Text preview for : sony_ZS-D5_service_manual.pdf part of Sony ZS-D5 ZS-D5 PERSONAL MiniDisc and CD Player AUDIO SYSTEM
Service Manual
Back to : sony_ZS-D5_service_manual | Home
ZS-D5
SERVICE MANUAL
Ver 1.3 2000.2
With SUPPLEMENT (9-923-270-82)
US Model Canadian Model AEP Model UK Model E Model
CD Section Tape deck Section
Model Name Using Similar Mechanism New Optical Pick-up Name KSM-213CDM/M-S
Model Name Using Similar Mechanism PMC-303 Tape Transport Mechanism Type MF-D55-144
SPECIFICATIONS
AUDIO POWER SPECIFICATIONS POWER OUTPUT AND TOTAL HARMONIC DISTORTION With 3-ohm load, both channel driven from 150 - 15,000 Hz; rated 3 W per channelminimum RAM power, with no more than 10 % total harmonic distortion in AC operation. Other Specifications CD player section System Compact disc digital audio system Laser diode properties Material: GaALAs Wave length : 780 nm Emission duration: Continuous Laser output: Less than 44.6 µW (This output is the value measured at a distance of about 200 mm from the objective lens surface on the optical pick-up block with 7 mm aperture.) Spindle speed 200 r/min (rpm) to 500 r/min (rpm) (CLV) Number of channels 2 Frequency response 20 - 20,000 Hz +0/-1dB Wow and flutter Below measurable limit
Cassette-corder section Recording system 4-track 2 channel stereo Fast winding time Approx. 120s (sec.) with Sony cassette C-60 Frequency response TYPE1 (normal): 50 - 15,000 Hz
Full range: 8 cm (3 1/4in.) dia., 3 , cone type x 2 Input LINE IN jack (stereo minijack) Minimum input level 250 mV Outputs Headphones jack (stereo minijack) For 16 - 68 impedance headphones LINE OUT jack (stereo minijack) Rated output level 250 mV at load impedance 47 k OPTICAL DIGITAL OUT (CD) (optical output connector) Wavelength: 630 - 690 nm Power output (excluding U.S. model) 4.5 W + 4.5 W (3 ohms at 10 % harmonic distortion in DC operation) Power requirements For personal component system: 120 V AC, 60 Hz 12 V DC, 8 size D (R20) batteries For memory back-up: 6 V DC, 4 size AA (R6) batteries For remote commander: 3 V DC, 2 size AA (R6) batteries Power consumption AC 25 W -- Continued on next page -- General Speaker
Radio section Frequency range US, Canadian
AEP, UK, E
Aerials
FM: 87.6 - 108 MHz AM: 530 - 1,710 kHz FM: 87.5 - 108 MHz (Italy) FM: 87.6 - 107 MHz (Other countries) MW: 531 - 1,602 kHz LW: 153 - 279 kHz FM: Telescopic aerial AM: Built-in ferrite bar aerial
PERSONAL AUDIO SYSTEM
MICROFILM
TABLE OF CONTENTS 1. SERVICE NOTE ............................................................... 3 2. GENERAL .......................................................................... 4 3. DISASSEMBLY
3-1. 3-2. 3-3. 3-4. 3-5. 3-6. Front Cabinet Assy ........................................................... 12 Mechanisum Assy ............................................................. 13 Control Board, Lump Board, H/P Board .......................... 14 CD Block Assyt, Handole ................................................ 14 Main Board, Optical Pick up ............................................ 15 Tuner Board, Power Board, Rear Cabinet ........................ 15
SAFETY CHECK-OUT
After correcting the original service problem, perform the following safety checks before releasing the set to the customer: Check the antenna terminals, metal trim, "metallized" knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below.
LEAKAGE
The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microamperes). Leakage current can be measured by any one of three methods. 1. A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers' instructions to use these instruments. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The "limit" indication is 0.75 V, so analog meters must have an accurate low-voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2V AC range are suitable. (See Fig. A)
4. TEST MODE ..................................................................... 16 5. MECHANICAL ADJUSTMENTS ............................. 16 6. ELECTRICAL ADJUSTMENTS ............................... 17 7. DIAGRAMS
7-1. 7-2. 7-3. 7-4. 7-5. 7-6. 7-7. 7-8. 7-9. 7-10. 7-11. 7-12. 7-13. 7-14. 7-15. 7-16. 7-17. 7-18. 8-1. 8-2. 8-3. 8-4. 8-5. 8-6. Circuit Boards Location ................................................... 20 Brock Diagrams Tuner/CD Section ........................... 21 Brock Diagrams TC Section ...................................... 23 Printed Wiring Board --Main Section -- ........................ 26 Schematic Diagram --Main Section (1/2) -- .................. 29 Schematic Diagram --Mainl Section (2/2) -- ................. 32 Printed Wiring Board --Power Section -- ...................... 35 Schematic Diagram --Power Section -- ......................... 37 Printed Wiring Board --Control/Switch Section -- ........ 39 Schematic Diagram --Control/Switch Section -- ........... 43 Printed Wiring Board --Tuner Section (US, CND model) -- ............................ 45 Schematic Diagram --Tuner Section (US, CND model) -- ............................ 47 Schematic Diagram --Tuner Section (AEP, IT, UK, E model) -- ................... 50 Printed Wiring Board --Tuner Section (AEP, IT, UK, E model) -- ................... 53 Schematic Diagram --TC Section -- .............................. 55 Printed Wiring Board --TC Section -- ........................... 57 IC Pin Function ................................................................ 58 IC Brock Diagrams ........................................................... 60 Cabinet Section ................................................................. 64 Rear Cabinet Section ........................................................ 65 CD Mechanism (KSM-213CDM/M-S) ............................ 66 Optical Pick up ................................................................. 67 Cassette Mechanism Deck Section-1 (MF-D55-144) ...... 68 Cassette Mechanism Deck Section-2 (MF-D55-144) ...... 69
2.
3.
To Exposed Metal Parts on Set
8. EXPLODED VIEWS
0.15 µF
1.5 k
AC Voltmeter (0.75 V)
Earth Ground Fig. A. Using an AC voltmeter to check AC leakage.
9. ELECTRICAL PARTS LIST ........................................ 70
Battery life For CD radio cassette-corder FM recording Sony R20P: approx. 6 h Sony alkaline LR20: approx. 12h Tape playback Sony R20P: approx. 3h Sony alkaline LR20: approx. 6h CD playback Sony R20P: approx. 1.5 h Sony alkaline LR20: approx. 3h Dimmensions (incl. projecting parts) Approx. 416 x 198.5 x 246 mm (w/h/d) (16 1/2 x 7 7/8 x 9 3/4 inches) Mass (incl. batteries) Approx. 5.2 kg (11 lb. 7 oz) Supplied accessories AC power cord (1) Remote commander (1) Design and specifications are subject to change without notice. SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉCURITÉ! LES COMPOSANTS IDENTIFÉS PAR UNE MARQUE ! SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈSES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPÉMENTS PUBLIÉS PAR SONY.
--2--
SECTION 1 SERVICING NOTE
The laser component in this product is capable of emitting radiation exceeding the limit for Class 1.
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic breakdown because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic breakdown and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care.
This appliance is classified as a CLASS 1 LASER product. The CLASS 1 LASER PRODUCT MARKING is located on the rear exterior. The following caution label is located inside the unit.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
CHUCK PLATE JIG ON REPAIRING
On repairing CD section, playing a disc without the CD lid, use Chuck Plate Jig. · Code number of Chuck Plate Jig : X-4918-255-1
CAUTION Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure.
LASER DIODE AND FOCUS SEARCH OPERATION CHECK
1. 2. 3. 4. Press CD open knob. Open the lid for CD. Push on SWITCH as following figure. Confirm the laser diode emission while observing the objecting lens. When there is no emission, Auto Power Control circuit or Optical Pick-up is broken. Objective lens moves up and down once for the focus search.
Insert a precision screw driver and push SWITCH
--3--
SECTION 2 GENERAL
LOCATION OF PARTS AND CONTROLS
12345678
This section is extracted from instruction manual.
@TM
@¡ @º !· !§ !ª !¶ ! !¡
9 !º !TM
!¢
!£
1 2 3 4 5 6 7 8 9 0 !¡
MEGA BASS button SOUND button STANDBY button SLEEP button CLOCK button PROGRAM AUTO PRESET CHECK button MODE MONO/ST ISS button CANSEL button VOL button EDIT button DISPLAY ENTER button
!TM !£ !¢ ! !§ !¶ !· !ª @º @¡ @TM
TUNE/TIME SET button MD (LINE) button OPTICAL DIGITAL OUT (CD) r/P button COUNTER RESET button DIR MODE button TIMER button Remote sensor OPR/BATT lamp POWER button 2
@£
@
@¢ @§ @¶
@£ PUSH OPEN/CLOSE (CD) @¢ CD button @ RADIO buttons
@§ TAPE buttons @¶ PUSH OPEN/CLOSE (CASSETTE)
--4--
--5--
--6--
--7--
--8--
--9--
-- 10 --
-- 11 --
SECTION 3 DISASSEMBLY
ZS-D5 FRONT CABINET ASSY MECHANISM DECK ASSY MAIN BOARD, OPTICAL PICK UP CONTROL BOARD, LAMP BOARD, H/P BOARD
CD BLOCK ASSY, HANDLE
TUNER BOARD, POWER BOARD, REAR CABINET
Note : Follow the disassembly procedure in the numerical order given.
3-1.
FRONT CABINET ASSY
6 Front cabinet assy 3 Connector(CN306)
4 Connector (CN801)
2 Screws (+BVTP 3 ×12)
2 Screws (+BVTP 3 ×12)
5 Rear cabinet assy 1 Battery lid 2 Screws (+BVTP 3 ×12)
-- 12 --
3-2.
MECHANISM ASSY
Rear cabinet assy
!£ MD chassis !º TC board
9 Screws (+BVTP 3 ×10)
2 Connector (CN301)
8 Connector (CN402) !TM MF-D55-144 9 Screws (+BVTP 3 ×10) !¡ Screws (+BVTP 3 ×10) 5 Connector (CN401)
4 Connector (CN442)
3 Connector (CN441) 1 Screw (+BVTP 3 ×10) 7 Terminal board
6 Screws (+BVTP 2.6 ×10)
-- 13 --
3-3.
CONTROL BOARD, LAMP BOARD, H/P BOARD
Rear cabinet assy
0 H/P board 8 Connector (CN305)
9 Screw (+BVTP 3 ×10)
7 LANB board
5 Screws (+BVTP 2.6 ×10) 6 Connector (CN804) 2 Connector (CN802) 4 CONTROL board
3 Screws (+BVTP 2.6 × 10)
1 Connector (CN803)
3-4.
CD BLOCK ASSY, HANDLE
1 Screws (+BVTP 3 ×10)
2 CD block assy 4 Handle
3 Screws (+BVTP 3 ×10)
-- 14 --
3-5.
MAIN BOARD, OPTICAL PICK UP
4 Screws (+BVTP 3 ×10) 4 Screws (+BVTP 3 ×10)
5 MAIN board
1 Connector (CN701)
2 Connector (CNP703)
CD chassis
Optical pick up KSM-213CDM 3 Connector (POSH SWITCH)
3-6. TUNER BOARD, POWER BOARD, REAR CABINET
7 Connector (CN904) 0 Rear cabinet
3 Screws (+BVTP 3 ×10)
5 TU cassis
4 TUNER board 2 Connector (CN1)
8 Screws (+BVTP 3 ×10) 6 Connector (CN901) 9 POWER board
1 Screws (+BVTP 3 ×10)
8 Screws (+BVTP 3 ×10)
-- 15 --
SECTION 4 TEST MODE
1. HOW TO ENTER THE TEST MODE 1. Turn on the main power. While the machine is in the CD STOP state, short-circuit JW824 and JW825 on the SWITCH board once. (Turn off the main power to exit the test mode.) [SWITCH Board] Soldering Side 2. 3. 4.
SECTION 5 MECHANICAL ADJUSTMENT
PRECAUTION
Clean the following parts with a denatured-alchool-moistened swab: record/playback head pinch roller erase head rubber belts capstans Do not use a magnetized screwdriver for the adjustments. After the adjustments, apply suitable locking compound to the parts adjusted. The adjustments should be performed with the raged power supply voltage unless otherwise noted.
Torque Measurement Mode FWD FWD back tension REV REW back tension FF · REW · Procedure (1) Press the CD key Press the DISPLAY ENTER MEMORY key. (2) Confirm that display on LCD changes as follows. F
CHECK
Torque Meter
Meter Reading 36 to 61 g·cm (0.504 to 0.854 oz·inch) 2 to 6 g·cm (0.028 to 0.084 oz·inch) 36 to 61 g·cm (0.504 to 0.854 oz·inch) 2 to 6 g·cm (0.028 to 0.084 oz·inch) 61 to 143 g·cm (0.854 to 2.002 oz·inch)
CQ-102C
JW825 JW824
2. RF Level and Jitter Check · Measurement Point MAIN board (see page 9) Vref (JW126) and RF Signal (JW135) (Confirm by oscilloscope)
CQ-102RC
CQ-201B
Tape Tension Measurement Mode Torque Meter CQ-403A CQ-403R Meter Reading more than 100 g·cm (more than 1.38 oz · inch) more than 100 g·cm (more than 1.38 oz · inch)
F
CHECK
ALL
88 88
FWD REV
(Indication that automatic adjustment is completed) (3) Press the EDIT key. (APC OFF)
88 88 The display ALL disappears.
(4) Confirm that jitter is 9.0 ns or less. Confirm also that the RF level is from 0.9 to 1.3 Vp-p.
0.9 to 1.3 Vp-p
0V
3. Traverse Signal Check · Measurement Point: MAIN board (see page 9) Vref (JW126) and TE Signal (IC701 pin $¶) (Confirm by oscilloscope) · Procedure (1) Press the = or + key. (2) Check that the traverse level is from 0.3 to 0.5 Vp-p.
A=B A+B= 0.3 to 0.5 Vp-p
-- 16 --
SECTION 6 ELECTRICAL ADJUSTMENT
PRECAUTION 1. Perform adjustments in the test mode. 2. Demagnetize the record/playback head with a head demagnetizer. 3. Do not use a magnetized screwdriver for the adjustments. 4. After the adjustments, apply suitable locking compound to the parts adjust. 5. The adjustments should be performed with the rated power supply voltage unless otherwise noted. 6. The adjustments should be performed in the order given in this service manual. (As a general rule, playback circuit adjustment should be completed before performing recording circuit adjustment.) 7. The adjustments should be performed for both L-CH and RCH. · Standard Record: Deliver the standard input signal level to the input jack and set the VOLUME +/ keys to obtain the standard input and output signal level. · Standard input level Input Pin Signal source impedance Input signal level · Standard output level SP OUT (L, R) 3.2 0.775 V (0 dB) H.P OUT 32 0.10 V (-18 dB) LINE IN 10 k 0.25 V (9.8 dB)
set 22.5 kHz frequency deviation by 400 Hz signal
ZS-D5
2. Turn the adjustment screw and check output peaks. If the peaks do not match for L-CH and R-CH, turn the adjustment screw so that outputs match within 1dB of peak.
Tape Speed Adjustment Procedure: Mode : FWD playback
test tape WS-48B (3 kHz, 0 dB)
TUNER SECTION
[Setting during adjustment] Function mode: RADIO VOLUME: Maximum
frequency counter 100 k
0 dB = 1µV
AEP/Italian/UK/E model LW TRACKING ADJUSTMENT Adjust for a maximum defection of level meter. L3 CT5 162 kHz 261kHz
Adjustment Location: TUNER board (Side A) [US/CND Model]
L2: FM Reception Frequency coverage AM Tracking L3 CT2
L-CH peak output level
within 1dB within 1dB set
· AM Section
AM RF SSG
+
Put the lead-wire antenna close to the set.
Screw position
R-CH peak L-CH peak R-CH peak
LINE OUT Screw position
FM RECEPTION FREQUENCY COVERAGE CHECK Frequency indication 87.5 MHz 108 MHz Digital voltmeter reading 0.9 to 1.3 V 3.4 to 4.4 V Adjustment L2 check
FM Tracking L1 CT1
1. 2. 3.
3. Phase Check Mode: REV playback
test tape P-4-A100 (100 kHz, 10 dB) R-CH oscilloscope 47 k
V H
Playback the standard tape in FWD mode. Adjust the variable resistor of the motor (M691) until frequency counter reading is from 2,985 to 3,015 Hz. Confirm that the freqency difference between the tape top and end is within 3 %.
30% amplitude modulation by 400 Hz signal Output level: as low as possible
· FM section
FM RF SSG
FM TRACKING ADJUSTMENT Adjust for a maximum defection of level meter. L1 CT1 87.5 MHz 108 MHz
Measurement Point: MAIN board (Side B)
to FM RF (FM IN)
L4: AM Reception Frequency coverage
L-CH
47 k LINE
[AEP/IT/UK/E model]
Output level: as low as possible VTVM 32 LW Tracking CT5
+
Output Pin Load impedance Output signal level · Test tape Test Tape P-4-A100 WS-48A
Oscilloscope Lissajous pattern
MW Tracking CT4 L3 (MW)
L3 (LW)
in phase
45°
90°
135°
180°
set HEADPHONES
Used for REC/PB/ERASE Head azimuth 10 kHz, -10 dB and phase adjustment. 3 kHz, 0 dB Tape speed adjustment
Signal
good
wrong
Note: Adjustment must be completed by cw turning of adjustment screw. After the adjustment, lock the screws with locking compound. 4. Repeat steps 1 to 3 FWD playback mode. 5. Check that phase difference between L-CH and R-CH is from o to 90 degrees. 6. After the adjustments, apply suitable locking compound to the pats adjusted. Adjustment Location:
· · (
Repeat the proceduresin each adjustment several times for the maximum level meter indication. The frequency coverage and tracking adjustments should be finally done by the trimmer capacitors. ) : US/Canadian model
JW135
IC701
CT3: LW Reception Frequency Coverage CT1 FM Tracking L1 JW126
TAPE RECODER SECTION
0 dB = 0.775V
Record/Playback Head Azimuth Adjustment Note: · Start adjustment after head has changed the direction. (When head is positioned in the FWD direction of tape running, start adjustment with REV .) · The adjustment must be ended with cw turning of adjustment screw. Procedure: 1. Mode : REV playback
test tape P-4-A100 (10KHz, 10dB) level meter set 47 k +
MW/AM RECEPTION FREQUENCY COVERAGE CHECK 531 kHz 1,611 kHz Frequency indication (530 kHz) (1,710 kHZ) Digital voltmeter reading Adjustment AEP/Italian/UK/E model LW RECEPTION FREQUENCY COVERAGE CHECK Frequency indication 151 kHz 273 kHz Digital voltmeter reading 0.6 to 0.7 V 4.7 to 5.7 V Adjustment CT3 check ( ) : US/Canadian model 0.6 to 1.2 V (0.9 to 1.0 V) L4 4.5 to 5.5 V (5.2 to 6.2 V) check
L2: FM Reception Frequency Coverage
CT2
L4
MW Reception Frequency Coverage
Adjustment screw (FWD)
Adjustment screw (REV)
LINE OUT
MW/AM TRACKING ADJUSTMENT Adjust for a maximum defection of level meter. L3 CT2 621 kHz (620 kHz) 1,404 kHz (1,400 kHz)
-- 17 --
-- 18 --
-- 19 --
ZS-D5
SECTION 7 DIAGRAMS
7-2.
BLOCK DIAGRAM
-- TUNER/CD SECTION --
7-1.
CIRCUIT BOARD LOCATION
AU7.5V
ANT1 FM TELESCOPIC ANTENNA
FM/AM FRONT-END IC1 9
CF3
CF4 13 22 5
QUAD
VCO
VCC1 VCC2
CD MOTOR board
FL1 B.P.F 1 L1 AU7.5V D1 23
FM RF I
Q23(AEP,IT,UK,E) Q18(US,CND) FM MIX MIX OUT 3 CF1 RF IF AMP CF2 6
FM IF
FM DET FM/AM BUFFER MPX 17 16 FM MPX MUTE 11 12
L-CH R-CH
MAIN board
FM RF O
A
TO TC SECTION
CFT1 7
AM IF
AM DET ST IND IF BUFFER 10 Q15 MUTE
MO/ST
CONTROL board
D2 L2 AEP,IT,UK,E Model L3 FERRITE-ROD ANTENNA Q1 BUFFER Q13 PD1 D5 Q2 IC 1 AU7.5V 24
21
FM OSC
FM OSC
BAND
PD1
L3 FERRITE-ROD ANTENNA
OSC 24
AM RF
19
17 FM 16 AM
PLL 14 IC2(AEP,IT,UK,E) Q12(AEP,IT, IC3(US,CND) UK,E) Q3(US,CND) P1 9
Q16 MUTE
15
18 AU7.5V MUTE SWITCH Q18
AM RF
AM MIX TU5V
D3 Q10(AEP,IT, UK,E) Q2(US,CND)
Q9(AEP,IT,UK,E) Q1(US,CND) TU7.5V H FREQ CUT AEP,IT,UK,E
18 VDD 22
AM OSC
P0
8
LAMP board
Q6 AU7.5V
Q5
Q4 22 MW-H Q22 Q3 LW-H Q21
AM OSC AU7.5V US,CND Model
AM OSC
1 XO 2 XI
IF 14 Q11(AEP,IT,UK,E) Q4(US,CND) CD 7 DA 6 CD DA CK CE Q17(AEP,IT,UK,E) Q15(US,CND) TU5V
Q13(AEP,IT,UK,E) Q17(US,CND) PLL L.P.F Q19(US,CND) Q14(AEP,IT,UK,E)
X1 75kHz 21 PD1 Q22 INV. INV. Q21
CK
5
SW board TC board TERMINAL board
CE 4 MW-H +B LW-H 10 MW-L 11 LW-L
AEP,IT,UK,E Model
OPTICAL PICK-UP BLOCK (KSM-213CDM/M-S)
VCC VC A A 38
PD1 CD5V
CD5V CD RF/SERVO PROSSESOR IC701 CD5V CD DIGITAL SIGNAL PROCESSOR IC702 D OUT 71
IC441 2 VDD 1 D IN 3 GND OPTICAL DIGITAL OUT
18 VCC 51 VC
PCMD D/A I/F RF AMP RFO
RF
52 54 50 72
53 55 51 73 SERIAL I/F
BCK LRCK EMPH
PWM
AL
84
L-CH
B
TO TC SECTION
H/P board
POWER board
BATTERY(L)board
C C B B D D E E 42 E 39
PD2
PWM
AR
95
R-CH
33
44
EFM DEMO.
FOK C OUT SENS 1 SENS 2 DATA TTL IIL XLT CLK XRST LOCK
27 24 25 26 22 21 20 23 19
23 14 13
FOK
IIL FE AMP TTL SERIAL/ PARALLEL CONVERTER DECODER
CN SE
BATTERY(S)board
CLV SERVO
SUB CODE PROSSESOR
XTAI 89 X701 XTAO 90
15 16 17 29 27
DAT XLT CLK
F F Q701 LD LD/POWER CONTROL 41 36 F LD
CPU I/F
100 XRST
LOCK MDP
DIGITAL CLV
GND
CLOCK
SQSO
18 FOCUS PHASE COMPENSATION TRACKING PHASE COMPENSATION
PD VR F/T COIL SL/SP MOTOR DRIVER IC703 F+ FOCUS COIL F T+ TRACKING COIL 16 T 10 F+
37
PD
10 11 12 7
SQCK
DATA
8
9 75
FEO
TEO
SLO
6
13
16
F IN 11 9 F 21 R ST 7 6 T+ T IN 4 T
CD DA CK CE
6
5
8 11
12 9
1
C SENSE1
C DATA
C SQSO
C SCOR
C SQCK
B MUTE
C XLAT
C CLK
SYSM
XLAT
SPOA
SCOR
SENS
APC
COMAND
22
XLON
80
7 · SIGNAL PATH :FM :CD :DIGITAL OUT
25 R CONT 23 R DATA 22 R CLK 24 R CE
SWITCH board TUNER board
M702 SLED MOTOR 28 SL+
M
27 SL 22 SP+
SL IN 29 13 C SENSE2 4 C XRST
IC801(1/2) SYSTEM CONTROL
· R-CH:Same as L-CH · Abbreviation CND : Canadian : Italian
M701 SPINDOL MOTOR
M
21 SP
SP IN 25 MUTE 15
IT
S701 LIMIT
-- 20 --
-- 21 --
-- 22 --
ZS-D5
7-3. BLOCK DIAGRAM -- TC SECTION --
LINE AMP IC305 5 J441 LINE IN
R-CH
7
R-CH
J442 LINE OUT · SIGNAL PATH :FM
Q107 Q105 Q103 PB/REC FUNCTION IC401 4 22 24
RADIO
MUTE Q326,327 SOUND/VOLUME IC302 5 6 7 8 MUTE CONTROL Q106 MUTE D441 S441 LINE
Q320,329 MUTE CONTROL FROM TUNER/CD SECTION
:CD :PB (MD) :REC (MD)
A B
TU L
CD L
LINE
TONE TAPE L MATRIX SURROUND
Q104 Q321 CD/LINE CONTROL CD5V D304 D303
POWER AMP IC304
R-CH
J301 PHONES
:LINE · R-CH :Same as L-CH
20
2 12
VR
9
2 STBY 5 Q325
12
TAPE 17 LINE/TUNER
M/D HEAD
L-CH
NAB 5 REC 4
R-CH
13 CONTROL 14
LATCH DATA CLK
BC
21
BASS DET
D306 L SPEAKER R
R-CH
REC 21 Q406,408,409 Q411,413 D401
TAPE 15 D402
VC
Q313,314 STBY SWITCH AU7.5V AMS IC303 6 1 2 LOGIC 5
16
23 Q324 AUDIO MUTE
19 20 18
D811 OPR/ BATT S817,825-830 FUNCTION SWITCH S818-823 FUNCTION SWITCH S809-816 FUNCTION SWITCH S801-807 FUNCTION SWITCH CD 8.5V MO 8.5V REG Q902 R+B +B (IC304) D301
ERASE
PB/REC SWITCH T401 Q403 BIAS OSC Q405,410 BIAS SWITCH Q401 Q402 AU7.5V
Q328 AMS MUTE
4
ISS CONTROL S691 HALF S692 TYPE II (CrO2) S694 ERASE PROOF (SIDE A) S695 ERASE PROOF (SIDE B) Q362 Q363 MOTOR DRIVE PH691 END DET Q361 S696 HEAD POSITION MO 8.5V
BU +B
D803 Q101 PB EQ SWITCH RA5V D361 Q322 LED DRIVE PM691 M691 TAPE SPEED D802 D801 BU +B 3 AU 7.5V REG Q901
Q323 D809 D810
Q301
Q805 WAKE-UP CONTROL
IC309 BACK-UP 5V REG 1 2
D807 D808
M
Q318,319 Q365 PL DRIVE
3
RESET IC803 2
1 COM5V REG Q315 T901 POWER D901-904 TRANSFORMER D314 D313 RECT J901 AC IN
SXXX OPEN/CLOSE
D805 D806 CD5V
LED DRIVE
IC802 1 IR RECEIVER 3 2
Q316,317 RMC +B REG CHK
COM5V
D311 85 LINE 88 87 CD RADIO 83 REC 86 TAPE 15 PL CONT 100 TAPE END 14 T MOTOR CONT 95 A MUTE 96 97 98 VR CLK VR CE VR DATA 10 P CONT 16 19 20 28 EP(A) EP(B) HALF CD OP/CL 17 T HEAD POS 27 33 32 31 30 99 KEY2 KEY1 WP KEY4 KEY3 AMS 38 RESET 3 RMC 2 REG CHK 34 8.5V CHK
D905
D907 MAIN BATT UM1.5Vx8 12V
92 CLK OUT X802 32.768kHz 93 CLK IN
Q311,312 B/L SWITCH
B/L CONT 84
PL801,802 LCD BACK LIGHT
D906 BACK-UP BATT UM1.5Vx4 6V
37 R SHIFT X801 4.21MHz OSC Q803,804 39 OSC OUT 40 OSC IN IC801(2/2) SYSTEM CONTROL
SEG0 SEG26 COM0 COM3
54 80 50 53
LCD801 LIQUID CRYSTAL DISPLAY PANEL
16
-- 23 --
-- 24 --
-- 25 --
7-17. IC PIN FUNCTION DESCRIPTION
· IC801 CXP83124A-021Q
Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 Pin Name C-SCOR REG-CHK RMC C-XRST C-XLAT C-DATA B-MUTE C-CLK C-SENSE 1 P-CONT C-SQCK C-SQSO C-SENSE 2 T-MOTOR CONT PL-CONT HALF (M/D) T-HEAD POS NC Write protect (A) Write protect (B) R-ST R-CLK R-DATA R-CE R-CONT AMS CD-OP/CL NC KEY 1 KEY 2 KEY 3 KEY 4 +8.5V-CHK INIT Destination R-SHIFT RESET OSC-OUT OSC-IN GND NC NC V REF GND VDDL VDD3 VDD2 VDD1 COM0 I/O I I I O O O O O I O O O I O O I I I I I O O O I I O I I I I I I I O I I O I I I I I O Ground LCD drive bias control terminal Bias power source supply terminal for LCD drive Bias power source supply terminal for LCD drive Bias power source supply terminal for LCD drive LCD common output Reset 4.19 MHz input 4.19 MHz input Ground Not used (open) Not used (open) Not used (open) Key input Key input Key input Key input DC voltage check INITIAL Destination Radio destination read-in input Not used (open) Write protect (A) Write protect (B) Tuner stereo receive signal PLL IC clock output PLL IC data output PLL IC chip enable output PLL IC data input Not used (open) Tape exist/not exist check Remote control input signal CD-system reset CD DSP for command latch CD DSP command date output CD and TUNER mute output CD DSP for command CLK output CD SENSE input Regulator control CD SUB-Q read-out clock CD-SQSO data input CD SENSE input CD DSP command date output Description
-- 58 --
Pin No. 51 52 53 54 to 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100
Pin Name COM1 COM2 COM3 SEG0 to SEG26 NC NC REC B/L-CONT LINE TAPE RADIO CD VDD NC GND CLK OUT CLK IN NC A-MUTE VR-DATA VR-CLK VR-CE WP TAPE END
I/O O O O O O O O O O O I I O O O O I I LCD common output LCD common output LCD common output LCD common output Not used (open) Not used (open) Record bias power source supply B/L-CONTROL LIFE FUNCTION output TAPE FUNCTION output RADIO FUNCTION output CD FUNCTION output Power supply Not used (connected to VDD) Ground 32 kHz output 32 kHz output Not used (open) AUDIO MUTE terminal VOLUME DATA output VOLUME CKL output terminal VOLUME ENABLE output terminal µ-COM WAKE UP terminal Tape end check
Description
-- 59 --
1 2 31 Vcc
32
NC FIN
IC703 BA6898S
Vcc
3
+
30
BIAS IN BIAS
10K
7-18. BLOCK DIAGRAMS
VIN4
4
13.3K 10K D.BUF
29
VIN1
VIN4
5
28
VIN1
VO4()
27
VO1(+)
VO1()
D.BUF
+
25
24
VO2() 9
LEVEL SHIFT
VO2(+)
D.BUF
+
11
22
VIN2
LEVEL SHIFT
100
RESET
REG-B
+
REGULATOR 14 REG OUT
10K
15
18
MUTE
50K
DRIVER-MUTE
16
17
FIN
13.3K
D.BUF
-- 60 --
8 GND 10
REGULATOR BIAS T.S.D. MONITOR
+
10K
13.3K LEVEL SHIFT OP-AMP
D.BUF
IC302 BH3854AS
LEVEL SHIFT
+
6
D.BUF
VO4(+)
26
7
D.BUF
NC
OP IN()
OP OUT
23
GND
VO3()
+
12 13
50K
21
D.BUF 13.3K
VO3(+)
20
VIN3
10K
19
VIN3
GND
NC
IC3 BU2615S
IC1 TA2008AN
24 23 22 21 20 19 18 17 16 15 14 13
FM MPX AM RF AM OSC FM OSC BUFF BUFF IF BUFF AF BUFF
AM/FM ST/MONO SW
1/801V FM MIX AM MIX AM DET
FM RF
AGC
FM IF
AM IF
LEVEL DET
FM DET
ST DET
MUTE
1
2
3
4
5
6
7
8
9
10
11
12
-- 61 --
IC702 CDX2529Q
VPCO1 VPCO2 EMPHI WDCK PCMDI
LRCKI
WFCK
PCMD
EMPH
GTOP
XUGF
C2PO
MNT3
MNT1
MNT0
RFCK
LRCK
V16M
VCTL
XTSL
TES0
VCKI
GFS
68 34 33 35 36 37 58 59 61 72 74
65 66 67
31
62 63 49 50 52 54
BCK
73 51 53 55 80
FSTT 69 C4M 70 RF 44 ASYI 46 ASYO 47 ASYE 48 BIAS 45
Clock Generator
osc
Error Corrector EFM demodurator
D/A Interface
SYSM
BCKI
4
RMUT LMUT
Serial-In Interface
Timing Logic
3
Asymmetry Corrector
16K RAM Digital OUT Over Sampling Digital Filter
89 XTAI 90 XTAO 6 CKOUT
XPCK 60 FILO 39 FILI 40 PCO 38 CLTV 42
Digital PLL
Sub Code Processor
3rd-Order Noise Shaper
PWM
PWM
FOK 23 SEIN 13 CNIN 14
Servo Auto Sequencer
CPU Interface
Digital CLV
15 16 17 CLKO DATO XLTO
9 10 11 12 18~21 22 75 76 77 8 SPOA~D SENS EXCK SCOR XLAT SBSO DATA CLOK XLON SQSO
7 SQCK
26 27 28 29 64 30 71 DOUT MDP MDS LOCK XROF PWMI MON
93 LOUT2
94 95 AIN2 AOUT2
86 LOUT1
85 84 AOUT1 AIN1
IC303 LA2010
-- 62 --
IC701 CXA1992BR
RF_M
RFTC
RF_O
RF_I
PD1
PD2
PD0
39
38
37
VEE
36
LD
35
34
33
32
31
30
29
28
27
+
PD2 IV AMP
PD1 IV AMP
+
RF SUMMING AMP + +
FE_BIAS 40
FOK
CC1
CC2
CP
CB
VCC APC
+
+
F 41
VEE LASER POWER CONTROL F IV AMP VCC FE AMP + +
VCC
E 42
+
+
E IV AMP +
BAL4 IFB1 IFB2 IFB3 IFB4 IFB5 IFB6
EI 43
BAL1 BAL2 BAL3
+ + +
FO BIAS WINDOW COMP VEE LEVEL 9
TGFL
VEE
+
VEE 44
TOG1 TOG2 TOG3 TOG4
VEE
TEO 45
+ +
+
TRK GAIN WINDOW COMP
+
E-F BALANCE WINDOW COMP
LPF1 46
+
+
LDON
DFCT1
MIRR
TEI 47 + FOH FOL TGH TGL BALH BALL ATSC TZC FZC DFCT TM1 TDFCT 50 VCC TG1 TRACKING PHASE COMPENSATION
TGFL
LPCL
LPC
CC1
ATSC 48
ATSC WINDOW COMP TZC COMP
TZC 49
VC 51 VCC + FZC 52
+ VEE FOCUS PHASE COMPENSATION DFCT FZC COMP + FS2 Charge up TG2 FS1 VCC
TM3 VEE
TM5
VEE
FSET +
FS4
1 FEO
2 FEI
3 FDFCT
4 FGD
5 FLB
6 FE_O
7 FE_M
8 SRCH
VEE
9 TGU
10 TG2
11 FSET
12 TA_M
13 TA_O
-- 63 --
+
+ 26 SENS2 +
IIL
+
+
+ + + +
25
VCC TTL
SENS1
24
C OUT
+
VEE
+
DFCT
23
XRST
TTL
FOK TTL
+ +
22
VEE IIL
DATA
+
MIRR
+
IIL
VCC
21
XLT
20
CLK
19
LOCK
IIL DATA REGISTER INPUT SHIFT REGISTER SENS SELECTOR OUTPUT DECODER
VCC
18
VCC
ISET
17
ISET
DFCTO
IFB1-6 BAL1-4 TOG1-4
FS1-4
TG1-2
TM1-7
PS1-4
VCC TM4
VCC TM6
16
SL_O
15
TM7
SL_M
14 TM2
SL_P
SECTION 8 EXPLODED VIEWS
NOTE: · -XX, -X mean standardized parts, so they may have some differences from the original one. · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · Abbreviation CND : Canadian IT : Italian
Ver 1.2 1999.10
· ·
The mechanical parts with no reference number in the exploded views are not supplied. Hardware (# mark) list and accessories and packing materials are given in the last of this parts list.
When indicating parts by reference number, please include the board name. The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.
8-1. FRONT CABINET SECTION
7 6
#5
#5
19
#1
#5 #4
10 #1 5 13
#2 #2
#5
17 12 18 14
15
#1
16 3 4 9 2 8 20 1
#3
11
5
Ref. No. 1 2 3 4 5 6 7 8 9 * 10 * 10 * 11 12
Part No. X-3376-357-1 X-3376-361-1 3-017-465-01 X-3375-359-1 1-505-742-11 1-501-480-11 3-017-470-01 3-017-473-01 3-017-877-11 A-3321-154-A
Description CABINET SUB ASSY, FRONT HOLDER SUB ASSY, JACK SPRING, CASSETTE OPEN HOLDER SUB ASSY, CASSETTE SPEAKER (8CM)
Remarks
Ref. No. 13 13 14 15 * 16 17 18 19 20
Part No. 3-017-456-41 3-017-456-51 X-3376-363-1 3-017-457-11 3-017-461-01 3-939-030-01 3-939-031-01 1-782-632-11 X-3374-296-1 3-014-503-01
Description BUTTON, POWER (US,E) BUTTON, POWER (AEP,UK) BUTTON SUB ASSY, CONTROL BUTTON, VOLUME BRACKET, OP/CLOSE CATCHER, PUSH SPRING, PUSH CATCHER RETURN WIRE, PARALLEL (FFC) (12 CORE) WINDOW SUB ASSY, LCD FOOT
Remarks
ANTENNA, TELESCOPIC LID, BATTERY CASE WINDOW, AZIMUTH PLATE (P), JACK SWITCH BOARD, COMPLETE (US,CND,E) *
A-3321-191-A SWITCH BOARD, COMPLETE (AEP,IT,UK) 3-017-462-01 BRACKET, JACK 3-351-377-11 GEAR, DAMPER
3-703-044-26 LABEL, CAUTION (US,CND) 3-839-640-00 CUSHION
-- 64 --
8-2. REAR CABINET SECTION 54
64
#1
55 65
#1
71 56 72
52 70
F901 #1 T901 #4
J301
57 58
61 62 70
#1 #2
63
#2
53
#1
68
#2
73 67
#6 not supplied
66 73 60 59
#1
73
#1
51
MF-D55-144 #2
Ref. No. * * * * * 51 51 52 52 53 Part No. 1-666-855-11 1-666-855-21 A-3321-150-A A-3293-875-A 1-666-856-11 1-666-856-21 3-017-448-01 1-666-860-11 1-666-860-21 1-666-861-11 1-666-861-21 3-017-438-01 3-017-437-01 A-3321-151-A A-3321-189-A 3-017-445-01 A-3321-148-A A-3321-186-A 3-017-443-01 1-667-132-11 Description Remarks Ref. No. * 63 64 65 66 66 67 * 68 * 68 70 71 72 73 ! F901 ! F901 ! T901 60 * 61 * 61 62 * 63 CHASSIS, TU CONTROL BOARD, COMPLETE(US,CND) CONTROL BOARD, COMPLETE (AEP,IT,UK,E) BUTTON, SOUND LAMP BOARD (US,CND) ! T901 J301
#1
73
#1
Part No. 1-667-132-21 3-017-440-01 3-017-449-01 3-017-436-01 3-017-436-11 3-017-441-01 A-3293-842-A A-3293-869-A 1-533-233-21 3-017-439-01
Description LAMP BOARD (AEP,IT,UK,E) BRACKET (L), HANDLE BRACKET (R), HANDLE CABINET, REAR (AEP,IT,UK,E) CABINET, REAR (US,CND) TERMINAL, ANT TC BOARD, COMPLETE (US,CND) TC BOARD, COMPLETE (AEP,IT,UK,E) HOLDER, FUSE SPRING (-) (L), BATTERY
Remarks
TERMINAL BOARD (US,CND) TERMINAL BOARD (AEP,IT,UK,E) POWER BOARD, COMPLETE (US,CND) POWER BOARD, COMPLETE (AEP,IT,UK,E) H/P BOARD (US,CND) H/P BOARD (AEP,IT,UK,E) HANDLE BATTERY (L) BOARD (US,CND) BATTERY (L) BOARD (AEP,IT,UK,E) BATTERY (S) BOARD (US,CND) BATTERY (S) BOARD (AEP,IT,UK,E) SPRING (+.-) (S), BATTERY SPRING (+.-) (L), BATTERY TUNER BOARD, COMPLETE (US,CND) TUNER BOARD, COMPLETE (AEP,IT,UK,E)
* 53 54 * 55 * 55 * 56 * 56 57 58 * 59 * 59
3-939-057-01 SPRING (-), BACK UP 3-831-441-99 CUSHION, SPEAKER 1-532-505-31 FUSE (5A 250V) (AEP,IT,UK,E) 1-533-420-11 FUSE, GLASS CYLINDRICAL(DIA.5) (5A 125V) (US,CND) 1-431-483-11 TRANSFORMER, POWER (US,CND) 1-431-484-11 TRANSFORMER, POWER (AEP,IT,UK,E) 1-566-891-11 JACK (H/P JACK)
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.
-- 65 --
8-3. CD MECHANISM SECTION (KSM-213CDM/M-S)
102 103 118 118
#1
104
#1
101
#1 #1
105
not supplied
112
118 118 106
#1
KSM-213 CDM
109 111 110 117
#7
111
107
108 116
#1
100 114 113
115
#1
Ref. No. * 100 * 100 101 102 103 104 105 106 107 108
Part No. A-3293-850-A A-3293-877-A 3-938-884-01 3-017-878-01 1-692-960-11 3-017-450-01 3-017-472-11 1-452-732-11 3-016-397-01 3-911-135-01
Description
Remarks
Ref. No. 109 110 111 112 113 114 115 116 117 118
Part No. 3-351-377-11 3-931-379-21 3-931-379-31 3-910-116-01 1-782-629-11 1-782-630-11 1-782-627-11 1-782-628-11 1-782-631-11 3-831-441-99
Description GEAR, DAMPER RUBBER, VIBRATION PROOF RUBBER, VIBRATION PROOF COVER, CD WIRE, PARALLEL (FFC) (14 CORE) WIRE, PARALLEL (FFC) (13 CORE) WIRE, PARALLEL (FFC) (27 CORE) WIRE, PARALLEL (FFC) (20 CORE) WIRE, PARALLEL (FFC) (16 CORE) CUSHION, SPEAKER
Remarks
MAIN BOARD, COMPLETE (US,CND) MAIN BOARD, COMPLETE (AEP,IT,UK,E) SPRING, CD COIL SLIDER, PUSH SWITCH, PUSH (1 KEY) SPRING, CD OPEN LID, CD MAGNET PLATE (KSM-213-CDM), CHUCKING SCREW (2.6X10), (+PWH) TAPPING
-- 66 --
8-4. OPTICAL PICK UP SECTION
155
151
not supplied
152
#8
153 154
M702
Ref. No. ! 151 152 153
Part No.
Description
Remarks
Ref. No. 154 155 M702
Part No.
Description
Remarks
8-848-483-05 OPTICAL, PIC-UP KSS-213C/Q-RP 2-627-003-02 GEAR (B) (RP) 2-626-908-01 SHAFT, SLED
X-2626-202-1 CHASSIS ASSY (MB) (RP), MOTOR 2-626-907-01 GEAR (A) X-2625-769-1 GEAR ASSY (MB), MOTOR
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.
-- 67 --
8-5. CASSETTE MECHANISM DECK SECTION-1 (MF-D55-144)
216 215 214
209 211 208
HRPE101
207 212 210
213 217 220
205 206 204
222 223
221 218 227
203 202 226 201
224 225 219
Ref. No. 201 202 203 204 205 206 * 207 208 209 210 211 212 213 214
Part No. 3-938-905-01 3-938-940-01 3-938-941-01 3-938-906-01 3-017-432-01 3-938-901-01 3-938-904-01 3-938-902-01 3-938-903-01 3-938-935-01 X-3374-292-1 3-938-933-01 3-017-592-01 3-938-934-01
Description HEAD, LEVER SPRING (L) SCREW (A) AZIMUTH, SPRING SPRING (A) HEAD, HOLDER HEAD, FRAME WASHER SCREW SPRING (G) ASSIST ASSY, LEVER SPRING (E) ARM (PINCH L) ASSY SPRING (F)
Remarks
Ref. No. * * * * 215 216 217 218 219
Part No. 3-938-916-01 3-938-914-01 3-938-913-01 3-938-909-01 3-938-944-01 3-017-591-01 3-938-937-01 3-938-938-01 3-938-911-01 3-938-907-01
Description BRAKE, ARM FRAME (C) FRAME (B) LOCK, EJECT SCREW (D) ARM (PINCH R) ASSY SPRING (I) SPRING (J) HEAD (B), CHASSIS HEAD, GEAR ARM SCREW (C) SCREW (B) HEAD BOARD HEAD, MAGNETIC (REC/PB/ERASE)
Remarks
220 221 222 * 223 224
225 3-938-943-01 226 3-938-942-01 227 1-662-743-11 HRPE101 1-500-480-11
-- 68 --
8-6. CASSETTE MECHANISM DECK SECTION-2 (MF-D55-144)
267 268 263 262
269 261
M691
PM691
270 264
261 265 260 266 273 275 274 272 276 259 275 277 286 285 284 278 279 280 253 255 251 254 252 256
not supplied
271
258 257 255 283 282 281
Ref. No. 251 252 253 254 255 * 256 257 258 259 260 261 262 263 * 264 265 266 * 267 268 269
Part No. 3-938-949-01 3-938-951-01 3-938-936-01 3-938-930-01 3-938-910-01 3-938-912-01 3-938-952-01 3-938-948-01 3-938-932-01 3-938-908-01 3-938-945-01 3-017-428-01 3-938-920-01 3-938-918-01 3-938-931-01 3-938-921-01 1-662-742-11 3-938-954-01 3-938-947-01
Description WASHER (B) WASHER (D) SPRING (H) SPRING (B) REEL, CAP ARM (UD) WASHER (E) WASHER (A) SPRING (D) CASSETTE, SPRING SCREW (E) FRAME (D) PLUNGER, K TRIGGER, ARM SPRING (C) GEAR (REEL) SW BOARD WASHER (G) SCREW (G)
Remarks
Ref. No. 270 271 272 273 274 275 276 277 * 278 279 280 281 282 283 284 285 286 M691 PM691
Part No. 3-017-431-01 3-017-430-01 3-017-596-01 3-017-434-01 3-017-595-01 3-938-950-01 3-017-433-01 3-938-946-01 3-938-919-01 3-017-435-01 3-017-429-01 3-938-917-01 3-938-924-01 3-938-923-01 X-3374-293-1 3-938-925-01 3-938-922-01 X-3374-291-1 1-454-806-11
Description BRACKET (MM) BELT FLYWHEEL (R) ASSY SCREW (H) FLYWHEEL (L) ASSY WASHER (C) SPRING (K) SCREW (F) ARM (FR) REFLECTOR GEAR (REF) GEAR (A) GEAR (P) GEAR (FR) CLUTCH ASSY GEAR (IDL) GEAR (CAM) MOTOR ASSY SOLENOID, PLUNGER
Remarks
-- 69 --
BATTERY (L) CD MOTOR
NOTE:
BATTERY (S) CONTROL
·
SECTION 9 ELECTRICAL PARTS LIST
Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. -XX, -X mean standardized parts, so they may have some difference from the original one. Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. CAPACITORS: uF: µF Remarks Ref. No. C820 C822 C823 C824 C825 C826 C827 C828 C829 C830 C831 C832 C833 C834 C835 C836 C837 C838 C839 C841 C842 C843 C844 C845 Part No. 1-102-960-00 1-162-294-31 1-162-294-31 1-162-294-31 1-136-165-00 1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31 · RESISTORS All resistors are in ohms. METAL: metal-film resistor METAL OXIDE: Metal Oxide-film resistor F: nonflammable COILS uH: µH SEMICONDUCTORS In each case, u: µ, for example: uA...: µA... , uPA... , µPA... , uPB... , µPB... , uPC... , µPC... , uPD..., µPD... Description CERAMIC CERAMIC CERAMIC CERAMIC FILM CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC 24PF 0.001uF 0.001uF 0.001uF 0.1uF 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 5% 10% 10% 10% 5% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% Remarks 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V (US,CND) 50V 50V 50V 50V 16V
When indicating parts by reference number, please include the board name. The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.
· ·
· ·
·
Abbreviation CND : Canadian IT : Italian Part No. Description
·
Ref. No. * *
1-666-860-11 BATTERY (L) BOARD (US,CND) ***************** 1-666-860-21 BATTERY (L) BOARD (AEP,IT,UK,E) *****************
3-017-439-01 SPRING (-) (L), BATTERY ************************************************************ * * 1-666-861-11 BATTERY (S) BOARD (US,CND) ***************** 1-666-861-21 BATTERY (S) BOARD (AEP,IT,UK,E) ***************** 3-939-057-01 SPRING (-), BACK UP < CONNECTOR > CN903 1-564-505-11 PLUG, CONNECTOR 2P CN904 1-564-506-11 PLUG, CONNECTOR 3P ************************************************************ * 1-639-678-12 CD MOTOR BOARD ****************
1-564-722-11 PIN, CONNECTOR (SMALL TYPE) 6P 1-572-085-11 SWITCH, LEAF ************************************************************ * * A-3321-148-A CONTROL BOARD, COMPLETE (US,CND) ************************* A-3321-186-A CONTROL BOARD, COMPLETE (AEP,IT,UK,E) ************************* 3-017-444-01 HOLDER, LCD 3-019-236-01 ILLUMINATOR (LCD) 7-685-535-14 SCREW +BTP 2.6X10 TYPE2 N-S < CAPACITOR >
C846 C847 C848 C849 C850 C851 C852
1-162-282-31 1-162-282-31 1-162-294-31 1-162-282-31 1-162-306-11
CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC
100PF 100PF 0.001uF 100PF 0.01uF 100PF 0.01uF 100PF
10% 10% 10% 10% 30% 10%
1-162-282-31 CERAMIC 1-162-306-11 CERAMIC 1-162-282-31 CERAMIC < CONNECTOR >
C800 C801 C803 C806 C807 C808 C809 C810 C811 C812 C813 C815 C817 C818 C819
1-164-159-21 1-164-159-21 1-162-306-11 1-126-967-11 1-126-964-11 1-102-514-11 1-102-516-11 1-162-282-31 1-162-282-31 1-102-960-00 1-102-960-00 1-136-165-00 1-162-306-11 1-162-306-11 1-102-960-00
CERAMIC CERAMIC CERAMIC ELECT ELECT CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC FILM CERAMIC CERAMIC CERAMIC
0.1uF 0.1uF 0.01uF 47uF 10uF 22PF 27PF 100PF 100PF 24PF 24PF 0.1uF 0.01uF 0.01uF 24PF
30% 20% 20% 5% 5% 10% 10% 5% 5% 5% 30% 30% 5%
50V 50V 16V 10V 50V 50V 50V 50V 50V 50V 50V 50V 16V 16V 50V
C853
50V (US,CND) 30% 16V (AEP,IT,UK,E) 10% 50V
CN801 * CN802 CN803 * CN804
1-691-071-31 1-695-381-31 1-695-388-21 1-564-704-11
HOUSING, CONNECTOR 12P PIN, CONNECTOR (PC BOARD) 20P PIN, CONNECTOR (PC BOARD) 27P PIN, CONNECTOR (SMALL TYPE) 2P < DIODE >
D801 D802 D803 D804
8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33
DIODE DIODE DIODE DIODE
1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77
-- 70 --
CONTROL
Ref. No. Part No. Description < IC > IC801 IC801 IC803 8-752-890-50 IC CXP83124A-021Q (US,CND) 8-752-894-98 IC CXP83124A-027Q (AEP,IT,UK,E) 8-759-430-16 IC PST600I < COIL > L803 L804 1-410-509-11 INDUCTOR 1-410-509-11 INDUCTOR 10uH 10uH Remarks Ref. No. R837 R838 R839 R840 R841 R842 R843 R844 R844 < LIQUID CRYSTAL DISPLAY > R845 LCD801 1-801-874-11 DISPLAY PANEL, LIQUID CRYSTAL < PILOT LAMP > PL801 PL802 1-517-487-11 LAMP, PILOT 1-517-487-11 LAMP, PILOT < TRANSISTOR > Q803 Q804 Q805 8-729-922-66 TRANSISTOR 2SC2410SN 8-729-922-66 TRANSISTOR 2SC2410SN 8-729-029-49 TRANSISTOR DTA143TSA-TP < RESISTOR > R801 R803 R804 R805 R806 R807 R808 R809 R810 R811 R812 R813 R814 R815 R816 R817 R818 R819 R820 R821 R822 R823 R824 R825 R826 R827 R828 R829 R830 R831 R832 R833 R834 R835 R836 1-249-417-11 1-247-807-31 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-247-807-31 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-426-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 1K 100 1K 1K 1K 1K 1K 1K 1K 1K 100 1K 1K 1K 1K 1K 1K 1K 1K 1K 1K 1K 1K 1K 1K 1K 1K 5.6K 1K 1K 1K 1K 1K 1K 1K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F F F F F F F F F R846 R847 R848 R849 R850 R851 R852 R853 R854 R855 R856 R857 R858 R859 R860 R861 R890 R891 R894 R896 R897 1-249-425-11 1-247-885-00 1-249-441-11 1-247-883-00 1-247-883-00 1-249-413-11 1-249-429-11 1-249-417-11 1-249-425-11 1-249-415-11 1-249-416-11 1-249-418-11 1-249-420-11 1-247-843-11 1-249-427-11 1-249-432-11 1-249-417-11 1-249-437-11 1-247-843-11 1-247-887-00 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 4.7K 180K 100K 150K 150K 470 10K 1K 4.7K 680 820 1.2K 1.8K 3.3K 6.8K 18K 1K 47K 3.3K 220K 470K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1-249-417-11 CARBON 1K Part No. 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 Description CARBON CARBON CARBON CARBON CARBON 1K 1K 1K 1K 1K 1K 47K 680 2.7K 5% 5% 5% 5% 5% 5% 5% 5%
H/P
Remarks 1/4W 1/4W 1/4W 1/4W 1/4W F F F F F
1-249-417-11 CARBON 1-249-437-11 CARBON 1-249-415-11 CARBON 1-249-422-11 CARBON
1/4W F 1/4W 1/4W F (US,CND) 5% 1/4W F (AEP,IT,UK,E) 5% 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F F F F F F F F
1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W
1-247-895-91 CARBON < SWITCH >
F F F F F F F F F F F F F F F F F F F F F F F
S801 S802 S803 S804 S805 S806 S807 S808
1-554-088-00 1-554-088-00 1-554-088-00 1-554-088-00 1-554-088-00
SWITCH, KEY BOARD (STBY) SWITCH, KEY BOARD (SLEEP) SWITCH, KEY BOARD (CLOCK) SWITCH, KEY BOARD (PGM SET AUTI PRESET) SWITCH, KEY BOARD (PLAY MODE MONO/ST)
1-554-088-00 SWITCH, KEY BOARD (CANCEL) 1-554-088-00 SWITCH, KEY BOARD (SOUND) 1-554-088-00 SWITCH, KEY BOARD (MEGABASS) < VIBRATOR >
X801 1-767-184-11 VIBRATOR, CERAMIC (4.21MHz) X802 1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz) ************************************************************ * * 1-666-856-11 H/P BOARD (US,CND) ********** 1-666-856-21 H/P BOARD (AEP,IT,UK,E) ********** 3-831-441-99 CUSHION, SPEAKER < CONNECTOR > * CN305 * CN306 1-564-507-11 PLUG, CONNECTOR 4P 1-564-519-11 PLUG, CONNECTOR 4P
-- 71 --
H/P
Ref. No.
LAMP
Part No.
MAIN
Description < JACK > Remarks Ref. No. C215 C218 C219 C220 C221 C226 C232 C234 C235 C302 C310 C311 C312 C313 C314 C315 C316 C318 C319 C320 C321 C322 C323 C325 C326 C327 C330 C331 C332 C333 C334 C335 C336 C337 C338 C339 C342 C345 C346 C347 C348 C349 C350 C351 C352 C362 C399 C700 C701 C702 C703 C704 C705 C706 C707 C708 C709 C710 C711 C712 Part No. 1-161-055-00 1-126-927-11 1-136-165-00 1-126-960-11 1-126-967-11 1-136-153-00 1-126-960-11 1-126-933-11 1-162-286-21 1-126-967-11 1-161-055-00 1-126-933-11 1-126-967-11 1-126-967-11 1-126-933-11 1-126-967-11 1-126-933-11 1-126-934-11 1-126-963-11 1-128-551-11 1-162-851-11 1-162-851-11 1-126-963-11 1-126-933-11 1-162-306-11 1-126-934-11 1-162-294-31 1-162-292-31 1-161-055-00 1-124-252-00 1-126-963-11 1-126-962-11 1-126-961-11 1-126-964-11 1-126-934-11 1-128-551-11 1-104-666-11 1-130-499-00 1-126-959-11 1-161-055-00 1-161-055-00 1-126-967-11 1-126-933-11 1-162-851-11 1-136-153-00 1-126-960-11 1-136-165-00 1-162-302-11 1-136-153-00 1-162-851-11 1-162-851-11 1-126-963-11 1-130-489-00 1-130-486-00 1-162-199-31 1-126-962-11 1-130-493-00 1-162-215-31 1-130-489-00 1-162-306-11 Description CERAMIC ELECT FILM ELECT ELECT FILM ELECT ELECT CERAMIC ELECT CERAMIC ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT CERAMIC CERAMIC ELECT ELECT CERAMIC ELECT CERAMIC CERAMIC CERAMIC ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT MYLAR ELECT CERAMIC CERAMIC ELECT ELECT CERAMIC FILM ELECT FILM CERAMIC FILM CERAMIC CERAMIC ELECT MYLAR MYLAR CERAMIC ELECT MYLAR CERAMIC MYLAR CERAMIC 0.022uF 2200uF 0.1uF 1uF 47uF 0.01uF 1uF 100uF 220PF 47uF 0.022uF 100uF 47uF 47uF 100uF 47uF 100uF 220uF 4.7uF 22uF 0.1uF 0.1uF 4.7uF 100uF 0.01uF 220uF 0.001uF 680PF 0.022uF 0.33uF 4.7uF 3.3uF 2.2uF 10uF 220uF 22uF 220uF 0.22uF 0.47uF 0.022uF 0.022uF 47uF 100uF 0.1uF 0.01uF 1uF 0.1uF 0.0022uF 0.01uF 0.1uF 0.1uF 4.7uF 0.033uF 0.018uF 10PF 3.3uF 0.068uF 47PF 0.033uF 0.01uF 10% 20% 5% 20% 20% 5% 20% 20% 10% 20% 10% 20% 20% 20% 20% 20% 20% 20% 20% 20% 10% 10% 20% 20% 30% 20% 10% 10% 10% 20% 20% 20% 20% 20% 20% 20% 20% 5% 20% 10% 10% 20% 20% 10% 5% 20% 5% 30% 5% 10% 10% 20% 5% 10% 5% 20% 5% 5% 5% 30% Remarks 50V 10V 50V 50V 10V 50V 50V 10V 50V 10V 50V 10V 10V 10V 10V 10V 10V 10V 50V 25V 16V 16V 50V 10V 16V 10V 50V 50V 50V 50V 50V 50V 50V 50V 10V 25V 25V 50V 50V 50V 50V 10V 10V 16V 50V 50V 50V 16V 50V 16V 16V 50V 50V 50V 50V 50V 50V 50V 50V 16V
J301
1-566-891-11 JACK (H/P JACK) < COIL >
L101 L201 L304
1-410-314-11 INDUCTOR 1-410-314-11 INDUCTOR 1-410-314-11 INDUCTOR < RESISTOR >
0.47uH 0.47uH 0.47uH
R170 1-249-407-11 CARBON 150 5% 1/4W F R270 1-249-407-11 CARBON 150 5% 1/4W F ************************************************************* * * 1-667-132-11 LAMP BOARD (US,CND) ************ 1-667-132-21 LAMP BOARD (AEP,IT,UK,E) ************ < PILOT LAMP > PL801 1-517-487-11 LAMP, PILOT PL802 1-517-487-11 LAMP, PILOT ************************************************************* * * A-3293-850-A MAIN BOARD, COMPLETE (US,CND) ********************* A-3293-877-A MAIN BOARD, COMPLETE (AEP,IT,UK,E) ********************* 1-782-627-11 1-782-628-11 1-782-629-11 1-782-630-11 7-685-646-79 WIRE, PARALLEL (FFC) (27 CORE) WIRE, PARALLEL (FFC) (20 CORE) WIRE, PARALLEL (FFC) (14 CORE) WIRE, PARALLEL (FFC) (13 CORE) SCREW +BVTP 3X8 TYPE2 IT-3 < CAPACITOR > C101 C107 C109 C110 C111 C112 C113 C114 C115 C118 C119 C120 C121 C126 C132 C134 C135 C201 C207 C209 C210 C211 C212 C213 C214 1-162-215-31 1-126-963-11 1-162-215-31 1-126-960-11 1-161-061-11 1-161-061-11 1-162-837-11 1-126-964-11 1-161-055-00 1-126-927-11 1-136-165-00 1-126-960-11 1-126-967-11 1-136-153-00 1-126-960-11 1-126-933-11 1-162-286-21 1-162-215-31 1-126-963-11 1-162-215-31 1-126-960-11 1-161-061-11 1-161-061-11 1-162-837-11 1-126-964-11 CERAMIC ELECT CERAMIC ELECT CERAMIC CERAMIC CERAMIC ELECT CERAMIC ELECT FILM ELECT ELECT FILM ELECT ELECT CERAMIC CERAMIC ELECT CERAMIC ELECT CERAMIC CERAMIC CERAMIC ELECT 47PF 4.7uF 47PF 1uF 0.068uF 0.068uF 0.0068uF 10uF 0.022uF 2200uF 0.1uF 1uF 47uF 0.01uF 1uF 100uF 220PF 47PF 4.7uF 47PF 1uF 0.068uF 0.068uF 0.0068uF 10uF 5% 20% 5% 20% 10% 10% 10% 20% 10% 20% 5% 20% 20% 5% 20% 20% 10% 5% 20% 5% 20% 10% 10% 10% 20% 50V 50V 50V 50V 50V 50V 16V 50V 50V 10V 50V 50V 10V 50V 50V 10V 50V 50V 50V 50V 50V 50V 50V 16V 50V
-- 72 --
MAIN
Ref. No. C713 C714 C715 C716 C717 C718 C719 C720 C721 C722 C723 C724 C725 C726 C727 C728 C729 C730 C731 C732 C733 C734 C735 C736 C737 C738 C739 C740 C742 C743 C745 C747 C748 C749 C750 C751 C752 C753 C755 C760 C761 C762 C763 C770 C771 C772 C773 C797 C798 C799 Part No. 1-136-153-00 1-130-493-00 1-126-960-11 1-162-199-31 1-126-967-11 1-162-294-31 1-130-491-00 1-162-305-11 1-101-005-00 1-162-306-11 1-162-600-11 1-162-851-11 1-101-005-00 1-126-964-11 1-162-306-11 1-126-934-11 1-162-306-11 1-126-967-11 1-136-153-00 1-126-967-11 1-126-959-11 1-162-306-11 1-162-290-31 1-162-286-21 1-162-306-11 1-130-499-00 1-162-306-11 1-162-302-11 1-162-199-31 1-162-199-31 1-162-302-11 1-126-964-11 1-162-851-11 1-126-967-11 1-126-924-11 1-136-153-00 1-162-306-11 1-126-935-11 1-162-294-31 1-126-963-11 1-162-290-31 1-162-290-31 1-162-306-11 1-126-963-11 1-162-294-31 1-162-306-11 1-162-851-11 1-162-306-11 1-162-294-31 1-162-294-31 Description FILM MYLAR ELECT CERAMIC ELECT CERAMIC MYLAR CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC ELECT CERAMIC ELECT CERAMIC ELECT FILM ELECT ELECT CERAMIC CERAMIC CERAMIC CERAMIC MYLAR CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC ELECT CERAMIC ELECT ELECT FILM CERAMIC ELECT CERAMIC ELECT CERAMIC CERAMIC CERAMIC ELECT CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC < CONNECTOR > * CN301 * CN302 CN303 CN304 CN701 1-695-337-31 1-695-381-31 1-695-388-21 1-695-336-31 1-774-975-11 PIN, CONNECTOR (PC BOARD) 14P PIN, CONNECTOR (PC BOARD) 20P PIN, CONNECTOR (PC BOARD) 27P PIN, CONNECTOR (PC BOARD) 13P CONNECTOR, FFC/FPC 16P 0.01uF 0.068uF 1uF 10PF 47uF 0.001uF 0.047uF 0.0068uF 22000PF 0.01uF 0.0047uF 0.1uF 22000PF 10uF 0.01uF 220uF 0.01uF 47uF 0.01uF 47uF 0.47uF 0.01uF 470PF 220PF 0.01uF 0.22uF 0.01uF 0.0022uF 10PF 10PF 0.0022uF 10uF 0.1uF 47uF 330uF 0.01uF 0.01uF 470uF 0.001uF 4.7uF 470PF 470PF 0.01uF 4.7uF 0.001uF 0.01uF 0.1uF 0.01uF 0.001uF 0.001uF 5% 5% 20% 5% 20% 10% 5% 30% 30% 30% 10% 20% 30% 20% 30% 20% 5% 20% 20% 30% 10% 10% 30% 5% 30% 30% 5% 5% 30% 20% 10% 20% 20% 5% 30% 20% 10% 20% 10% 10% 30% 20% 10% 30% 10% 30% 10% 10% Remarks 50V 50V 50V 50V 10V 50V 50V 16V 50V 16V 16V 16V 50V 50V 16V 10V 16V 10V 50V 10V 50V 16V 50V 50V 16V 50V 16V 16V 50V 50V 16V 50V 16V 10V 10V 50V 16V 16V 50V 50V 50V 50V 16V 50V 50V 16V 16V 16V 50V 50V Ref. No. Part No. Description < DIODE > D301 D302 D303 D304 D306 D310 D311 D313 D314 D361 D702 8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33 8-719-109-89 8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33 DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77 RD5.6ESB2 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77 Remarks
8-719-991-33 DIODE 1SS133T-77 < FERRITE BEAD >
FB701 FB702 FB703 FB704 FB705
1-410-397-21 1-410-397-21 1-410-397-21 1-410-397-21 1-410-397-21
FERRITE BEAD INDUCTOR FERRITE BEAD INDUCTOR FERRITE BEAD INDUCTOR FERRITE BEAD INDUCTOR FERRITE BEAD INDUCTOR < IC >
IC302 IC303 IC304 IC305 IC309 IC701 IC702 IC703
8-759-432-41 8-759-800-71 8-759-820-22 8-759-076-15 8-759-479-70
IC IC IC IC IC
BH3854AS LA2010 LA4597 KIA4558P S-81250SGY-Z
8-752-082-14 IC CXA1992BR 8-752-380-64 IC CXD2529Q 8-759-478-60 IC BA6898S < COIL >
L301 L302 L303 L701
1-410-509-11 1-410-509-11 1-410-509-11 1-412-852-11
INDUCTOR INDUCTOR INDUCTOR INDUCTOR
10uH 10uH 10uH 47uH
< TRANSISTOR > Q101 Q101 Q103 Q104 Q105 Q106 Q107 Q201 Q203 Q204 Q205 Q206 Q207 Q301 Q311 Q312 Q312 Q313 Q314 Q315 8-729-115-80 8-729-029-72 8-729-905-50 8-729-905-50 8-729-905-50 8-729-905-50 8-729-905-50 8-729-115-80 8-729-905-50 8-729-905-50 8-729-905-50 8-729-905-50 8-729-905-50 8-729-115-80 8-729-036-86 8-729-115-82 8-729-030-10 8-729-920-94 8-729-115-80 8-729-036-86 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR BA1A4P DTC114YS-TP DTC343TS DTC343TS DTC343TS DTC343TS DTC343TS BA1A4P DTC343TS DTC343TS DTC343TS DTC343TS DTC343TS BA1A4P KTC3203Y-AT BA1L4L-TP DTC144WS-TP DTA123YS BA1A4P KTC3203Y-AT
-- 73 --
MAIN
Ref. No. Q316 Q316 Q317 Q318 Q319 Q320 Q321 Q321 Q322 Q322 Q323 Q323 Q324 Q325 Q326 Q326 Q327 Q328 Q329 Q329 Q361 Q362 Q363 Q365 Q701 Part No. 8-729-037-34 8-729-902-80 8-729-036-89 8-729-801-84 8-729-115-80 8-729-115-80 8-729-037-34 8-729-902-80 8-729-037-34 8-729-902-80 8-729-037-34 8-729-902-80 8-729-036-89 8-729-036-89 8-729-037-34 8-729-902-80 8-729-036-89 8-729-115-80 8-729-037-34 8-729-902-80 8-729-115-80 8-729-801-84 8-729-115-80 8-729-036-86 8-729-037-02 Description TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR < RESISTOR > R101 R102 R107 R108 R109 R110 R111 R112 R113 R114 R115 R116 R117 R118 R119 R120 R123 R124 R125 R131 R132 R133 R134 R201 R202 R207 R208 R209 R210 R211 1-249-417-11 1-249-431-11 1-247-843-11 1-249-429-11 1-249-426-11 1-249-425-11 1-249-401-11 1-249-427-11 1-249-419-11 1-249-417-11 1-249-417-11 1-249-441-11 1-249-435-11 1-249-429-11 1-249-429-11 1-249-420-11 1-249-401-11 1-249-387-11 1-249-421-11 1-249-431-11 1-247-843-11 1-249-437-11 1-249-425-11 1-249-417-11 1-249-431-11 1-247-843-11 1-249-429-11 1-249-426-11 1-249-425-11 1-249-401-11 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 1K 15K 3.3K 10K 5.6K 4.7K 47 6.8K 1.5K 1K 1K 100K 33K 10K 10K 1.8K 47 3.3 2.2K 15K 3.3K 47K 4.7K 1K 15K 3.3K 10K 5.6K 4.7K 47 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F F F F F KRA107M DTA114YS KTC3198GR-AT 2SB1013-4 BA1A4P BA1A4P KRA107M DTA114YS KRA107M DTA114YS KRA107M DTA114YS KTC3198GR-AT KTC3198GR-AT KRA107M DTA114YS KTC3198GR-AT BA1A4P KRA107M DTA114YS BA1A4P 2SB1013-4 BA1A4P KTC3203Y-AT KTA1266Y-AT Remarks Ref. No. R212 R213 R214 R215 R216 R217 R218 R219 R220 R223 R224 R225 R231 R232 R233 R234 R301 R301 R313 R314 R315 R316 R317 R318 R319 R320 R321 R323 R324 R325 R326 R327 R328 R329 R330 R331 R332 R334 R335 R336 R337 R338 R340 R341 R342 R344 R345 R346 R350 R361 R362 R363 R364 R365 R366 Part No. 1-249-427-11 1-249-419-11 1-249-417-11 1-249-417-11 1-249-441-11 1-249-435-11 1-249-429-11 1-249-429-11 1-249-420-11 1-249-401-11 1-249-387-11 1-249-421-11 1-249-431-11 1-247-843-11 1-249-437-11 Description CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 6.8K 1.5K 1K 1K 100K 33K 10K 10K 1.8K 47 3.3 2.2K 15K 3.3K 47K 4.7K 100 1K 5.6K 330K 100K 10K 12K 1M 1M 100K 18K 47 10K 10K 10K 2.2K 3.3K 1M 10K 10K 4.7K 10K 150 470K 47K 10K 4.7K 1.2K 1M 47 4.7K 10K 100K 1K 100K 100K 100K 100K 33K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remarks 1/4W 1/4W 1/4W 1/4W 1/4W F F F F
1/4W 1/4W 1/4W 1/4W F 1/4W F 1/4W F 1/4W F 1/4W 1/4W 1/4W
1-249-425-11 CARBON 1-247-807-31 CARBON 1-249-417-11 CARBON 1-249-426-11 CARBON 1-247-891-00 CARBON 1-249-441-11 1-249-429-11 1-249-430-11 1-247-903-00 1-247-903-00 1-249-441-11 1-249-432-11 1-249-401-11 1-249-429-11 1-249-429-11 1-249-429-11 1-249-421-11 1-247-843-11 1-247-903-00 1-249-429-11 1-249-429-11 1-249-425-11 1-249-429-11 1-249-407-11 1-247-895-91 1-249-437-11 1-249-429-11 1-249-425-11 1-249-418-11 1-247-903-00 1-249-401-11 1-249-425-11 1-249-429-11 1-249-441-11 1-249-417-11 1-249-441-11 1-249-441-11 1-249-441-11 1-249-441-11 1-249-435-11 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON
1/4W F 1/4W (US,CND) 5% 1/4W F (AEP,IT,UK,E) 5% 1/4W 5% 1/4W 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W F 1/4W F 1/4W 1/4W F 1/4W F 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W
1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F F F F
1/4W 1/4W 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W F
-- 74 --
MAIN
Ref. No. R367 R368 R369 R370 R371 R377 R700 R701 R702 R703 R704 R705 R706 R707 R708 R709 R710 R711 R712 R713 R714 R716 R718 R719 R720 R721 R722 R723 R724 R725 R726 R727 R728 R731 R732 R733 R734 R735 R736 R737 R738 R739 R740 R745 R746 R747 R748 R749 R750 R751 R752 R754 R799 Part No. 1-249-441-11 1-249-441-11 1-249-417-11 1-249-413-11 1-249-441-11 1-249-437-11 1-249-429-11 1-247-843-11 1-247-899-11 1-249-441-11 1-247-896-11 1-249-439-11 1-249-441-11 1-249-437-11 1-249-441-11 1-249-432-11 1-247-887-00 1-249-435-11 1-249-430-11 1-249-429-11 1-247-903-00 1-249-411-11 1-249-393-11 1-249-441-11 1-249-441-11 1-249-441-11 1-249-441-11 1-249-440-11 1-249-440-11 1-247-891-00 1-247-883-00 1-247-883-00 1-247-887-00 1-249-437-11 1-249-437-11 1-247-843-11 1-249-417-11 1-249-429-11 1-247-903-00 1-249-429-11 1-247-887-00 1-249-417-11 1-249-417-11 1-249-417-11 1-249-435-11 1-247-863-91 1-249-437-11 1-247-843-11 1-249-417-11 1-249-430-11 Description CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 100K 100K 1K 470 100K 47K 10K 3.3K 680K 100K 510K 68K 100K 47K 100K 18K 220K 33K 12K 10K 1M 330 10 100K 100K 100K 100K 82K 82K 330K 150K 150K 220K 47K 47K 3.3K 1K 10K 1M 10K 220K 1K 1K 1K 33K 22K 47K 3.3K 1K 12K 7.5K 47K 10K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remarks 1/4W 1/4W 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W Ref. No. * * Part No. Description
POWER
Remarks
A-3321-150-A POWER BOARD, COMPLETE (US,CND) *********************** A-3293-875-A POWER BOARD, COMPLETE (AEP,IT,UK,E) *********************** 1-533-233-21 HOLDER, FUSE 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3 < CAPACITOR > C900 C901 C902 C903 C904 C905 C906 C907 C908 C909 C910 C911 C912 C913 1-128-548-11 1-101-005-00 1-101-005-00 1-101-005-00 1-101-005-00 ELECT CERAMIC CERAMIC CERAMIC CERAMIC 4700uF 22000PF 22000PF 22000PF 22000PF 0.1uF 0.022uF 0.022uF 47uF 220uF 0.022uF 0.022uF 220uF 100uF 20% 25V 50V 50V 50V 50V
1-136-165-00 FILM 1-161-055-00 1-161-055-00 1-126-967-11 1-126-934-11 1-161-055-00 1-161-055-00 1-126-934-11 1-126-933-11 CERAMIC CERAMIC ELECT ELECT CERAMIC CERAMIC ELECT ELECT < CONNECTOR >
50V (AEP,IT,UK,E) 10% 50V 10% 50V 20% 10V 20% 10V 10% 10% 20% 20% 50V 50V 10V 10V
5%
CN901
1-564-510-11 PLUG, CONNECTOR 7P < DIODE >
D901 D902 D903 D904 D905 D906 D907 D908 D909 D910 D911
8-719-046-07 8-719-046-07 8-719-046-07 8-719-046-07 8-719-991-33 8-719-991-33 8-719-981-95 8-719-110-14 8-719-110-09 8-719-991-33
DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE
2A02M 2A02M 2A02M 2A02M 1SS133T-77 1SS133T-77 MTZJ-2.7B RD9.1ES-B3 RD8.2ES-B3 1SS133T-77
8-719-991-33 DIODE 1SS133T-77 < FUSE >
! F901 ! F901
1-532-505-31 FUSE (5A 250V) (AEP,IT,UK,E) 1-533-420-11 FUSE ,GLASS CYLINDRICAL (DIA.5) (5A 125V) (US, CND) < JACK >
! J901 ! J901
1-540-009-11 INLET, AC (/ AC IN) (US,CND) 1-526-838-11 INLET, AC 2P (/ AC IN) (AEP,IT,UK,E) < TRANSISTOR >
1-247-852-11 CARBON 1-249-437-11 CARBON 1-249-429-11 CARBON < VIBRATOR >
Q901 Q902
8-729-209-15 TRANSISTOR 2SD2012 8-729-209-15 TRANSISTOR 2SD2012
X701 1-767-226-11 VIBRATOR, CRYSTAL (16.9344NHz) *************************************************************
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.
-- 75 --
POWER
Ref. No. Part No.
RETAINER
Description < RESISTOR >
SW
SWITCH
Remarks Ref. No. Part No. Description < IC > IC802 8-742-012-11 HY B IC SBX1976-51 < RESISTOR > R862 R863 R864 R865 R866 R867 R869 R870 R871 R872 R873 R874 R875 R876 R877 R878 R879 R880 R881 R882 R883 R884 R885 R886 R887 R893 R895 1-249-425-11 1-249-415-11 1-249-416-11 1-249-418-11 1-249-420-11 1-247-843-11 1-249-427-11 1-249-432-11 1-249-425-11 1-249-415-11 1-249-416-11 1-249-418-11 1-249-420-11 1-247-843-11 1-249-427-11 1-249-432-11 1-249-425-11 1-249-415-11 1-249-416-11 1-249-418-11 1-249-420-11 1-247-843-11 1-249-427-11 1-249-410-11 1-249-432-11 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 4.7K 680 820 1.2K 1.8K 3.3K 6.8K 18K 4.7K 680 820 1.2K 1.8K 3.3K 6.8K 18K 4.7K 680 820 1.2K 1.8K 3.3K 6.8K 270 18K 150 150 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W F F F F F Remarks
! R901 1-211-757-11 FUSIBLE 1 5% 1/2W F ! R902 1-211-757-11 FUSIBLE 1 5% 1/2W F R903 1-249-410-11 CARBON 270 5% 1/4W F R904 1-249-414-11 CARBON 560 5% 1/4W F R905 1-249-421-11 CARBON 2.2K 5% 1/4W F ************************************************************* * * 1-666-862-11 RETAINER BOARD (US,CND) *************** 1-666-862-21 RETAINER BOARD (AEP,IT,UK,E) ***************
************************************************************* * 1-662-742-11 SW BOARD ******** < CONNECTOR > CN691 1-580-170-11 PIN,CONNECTOR (PC BOARD) 9P < PHOTO INTERUPTER > PH691 1-801-455-11 PHOTO REFLECTOR < PLUNGER SOLENOID > PM691 1-454-806-11 SOLENOID, PLUNGER < RESISTOR > R691 1-247-822-11 RES,CARBON (SMALL) 430 < SWITCH > S691 1-762-811-11 SWITCH,LEAF (HALF) S692 1-762-811-11 SWITCH,LEAF (CrO2) S694 1-762-811-11 SWITCH,LEAF (ERASE PROOF A) S695 1-762-811-11 SWITCH,LEAF (ERASE PROOF B) S696 1-762-810-11 SWITCH,LEAF (HEAD POSITION) ************************************************************* * * A-3321-154-A SWITCH BOARD, COMPLETE (US,CND,E) *********************** A-3321-191-A SWITCH BOARD, COMPLETE (AEP,IT,UK) *********************** 1-782-632-11 WIRE, PARALLEL (FFC) (12 CORE) < CONNECTOR > * CN805 1-695-373-31 PIN, CONNECTOR (PC BOARD) 12P < DIODE > D805 D806 D807 D808 D809 D810 D811 8-719-067-05 8-719-067-05 8-719-067-05 8-719-067-05 8-719-067-05 DIODE DIODE DIODE DIODE DIODE SLR-342MGTC7 (CD ^) SLR-342MGTC7 (CD p) SLR-342MGTC7 (RADIO BOARD