/16S821J RS1/16S102J RS1/16S102J RAB4C102J RS1/16S101J RS1/16S101J RS1/16S101J RS1/16S101J RS1/16S101J RS1/16S101J RS1/16S104J RS1/16S104J RS1/16S563J RS1/16S563J RS1/16S474J RS1/16S474J RS1/16S681J RS1/16S103J RS1/16S103J RS1/16S331J RS1/16S681J RS1/16S103J RS1/16S103J RS1/16S473J RS1/16S104J RS1/16S473J RS1/2PMF3R3J RS1/2PMF3R3J RD1/4MUF470J RD1/4MUF470J RS1/16S222J RS1/16S104J RS1/16S822J RS1/16S224J RS1/16S472J RS1/16S103J RS1/16S1002D RS1/16S1002D RS1/16S3902D RS1/16S3902D
B
C
D 981 D 982 D 983 D 984 ZNR401 L L L L L L L L L L L L L L L L L L X S 101 131 241 242 243 341 401 402 403 404 601 701 801 831 841 842 843 951 601 421
D
E
F
VR321 FU361 MIC321
DEH-P8MP/XN/UC
7 8
47
1
2
3
4
Circuit Symbol and No.
R R R R R R R R R R R R R R R R R R R R 256 257 258 259 260 261 262 263 264 265 266 267 268 269 321 323 324 325 341 342 (P8MP/XN/UC,P1Y/XN/ES) (P80MP/XN/UC) (P8MP/XN/UC,P1Y/XN/ES) (P80MP/XN/UC) (P8MP/XN/UC,P1Y/XN/ES) (P80MP/XN/UC) (P8MP/XN/UC,P1Y/XN/ES) (P80MP/XN/UC) (P8MP/XN/UC,P1Y/XN/ES) (P80MP/XN/UC) (P8MP/XN/UC,P1Y/XN/ES) (P80MP/XN/UC) (P8MP/XN/UC,P1Y/XN/ES) (P80MP/XN/UC) (P8MP/XN/UC,P1Y/XN/ES) (P80MP/XN/UC) (P8MP/XN/UC,P1Y/XN/ES) (P80MP/XN/UC) (P8MP/XN/UC,P1Y/XN/ES) (P80MP/XN/UC) (P8MP/XN/UC,P1Y/XN/ES) (P80MP/XN/UC) (P8MP/XN/UC,P1Y/XN/ES) (P80MP/XN/UC)
Part No.
RS1/16S2R2J RS1/16S2R2J RS1/16S473J RS1/16S473J RS1/16S103J RS1/4SA331J RS1/4SA331J RS1/16S0R0J RS1/4SA151J RS1/16S332J RS1/16S332J RS1/16S152J RS1/4SA151J RS1/16S152J RS1/16S222J RS1/16S561J RS1/16S104J RS1/16S104J RS1/16S103J RS1/16S103J RS1/16S820J RS1/16S821J RS1/16S820J RS1/16S821J RS1/16S820J RS1/16S821J RS1/16S820J RS1/16S821J RS1/16S820J RS1/16S821J RS1/16S820J RS1/16S821J RS1/16S103J RS1/16S0R0J RS1/16S103J RS1/16S0R0J RS1/16S103J RS1/16S0R0J RS1/16S103J RS1/16S0R0J RS1/16S103J RS1/16S0R0J RS1/16S103J RS1/16S0R0J RS1/16S223J RS1/16S223J RS1/16S223J RS1/16S223J RS1/16S223J RS1/16S223J RS1/16S471J RS1/16S471J RS1/16S471J RS1/16S471J
Circuit Symbol and No.
R 404 R 405 R 406 R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R 421 422 451 501 502 503 561 571 572 601 602 603 604 605 606 607 608 609 610 612 613 614 615 616 617 618 619 620 621 622 623 624 625 626 627 628 629 630 631 642 651 652 653 654 655 701 703 704 705 706 707 708 709 710 711
Part No.
RS1/16S681J RS1/16S681J RS1/16S681J RS1/16S104J RS1/16S102J RD1/4PU2R2J RS1/16S103J RS1/16S473J
A
RS1/16S473J RS1/16S103J (P8MP/XN/UC,P80MP/XN/UC) RS1/16S102J (P8MP/XN/UC,P80MP/XN/UC) RS1/16S102J RS1/16S472J RS1/16S472J RS1/16S473J RS1/16S104J RS1/16S104J RS1/16S103J RS1/16S0R0J RS1/16S104J RS1/16S104J RS1/16S102J RS1/16S103J RS1/16S681J RS1/16S681J RS1/16S681J RS1/16S473J RS1/16S104J
B
R 361 R 362 R 363
C
R 364 R 365 R 366
(P1Y/XN/ES)
(P8MP/XN/UC,P80MP/XN/UC) RS1/16S104J
R 367 R 368
D
RS1/16S104J (P80MP/XN/UC) RS1/16S104J (P8MP/XN/UC,P1Y/XN/ES) RS1/16S104J RS1/16S104J RS1/16S104J RS1/16S104J RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16S104J RS1/16S104J RS1/16S102J RS1/16S102J RS1/16S183J RS1/16S473J RS1/16S222J RS1/16S473J RS1/16S682J RS1/16S682J RS1/16S682J RS1/16S682J RS1/16S221J RS1/16S221J RS1/16S221J RS1/16S221J RS1/16S221J RS1/16S221J
3 4
R 369
R 370 R 371 R 372
E
R R R R R R R R R R R R R R R
373 374 375 376 377 378 379 380 381 382 383 384 385 389 401
(P8MP/XN/UC,P1Y/XN/ES) (P8MP/XN/UC,P1Y/XN/ES) (P8MP/XN/UC,P1Y/XN/ES) (P8MP/XN/UC,P1Y/XN/ES)
F
(P8MP/XN/UC,P1Y/XN/ES) RS1/16S471J (P8MP/XN/UC,P1Y/XN/ES) RS1/16S471J (P80MP/XN/UC) RS1/16S0R0J RS1/16S102J RS1/16S681J RS1/16S681J RS1/16S681J
1 2
R 402 R 403
R 712
48
DEH-P8MP/XN/UC
5
6
7
8
Circuit Symbol and No.
R 741 R 743 R 801 R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R 802 803 804 805 806 807 808 809 810 811 812 813 815 816 818 819 821 822 823 824 825 826 827 831 832 833 841 842 844 845 846 847 848 861 862 863 864 865 871 872 881 882 883 884 885 886 887 888 889 890 891 892 893 894 895
Part No.
RD1/4PU391J RD1/4PU391J RS1/16S104J RS1/16S104J RS1/16S102J RS1/16S222J RS1/16S472J RS1/16S222J RS1/16S222J RS1/16S222J RS1/16S222J RS1/16S222J RS1/16S0R0J RS1/16S104J RS1/16S102J RS1/16S104J RS1/16S221J RS1/16S103J RS1/16S122J RS1/16S221J RS1/16S221J RS1/16S1R0J RS1/16S473J RS1/16S473J RS1/16S473J RS1/16S104J RS1/16S472J RS1/16S102J RS1/16S472J RS1/16S331J RS1/16S331J RS1/16S1R0J RS1/16S391J RS1/16S121J RD1/4PU302J RD1/4PU302J RS1/16S331J RS1/16S331J RS1/16S331J RS1/16S103J RS1/16S103J RAB4C102J RD1/4PU391J RS1/16S472J RS1/16S2203D RS1/16S3303D RS1/16S4702D RS1/16S223J RS1/16S223J RS1/16S3303D RS1/16S3303D RS1/16S1503D RS1/16S1503D RS1/16S1503D RS1/16S1503D RS1/16S1503D RS1/16S1503D RS1/16S1503D RS1/16S1503D RS1/16S223J
Circuit Symbol and No.
R 903 R 904 R 922 R R R R R R R R R R R R R R R 923 924 925 931 932 933 934 935 943 951 952 953 954 955 981
Part No.
RS1/16S332J RS1/16S0R0J RS1/16S152J
A
RD1/4PU152J RS1/16S223J RS1/16S472J RS1/16S104J RS1/16S473J RS1/16S103J RS1/16S473J RS1/16S472J RS1/16S103J RS1/16S102J RS1/16S472J RS1/16S472J RS1/16S153J RS1/16S104J RD1/4PU102J RS1/4SA0R0J RS1/16S0R0J
B
R 982 R 987
CAPACITORS
C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C 102 103 104 131 132 133 134 135 136 137 138 139 140 141 142 143 144 145 146 147 148 149 150 151 152 159 160 161 171 172 173 174 175 176 177 CKSRYB104K16 CKSRYB102K50 CKSRYB102K50 CCSQCH222J50 CEAL1R0M50 CEAL1R0M50 CKSRYB104K16 CKSRYB104K16 CEAL1R0M50 CEAL1R0M50 CEAL1R0M50 CEAL1R0M50 CEJQ470M10 CKSRYB104K16 CCSQCH222J50 CEALNP4R7M16 CEALNP4R7M16 CEALNP4R7M16 CEALNP4R7M16 CCSQCH152J50 CEALNP4R7M16 CEALNP4R7M16 CCSQCH152J50 CEALNP4R7M16 CEALNP4R7M16 CKSRYB474K10 CKSRYB474K10 CEJQ100M50 CKSRYB103K50 CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 CKSRYB474K10 CKSRYB474K10 CCSRCH101J50
C
D
E
F
R 896 R 902
5
C 178
DEH-P8MP/XN/UC
6 7 8
49
1
2
3
4
Circuit Symbol and No.
C C C C C C C C C C C C C C
B
Part No.
CCSRCH101J50 CFTNA224J50 CFTNA224J50 CFTNA224J50 CFTNA224J50 CEAL330M10 CEHAR100M16 CKSQYB225K10 CKSQYB225K10 CKSRYB472K50 CKSRYB472K50 CKSRYB472K50 CKSRYB472K50 CKSRYB103K50 CKSRYB104K25 CKSRYB104K25 CQMA332J50 CQMA332J50 CCH1594 CCH1594 CEHAZL102M16 CEHAZL102M16 CCSRCH270J50 CKSRYB222K50 CQMAQ102J50 CKSRYB332K50 CKSYB105K25 CKSYB105K25 CCSQCH222J50 CEJQ101M16 CKSRYB103K50 CKSRYB103K50 CEHAZL100M50 CEJQ100M50 CEJQ220M25 CEJQ100M50 CEAL4R7M35 CEJQ101M16 CASAQ3R3M16 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CKSYB684K16 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CEAL100M16 CKSQYB225K10 CEJQ330M25 C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C
Circuit Symbol and No.
369 370 371 372 373 401 402 403 404 405 407 451 452 453 454 455 456 561 562 601 602 603 604 606 652 653 702 741 742 743 744 745 801 821 832 833 834 841 842 843 844 845 846 847 848 849 861 873 874 875 876 877 878 881 882 883 884 885 886 (P8MP/XN/UC,P1Y/XN/ES) (P8MP/XN/UC,P1Y/XN/ES) (P8MP/XN/UC,P1Y/XN/ES) (P8MP/XN/UC,P1Y/XN/ES)
Part No.
CKSRYB222K50 CKSRYB222K50 CKSRYB222K50 CKSRYB222K50 CEAL220M35 CKSRYB103K50 CKSRYB103K50 CEJQ470M10 CKSRYB103K50 CEJQ101M10 CKSYB475K10 CKSRYB103K50 CKSRYB103K50 CEJQ220M25 CKSYB475K10 CKSRYB103K50 CKSYB475K10 CKSRYB104K25 CKSRYB473K25 CCSRCH180J50 CCSRCH220J50 CEAL470M16 CKSRYB103K50 CCSRCH470J50 CKSRYB105K10 CKSRYB104K16 CCH1438 CKSRYB473K16 CKSRYB102K50 CEJQ101M16 CKSRYB473K16 CEJQ101M10 CKSRYB473K16 CKSRYB473K25 CCSRCH101J50 CKSRYB473K50 CKSRYB105K10 CKSRYB104K16 CEAL470M16 CEAL101M10 CKSRYB104K16 CCSRCH331J50 CKSRYB103K50 CEAL330M25 CEAL100M25 CCG1111 CKSRYB104K25 CKSRYB224K10 CKSRYB224K10 CEAT331M10 CKSRYB102K50 CCSRCH101J50 CCSRCH101J50 CKSRYB103K50 CKSQYB105K16 CKSQYB474K25 CKSQYB474K25 CKSQYB474K25 CKSQYB474K25 CKSQYB474K25
A
179 201 202 203 204 205 206 207 208 211 212 213 214 221 222 223 241 242 243 244 245 246 247 249 250 251 252 253 254 255 256 257 259 321 322 323 341 342 343 344 345 346 347 348 349 350 351 352 353 354 355 356 361 362 363 364 365 366 367
C C C C C C C C C C
C
2200µF/25V 2200µF/25V
C C C C C C C C C C
470µF/10V
D
C C C C C C C C C C C C C C C C C C C C C C C C C
E
4.7µF
CEJQ330M25 (P8MP/XN/UC,P1Y/XN/ES) CEJQ330M25 (P8MP/XN/UC,P1Y/XN/ES) CEJQ330M25 CEJQ100M50 CEJQ100M50 CEJQ100M50 CEJQ100M50 CEJQ100M50 CEJQ100M50 (P8MP/XN/UC,P1Y/XN/ES) CKSRYB222K50 (P8MP/XN/UC,P1Y/XN/ES) CKSRYB222K50
1 2
F
C 368
C 887
3
50
DEH-P8MP/XN/UC
4
5
6
7
8
Circuit Symbol and No.
C C C C C C C C C C C C C C 888 889 890 901 902 903 904 905 921 922 923 924 931 941
Part No.
CKSQYB474K25 CKSQYB474K25 CKSQYB474K25 CEJQ101M10 CKSRYB103K50 CKSRYB472K50 CCH1331 CCH1331 CEJQ221M10 CKSRYB103K50 CEJQ101M10 CCH1331 CKSRYB104K25 CKSQYB105K16 CKSRYB104K25 CKSRYB473K50
Circuit Symbol and No.
TH1981 X 1951 S 1901 S 1902 S 1903 S S S S S 1921 1922 1923 1924 1925 Thermistor Ceramic Resonator 16MHz Push Switch Push Switch Switch(SEL/VOL) Push Switch Push Switch Push Switch Push Switch Push Switch Push Switch Push Switch Push Switch Push Switch Semi-fixed 10k(B) OEL Unit
Part No.
CCX1037 CSS1616 CSG1155 CSG1155 CSX1065 CSG1155 CSG1155 CSG1155 CSG1155 CSG1155 CSG1155 CSG1155 CSG1155 CSG1155 CCP1229 MXS8202
A
470µF/16V 470µF/16V
470µF/16V
C 951 C 981
S 1926 S 1927 S 1928 S 1929 VR1981
B
B Number:CWS1389 Unit
Unit Name:Switch Unit
S 1 S 2 Switch(CLOSE) Switch(OPEN) CSN1051 CSN1052
RESISTORS
R R R R R R R R R R S-818A33AUC-BGN PD5933A RS-140 PD6469A UMD2N 2SC4154-11 UMD2N 2SC4617 2SD1664 DAP202U DAN202U SML311BBT(PQ) SML311BBT(PQ) SML311BBT(PQ) SML311BBT(PQ) SML311BBT(PQ) SML311BBT(PQ) SML311BBT(PQ) SML311BBT(PQ) SML311BBT(PQ) SML311BBT(PQ) SML311BBT(PQ) SML311BBT(PQ) SML311BBT(PQ) SML311BBT(PQ) 1SS355 UDZS13(B) DAN202U CTF1530 CTF1530 R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R 1901 1902 1905 1906 1907 1908 1909 1910 1911 1912 1913 1914 1916 1921 1922 1923 1924 1925 1926 1927 1928 1929 1930 1931 1932 1933 1934 1941 1951 1952 1953 1954 1955 1956 1957 1958 1959 1960 1961 1962 RS1/16S222J RS1/16S222J RS1/16S822J RS1/16S102J RS1/16S102J RS1/16S222J RS1/16S332J RS1/16S822J RS1/16S473J RS1/16S154J RS1/10S0R0J RS1/10S0R0J RS1/16S103J RS1/16S221J RS1/16S560J RS1/16S221J RS1/16S560J RS1/16S221J RS1/16S560J RS1/16S221J RS1/16S560J RS1/16S221J RS1/16S560J RS1/16S221J RS1/16S560J RS1/16S221J RS1/16S560J RS1/16S222J RS1/16S121J RS1/16S184J RS1/16S2R2J RS1/16S154J RS1/16S473J RAB4C102J RS1/16S103J RAB4C473J RS1/16S473J RAB4C101J RAB4C101J RAB4C101J
E D
C Number:CWM9290 Unit
Unit Name:Keyboard Unit
MISCELLANEOUS
IC 1941 IC 1951 IC 1952 IC 1953 Q 1951 Q Q Q Q D D D D D D D D D D D D D D D D D D D L L 1952 1953 1981 1982 1901 1902 1921 1922 1923 1924 1925 1926 1927 1928 1929 1930 1931 1932 1933 1934 1951 1952 1953 1903 1941 IC IC IC IC Transistor Transistor Transistor Transistor Transistor Diode Diode LED LED LED LED LED LED LED LED LED LED LED LED LED LED Diode Diode Diode Inductor Inductor
C
F
DEH-P8MP/XN/UC
5 6 7 8
51
1
2
3
4
Circuit Symbol and No.
R R R R R R R R R R R R R R R R R R R R 1963 1964 1965 1966 1967 1968 1969 1970 1971 1972 1973 1974 1975 1977 1981 1982 1983 1984 1985 1986
Part No.
RAB4C101J RAB4C101J RAB4C101J RAB4C101J RAB4C101J RAB4C101J RAB4C101J RAB4C102J RS1/16S102J RS1/16S0R0J RS1/16S473J RS1/16S473J RS1/16S473J RS1/16S473J RS1/16S333J RS1/16S683J RS1/16S393J RS1/16S392J RAB4C101J RS1/16S152J RS1/16S101J RS1/16S101J RS1/16S104J
Circuit Symbol and No.
Part No.
Unit Number:CWX2952 Unit Name:CD CORE UNIT(S10WMACODE2)
MISCELLANEOUS
IC 201 IC 203 IC 301 IC 501 IC 701 IC 703 Q 101 Q 601 Q 603 Q 701 D D L L L L X X S S 101 601 203 207 209 703 201 702 901 902 IC IC IC IC IC IC Transistor Transistor Transistor Transistor Diode Diode Inductor Inductor Inductor Inductor
Ceramic Resonator 16.934MHz
A
UPD63761GJ NJM2391DL1-33 BA5835FM S-L2980A15MC-C6A PE5423A S-812C33AUA-C2N 2SB1132 IMH20 2SB709A UN2111 1SS355 MA152WA CTF1389 CTF1389 CTF1389 CTF1389 CSS1603 CSS1654 CSN1051 CSN1051 CSN1052 CSN1051 CSN1051
B
R 1988 R 1989 R 1991
C
Resonator 4.00MHz Switch(HOME) Switch(CLAMP) Spring Switch(DSCSNS) Switch(12EJ) Switch(8EJ)
CAPACITORS
C C C C C C C C C C C C C C C C C C C C 1905 1908 1909 1921 1922 1923 1924 1925 1926 1927 1928 1929 1930 1931 1932 1933 1934 1941 1942 1943 1944 1951 1952 1953 1954 1955 1957 1981 1982 1983 CKSRYB104K25 CKSRYB104K25 CKSRYB104K25 CKSRYB104K25 CKSRYB104K25 CKSRYB104K25 CKSRYB104K25 CKSRYB104K25 CKSRYB104K25 CKSRYB104K25 CKSRYB104K25 CKSRYB104K25 CKSRYB104K25 CKSRYB104K25 CKSRYB104K25 CKSRYB104K25 CKSRYB104K25 CSZSR4R7M16 CSZSR4R7M10 CKSQYB103K50 CSZSR4R7M10 CKSYF106Z10 CKSRYB473K50 CKSRYB103K25 CKSRYB103K25 CKSYF475Z16 CKSRYB103K25 CKSRYB104K25 CKSRYB104K25 CKSRYB104K25 CKSRYB104K25 S 903 S 904 S 905
RESISTORS
R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R 101 102 103 104 105 107 201 202 205 207 209 214 216 218 220 221 222 223 224 225 226 227 228 229 231 232 233 240 241 242 RS1/10S1R5J RS1/10S1R5J RS1/10S1R5J RS1/10S1R5J RS1/10S1R5J RS1/16SS0R0J RS1/16SS102J RS1/16SS333J RS1/16SS473J RS1/16SS473J RS1/16SS473J RS1/16SS472J RS1/16SS472J RS1/16SS472J RS1/16SS472J RS1/16SS103J RS1/16SS103J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS103J RS1/16SS393J RS1/16SS562J RS1/16SS122J RS1/16SS472J RS1/16SS0R0J RS1/16SS122J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS333J RS1/16SS0R0J
D
E
C C C C C C C C C C
F
C 1985
D
52
1 2
DEH-P8MP/XN/UC
3 4
5
6
7
8
Circuit Symbol and No.
R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R R 243 245 250 256 261 262 263 264 267 301 302 304 305 307 308 309 310 501 601 602 603 604 605 606 701 702 703 704 705 706 707 708 709 710 711 712 713 714 715 716 717 718 719 720 721 724 725 726 727 729 730 731 732 733 735 737 740 742 745 746
5
Part No.
RS1/16SS333J RS1/16SS333J RS1/16SS0R0J RS1/16SS0R0J RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16SS183J RS1/16SS822J RS1/16SS183J RS1/16SS822J RS1/16SS183J RS1/16SS183J RS1/16SS183J RS1/16SS183J RS1/16SS0R0J RS1/16S101J RS1/16S101J RS1/16S223J RS1/16S223J RS1/16SS103J RS1/16S0R0J RS1/16S0R0J RS1/16SS0R0J RS1/16SS104J RS1/16SS104J RS1/16SS221J RS1/16SS221J RS1/16SS0R0J RS1/16SS221J RS1/16SS473J RS1/16SS102J RS1/16SS102J RS1/16SS102J RS1/16SS102J RS1/16SS473J RS1/16SS101J RS1/16SS472J RS1/16SS221J RS1/16SS221J RS1/16SS221J RS1/16SS471J RS1/16S0R0J RS1/16S473J RS1/16SS222J RS1/16SS103J RS1/16SS473J RS1/16SS223J RS1/16SS473J RS1/16SS104J RS1/16SS104J RS1/16SS104J RS1/16SS473J RS1/16SS104J RS1/16SS473J RS1/16SS104J RS1/16SS473J RS1/16SS104J
6
Circuit Symbol and No.
R R R R R R R R R R R R R R R 750 754 755 756 765 769 773 777 778 779 901 902 905 906 908
Part No.
RS1/16SS473J RS1/16SS102J RS1/16SS102J RS1/16SS104J RAB4CQ221J RAB4CQ221J RAB4CQ221J RS1/16SS221J RS1/16SS221J RS1/16SS221J RAB4CQ221J RS1/16S0R0J RS1/16SS221J RS1/16SS221J RS1/16SS0R0J RS1/16SS0R0J
A
B
R 910
CAPACITORS
C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C 101 102 103 104 105 106 107 108 110 201 202 203 204 205 207 208 209 216 217 218 219 220 221 222 223 224 225 226 227 228 230 232 233 234 235 237 239 242 246 250 CKSSYB104K10 CKSSYB104K10 CCH1504 CCH1506 CKSSYB104K10 CCSSCH101J50 CKSRYB224K16 CKSSYB104K10 CKSSYB104K10 CKSSYB471K50 CKSSYB104K10 CKSSYB104K10 CCH1507 CKSSYB104K10 CCH1590 CKSSYB104K10 CKSSYB104K10 CKSSYB332K50 CKSSYB104K10 CKSSYB223K16 CKSSYB104K10 CKSSYB103K16 CKSSYB104K10 CCSSCH560J50 CCSSCH5R0C50 CKSSYB104K10 CKSSYB103K16 CCSSCH680J50 CCSSCH470J50 CKSSYB682K25 CKSSYB104K10 CKSSYB104K10 CCH1470 CCH1590 CKSRYB224K16 CKSSYB104K10 CCSSCH330J50 CKSSYB104K10 CKSSYB104K10 CKSRYB102K50
D C
100µF/16V 47µF/6.3V
22µF/6.3V 220µF/4V
E
10µF/6.3V 220µF/4V
F
DEH-P8MP/XN/UC
7 8
53
1
2
3
4
Circuit Symbol and No.
C C C C C C C C C C C C C C C C C C C C C C C C C
C
Part No.
CKSRYB102K50 CKSSYB104K10 CKSSYB221K50 CKSSYB221K50 CKSSYB472K25 CKSSYB103K16 CCH1504 CKSSYB104K10 CKSSYB104K10 CKSRYB224K16 CKSQYB475K6R3 CCSRCH102J50 CCSRCH102J50 CCH1568 CCH1568 CKSSYB104K10 CKSSYB471K50 CKSSYB103K16 CCH1592 CKSSYB104K10 CKSSYB104K10 CKSRYB224K16 CKSSYB104K10 CKSSYB104K10 CKSSYB103K16 CCSSCH180J50 CCSSCH180J50 CKSQYB225K10 CKSRYB105K10 CKSSYB471K50 CKSRYB224K16 CKSSYB103K16 CKSQYB225K10
A
251 260 301 302 303 304 305 306 307 501 505 601 602 603 604 701 702 703 704 706 707 712 713 714 716 717 718 720 722 903
100µF/16V
B
4.7µF/25V 4.7µF/25V
4.7µF/25V
C C C C C
C 906 C 907 C 910
Miscellaneous Parts List
D
Pickup Unit(P9.9MP3)(Service) CXX1805
M 1 M 2 M 871
Motor Unit(SPINDLE) Motor Unit(FLAP)
CXB6007 CXC2204
Motor Unit(LOADING/CARRIAGE) CXB8933
E
F
54
DEH-P8MP/XN/UC
1 2 3 4
5
6
7
8
6. ADJUSTMENT
6.1 CONNECTION DIAGRAM
A
TUNER AMP UNIT CN801
B
GGD1160
C
GGD1378 KEYBOARD UNIT
D
CN1901
Rubber Band
Rubber Band
E
F
DEH-P8MP/XN/UC
5 6 7 8
55
1
2
3
4
6.2 OEL UNIT ADJUSTMENT
A
Adjustment point
KEYBOARD UNIT (SIDE B)
B
C
Digital Multi-Meter
VR1981 TP6
TP5
D
E
1. Use VR1981 to adjust the resistance between TP5 and TP6 to 2.3 k.
F
56
DEH-P8MP/XN/UC
1 2 3 4
5
6
7
8
6.3 CD ADJUSTMENT
1) Cautions on adjustments · In this product the single voltage (3.3V) is used for the regulator. The reference voltage is the REFO1 (1.65V) instead of the GND. If you should mistakenly short the REFO1 with the GND during adjustment, accurate voltage will not be obtained, and the servo's misoperation will apply excessive shock to the pickup. To avoid such problems: a. Do not mix up the REFO1 with the GND when connecting the (-) probe of measuring instruments. Especially on an oscilloscope, avoid connecting the (-) probe for CH1 to the GND. b. In many cases, measuring instruments have the same potential as that for the (-) probe. Be sure to set the measuring instruments to the floating state. c. If you have mistakenly connected the REFO1 to the GND, turn off the regulator or the power immediately. · Before mounting and removing filters or leads for adjustment, be sure to turn off the regulator. · For stable circuit operation, keep the mechanism operating for about one minute or more after the regulator is turned on. · In the test mode, any software protections will not work. Avoid applying any mechanical or electrical shock to the mechanism during adjustment. · The RFI and RFO signals with a wide frequency range are easy to oscillate. When observing the signals, insert a resistor of 1k ohms in series. · The load and eject operation is not guarantied with the mechanism upside down. If the mechanism is blocked due to mistaken eject operation, reset the product or turn off and on the ACC to restore it. 2) Test mode This mode is used to adjust the CD mechanism module. · To enter the test mode. While pressing the LIST and EQ keys at the same time, reset. · To exit from the test mode. Turn off the ACC and back up. Notes: a. During ejection, do not press any other keys than the EJECT key until the loaded disc is ejected. b. If you have pressed the () key or () key during focus search, turn off the power immediately to protect the actuator from damage caused by the lens stuck. c. For the TR jump modes except 100TR, the track jump operation will continue even if the key is released. d. For the CRG move and 100TR jump modes, the tracking loop will be closed at the same time when the key is released. e. When the power is turned off and on, the jump mode is reset to the single TR (91), the RF amp gain is set to 0dB, and the auto-adjustment values are reset to the default settings.
A
B
C
D
E
F
DEH-P8MP/XN/UC
5 6 7 8
57
1
2
3
4
- Flow Chart
A
[KEY] Contents Display [LIST]+[EQ]+Reset or [LIST]+[EQ]+BU+ACC Test Mode In Key of the head unit [CD]or[SOURCE] Source On
TRK MIN SEC
Key of the remote control unit
[BAND] Power On
(T.Offset is adjusted)
TRK 00 MIN00 SEC 00
[3] Power On
(T.Offset is not adjusted)
TRK 99 MIN 99 SEC 99
[2] RF AMP *1 Gain switching
TRK GGMIN GGSEC GG
[4] SPINDLE *9 Speed switching
TRK SP MIN SP SEC SP
B
[BAND] Power Off
TRK MIN SEC
[3] Focus Close S.Curve check
TRK
[6] Focus Mode *2 switching TRK MIN SEC 0x 0x 0x
[1] Tracking Servo Close
TRK
[] CRG+
TRK *8
[] CRGTRK *8
[2]
Automatic adjustment display switching
TRK *3
91 MIN91 SEC 91
or
TRK
00 MIN00 SEC00 99 MIN99 SEC99
or
TRK
00 MIN00 SEC00 99 MIN99 SEC 99
or
TRK
00 MIN00 SEC00 99 MIN 99 SEC 99
?? MIN?? SEC ??
[BAND] Power Off
TRK MIN SEC
[1] T.Close and AGC
Applicable servomechanism TRK MIN SEC
[6] T.Close
Applicable servomechanism
TRK
[3] RF AGC /
RF AGC coefficient display
TRK ?? MIN ?? SEC ?? SEC
[] CRG+
TRK8x MIN8x SEC8x
[] CRGTRK8x MIN8x SEC8x
[2]
T.Balance adjustment /
T.Balance coefficient display
TRK ?? MIN?? SEC ??
?tr
?min ?sec
?tr
MIN
?min ?sec
or
TRK 9x MIN 9x SEC 9x
or
TRK 9x MIN 9x SEC 9x
C
[BAND] Power Off
TRK MIN SEC
[1] F, T, RF AGC
TRK *7
[3] F, T AGC / F.Bias RF AGC
TRK
[6] CRG/TR Jump value switching
TRK *5
[]
*4
[]
*4
[2] Tracking Open
TRK
F.Bias display switching
CRG/TR Jump +
TRK
CRG/TR Jump TRK
?? MIN?? SEC ??
?tr
MIN
?min ?sec
SEC
?tr
MIN
?min ?sec
SEC
?tr
MIN
?min ?sec
SEC
?tr
MIN
?min ?sec
*6
SEC
or
TRK
8x MIN8x SEC 8x 9xMIN 9xSEC 9x
[BAND] Power Off
TRK MIN SEC
[2] Tracking Open
TRK8x MIN8x SEC8x
or
TRK 9x MIN 9x SEC 9x
D
*1)
TRK
TYP
MIN SEC
-6dB
TRK 06 MIN 06 SEC 06
-12dB
TRK 12 MIN 12 SEC 12
[Key]
Operation Test Mode
*2) Focus Close
S.Curve ckeck setting
TRK 01 MIN 01 SEC 01
F EQ measurement setting
TRK 02 MIN 02 SEC 02
[BAND] Power On/Off [] [] [1] CRG + / TR Jump + (Direction of the external surface) CRG - / TR Jump (Direction of the internal surface) T.CLS and AGC and Applicable servomechanism / AGC, AGC display switching RF Gain switching / Offset adjustment display / T.Balance adjustment / T.Open F.Close, S.Curve / Rough Servo and RF AGC / F, T, RF AGC SPDL 1X/2X switching As for the double speed (2x), audio output cannot be supported. Error Rate measurement 1st-ON : ERR count beginning(30Sec) 2nd-ON : BER display data[%] F. Mode switching / Tracking Close / CRG, TR Jump switching
TRK 00 MIN 00 SEC 00 (TRK 99 MIN 99 SEC 99)
*3) F.Offset Display T.Offset Display Switch to the order of the original display
E
*4) 1TR / 32TR / 100TR *5) Single TR 32TR 100TR CRG Move 9x(8x) : 91(81) 92(82) 93(83) 94(84) *6) Only at the time of CRG Move, 100TR Jump *7) TRK/MIN/SEC F.AGC T.AGC F.Bias RF AGC
[2] [3] [4] [5] [6] 2X
TRK 22 MIN 22 SEC 22
*8) CRG motor voltage = 2[V] *9) TYP(1X)
TRK MIN SEC
1X
TRK 11 MIN 11 SEC 11
As for the double speed (2x), audio output cannot be supported. TYP(2X)
TRK MIN SEC
1X
TRK 11 MIN 11 SEC 11
2X
TRK 22 MIN 22 SEC 22
F
58
DEH-P8MP/XN/UC
1 2 3 4
5
6
7
8
6.4 CHECKING THE GRATING AFTER CHANGING THE PICKUP UNIT
A
· Note : The grating angle of the PU unit cannot be adjusted after the PU unit is changed. The PU unit in the CD mechanism module is adjusted on the production line to match the CD mechanism module and is thus the best adjusted PU unit for the CD mechanism module. Changing the PU unit is thus best considered as a last resort. However, if the PU unit must be changed, the grating should be checked using the procedure below. · Purpose : To check that the grating is within an acceptable range when the PU unit is changed. · Symptoms of Mal-adjustment : If the grating is off by a large amount symptoms such as being unable to close tracking, being unable to perform track search operations, or taking a long time for track searching. · Method : · Measuring Equipment · Measuring Points · Disc · Mode
B
· Oscilloscope, Two L.P.F. · E, F, REFO1 · TCD-782 · TEST MODE
CD CORE UNIT(S10WMACODE2)
C
L.P.F. REFO1 E VREF Xch 100k 390pF Ych
Oscilloscope
F VREF
100k 390pF L.P.F.
D
F E
· Checking Procedure 1. In test mode, load the disc and switch the 3V regulator on. 2. Using the and buttons, move the PU unit to the innermost track. 3. Press key 3 to close focus, the display should read "91". Press key 2 to implement the tracking balance adjustment the display should now read "81". Press key 3. The display will change, returning to "81" on the fourth press. 4. As shown in the diagram above, monitor the LPF outputs using the oscilloscope and check that the phase difference is within 75° . Refer to the photographs supplied to determine the phase angle. 5. If the phase difference is determined to be greater than 75° try changing the PU unit to see if there is any improvement. If, after trying this a number of times, the grating angle does not become less than 75° then the mechanism should be judged to be at fault. · Note Because of eccentricity in the disc and a slight misalignment of the clamping center the grating waveform may be seen to "wobble" ( the phase difference changes as the disc rotates). The angle specified above indicates the average angle. · Hint Reloading the disc changes the clamp position and may decrease the "wobble".
E
F
DEH-P8MP/XN/UC
5 6 7 8
59
1
2
3
4
Grating waveform
A
Ech Xch 20mV/div, AC Fch Ych 20mV/div, AC 30°
0°
B
45°
60°
C
D
75°
90°
E
F
60
DEH-P8MP/XN/UC
1 2 3 4
5
6
7
8
6.5 ERROR MODE
- Error Messages
If a CD is not operative or stopped during operation due to an error, the error mode is turned on and cause(s) of the error is indicated with a corresponding number. This arrangement is intended at reducing nonsense calls from the users and also for facilitating trouble analysis and repair work in servicing.
A
(1) Basic Indication Method 1) When SERRORM is selected for the CSMOD (CD mode area for the system), error codes are written to DMIN (minutes display area) and DSEC (seconds display area). The same data is written to DMIN and DSEC. DTNO remains in blank as before.
2) Head unit display examples Depending on display capability of LCD used, display will vary as shown below. xx contains the error number. 8-digit display ERRORxx 6-digit display ERRxx 4-digit display Exx
B
(2) Error Code List Displayed error code Description of the code and potential cause(s) Code Class Electricity Carriage Home NG CRG can't be moved to inner diameter. 10 CRG can't be moved from inner diameter. SERVO LSI Communication Error 11 12 Electricity Electricity Focus Servo NG Spindle Lock NG Subcode NG Failure on home switch or CRG move mechanism. Communication error between microcomputer and SERVO LSI. Focusing not available. Stains on rear side of disc or excessive vibrations on REWRITABLE. Spindle not locked. Sub-code is strange (not readable). Failure on spindle, stains or damages on disc, or excessive vibrations. A disc not containing CD