Text preview for : Samsung TXM2091FX-XAA (Chassis KS2A(N) (REV.2)) (Service Manual).pdf part of Samsung TXM2091FX/XAA Samsung TXM2091FX/XAA (Chassis KS2A(N) (REV.2)) (Service Manual)
Back to : Samsung TXM2091FX-XAA (Ch | Home
COLOR TELEVISION RECEIVER
Chassis : Model : KS2A(N) (REV.2) TXM2091FX/XAA
COLOR TELEVISION RECEIVER
CONTENTS
1. Precautions 2. Reference Information 3. Specifications 4. Alignment and Adjustments 5. Troubleshooting 6. Exploded Views and Parts List 7. Electrical Parts List 8. Block Diagrams 9. Wiring Diagram 10. Schematic Diagrams
ELECTRONICS
© Samsung Electronics Co., Ltd. JUN. 2002
Printed in Korea AA82-00054A
Precautions
1. Precautions
Follow these safety, servicing and ESD precautions to prevent damage and protect against potential hazards such as electrical shock and X-rays.
1-1 Safety Precautions
1. Be sure that all of the built-in protective devices are replaced. Restore any missing protective shields. 2. When reinstalling the chassis and its assemblies, be sure to restore all protective devices, including: nonmetallic control knobs and compartment covers. 3. Make sure that there are no cabinet openings through which people--particularly children--might insert fingers and contact dangerous voltages. Such openings include the spacing between the picture tube and the cabinet mask, excessively wide cabinet ventilation slots, and improperly fitted back covers. If the measured resistance is less than 1.0 megohm or greater than 5.2 megohms, an abnormality exists that must be corrected before the unit is returned to the customer. 4. Leakage Current Hot Check (Figure 1-1): Warning: Do not use an isolation transformer during this test. Use a leakagecurrent tester or a metering system that complies with American National Standards Institute (ANIS C101.1, Leakage Current for Appliances), and Underwriters Laboratories (UL Publication UL1410, 59.7). 5. With the unit completely reassembled, plug the AC line cord directly into the power outlet. With the unit's AC switch first in the ON position and then OFF, measure the current between a known earth ground (metal water pipe, conduit, etc.) and all exposed metal parts, including: antennas, handle brackets, metal cabinets, screwheads and control shafts. The current measured should not exceed 0.5 milliamp. Reverse the powerplug prongs in the AC outlet and repeat the test.
DEVICE UNDER TEST TEST ALL EXPOSED METAL SURFACES 2-WIRE CORD ALSO TEST WITH PLUG REVERSED (USING AC ADAPTER PLUG AS REQUIRED)
LEAKAGE CURRENT TESTER
(READING SHOULD NOT BE ABOVE 0.5mA)
EARTH GROUND
Fig. 1-1 AC Leakage Test 6. Antenna Cold Check: With the unit's AC plug disconnected from the AC source, connect an electrical jumper across the two AC prongs. Connect one lead of the ohmmeter to an AC prong. Connect the other lead to the coaxial connector. 7. X-ray Limits: The picture tube is especially designed to prohibit X-ray emissions. To ensure continued X-ray protection, replace the picture tube only with one that is the same type as the original. Carefully reinstall the picture tube shields and mounting hardware; these also provide X-ray protection. 8. High Voltage Limits: High voltage must be measured each time servicing is done on the B+, horizontal deflection or high voltage circuits. Correct operation of the X-ray protection circuits must be reconfirmed whenever they are serviced. (X-ray protection circuits also may be called "horizontal disable" or "hold-down".) Heed the high voltage limits. These include the Xray Protection Specifications Label, and the Product Safety and X-ray Warning Note on the service data schematic.
Samsung Electronics
1-1
Precautions
1-1 Safety Precautions (Continued)
9. High voltage is maintained within specified limits by close-tolerance, safety-related components and adjustments. If the high voltage exceeds the specified limits, check each of the special components. 10. Design Alteration Warning: Never alter or add to the mechanical or electrical design of this unit. Example: Do not add auxiliary audio or video connectors. Such alterations might create a safety hazard. Also, any design changes or additions will void the manufacturer's warranty. 11. Hot Chassis Warning: Some TV receiver chassis are electrically connected directly to one conductor of the AC power cord. If an isolation transformer is not used, these units may be safely serviced only if the AC power plug is inserted so that the chassis is connected to the ground side of the AC source. To confirm that the AC power plug is inserted correctly, do the following: Using an AC voltmeter, measure the voltage between the chassis and a known earth ground. If the reading is greater than 1.0V, remove the AC power plug, reverse its polarity and reinsert. Re-measure the voltage between the chassis and ground. 12. Some TV chassis are designed to operate with 85 volts AC between chassis and ground, regardless of the AC plug polarity. These units can be safely serviced only if an isolation transformer inserted between the receiver and the power source. 13. Some TV chassis have a secondary ground system in addition to the main chassis ground. This secondary ground system is not isolated from the AC power line. The two ground systems are electrically separated by insulating material that must not be defeated or altered. 14. Components, parts and wiring that appear to have overheated or that are otherwise damaged should be replaced with parts that meet the original specifications. Always determine the cause of damage or overheating, and correct any potential hazards. 15. Observe the original lead dress, especially near the following areas: Antenna wiring, sharp edges, and especially the AC and high voltage power supplies. Always inspect for pinched, out-of-place, or frayed wiring. Do not change the spacing between components and the printed circuit board. Check the AC power cord for damage. Make sure that leads and components do not touch thermally hot parts. 16. Picture Tube Implosion Warning: The picture tube in this receiver employs "integral implosion" protection. To ensure continued implosion protection, make sure that the replacement picture tube is the same as the original. 17. Do not remove, install or handle the picture tube without first putting on shatterproof goggles equipped with side shields. Never handle the picture tube by its neck. Some "in-line" picture tubes are equipped with a permanently attached deflection yoke; do not try to remove such "permanently attached" yokes from the picture tube. 18. Product Safety Notice: Some electrical and mechanical parts have special safety-related characteristics which might not be obvious from visual inspection. These safety features and the protection they give might be lost if the replacement component differs from the original--even if the replacement is rated for higher voltage, wattage, etc. Components that are critical for safety are indicated in the circuit diagram by shading, ( ) or ( ). Use replacement components that have the same ratings, especially for flame resistance and dielectric strength specifications. A replacement part that does not have the same safety characteristics as the original might create shock, fire or other hazards.
1-2
Samsung Electronics
Precautions
1-2 Servicing Precautions
Warning1: First read the "Safety Precautions" section of this manual. If some unforeseen circumstance creates a conflict between the servicing and safety precautions, always follow the safety precautions. Warning2: An electrolytic capacitor installed with the wrong polarity might explode. 1. Servicing precautions are printed on the cabinet. Follow them. 2. Always unplug the unit's AC power cord from the AC power source before attempting to: (a) Remove or reinstall any component or assembly, (b) Disconnect an electrical plug or connector, (c) Connect a test component in parallel with an electrolytic capacitor. 3. Some components are raised above the printed circuit board for safety. An insulation tube or tape is sometimes used. The internal wiring is sometimes clamped to prevent contact with thermally hot components. Reinstall all such elements to their original position. 4. After servicing, always check that the screws, components and wiring have been correctly reinstalled. Make sure that the portion around the serviced part has not been damaged. 5. Check the insulation between the blades of the AC plug and accessible conductive parts (examples: metal panels, input terminals and earphone jacks). 6. Insulation Checking Procedure: Disconnect the power cord from the AC source and turn the power switch ON. Connect an insulation resistance meter (500V) to the blades of the AC plug. The insulation resistance between each blade of the AC plug and accessible conductive parts (see above) should be greater than 1 megohm. 7. Never defeat any of the B+ voltage interlocks. Do not apply AC power to the unit (or any of its assemblies) unless all solid-state heat sinks are correctly installed. 8. Always connect a test instrument's ground lead to the instrument chassis ground before connecting the positive lead; always remove the instrument's ground lead last.
Samsung Electronics
1-3
Precautions
1-3 Precautions for Electrostatically Sensitive Devices (ESDs)
1. Some semiconductor ("solid state") devices are easily damaged by static electricity. Such components are called Electrostatically Sensitive Devices (ESDs); examples include integrated circuits and some field-effect transistors. The following techniques will reduce the occurrence of component damage caused by static electricity. 2. Immediately before handling any semicon ductor components or assemblies, drain the electrostatic charge from your body by touching a known earth ground. Alternatively, wear a discharging wrist-strap device. (Be sure to remove it prior to applying power-- this is an electric shock precaution.) 3. After removing an ESD-equipped assembly, place it on a conductive surface such as aluminum foil to prevent accumulation of electrostatic charge. 4. Do not use freon-propelled chemicals. These can generate electrical charges that damage ESDs. 5. Use only a grounded-tip soldering iron when soldering or unsoldering ESDs. 6. Use only an anti-static solder removal device. Many solder removal devices are not rated as "anti-static"; these can accumulate sufficient electrical charge to damage ESDs. 7. Do not remove a replacement ESD from its protective package until you are ready to install it. Most replacement ESDs are packaged with leads that are electrically shorted together by conductive foam, aluminum foil or other conductive materials. 8. Immediately before removing the protective material from the leads of a replacement ESD, touch the protective material to the chassis or circuit assembly into which the device will be installed. 9. Minimize body motions when handling unpackaged replacement ESDs. Motions such as brushing clothes together, or lifting a foot from a carpeted floor can generate enough static electricity to damage an ESD.
CAUTION
These servicing instructions are for use by qualified service personnel only. To reduce the risk of electric shock do not perform any servicing other than that contained in the operating instructions unless you are qualified to do so.
1-4
Samsung Electronics
Reference Information
2. Reference Information
2-1 Tables of Abbreviations and Acronyms
Table 2-1 Abbreviations A Ah Å dB dBm °C °F °K F G GHz g H Hz h ips kWh kg kHz k km km/h kV kVA kW I MHz Ampere Ampere-hour Angstrom Decibel Decibel Referenced to One Milliwatt Degree Celsius Degree Fahrenheit degree Kelvin Farad Gauss Gigahertz Gram Henry Hertz Hour Inches Per Second Kilowatt-hour Kilogram Kilohertz Kilohm Kilometer Kilometer Per Hour Kilovolt Kilovolt-ampere Kilowatt Liter Megahertz MV MW M m µA µF µH µm µs µW mA mg mH mI mm ms mV nF pF Ib rpm rps s V VA W Wh Megavolt Megawatt Megohm Meter Microampere Microfarad Microhenry Micrometer Microsecond Microwatt Milliampere Milligram Millihenry Milliliter Millimeter Millisecond Millivolt Nanofarad Ohm Picofarad Pound Revolutions Per Minute Revolutions Per Second Second (Time) Volt Volt-ampere Watt Watt-hour
Samsung Electronics
2-1
Reference Information
Table 2-2 Table of Acronyms ABL AC ACC AF AFC AFT AGC AM ANSI APC APC A/V AVC BAL BPF B-Y CATV CB CCD CCTV Ch CRT CW DC DVM EIA ESD ESD FBP FBT FF FM FS GND G-Y H HF HI-FI IC IC IF Automatic Brightness Limiter Alternating Current Automatic Chroma Control Audio Frequency Automatic Frequency Control Automatic Fine Tuning Automatic Gain Control Amplitude Modulation American National Standards Institute Automatic Phase Control Automatic Picture Control Audio-Video Automatic Volume Control Balance Bandpass Filter Blue-Y Community Antenna Television (Cable TV) Citizens Band Charge Coupled Device Closed Circuit Television Channel Cathode Ray Tube Continuous Wave Direct Current Digital Volt Meter Electronics Industries Association Electrostatic Discharge Electrostatically Sensitive Device Feedback Pulse Flyback Transformer Flip-Flop Frequency Modulation Fail Safe Ground Green-Y High High-Frequency High Fidelity Inductance-Capacitance Integrated Circuit Intermediate Frequency I/O L L LED LF MOSFET MTS NAB NEC NTSC OSD PCB PLL PWM QIF R RC RF R-Y SAP SAW SIF SMPS S/N SW TP TTL TV UHF UL UV VCD VCO VCXO VHF VIF VR VTR VTVM TR Input/output Left Low Light Emitting Diode Low Frequency Metal-Oxide-Semiconductor-Field-Effect-Tr Multi-channel Television Sound National Association of Broadcasters National Electric Code National Television Systems Committee On Screen Display Printed Circuit Board Phase-Locked Loop Pulse Width Modulation Quadrature Intermediate Frequency Right Resistor & Capacitor Radio Frequency Red-Y Second Audio Program Surface Acoustic Wave(Filter) Sound Intermediate Frequency Switching Mode Power Supply Signal/Noise Switch Test Point Transistor Transistor Logic Television Ultra High Frequency Underwriters Laboratories Ultraviolet Variable-Capacitance Diode Voltage Controlled Oscillator Voltage Controlled Crystal Oscillator Very High Frequency Video Intermediate Frequency Variable Resistor Video Tape Recorder Vacuum Tube Voltmeter Transistor
2-2
Samsung Electronics
Reference Information
2-2 IC Line Up
Table 2 - 3 IC Line - Up NO BOARD LOC. NO IC201S IC601 IC901 IC902 IC602 HIC201 IC301 DH01 DAMPER-D 1 MAIN IC801S D801S PC801S DDR01 IC804 IC803 IC903 IC904 Q909 Q910 TU01 D813 2 CRT IC501 TAFC-H0051 FML-G12S STV5109 Main Tuner with IF Block Rectifier Diode Video Output AMP R.G.B Drive SPEC VDP3130Y-B1 MSP3440G-B6 SIM408A 24WC16 TDA7297 DRGB001 LA7845 KSD5703 FMP-3FU KA3A1265RD D5SB60 PC123Y KA78R05 KA7806 KA78R08 KA78RM33 KIA7025AP 2N7000 SPS Controllor Bridge Diode Photo Coupler Regulator 6V Regulator 8V Controlled Regulator 3.3V Regulator MICOM Reset IC IIC Level Shifter DDR01 Option DESCRIPTION Video Processor NTSC Sound Processor MICOM, Caption (MTP) EEPROM Audio AMP RGB Drive AMP Hybrid IC Vertical IC Horizontal Drive IC DH01 Refer to Table 2-3-2 VM Option REMARK Refer to Table 2-3-1
Samsung Electronics
2-3
Reference Information
Table 2-3-1 VIDEO IC SPEC VDP3108B VDP3130Y Basic 1H Comb Filter 2H Comb Filter, DVD Input FUNCTION REMARK
Table 2-3-2 SOUND AMP SPEC TDA7297 7W x 2CH, 10W x 2CH FUNCTION REMARK
2-4
Samsung Electronics
Specifications
3. Specifications
Television System
NTSC-M, PAL N.M 75ohms, Coaxial Cable 120W (Applied When 29" Flat) Free Volts(100V-240Volts) Free Voltage Frequency 50/60Hz 15W x 2CH Output 10W x 2CH 5W x 2CH Vitual Dolby Effect Turbo Sound Pseudo Stereo RCA Input Front (AV2) S-VHS Head-Phone
Option Option Option Option Not Present R815
Multi
Option
Antena Input
Consumption
Power
Requirements
Sound
Jacks
Back
2 AV Input DVD Input(YPbPr) AV2 Monitor Audio Output S-VHS
Option Option Option
Specifications are subject to change.
Samsung Electronics
3-1
MEMO
3-2
Samsung Electronics
Alignment and Adjustments
4. Alignment and Adjustments
4-1 General Alignment Instructions
1. Usually, a color TV-VCR needs only slight touch-up adjustment upon installation. Check the basic characteristics such as height, horizontal and vertical sync and focus. 2. Observe the picture for good black and white details. There should be objectionable color shading; if color shading is present, demagnetize, perform purity and convergence adjustments described below. 3. Use the specified test equipment or its equivalent. 4. Correct impedance matching is essential. 8. To protect against shock hazard, use an isolation transformer. 5. Avoid overload. Excessive signal from a sweep generator might overload the front-end of the TV. When inserting signal markers, do not allow the marker generator to distort test results. 6. Connect the TV only to an AC power source with voltage and frequency as specified on the backcover nameplate. 7. Do not attempt to connect or disconnect any wires while the TV is turned on. Make sure that the power cord is disconnected before replacing any parts.
4-2 Automatic Degaussing
A degaussing coil is mounted around the picture tube, so that external degaussing after moving the TV should be unnecessary. But the receiver must be properly degaussed upon installation. The degaussing coil operates for about 1 second after the power is switched ON. If the set is moved or turned in a different direction, the power should be OFF for at least 10 minutes. If the chassis or parts of the cabinet become magnetized, poor color purity will result. If this happens, use an external degaussing coil. Slowly move the degaussing coil around the faceplate of the picture tube and the sides and front of the receiver. Slowly withdraw the coil to a distance of about 6 feet before turning power OFF. If color shading persists, perform the following Color purity and Convergence adjustments.
4-3 High Voltage Check
CAUTION : There is no high voltage adjustment on this chassis. The B+ power supply should be +135 volts (with full color- bar input and normal picture level).
1. Connect a digital voltmeter to the second anode of the picture tube. 2. Turn on the TV. Set the Brightness and Contrast controls to minimum (zero beam current). 3. Adjust the Brightness and contrast controls to both extremes. Ensure that the high voltage does not exceed 30 KV under any conditions.
Samsung Electronics
4-1
Alignment and Adjustments
4-4 FOCUS Adjustment
1. Input a black and white signal.
2. Adjust the tuning control for the clearest picture. 3. Adjust the FOCUS control for well defined scanning lines in the center area of the screen.
4-5 SCREEN Adjustment
1. Input Toshiba Pattern 2. Enter "Service Mode".(Refer to "4-8-1 Service Mode") 3. Select "G2-Adjust". 4. Set the values as below. Table 1. Screen Adjustment Table COLR G B (Smallest Value) 100 100 100 120 65 65 75 120 150 180 180 140 Normal
No 1 2 3 4 5 6 7 8 9 10 11 12
INCH / CRT 14" / SDI 15PF / SDI 21" 1.7R / SDI 20V 10.0R/SDI 21PF / TSB 21PF / LG 21PF / SDI 25PF / SDI 27V 1.3R / SDI 27V 1.0R/SDI 25V 1.0R/SDI 23V 1.3R/SDI
IBRM 205 220 220 205 220 230 225 210 210 210 210 205
WDRV 35 35 35 35 35 35 45 35 35 35 35 35
CDL 100 180 180 115 180 230 220 160 170 150 150 120
REGION
5. Turn the SCREEN VR until "MRCR G B" and "MRWDG" are green and those value are about 100. (The incorrect SCREEN Voltage may result that "MRCR G B" and "MRWDG" should be red)
4-2
Samsung Electronics
Alignment and Adjustments
4-6 E2PROM (IC902) Replacement
1. When IC902 is replaced, all adjustment data revert to the initial values. So, all adjustment values when servicing should be readjusted. 2. After IC902 is replaced, connect the AC power supply cord. 3. Turn the power switch ON. 4. In stand-by, warm up the TV for at least 10 seconds. 5. Power on the TV.
4-7 White Balance Adjustment
Equipment : Color-Analyzer (CA-100) Input Signal : Pattern signal (Toshiba pattern) 1. Select STANDARD from the menu. 2. Input an 100% White pattern. 3. Enter the "Service Mode". (Refer to "4-8 Service Mode") 4. Warm up the TV set at least for 30 minutes. 5. Input a Toshiba pattern signal. 6. Enter the "Video Adjust1". - Adjust "Sub Contrast" so that Y (luminance) becomes 65 ft ± 3. - Use "Red Drive" and " Blue Drive" to adjust High-Light (x : 275, y : 265) - Adjust "Sub Bright" so that Y (luminance) becomes 1.2ft ± 0.3. - Use "Red Cutoff" and "Blue Cutoff" to adjust Low-Light (x : 275, y : 265). 7. Adjust CA-100 so that the final adjustment value can be fixed. 8. Use the Channel Up/Down ( / ) buttons to move the cursor on the adjustment modes.
9. Use the Volume +/- buttons to change the adjustment value.
Samsung Electronics
4-3
Alignment and Adjustments
4-8 Factory Adjustment
4-8-1 Service Mode
1. To enter the "Service Mode", Press the remote-control keys in this sequence : - If you do not have Factory remote-control PICTURE OFF MUTE 1,8,2 PICTURE ON
- If you have Factory remote-control
PICTURE ON
DISPLAY (
)
FACTORY
2. After the Service Mode is entered, the initial screen is as shown in the figure below.
xx xx xx *
These hexa * depends on digits are check sum value which the MICOM version. If check sum value is changed, the value of 2 E PROM Data newly initialed.
3. Use the Channel Up/Down buttons to move the cursor in the adjustment parameters. Note : - When CRT, CRT PCB, FBT, E PROM (sometimes MICOM) is replaced, the adjustment values should be controlled. - After the Service adjustment is completed, Do not select "Reset" in the service mode menu. (After above procedure is done, power is on initially and the "Plug and Play" will be operated.)
2
4-4
Samsung Electronics
Alignment and Adjustments
4-8-2 Deflection (Memory Data)
- SIM408A USA, LATIN FACTORY (VDP IC VDP3108B)
4-8-2(A) GEOMETRIC ADJUSTMENT VALUE
INCH 27V 1.3R 23V 1.3R
25V 1R TXK2550 TXK2554 TXK2566 TXK2567 CL663BW 27V 1R TXK2750 TXK2754 20V 1R TXK2060 TXK2066 TXK2067
15" FLAT
21" STEREO 25" STEREO
CL25M6P CL25M6W
Model
TXK2767
CL25D4W
CT-15A8
CL21A8W7X
DEFLECTION H Bow H Angle H Dscc V SHIFT V AMP V SLOPE V SC H EW H TRAPEZIUM H PARABOLA H SYMMETRY H CORNER H SHIFT PIP CONTRAST PIP TINT PIP PAL V.POS PIP NTSC V.POS PIP H.POS
INIT 0 0 0 -40 5 -2 -7 64 -20 -13 13 15 4
FIX FIX FIX Control Control Control FIX Control Control Control FIX Control Control FIX FIX FIX FIX FIX
0 0 3 -27 -50 -7 0 10 -82 -89 13 0 0 0 0 12 12 12
0 0 3 -24 -41 -4 -13 -37 -48 -44 13 69 8 0 0 12 12 12
0 0 3 -18 18 -4 -13 64(FIX) -20(FIX) -13(FIX) 13 69(FIX) 13 0 0 12 12 12
0 0 3 -18 18 -4 -13 64(FIX) -20(FIX) -13(FIX) 13 69(FIX) 13 0 0 12 12 12
0 0 3 -40 5 -2 -13 64(FIX) -20(FIX) -13(FIX) 13 69(FIX) 4 0 0 12 12 12
0 0 3 -35 20 -4 -13 64(FIX) -20(FIX) -13(FIX) 13 69(FIX) 13 0 0 12 12 12
0 0 3 -40 -20 -6 -5 -5 -20 20 13 40 -24
0 0 3 -50 -15 -2 -6 10 -20 -60 13 40 -27 7 0 10 10 15
INCH
27V 1.3R
23V 1.3R
25V 1R
27V 1R TXK2750 TXK2754
20V 1R
TXK2060 TXK2066 TXK2067
15" FLAT
21" STEREO 25" STEREO
CL25M6P CL25M6W
Model
TXK2767
VIDEO ADJUST1 RED CUT OFF GREEN CUT OFF BLUE CUT OFF RED DRIVE GREEN DRIVE BLUE DRIVE SUB BRIGHT SUB CONTRAST SUB COLOR SUB TINT BCL THRESHOLD BCLGAIN BCL TIME DVD SUB TINT N. YC DELAY
INIT 127 127 127 127 127 127 110 52 27 30 62 8 13 90 0
TXK2550 TXK2554 CL25D4W TXK2566 TXK2567 CL663BW
CT-15A8
CL21S8W7X
Control FIX Control Control FIX Control Control Control FIX FIX FIX FIX FIX FIX FIX
127 127 127 150 127 170 100 52 50 70 60 8 10 100 3
127 127 127 127 127 127 110 52 50 70 54 8 10 100 3
127 127 127 127 127 127 100 52 50 70 58 8 10 100 3
127 127 127 127 127 127 100 52 50 70 58 8 10 100 3
127 127 127 127 127 127 114 52 50 30 70 8 10 100 3
127 127 127 127 127 127 110 52 67 15 40 8 13 120 4
127 127 127 127 127 127 100 52 60 30 62 9 5 25 4
127 127 127 127 127 127 110 52 60 30 67 9 5 25 4
Samsung Electronics INCH
Model
27V 1.3R
23V 1.3R
25V 1R
TXK2550 TXK2554 TXK2566 TXK2567
27V 1R
TXK2750 TXK2754
20V 1R TXK2060 TXK2066 TXK2067
15" FLAT
4-5 21" STEREO 25" STEREO
CL21S8W7X CL25M6P CL25M6W
TXK2767 CL25D4W
CT-15A8
Alignment and Adjustments
4-8-2(B) SCREEN CHANGE (I2C BUS GEOMETRIC ADJUSTMENT)
1
V Shift
6
V Amp
2
V Slope
7
V SC
3
H EW
8
H Trapizium
4
H Parabola
9
H Symmetry
5
H Corner
10
H Shift
4-6
Samsung Electronics
4-8-2(C) VIDEO ADJUST 1
H PARABOLA H SYMMETRY H CORNER H SHIFT PIP CONTRAST PIP TINT PIP PAL V.POS PIP NTSC V.POS PIP H.POS
-13 13 15 4
Control FIX Control Control FIX FIX FIX FIX FIX
-89 13 0 0 0 0 12 12 12
-44 13 69 8 0 0 12 12 12
-13(FIX) 13 69(FIX) 13 0 0 12 12 12
-13(FIX) 13 69(FIX) 13 0 0 12 12 12
-13(FIX) 13 69(FIX) 4 0 0 12 12 12
-13(FIX) 13 69(FIX) 13 0 0 12 12 12
-60 13 40 -27 7 0 Alignment and Adjustments 10 10 15 20 13 40 -24
INCH
27V 1.3R
23V 1.3R
25V 1R
27V 1R TXK2750 TXK2754
20V 1R
TXK2060 TXK2066 TXK2067
15" FLAT
21" STEREO 25" STEREO
CL25M6P CL25M6W
Model
TXK2767
VIDEO ADJUST1 RED CUT OFF GREEN CUT OFF BLUE CUT OFF RED DRIVE GREEN DRIVE BLUE DRIVE SUB BRIGHT SUB CONTRAST SUB COLOR SUB TINT BCL THRESHOLD BCLGAIN BCL TIME DVD SUB TINT N. YC DELAY
INIT 127 127 127 127 127 127 110 52 27 30 62 8 13 90 0
TXK2550 TXK2554 CL25D4W TXK2566 TXK2567 CL663BW
CT-15A8
CL21S8W7X
Control FIX Control Control FIX Control Control Control FIX FIX FIX FIX FIX FIX FIX
127 127 127 150 127 170 100 52 50 70 60 8 10 100 3
127 127 127 127 127 127 110 52 50 70 54 8 10 100 3
127 127 127 127 127 127 100 52 50 70 58 8 10 100 3
127 127 127 127 127 127 100 52 50 70 58 8 10 100 3
127 127 127 127 127 127 114 52 50 30 70 8 10 100 3
127 127 127 127 127 127 110 52 67 15 40 8 13 120 4
127 127 127 127 127 127 100 52 60 30 62 9 5 25 4
127 127 127 127 127 127 110 52 60 30 67 9 5 25 4
Note 1. Beam Control Limit Characteristic
INCH
27V 1.3R 23V 1.3R
25V 1R
TXK2550 TXK2554 TXK2566 TXK2567 CL663BW
27V 1R
TXK2750 TXK2754
20V 1R TXK2060 TXK2066 TXK2067
15" FLAT
21" STEREO 25" STEREO
CL25M6P CL25M6W
Model
TXK2767 CL25D4W
CT-15A8
CL21S8W7X
VIDEO ADJUST2 B STRETCH-BTHR B DTRETCH-BTLT B STERTCH-BAM CORING NTSC COMB FILTER RGB BRIGHT RG B CONTRAST EHT TIME EHT VERTICAL DTI CORING DTI GAIN DTI BAND EHT OFFSET EHT HORIZONTAL
INIT 50 8 4 31 1 0 0 0
FIX FIX FIX FIX FIX FIX FIX FIX FIX FIX FIX FIX FIX FIX
50 8 4 31 1 0 0 0 60 0 1 1 0 0
50 8 4 31 1 0 0 0 60 0 1 1 0 0
50 8 4 31 1 0 0 0 60 0 1 1 0 0
50 8 4 31 1 0 0 0 60 0 1 1 0 0
50 8 4 31 1 0 0 0 60 0 1 1 0 0
50 8 4 31 1 0 0 0 60 0 1 1 0 0
50 8 4 31 3 0 0 8 60 0 1 1 0 0
50 8 4 31 3 0 0 8 60 0 1 1 0 0
Samsung Electronics
4-7
BCLGAIN BCL TIME DVD SUB TINT N. YC DELAY
8 13 90 0
FIX FIX FIX FIX
8 10 100 3
8 10 100 3
8 10 100 3
8 10 100 3
8 10 100 3
8 13 120 4
9 5 25 4
9 5 25 4
Alignment and Adjustments
4-8-2(D) VIDEO 2 ADJUST
INCH
27V 1.3R 23V 1.3R
25V 1R
TXK2550 TXK2554 TXK2566 TXK2567 CL663BW
27V 1R
TXK2750 TXK2754
20V 1R TXK2060 TXK2066 TXK2067
15" FLAT
21" STEREO 25" STEREO
CL25M6P CL25M6W
Model
TXK2767 CL25D4W
CT-15A8
CL21S8W7X
VIDEO ADJUST2 B STRETCH-BTHR B DTRETCH-BTLT B STERTCH-BAM CORING NTSC COMB FILTER RGB BRIGHT RG B CONTRAST EHT TIME EHT VERTICAL DTI CORING DTI GAIN DTI BAND EHT OFFSET EHT HORIZONTAL
INIT 50 8 4 31 1 0 0 0
FIX FIX FIX FIX FIX FIX FIX FIX FIX FIX FIX FIX FIX FIX
50 8 4 31 1 0 0 0 60 0 1 1 0 0
50 8 4 31 1 0 0 0 60 0 1 1 0 0
50 8 4 31 1 0 0 0 60 0 1 1 0 0
50 8 4 31 1 0 0 0 60 0 1 1 0 0
50 8 4 31 1 0 0 0 60 0 1 1 0 0
50 8 4 31 1 0 0 0 60 0 1 1 0 0
50 8 4 31 3 0 0 8 60 0 1 1 0 0
50 8 4 31 3 0 0 8 60 0 1 1 0 0
4-8-2(E) VIDEO 3 ADJUST
INCH
27V 1.3R
23V 1.3R
25V 1R
27V 1R
20V 1R TXK2060 TXK2066 TXK2067
15" FLAT 21" STEREO 25" STEREO
CL25M6W CL25M6P
Model
VIDEO ADJUST3 PEAK WHITE LIMLT SOFT LIMIT SLOPE B HARD LIMIT MODULATION ON/OFF A TILT POINT B TILT POINT GAIN 1 (VIDEO) DELAY 1 (VIDEO) PEAK VIDEO REF PEAK VIDEO GAIN LIMIT VALUE VELOCITY DELAY VELOCITY CORING ACC-REF ACCR
INIT 255 4 255 0 0 0
TXK2550 TXK2554 TXK2750 TXK2767 CL25D4W TXK2566 TXK2754 TXK2567 CL663BW FIX FIX FIX FIX FIX FIX FIX FIX FIX FIX FIX FIX FIX FIX FIX 255 4 255 0 0 114 11 3 0 0 74 7 10 20 21 255 4 255 0 0 114 11 3 0 0 74 7 10 20 21 255 4 255 0 0 114 11 3 0 0 74 7 10 20 21 255 4 255 0 0 114 11 3 0 0 74 7 10 20 21
CT-15A8
CL21S8W7X
20 21
255 4 255 0 0 114 11 3 0 0 74 7 10 20 21
255 4 255 0 0 114 11 3 0 0 74 7 10 20 21
255 4 255 0 0 114 11 3 0 0 74 7 10 20 21
255 4 180 0 0 114 11 3 0 0 74 7 10 20 21
INCH
27V 1.3R
23V 1.3R
25V 1R TXK2550 TXK2554 TXK2566 TXK2567 CL663BW
27V 1R TXK2750 TXK2754
20V 1R TXK2060 TXK2066 TXK2067
15" FLAT
21" STEREO
25" STEREO
CL25M6W CL25M6P
4-8
Model TXK2767 CL25D4W
Samsung Electronics
CT-15A8 CL21S8W7X
OTHERS
INIT
VIDEO ADJUST3 INIT PEAK WHITE LIMLT 255 FIX 255 255 SOFT LIMIT SLOPE B 4 FIX 4 4 HARD LIMIT 255 FIX 255 1.3R 255 1.3R INCH 27V 23V MODULATION ON/OFF 0 FIX 0 0 A TILT POINT 0 FIX 0 0 Model FIX TXK2767 114 CL25D4W Note 2. Soft Limit & Hard Limit Characteristics B TILT POINT 0 114 GAIN 1 (VIDEO) FIX 11 11 DELAY 1 (VIDEO) ADJUST3 FIX 3 3 VIDEO INIT PEAK VIDEO REF WHITE LIMLT FIX 0 255 PEAK 255 FIX 0 255 SOFT PEAK VIDEO GAIN LIMIT SLOPE B FIX4 FIX 0 4 0 4 255 FIX 74 255 LIMIT VALUE HARD LIMIT FIX 74255 MODULATION ON/OFF VELOCITY DELAY FIX0 FIX 7 0 7 0 A TILT POINT 0 FIX 0 0 VELOCITY CORING POINT FIX0 FIX 10 114 10114 B TILT ACC-REF GAIN 1 (VIDEO) 20 FIX 20 11 FIX 20 11 DELAY 1 (VIDEO) 21 FIX 21 3 ACCR FIX 21 3
PEAK VIDEO REF PEAK VIDEO GAIN LIMIT VALUE VELOCITY DELAY VELOCITY CORING ACC-REF ACCR
TXK2566 TXK2754 TXK2567 CL663BW
TXK2067
CL25M6P
255 255 255 255 255 255 4 4 4 4 4 4 Alignment and Adjustments 2551R 255 255 15" FLAT 21" STEREO 255 STEREO 180 255 25V 27V 1R 20V 1R 25" 0 0 0 0 0 0 TXK2550 TXK2060 0 0 0 0 0 0CL25M6W TXK2554 TXK2750 CL21S8W7X 114 114 114 114 114 TXK2566 TXK2754 TXK2066 CT-15A8114 CL25M6P TXK2567 11 11 TXK2067 11 11 11 11 CL663BW 3 3 3 3 3 3 0 0 0 255 0 0 255 255 255 255 0 255 40 4 0 4 4 04 0 0 0 4 255 255 255 74 255 74 255 74 74 74 74 180 "Soft Limit" is that Limitting 0 0 0 0 70 7 7 7 7 7 0 0 0 0 0 the 0 peak white 0without 10 10 10 10 10 114 10 114 114 114 114 114 feed-back,20 11 but "Peak Limit" is 20 20 20 11 11 11 20 11 20 11 3 3 3 21 3 21 21 21that3with feed-back for white 21 21 3
0 0 74 7 10 20 21 0 0 74 7 10 20 21 0 0 74 7 10 20 21 0 0 74 7 10 20 21 0 peak level 0 74 7 10 20 21 0 0 74 7 10 20 21
20 21
FIX FIX FIX FIX FIX FIX FIX
0 0 74 7 10 20 21
0 0 74 7 10 20 21
INCH
27V 1.3R
23V 1.3R
25V 1R TXK2550 TXK2554 TXK2566 TXK2567 25V 1R CL663BW TXK2550
27V 1R TXK2750 TXK2754
27V 1R
20V 1R TXK2060 TXK2066 TXK2067
15" FLAT
21" STEREO
25" STEREO
CL25M6W CL25M6P
4-8-2(F) OTHERS
Model
INCH
TXK2767
27V 1.3R
CL25D4W
23V 1.3R
CT-15A8
15" FLAT
CL21S8W7X
25" STEREO
20V 1R
21" STEREO
INIT OTHERS TXK2060 TXK2554 TXK2750 CL25M6W CL21S8W7X 100 TXK2066104 CT-15A8 110 108 CL25D4W VSU 108 Model FIX 108 TXK2767 104 100 100 TXK2566 TXK2754 CL25M6P TXK2067 0 0 0 VSU2 FIX 0 0 0 0 0 TXK2567 CL663BW 0 0 H QEW 0 FIX 0 0 0 0 0 0 INIT OTHERS 25 108 -12 H ZOOM Parabola 8 FIX -22 108 -35104 8 8 8 8 100 VSU 108 FIX 100 100 104 110 -30 0 0 H 16:9 Parabola FIX 13 0 -18 -10 0 FIX 8 0 0 0-18 0 -18 0 VSU2 -10 0 FIX 0 0 0 0 0 0 0 1 0 1 TTX H Shift H QEW 0 FIX 0 0 0 0 0 0 25 8 FIXOFFSET-22 -35 8 8 8 OFFSET 8 -51-12 -61 PAL V SHIFT H ZOOM Parabola FIX OFFSET OFFSET OFFSET OFFSET -30 -10 FIX 13 -18 -18 -18 -19 0 -22 PAL H SHIFT H 16:9 Parabola FIX OFFSET 8 OFFSET OFFSET OFFSET OFFSET -10 OFFSET TTX H Shift 0 FIX 0 0 0 0 0 0 1 1 7 -61 7 Melidy Volume V SHIFT 5 FIX 7 OFFSET 7OFFSET 7 7 7 7 -51 PAL FIX OFFSET OFFSET OFFSET OFFSET PIP BRIGHT PAL H SHIFT FIX 3 -19 FIX OFFSET OFFSET OFFSET OFFSET OFFSET OFFSET -22 7 5 FIX 7 7 7 7 7 7 7 PIP COLOR Melidy Volume FIX 9 FIX 3 PIP VSPD PIP BRIGHT FIX 0 FIX PIP COLOR 9 65FL 275/265 45FL H Control 275/295 35FL 275/295 35FL 275/295 35FL 275/295 35FL 275/295 35FL 275/295 95FL 275/265 0 PIP FIX WHITE BALANCE VSPD L Control Control 275/295 35FL 275/295 35FL275/295 1.2FL 275/295 35FL 275/295 35FL 1.2FL 275/295 2.0FL 65FL 275/265 45FL275/265 1.4FL 275/295 1.2FL 275/295 1.2FL 275/295 35FL 275/295 1.2FL 275/295 275/295 95FL 275/265 275/265 1.2FL H WHITE BALANCE
L Control 275/295 1.2FL 275/295 1.2FL 275/295 1.2FL 275/295 1.2FL 275/295 1.2FL 275/295 2.0FL 275/265 1.2FL 275/265 1.4FL
4-8-2(G) G2 ADJUST
INCH
INCH 27V 25V 1R 27V 1.3R 1.3R23V23V 1.3R 25V 1R 1.3R 27V 1R 1R 15" 15" 21" 21" 25" STEREO 27V 1R 20V20V 1R FLAT FLAT STEREO STEREO 25" STEREO
TXK2550 TXK2550 TXK2060 TXK2060 TXK2554 TXK2750 CT-15A8 CL21S8W7X CL25M6W CL25M6W CL25D4W TXK2554 TXK2750 TXK2066 TXK2566 TXK2754 CL25M6P Model TXK2767 CL25D4W TXK2066 CT-15A8 CL21S8W7X TXK2566 TXK2754 TXK2067 CL25M6P TXK2567 TXK2067 TXK2567 CL663BW G2 Adjust CL663BW MRC R Max 110 110 110 110 110 110 110 110 G2 Adjust G B MRWDG 110 110 110 110 110 110 110 MRC R G B 110 Max 110 110 110 110 110 110 110 110 IBRM FIX 210 210 210 205 220 225 205 205 110 MRWDG WDRV 110 110 110 45 11035 FIX 110 35 35 35 35 110 35 110 45 205 IBRM FIX FIX 210 170 205 210 210 225 150 CDL 150 150 115 205 180 220 220 120 150 150 120 35 100 35 75 45 WDRV COL FIX MIN 35 150 35 35 45 140 35140 150 CDL FIX 170 150 150 115 180 220 120 140 COL MIN 150 150 150 120 100 75 140 Model TXK2767
Samsung Electronics
4-9
Alignment and Adjustments
4-8-3 Deflection (Memory Data)
- SIM408A USA, LATIN FACTORY (VDP IC VDP3130Y)
4-8-3(A) GEOMETRIC ADJUSTMENT VALUE
INCH
27V 1.3R
23V 1.3R
25V 1R TXK2550 TXK2554 TXK2566 TXK2567 CL663BW
27V 1R TXK2750 TXK2754
20V 1R TXK2060 TXK2066 TXK2067
15" FLAT
21" STEREO 25" STEREO CL25M6W CL25M6P
Model
TXK2767
CL25D4W
CT-15A8 CL21A8W7X
DEFLECTION H Bow H Angle H Dscc V SHIFT V AMP V SLOPE V SC H EW H TRAPEZIUM H PARABOLA H SYMMETRY H CORNER H SHIFT PIP CONTRAST PIP TINT PIP PAL V.POS PIP NTSC V.POS PIP H.POS
INIT 0 0 0 -40 5 -2 -7 64 -20 -13 13 15 4
FIX FIX FIX Control Control Control FIX Control Control Control FIX Control Control FIX FIX FIX FIX FIX
0 0 3 -27 -50 -7 0 10 -82 -89 13 0 0 0 0 12 12 12
0 0 3 -24 -41 -4 -13 -37 -48 -44 13 69 8 0 0 12 12 12
0 0 3 -18 18 -4 -13 64(FIX) -20(FIX) -13(FIX) 13 69(FIX) 13 0 0 12 12 12
0 0 3 -18 18 -4 -13 64(FIX) -20(FIX) -13(FIX) 13 69(FIX) 13 0 0 12 12 12
0 0 3 -40 5 -2 -13 64(FIX) -20(FIX) -13(FIX) 13 69(FIX) 4 0 0 12 12 12
0 0 3 -35 20 -4 -13 64(FIX) -20(FIX) -13(FIX) 13 69(FIX) 13
0 0 3 -40 -20 -6 -5 -5 -20 20 13 40 -24 0 0 10 10 15
0 0 3 -50 -15 -2 -6 10 -20 -60 13 40 -27 7 0 10 10 15
4-10
Samsung Electronics
Alignment and Adjustments
4-9 MICOM
4-9-1 Pin Layout
Write Protect EEPROM SDA EEPROM SCL Bus-Stop Main SDA Main SCL Sound Reset Video Reset VDD 2.5V GND VDD 3.3V CVBS Input VDD 2.5V GND AFT Scart1 Ident Scart2 Ident Key 1 H-Sync V-Sync Key 3 Key 2 X-Ray Protect IR Input Stand-By LED Time LED
1 2 3 4 5 6 7 8 9 10 11 12 13 14
I/O I/O IO I/O I/O I/O I/O I/O
PWM I/O I/O
52 51 50 49 48 47 46 45
Tilt N.C. Power Sound Mute N.C. N.C. PX. Y PX. Y VDD 3.3V GND VDD 2.5V CORE OSD-B OSD-G OSD-R VDD 2.5V GND X-TAL Out X-TAL In MICOM Reset N.C. N.C. VDD 3.3V GND N.C. Relay
15 ADC 16 ADC 17 ADC 18 ADC 19 20 21 I/O 22 I/O 23 I/O 24 I/O 25 I/O 26 I/O
S I M 4 0 8 A
44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 I/O 27
Samsung Electronics
4-11
Alignment and Adjustments
4-9-2 Pin Assignment Specification
PIN NO FUNCTION 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 I/O I/O I/O I/O I/O I/O I/O I/O Vdd GND Vdd CVBS Vdd GND ADC ADC ADC ADC HS VS I/O I/O I/O I/O I/O I/O
ASSIGN Write Protect ROM SDA ROM SCL Bus Stop Main SDA Main SCL Sound Reset Video Reset VDD 2.5V
IN/OUT Out I/O I/O In I/O I/O Out Out
ACTIVE H/L Low
DESCRIPTION EEPROM Write Protection EEPROM Serial Data Line EEPROM Serial Clock Line
Low
Disable Micom IIC Peripheral IC Serial Data Line
Low Low
Peripheral IC Serial Clock Line MSP IC Initial Control VDP IC Initial Control
VDD 3.3V CVBS Input VDD 2.5V In TTX CVBS Input Analog B+ Analog Ground AFT SC1-ID SC2-ID Key1 H-Sync V-Sync Key3 Key2 X-Ray IR-In STD-LED TIM-LED In In In In In In In In In In Out Out Auto Fine Tuning Control Scart1 Ident Scart2 Ident Key1 Input Horizontal Sync Input Vertical Sync Input Key3 Input Key2 Input X-Ray Protection Remocon Signal Input LED Drive Output(Red) LED Drive Output(Green)
4-12
Samsung Electronics
Alignment and Adjustments
4-9-2 Pin Assignment Specification (Continued)
PIN NO FUNCTION 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 I/O N.C. GND Vdd N.C. N.C. Reset X-In X-Out GND Vdd R G B COR Vdd GND Vdd I/O I/O N.C. Not Used (Programmed Gound Level) N.C. I/O I/O N.C. I/O S-Mute Power Out Out High Low Sound Amp Mute Picture On/Off Control Not Used (Programmed Gound Level) VDD 3.3V PX.Y PX.Y In When The Caption Function Adopted, Used. Out VDD 2.5V OSD-R OSD-G OSD-B CORE VDD 2.5V Out Out Out Out Reset X-TAL In X-TAL Out In In Out Low 6MHz 6MHz VDD 3.3V ASSIGN Relay
IN/OUT Out
ACTIVE H/L Low
DESCRIPTION Activate Degausssing Coil Not Used (Programmed Gound Level) Analog Ground Not Used (Programmed Gound Level) Not Used (Programmed Gound Level) Micom Hardware Reset Crystal Oscillation Input Crystal Oscillation Output Analog Ground Analog B+ OSD/TTX Output (Red) OSD/TTX Output (Green) OSD/TTX Output (Blue) Fast Blank/Half Contrast Output
Samsung Electronics
4-13
MEMO
4-14
Samsung Electronics
Troubleshooting
5. Troubleshooting
5-1 No Power
Disconnect the Power Cord
Check/Replace IC803, DDR01 Abnormal
Check Power LED
LED ON
Check IC901 Pin 5 6
Normal
Check IC901 Pin 50
Normal
Check the voltage of IC803, 805
LED OFF
Abnormal
Abnormal
Normal
Check IC901 B+
Normal
Check Q909, Q910 Abnormal
Normal
Replace IC901
Abnormal
Check H-OUT of IC201 Pin 50
Abnormal
Check IC803 Normal
Replace Q909,Q910 Abnormal Check IC902
Replace IC201 Abnormal
Normal
Check the voltage of IC804 Abnormal
Check the voltage of IC803, 805 Normal Check FBT and B+(130V)
Check IC803
Replace IC902
Normal
Check Q401 and Horizontal Circuit
Check the resistance of FD803 Normal
Abnormal
Check SCL, SDA Line
Replace FD803
Check IC801, D801 FUSE
Samsung Electronics
5-1
Troubleshooting
5-2 No Raster (Sound OK)
Check Fusible Resistance Abnormal Check voltage of heater Normal
No Raster (Sound OK)
Check the fusible resistance of abnormal volatge line Abnormal
Check Abnormal RK,GK,BK Signal output from CRT PCB
Check R.G.B Signal input to CRT PCB
Normal
Check B+ (200V, 16V)
Normal
Abnormal
Normal
Check CRT and FBT
Abnormal
Check R.G.B Signal Output from IC201 Normal Check Q202, Q203, Q204, Q207, Q209, Q213, Q206, Q208, Q210
Re-adjust Screen Voltage
Check the signal output from IC201 Pin 63 Normal Check / Replace IC201 Abnormal Check tuner B+ and Main CVBS
5-2
Samsung Electronics
Troubleshooting
5-3 No Sound
No Sound
Normal Check Speaker and Wire
Check the signal output from 602 Pins
Abnormal Check the signal input to IC602 pins 4 ,12
Abnormal
Normal
Normal
Check the signal input to IC601 Pin 47 Abnormal
Abnormal
Check IC602 B+ Normal Replace IC602
Normal
Check IC601 B+
Abnormal
Check tuner B+ and SIF
Check/Replace the resistance of FD802
Check/Replace IC601
Check B+ Line (8V)
Samsung Electronics
5-3
Troubleshooting
5-4 Horizontal Lines Appear on screen
Horizontal Lines Apper on screen
Normal
Check IC301 B+ (16V, -16V)
Abnormal Check B+ Line and the fusible resistance of R425, 424
Normal
Check the VDP Signal output from IC201 Pin 31 Abnormal
Check/Replace IC301
Check IC201
5-4
Samsung Electronics
Exploded View & Parts List
6. Exploded View & Parts List
6-1 TXM2091FX/XAA
No 1 1-1 1-2 1-3 1-4 1-5 1-6 1-7 1-8 1-9 1-10
Code No AA64-02977A AA64-02979A AA61-60003J 3001-000274 6003-001026 AA61-40113A AA64-02978A 6003-001026 AA64-00816B 6003-001026 AA65-30105A
Description;Specification CABINET-FRONT;21A8,HIPS,VO,BLK,DG703P,SE KNOB-POWER;21A8,ABS,HB,BLK,DG703P SPRING-CS;-,-,SUS304,0.5,OD6,H SPEAKER-GENERAL;5W8OHM100X50MM SCREW-TAPTITE;RH,+,B,M4,L15,ZPC(BLK),SWR STOPPER-PCB;-,ABS,HB,NTR. KNOB-CONTROL;21A8,ABS,HB,BLK,DG703P SCREW-TAPTITE;RH,+,B,M4,L15,ZPC(BLK),SWR WINDOW REMOCON;-,21A8,-,PC,V0,VIOLET,SCREW-TAPTITE;RH,+,B,M4,L15,ZPC(BLK),SWR CLAMP-WIRE;NYLON 66N,VO,NTR,15MM
Q'ty 1 1 1 2 8 1 1 1 1 1 1
Remark F/C KP SPRING SPK SPK+CF STOPPE KC KC+CF WR WR+CF CWFCL
2 2-1 2-2 2-3
AA03-00317A AA65-00009B AA60-10050R 3704-001105
CRT COLOR;A51QDX992X,0MG,1.85MH,18.0MH,2 CLAMP-D,COIL;NYLON 66,V0,-,-,21A8,SCREW-ASSY;WC,HH,+M5,L31.5,SWR SOCKET-CRT;11P,20PI,26.5PI,NI,-
1 4 4 1
CRT CDCOIL CRT+CF V999S
3 3-1 3-2
AA64-00811D 6003-001026 AA96-20129A
CABINET BACK;21A8,HIPS,-,-,-,V0,BLK,SCREW-TAPTITE;RH,+,B,M4,L15,ZPC(BLK),SWR ASSY-POWER,CORD;-,EP2/YES,H/C300,ME301P,
1 4 1
C/B CB+CF PWR/AC
Samsung Electronics
6-1
Electrical Parts List
7. Electrical Parts List
7-1 TXM2091FX/XAA
Loc. No. Code No. Description ; Specification Remark Loc. No. Code No. Description ; Specification Remark
ASSY CHASSIS
1 2 2 2 2 2 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 4 4 3 3 3 3 3 3 4 4 4 A/CHAS INLA/P DRESB FBT H/S+CW ASSY,P AA91-01598A AA64-01230B AA65-30018A AA65-30018A AA65-30018A AA94-07046A 0202-000008 0202-000187 0204-000442 0204-001024 0402-000233 0402-001082 0402-001296 0502-001007 0502-001136 0604-001032 1103-001211 1203-001944 1203-002085 1204-001594 1204-001812 1404-000208 1404-001045 2201-000406 2201-000446 2301-001067 2301-001338 2301-001467 2301-001468 2306-000318 2306-000318 2306-000350 2401-001387 2401-003026 3404-001004 3501-001040 3601-001012 3704-001105 3711-002644 3711-002647 3711-003043 3722-001333 3722-001423 AA09-00243A AA26-00044C AA26-00057A AA26-50001M AA27-00098A AA27-00146A AA27-00147A AA29-30002N AA29-30002N AA39-00172A AA39-20053A AA39-20054B AA39-20010B AA39-20010H AA40-00074A AA59-60001U AA68-01018A AA96-00243C 0205-000129 1203-000284 6003-000335 ASSY CHASSIS-KS2A;SPACE INLAY-COVER;D2,D3,PVC-SHEET,T0.4,94V0,-, CLAMP-WIRE;-,NYLON6.6,-,-,DATL CLAMP-WIRE;-,NYLON6.6,-,-,DATL CLAMP-WIRE;-,NYLON6.6,-,-,DATL ASSY PCB MAIN;TXL2091FX/XAA SOLDER-WIRE;S63S-D3.0,S63A,D3,63/37 SOLDER-WIREFLUX;-,RS60S,D1.2,6 SOLVENT;CH3-CH5H-CH396%IM-1000 FLUX;DF-96TVS,-,20%,DIODE-RECTIFIER;FML-G12S,200V, DIODEBRIDGE;RBV406LFB,600V,4A DIODE-RECTIFIER;FMP-3FU,1500V,5A,T0-3PF TR-POWER;KSC2073-H2,NPN,150V,1 TR-POWER;KSD5703,NPN,70W,TO-3PF,ST,8PHOTO-COUPLER;TR,170-260%,300M IC-EEPROM;24C16-PC27 C,2048x8Bit,DIP,8P, IC-POSI.FIXEDREG.78RM33,TO-220,3P,PLAST IC-VOLTAGEREGULATOR;78R08,TO-220,4P IC-SOUND PROCESSOR;MSP3440G-B6,SDIP,52P, IC-VIDEO PROCESS;VDP3130Y-B2,DIP,64P,760 POSISTOR;PTH631D02BF7ROM140TDE THERMISTOR NTC;4.7OHM,15%,2900K,35.0MW,T C-CERAMIC,HIC;CK45(T)B2KV271-K C-CERAMIC,AC;CK45PE400V332-M(T C-FILM,MPPF;82NF,5%,400V,TP,19 C-FILM,MPE,PPF0.68nF,5%,1.6kV,TP,28x7x1 C-FILM,PPF;3.9NF,3%,1.6KV,TP,29X8.X15MM, C-FILM,PPF;3.3NF,3%,1.6KV,TP,29X13.5X8MM C-FILM,MPPF;220NF,20%,250V,-,2 C-FILM,MPPF;220NF,20%,250V,-,2 C-FILM,MPPF;270nF,5%,400V,BK,26x18.5x10, C-AL;470uF,20%,250V,GP,BK,25.4x40,1 C-AL;330UF,20%,200V,GP,ST,22X3 SWITCH TACT;12V,50MA,160GF8.4X22.7MM RELAYPOWER;12VDC,500MW,10A,1FO FUSE-FERRULE;250V,4A,SLOW-BLOW SOCKET-CRT;11P,20PI,26.5PI,NI,POST-HEADER;67094-005(AUTO) POST-HEADER;67094-008(AUTO) CONNECTOR-HEADER;BOX,4P,1R,2.5mm,STRAIGH JACK-RCA9P,3.2mm,NI,BLK JACK-RCA;3P+S1P,3.4mm,NI,BLK,IC MICOM;SIM-408A3,CL-21A8,52P,-0.3~+7, TRANS SWITCHING,CODE-NO,CT-21A8,AC90-260 TRANS-FBT;-,FUH-29A001B(S),25/29,130 HORIZ.DRIVE;-,80MH,520UH,4UH,E COIL CHOKE;-,-,24uH,10%,-,0.1,3.0A,DR10X COIL LINEARITY;,68UH,L-81 OWA 12X15,2UEW COIL HORIZ. WIDTH;,170UH,BK,54T+2-2 FILTER-LINE NOISE;-,16MH,1.5A,AC100~260V FILTER-LINE NOISE;-,16MH,1.5A,AC100~260V LEAD-CONNECTOR,ASSY;DREAM,1007#26,UL/CSA LEAD-CONNECTOR,ASSY;YBNH025-05,S,5P,400m LEAD-CONNECTOR,ASSY;YBNH025-06,S,6P,500m LEAD-CONNECTOR,ASSY;-,YFH800-01,500MM,1P LEAD-CONNECTOR,ASSY;,YFH800-01,S,1P,300, TUNER;TCPN3081PA09A(B),NTSC,181CH,45 MODULE-REMOCON;-,ORC-50VF,38KH LABEL-PQS,-,50mmX,13,-,WHITE,ASSY H/S;-,REGULATOR,AA62-00045A,KA7806 GREASE-SILICON;SC102,JAPAN IC-POSI.FIXEDREG.;7806,TO-220, SCREW-TAPTITE;RH,+,2S,M3,L8,ZPC(YEL),SWR
! !
!
! ! ! ! ! ! ! ! ! ! !
! ! ! !
! ! ! ! ! ! !
!
!
D813 D801S DH02 Q402 DH01 PC801S IC902 IC903 IC803 IC601 IC201S P802S NT802S C428 CY802S CR403S C407 CR402S CR401S CX801S CX802S CR405S C806 C815 SW906 RL801S FP801S V999S CN602 CN701 CN601 JA701 JA702 IC901 T801S T444S T401 L808 LR401S CR404S LX801S LX802S CN501B CN502B CN501B GT101 GT407 TU01S RM901 L/PQS IC804
!
!
!
!
! !
! ! !
4 3 4 4 4 4 4 4 3 3 4 4 4 4 3 4 4 3 4 4 4 4 4 4 3 4 4 4 4 3 4 4 4 3 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4
AA62-00045A AA96-00469F 0205-000129 0402-001358 0402-001375 1203-001006 6003-000334 AA62-00053B LD901 AA96-00555A IC501 AA96-00582A 0205-000129 1201-001687 6003-000335 AA62-00096A PWR/AC AA96-20129A AA39-10007Y AA61-20284A IC801S AA96-50373F 0205-000129 6003-000333 AA02-00007A AA13-00101A AA61-10386A AA62-30181K IC602 AA96-50398B 0205-000129 1201-001308 6003-000333 AA62-30182E IC301 AA96-50406A 1204-000517 6003-000333 AA62-30180K ASSY,A AA97-02203A D201 0401-000005 D202 0401-000005 D207 0401-000005 D208 0401-000005 D209 0401-000005 D210 0401-000005 D212 0401-000005 D501 0401-000005 D502 0401-000005 D503 0401-000005 D508 0401-000005 D602 0401-000005 D604 0401-000005 D804 0401-000005 D908 0401-000005 DZ402 0401-000005 D407 0402-000493 DR01S 0402-000534 D413 0402-000537 D401 0402-000540 D402 0402-000540 D301 0402-000546 D411 0402-000546 D803 0402-000546 D801 0402-001111 D403 0402-000132 D406 0402-000132 D504 0402-000132 D808 0402-000132 D810 0402-000132 D811 0402-000132 D907 0402-000132 DZ201 0403-000508 DZ203 0403-000508 DZ204 0403-000508 DDR01
HEAT SINK-PS;-,-,T1.0,-,-,DREAM,-,-,-,-, ASSY H/S;-,REGULATOR,AA62-00053B,D10U60 GREASE-SILICON;SC102,JAPAN DIODE-RECTIFIER;SDS10U60S,600V,10A,TO-22 DIODE-RECTIFIER;FFPF10U20S,200V,10A,TO-2 IC-VOLTAGEREGULATOR78R05,TO-220F,4P SCREW-TAPTITE;RH,+,2S,M3,L6,ZP HEAT SINK;DREAM (D2,D3),AL ,T1.0,147,50, ASSY LED GUIDE;-,-,UEX-LD-030,GREEN ASSY H/S;-,CRT,AA62-00096A,STV5109,KS1A GREASE-SILICON;SC102,JAPAN IC-VIDEO AMP;STV5109,ZIP,15P,-,SIGLE,50d SCREW-TAPTITE;RH,+,2S,M3,L8,ZPC(YEL),SWR HEAT SINK;KS2A,AL5052,T1.0,W36.0,H35.0,S ASSY-POWER,CORD;-,EP2/YES,H/C300,ME301P, POWER-CORD;-,EP2/YES,SPT-2 18AWGx2C,2.4m HOLDER P CORD;PP,VO,BLK,KE-002 ASSY H/S;-,PWM,AA62-30181K,KA3A1265RD GREASE-SILICON;SC102,JAPAN SCREW-TAPTITE;RH,+,2S,M3,L10,ZPC(YEL),SW MICA;DPM-04,MICA,22x29x0.15mm IC HYBRID;KA3A1265RD,CN5039,5Pin,-50to12 BRACKET-IC;-,-,SECC100,T1.0,-,KA2S0680, HEATSINK-ES;-,AL6063EXTR.,2,WHT,40MM,ASSY-H/S;-,-,AA62-30182E,TDA7266S,GREASE-SILICON;SC102,JAPAN IC-POWERAMP;7266,ZIP,15P,-,DUAL,26dB,PL SCREW-TAPTITE;RH,+,2S,M3,L10,ZPC(YEL),SW HEAT-SINK,ES;-,A6063 EXTR,-,WHT,-,-,-,40 ASSY-H/S;LA62-30180K,LA7845 IC-LINEAR;LA7845SIPVERTICALAMP SCREW-TAPTITE;RH,+,2S,M3,L10,ZPC(YEL),SW HEATSINK-ES;-,A6063EXTR,-,WHT,50/13,-, ASSY AUTO-MAIN;TXL2091FX/XAA DIODE;1N4148,100V,300mA,1V,8nS,TAPING DIODE;1N4148,100V,300mA,1V,8nS,TAPING DIODE;1N4148,100V,300mA,1V,8nS,TAPING DIODE;1N4148,100V,300mA,1V,8nS,TAPING DIODE;1N4148,100V,300mA,1V,8nS,TAPING DIODE;1N4148,100V,300mA,1V,8nS,TAPING DIODE;1N4148,100V,300mA,1V,8nS,TAPING DIODE;1N4148,100V,300mA,1V,8nS,TAPING DIODE;1N4148,100V,300mA,1V,8nS,TAPING DIODE;1N4148,100V,300mA,1V,8nS,TAPING DIODE;1N4148,100V,300mA,1V,8nS,TAPING DIODE;1N4148,100V,300mA,1V,8nS,TAPING DIODE;1N4148,100V,300mA,1V,8nS,TAPING DIODE;1N4148,100V,300mA,1V,8nS,TAPING DIODE;1N4148,100V,300mA,1V,8nS,TAPING DIODE;1N4148,100V,300mA,1V,8nS,TAPING DIODE-RECTIFIER;1R5GU41,400V,1 DIODE-RECTIFIER;RG10V,400V,1.5 DIODE-RECTIFIER;RH1A,600V,0.6A, DIODE-RECTIFIER;RU20A,600V,1.5 DIODE-RECTIFIER;RU20A,600V,1.5 DIODE-RECTIFIER;TVR10G,400V,1. DIODE-RECTIFIER;TVR10G,400V,1. DIODE-RECTIFIER;TVR10G,400V,1. DIODE-RECTIFIER;1N5397GP,600V,1.5A,DO-2 DIODE-RECTIFIER;1N4004,400V,1A,DO-41 DIODE-RECTIFIER;1N4004,400V,1A,DO-41 DIODE-RECTIFIER;1N4004,400V,1A,DO-41 DIODE-RECTIFIER;1N4004,400V,1A,DO-41 DIODE-RECTIFIER;1N4004,400V,1A,DO-41 DIODE-RECTIFIER;1N4004,400V,1A,DO-41 DIODE-RECTIFIER;1N4004,400V,1A,DO-41 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500
Samsung Electronics
7-1
Electrical Parts List
Loc. No.
Code No.
Description ; Specification
Remark
Loc. No.
Code No.
Description ; Specification
Remark
!
!
!
! !
4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4
DZ601 DZ602 DZ802 DZ806 DZ901 DZ902 DZ903 DZ904 DZ905 DZ906 DZ907 DZ908 DZ306 DZ804 DZ808 DZ701 DZ702 DZ803 DZ509 DZ305 DZ202 DZR01S DZ801 DZ501 DZ301 DZ302 DZ303 DZ304 D203 D204 D205 D206 D901 D902 D903 D904 D905 Q206 Q208 Q210 QR01S Q802 Q201 Q202 Q203 Q204 Q207 Q209 Q211 Q212 Q213 Q222 Q901 Q902 Q903 Q904 Q905 Q906 Q907 Q908 Q911 QR02S Q909 Q910 DZ805 IC904 VP801S VX801S R223 R224 R225 R226 R264 R265 R267 R934 R245
0403-000508 0403-000508 0403-000508 0403-000508 0403-000508 0403-000508 0403-000508 0403-000508 0403-000508 0403-000508 0403-000508 0403-000508 0403-000700 0403-000700 0403-000719 0403-000720 0403-000720 0403-001167 0403-001211 0403-001221 0403-001321 0403-001321 0403-001322 0403-001325 0403-001328 0403-001329 0403-001329 0403-001329 0404-000156 0404-000156 0404-000156 0404-000156 0404-000156 0404-000156 0404-000156 0404-000156 0404-000156 0501-000283 0501-000283 0501-000283 0501-000283 0501-000369 0501-000389 0501-000389 0501-000389 0501-000389 0501-000389 0501-000389 0501-000389 0501-000389 0501-000389 0501-000389 0501-000389 0501-000389 0501-000389 0501-000389 0501-000389 0501-000389 0501-000389 0501-000389 0501-000389 0501-000389 0505-000109 0505-000109 1203-001217 1203-001943 1405-000152 1405-000152 2001-000003 2001-000003 2001-000003 2001-000003 2001-000003 2001-000003 2001-000003 2001-000003 2001-000005
DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 DIODE-ZENER;TZP33A,33V,31-35V, DIODE-ZENER;TZP33A,33V,31-35V, DIODE-ZENER;MTZJ7.5B,7.5V,7.07-7.45V,500 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 DIODE-ZENER;MTZJ30D,30V,29.02-30.51V,500 DIODE-ZENER;MTZJ12B,11.44-12.03V,500MW,D DIODE-ZENER;UZ39BSB,35.36-37.19V,500MW,D DIODE-ZENER;MTZJ6.8C,6.66-7.01V,500mW,DO DIODE-ZENER;MTZJ6.8C,6.66-7.01V,500mW,DO DIODE-ZENER;MTZJ8.2B,7.78-8.19V,500mW,DO DIODE-ZENER;MTZJ15C,14.35-15.09V,500mW,D DIODE-ZENER;MTZJ22A,20.15-21.20V,500mW,D DIODE-ZENER;MTZJ24B,22.61-23.77V,500mW, DIODE-ZENER;MTZJ24B,22.61-23.77V,500mW, DIODE-ZENER;MTZJ24B,22.61-23.77V,500mW, DIODE-SCHOTTKY;RB441Q,10V,100MA,DO-34,TP DIODE-SCHOTTKY;RB441Q,10V,100MA,DO-34,TP DIODE-SCHOTTKY;RB441Q,10V,100MA,DO-34,TP DIODE-SCHOTTKY;RB441Q,10V,100MA,DO-34,TP DIODE-SCHOTTKY;RB441Q,10V,100MA,DO-34,TP DIODE-SCHOTTKY;RB441Q,10V,100MA,DO-34,TP DIODE-SCHOTTKY;RB441Q,10V,100MA,DO-34,TP DIODE-SCHOTTKY;RB441Q,10V,100MA,DO-34,TP DIODE-SCHOTTKY;RB441Q,10V,100MA,DO-34,TP TRANSISTOR;KSA539-Y(TAPG)/YTAM TRANSISTOR;KSA539-Y(TAPG)/YTAM TRANSISTOR;KSA539-Y(TAPG)/YTAM TRANSISTOR;KSA539-Y(TAPG)/YTAM TRANSISTOR;KSC2331-Y(TAPG) TRANSISTOR;KSC815-Y(TAPG)/YTAM TRANSISTOR;KSC815-Y(TAPG)/YTAM TRANSISTOR;KSC815-Y(TAPG)/YTAM TRANSISTOR;KSC815-Y(TAPG)/YTAM TRANSISTOR;KSC815-Y(TAPG)/YTAM TRANSISTOR;KSC815-Y(TAPG)/YTAM TRANSISTOR;KSC815-Y(TAPG)/YTAM TRANSISTOR;KSC815-Y(TAPG)/YTAM TRANSISTOR;KSC815-Y(TAPG)/YTAM TRANSISTOR;KSC815-Y(TAPG)/YTAM TRANSISTOR;KSC815-Y(TAPG)/YTAM TRANSISTOR;KSC815-Y(TAPG)/YTAM TRANSISTOR;KSC815-Y(TAPG)/YTAM TRANSISTOR;KSC815-Y(TAPG)/YTAM TRANSISTOR;KSC815-Y(TAPG)/YTAM TRANSISTOR;KSC815-Y(TAPG)/YTAM TRANSISTOR;KSC815-Y(TAPG)/YTAM TRANSISTOR;KSC815-Y(TAPG)/YTAM TRANSISTOR;KSC815-Y(TAPG)/YTAM TRANSISTOR;KSC815-Y(TAPG)/YTAM FET-SILICON;2N7000,N,60V,200mA,5ohm,400 FET-SILICON;2N7000,N,60V,200mA,5ohm,400 IC-POST,ADJUSTREG;431,T0-92,3P,4.58MIL,P IC-VOL.DETECTOR;7025,T0-92,3P,PLASTIC VARISTOR;560V,2500A,14X8.5MM,T VARISTOR;560V,2500A,14X8.5MM,T R-CARBON;330OHM,5%,1/8W,AA,TP, R-CARBON;330OHM,5%,1/8W,AA,TP, R-CARBON;330OHM,5%,1/8W,AA,TP, R-CARBON;330OHM,5%,1/8W,AA,TP, R-CARBON;330OHM,5%,1/8W,AA,TP, R-CARBON;330OHM,5%,1/8W,AA,TP, R-CARBON;330OHM,5%,1/8W,AA,TP, R-CARBON;330OHM,5%,1/8W,AA,TP, R-CARBON;390OHM,5%,1/8W,AA,TP,
!
! !
4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4
R250 R255 R916 R214 R918 RR03S R303 R412 R527 R307 R825 R209 R914 R103 R201 R203 R204 R246 R251 R256 R609 R610 R611 R612 R613 R619 R706 R707 R708 R723 R730 R731 R902 R907 R909 R940 R941 R942 R944A R202 R205 R206 R211 R260 R261 R262 R268 R309 R310 R601 R602 R606 R620 R627 R715 R716 R935 RR07S RR10S R241 R208 R243 R509 R511 R517 C906 D505 D506 D507 J909 R222 R231 R232 R233 R234 R235 R252
2001-000005 2001-000005 2001-000007 2001-000008 2001-000009 2001-000009 2001-000016 2001-000020 2001-000028 2001-000066 2001-000066 2001-000221 2001-000221 2001-000281 2001-000281 2001-000281 2001-000281 2001-000281 2001-000281 2001-000281 2001-000281 2001-000281 2001-000281 2001-000281 2001-000281 2001-000281 2001-000281 2001-000281 2001-000281 2001-000281 2001-000281 2001-000281 2001-000281 2001-000281 2001-000281 2001-000281 2001-000281 2001-000281 2001-000281 2001-000290 2001-000290 2001-000290 2001-000290 2001-000290 2001-000290 2001-000290 2001-000290 2001-000290 2001-000290 2001-000290 2001-000290 2001-000290 2001-000290 2001-000290 2001-000290 2001-000290 2001-000290 2001-000290 2001-000290 2001-000362 2001-000405 2001-000405 2001-000405 2001-000405 2001-000405 2001-000429 2001-000429 2001-000429 2001-000429 2001-000429 2001-000429 2001-000429 2001-000429 2001-000429 2001-000429 2001-000429 2001-000429
R-CARBON;390OHM,5%,1/8W,AA,TP, R-CARBON;390OHM,5%,1/8W,AA,TP, R-CARBON;3KOHM,5%,1/8W,AA,TP,1 R-CARBON;15KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;20KOHM,5%,1/8W,AA,TP, R-CARBON;20KOHM,5%,1/8W,AA,TP, R-CARBON(S);1OHM,5%,1/2W,AA,TP R-CARBON(S);22OHM,5%,1/2W,AA,T R-CARBON(S);100OHM,5%,1/2W,AB, R-CARBON(S);10KOHM,5%,1/2W,AA, R-CARBON(S);10KOHM,5%,1/2W,AA, R-CARBON;1.2KOHM,5%,1/8W,AA,TP R-CARBON;1.2KOHM,5%,1/8W,AA,TP R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;100OHM,5%,1/8W,AA,TP, R-CARBON;10KOHM,5%,1/8W,AA,TP, R-CARBON;10KOHM,5%,1/8W,AA,TP, R-CARBON;10KOHM,5%,1/8W,AA,TP, R-CARBON;10KOHM,5%,1/8W,AA,TP, R-CARBON;10KOHM,5%,1/8W,AA,TP, R-CARBON;10KOHM,5%,1/8W,AA,TP, R-CARBON;10KOHM,5%,1/8W,AA,TP, R-CARBON;10KOHM,5%,1/8W,AA,TP, R-CARBON;10KOHM,5%,1/8W,AA,TP, R-CARBON;10KOHM,5%,1/8W,AA,TP, R-CARBON;10KOHM,5%,1/8W,AA,TP, R-CARBON;10KOHM,5%,1/8W,AA,TP, R-CARBON;10KOHM,5%,1/8W,AA,TP, R-CARBON;10KOHM,5%,1/8W,AA,TP, R-CARBON;10KOHM,5%,1/8W,AA,TP, R-CARBON;10KOHM,5%,1/8W,AA,TP, R-CARBON;10KOHM,5%,1/8W,AA,TP, R-CARBON;10KOHM,5%,1/8W,AA,TP, R-CARBON;10KOHM,5%,1/8W,AA,TP, R-CARBON;10KOHM,5%,1/8W,AA,TP, R-CARBON;150OHM,5%,1/8W,AA,TP, R-CARBON;180OHM,5%,1/8W,AA,TP, R-CARBON;180OHM,5%,1/8W,AA,TP, R-CARBON;180OHM,5%,1/8W,AA,TP, R-CARBON;180OHM,5%,1/8W,AA,TP, R-CARBON;180OHM,5%,1/8W,AA,TP, R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm
7-2
Samsung Electronics
Electrical Parts List
Loc. No.
Code No.
Description ; Specification
Remark
Loc. No.
Code No.
Description ; Specification
Remark
!
!
!
4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4
R603 R607 R608 R910 R912 R924 R929 R930 R943 RR08S R207 R833 R236 R237 R238 R249 R254 R259 R932 R946 R215 R915 R504 R505 R506 R824 R213 R901 R903 R904 R905 R906 R908 R921 R926 R937 R947 R948 R952 R953 RR02S R614 R615 R616 R617 R812 R831 R919 R920 R931 R933 RR09S R816 R105 R263 R210 R927 R106 R917 R621 R622 R501 R502 R503 R102 R923 R709 R913 R248 R253 R258 R701 R702 R703 R704 R705 R711
2001-000429 2001-000429 2001-000429 2001-000429 2001-000429 2001-000429 2001-000429 2001-000429 2001-000429 2001-000429 2001-000449 2001-000472 2001-000515 2001-000515 2001-000515 2001-000515 2001-000515 2001-000515 2001-000515 2001-000515 2001-000522 2001-000577 2001-000613 2001-000613 2001-000613 2001-000660 2001-000734 2001-000734 2001-000734 2001-000734 2001-000734 2001-000734 2001-000734 2001-000734 2001-000734 2001-000734 2001-000734 2001-000734 2001-000734 2001-000734 2001-000766 2001-000780 2001-000780 2001-000780 2001-000780 2001-000780 2001-000780 2001-000780 2001-000780 2001-000780 2001-000780 2001-000780 2001-000780 2001-000786 2001-000786 2001-000812 2001-000837 2001-000864 2001-000878 2001-000890 2001-000890 2001-000904 2001-000904 2001-000904 2001-000924 2001-000924 2001-000938 2001-000947 2001-000969 2001-000969 2001-000969 2001-000969 2001-000969 2001-000969 2001-000969 2001-000969 2001-000969
R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;2.2KOHM,5%,1/8W,AA,TP R-CARBON;2.7KOHM,5%,1/8W,AA,TP R-CARBON;220OHM,5%,1/8W,AA,TP, R-CARBON;220OHM,5%,1/8W,AA,TP, R-CARBON;220OHM,5%,1/8W,AA,TP, R-CARBON;220OHM,5%,1/8W,AA,TP, R-CARBON;220OHM,5%,1/8W,AA,TP, R-CARBON;220OHM,5%,1/8W,AA,TP, R-CARBON;220OHM,5%,1/8W,AA,TP, R-CARBON;220OHM,5%,1/8W,AA,TP, R-CARBON;22KOHM,5%,1/8W,AA,TP, R-CARBON;2KOHM,5%,1/8W,AA,TP,1 R-CARBON;3.9KOHM,5%,1/8W,AA,TP R-CARBON;3.9KOHM,5%,1/8W,AA,TP R-CARBON;3.9KOHM,5%,1/8W,AA,TP R-CARBON;33KOHM,5%,1/8W,AA,TP, R-CARBON;4.7KOHM,5%,1/8W,AA,TP R-CARBON;4.7KOHM,5%,1/8W,AA,TP R-CARBON;4.7KOHM,5%,1/8W,AA,TP R-CARBON;4.7KOHM,5%,1/8W,AA,TP R-CARBON;4.7KOHM,5%,1/8W,AA,TP R-CARBON;4.7KOHM,5%,1/8W,AA,TP R-CARBON;4.7KOHM,5%,1/8W,AA,TP R-CARBON;4.7KOHM,5%,1/8W,AA,TP R-CARBON;4.7KOHM,5%,1/8W,AA,TP R-CARBON;4.7KOHM,5%,1/8W,AA,TP R-CARBON;4.7KOHM,5%,1/8W,AA,TP R-CARBON;4.7KOHM,5%,1/8W,AA,TP R-CARBON;4.7KOHM,5%,1/8W,AA,TP R-CARBON;4.7KOHM,5%,1/8W,AA,TP R-CARBON;43KOHM,5%,1/8W,AA,TP, R-CARBON;470ohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;470ohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;470ohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;470ohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;470ohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;470ohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;470ohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;470ohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;470ohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;470ohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;470ohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;470ohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;47KOHM,5%,1/8W,AA,TP, R-CARBON;47KOHM,5%,1/8W,AA,TP, R-CARBON;5.6Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;51KOHM,5%,1/8W,AA,TP, R-CARBON;56Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;6.2KOHM,5%,1/8W,AA,TP R-CARBON;6.8KOHM,5%,1/8W,AA,TP R-CARBON;6.8KOHM,5%,1/8W,AA,TP R-CARBON;620OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;620OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;620OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;680ohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;680ohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON ;68ohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;7.5KOHM,5%,1/8W,AA,TP R-CARBON;75OHM,5%,1/8W,AA,TP,1 R-CARBON;75OHM,5%,1/8W,AA,TP,1 R-CARBON;75OHM,5%,1/8W,AA,TP,1 R-CARBON;75OHM,5%,1/8W,AA,TP,1 R-CARBON;75OHM,5%,1/8W,AA,TP,1 R-CARBON;75OHM,5%,1/8W,AA,TP,1 R-CARBON;75OHM,5%,1/8W,AA,TP,1 R-CARBON;75OHM,5%,1/8W,AA,TP,1 R-CARBON;75OHM,5%,1/8W,AA,TP,1
!
! !
!
! !
!
4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4
R712 R719 R720 R721 R722 RR06S L905 R925 R308 R524 R826 R811 R818 R239 R805 R806 R813 R832 R939 R414 R228 R810 R409 R410 R507 R510 R513 R809 R512 R515 R518 R521 RP801S RY802S R426 R434 R807 R808 R802 R803 R804 R829 R403 R436 R305 R306 R401 R402 R835 R836 R212 R313 R821 R301 R429 R432 RR05S R819 R302 R314 R315 RR04S R522 RR01S R304 R828 R827 R405 R424 R425 R433 R523 C424 C656 C657 C804 C805
2001-000969 2001-000969 2001-000969 2001-000969 2001-000969 2001-000977 2001-000995 2001-001035 2001-001062 2001-001062 2001-001072 2001-001078 2001-001113 2001-001114 2001-001150 2001-001150 2001-001153 2001-001153 2001-001153 2001-001165 2001-001170 2001-001178 2001-001187 2001-001192 2001-001194 2001-001194 2001-001194 2001-001410 2002-001008 2002-001008 2002-001008 2002-001009 2002-001010 2002-001013 2003-000540 2003-000664 2003-000746 2003-000746 2003-001025 2003-001025 2003-001025 2003-001036 2003-002037 2003-002151 2003-002182 2003-002182 2003-002186 2003-002186 2003-002211 2003-002211 2004-000218 2004-001137 2004-001377 2004-001397 2004-001397 2004-001397 2004-001406 2004-001983 2004-001984 2004-001986 2004-004970 2004-004970 2008-000206 2008-000264 2008-000266 2008-000266 2008-000284 2008-001018 2008-001018 2008-001018 2008-001127 2008-001129 2201-000132 2201-000304 2201-000304 2201-000332 2201-000332
R-CARBON;75OHM,5%,1/8W,AA,TP,1 R-CARBON;75OHM,5%,1/8W,AA,TP,1 R-CARBON;75OHM,5%,1/8W,AA,TP,1 R-CARBON;75OHM,5%,1/8W,AA,TP,1 R-CARBON;75OHM,5%,1/8W,AA,TP,1 R-CARBON;8.2Kohm,5%,1/8W,AA,TP,1.8x3.2m R-CARBON;820OHM,5%,1/8W,AA,TP, R-CARBON ;91ohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON(S);10MOHM,5%,1/2W,AA, R-CARBON(S);10MOHM,5%,1/2W,AA, R-CARBON(S);12ohm,5%,1/2W,AA,TP,2.4x6.4m R-CARBON(S);15KOHM,5%,1/2W,AA, R-CARBON(S);270KOHM,5%,1/2W,AA R-CARBON(S);270OHM,5%,1/2W,AA, R-CARBON(S);470KOHM,5%,1/2W,AA R-CARBON(S);470KOHM,5%,1/2W,AA R-CARBON(S);47OHM,5%,1/2W,AA,T R-CARBON(S);47OHM,5%,1/2W,AA,T R-CARBON(S);47OHM,5%,1/2W,AA,T R-CARBON(S);56OHM,5%,1/2W,AB,T R-CARBON(S);6.8OHM,5%,1/2W,AB, R-CARBON(S);680OHM,5%,1/2W,AA, R-CARBON(S);75OHM,5%,1/2W,AA,T R-CARBON(S);820OHM,5%,1/2W,AB, R-CARBON(S);82KOHM,5%,1/2W,AA, R-CARBON(S);82KOHM,5%,1/2W,AA, R-CARBON(S);82KOHM,5%,1/2W,AA, R-CARBON;RD1/2T(S)430-J43R R-COMPOSITION;1.8KOHM,10%1/2W,AA,TP,3.7 R-COMPOSITION;1.8KOHM,10%1/2W,AA,TP,3.7 R-COMPOSITION;1.8KOHM,10%1/2W,AA,TP,3.7 R-COMPOSITION;2.7KOHM,10%,1/2W,AA,TP,3.7 R-COMPOSITION;1.8MOHM,5%,1/2W,AA,TP,3.7X R-COMPOSITION;4.7MOhm,5%,1/2W,AA,TP,3.7X R-METALOXIDE(S);1KOHM,5%,2W,AD R-METAL OXIDE(S);330HM,5%,2W,AF,TP,4X12M R-METALOXIDE(S);56OHM,5%,2W,AD R-METALOXIDE(S);56OHM,5%,2W,AD R-METALOXIDE(S);15KOHM,5%,2W,A R-METALOXIDE(S);15KOHM,5%,2W,A R-METALOXIDE(S);15KOHM,5%,2W,A R-METALOXIDE(S);3.3OHM,5%,2W,A R-METAL OXIDE(S);270OHM,5%,2W,AF,TP,3.9X R-METALOXIDE;18KOHM,5%,2W,AG,TP,6X16 R-METALOXIDE(S)470ohm,5%,2W,AG,TP,3x R-METALOXIDE(S)470ohm,5%,2W,AG,TP,3x R-METALOXIDE(S);22Kohm,5%,2W,AG,TP,3x R-METALOXIDE(S);22Kohm,5%,2W,AG,TP,3x R-METALOXIDE(S)91Kohm,5%,2W,AG,TP,3x R-METALOXIDE(S)91Kohm,5%,2W,AG,TP,3x R-METAL;10KOHM,1%,1/8,1.8X3.2M R-METAL;6.8KOHM,1%,1/8W,AA,TP,1.8*3.2M R-METAL(S);120KOHM,1%,1/2W,AA,TP,2.4X6.4 R-METAL(S);4.7KOHM,1%,1/2W,AA, R-METAL(S);4.7KOHM,1%,1/2W,AA, R-METAL(S);4.7KOHM,1%,1/2W,AA, R-METAL(S);8.2KOHM,1%,1/2W,AA, R-METAL;2.49KOHM,1%,1/2W,AA,TP,2.4X6.4 R-METAL;26.7KOHM,1%,1/2W,AA,TP R-METAL;35.7KOHM,1%,1/2W,AA,TP R-METAL(S);62Kohm,1%,1/8W,AA,TP,1.8x3.2m R-METAL(S);62Kohm,1%,1/8W,AA,TP,1.8x3.2m R-FUSIBLE(S);1OHM,5%,1/2W,AF,T R-FUSIBLE(S);1OHM,5%,1W,AF,TP, R-FUSIBLE(S);1OHM,5%,2W,AF,TP, R-FUSIBLE(S);1OHM,5%,2W,AF,TP, R-FUSIBLE(S);0.1OHM,10%,2W,AF,TP,3.9X10M R-FUSIBLE(S);0.47OHM,10%,2W,AF R-FUSIBLE(S);0.47OHM,10%,2W,AF R-FUSIBLE(S);0.47OHM,10%,2W,AF R-FUSIBLE(S);6.8Kohm,5%,1W,AF,TP,3.9x10m R-FUSIBLE(S),1.5OHM,5%1/2W,AF,TP,2.5 C-CERAMIC,DISC;100PF,10%,500V,Y5P,6X3MM, C-CERAMIC,DISC0.001nF,0.25pF,50V,NP0,TP C-CERAMIC,DISC0.001nF,0.25pF,50V,NP0,TP C-CERAMIC,AC;CK45PTAPGE250V222 C-CERAMIC,AC;CK45PTAPGE250V222
Samsung Electronics
7-3
Electrical Parts List
Loc. No.
Code No.
Description ; Specification
Remark
Loc. No.
Code No.
Description ; Specification
Remark
!
!
4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4
C401 C403 C421 CR01S C650 C817 C819 C822 C843 C509 C910 C911 C814 C224 C225 C303 C115 C116 C243 C244 C245 C632 C702 J218 C647 C654 C211 C504 C505 C506 C607 C608 C905 C908 C206 C218 C219 C220 C221 C222 C223 C226 C232 C901 C921 C960 C412 C821 C811 C213 C242 C610 C611 C306 C228 C803 C809 C103 C105 C420 C807 C305 C304 C408 C233 C234 C235 C236 CR04S C205 C214 C216 C308 C513 C605