Sony Ericsson Xperia Active ST17 ST17i ST17a free download

File name DocumentDispatch_(Component Replacement)_010.pdf

Component Replacement - electrical - XperiaTM active ST17i, ST17a 1249-2437 Rev 1 Sony Ericsson Mobile Communications AB ­ Company Internal CONTENTS 1 2 3 4 Component Replacement (elec) Replaceable Components ... 3 Component Placing ... 7 Repair Actions ... 8 3.1 Shield Can Fence Modifications ... 8 3.2 Additional Repair Info ... 9 Revision History ... 17 For general information about electrical repair related issues, refer to 1220-1336: Generic Repair Manual - electrical 1249-2437 Rev 1 Sony Ericsson Mobile Communications AB ­ Company Internal 2(17) 1 Replaceable Components Component Replacement (elec) EXPLANATION OF ABBREVIATIONS USED IN THE COLUMN `COMMENTS' BELOW COMPONENT LOCATION P = Primary side S = Secondary side MOISTURE SENSITIVITY LEVEL MSLX (X = 1, 2, 2A, 3, 4, 5, 5A or 6) For more information on moisture sensitivity levels: Refer to 1220-1336: Generic Repair Manual ­ electrical, section `Moisture & Baking'! REPAIR METHOD HA = Hot Air (removal & mounting) ST = Soldering Tool (removal & mounting) HA/ST = Hot Air for removal - Soldering Tool for mounting BGA = BGA Station BH = Bottom Heater ADDITIONAL INFORMATION 1 (2,3,4, etc.) = Proceed to `Additional Repair Info' for further instructions in the indicated section(s). CALIBRATION CAL in the column Comments = Calibration of the phone is required after replacing the component Calibration to be done by authorized centers only! REMOVE SENSITIVITY PARTS Due to the temperature sensitivity, the camera has to be removed before any repair action is done on the PBA. Adhesives, gaskets and the Spacer for SIM card has also to been removed when there is a risk for them to be heated. Please follow the Replacement instruction in the Working instruction. 1249-2437 Rev 1 Sony Ericsson Mobile Communications AB ­ Company Internal 3(17) Position B3501 B3502 B5100 C1317 C2200 C7603 E1006 L1000 L1001 L1002 L1003 L1004 L1300C L1306 L2400C L2401C L3100 L3500 L3501 L3502 L3503 L3504 L3505 L3506 L3600 L3601 L3602 L3603 L3605 L3606 L7600 L7610 L7801 L8100 Component Microphone Microphone Vibr Bar Analog DC Capacitor 1.0 uF +/-10% 25.0 V K0603 Capacitor 1.0 uF +/-10% 25.0 V K0603 Capacitor Ceramic 4.7 uF Thread Insert Ind WW 2.2 uH Ind WW 2.2 uH Ind Chip 2.2 uH Ind WW 2.2 uH Ind WW 2.2 uH Ind Chip 1.0 uH Ferrite B 120 Ohm Ind WW 2.2 uH Filter 100 MHz Ind Chip 120.0 nH Inductor Chip Inductor Chip Ind Chip 0.0 mH 060 Ind Chip 0.0 mH 060 Resistor 0.0 Ohm +/-5% NA mW K0402 Resistor 0.0 Ohm +/-5% NA mW K0402 Resistor 0.0 Ohm +/-5% NA mW K0402 Filter Filter Ferrite B 1.8 kOhm Ferrite B 1.8 kOhm Transformer F

File name DocumentDispatch_(Customization)_008.pdf

Customization - build swap - XperiaTM active ST17i, ST17a 1249-2440 Rev 1 Sony Ericsson Mobile Communications AB ­ Company Internal CONTENTS 1 2 Customization (swap) Emma Login & Script Execution ... 3 Customization Workflow ... 4 2.1.1 2.2.1 2.2.2 Customization ... 5 Customize to Ship ... 6 Build Swap ... 6 2.1 Customize Unit ... 5 2.2 Customize to Ship or Build Swap ... 6 3 Revision History ... 7 For general information about Customization and Swap, refer to 1221-5655: Generic Repair Manual ­ build swap 1249-2440 Rev 1 Sony Ericsson Mobile Communications AB ­ Company Internal 2(7) 1 Emma Login & Script Execution Customization (swap) In order to change a phone from Customer A to Customer B you must run a `Customization Script', see chapter 2.1.1 Customization below. Start by launching the Emma application. Connect the Micro USB to USB cable to one of the computer's USB ports but do not connect the cable to the phone. The USB Activation Dongle has to be inserted into one of the computer's USB ports to be able to log in. To execute a `Customization' or `Activation' you need to be properly logged on to the Emma application by using your User ID and Password. To execute a `Customization Script' or `Activation Script' (or any other function): · check that the phone is powered off · press and keep the "Volume Down" key on the phone · connect the phone to the USB Cable · release the " Volume Down" key When executing an `Activation Script' you will be prompted for the PIN of your USB Activation Dongle. 1249-2440 Rev 1 Sony Ericsson Mobile Communications AB ­ Company Internal 3(7) 2 Customization Workflow Customization (swap) Not required for Quick Customization. 1249-2440 Rev 1 Sony Ericsson Mobile Communications AB ­ Company Internal 4(7) Customization Workflow Customization (swap) The primary reason for the customization process is to create a customized unit. A customized unit is a unit that is ready to ship as a final swap unit. The second reason for customization is to create "build swap" units and this can be done by selecting the `Service Exchange Unit' customization script for the particular model. The instruction steps below refer to the flowchart on previous page. Note! If the phone have never been used with a correct SIM card EMMA will not find any script to the phone. Then you need to put in a SIM card that matches the phone and lo

File name DocumentDispatch_(Part List)_005.pdf

Part List - mechanical - XperiaTM active ST17i, ST17a 1249-2434 Rev 6 Sony Ericsson Mobile Communications AB ­ Company Internal Part List (mech) CONTENTS 1 2 Part List ... 3 Revision History ... 10 1249-2434 Rev 6 Sony Ericsson Mobile Communications AB ­ Company Internal 2(10) Part List (mech) 1 Part List The following parts are available for order in `E-star'. The `E-star' name of a part may often be complex and even confusing, so the name of certain parts mentioned in the Working Instructions, Repair Movies and Troubleshooting Guide are often referred to by a simple descriptive name for better understanding. Both names (designations) will in that case be included in this Part List, where the name being used in the documents mentioned above is underlined, e.g. Battery Cover. Designation Part No. Part Location Adhesive 3 x 6 1256-7572 Adhesive 7,8 x 1,4 1237-2031 Adhesive Earspeaker 1252-1133 Adhesive Irregular 1249-2665 Audio Jack 1242-3994 Camera 5 MPixel 1249-1815 1249-2434 Rev 6 Sony Ericsson Mobile Communications AB ­ Company Internal 3(10) Designation Cap Audio Cap Audio Jack Black Cap Audio Jack White Part No. Part Part List (mech) Location 1248-4167 1250-0170 Cap USB Cap USB Black Cap USB White 1248-4170 1250-0172 Cover Back Cover Back Black Cover Back Blue Billabong Cover Back Grey Billabong Cover Back White 1248-3737 1253-1520 1253-1524 1250-0175 Cover Battery Cover Battery 1/2/5 Cover Battery 1/8 [for ST17a] [for ST17i] 1249-7127 1249-7284 Cover Front Cover Front with display Black Note Touch panel calibration has to be done every time the Front Cover is replaced. 1252-5717 Cushion 5 x 2 1242-6502 Cushion 7 x 7 1241-6722 Cushion Earspeaker 1256-9171 1249-2434 Rev 6 Sony Ericsson Mobile Communications AB ­ Company Internal 4(10) Designation Deco Belt Deco Belt Orange Deco Belt White Part No. Part Part List (mech) Location 1248-3739 1250-0168 Earspeaker 1252-6446 Foil Adhesive for Cover Front flex 1264-1080 Foil Component Protection 1249-2666 Foil Grounding Camera 1230-4736 Gasket 14,1 x 6,4 1249-2667 Gasket 2nd Mic for Battery Cover 1248-4156 Gasket 2nd Mic for Inner Frame 1248-5065 1249-2434 Rev 6 Sony Ericsson Mobile Communications AB ­ Company Internal 5(10) Designation Part No. Part Part List (mech) Location Gasket Mic with Membrane 1248-4145 Gasket 7,3 x 1,5 1242-7651 Gasket Conductive 19 x 10 1250-5602 Gasket Key Sealing 1253-8369 Gasket Camera Key Sealing 1257-1637 Gasket Proxy 1248-3774 Gasket RGB 1248-3769 1249-2434 Rev 6 Sony Ericsson Mobile Communications AB ­ Company Internal 6(10) Designation Part No. Part Part List (mech) Location Gasket US-welding 1245-2118 Inner Frame 1248-3777 Key Camera Key Camera Orange Key Camera White 1248-3729 1250-0163 Key On/Off Key On/Of

File name DocumentDispatch_(Repair Movie)_003.pdf

Repair Movies - mechanical - XperiaTM active ST17i, ST17a 1249-2432 Rev 1 Sony Ericsson Mobile Communications AB ­ Company Internal Repair Movies (mech) CONTENTS 1 2 Movies ... 3 1.1 Disassembly ... 3 1.2 Reassembly ... 3 Revision History ... 4 To view the embedded repair movies in this document, Acrobat Reader version 8 (or later) and Flash Player version 8 (or later) must be installed on your computer. For best picture quality, select "Actual size" or "100%" as zoom level in Acrobat Reader. To magnify while keeping an acceptable picture quality, increase the zoom level to 200%. If the movies appear to be jerky or blurred when viewing on-line, this is probably caused by the connection speed being too slow. In that case, right-click with the mouse on the document name and select Save Target As to download the repair movie document for off-line viewing. For general information about repair movies, refer to 1220-1333: Generic Repair Manual - mechanical 1249-2432 Rev 1 Sony Ericsson Mobile Communications AB ­ Company Internal 2(4) Repair Movies (mech) 1 1.1 Movies Disassembly 1. Cover Back 2. Cover Battery & Battery 3. Inner Frame 4. Main PBA 5. LCD Support & Cover Front with Display 1.2 Reassembly 1. LCD Support & Cover Front with Display 2. Main PBA 3. Inner Frame 4. Battery & Cover Battery 5. Cover Back 1249-2432 Rev 1 Sony Ericsson Mobile Communications AB ­ Company Internal 3(4) Repair Movies (mech) 2 Rev. 1 Revision History Date 2011-Sep-23 Changes / Comments Initial release 1249-2432 Rev 1 Sony Ericsson Mobile Communications AB ­ Company Internal 4(4)

File name DocumentDispatch_(Schematics)_012.pdf

Schematics - electrical - XperiaTM active ST17i, ST17a 1249-2439 Rev 1 Sony Ericsson Mobile Communications AB ­ Company Internal 1 Rev. Revision History Date Changes / Comments Schematics (elec) 1 2011-Sept-26 Initial release 1249-2439 Rev 1 Sony Ericsson Mobile Communications AB ­ Company Internal 2(2) Core POWER_BUS POWER_BUS POWER_BUS POWER_BUS KYPD_PWR_N Peripheral NFC Board - 8600 N1600 PM8058_NFC_IF P5_Keypad KYPD_PWR_N I2C_SCL I2C_SDA POWER_BUS I2C_SCL POWER_BUS I2C_SDA PM8058 1226-6567_2 P4_IO_Devices GPIO_18 M11 NFC_DWLDEN NC POWER_BUS POWER_BUS NFC_EXT_EN B15 NFC_EXT_EN NC GPIO_19 M10 NFC_IRQ NC C3_Power_ASICs C2_Power_Management GPIO_17 N7 NFC_RST_N NC POWER_BUS I2C_SCL I2C_SDA POWER_BUS I2C_SCL I2C_SDA MCLK_A0_RF XO_OUT_A1_EN MCLK_A1_RF GSM_TX_MASK MCLK_D1_MSM POWER_BUS C1_Charge MCLK_A1_RF MCLK_A1_RF XO_OUT_A1_EN POWER_BUS Product Specific I2C_SCL I2C_SDA eMMC - 4200 N1500C GPIO_064 AL8 SDC2_CLK NC GPIO_065 AH10 SDC2_CMD NC KYPD_PWR_N SLEEP_CLK MCLK_D1_MSM DTV_DATA[23:0] RESOUT_1V8_N HW_SERVICE MCLK_D1_MSM SLEEP_CLK SLEEP_CLK WL1271_FEM FM_ANTENNA P2_WLAN&BT WCF_I2S_SCLK WCF_I2S_WS WCF_I2S_DATA WCF_I2S_SCLK WCF_I2S_WS WCF_I2S_DATA WCF_I2S_SCLK WCF_I2S_WS WCF_I2S_DATA HPH_LP AUXO C4_System&Debug DTV_DATA[23:0] XO_OUT_A1_EN DTV_DATA[23:0] P8_HDMI GPIO_112 AN4 SDC2_D[7] NC GPIO_113 AL6 SDC2_D[6] NC POWER_BUS GPIO_114 POWER_BUS AM6 SDC2_D[5] NC GPIO_115 AL5 SDC2_D[4] NC RESOUT_1V8_N HW_SERVICE RESOUT_1V8_N HW_SERVICE C5_Memories GPIO_066 AJ9 SDC2_D[3] NC GPIO_067 AN6 SDC2_D[2] NC GPIO_068 FM_ANTENNA AUXO HPH_LP GPIO_133 MCLK_A0_RF POWER_BUS MSM8255-0 1238-9813 POWER_BUS S U B _ R E W O P S U B _ R E W O P GND_CDC_REF GND_CDC_REF POWER_BUS POWER_BUS MCLK_A0_RF GND_CDC_REF PA_R0 PA_R1 PA_R0 PA_R1 POWER_BUS PA_R0 PA_R1 TX_DCS1800_PCS1900 C6_RF_Power_Asics TX_GSM850_EGSM900 TX_DCS1800_PCS1900 TX_GSM850_EGSM900 TX_DCS1800_PCS1900 TX_GSM850_EGSM900 POWER_BUS TRX_UC_B2_BC3 TRX_UC_B1_BC6 TRX_UC_B5_B8_BC0 POWER_BUS WL1271_FEM WL1271_FEM POWER_BUS P3_Audio FM_ANTENNA N1600 PM8058_USER KYPD_DRV_N R1 HPH_LP AUXO GPIO_069 AM7 SDC2_D[1] NC AJ10 SDC2_D[0] NC AE1 EMMC_VDDF_EN NC Product Specific NC LED_DRV0_N LED_DRV1_N POWER_BUS PM8058 1226-6567_2 LED_DRV2_N T11 T9 R9 NC NC NC TRX_UC_B2_BC3 TRX_UC_B1_BC6 TRX_UC_B5_B8_BC0 TRX_UC_B2_BC3 TRX_UC_B1_BC6 TRX_UC_B5_B8_BC0 POWER_BUS I2C_SCL POWER_BUS PA_ON_GSMHB PA_ON_GSMLB C7_RF_Power_Amps C8_RF_Ant_Switch&Signal P1_GPS_Diversity I2C_SDA SCL_GSB_CAM SDA_GSB_CAM P6_Optics SCL_GSB_CAM SDA_GSB_CAM POWER_BUS SCL_GSB_CAM SDA_GSB_CAM GND pins & pads 1 X1009 1238-5878 X1011 1238-5878 X1012 1238-5878 1 1 1 1 1 1 1 1 E1006 1 1 1240-8715 X1014 1238-5878 1 X1013 1238-5878 1 I2C_SCL I2C_SDA Shield cans E1000 Clamp GND 1 E1003 Clamp GND PA_ON_GSMHB PA_ON_GSMLB GSM_TX_MASK PA_ON_GSMHB PA_ON_GSMLB GSM_TX_MASK 1 P7_Camera 1 1 X1008 1238-5878 X1006 1238-5878 X1007 1238-5878 1 1 X1010 1238-5861 1 1 1240-5765 E1001 1 Clamp GND

File name DocumentDispatch_(Test and Calibration)_006.pdf

Test & Calibration - electrical - XperiaTM active ST17i, ST17a 1249-2435 Rev 2 Sony Ericsson Mobile Communications AB ­ Company Internal Test and Calibration Repair Instruction Electrical/ CONTENTS 1 Go/NoGo Testing ... 3 1.1 Antenna Coupler ... 3 1.2 Direct Line ... 4 1.3 Attenuation Factors ... 6 1.3.1 1.3.2 Loss Values ­ Antenna Coupler ... 6 Loss Values ­ Direct Line in Box ... 7 2 SERP Calibration ... 8 2.1 Calibration Setup ... 8 2.2 Calibration Procedure ... 9 2.2.1 Test Program (ETS) Flashing ... 9 2.2.2 Calibration Instructions ... 9 2.2.3 Re-Customization ... 9 3 Revision History ... 10 This product is ONLY implemented in SERP II 1249-2435 Rev 2 Sony Ericsson Mobile Communications AB ­ Company Internal 2(10) Test and Calibration Repair Instruction Electrical/ 1 Go/NoGo Testing This Go/NoGo testing has to be carried out in two ways, with an: · Antenna Coupler. · Cable in shield box. For more information on Antenna Coupler and Cable in shield box testing, refer to 1220-1336: Generic Repair Manual ­ electrical, section `Setup Go/NoGo Test'! For part no's on the equipment below, refer to the `Tools Catalogue/Matrix'! 1.1 Antenna Coupler The following equipment has to be used: · Rohde & Schwartz RF Shield Package - Rohde & Schwartz RF Shield Box - Rohde & Schwartz RF Coupler - Grid Positioning Holder · RF Test Cable Flexible 1M · RF Adapter for RF Shield Box · USIM Card, instrument specific GSM-850/900/1800/1900 WCDMA-850/900/1900/2100 Put the grid positioning holder with its reference point in position D7 and place the phone as shown in the adjacent picture. Please be aware that the antenna is mounted on the Cover Battery. There is two different version of the Cover Battery, one for ST17i and one for ST17a. 1249-2435 Rev 2 Sony Ericsson Mobile Communications AB ­ Company Internal 3(10) Test and Calibration Repair Instruction Electrical/ Go/NoGo Testing 1.2 Direct Line The following equipment has to be used: · RF Test Cable Flexible 1M and support sleeve · A Test Inner Fra

File name DocumentDispatch_(Test Instruction)_001.pdf

Test Instructions - mechanical - XperiaTM active ST17i, ST17a 1249-2430 Rev 6 Sony Ericsson Mobile Communications AB ­ Company Internal Test Instruction (mech) CONTENTS 1 Pre-Test Preparations ... 4 1.1 Process flow ­ Water Resistant Test (WRT) for incoming units ... 4 1.2 Hardware... 5 1.2.1 1.3.1 Water indicator inspection... 5 Software update ... 6 1.3 Software ... 6 2 Tests ... 7 2.1 Service Test Mode ... 7 2.2 Service Tests ... 8 2.2.1 2.2.2 2.2.3 2.2.4 2.2.5 2.2.6 2.2.7 2.2.8 2.2.9 2.2.10 2.2.11 2.2.12 2.2.13 2.2.14 2.2.15 2.2.16 2.2.17 2.2.18 2.2.19 2.2.20 2.2.21 2.2.22 2.2.23 2.2.24 2.2.25 2.2.26 2.2.27 2.2.28 2.2.29 2.2.30 2.2.31 2.2.32 2.2.33 2.2.34 Keyboard & Switch ... 8 Touch Screen ... 8 Display ... 8 LED/Illumination ... 9 Speaker... 9 Stereo speaker ... 9 Earphone ... 10 Microphone ... 10 Secondary Microphone ... 10 Vibrator ... 11 Camera ... 11 Secondary Camera ... 11 Flash LED ... 12 Bluetooth ... 12 WLAN ...

File name DocumentDispatch_(Trouble Shooting Guide)_004.pdf

Troubleshooting Guide - mechanical - XperiaTM active ST17i, ST17a 1249-2433 Rev 5 Sony Ericsson Mobile Communications AB ­ Company Internal Trouble Shooting Guide (mech) CONTENTS 1 Problem Areas ... 4 1.1 Power ... 4 1.1.1 1.2.1 1.2.2 1.2.3 1.2.4 1.3.1 1.4.1 1.5.1 1.5.2 1.6.1 1.7.1 1.8.1 1.8.2 1.8.3 1.9.1 Will not power on or will switch off randomly... 4 Back, Home and Menu Keys ... 5 Camera Key ... 5 Volume Key ... 7 On/Off key ... 8 Touch Screen malfunction... 11 Graphics & Illumination ... 12 LED / Illumination ... 13 Key Illumination ... 14 Loudspeaker ... 15 Earphone ... 17 Microphone ... 18 Acoustic feedback in Earspeaker or Loudspeaker ... 19 Secondary Microphone ... 20 Vibrator not generating alerts ... 22 1.2 Keys ... 5 1.3 Touch Screen ... 11 1.4 Display ... 12 1.5 LED / Illumination ... 13 1.6 Speaker ... 15 1.7 Earphone ... 17 1.8 Microphone ... 18 1.9 Vibrator ... 22 1.10 Camera ...

File name DocumentDispatch_(Trouble Shooting Guide)_009.pdf

Troubleshooting Guide - electrical - XperiaTM active ST17i, ST17a 1249-2436 Rev 2 Sony Ericsson Mobile Communications AB ­ Company Internal CONTENTS 1.1 1.2 1.3 1.4 1.5 1.6 1.7 1.8 1.9 1.10 1.11 1.12 Troubleshooting Guide (elec) 1 Troubleshooting Flow ... 3 2 Revision History ... 10 For general information about electrical repair related issues, refer to 1220-1336: Generic Repair Manual - electrical Display & Touch ... 3 Illumination ... 3 Keys & Sensors ... 4 Alert ... 4 Audio ... 5 On/Off ... 6 Charging & Capacity ... 7 SIM ... 7 Camera ... 7 Data Communication ... 8 Memory Card... 8 Network & Signal ... 9 1249-2436 Rev 2 Sony Ericsson Mobile Communications AB ­ Company Internal 2(10) 1 1.1 Troubleshooting Flow Display & Touch vision check all pins Troubleshooting Guide (elec) Symptom: Display problem Replace: X7002, if damaged 1.2 Illumination Symptom: No Display illumination Replace: X7002, if damaged vision check pin 19, 23 and 25 L7600 or L7610, if more than 1 C7603, if short circuit V7601 N7600 Symptom: No Key Back Light Replace: X5303, if damaged N7600 Symptom: No RGB LED Replace: V5107 N7600 Symptom: No Flash LED Replace: L7801, if more than 1 vision check pin A7-A8 1249-2436 Rev 2 Sony Ericsson Mobile Communications AB ­ Company Internal 3(10) Troubleshooting Flow Troubleshooting Guide (elec) 1.3 Keys & Sensors Symptom: On / Off key problems Replace: R5205, if more than 2.5 k S5207 Symptom: Back Key, Home Key, Menu Key and Display Touch Sensor problems Replace: X5303, if damaged vision check pin B1-B9 Symptom: Camera key problems Replace: R5203 or R5204, if more than 2.5 k S5205 Symptom: Volume Up key problems Replace: R5200 or R5201, if more than 2.5 k S5203 Symptom: Volume Down key problems Replace: R5206 or R5207, if more th

File name DocumentDispatch_(Working Instruction)_002.pdf

Working Instructions - mechanical - XperiaTM active ST17i, ST17a 1249-2431 Rev 11 Sony Ericsson Mobile Communications AB ­ Company Internal Working Instruction (mech) CONTENTS 1 2 3 Exterior Views ... 4 1.1 ST17i, ST17a ... 4 Tools ... 5 Disassembly... 6 3.1 3.2 3.3 3.4 3.5 Cover Back ... 6 Cover Battery... 7 Inner Frame ... 8 Main PBA ... 9 LCD Support & Cover Front ... 11 4 Replacement ... 12 4.1 Cover Back ... 12 4.2 Cover Battery... 12 4.3 Inner Frame ... 12 4.4 LCD Support ... 12 4.5 Cover Front ... 13 4.6 Adhesive 3 x 6 ... 14 4.7 Adhesive 7,8 x 1,4 ... 16 4.8 Adhesive Irregular ... 17 4.9 Foil Adhesive for front flex ... 19 4.10 Audio Jack ... 20 4.11 Camera 5 MPixel... 21 4.12 Cap Audio ... 23 4.13 Cap USB... 25 4.14 Co-Brand... 27 4.15 Cushion 5 x 2 ... 28 4.16 Cushion 7 x 7 ... 29 4.17 Cushion Earspeaker...