Text preview for : CDX-CA650_CA650V_CA650X Ver1.0.pdf part of SONY CDX-CA650/CA650V/CA650X Ver1.0
Back to : CDX-CA650_CA650V_CA650X V | Home
CDX-CA650/CA650V/CA650X
SERVICE MANUAL
Ver 1.0 2001. 01
AEP Model UK Model
Photo: CDX-CA650X
· The tuner and CD sections have no adjustments.
Model Name Using Similar Mechanism CD Drive Mechanism Type Optical Pick-up Name
NEW MG-393X-121//Q KSS-720A
SPECIFICATIONS
CD player section
Signal-to-noise ratio Frequency response Wow and flutter 90 dB 10 20,000 Hz Below measurable limit
General
Outputs Audio outputs Power aerial relay control lead Power amplifier control lead Telephone ATT control lead Remote controller input connector Aerial input connector Bass ±8 dB at 100 Hz Treble ±8 dB at 10 kHz 12 V DC car battery (negative ground) Approx. 178 × 50 × 177 mm (w/h/d) Approx. 182 × 53 × 161 mm (w/h/d) Approx. 1.2 kg Parts for installation and connections (1 set) Front panel case (1)
Tuner section
FM Tuning range Aerial terminal Intermediate frequency Usable sensitivity Selectivity Signal-to-noise ratio 87.5 108.0 MHz External aerial connector 10.7 MHz/450 kHz 8 dBf 75 dB at 400 kHz 66 dB (stereo), 72 dB (mono) Harmonic distortion at 1 kHz 0.6% (stereo), 0.3% (mono) Separation 35 dB at 1 kHz Frequency response 30 15,000 Hz MW/LW Tuning range
Inputs
Tone controls Power requirements Dimensions Mounting dimension Mass Supplied accessories
MW: 531 1,602 kHz LW: 153 279 kHz Aerial terminal External aerial connector Intermediate frequency 10.7 MHz/450 kHz Sensitivity MW: 30 µV LW: 40 µV
Design and specifications are subject to change without notice.
Power amplifier section
Outputs Speaker outputs (sure seal connectors) Speaker impedance 4 8 ohms Maximum power output 50 W × 4 (at 4 ohms)
FM/MW/LW COMPACT DISC PLAYER
9-870-260-11
2001A0400-1 © 2001. 1
Sony Corporation
Audio Entertainment Group General Engineering Dept.
1
CDX-CA650/CA650V/CA650X
SERVICE NOTES 1. GENERAL
TABLE OF CONTENTS
Location of Controls ................................................................ 3 Getting Started ......................................................................... 3 CD Player ................................................................................ 4 Radio ....................................................................................... 5 RDS ......................................................................................... 6 Connections ............................................................................. 7 This label is located on the bottom of the chassis.
2. DISASSEMBLY
2-1. Sub Panel Assy .................................................................... 8 2-2. CD Mechanism Block ......................................................... 8 2-3. Main Board ......................................................................... 8 2-4. Heat Sink ............................................................................. 9 2-5. Chassis (T.U) Assy .............................................................. 9 2-6. Disc In Board, Guid (Disc) ............................................... 10 2-7. Servo Board ....................................................................... 10 2-8. Arm Roller Assy ................................................................ 11 2-9. Chassis (OP) Assy ............................................................. 11 2-10. Optical Pick-up Block ....................................................... 12
This label is located on the drive unit's internal chassis. When replacing the chassis (T.U) of mechanism deck which have the "CAUTION LABEL" attached, please be sure to put a new CAUTION LABEL (3-223-913-11) to the chassis (T.U). NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT The laser diode in the optical pick-up block may suffer electrostatic breakdown because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic breakdown and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care. NOTES ON LASER DIODE EMISSION CHECK The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens. Notes on Chip Component Replacement · Never reuse a disconnected chip component. · Notice that the minus side of a tantalum capacitor may be damaged by heat.
3. DIAGRAMS
3-1. IC Pin Descriptions ........................................................... 13 3-2. Block Diagram CD Section ........................................... 15 3-3. Block Diagram Tuner Section ....................................... 16 3-4. Block Diagram Display Section .................................... 17 3-5. Circuit Boards Location .................................................... 17 3-6. Printed Wiring Boards CD Mechanism Section ............ 18 3-7. Schematic Diagram CD Mechanism Section ................ 20 3-8. Printed Wiring Board Main Section .............................. 21 3-9. Schematic Diagram Main Section (1/2) ........................ 22 3-10. Schematic Diagram Main Section (2/2) ........................ 23 3-11. Printed Wiring Board Sub (CD) Section ....................... 24 3-12. Schematic Diagram Sub (CD) Section .......................... 25 3-13. Schematic Diagram Key Section .................................. 26 3-14. Printed Wiring Board Key Section (CA650/CA650X) .................................... 27 3-15. Printed Wiring Board Key Section (CA650V) .............. 28
4. EXPLODED VIEWS
4-1. 4-2. 4-3. 4-4. 4-5. Chassis Section ................................................................. 32 Front Panel Section ........................................................... 33 CD Mechanism Section (1) ............................................... 34 CD Mechanism Section (2) ............................................... 35 CD Mechanism Section (3) ............................................... 36
5. ELECTRICAL PARTS LIST ........................................ 37
SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
2
CDX-CA650/CA650V/CA650X SECTION 1 GENERAL
This section is extracted from instruction manual.
3
CDX-CA650/CA650V/CA650X
4
CDX-CA650/CA650V/CA650X
5
CDX-CA650/CA650V/CA650X
6
CDX-CA650/CA650V/CA650X
7
7
CDX-CA650/CA650V/CA650X SECTION 2 DISASSEMBLY
· The equipment can be removed using the following procedure.
2-2. CD MECHANISM BLOCK Main Board Heat Sink
7 bracket (CD)
Set
Sub Panel Assy
CD Mechanism Block
Chassis (T.U) Assy
Disc In Board, Guide (Disc) Servo Board
Arm Roller Assy
5 CD mechanism block
6 PTT 2.6x4
Chassis (OP) Assy
Optical Pick-up Block
2 PTT 2.6x4
3 1 PTT 2.6x4
4 CNP301
Note : Follow the disassembly procedure in the numerical order given.
2-1. SUB PANEL ASSY
2-3. MAIN BOARD
6 MAIN board 4 two claws 5 ground point screws (PTT 2.6x6)
4 ground point screw (PTT 2.6x6)
6 sub panel assy
3 PTT 2.6x4 2 PTT 2.6x6 3 claw
5 CN701 1 PTT 2.6x6
2 PTT 2.6x4
1 PTT 2.6x4
8
8
CDX-CA650/CA650V/CA650X
2-4. HEAT SINK
4 heat sink
3 PTT 2.6x10
2 PTT 2.6x16
1 PTT 2.6x10
2-5. CHASSIS (T.U) ASSY
2 P 2x3 3 P 2x3
1 Unsolder the lead wires.
4 chassis (T.U) assy
black red white
9
CDX-CA650/CA650V/CA650X
2-6. DISC IN BOARD, GUIDE (DISC)
4 guide (disc)
3 tension spring (LR) 1 PS 2x4 2 DISC IN board
4 claws
2-7. SERVO BOARD
7 PS 2x4 8 PS 2x4 3 Removal the solders. 2 CN2
1 CN3 5 P 2x3 9 SERVO board 4 Removal the solders.
6 loading motor assy (M903)
10
CDX-CA650/CA650V/CA650X
2-8. ARM ROLLER ASSY
· When installing, take note of the positions arm (roller) and washers. (Fig. 1) retaining ring (roller) arm bearing (roller) washer(RA) washer(RA) bearing (roller) arm
Fig. 1
2 arm roller assy
3 PS 2x3
4 LOAD board
1 tension spring (RA3)
2-9. CHASSIS (OP) ASSY
7 chassis (OP) assy
8 compression spring (FL)
1 tension spring (KF1) 9 compression spring (FL)
2 tension spring (KR1)
5 Fit lever (D) in the direction of the arrow.
6 Turn loading ring in the direction of the arrow. 3 damper (T) 4 damper (T)
11
CDX-CA650/CA650V/CA650X
2-10. OPTICAL PICK-UP BLOCK
1 P 2x3
2 sled motor assy (M902) 3 optical pick-up block
12
CDX-CA650/CA650V/CA650X SECTION 3 DIAGRAMS
3-1. IC PIN DESCRIPTION
· IC501 MN101C49KTH (SYSTEM CONTROL) Pin No. Pin Name I/O Pin Description 1 VREF -- A/D converter power supply () pin 2 VSM I S-meter voltage detection input 3 NIL (FMAGC) I Not used. (Connect to VSS in this set) 4, 5 KEYIN1, 0 I Key input 1, 0 6 RCIN0 I Rotary commander key input 7 QUALITY I Noise detection input 8 MPTH I Multipath detection input 9 NIL (DSTSEL) I Not used. (Fixed at L in this set) 10 VREF+ -- A/D converter power supply (+) pin (+5 V) 11 VDD -- Power supply pin (+5 V) 12 OSCOUT O Main clock output (18.43 MHz) 13 OSCIN I Main clock input (18.43 MHz) 14 VSS -- Ground 15 XIN I Sub clock input (32.768 kHz) 16 XOUT O Sub clock output (32.768 kHz) 17 MMOD I Memory mode select input (Fixed at L in this set) 18 LCDSO O Serial data output for LCD driver IC. 19 LCDCE O Chip enable output for LCD driver IC. 20 LCDCKO O Serial clock output for LCD driver IC. 21 CD TSO O Serial data output for CD servo IC. 22 CD TSI I Serial data input from CD servo IC. 23 CD TCKO O Serial clock output for CD servo IC. 24 SYSRST O System reset output 25 BUSON O BUS ON output 26 KEYACK I Key acknowledge detection input 27 DAVN I RDS data block synchronization detection input 28 BUIN I Backup power supply input 29 SIRCS I SIRCS input 30 CD SELFSW I CD mechanism deck Self switch detection input 31 CD PACK I CD text pack synchronization signal input from CD servo IC. 32 VDD2 -- Power supply pin (+5 V) 33 RESET I Microcomputer reset input 34 NOSESW I Front panel attachment detection input 35 BEEP O Beep output 36 NCO O Not used. (Open) 37 TESTIN I Test mode detection input 38 ACCIN I Accessory power supply detection input 39 NCO (VCC) O Not used. (Open) 40 TELATT I Telephone attenuator detection input 41 NCO (VCC) I Not used. (Fixed at H in this set) 42 UNISO O SONY-BUS data output 43 UNISI I SONY-BUS data input 44 UNICKO O SONY-BUS clock output 45 12C SIO I/O I2C BUS serial data input/output 46 NCO O Not used. (Open) 47 12C CKO O I2C BUS serial clock output 48 NCO O Not used. (Open) 49 TUNON O Tuner power supply control output 50 PW ON O System power supply control output 51 TSTB O CD text parameter strobe output for CD servo IC. 52 RFOK I RFOK signal input from CD servo IC.
13
CDX-CA650/CA650V/CA650X
Pin No. 53 54 55 56 57 58 59 60 61 62 63 64, 65 66 67 68 69 70 71 75 76 77 78 79 80 81 85 86 87 88 89 90 91 92 93 94 95 96, 97 98 99 100
Pin Name CD RST A0 STB X EN LIMIT PH1 D SW INSW NC (PH3) CD LM LO CD LM EJ NCO AMPATT AMPON CDMD ON ATT VOLATT NCO COLSW COLSEL DIMSEL XCD ON NCO NCO E2P SIO E2P CKO NCO FLASH W NS MASK AD ON DOORIND ILLON DOORSW DAVSS REIN1, 0 RCIN1 RAMBU DAVDD
I/O O O O O I I I I O O O O O O O O O O I I I O O O I/O O O I O O O O I -- I I I --
Pin Description Reset signal output for CD servo IC. Command/parameter discrimination signal output for CD servo IC. Data strobe signal output for CD servo IC. Crystal oscillation control output for CD servo IC. CD mechanism deck Limit switch detection input CD mechanism deck PH1 detection input (Not used in this set) CD mechanism deck Down switch detection input CD mechanism deck Disc in switch detection input CD mechanism deck PH3 detection input (Not used in this set) CD mechanism deck loading motor control output (Loading direction) CD mechanism deck loading motor control output (Eject direction) Not used. (Open) Power amplifier attenuator control output Power amplifier standby control output CD mechanism deck power supply control output System attenuator control output Electric volume attenuator control output Not used. (Open) Key illumination 1 color/2 color select initial setting input (L: 1 COLOR, H: 2 COLOR) (Fixed at L: CDX-CA650, H: CDX-CA650V/CA650X) 1 color initial setting input (L: amber, H: green) (Fixed at L in this set) Manual dimmer initial setting input (L: dimmer without, H: dimmer with) (Fixed at L: CDX-CA650/CA650X, H: CDX-CA650V) CD signal processing crystal drive output Not used. (Fixed at L in this set) Not used. (Open) EEPROM serial data input/output EEPROM serial clock output Not used. (Open) Flash microcomputer write detection input Noise mask output Key power supply control output Sub panel power control output Illumination power control output Front panel OPEN/CLOSE detection input D/A converter power supply () pin Rotary encoder input 1, 0 Rotary commander SHIFT key input Not used. (Fixed at L in this set) D/A converter power supply (+) pin (+5 V)
14
CDX-CA650/CA650V/CA650X
3-2. BLOCK DIAGRAM -- CD SECTION --
OPTICAL PICK-UP KSS-720A
RF AMP,DIGITAL SERVO DIGITAL SIGNAL PROCESSOR IC1
A
82
A
(Page 16) TUNER SECTION
RF EQ EFM DEMOD D/A CONV LOUT 16 ROUT 12 PACK 52 TSTB 56 SI FORCUS ERROR I/F SO SCK STB AO TRACKING ERROR LD AMP RST SERVO CTL CDL R-CH
C B
83 84
C B
A
SYSTEM CONTROL IC501(1/3)
D
I-V CONV.
D 85
DSUB CODE PROCESS
31 CD PACK 51 TSTB
8 7 6 5 4 3
21 CD TSO 22 CD TSI 23 CD TCKO 55 STB 54 AO 53 CD RST
E F PD
E 87 86 F PD
RFOK
2
52 RFOK
97
OSC LD DRIVE Q1 LD SD TD FD
XTALEN
9
56 XEN
BUS INTERFACE IC505 BATT DET Q556
98
MD
LD
BU IN 28 23 24 SYS RST 24 X1 16.9344MHz
10
3
BATT
62 63 64 65 FOCUS/TRACKING COIL DRIVE SLED/SPINDLE/LOADING MOTOR DRIVE IC2 FOCUS COIL DRIVE
13
2
BUS ON 25
12
1 8
FOCUS COIL
15 16
26
FD SW1 (DISC IN) SW2 (SELF) SW3 (LIMIT) SW4 (DOWN) 60 IN SW UNI SO 42 9 6 30 CD SELF SW UNI SI 43 8 6 5 4
3 2 1 7
TRACKING COIL
17 18
TRACKING COIL DRIVE
23
TD
57 LIMIT
UNI CKO 44
11
4
CNJ600 (BUS CONTROL IN)
59 D SW IC602 RESET 33 1 RESET 2 BU 5V
M902 (SLED)
M
13 14
SLED MOTOR DRIVE SPINDLE MOTOR DRIVE
5
SD
M901 (SPINDLE)
M
11 12
6
MD
S702 RESET
M903 (LOADING)
M
9 10
LOADING MOTOR DRIVE
1 2
LOAD EJECT
62 CD LM LO 63 CD LM EJ POWER CONTROL Q332 POWER CONTROL Q333 REG Q331 BATT
68 CDMD ON
A5V AU5V D5V DR6V
REG Q341
· Signal path :CD
79 XCD ON
15
15
CDX-CA650/CA650V/CA650X
3-3. BLOCK DIAGRAM -- TUNER SECTION --
PJ401-1,-2 BUS AUDIO IN -1 -2 L R
PJ401-3, -4 AUDIO OUT REAR -3 -4 L R
PJ401-5, -6 AUDIO OUT FRONT -5 -6 L R POWER AMP IC404
R-CH
R-CH
R-CH
(Page 15)
TUNER UNIT TU10 J10 (ANTENNA)
ELECTRONIC VOLUME IC401 4 AUX LCH OUT FL 28
CNP601 5 3 1 FL+ 9 FL
A
CD SECTION
CDL
12
43 MD LCH 12 MPXI 9 AM OUT RL 27 Q451 MUTE Q431 MUTE 11 16 AUX 4 STBY 22 MUTE 4 FR+ 12 FR R-CH 3 RR+ 11 RR MUTE CONT Q478,479 9 7 2 RL+ 10 RL
2 ANTFM 1 ANTAM
MPX 10 AM DET 8
BUFFER Q10
13 14 19 20 17
LEVEL MPIN SDA SCL EXA ATT
BATT F901
16 BATT
SYSTEM CONTROL IC501 (2/3) IC20 5 NOISE 1 SUPPRESSOR Q22 NOISE SUPPRESSOR ON S-METER 14 I2C SDA 12 I2C SCL 13 9 SDA 20 LV IN 10 SCL MULTI PATH DET RDS/RDBS DEM/DEC OSCI 5 X51 4.332MHz E2PROM SDA 17 E2PROM SCL 18 86 E2P SIO 87 E2P CKO 2 RDS DECODER IC51 8 MPTH ATT BEEP AMP ON AMP ATT TEL ATT 69 35 67 66 40 ACC CHECK Q631 POWER SUPPLY IC601 BATT 7 VCC 2 8.7V ON 3 5.6V ON 4 STB AMP +B 6 ANT +B 8 BU+B COM 8V TU 5.6V TU 8.7V 5 9 10 11 BU 5V COM 8V TU 5.6V TU 8.7V 5 AMP R 6 ANT R
70 VOL ATT 7 QUALITY
TEL ATT Q651
13 ATT 7 ACC 15 TEST
90 NS MASK
ACC IN 38 TEST IN 37
2 VSM 45 I2C SIO 47 I2C CKO
TUN ON 49 PW ON 50
RDS DET 9
16
MPX
8
27 DAVN
OSCO 4
· Signal path :FM :MW :CD
16
16
CDX-CA650/CA650V/CA650X
3-4. BLOCK DIAGRAM -- DISPLAY SECTION --
3-5. CIRCUIT BOARDS LOCATION
SYSTEM CONTROL IC501 (3/3) KEY MATRIX LSW901-911,914-919 S902-907 LSW801 5 KEY IN0
LCD DRIVE IC900
DISC IN board
LCD SO 18 LCD CKO 20 LCD CE 19 78 DATA 77 CLK 76 CE GREEN 80 AMBER 79 KEY ACTIVE Q665 LCD901
SUB board
4 KEY IN1
SUB (CD) board
LIMIT board
26 KEY ACK 91 AD ON DOOR IND DRIVE Q633
CA650 AMBER DRIVE Q901 GREEN DRIVE Q902 LED DRIVE Q906
CA650V LED DRIVE Q905
DOOR IND 92 J501 (REMOTE IN) 98 RC IN1 6 RC IN0 IC971 IR RECEIVE 29 SIRCS
tuner unit (TU10)
LED801,LSW801 POWER CONT Q662 LSW901-911,814-919 LED900,901,913,914 LED905,906 909,910
LOAD board
MAIN board
ROTARY ENCODER RE901
97 RE IN0 96 RE IN1
ILL ON 93
KEY board
34 NOSE SW 15 XIN 16 XOUT OSC OUT 12 OSC IN 13 BATT REG Q660,661 ILL +B
SERVO board
S701 (NOSE DET) X502 32.768kHz
X501 18.43MHz
LED902,903
· Waveforms -- Servo Board --
(MODE: CD PLAY)
-- Main Board --
1
2.4Vp-p
1
3.6Vp-p 4.332MHz
16.9344MHz
IC1
wd
(X TAL)
IC51
5
(OSCI)
2
4.8Vp-p 3.4msec
2
1.8Vp-p
IC1
ts
(PACK)
18.43MHz
IC501
qd
(OSCIN)
3
1.8Vp-p
3
2.2Vp-p 32.768kHz
IC1
uj
(RFO)
IC501
qg
(XIN)
4
0V Approx. 620mVp-p
IC1
oa
(FEO)
5
0V Approx. 200mVp-p
IC1
od
(TEO)
17
17
CDX-CA650/CA650V/CA650X
3-6. PRINTED WIRING BOARDS -- CD MECHANISM SECTION --
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) for schematic diagram: · All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. · All resistors are in and 1/ 4 W or less unless otherwise specified. · % : indicates tolerance. f · : internal component. · C : panel designation. Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. · A : B+ Line. · Power voltage is dc 14.4V and fed with regulated dc power supply from ACC and BATT cords. · Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal production tolerances. · Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. · Circled numbers refer to waveforms. · Signal path. F : FM f : MW J : CD for printed wiring boards: · X : parts extracted from the component side. · Y : parts extracted from the conductor side. x : parts mounted on the conductor side. · a · : Through hole. · : Pattern from the side which enables seeing. (The other layer's patterns are not indicated.) Caution: Pattern face side: (Side B) Parts face side: (Side A) Parts on the pattern face side seen from the pattern face are indicated. Parts on the parts face side seen from the parts face are indicated.
18
18
CDX-CA650/CA650V/CA650X
· Semiconductor Location Ref. No. IC1 IC2 Q1 Location D-2 G-2 B-3
(Page 21)
19
19
CDX-CA650/CA650V/CA650X
· Refer to page 17 for Waveforms. 3-7. SCHEMATIC DIAGRAM -- CD MECHANISM SECTION -- · Refer to page 29 for IC Block Diagrams.
IC B/D
(Page 22)
IC B/D
Note: · Voltage is dc with respect to ground under no-signal conditions. no mark : CD PLAY
20
20
CDX-CA650/CA650V/CA650X
3-8. PRINTED WIRING BOARD -- MAIN SECTION --
(Page 19)
· Semiconductor Location Ref. No. Location Ref. No. D21 J-2 D713 D22 J-2 D714 D23 I-3 D720 D331 H-13 D332 H-13 IC20 D341 G-9 IC51 D471 A-9 IC401 D472 A-9 IC404 D473 A-9 IC501 D474 A-9 IC505 D475 C-8 IC601 D476 A-10 IC602 D477 C-8 D478 A-11 Q21 D479 D-8 Q22 D551 D-13 Q331 D553 B-12 Q332 D554 C-12 Q333 D555 C-12 Q341 D556 D-13 Q431 D601 B-12 Q441 D609 E-11 Q451 D610 E-6 Q461 D611 B-11 Q478 D612 D-10 Q479 D613 D-10 Q556 D614 C-11 Q631 D621 G-13 Q651 D662 J-13 Q660 D671 K-4 Q661 D701 J-4 Q662 D710 L-3 Q663 D711 K-2 Q664
Location L-2 L-2 K-2 I-1 I-4 D-4 B-7 I-8 I-11 F-13 J-10 J-2 I-3 H-13 I-13 H-13 G-10 B-5 B-5 B-4 B-4 E-8 E-9 C-13 E-10 E-10 I-14 J-13 I-13 J-14 J-6
(Page 24)
21
21
CDX-CA650/CA650V/CA650X
· Refer to page 17 for Waveforms. 3-9. SCHEMATIC DIAGRAM -- MAIN SECTION (1/2) -- · Refer to page 29 for IC Block Diagrams.
IC B/D
IC B/D
(Page 23)
(Page 20)
Note: · Voltage is dc with respect to ground under no-signal (detuned) condition. no mark : FM ( ) : MW < > : CD PLAY
22
22
CDX-CA650/CA650V/CA650X
3-10. SCHEMATIC DIAGRAM -- MAIN SECTION (2/2) -- · Refer to page 29 for IC Block Diagrams.
IC B/D
(Page 22)
IC B/D
(Page 25)
Note: · Voltage is dc with respect to ground under no-signal (detuned) condition. no mark : FM
23
23
CDX-CA650/CA650V/CA650X
3-11. PRINTED WIRING BOARD -- SUB (CD) SECTION --
(Page 21)
(Page 27, 28)
24
24
CDX-CA650/CA650V/CA650X
3-12. SCHEMATIC DIAGRAM -- SUB (CD) SECTION --
(Page 26) (Page 23)
25
25
CDX-CA650/CA650V/CA650X
3-13. SCHEMATIC DIAGRAM -- KEY SECTION --
(Page 25)
Note: · Voltage is dc with respect to ground under no-signal (detuned) condition. no mark : FM
26
26
CDX-CA650/CA650V/CA650X
3-14. PRINTED WIRING BOARD -- KEY SECTION (CA650/CA650X) --
· Semiconductor Location Ref. No. Location Ref. No. (D901) C-10 LED901 (D902) C-11 LED902 (D903) C-11 LED903 (D904) C-11 LED905 (D906) C-11 LED906 (D908) C-10 LED909 D971 A-11 LED910 LED913 (IC900) C-8 LED914 IC971 A-11 (Q901) LED900 A-2 (Q902) ( ) : SIDE B
Location C-2 B-1 B-1 A-4 A-10 B-10 B-4 B-12 B-13 B-4 C-4
(Page 24)
27
27
CDX-CA650/CA650V/CA650X
3-15. PRINTED WIRING BOARD -- KEY SECTION (CA650V) --
· Semiconductor Location Ref. No. Location Ref. No. (D901) B-10 LED900 (D902) C-11 LED901 (D903) C-11 LED902 (D904) C-11 LED903 (D906) C-11 LED905 (D908) C-10 LED906 D971 A-11 LED913 LED914 (IC900) B-8 IC971 A-10 (Q905) (Q906) ( ) : SIDE B
Location A-2 C-2 B-1 B-1 A-4 A-10 B-12 B-13 B-5 B-5
(Page 24)
28
28
CDX-CA650/CA650V/CA650X
· IC Block Diagrams IC1 µPD63711GC-8EB
7D DAC2 7C DAC1 7E DAC3 7F DAC0 ATEST TEST1 TEST0 DGND AGND DVDD 51 AGCO AVDD PACK 52 TSCK TSTB EFM ASY TSO 53 C3T MD TSI 54 RFI SD TD 63 FD 62
75
74
73
72
71
70
69
68
67
66
65
64
61
60
59
58
57
56
55
AGCI 76 RFO 77 EQ2 78 EQ1 79 RF- 80 AGND 81 A 82 C 83
EFM COMPARATOR EFM D/A MEMORY PROCESSOR 16K SRAM
MICROCOMPUTER INTERFACE ERROR CORRECTION PROCESSOR OUTPUT PROCESSOR 25 XGND
50 C2D3 49 C2D2 48 C2D1 47 C1D2 46 C1D1 45 DGND
CD-TEXT DECODER SUB-CODE PROCESSOR
AUTO GAIN CONTROLLER
FD/TD/SD/MD CONTROLLER
ADDER FEOFS SVDRAM TEOFS MULTIPLIER SVROM SVCRAM ROM DECODER
EFM DEMODULATOR
DIGITAL PLL
44 PLCK 43 MIRR/WFCK
B 84 D 85 F 86 E 87 AVDD 88 REFOUT 89 FE- 90 DEFECT FEO 91 A/D CONVERTER TE- 92 TEO 93 TE2 94 TEC 95 AGND 96 PD 97 LD 98 FOK A3T MIRR FEO TEO COMPARATOR SWITCH EFM RF AMP BLOCK
TIMING GENERATOR
42 RFCK 41 LOCK 40 DVDD 39 TSOI
CLV PROCESSOR DIGITAL AUDIO INTERFACE D/A INTERFACE CIRCUIT DE-EMPHASIS CIRCUIT
38 C16M 37 DGND 36 TX 35 HOLD/WDCK 34 LRCK 33 LRCKIN 32 SCKO 31 SCKIN 30 DOUT 29 DIN 28 FLAG OUTPUT BUFFER OUTPUT BUFFER 27 EMPH
DEFECT COMPARATOR RFENV MIRENV TRACKING REGISTER FOCUS REGISTER
OCTUPLED OVERSAMPLING DIGITAL FILTER NOISE SHAVER NOISE SHAVER
PN 99 AVDD 100 MICROCOMPUTER INTERFACE SCF OSC
26 DVDD
1 DGND
2 RFOK
3 RST
4 A0
5 STB
6 SCK
7 SO
8 SI
9 XTALEN
10 DVDD
11 DAVDD
12 ROUT
13 DAGND
14 REGC
15 DAGND
16 LOUT
17 DAVDD
18 R+
19 R
20 L
21 L+
22 XVDD
23 XTAL
24 XTAL
IC51 SAA6588T
SCOUT LVIN MPX MAD PSWN 12 11 PAUSE DETECTOR VSSA VDDA VREF CIN AFIN 13 IIC BUS SLAVE TRANSCEIVER 9 SDA 10 SCL
20
19
18
17
16
15
14
MULTI PATH DETECTOR
POWER SUPPLY & RESET 57kHz 8th ORDER BAND-PASS FILTER SIGNAL QUALITY DECODER 4 CLOCK 5 4 CLOCK INTERFACE REGISTER DATA DATA
CLOCKED COMPARATOR
RDS/RDBS DEMODULATOR
RDS/RDBS DECODER
TEST CONTROL
OSCILLATOR & CLOCK
1 2 MRO MPTH
3 TCON
4 OSCO
5 OSCI
6 VSSD
7 VDDD
8 DAVN
29
CDX-CA650/CA650V/CA650X
IC2 BA5810FP
IC505 BA8270F
FWD
1 LOADING PRE FWD REV X3 POWER SAVE
+
28 BIAS
BUS ON 1
BUS ON SWITCH RESET SWITCH BATTERY SWITCH
14 VCC
REV
2
27 OPIN4+ 26 OPIN4
+
RST 2
LDCONT PS IN1 IN2
3 4 5
BATT 3 25 OPOUT4 24 OPIN3+ 23 OPIN3 CLK 4 VREF 5 DATA 6 GND 7
13 12 11 10
RST BUS ON CLK IN BU IN
7.5k
7.5k
6 16k PREVCC (PRE.LOADING) 7.5k
+
+
16k
POWVCC12 (CH1.CH2) 16k POWVCC 8
7.5k
PREVCC
7
+
+
16k
VOL
9
POWVCC34 (CH3,CH4) 20 POWVCC
VOL+ 10 10k 10k
10k
10k VO1 13 VO1+ 14 10k 10k
10k 10k LEVEL SHIFT 10k LEVEL SHIFT
+
10k 10k
+
+
10k
IC601 BA4908-V3
REGULATOR
OVER VOLTAGE PROTECT + + + +
1 NC
2 3 4 MODE2 MODE1 STB
5 VDD
6 AMP
COM
30
GND
VCC
ANT
AM
FM
VO2+ 12
LEVEL SHIFT
+
+
VO2 11
LEVEL SHIFT
9 DATA IN 8 DATA OUT
22 OPOUT3
CH1-4 MUTE
21 MUTE
19 GND 10k
18 VO3 17 VO3+
+ + +
10k 10k 16 VO4 15 VO4+ 10k
7
8
9
10
11
12
CDX-CA650/CA650V/CA650X
IC401 TDA7406T
MIXINFL MIXINRL MIXINRR MIXINFR
OUTSW
OUTFR OUTRR
33 32 31 30 29
28 27 MIXER
26 25
24
23
SOFT STEP FADER
SOFT STEP FADER
SOFT STEP FADER
MONO FADER
SAOUT CREF
OUTFL OUTRL
ACINL
SUPPLY
22 VDD
SUB WOOFER FILTER OUTPUT SELECTOR SWIN 34 ACINR 35
21 SACLK 20 SCL 19 SDA 18 GND
17 ATT ACOUTR 36 SWACOUT 37 AC OUTL 38 HIGH PASS
IIC-BUS
QUAL.
16 QUAL
A/D 7BAND EQUALIZER CREF 39 SOFT STEP VOLUME SOFT MUTE DIGITAL CONTROL HIGH OUT S&H 25kHz LP AM/FM NOISE BLANKER DEMODULATOR +STEREO ADJUST +STEREO BLEND BEEP IN GAIN + AUTO ZERO MULTI PATH DETECTOR 15 MP OUT 14 MP IN PULSE FORMER
LOUDNESS SPECTRUM ANALIZER
PILOT CANCELLATION PIL, DET PAUSE PLL 13 LEVEL
MAIN SOURCE SELECTOR CDR CDL MDR MDL TAPEL 40 41 42 43 44
MIXING SELECTOR
86kHz LP STD IN GAIN
INPUT MULTIPLEXER
12 AUX1
1 2 3 4 5 TAPE R FDR+ FDL FDL+ PAUSE
6 7 8 PHONE TIM NAVI
9 AM/MPX2
10 AMIF
11 CMPX
31
CDX-CA650/CA650V/CA650X SECTION 4 EXPLODED VIEWS
NOTE: · The mechanical parts with no reference number in the exploded views are not supplied. · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · -XX and -X mean standardized parts, so they may have some difference from the original one. · Color Indication of Appearance Parts Example : KNOB, BALANCE (WHITE) ... (RED) R R Parts Color Cabinet's Color · Accessories and packing materials and hardware (# mark) list are given in the last of this parts list. The components identified by mark 0 or dotted line with mark. 0 are critical for safety. Replace only with part number specified.
4-1. CHASSIS SECTION 9 10
MG-393X-121//Q #1
11
#1
#1 #5 #6
14
#7 #6 #5 #5 #1
17 8
#4
12
#6
16 15
#6
13
#1 TU10
4 3 1 2 7 5
#2 #3 #2 #3 #3 #1
#4
17
18 19
F901
6
20
22
#1 #1
21
Ref. No. 1 2 * 3 4 5 6 7 * 8 9 * 10 * 11 * 12 * 13
Part No. X-3378-512-1 3-040-990-01 1-680-762-11 X-3376-699-1 3-030-909-01 3-713-786-51 X-3377-621-1 3-223-782-01 1-776-527-61 3-041-012-01
Description PANEL ASSY, SUB BUTTON (EJECT) SUB (CD) BOARD GEAR ASSY DAMPER, OIL
Remark
Ref. No. * * * * * 14 14 14 15 16 17 18 19 20 21 22 F901 TU10
Part No. A-3326-846-A A-3326-849-A A-3326-852-A 3-040-998-01 3-041-011-01 3-376-464-11 3-045-878-01 3-045-877-01 3-224-755-01 3-223-781-01
Description MAIN BOARD, COMPLETE (CA650) MAIN BOARD, COMPLETE (CA650X) MAIN BOARD, COMPLETE (CA650V) BRACKET (IC) HEAT SINK (REG) SCREW (+PTT 2.6X6), GROUND POINT PLATE (TU), GROUND CUSHION (TU) SHEET, INSULATING CHASSIS
Remark
SCREW +P 2X3 LOCK ASSY COVER CORD (WITH CONNECTOR) (ISO) (POWER) BRACKET (CD)
* * * *
3-227-287-01 SHEET, DUST PROTECTION 3-223-783-01 CHASSIS (BACK) 3-223-780-11 HEAT SINK
3-047-812-01 SCREW (LOCK) 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A A-3220-812-A TUNER UNIT (TUX-020)
32
CDX-CA650/CA650V/CA650X
4-2. FRONT PANEL SECTION
#8
#8
57
#8
67 65
LCD901
63 64 62 66 56 61 60 67
not supplied (KEY board)
51 59 58
52
53
54 55
Ref. No. 51 52 53 54 55 55 55 * 56 57 58 58 59
Part No. 3-223-789-01 3-223-791-01 3-223-792-01 3-223-790-01 X-3380-529-1 X-3380-530-1 X-3380-531-1 3-223-798-01 X-3380-079-1 X-3380-080-1
Description BUTTON (DSPL/SCRL) BUTTON (MENU/SOUND) BUTTON (AF/TA/OFF) BUTTON (LIST/ENTER) SUB ASSY, PANEL (CA650X) SUB ASSY, PANEL (CA650) SUB ASSY, PANEL (CA650V) HOLDER (LCD) PANEL ASSY, FRONT BACK KNOB (VOL) ASSY (CA650V/CA650X)
Remark
Ref. No. 60 61 62 * 63 64 * * * * 65 65 66 67 LCD901
Part No. 3-223-753-01 3-223-750-01 3-223-752-11 3-223-799-01 1-694-780-11 3-223-800-01 3-231-293-01 3-223-797-01 3-231-648-01 1-804-292-11
Description BUTTON (SOURCE/MODE) BUTTON (1-3) BUTTON (DSO/EQ7) PLATE (LCD), GROUND CONDUCTIVE BOARD, CONNECTION
Remark
ILLUMINATOR (LCD) (CA650/CA650X) ILLUMINATOR (LCD) (CA650V) PLATE (LCD), LIGHT GUIDE SHEET (LIGHT INTERCEPTION) (CA650V) DISPLAY PANEL, LIQUID CRYSTAL (CA650)
X-3380-081-1 KNOB (VOL) ASSY (CA650) 3-223-751-01 BUTTON (4-6)
LCD901 1-804-292-31 DISPLAY PANEL, LIQUID CRYSTAL (CA650X) LCD901 1-804-293-11 DISPLAY PANEL, LIQUID CRYSTAL (CA650V)
33
CDX-CA650/CA650V/CA650X
4-3. CD MECHANISM SECTION (1) (MG-393X-121//Q)
#9
101
#9
103 102
#11
104 105
C
108
C
M903
107 109
#10
#11 #11 #9
106
Ref. No. 101 102 * 103 104 * 105
Part No. A-3315-247-A 3-931-909-01 1-659-836-11 3-338-737-01 1-659-837-11
Description CHASSIS (T.U) ASSY SPRING (LR), TENSION DISC IN BOARD SCREW (2X3), +PS LOAD BOARD
Remark
Ref. No. * 106 * 107 108 109 M903
Part No. 3-039-629-01 A-3283-047-A 3-225-784-01 A-3315-040-A A-3315-039-A
Description BRACKET (MOTOR) SERVO BOARD, COMPLETE SPRING (RA3), TENSION ROLLER ASSY, ARM MOTOR SUB ASSY, LD (LOADING)
Remark
34
CDX-CA650/CA650V/CA650X
4-4. CD MECHANISM SECTION (2) (MG-393X-121//Q)
154
151
156
157 158
D
157
166 160 167 162 155 163 155 165 164 153
161
D
159 152 152
152
Ref. No. 151 152 153 154 155 156 157 158 159
Part No. X-3378-956-1 3-931-897-61 3-039-627-01 3-040-165-01 3-018-272-01 3-931-895-01 3-931-898-01 3-032-483-01 A-3315-243-A
Description ARM ASSY, CHUCKING DAMPER (T) LEVER (D) RETAINER (DISC) WASHER SPRING (CH), TENSION SPRING (FL), COMPRESSION SPRING (KF1), TENSION CHASSIS (M) ASSY
Remark
Ref. No. 160 161 162 163 164 165 166 167
Part No. 3-220-180-01 3-931-881-01 3-931-882-02 3-007-537-11 3-032-484-01
Description SPRING (TR2), TENSION LEVER (LOCK) GEAR (MDL) WHEEL (U), WORM SPRING (KR1), TENSION
Remark
3-014-727-01 WHEEL (LW), WORM 3-039-626-01 LEVER (TR) 3-225-093-21 RING, LOADING
35
CDX-CA650/CA650V/CA650X
4-5. CD MECHANISM SECTION (3) (MG-393X-121//Q) 201
M901
207 202
M902
208 205
203
#12
209
206 210 204
#9
213 212 211
#9
The components identified by mark 0 or dotted line with mark. 0 are critical for safety. Replace only with part number specified.
Ref. No. 201 202 203 204 * 205 206 207
Part No. X-3378-598-1 3-043-494-01 3-040-170-01 3-040-419-01 1-659-835-12
Description CHASSIS (OP) ASSY (including M901) SPRING (SL), TORSION BASE (DRIVING) GEAR (MIDWAY) LIMIT BOARD
Remark
Ref. No. * 208 209 0 210 211 212 213 M902
Part No. 1-659-834-11 3-909-607-01 8-820-103-03 3-025-743-01 1-676-707-21
Description SUB BOARD SCREW PICK-UP, OPTICAL KSS-720A/K1RP SPRING (FEED), LEAF PICK-UP FLEXIBLE BOARD
Remark
3-338-737-01 SCREW (2X3), +PS 1-659-880-11 MOTOR FLEXIBLE BOARD
A-3291-669-A SHAFT (FEED) ASSY A-3291-674-A MOTOR ASSY, SLED (SLED
36
CDX-CA650/CA650V/CA650X SECTION 5 ELECTRICAL PARTS LIST
NOTE: · Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. · -XX and -X mean standardized parts, so they may have some difference from the original one. · RESISTORS All resistors are in ohms. METAL:Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F:nonflammable · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · SEMICONDUCTORS In each case, u : µ, for example: uA.. : µA.. uPA.. : µPA.. uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD.. · CAPACITORS uF : µF · COILS uH : µH
DISC IN
The components identified by mark 0 or dotted line with mark. 0 are critical for safety. Replace only with part number specified.
KEY
When indicating parts by reference number, please include the board. · Abbreviation G : German model
Ref. No. *
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
1-659-836-11 DISC IN BOARD ************* < SWITCH >
LCD901 1-804-293-11 DISPLAY PANEL, LIQUID CRYSTAL (CA650V) < DIODE > LED900 LED900 LED901 LED901 LED902 8-719-061-16 8-719-082-91 8-719-061-16 8-719-082-91 8-719-082-81 LED LED LED LED LED CL-190SR-CD-T (RING) (CA650V/CA650X) CL-165Y/FG-D-T (RING) (CA650) CL-190SR-CD-T (RING) (CA650V/CA650X) CL-165Y/FG-D-T (RING) (CA650) LBM676 (MBP)
SW1 1-572-288-21 SWITCH, PUSH (DISC IN) SW2 1-572-288-21 SWITCH, PUSH (SELF) ************************************************************* KEY BOARD ********** 1-694-780-11 3-223-797-01 3-223-798-01 3-223-799-01 3-223-800-01 CONDUCTIVE BOARD, CONNECTION PLATE (LCD), LIGHT GUIDE HOLDER (LCD) PLATE (LCD), GROUND ILLUMINATOR (LCD) < CAPACITOR > C952 C953 C956 C961 C962 C971 1-164-227-11 1-115-412-11 1-115-467-11 1-107-826-11 1-107-826-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.022uF 680PF 0.22uF 0.1uF 0.1uF 0.1uF 10% 5% 10% 10% 10% 10% 25V 25V 10V 16V 16V 16V
* * * *
LED903 8-719-082-81 LED LBM676 (EQ7) LED905 8-719-078-19 LED LWA673-R1S2 (LCD BACK LIGHT) (CA650/CA650X) LED905 8-719-084-73 LED NSSB440-WRS-THR (LCD BACK LIGHT) (CA650V) LED906 8-719-078-19 LED LWA673-R1S2 (LCD BACK LIGHT) (CA650/CA650X) LED906 8-719-084-73 LED NSSB440-WRS-THR (LCD BACK LIGHT) (CA650V) LED909 8-719-078-19 LED LWA673-R1S2 (LCD BACK LIGHT) (CA650/CA650X) LED910 8-719-078-19 LED LWA673-R1S2 (LCD BACK LIGHT) (CA650/CA650X) LED913 8-719-061-16 LED CL-190SR-CD-T (RING) (CA650V/CA650X) LED913 8-719-082-91 LED CL-165Y/FG-D-T (RING) (CA650) LED914 8-719-061-16 LED CL-190SR-CD-T (RING) (CA650V/CA650X) LED914 8-719-082-91 LED CL-165Y/FG-D-T (RING) (CA650) < SWITCH > LSW901 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (OFF) (CA650V/CA650X) LSW901 1-786-112-11 SWITCH, KEYBOARD (WITH LED) (OFF) (CA650) LSW902 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (MENU) (CA650V/CA650X) LSW902 1-786-112-11 SWITCH, KEYBOARD (WITH LED) (MENU) (CA650) LSW903 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (SOURCE) (CA650V/CA650X) LSW903 1-786-112-11 SWITCH, KEYBOARD (WITH LED) (SOURCE) (CA650) LSW904 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (MODE) (CA650V/CA650X) LSW904 1-786-112-11 SWITCH, KEYBOARD (WITH LED) (MODE) (CA650) LSW905 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (SOUND) (CA650V/CA650X) LSW905 1-786-112-11 SWITCH, KEYBOARD (WITH LED) (SOUND) (CA650)
1-107-826-11 CERAMIC CHIP < CONNECTOR >
CN901
1-794-065-22 PLUG, CONNECTOR 14P < DIODE >
D901 D902 D903 D904 D906 D908 D908 D971
8-719-073-01 8-719-056-82 8-719-056-82 8-719-056-82 8-719-056-93
DIODE DIODE DIODE DIODE DIODE
MA111-(K8).S0 UDZ-TE-17-6.2B UDZ-TE-17-6.2B UDZ-TE-17-6.2B UDZ-TE-17-18B
8-719-158-15 DIODE UDZ-TE-17-5.6B (CA650V) 8-719-976-99 DIODE DTZ5.1B (CA650/CA650X) 8-719-056-82 DIODE UDZ-TE-17-6.2B < IC >
IC900 IC971
8-759-826-21 IC LC75874W 8-749-012-25 IC RS-170-TU < LIQUID CRYSTAL DISPLAY >
LCD901 1-804-292-11 DISPLAY PANEL, LIQUID CRYSTAL (CA650) LCD901 1-804-292-31 DISPLAY PANEL, LIQUID CRYSTAL (CA650X)
37
CDX-CA650/CA650V/CA650X KEY
Ref. No. Part No. Description Remark Ref. No. R906 R907 R908 R909 R910 R911 R912 R913 R914 R915 R916 R917 R918 R919 R920 R921 R922 R923 R924 R925 R926 R928 R928 R929 R930 Part No. 1-216-823-11 1-216-823-11 1-216-825-11 1-216-827-11 1-216-829-11 1-216-864-11 1-216-831-11 1-216-833-11 1-216-819-11 1-216-819-11 1-216-821-11 1-216-823-11 1-216-823-11 1-216-825-11 1-216-827-11 1-216-829-11 1-216-831-11 1-216-833-11 1-216-037-00 1-216-864-11 Description METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP SHORT METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP SHORT 1.5K 1.5K 2.2K 3.3K 4.7K 0 6.8K 10K 680 680 1K 1.5K 1.5K 2.2K 3.3K 4.7K 6.8K 10K 330 0 680 100 150 100 100 5% 5% 5% 5% 5% Remark 1/16W 1/16W 1/16W 1/16W 1/16W LSW906 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (ENTER) (CA650V/CA650X) LSW906 1-786-112-11 SWITCH, KEYBOARD (WITH LED) (ENTER) (CA650) LSW907 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (SCROLL) (CA650V/CA650X) LSW907 1-786-112-11 SWITCH, KEYBOARD (WITH LED) (SCROLL) (CA650) LSW908 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (DISPLAY/PTY) (CA650V/CA650X) LSW908 1-786-112-11 SWITCH, KEYBOARD (WITH LED) (DISPLAY/PTY) (CA650) LSW909 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (LIST) (CA650V/CA650X) LSW909 1-786-112-11 SWITCH, KEYBOARD (WITH LED) (LIST) (CA650) LSW910 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (AF) (CA650V/CA650X) LSW910 1-786-112-11 SWITCH, KEYBOARD (WITH LED) (AF) (CA650) LSW911 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (TA) (CA650V/CA650X) LSW911 1-786-112-11 SWITCH, KEYBOARD (WITH LED) (TA) (CA650) LSW914 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (6/SHUF) (CA650V/CA650X) LSW914 1-786-112-11 SWITCH, KEYBOARD (WITH LED) (6/SHUF) (CA650) LSW915 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (5) (CA650V/CA650X) LSW915 1-786-112-11 SWITCH, KEYBOARD (WITH LED) (5) (CA650) LSW916 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (4) (CA650V/CA650X) LSW916 1-786-112-11 SWITCH, KEYBOARD (WITH LED) (4) (CA650) LSW917 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (3/REP) (CA650V/CA650X) LSW917 1-786-112-11 SWITCH, KEYBOARD (WITH LED) (3/REP) (CA650) LSW918 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (2) (CA650V/CA650X) LSW918 1-786-112-11 SWITCH, KEYBOARD (WITH LED) (2) (CA650) LSW919 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (1) (CA650V/CA650X) LSW919 1-786-112-11 SWITCH, KEYBOARD (WITH LED) (1) (CA650) < TRANSISTOR > Q901 Q902 Q905 Q906 8-729-904-75 8-729-904-75 8-729-904-75 8-729-904-75 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR < RESISTOR > R902 R903 R904 R905 1-216-819-11 1-216-819-11 1-216-819-11 1-216-821-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP 680 680 680 1K 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W DTD114EK (CA650) DTD114EK (CA650) DTD114EK-T-146 (CA650V) DTD114EK-T-146 (CA650V)
5% 5% 5% 5% 5% 5% 5% 5% 5%
1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W
5% 1/16W 5% 1/16W 5% 1/16W 5% 1/10W (CA650VCA650X) 1/16W 1/10W (CA650) 5% 1/10W (CA650V/CA650X) 5% 1/10W (CA650) 5% 1/10W (CA650) 5% 1/10W (CA650V/CA650X) 5% 1/10W (CA650) 5% 1/10W (CA650) 5% 1/10W (CA650V/CA650X) 5% 1/10W (CA650) 1/10W (CA650) 5% 1/10W (CA650V/CA650X) 5% 1/10W (CA650) 5% 1/10W 5% 1/10W (CA650) 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W (CA650) 5% 5% 5%
1-216-819-11 METAL CHIP 1-216-025-11 RES-CHIP 1-216-029-00 METAL CHIP 1-216-025-11 RES-CHIP 1-216-025-11 RES-CHIP
R930 R931 R932 R932 R933
1-216-029-00 METAL CHIP 1-216-025-11 RES-CHIP 1-216-025-11 RES-CHIP 1-216-029-00 METAL CHIP 1-216-025-11 RES-CHIP
150 100 100 150 100
R934 R934 R935 R936 R937
1-216-025-11 RES-CHIP 1-216-029-00 METAL CHIP 1-216-025-11 RES-CHIP 1-216-031-00 METAL CHIP 1-216-031-00 METAL CHIP
100 150 100 180 180
R942 R943 R944 R945 R946
1-216-037-00 1-216-031-00 1-216-029-00 1-216-029-00 1-216-029-00
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
330 180 150 150 150
38
CDX-CA650/CA650V/CA650X KEY
Ref. No. R946 R948 R948 R950 R952 R953 R954 R955 R956 R957 R958 R959 R960 R961 R962 R963 R966 R967 R968 R969 Part No. Description 180 100 150 150 0 330 100 100 100 47K 180 180 1M 4.7K 4.7K 4.7K 150 150 150 82 Remark 5% 1/10W (CA650V/CA650X) 5% 1/10W (CA650V) 5% 1/10W (CA650/CA650X) 5% 1/10W (CA650/CA650X) (CA650/CA650X) 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W (CA650V) 1/16W 1/16W 1/16W 1/16W 1/10W 1/10W 1/16W 1/16W 1/16W 1/16W 1/10W (CA650) 1/10W (CA650) 1/10W (CA650) 1/10W (CA650V) Ref. No. Part No. 1-216-031-00 METAL CHIP 1-216-025-11 RES-CHIP 1-216-029-00 METAL CHIP 1-216-029-00 METAL CHIP 1-216-864-11 SHORT 1-216-037-00 RES-CHIP 1-216-809-11 1-216-809-11 1-216-809-11 1-216-841-11 1-216-031-00 1-216-031-00 1-216-857-11 1-216-829-11 1-216-829-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
LIMIT
Description < SWITCH >
LOAD
MAIN
Remark
S902 S903 S904 S905 S906
1-771-884-11 SWITCH, TACTILE (WITH LED) (M >/SEEK +) 1-771-884-11 SWITCH, TACTILE (WITH LED) (. m/SEEK ) 1-771-884-11 SWITCH, TACTILE (WITH LED) (DISC (PRST) +) 1-771-884-11 SWITCH, TACTILE (WITH LED) (DISC (PRST) ) 1-771-884-11 SWITCH, TACTILE (WITH LED) (EQ7)
S907 1-771-884-11 SWITCH, TACTILE (WITH LED) (MBP) ************************************************************* * 1-659-835-12 LIMIT BOARD *********** < SWITCH > SW3 1-572-688-11 SWITCH, PUSH (1 KEY) (LIMIT) ************************************************************* * 1-659-837-11 LOAD BOARD *********** < SWITCH > SW4 1-572-288-21 SWITCH, PUSH (DOWN) ************************************************************* * * * A-3326-846-A MAIN BOARD, COMPLETE (CA650) A-3326-849-A MAIN BOARD, COMPLETE (CA650X) A-3326-852-A MAIN BOARD, COMPLETE (CA650V) ********************* 3-040-998-01 3-041-011-01 3-223-780-11 3-223-783-01 7-685-647-79 BRACKET (IC) HEAT SINK (REG) HEAT SINK CHASSIS (BACK) SCREW +BVTP 3X10 TYPE 2 N-S
1-216-829-11 METAL CHIP 1-216-029-00 METAL CHIP 1-216-029-00 METAL CHIP 1-216-029-00 METAL CHIP 1-216-023-00 METAL CHIP
R969 R971 R972 R978 R978
1-216-027-00 METAL CHIP 1-216-027-00 METAL CHIP 1-216-825-11 METAL CHIP 1-216-029-00 METAL CHIP 1-216-031-00 METAL CHIP
120 120 2.2K 150 180
5% 1/10W (CA650/CA650X) 5% 1/10W (CA650/CA650X) 5% 1/16W 5% 1/10W (CA650) 5% 1/10W (CA650V/CA650X) 5% 5% 5% 5% 5% 1/10W (CA650) 1/10W 1/10W (CA650) 1/10W 1/10W (CA650) 1/10W 1/10W (CA650) 1/10W 1/10W (CA650)
* * * *
R979 R980 R981 R982 R983
1-216-029-00 METAL CHIP 1-216-027-00 METAL CHIP 1-216-027-00 METAL CHIP 1-216-027-00 METAL CHIP 1-216-027-00 METAL CHIP
150 120 120 120 120
7-685-793-09 SCREW +PTT 2.6X8 (S) 7-685-794-09 SCREW +PTT 2.6X10 (S) 7-685-797-09 SCREW +PTT 2.6X16 (S) < CAPACITOR > C11 C14 C15 C16 C21 C22 C23 C24 C25 C26 C27 C28 C29 1-163-233-11 1-124-584-00 1-163-038-11 1-124-584-00 1-163-009-11 1-163-009-11 1-163-009-11 1-163-038-11 1-163-133-00 1-163-227-11 CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 18PF 100uF 0.1uF 100uF 0.001uF 0.001uF 0.001uF 0.1uF 470PF 10PF 0.47uF 0.047uF 0.1uF 5% 20% 20% 10% 10% 10% 5% 0.5PF 10% 10% 50V 10V 25V 10V 50V 50V 50V 25V 50V 50V 16V 25V 25V
R984 R985 R986 R987
1-216-027-00 METAL CHIP 1-216-027-00 METAL CHIP 1-216-027-00 METAL CHIP 1-216-027-00 METAL CHIP
120 120 120 120
5% 5% 5% 5%
< ROTARY ENCODER > RE901 1-476-507-11 ENCODER, ROTARY 1-107-823-11 CERAMIC CHIP 1-163-809-11 CERAMIC CHIP 1-163-038-11 CERAMIC CHIP
39
CDX-CA650/CA650V/CA650X MAIN
Ref. No. C31 C32 C33 C41 C42 C51 C52 C53 C54 C55 C56 C57 C58 C59 C61 C62 C63 C64 C301 C302 C303 C305 C331 C332 C341 C342 C343 C401 C402 C403 C404 C405 C407 C411 C412 C413 C414 C415 C416 C430 C431 C433 C434 C435 C440 C441 C442 C444 C445 C450 C451 C453 C454 Part No. 1-163-017-00 1-163-809-11 1-163-037-11 1-109-982-11 1-109-982-11 1-124-589-11 1-107-725-11 1-163-133-00 1-163-229-11 1-163-229-11 1-163-038-11 1-163-009-11 1-163-038-11 1-163-263-11 1-164-346-11 1-163-135-00 1-164-161-11 1-164-346-11 1-126-153-11 1-126-153-11 1-126-153-11 1-124-584-00 1-163-038-11 1-163-021-11 1-126-153-11 1-163-021-11 1-163-021-11 1-124-589-11 1-163-021-11 1-163-017-00 1-107-823-11 1-124-233-11 1-163-021-11 1-126-160-11 1-126-160-11 1-126-160-11 1-126-160-11 1-163-251-11 1-163-251-11 1-163-251-11 1-124-233-11 1-107-823-11 1-164-161-11 1-163-251-11 1-163-251-11 1-124-233-11 1-107-823-11 1-164-161-11 1-163-251-11 1-163-251-11 Description CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.0047uF 0.047uF 0.022uF 1uF 1uF 47uF 0.1uF 470PF 12PF 12PF 0.1uF 0.001uF 0.1uF 330PF 1uF 560PF 0.0022uF 1uF 22uF 22uF 22uF 100uF 0.1uF 0.01uF 22uF 0.01uF 0.01uF 47uF 0.01uF 0.0047uF 0.47uF 10uF 0.01uF 1uF 1uF 1uF 1uF 100PF 100PF 100PF 10uF 0.47uF 0.0022uF 100PF 100PF 10uF 0.47uF 0.0022uF 100PF 100PF 5% 10% 10% 10% 10% 20% 10% 5% 5% 5% Remark 50V 25V 25V 10V 10V 16V 16V 50V 50V 50V 25V 50V 25V 50V 16V 50V 100V 16V 6.3V 6.3V 6.3V 10V 25V 50V 6.3V 50V 50V 16V 50V 50V 16V 16V 50V 50V 50V 50V 50V 50V 50V 50V 16V 16V 100V 50V 50V 16V 16V 100V 50V 50V 16V 16V 100V Ref. No. C455 C460 C461 C463 C464 C465 C471 C474 C475 C479 C501 C504 C505 C506 C507 C510 C511 C512 C551 C552 C601 C602 C611 C612 C613 C614 C617 C618 C622 C631 C661 C662 C710 C711 C712 C713 Part No. 1-163-251-11 1-163-251-11 1-124-233-11 1-107-823-11 1-164-161-11 1-163-251-11 1-163-037-11 1-124-259-11 1-124-233-11 1-124-589-11 1-163-017-00 1-163-235-11 1-163-234-11 1-163-038-11 1-163-021-11 1-124-584-00 1-163-021-11 1-126-153-11 1-163-021-11 1-126-934-11 1-135-473-21 1-163-038-11 1-126-157-11 1-126-157-11 1-126-157-11 1-126-157-11 1-163-009-11 1-163-009-11 1-125-710-11 1-126-160-11 Description CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP DOUBLE LAYERS ELECT 100PF 100PF 10uF 0.47uF 0.0022uF 100PF 0.022uF 4.7uF 10uF 47uF 0.0047uF 22PF 20PF 0.1uF 0.01uF 100uF 0.01uF 22uF 0.01uF 220uF 3300uF 0.1uF 10uF 10uF 10uF 10uF 0.001uF 0.001uF 0.1F 1uF 0.1uF 10uF 0.01uF 0.01uF 0.01uF 0.01uF 20% 10% 10% 10% 10% 5% 5% 20% 10% 10% 5% 10% 20% 20% 20% 5% 5% 5% 10% 20% 10% 20% 10% 20% 20% 20% 20% 20% 20% 10% 10% 20% Remark 50V 50V 16V 16V 100V 50V 25V 35V 16V 16V 50V 50V 50V 25V 50V 10V 50V 6.3V 50V 16V 16V 25V 16V 16V 16V 16V 50V 50V 5.5V 50V 25V (CA650V) 16V 50V 50V 50V 50V
10% 5%
5% 10% 20% 20% 20% 20% 10% 20% 10% 10% 20% 10% 5% 10% 20% 10% 20% 20% 20% 20% 5% 5% 5% 20% 10% 10% 5% 5% 20% 10% 10% 5% 5%
1-163-038-11 CERAMIC CHIP 1-124-233-11 1-163-021-11 1-163-021-11 1-163-021-11 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
1-163-021-11 CERAMIC CHIP < CONNECTOR >
CN701 CNJ600 CNP301 CNP601
1-784-456-11 1-580-907-31 1-764-617-12 1-774-701-11
CONNECTOR, FFC/FPC 14P PLUG, CONNECTOR (BUS CONTROL IN) PIN, CONNECTOR (PC BOARD) 30P PIN, CONNECTOR 16P < DIODE >
D21 D22 D23 D331 D332 D341 D471 D472
8-719-073-01 8-719-073-01 8-719-976-99 8-719-056-84 8-719-056-83
DIODE DIODE DIODE DIODE DIODE
MA111-(K8).S0 MA111-(K8).S0 DTZ5.1B UDZ-TE-17-7.5B UDZ-TE-17-6.8B
1-124-233-11 ELECT 1-107-823-11 CERAMIC CHIP 1-164-161-11 CERAMIC CHIP
10uF 20% 0.47uF 10% 0.0022uF 10%
8-719-158-15 DIODE RD5.6SB 8-719-081-83 DIODE CRG01(TE85L) 8-719-081-83 DIODE CRG01(TE85L)
40
CDX-CA650/CA650V/CA650X MAIN
Ref. No. D473 D474 D475 D476 D477 D478 D479 D551 D553 D554 D555 D556 D601 D609 D610 D611 D612 D613 D614 D621 D662 D671 D701 D710 D711 D713 D714 D720 Part No. 8-719-081-83 8-719-081-83 8-719-081-83 8-719-081-83 8-719-081-83 8-719-081-83 8-719-073-01 8-719-056-82 8-719-056-93 8-719-056-93 8-719-420-51 8-719-056-93 8-719-049-38 8-719-056-83 8-719-056-65 8-719-053-18 8-719-053-18 8-719-053-18 8-719-053-18 8-719-067-56 8-719-056-88 8-719-073-01 8-719-073-01 8-719-078-81 8-719-078-81 Description DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE CRG01(TE85L) CRG01(TE85L) CRG01(TE85L) CRG01(TE85L) CRG01(TE85L) CRG01(TE85L) MA111-(K8).S0 UDZ-TE-17-6.2B UDZ-TE-17-18B UDZ-TE-17-18B MA729 UDZ-TE-17-18B 1N5404TU UDZ-TE-17-6.8B 1SS372-TE85L 1SR154-400TE-25 1SR154-400TE-25 1SR154-400TE-25 1SR154-400TE-25 MA112-TX UDZ-TE-17-11B (CA650V) MA111-(K8).S0 MA111-(K8).S0 DF5A6.8FU(TE85R) DF5A6.8FU(TE85R) Remark Ref. No. JC12 Part No. Description 0 Remark 1-216-295-11 SHORT < COIL > L10 L50 L500 L501 1-410-509-11 1-410-509-11 1-419-476-11 1-410-509-11 INDUCTOR INDUCTOR COIL, CHOKE INDUCTOR < JACK > PJ401 1-774-700-11 JACK, PIN 6P (BUS AUDIO IN, AUDIO OUT FRONT/REAR) < TRANSISTOR > Q21 Q22 Q331 Q332 Q333 Q341 Q431 Q441 Q451 Q461 Q478 Q479 Q556 Q631 Q651 Q660 Q661 Q662 Q663 Q664 8-729-120-28 8-729-900-53 8-729-021-82 8-729-047-76 8-729-900-53 8-729-920-85 8-729-920-21 8-729-920-21 8-729-920-21 8-729-920-21 8-729-900-53 8-729-027-23 8-729-900-53 8-729-120-28 8-729-120-28 8-729-903-46 8-729-019-00 8-729-047-76 8-729-047-76 8-729-027-23 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR < RESISTOR > R21 R22 R23 R24 R25 R26 R27 R28 R29 R31 R32 R41 R52 R53 R54 R56 R57 R60 1-216-057-00 1-216-057-00 1-216-057-00 1-216-073-00 1-216-073-00 1-216-025-11 1-216-097-11 1-216-121-11 1-216-025-11 1-216-069-00 1-216-097-11 1-216-089-11 1-216-113-00 1-216-049-11 1-216-061-00 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP METAL CHIP 2.2K 2.2K 2.2K 10K 10K 100 100K 1M 100 6.8K 100K 47K 470K 1K 3.3K 10 470 10 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 2SC1623-L5L6 DTC114EK 2SD2396K FMC2A-T148 DTC114EK 2SD1664-QR DTC314TKH04 DTC314TKH04 DTC314TKH04 DTC314TKH04 DTC114EK DTA114EKA-T146 DTC114EK 2SC1623-L5L6 2SC1623-L5L6 2SB1132-P (CA650/CA650X) 2SD2394-G (CA650V) FMC2A-T148 FMC2A-T148 DTA114EKA-T146 10uH 10uH 250uH 10uH
8-719-056-83 DIODE UDZ-TE-17-6.8B 8-719-056-93 DIODE UDZ-TE-17-18B 8-719-056-83 DIODE UDZ-TE-17-6.8B < IC >
IC20 IC51 IC401 IC404 IC501 IC505 IC601 IC602
8-759-909-71 8-759-492-59 8-759-827-13 8-759-827-14 6-800-078-01
IC IC IC IC IC
BA4558F-E2 SAA6588T/V2-118 TDA7406T TA8268AH MN101C49KTH1
8-759-449-89 IC BA8270F-E2 8-759-661-47 IC BA4908-V3 8-759-682-69 IC XC61CN4302MR < JACK >
J10 J561
1-815-185-11 JACK (ANTENNA) 1-566-822-41 JACK (REMOTE IN) < JUMPER RESISTOR >
JC1 JC2 JC3 JC4 JC5 JC6 JC7 JC8 JC9
1-216-295-11 1-216-295-11 1-216-295-11 1-216-296-11 1-216-296-11 1-216-295-11 1-216-296-11 1-216-295-11 1-216-296-11
SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT SHORT
0 0 0 0 0 0 0 0 0
1-216-001-00 METAL CHIP 1-216-041-00 METAL CHIP 1-216-001-00 METAL CHIP
41
CDX-CA650/CA650V/CA650X MAIN
Ref. No. R331 R332 R333 R341 R342 R403 R413 R414 R415 R416 R431 R432 R433 R441 R442 R443 R451 R452 R453 R461 R462 R463 R464 R471 R472 R473 R474 R479 R501 R502 R503 R504 R505 R506 R507 R508 R509 R510 R511 R512 R513 R514 R515 R516 R517 R519 R521 R524 R525 R526 R527 R531 Part No. 1-216-053-00 1-216-053-00 1-216-053-00 1-216-057-00 1-216-057-00 1-216-089-11 1-216-049-11 1-216-049-11 1-216-073-00 1-216-073-00 1-216-033-00 1-216-089-11 1-216-025-11 1-216-033-00 1-216-089-11 1-216-025-11 1-216-033-00 1-216-089-11 1-216-025-11 1-216-033-00 1-216-089-11 1-216-025-11 1-216-295-11 1-216-089-11 1-216-057-00 1-216-049-11 1-216-073-00 1-216-017-11 1-216-081-00 1-216-295-11 1-216-097-11 1-216-049-11 1-216-049-11 1-216-049-11 1-216-089-11 1-216-097-11 1-216-025-11 1-216-025-11 1-216-025-11 1-216-025-11 1-216-025-11 1-216-025-11 1-216-025-11 1-216-025-11 1-216-097-11 1-216-105-11 1-216-097-11 1-216-073-00 1-216-073-00 1-216-073-00 Description METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP SHORT RES-CHIP METAL CHIP RES-CHIP METAL CHIP RES-CHIP METAL CHIP SHORT RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP 1.5K 1.5K 1.5K 2.2K 2.2K 47K 1K 1K 10K 10K 220 47K 100 220 47K 100 220 47K 100 220 47K 100 0 47K 2.2K 1K 10K 47 22K 0 100K 1K 1K 1K 47K 100K 100 100 100 100 100 100 100 100 100K 220K 100K 10K 10K 10K 10K 100K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W Ref. No. R533 R534 R536 R541 R544 R551 R552 R553 R556 R609 R631 R632 R633 R634 R635 R636 R651 R652 R653 R654 R660 R661 R662 R663 R664 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W (CA650V) Part No. Description 100K 100K 100K 100K 100K 15K 100 100 1K 1K 10K 47K 47K 4.7K 10K 100K 1K 47K 10K 10K 3.3K 330 10 10 10 Remark 5% 1/10W (CA650V/CA650X) 5% 1/10W (CA650/CA650X) 5% 1/10W (CA650) 5% 1/10W 5% 1/10W 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1-216-097-11 RES-CHIP 1-216-097-11 RES-CHIP 1-216-097-11 RES-CHIP 1-216-097-11 RES-CHIP 1-216-097-11 RES-CHIP 1-216-077-11 1-216-025-11 1-216-025-11 1-216-049-11 1-216-049-11 1-216-073-00 1-216-089-11 1-216-089-11 1-216-065-11 1-216-073-00 1-216-097-11 1-216-049-11 1-216-089-11 1-216-073-00 1-216-073-00 RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP
1-216-061-00 METAL CHIP 1-216-037-00 METAL CHIP 1-249-393-11 CARBON 1-249-393-11 CARBON 1-249-393-11 CARBON
5% 1/10W (CA650/CA650X) 5% 1/10W (CA650V) 5% 1/4W (CA650/CA650X) 5% 1/4W (CA650/CA650X) 5% 1/4W (CA650/CA650X) 5% 1/4W (CA650/CA650X) 5% 1/10W 5% 1/10W 5% 1/10W 5% 1/10W 5% 0.5% 5% 0.5% 0.5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W
R665 R666 R667 R668 R671 R672 R673 R700 R701 R702 R710 R711 R712 R713 R714 R715 R719
1-249-393-11 CARBON 1-216-029-00 1-216-029-00 1-216-029-00 1-216-025-11 1-216-025-11 1-216-675-00 1-216-025-11 1-216-675-00 1-216-675-00 1-216-025-11 1-216-025-11 1-216-025-11 1-216-025-11 1-216-025-11 METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP
10 150 150 150 100 100 10K 100 10K 10K 100 100 100 100 100 100 1K
1-216-025-11 RES-CHIP 1-216-049-11 RES-CHIP
1-216-073-00 METAL CHIP 1-216-097-11 RES-CHIP
42
CDX-CA650/CA650V/CA650X MAIN
Ref. No. Part No. Description < SWITCH > S701 S702 1-771-540-11 SWITCH, PUSH (1 KEY) (NOSE DET) 1-692-431-21 SWITCH, TACTILE (RESET) < THERMISTOR (POSITIVE) > C44 TH600 1-801-792-21 THERMISTOR, POSITIVE < CONNECTOR > < TUNER > TU10 A-3220-812-A TUNER UNIT (TUX-020) < VIBRATOR > < JUMPER RESISTOR > X51 1-579-242-41 VIBRATOR, CRYSTAL (4.332MHz) X501 1-795-165-11 VIBRATOR, CERAMIC (18.43MHz) X502 1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz) ************************************************************* * A-3283-047-A SERVO BOARD, COMPLETE ********************** < CAPACITOR > < IC > C1 C3 C4 C5 C6 C7 C8 C9 C10 C11 C13 C14 C15 C16 C17 C18 C19 C20 C21 C22 C23 C24 C25 C26 C27 C28 C29 C30 C31 C34 C35 C36 1-164-227-11 1-164-227-11 1-104-609-11 1-164-227-11 1-164-227-11 1-126-394-11 1-107-826-11 1-162-924-11 1-162-924-11 1-162-909-11 1-162-916-11 1-125-837-11 1-164-227-11 1-164-227-11 1-162-970-11 1-162-970-11 1-107-826-11 1-107-826-11 1-164-227-11 1-164-227-11 1-162-970-11 1-164-227-11 1-164-227-11 1-126-391-11 1-164-227-11 1-126-391-11 1-164-227-11 1-164-227-11 1-126-391-11 1-164-227-11 CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP 0.022uF 0.022uF 100uF 0.022uF 0.022uF 10uF 0.1uF 56PF 56PF 4PF 12PF 1uF 0.022uF 0.022uF 0.01uF 0.01uF 0.1uF 0.1uF 0.022uF 0.022uF 0.01uF 0.022uF 0.022uF 47uF 0.022uF 47uF 0.022uF 0.022uF 47uF 0.022uF 0.022uF 0.022uF 10% 10% 20% 10% 10% 20% 10% 5% 5% 0.25PF 5% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 20% 10% 20% 10% 10% 20% 10% 10% 10% 25V 25V 4V 25V 25V 16V 16V 50V 50V 50V 50V 6.3V 25V 25V 25V 25V 16V 16V 25V 25V 25V 25V 25V 6.3V 25V 6.3V 25V 25V 6.3V 25V 25V 25V IC1 IC2 8-759-699-98 IC uPD63711GC-8EU 8-759-658-87 IC BA5810FP-E2 < TRANSISTOR > Q1 8-729-904-87 TRANSISTOR 2SB1197K-T-146-R < RESISTOR > R3 R5 R6 R7 R8 R9 R10 R12 R14 R15 R17 R18 R19 R20 R21 R22 R24 R25 R26 R29 R30 R31 1-216-797-11 1-218-344-11 1-216-837-11 1-216-839-11 1-216-833-11 1-216-840-11 1-216-835-11 1-216-837-11 1-216-841-11 1-216-841-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-821-11 1-216-821-11 1-216-864-11 1-216-864-11 1-216-797-11 1-216-833-11 METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP SHORT SHORT METAL CHIP METAL CHIP 10 7.5K 22K 33K 10K 39K 15K 22K 47K 47K 100 100 100 100 1K 1K 0 0 10 10K 10K 2.2 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W FB1 FB2 FB4 FB5 FB6 FB7 1-216-864-11 1-216-864-11 1-216-864-11 1-216-295-11 1-216-864-11 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 0 CN1 CN2 CN3 1-764-616-12 HOUSING, CONNECTOR (PC BOARD) 30P 1-794-153-21 CONNECTOR, FPC (ZIF) 16P 1-770-347-21 CONNECTOR, FPC 6P 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V Remark Ref. No. C37 C38 C39 C41 C43 Part No. 1-126-393-11 1-164-227-11 1-126-391-11 1-164-227-11 1-162-967-11 Description ELECT CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP 33uF 0.022uF 47uF 0.022uF 0.0033uF 20% 10% 20% 10% 10%
SERVO
Remark 10V 25V 6.3V 25V 50V
1-216-864-11 SHORT
5% 5% 5% 5%
1/16W 1/16W 1/16W 1/16W
1-216-833-11 METAL CHIP 1-216-789-11 METAL CHIP
1-164-227-11 CERAMIC CHIP 1-164-227-11 CERAMIC CHIP
43
CDX-CA650/CA650V/CA650X SERVO
Ref. No. Part No.
SUB
SUB (CD)
Remark Ref. No. Part No. Description ************** HARDWARE LIST ************** #1 #2 #3 #4 #5 #6 #7 #8 #9 #10 7-685-790-01 7-685-792-09 7-621-772-20 7-685-647-79 7-685-794-09 7-685-793-09 7-685-797-09 7-685-106-19 7-627-553-37 7-627-553-17 SCREW +PTT 2.6X4 (S) SCREW +PTT 2.6X6 (S) SCREW +B 2X5 SCREW +BVTP 3X10 TYPE 2 N-S SCREW +PTT 2.6X10 (S) SCREW +PTT 2.6X8 (S) SCREW +PTT 2.6X16 (S) SCREW +P 2X10 TYPE 2 NON-SLIT SCREW, PRECISION +P 2X3 TYPE 3 SCREW, PRECISION +P 2X2 TYPE 3 Remark
Description < VIBRATOR >
1-781-759-21 VIBRATOR, CERAMIC (CHIP TYPE) (16.9344MHz) ************************************************************* * 1-659-834-11 SUB BOARD ********** < CONNECTOR > CN1 1-770-347-21 CONNECTOR, FPC 6P ************************************************************* * 1-680-762-11 SUB (CD) BOARD ************** 3-039-443-11 SHEET (CONNECTOR) < CONNECTOR > CNP801 1-794-064-12 SOCKET, CONNECTOR 14P CNP802 1-792-195-11 CABLE, FLEXIBLE FLAT (14 CORE) < DIODE > LED801 8-719-082-38 LED CL-270SR-C-TS (INSERT MARK) (CA650V/CA650X) LED801 8-719-082-40 LED CL-270FG-C-TS (INSERT MARK) (CA650) < SWITCH > LSW801 1-771-883-11 SWITCH, TACTILE (WITH LED) (Z) (CA650V/CA650X) LSW801 1-786-113-11 SWITCH, TACTILE (WITH LED) (Z) (CA650) ************************************************************* MISCELLANEOUS *************** 9 201 207 0 210 212 1-776-527-61 X-3378-598-1 1-659-880-11 8-820-103-03 1-676-707-21 CORD (WITH CONNECTOR) (ISO) (POWER) CHASSIS (OP) ASSY (including M901) MOTOR FLEXIBLE BOARD PICK-UP, OPTICAL KSS-720A/K1RP PICK-UP FLEXIBLE BOARD
X1
*
#11 7-628-253-00 SCREW +PS 2X4 #12 7-627-850-28 SCREW, PRECISION +P 1.4X3 ************************************************************* PARTS FOR INSTALLATION AND CONNECTIONS *************************************** 251 252 253 254 255 256 257 258 259 X-3373-602-1 3-386-828-01 3-349-410-01 X-3366-405-1 3-040-979-02 3-934-325-01 1-465-459-21 3-041-000-01 1-776-527-61 FRAME ASSY SCREW, FITTING BUSHING SCREW ASSY (EXP), FITTING COLLAR SCREW, +K (5X8) TAPPING ADAPTOR, ANTENNA SPRING, FITTING CORD (WITH CONNECTOR) (ISO) (POWER)
251
254 252 253
255
256
257
F901 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A M902 A-3291-674-A MOTOR ASSY, SLED (SLED) M903 A-3315-039-A MOTOR SUB ASSY, LD (LOADING) ************************************************************* ACCESSORIES & PACKING MATERIALS ******************************** 3-227-675-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH, GERMAN,DUTCH,ITALIAN) 3-227-675-21 MANUAL, INSTRUCTION (ENGLISH,SPANISH, SWEDISH,PORTUGUESE,GREEK,RUSSIAN) 3-227-676-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH, FRENCH,GERMAN,DUTCH,ITALIAN) 3-227-676-21 MANUAL, INSTRUCTION, INSTALL (ENGLISH, SPANISH,SWEDISH,PORTUGUESE, GREEK,RUSSIAN) X-3378-490-1 CASE (PANEL) ASSY (for FRONT PANEL) *************************************************************
258
259
The components identified by mark 0 or dotted line with mark. 0 are critical for safety. Replace only with part number specified.
44