Text preview for : Alpine-CDM9807RB carrec.pdf part of Alpine CDM9807RB car radio
Back to : Alpine-CDM9807RB carrec.p | Home
SERVICE MANUAL
FM/MW/LW/RDS Compact Disc Receiver
TO ALPINE Home Page
3 / 03-A 68E35111S01
CDM-9807RB
The following cautions will prevent accidents in the workplace and will ensure safe products. *The symbols indicate caution is needed to prevent injuries and damage to property. The symbols and their meanings follow. If you ignore this symbol and handle the product incorrectly or unsafely, serious injury or death may result. If you ignore this symbol and handle the product incorrectly or unsafely, injury or only material damage may result.
Warning Caution
*The following symbols indicate two levels of cautions. When you see this symbol, you have to be very careful.
When you see this symbol, you have to follow the instructions there.
Warning
Do not look squarely into the laser light coming from the pickup.
You may loose you sight.
Fuse Caution
Always use a designated fuse. Use of an incorrect fuse may result in a fire.
Caution
Do not allow wiring to be caught in the screw/chassis.
If wiring is caught in the screw/chassis, it may cause a short circuit, resulting in a fire.
Battery Caution
Use the designated battery. Confirm the correct polarity and seat of the battery. An incorrect battery or an improperly connected or seated battery may result in a fire.
High Temperature Caution
Touching the heat sink may cause severe burns.
Designated Parts Caution
Look up the part list and ensure that only designated parts are used to prevent problems or accidents.
Reverse Power Supply Connections or Misconnections Caution
Reverse power supply connections or misconnections may cause ignition problems and smoke may result.
Wiring Caution
Ensure that the wiring is correct when rewiring to prevent problems with ignition/breakdown.
Soldering Caution
Hot solder from solder splash may cause severe burns.
Wear Gloves
Wear gloves to prevent electrical shocks or injury from the end face of the metal.
Contents Packing Assembly Parts List Packing Method View Specifications Extension Cable Adjustment Procedures Block Diagram Parts Layout on P.W.Boards and Wiring Schematic Diagram Terminal Voltage of IC/ TR Description of IC Terminal Exploded View (Cabinet) Exploded View (CD Deck Mechanism) (DP23S2AO)
Cabinet Assembly Parts List CD Deck Mechanism Assembly Parts List Electrical Parts List
NOTE : Due to continuing product improvement, specifications and designs are subject to change without notice.
Packing Assembly Parts List
Symbol No.
101-1 101-2 101-3 102
Part No.
03S72235F13 36A11113W01 03A11112W01 15D00529K02
Description
SCR,MCH M5X8 FLAT CAP,RUBBER(A) BOLT,HEX.M5(A) CASE,INNER
Symbol No.
103 104 105
Part No.
15D01798K01 01T35536Y08 68P02294K52
Description
CARRYING,CASE ASSY,WIRE ISO 9807R O/M AOEU AODN
Packing Method View
101
-1
101
-2
X4
BO TT SID OM E
X1
105
101 104 101
-3
X1
103 102
X1
BO TT SID OM E
103
102 X1
104
X1
TO CONTENTS
Specifications
Intermediate Frequency ................................................................................................................................ 10.7MHz Frequency Range ............................................................................................................................ 87.5 to 108.0MHz Usable Sensitivity (30 S/N, Mono, at 98.1MHz) .............................................................................................. 20.2dBf -3dB Limiting Sensitivity (at 98.1MHz) ............................................................................................................ 20.2dBf Residual Noise (Ref. 400Hz, at 98.1MHz) ..................................................................................................... 25±10dB S/N Ratio (at 98.1MHz) ......................................................................................................................... Stereo : 50dB Mono : 55dB Image Rejection (at 106.1MHz) .......................................................................................................................... 40dB IF Rejection (at 90.1MHz) ................................................................................................................................... 60dB Distortion (Input 60dBu, at 98.1MHz) .................................................................................................................. 1.0% Frequency Response (Ref. 400Hz, at 98.1MHz) ................................................................................. 100Hz : 0±3dB 10kHz : -12±3dB Stereo Separation (1kHz, at 98.1MHz) ............................................................................................................... 20dB PS Sensitivity (at 98.1MHz) ............................................................................................................................ 36.2dBf
(European Model Only)
Intermediate Frequency ........................................................................................................................ 1st : 10.7MHz 2nd : 450kHz Frequency Range .............................................................................................................................. 531 to 1,602kHz Usable Sensitivity (20dB S/N, at 999kHz) ........................................................................................................... 34dB S/N Ratio (at 999kHz) ......................................................................................................................................... 44dB Image Rejection (at 603kHz) ............................................................................................................................... 40dB IF Rejection (at 603kHz) ..................................................................................................................................... 50dB Distortion (at 999kHz) .......................................................................................................................................... 1.5% Frequency Response (Ref. 400Hz, at 999kHz) .................................................................................. 100Hz : -3±4dB 4kHz : -12+4, -8dB
(General Foreign Model Only)
........................................................................................................................ 1st : 10.7MHz 2nd : 450kHz Frequency Range .............................................................................................................................. 531 to 1,602kHz Usable Sensitivity (20dB S/N, at 999kHz) ........................................................................................................... 34dB S/N Ratio (at 999kHz) ......................................................................................................................................... 44dB Image Rejection (at 603kHz) ............................................................................................................................... 40dB IF Rejection (at 603kHz) ..................................................................................................................................... 50dB Distortion (at 999kHz) .......................................................................................................................................... 1.5% Frequency Response (Ref. 400Hz, at 999kHz) .................................................................................. 100Hz : -3±4dB 4kHz : -12+4, -8dB Intermediate Frequency
TO CONTENTS
(European Model Only)
Intermediate Frequency ........................................................................................................................ 1st : 10.7MHz 2nd : 450kHz Frequency Range .................................................................................................................................. 153 to 281kHz Usable Sensitivity (20dB S/N, at 216kHz) ........................................................................................................... 38dB S/N Ratio (at 216kHz) ......................................................................................................................................... 45dB Image Rejection (at 270kHz) ............................................................................................................................... 40dB IF Rejection (at 162kHz) ..................................................................................................................................... 50dB Distortion (at 216kHz) .......................................................................................................................................... 1.5% Frequency Response (Ref. 400Hz, at 216kHz) .................................................................................. 100Hz : -3±4dB 4kHz : -12+4, -8dB
System ....................................................................................................................... Optical (Compact Disc System) Channel Balance (1kHz) ................................................................................................................................... 0±3dB Distortion (1kHz) .................................................................................................................................................. 0.1% Frequency Response (Ref. 1kHz) ......................................................................................................... 17Hz : 0±3dB 127Hz : 0±2dB 10.007kHz : 0±2dB 19.997kHz : 0±4dB S/N Ratio ............................................................................................................................................................. 95dB Separation (1kHz) ............................................................................................................................................... 55dB De-Emphasis (Ref. 1kHz) ................................................................................................................... 4kHz : -20±3dB 16kHz : -20±3dB
Wave Length .................................................................................................................................................... 795nm Laser Power ................................................................................................................................................... CLASS I
Power Supply ................................................................................................................................................ DC14.4V Power Output (Ref. CD Mode, SP-OUT, T.H.D. 10%) /Impedance ...................................................... 25W/ch/4ohm Pre Output (Ref. TCD-782(1KHz, 0dB), T.H.D. 1%) /Impedance ................ FRONT/REAR : 4V±2.5dBV/ch/10kohm SUB-W(STEP+15) : 4V±2.5dBV/ch/10kohm Dimensions (W x H x D) ................................................................................................ Chassis : 178 x 50 x 160mm Nose : 188 x 58 x 27mm Weight ................................................................................................................................................................. 1.5kg
NOTE : Due to Continuing product improvement, specifications and designs are subject to change without notice.
TO CONTENTS
Extension Cable
* When repairing or measuring the voltage of this unit, connect with the Extension Cable as shown in below.
TO CONTENTS
Adjustment Procedures
1. FM/AM SECTION
(1) Dummy Antenna Circuit
(2) Connections
(3) Control Settings Power Switch Fader Control Balance Control Treble Control Bass Contro .............................................. ON ........................... Center Position ....................... Center Position .......................... Center Position ............................. Center Position Band Switch Band Switch LOUD SUB-W Others ....................... FM/MW/LW(#1) ............................... FM/AM($1)
.................................................... OFF .................................................. OFF ................................................... OFF
NOTE: #1 : For European Model Only, $1 : For General Foreign Model Only, Others : Common.
TO CONTENTS
(4) Adjustment Procedures
Test Point / P.W.Board Coordinates TP002 (3-F) TP608 (5-D)
Step
Description
Connection
Signal Generator
Dial Control
Adjustment
(1)
87.5MHz , 26dBµ (Mod. OFF)
87.5MHz
Auto Adjustment : After setting up of Signal Genarator, short GND and TP608 (Pull-Down) for 1 seconds. Proceed same Auto Adjustment of step (1) under step (2). (SPEC) TP002 : 1.5±0.1V OK (SPEC) TP002 : others 1.5±0.1V NG NOTE : NG : Proceed same Auto Adjustment of step (1) under step (3).
(2) 1 Signal Meter Auto Adjustment (FM) Figure 3
87.5MHz , 26dBµ (Mod. OFF)
87.5MHz
TP002 (3-F) TP608 (5-D)
(3)
87.5MHz , 21~23dBµ (Mod. OFF)
87.5MHz
TP002 (3-F) TP608 (5-D) TP002 (3-F) TP608 (5-D) TP002 (3-F) TP608 (5-D)
Proceed same Auto Adjustment of step (1) under step (3).
(4)
87.5MHz , 26dBµ (Mod. OFF)
87.5MHz
Proceed same Auto Adjustment of step (1) under step (4).
(1)
999kHz , 34dBµ (Mod. OFF)
999kHz
Auto Adjustment : After setting up of Signal Genarator, short GND and TP608 (Pull-Down) for 1 seconds. Proceed same Auto Adjustment of step (1) under step (2). (SPEC) TP002 : 1.0±0.1V OK (SPEC) TP002 : others 1.0±0.1V NG NOTE : NG : Proceed same Auto Adjustment of step (1) under step (3).
2
Signal Meter Auto Adjustment (#1 MW) ($1 AM)
(2) Figure 4
999kHz , 34dBµ (Mod. OFF)
999kHz
TP002 (3-F) TP608 (5-D)
(3)
999kHz , 29~31dBµ (Mod. OFF)
999kHz
TP002 (3-F) TP608 (5-D) TP002 (3-F) TP608 (5-D)
Proceed same Auto Adjustment of step (1) under step (3).
(4)
999kHz , 34dBµ (Mod. OFF)
999kHz
Proceed same Auto Adjustment of step (1) under step (4).
NOTE: #1 : For European Model Only, $1 : For General Foreign Model Only, Others : Common.
TO CONTENTS
Step
Description
Connection
Signal Generator
Dial Control
Test Point / P.W.Board Coordinates TP002 (3-F) TP608 (5-D)
Adjustment
(1)
216kHz , 34dBµ (Mod. OFF)
216kHz
Auto Adjustment : After setting up of Signal Genarator, short GND and TP608 (Pull-Down) for 1 seconds. Proceed same Auto Adjustment of step (1) under step (2). (SPEC) TP002 : 1.0±0.1V OK (SPEC) TP002 : others 1.0±0.1V NG NOTE : NG : Proceed same Auto Adjustment of step (1) under step (3).
3
#1 Signal Meter Auto Adjustment (LW)
(2) Figure 4
216kHz , 34dBµ (Mod. OFF)
216kHz
TP002 (3-F) TP608 (5-D)
(3)
216kHz , 29~31dBµ (Mod. OFF)
216kHz
TP002 (3-F) TP608 (5-D) TP002 (3-F) TP608 (5-D)
Proceed same Auto Adjustment of step (1) under step (3).
(4)
216kHz , 34dBµ (Mod. OFF)
216kHz
Proceed same Auto Adjustment of step (1) under step (4).
NOTE: #1 : For European Model Only.
TO CONTENTS
Block Diagram
MINI BUS IN
ANT001
MB4R002Z Tuner unit DP23S2AO Servo +B
FM AM LPF CD I²C Selector Vol. 1
DIN001 EL VOL (TDA7412)
PRE-OUT
Tre/Bass
Vol. 2
PRE-OUT
MUTE
RCA201
SUB-W
MUTE
F
JK201
RDS DECODER
MUTE
PRE-OUT
R
TUNER+B
-8.5V REG. Mute Driver Front
POWER IC
MINI Bus I/F
CB801
Main u-Com
System Reset BAT Det
Rear
POWER ON+B
BATT
ST-REMO
Acc Det ACC
P.ANT O.REM
P-ANT O-REM
LCD Driver
Key Matrix LCD401
Rotary Encoder
Remote Control
TO CONTENTS
100k
TH602 R877
47k
22k
R635
R658
R610
N.U.
100k
1.8k-F
R648
Q601 DTA124EKA R630 22k D601 1SS133 Q612 DTC124EKA 1000p C662 Q610 DTC124EKA C610 R631 22k-1/4 R632 220-1/4
R606 1k
R878
R685
R637 R627 N.U. TP605 TP606 N.U.
R601 R602 C601 N.U.
N.U. TH601 N.U. 100k
N.U.
1.5k-F
C628 R638
0.1 N.U.
R833
TP601 TP602 TP603 R622 N.U.
R607 10k 1k
R604 22k Q664 DTA143EKA D662 DAN202K
CB802 53253-0210
Q867 2SD1994A
C806 0.1
C805 0.1
M802 MOTOR, F2510CT-12UCV
R882 470-1/4
Q866 FMC2
R642
1k R664 47k-1/4
EB12
10/16
ZD804 HZS9C2L
IC601 D784216AGF
TP604 C609 18p XL601 12.288MHz
R641
R686 2.2k
22k-1/4
IC6551
TDA3606AT
18p R663 22k
C651
R656
L600 4.7uH
R651 56k
C608
N.U.
330p
330k R657 120kF
L602 4.7uH R600
R618 0 1k R624 1k R623 R643 270 270 R634 1k R619 1k R620
R691 1k
TP609
TP610
TP600
R683 R684 R617 R666 R668 R667 R613
R625 R626
10k 10k TP608
C602 0.022
R636 47k-1/4
R674 3.9k-F 0.1-B [C652 S080930CNMC C605 47k R676 2.7k-1/4
R675 10k-F R629 47k
Q652 FMC2
ZD652 HZS7B2L
R654 4.7k-1/4 R655 4.7k-1/4
1000p
C501
R639
R640 470k
TP650
1SS133
D653
C653
E602 220/10
0
R644
SW601 SKHHLW
R879 22k
R670 22k
R671 22k
R672 1k
TP651
C611 E601 22/16
0.022
R880 N.U.
R605 47k
Q605 JK601 JAC, CK-3 5-14 DTC114EKA Q606 2SA1037AK C607 0.01 R673 10k Q604 FMC3
R609 12-2W R647 4.7k R660 R646 4.7k 10k-1/4 R659 10k-1/4 ZD803 HZS9C2L R803 100k E805 Q603 UN2212 E604 10/16 R808 820-1/4 1/50 Q807 2SD1994A R881 N.U.
R633
100p
D602 DAN202k R628 R612 100-1/4 2200p C603 C606 0.1
3.3k
2.2k
Q611 DTC114EKA
Q607 DTC114EKA
TP652
0.047-B
C604
0.1
C652
R611
4.7k-1/4
Q651
FMC2
0.47-B
1k
1k 1k 0 0 0 1k
C618
47k
0.022-B
1k 1k 1k
1k
C612
TP653 R615 R616 R614 R621 R649 R650 22k R681 1k 22k
R608 10k
R682 1k
CB601 BTB, TMD-VF15X-A1
R680 N.U.
TO P. W. Board
TO PARTS LIST
E651 Q865 FMC2
R662 12k
33/16
TO CONTENTS
L200 R629 120k
1mH MA740 SD201 [C200 MAX829EUK E205 E203 47/25 1 C224 47/25 N.U. 22 22 1
L201 1mH 120k 22/16 E206
D200 N.U.
E201 22/16
C222
R272
L202 1mH
R270 N.U.
C221
E200 22/16
C226
C225
R271
C223
22
N.U.
IC301
STK475-010
ZD304 ZSH5MA27A
E301 IC201 N.U. 2500/20 1000/25 820k-1/4 10/16 1-B 1-B 1-B 470/16 1-B 1-B N.U.
R300 360k-1/4
E302
C300
R301
C302
R201 R200 24k C200 1u R261 E207 R262 10/16 R202 0 0
N.U.
N.U. Z600 R344 N.U. 2.2/50 E311 N.U. 3300/16 0.047 E305 E306 N.U. E307 E308 10/16 C307 10/16 C308 10/16 C309 0.22-TF 0.22-TF 0.22-TF 0.22-TF N.U. TP804 TP802 TP803 CB801 WTB, F169B001-16 1.8k-1/4 10k-1/4 0.1-TF R820 D802 MPG06G R839 C804 C800 C801 C802 0.022 10k-1/4 C803 0.01 0.01 0.01 R836 1k-1/4 Q809 DTC143EKA DIN001 DIN, SKT 8P CMS-R TP801 R310 N.U. IC201 N.U.
E209 E210
1/50 1/50
E208
E304
C303 C304 C305
C301
10/16 C310
R263 0 R264 0
1/50 1/50 R205 6.8k
R203 N.U.
R302 47k
1/50 1/50
E211 E212 E213 E214 C201 0.12-B
IC202 TDA7412
IC203 N.U.
R307 10k-1/4
R308 0
R309 220
E309
R204
N.U. IC203 N.U. Q300 DTC124EKA E312 1/50
N.U.
1/50
N.U. E218 22/16
C204 0.1k-B R206 2.2k
R207 39k
R208 C205 470k 100p
E217
C206 N.U.
C314
1000p
C311
C202 0.1k-B C203
E215
1u
E310 10/16
IC302 TB2901H
E300
C306 0.1
C312 L603 CHOKE
D306 Q201 DTC124EKA D307 C207 0.068 D308 10/16
N.U. SRT14 N.U.
R209
1k 1k
C313 N.U.
SD600 P300G
R210
PS001 R800 D800 1SS133 100-1/4
PTGL05BA1R8M1
R801 Q801 2SB1243 24k-1/4 R826 Q803 N.U. R830 N.U. N.U. R802 N.U. R831 N.U. R832 N.U. D801 N.U. R838 E811
Q802 2SB1243
R828
R834 1.8k-1/4
E810
47/16
1.6k-1/4 R825
1.6k-1/4 R824
1.5k-1/4 R827
1.5k-1/4
100/10
R837 10k
ZD802 HZS6BF1L
E806 220/10
ZD800 HZS9C1L
E801
E808 100/16
E807
E804 1/50
R821
33/16
E803 N.U.
Q804 FMC2
E809
R807 5.6k-1/4
R822 510-1/4
R823
Q806 N.U.
Q805 DTC143XKA
N.U.
Q810 DTC124EKA
R840 N.U.
R829 N.U.
620k
R835
Q808 2SD1994A
100/16
Q800 2SC3421
N.U.
R833 24k
TO P. W. Board
E313
D305
N.U.
D313 N.U. D314 N.U. D315 N.U. D316 SRT14
E216 10/16
TO PARTS LIST
TO CONTENTS
JK201 ASSY, CONN NLT1661 Z301 BL02RN1R2P1A
TP201 TP203
R218
N.U. C208 R230 R224 18k IC204 BA4560F 10p-CH 22k Z302 BLO2RN1R2P1A E226 1/50 R236 100 R244 TP202 R250 100 47k
TP204 TP205
E220 1/50
CB201 53253-0310 TP206 TP207
RCA201 ASSY, WIRE RCA 9807R
E232 2.2/50
R213
R212
R213
68k
Q202 DTC343TK
68k
R245
E221 1/50
IC204 BA4560F R225 18k
E233 2.2/50 R237 100
47K R251 1000P N.U. N.U. N.U. N.U. C214 C219 N.U. C215 C216 C217 C218 C219 N.U. C220 100 R252 100 R253 100 R254 100
E227 1/50
Q203 DTC343TK
R219 N.U.
R231 C209
22k 10p-CH
R220
N.U. C210 R232 R226 18k 10p-CH 22k
E222 1/50
E228 1/50 IC205 BA4560F
E234 2.2/50
R238 100 R246 47k R239 100 R249 47k R248 47k R247 47k
R214
Q204 DTC343TK
R215
68k
E223 1/50
68k
IC205 BA4560F
E229 1/50
Q205 DTC343TK E235
R227 18k R233 R221 N.U. C211 22k 10p-CH
2.2/50
R222
N.U. C212 R234 R228 18k 10p-CH 22k E230 100/16 IC206 BA4560F
E224 1/50
E236 2.2/50
R240 100
R216
Q206 DTC343TK
R217
68k
68k
E225 1/50
IC206 BA4560F
E231 100/16
Q207 DTC343TK E237
R229 18k R235 C213 22k 10p-CH
2.2/50
R241 100
R255 100
R223
N.U.
TO P. W. Board
TO PARTS LIST
TO CONTENTS
TU002 MB4R002Z FM/AM UNIT R047 10-1/4 L003 15uH TP002 R040 R035 L005 L002 4.7uH
R038 R039 C089 C091 C094 470
470
L004
C090
52mH
1k R027
1k
10k R041 1000p 4.7uH R042 22k 0 047 10k
D002 1PS226
0.01-B
ANT001 ASSY, ANT CABLE ISO
CF002 LPF11830KH
SA002 DSP-201M
0 01-B R032 C079 R028 C080 C081 E013 E014 E015 R024 R023 R025 1k C098 N.U. 0 0 01-B 0 01-B 0 01-B 220/10 22/16 22/16 C099 1k R030 N.U.
R045 N.U.
C001 C095 R043 0.1-B 10
1000P
0 0
0
R044 0-1/4 IC012 NJM2904M R021 1k 1k R036 R029 1k R017 3.3k FMC3 Q075 Q074 2SA1037AK C002 N.U. R037 N.U. E017 22/16 C076 330p R026 0 IC013 TC7S66F C092 0.022 0.022 C082 E016 22/16 C073 2.2/50 2200p C074 100p Q077 FMC3 R046 R022 0 C075 0.1 C096 100p C083 180p E018 10/25-TA C093 0.022-B R033 2.2kF R031 13kF IC011 BA00AST C085 27p R034 N.U. E019 220/16 C086 C087 C097 N.U. 100p 100p C072 0.1 XL002 4.332MHz XL002 E012 2.2/50 C077 0.022 10 C071 560p R018 C078 C084 R019 N.U. 27p 470k 2200p 0 0 IC010 SAA6588T R006 R005 R020 4.7k 1k 1k R004 0 R003 0 R015 R013 R014 R050 5.6k 5.6k
TO P. W. Board TO PARTS LIST
TO CONTENTS
CH101 SLW22R-1C7
R103 750-1/4
C101
3300p
R104 C103 N.U.
750-1/4 C115 3300p
TP101
TP100
C116
R108
E100
470/10
0.022
68k
TO P. W. Board
TO PARTS LIST
TO CONTENTS
LCD401 LCD.WTD-21544AEHU
IC401 C406 0.047-B
PT6583LQ C407 0.047-B R423 R424 R425 R426 R427 R428 R429 R430 R421 R422
SW421 ENC, EC11B15243 1k 1k 1k 1k 1k 1k 1k 1k 1k 1k C404 R407 SW401 SW404 C405 0.047-B 820p 47k SW422 SW407 SW406 SW402 SW405 SW410 SW408 ZD401 RD6.2MB3 R419 4.7k R420 SW414 SW413 SW412 SW420 SW418 SW419 MA159 D416 D415 MA159 SW416 MA159 D417 IC402 RS-671 R447 N.U. 4.7 C408 4.7 100k R406 1PS226 R446 100 SW411
R402 R403 R404 R405 R406
1k 1k 1k 1k 1k
R476 1.2k
Q451 2SD1328 R477 R487 160-1/4 PL454 N.U. 180-1/4 PL451 N.U. LD465 BG1111C LD467 BG1111C LD471 BG1111C LD473 LD469
LD481 LB1111C LD463
LD480 DB1111C
R451 680-1/4
R480 680-1/4
D401 1PS226 LD451 DB1111C DB1111C R486 R485 N.U. N.U. R454 PL453 N.U. LD464 BG1111C LD466 BG1111C LD470 PL452 N.U. LD452 BG1111C LD453 N.U. R452 680-1/4 R481 680-1/4 R453 N.U. 1PS226 D404 1PS226 D405 1PS226 R456 220-1/4 R458 BG1111C 220-1/4 LD455 BG1111C BG1111C LD472 LD458 R462 220-1/4 R464 BG1111C BG1111C BG1111C 220-1/4 LD458 BG1111C BG1111C R482 270-1/4 R483 LD474 LD457 LD459 DB1111C LD482 AA1111C DB1111C N.U. 680-1/4 R484 560-1/4 R455 220-1/4 R457 220-1/4 R461 220-1/4 D402 1PS226 D403
R463 220-1/4 R465 270-1/4
R466 680-1/4 R467 620-1/4 R469 330-1/4 R468 330-1/4 C409 0.022
ZD451
MAZS180 C410 0.022 LD461 LD478 NSCWS405T NSCWS405T R474 120-1/4 R472 56-1/4
ZD452 LD479 NSCWS405T
MAZS180 LD462 NSCWS405T R475 120-1/4 R473 56-1/4
TO P. W. Board TO PARTS LIST
R401 24k
R414 24k
R408 R409 R410 R411 R412 R413 10k 1k 10k 10k 10k 1k CH401 BTB, TMD-V15P-A1
TO CONTENTS
TP409
TP411
TP412
TP413
TP414
TP410
R434 100 R435 100 C322 TP401 TP402 TP403 TP404 C323 0.1 R406 10k R407 10k C448 N.U. R405 15k C447 N.U. TP331 C326 0.22 R404 39k TP323 E407 10/16 C308 0.1
R436 100
TP415
R437 100 C320 0.1
TP416
0.033 0.1 R324 39k R323 10k TP322 TP321 TP320 TP319
R345 33k R344 33k TP318 R343 33k
CB103 52207-0790
TP325
C312
C324 C325 3900p
0.1
TP316 C327 22p-CH R325 7.5k 1.5p-CH N.U. N.U. IC301 TP311 TP315
TP417
TP418 TP419
IC401
BA5984FP
C328 R338
TP329 R301 10-1/4 E301 47/5 5
R339 E303 10/16-T R302 10-1/4 2SB1132 Q301 TP423 C302 0.1 C409
0.1
TP330 CB102 52207-1590
D401 MA159 E329 560p-CH C450 R410 R409 10k 10k R411 22/10-T 22k C347 N.U.
HD101 PICKUP, EP21A67L
TP420 TP421 TP422
C449 150p-CH R334 J R333 J R408 22k C305 0.1 C304 0 022
C330 56p-CH TP326 R335 N.U. R336 N.U. TP327 C331 39p-CH TP328 C332 0.1
UPD63711A
TP306
ASSY, MTR SPINDOL 2BO
M102 ASSY, MOTOR SLED 2BO
C306 R332 J 0.1
TP305
M103
C319 0.1
IC302 AN80M50RSPE1
R331 J
R402 100
R401 E310 10/16-T 100k
C310 0.1
E331 2.2/16-T
TP406
E338 10/16-T
TP407
E337 47/5.5
C336
E333 10/16
C334 TP301
R403 27k
TP424
TP425
TP426
TP405
TP408
R341 J
0.1
C345 1000p
C311 SW1 SPVG23 SW3 SPVG21 SW4 SPVG23 SW2 SPVG13
0.01
C318 0.01
C340 N.U. R342 N.U. E316 47/5.5 22/6.3 E317 CL301 16.9MHz C341 22p-CH
R312 N.U.
TP226 TP227 TP228 TP229 TP230
TP225
Q401 DTC124EUA
R260 R261 R262 47k
47k 47k R259 47k
TP215
TP212 TP213 TP214
RA201 100x4
RA202 100x4
47k
47k 47k 47k
47k 47k 47k 47k 47k
R311 J
R250
R251 R250
R253
R254 R255 R256 R257 R258
TP210 TP211 R226 33k
TP206
R316 220 2200p C314 CB101 52207-2290
C315
TP217 TP218 TP219 TP220 TP221 TP222 TP223 TP216 R212 100
IC201 D789026GB
2200p
C246 0.1
TP209 R229 47k TP208
TP302
0.1
C346 1000p
TP119
C238 0.1 R228 10k C241 0.01
R247 N.U.
R317 220 C240 0.1
TP303
E239 47/5.5
R270 33k
47k 47k 47k 47k
R246 CL201 J 4.19MHz TP207
R230
100
M101 ASSY, MOTOR WORM 2BO TP206
R263 R264 R265 R266
R201 47k
R202 47k
R203 47k
TP201
TP202 TP203 TP204 TP205
TO P. W. Board
TP101 TP102 TP103 TP104 TP105 TP106 TP107 TP108 TP109 TP110 TP111 TP112 TP113 TP114 TP115 TP116 TP117 TP118
TO PARTS LIST
TO CONTENTS
Terminal Voltage of IC/TR
IC010 1 2 3 4 5 0.1 0 0 2.4 2.1 6 7 8 9 10 0 4.8 4.8 4.8 4.3 11 12 13 14 15 NC 0 2.4 4.7 0 16 17 18 19 20 2.3 2.3 2.4 2.3 2.3 1 2 3 4 5 IC011 4.8 14.2 0 8.5 1.2
IC012 1 2 3 4 5 6 7 8 0.1 0.1 0.1 0 0.1 0.1 0.1 8.5 1 2 3 4 5
IC013 3.1 3.1 0 4.9 4.8 1 2 3 4 5 6 7 8 9.8 0 0.6 0 1.3 14 14 9.8
IC101
at CD mode
1 2 3 4 5
IC200 -4.6 5.1 -2.2 0 2.6
IC202 1 2 3 4 5 6 7 8 9 10 11 4.4 4.4 NC NC NC NC 4.4 4.4 4.4 4.4 4.4 12 13 14 15 16 17 18 19 20 21 22 4.4 4.4 4.4 0.1 5.0 NC 3.6 0 0.5 0.5 8.9 23 24 25 26 27 28 29 30 31 32 33 NC NC 4.4 4.4 4.4 4.4 4.4 4.4 NC NC NC 34 35 36 37 38 39 40 41 42 43 44 NC 4.4 4.4 4.4 4.4 4.4 4.4 NC NC NC NC
IC204 1 2 3 4 5 6 7 8 0 0 0 -8.9 0 0 0 8.9 1 2 3 4 5 6 7 8
IC205 0 0 0 -8.9 0 0 0 8.9 1 2 3 4 5 6 7 8
IC206 0 0 0 -8.9 0 0 0 8.9
IC301 1 2 3 4 5 6 0 0.53 NC 16.5 16.5 16.5 7 8 9 10 11 12 0 0 14 14 14 14
at CD MODE, VOL Over-20
at CD MODE, VOL Over-20
TO SCHEMATIC
TO CONTENTS
IC302 1 2 3 4 5 6 7 0 0 6.7 4.9 6.6 13.7 6.7 8 9 10 11 12 13 0 6.7 8.2 3.4 3.3 0 14 15 16 17 18 19 3.4 3.3 3.5 6.7 0 6.7 20 21 22 23 24 25 13.8 6.6 8.5 6.7 0 NC
IC401 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.3 2.3 2.3 2.4 2.3 2.3 2.3 2.3 2.3 2.3 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 2.3 2.3 2.4 2.3 2.4 2.3 2.3 2.3 2.4 2.4 2.4 2.4 2.4 2.3 2.3 2.3 2.4 2.4 2.4 2.4 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.3 2.3 2.3 2.3 2.3 2.3 2.3 2.4 4.8 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 4.8 4.8 4.8 4.8 0 0 0 0 0 4.8 3.1 1.5 0 0 3.8 4.5 4.8 0.7 0.2 1.3
IC402 1 2 3 4 4.7 0 0 1.8
IC601-1 1 2 3 4 5 6 7 8 9 10 0.2 4.5 4.9 1.3 0.7 0.2 4.8 NC 4.9 4.9 11 12 13 14 15 16 17 18 19 20 4.9 4.9/0 4.8 4.8/0 0 NC 4.6 0 4.1 NC B.OUT OFF/ON DIMM OFF/ON
TO SCHEMATIC
TO CONTENTS
IC601-2 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 NC 0 4.8 4.8 4.2 4.7 0 0 4.9 NC 0 0/4.8 0/4.9 4.9 0/4.9 4.7 4.9 2.6 1 0 NC 0 4.7 4.9 4.9 NC 4.7 0 4.5 0 4.9 4.9 4.7 0.1 2.6 0 0.1 2.6 4.8 4.7 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 0 NC NC 4.9 4.8 4.9 0 0 0 0 NC NC NC NC NC 0.1 3.9 NC 4.8/0 4.8 4.9 0 NC 0 4.9 4.7/0.9 NC NC NC NC NC NC NC NC NC NC NC NC 4.9 0
TUNER/CD TUNER/CD TUNER/CD
FM/AM
DIMM OFF/ON
IC651 1 2 3 4 5 6 7 8 9 10 0 0 0 3.8 4.8 2.7 0 0 0 0 11 12 13 14 15 16 17 18 19 20 0 0 0 NC NC 4.9 14.2 0 0 0 1 2 3 4 5
IC652 4.9 4.9 0 NC 0
TO SCHEMATIC
TO CONTENTS
PIN NO Q075 Q077 Q112 Q604 Q651 Q652 Q804 Q865 Q866
1 NC NC NC NC NC NC NC NC NC
2 8.3/1.7 4.8 0.1/14 4.8 4.9 4.9 0/14 14.0 -0.2
3 8.5/8.5 4.9 14.0 4.9 4.9 4.9 14 14.0 14.0
4 4.8/0 8.5 0/4.5 4.9 4.8 6.0 0/4.5 4.9 0
5 0/0 0 0 0 0 0 0 0 0
NOTE FM/AM RADIO/CD
A-MUTE OFF/ON
PIN NO Q074 Q111 Q201 Q202 Q203 Q204 Q205 Q206 Q207 Q300 Q451 Q601 Q603 Q605 Q606 Q607 Q610 Q611 Q612 Q664 Q800 Q801 Q802 Q805 Q807 Q808 Q809 Q810 Q867
E 8.5/8.4 14.1 0 0 0 0 0 0 0 0 0/0 4.9 0/0 0 4.3/4.8 0 0 0 0 4.9 8.9 14.0 13.9 0 8.8/0.1 5.2 0 0 0
C 2.2/8.4 0/7.4 3.6 0 0 0 0 0 0 8.7/0 0/4.7 0 4.9/0 3.9/4.6 4.7/0 0.6/0 14.2 0 4.9 0 14.2 13.9 13.9 0.1 14.2/13.9 14.2 0 0/4.9 14.2
B 8.3/7.7 14.1/13.6 0 14/0 14/0 14/0 14/0 14/0 14/0 0/4.5 0.7/0 4.9 0/10 0.3/0 4.8 1.3/1.6 0 2.7 0 4.9 9.6 13.2 13.3 4.8 9.5/0 5.8 4.7 4.9/0 -0.2
NOTE FM/AM RADIO/CD MUTE ON/OFF MUTE ON/OFF MUTE ON/OFF MUTE ON/OFF MUTE ON/OFF MUTE ON/OFF IF MUTE OFF/ON DIMM OFF/ON DIMM OFF/ON REMOTE ON/OFF REMOTE ON/OFF REMOTE ON/OFF REMOTE ON
B.OUT OFF/ON
A-MUTE OFF/ON
[Measuring Conditions] 1.Power Supply Voltage 2.Measuring Meter 3.Measuring Point Reference 4.Measuring Condition
: DC14.4V : Digital Multi Meter : Between GND : FM : 98.1MHz AM : 999KHz CD : at playing Disc
TO SCHEMATIC
TO CONTENTS
(CD Deck Mechanism) IC201 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 0 0 0 0 0 5 0 0 0 0 0 0 0 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 0 5 5 5 0 5 0 0 or 5 0-5 5 0-5 0-5 0-5 0 0-5 31 32 33 34 35 36 37 38 39 40 41 42 43 44 0 or 5 0 or 5 0 0-5 0-5 0-5 0 5 0 0-5 0-5 5 5 5
repeat of H to L repeat of H to L repeat of H to L
repeat of H to L repeat of H to L repeat of H to L repeat of H to L repeat of H to L
repeat of H to L repeat of H to L
NOTE : - : indefinite voltage
IC301-1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 0 5 5 0-5 0-5 0-5 0-5 0-5 0 5 5 0 2.5 0 5 NC NC NC NC 5 0 5 NC NC 0-5 0-5 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 0-5 0-5 0-5 0-5 0-5 NC 0 NC 0 5 NC NC NC NC 0 NC NC 0 0 NC 5 NC NC 0 0 0 0 0 0 NC repeat of H to L repeat of H to L repeat of H to L repeat of H to L repeat of H to L
repeat of H to L repeat of H to L repeat of H to L repeat of H to L repeat of H to L
repeat of H to L repeat of H to L
NOTE : - : indefinite voltage
TO SCHEMATIC
TO CONTENTS
IC301-2
61 62 63 64 65 66 67 68 69 70 0 2.5±2.5 2.5±2.5 2.5±2.5 2.5±2.5 NC NC NC NC 5
71 72 73 74 75 76 77 78 79 80
0.5-4.5 2.5 3 RF signal RF signal RF signal RF signal
NC
repeat of H to L
RF signal 2.5
81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100
0 about 2.8 NC about 2.8 NC about 2.9 about 2.9 5 2.5 about 2.5 about 2.5 about 2.5 about 2.5 about 2.5 about 2.5 0 0.17 0 5
NOTE : - : indefinite voltage IC302 1 2 3 4 5 7 7 or 5 0 1.4 5 B C E Q301 3.9 2.4 4.5 E B C Q401 0 0-5 0-2.5 repeat of H tp L repeat of H to L
IC401 1 2 3 4 5 6 7 8 9 10 0 2.5 about 2.5 about 2.5 2.5 about 2.5 about 2.5 7 0 0 11 12 13 14 15 16 17 18 19 20 0 2.5 21 22 23 24 25 26 27 28 5 about 2.5 about 2.5 2.5 about 2.5 about 2.5 2.5 0
NOTE : - : indefinite voltage
[Measuring Conditions] 1. Power Supply Voltage 2. Measuring Meter 3. Measuring Point Reference 4. Measuring Condition
: DC14.4V : Digital Multi Voltmeter : Between GND : at playing disc
TO SCHEMATIC
TO CONTENTS
Description of IC Terminal
D784216AGF : IC601
No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 Vpp SCL SDA RDS SCL RDS SDA E.VOL SCL E.VOL SDA AUTO ADJ NC LCD SEL(PULL-DOWN) CD STBY 0 MUTE-DET CD RST CD CS V-Link SEL VDD X2 X1 GND XT2(NC) XT1(GND) RESET BATT DET ACC DET O I/O O I/O O I/O I O I O O I I I I Flash Memory writing terminal. Serial Clock signal output terminal to TUNER. Serial Data signal input/output terminal to TUNER. RDS Clock output terminal from RDS Decoder (SAA6588T). RDS Data input/output terminal to RDS Decoder (SAA6588T). Serial Clock signal output terminal to E.VOL (TDA7412). Serial Data signal input/output terminal to E.VOL (TDA7412). Auto adjustment control signal input terminal. L : Auto adjustment No connect terminal. Pull-down connect terminal. Stand-by control signal output terminal of Mechanism u-COM. 0-bit MUTE signal input terminal. RESET signal output terminal of Mechanism u-COM. Communication control signal output terminal of Mechanism u-COM. V-Link set up input terminal. Power supply terminal. Main System Clock OSC input terminal. (12.288MHz) Symbol ENCODER1 ENCODER2 LCD RST LCD DI LCD CE LCD CLK LCD DO NC VDD POWER-IC ON NOSE POWER BL-LCD ON POWER CONT DIMMER 60W CONT NC GAIN SEL V-CONT REMOCON NC O O O O I O O O O I O I O I RESET signal output terminal to LCD Driver (PT6583LQ). Serial Data signal output terminal to LCD Driver (PT6583LQ). Chip Enable signal output terminal to LCD Driver (PT6583LQ). Serial Clock signal output terminal to LCD Driver (PT6583LQ). Serial Data signal input terminal from LCD Driver (PT6583LQ). No connect terminal. Power supply terminal. STBY CONT signal output terminal to Power IC. Power supply control signal output terminal of LCD Driver and Remote Control. Power supply control signal output terminal of LCD back-lighting. Power supply control signal output terminal of Audio and Key lighting. DIMMER input terminal. L : DIMMER ON POWER-IC control signal output terminal for 60W. No connect terminal. Sub-W output GAIN set up input terminal. Power supply control signal output terminal of Servo/Mechanism. Remote Control Data input terminal. No connect terminal. I/O I Encoder Data input terminal. Terminal Description
GND connect terminal.
No connect terminal.
GND connect terminal.
System RESET signal input terminal. BATT detect signal input terminal. (Compulsion Stand-by) ACC (IGNITION) detect signal input terminal.
TO SCHEMATIC
TO CONTENTS
No. 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68
Symbol NC CHG BUS IN CHG BUS OUT DISC IN SW CD SRQ AVDD AVREF 0 HI-TEMP NOSE ON S-METER MULTIPATH ADJCH AFC T-SENS 45W/60W SEL AVSS NC AVREF 1 RDS MONI RxD RDS MONI TxD FAN-CONT CD STS (RXD1)
I/O I O I I I I I I I I I I I O O I O O No connect terminal.
Terminal Description
Signal input terminal from CD CHANGER BUS I/F. Signal output terminal to CD CHANGER BUS I/F. DISC insert detect SW input terminal. Communication request signal input terminal from Mechanism u-COM. Analog power supply terminal of A/D Converter. Standard voltage input terminal of A/D Converter. Temperature sensor signal (Thermistor) input terminal for CD. FRONT Panel detect signal input terminal. Signal Meter input terminal. Multipath rejection detect terminal of receiving station. Adjoining channel signal input terminal. AFC signal input terminal. POWER-IC temperature measurement input terminal. 45W/60W set up input terminal. GND terminal of A/D Converter. No connect terminal. Standard voltage input terminal of A/D Converter. Serial Data input terminal from RDS Monitor Soft (P/C). Serial Data output terminal to RDS Monitor Soft (P/C). FAN control signal output terminal. H : FAN ON, L : FAN OFF Status signal input termminal from Mechanism u-COM. (Flash-Pro II connect terminal by UART format.) Command output terminal to Mechanism u-COM. (Flash-Pro II connect terminal by UART format.) Serial Clock output terminal to Mechanism u-COM. (Flash-Pro II connect terminal by UART format.) No connect terminal.
69
CD CMD (TXD1)
70 71 I 75 76 77 78 79 80 81 82 83 84 85 86 87 I 98 99 100
CD SCK (ASCK1) NC
AM SD SSTOP NC FM/AM DAVN RDS CONT IF MUTE ENCODER SEL(NC) IN-INT OUT REM ON(NC) DIMMER OUT NC
I I O I O O I O -
AM SD signal input terminal. Seek Stop signal input terminal of TUNER. No connect terminal. FM/AM power switching signal output terminal. (H : FM, L : AM) Available input terminal of RDS Decoder (SAA6588T). MPX MUTE signal output terminal to RDS Decoder (SAA6588T) at FM adjoining rejection. High Speed MUTE signal output terminal at AF SW. No connect terminal. Outernal AUDIO signal input terminal. No connect terminal. DIMMER signal output terminal. No connect terminal.
A-MUTE GND
O -
AUDIO MUTE signal output terminal. (L : MUTE ON) GND connect terminal.
TO SCHEMATIC
TO CONTENTS
D789026GB : IC201 (DP23S2A0)
No. 1 2 3 4 5 6 7 I 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 VPP X2 X1 VSS0 VDD0 /RESET S-CONT NC(GND) SW-A NC(GND) L-ZERO /CS /STBY CMD STS SCK NC(GND) /SRQ R-ZERO ZMUTE /XTALEN SI SO /SCK NC(GND) VDD1 VSS1 /STB AO /RST RFOK LIMIT SW I O I I I I I O I O I O O O I O O O O I I GND connect terminal. VDD connect terminal. Host I/F RESET signal input terminal. Servo power supply control output terminal. GND connect terminal. SW-A input terminal for mechanism control. GND connect terminal. DSP L-ch 0 data signal input terminal. Host I/F communication start/end signal input terminal. Host I/F STBY signal input terminal. Host I/F command input terminal. Host I/F status output terminal. Clock input terminal for Host I/F communication. GND connect terminal. Host I/F status request signal output terminal. DSP R-ch 0 data signal input terminal. Host I/F 0 data signal output terminal. DSP crystal OSC control output terminal. DSP serial data output terminal. DSP serial data/status signal input terminal. Clock output terminal for DSP serial data. GND connect terminal. VDD connect terminal. GND connect terminal. DSP data strobe signal output terminal. DSP command/parameter discrimination signal output terminal. DSP RESET signal output terminal. DSP RFOK signal input terminal. LIMIT-SW input terminal. Pull-down connect terminal. Crystal OSC connect terminal. (4.19MHz) NC(GND) GND connect terminal. Symbol SW-D SW-C SW-B LODMLODM+ DR MUTE O Driver IC Mute control output terminal. I/O I I I O Terminal Description SW-D input terminal for mechanism control. SW-C input terminal for mechanism control. SW-B input terminal for mechanism control. Loading Motor control output terminal.
TO SCHEMATIC
TO CONTENTS
Exploded View (Cabinet)
6 X2
17
17 X2
17
A
RCA201
F
2
18
ANT001
27 20
19 8
G
1 SW421 12 31 28 34 32 CH401 12 29 15 27 CB801 JK201
C F
6 14 9 X4
D E
30
12 X2 9 X2
D
13
35
E
DIN001
B
M802
33
LCD401
23 CB601 16 4
G
24 24 JK601 22 25
5 6
6
C
A
10 7
B
6
3
11
6
TO PARTS LIST
TO CONTENTS
67 X2 31 65
(DP23S2AO)
8 33 41 6 32
B
30 78
P
2
5 3 6 4 23 X3 39 34
42 81
40
38 37 7
L
62 36
Exploded View (CD Deck Mechanism)
D
1 75 72 M102 22
N D K
M103
L P
19
27 45
SW105
67 21 29 53
C
28
HD101
20
66
64 79 88 87 86 83 85 84 82 13 12 89 49
G E F
64
52
J G
29 68
M
24
A
43 44 47 48
25 63 26 X2
59
F J A
51 61
E K
67 X2 10 X2 54
46 50
L
67 9 11 67 55
M N B L H
M101
C
57
SW4 SW3 SW1 SW2
91
H
TO PARTS LIST
56
58 69
60
77 X2 74
TO CONTENTS
90
CDM-9807RB
Cabinet Assembly Parts List
Note : The part that has not PART NUMBER will not be supplied. 1 01V64600Y32 ASSY,NOSE UNIT 07RM 2 - - - - - - - - - - - COVER,TOP 3 - - - - - - - - - - - CHAS,BASE 4 14B02859K01 INSULATOR,MAIN 5 13C02811K01 NOSE,BASE ASSY 6 03S44205G29 SCR,T-TITE M2.6X6 7 33C01797K03 FACE,PLATE 8 - - - - - - - - - - - HEAT,SINK(SW) 9 03S38013W02 SCR,T-TITE M2.6X14 10 07D00749K01 BKT,SIDE L 11 07D00749K02 BKT,SIDE R 12 03T25225Y01 SCR,GND 13 03S68555F30 SCR,WAVE M2.6X10 14 03S71677F05 SCR,T-TITE-B M3X8 15 75T25010Y33 CUSHION,SHLD5-5.5-25 16 41A03685K01 SPRING,SHIELD 17 03S44205G07 SCR,T-TITE M2.6X5 18 81D50617Y01 DP23S2AO,CD MECH 19 30T03013K03 SMCD22X120BDX6(BL)M 20 75S40755Y78 CUS,RUB 11X5XT4.5 22 - - - - - - - - - - - BKT,CHAS REAR(SW) 23 77B50886Y01 MB4R002Z FM/AM UNIT(TU002) 24 09T84840F01 LUG,STYLE 18MM 25 14S50096Y69 INS,CVR 40X17.5XT0.3 27 03S71677F56 SCR,B-TITE M1.7X12 28 13C02846K03 NOSE,PIECE ASSY(L) 29 13D02810K02 NOSE,BOTTOM 30 36B02841K02 KNOB,ROTARY ASSY 31 75S40755Y94 CUS,RUB 10X2XT3 32 15B01768K01 COVER,LCD 33 26A41975Y01 REFLECTOR,SHEET 34 75T03213K02 RUBBER,ELECTRIC 35 15D01770K01 CASE,LCD ASSY
CDM-9807RB
CD Deck Mechanism Assembly Parts List
Note:The part that has not PART NUMBER will not be supplied. 1 2 3 4 5 6 7 8 9 10 11 12 13 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 01V43800Y84 ----------45B11564Y02 45B11595Y02 45B11596Y02 41B11613Y16 15D50248Y01 75A21286Y04 07C50608Y01 03S40014G07 44B11578Y02 44B11579Y02 44B11580Y02 27D11602Y04 47A11575Y01 01V28100Y59 44A70590W03 03S72235F96 07B30337Y02 41A11606Y02 03S94385F18 84T01803K01 41B11566Y02 03S70494F13 --------------------07A11565Y02 03S94385F01 43A41812Y02 ----------45A11599Y02 41B11613Y03 41B11613Y05 41A11609Y01 41B40574Y02 41B11613Y15 41A11040Y02 03S70494F52 43A21240Y01 ----------45B40510Y02 44B40527Y02 45A11601Y02 44B11581Y02 45B11594Y02 45A11592Y02 03A11574Y01 45B11591Y02 07A50606Y01 45B11593Y02 45B11607Y02 45A11597Y02 41B11613Y04 75C30466Y04 41B11613Y06 ASSY,ARM GUIDE 280 CHASSIS,TOP LEVER,LINK-TOP LEVER DISC(R) LEVER,DISC(L) SPRING,PULL GUIDE,TOP-DPS2 CUSHION,CLAMPER DPS2 BKT,MOTOR LOAD-P SCR,MCH M2X4 GEAR,(A) GEAR,(B) GEAR,(C) CHASSIS,PICKUP SHAFT,PICK ASSY,SHAFT.SCREW GEAR,MIDDLE SCR,MCH M1.7X3.5(SW) BKT,SPRING NUT SPRING NUT SCR,NYLON M2X3.5 PANEL,FPC CONT SPRING,SHAFT SCR,P-TITE M2X6 BLK ASSY,RIV.ARM CLAMP LEVER,LOCK PLATE,CLAMP SCR,NYLOK M1.7X2.3 TABLE,CLAMPER2 SLIDER DISC LEVER,ACTUATOR SPRING,PULL SPRING,LEV-ACT SPRING,LEVER SPRING,PLATE-S SPRING,PULL SPRING,SLED-HOE SCR,P-TITE M1.4X4.5 SHEET,FPC PICK ASSY,RIV CHAS BASE SLIDER,LOAD RACK LEVER,TRIGER GEAR,(D) SLIDER,LOCK(L) ARM,LOCK(L2) SCREW,LOCK ARM,LOCK(L1) BKT,MOTOR WIRE-P SLIDER,LOCK(R) ARM,LOCK(R) LEVER,SW SPRING,TRIGER DAMPER,DPS2 SPRING,PULL 62 41B11613Y07 63 64 65 66 67 68 69 72 74 75 77 78 79 81 82 83 84 85 86 87 88 89 90 91 41B11613Y08 41A40518Y01 41A31894Y02 ----------03A21791Y01 07B20905Y02 30T15126W15 41A21613Y02 14A30831Y01 43A31443Y01 75C30466Y05 41B11613Y14 04B41345P52 75A21286Y02 44B40523Y02 04A40528Y01 44A40524Y02 41A40529Y01 44A40525Y02 15A40526Y02 43A41446Y02 04B41345P25 03S44205G99 75A21286Y05 SPRING,PULL SPRING,PULL SPRING,ROL SPRING,SLIDER BKT,SP-TOP SCREW,M2X3.5 S-TITE BKT,FPC CONT WIRE,PC JOINT 7P SPRING,SPINDLE INS,CVR ROLLER,ARM DISC (C) DAMPER,DPS2 SPLING,PULL WASH,1.6X3.5X0.25 CUSHION,CLAMPER BACK GEAR,BASE WASHER,FELT GEAR,CLUTCH SPRING,CLUTCH GEAR,PINION HOLDER,CLUTCH SLEEVE,CLUTCH WASH,L. 3.1X6X0.35 SCR,T-TITE M2X3 CUSHION,PWB
CDM-9807RB
Electrical Parts List
*******MAIN P.W.Board =======IC's IC010 IC011 IC012 IC013 IC101 IC200 IC202 IC204 IC205 IC206 IC301 IC302 IC601 IC651 IC652 =======Diodes D002 48T85357W01 D307 48T02162K01 D316 48T02162K01 D601 48T68828F01 D602 48T63462F01 D653 48T68828F01 D662 48T63462F01 D800 48T68828F01 D802 48T85270W01 SD100 48T85269W01 SD201 48T95294W01 SD600 48T85268W01 ZD304 48T25064Y02 ZD652 48T83128F14 ZD800 48T83128F25 ZD802 48T83128F04 ZD803 48T83128F26 ZD804 48T25766W25 =======Coils L002 L003 L004 L005 L101 L200 L201 L202 L600 L602 L603 DIO,1PS226 -CP DIO,SHT SRT14 -A5 DIO,SHT SRT14 -A5 DIO,1SS133 -A5 DIO,CP.DAN202K -96 DIO,1SS133 -A5 DIO,CP.DAN202K -96 DIO,1SS133 -A5 DIO,MPG06G -A5 DIO,SHT SB040 -A5 DIO,SHT MA740-TX -CP DIO,P300G DIO,ZEN ZSH5MA27A-ED DIO,ZEN HZS 7B2L -A5 DIO,ZEN.HZS 9C1L -A5 DIO,ZEN.HZS 6B1L -A5 DIO,ZEN.HZS 9C2L -A5 DIO,ZEN.HZS 9C2L -R5
51T15132Y02 51T25259Y01 51T93333F01 51T15731W10 51T15510W01 51T65166Y01 51T65381Y01 51T15420Y01 51T15420Y01 51T15420Y01 51T15426Y02 51T65184Y01 51T65272Y01 51T95193W01 51T65016Y19
SAA6588T-SE9 BA00AST -IS NJM2904M-TE3 -SE2 TC7S66F-TE85L -CP IC ,MC34063AML -SPD MAX829EUK-CP TDA7412 -QT BA4560F-E2-SE2 BA4560F-E2-SE2 BA4560F-E2-SE2 STK475-010 -IB TB2901H -ZS IC,D784216AGF-532-QT TDA3606AT -SE9 S-80930CNMC-T2 -CP
=======Transistors Q074 48T63420F01 Q075 48T73888F13 Q077 48T73888F13 Q111 48T15511W02 Q112 48T73888F12 Q201 48T62967F03 Q202 48T62967F33 Q203 48T62967F33 Q204 48T62967F33 Q205 48T62967F33 Q206 48T62967F33 Q207 48T62967F33 Q300 48T62967F03 Q601 48T62966F03 Q603 48T64222F02 Q604 48T73888F13 Q605 48T62967F02 Q606 48T63420F01 Q607 48T62967F02 Q610 48T62967F03 Q611 48T62967F02 Q612 48T62967F03 Q651 48T73888F12 Q652 48T73888F12 Q664 48T62966F01 Q800 48T69176F02 Q801 48T84366F04 Q802 48T84366F04 Q804 48T73888F12 Q805 48T62967F05 Q807 48T93828F04 Q808 48T93828F04 Q809 48T62967F01 Q810 48T62967F03 Q865 48T73888F12 Q866 48T73888F12 Q867 48T93828F04
TR,2SA1037AK-146 -CP TR ,CP FMC3-99 TR ,CP FMC3-99 CP.2SB1261-TE2 -E5 TR ,CP.FMC2-99 TR,DTC124EKA-T146-CP TR,DTC343TK-T146 -CP TR,DTC343TK-T146 -CP TR,DTC343TK-T146 -CP TR,DTC343TK-T146 -CP TR,DTC343TK-T146 -CP TR,DTC343TK-T146 -CP TR,DTC124EKA-T146-CP TR,DTA124EKA-T146-CP TR ,UN2212 22-22 -TX TR ,CP FMC3-99 TR,DTC114EKA-T146-CP TR,2SA1037AK-146 -CP TR,DTC114EKA-T146-CP TR,DTC124EKA-T146-CP TR,DTC114EKA-T146-CP TR,DTC124EKA-T146-CP TR ,CP.FMC2-99 TR ,CP.FMC2-99 TR,DTA143EKA-T146-CP TR ,2SC3421-Y TR,2SB1243-QR-TV2-RD TR,2SB1243-QR-TV2-RD TR ,CP.FMC2-99 TR,DTC143XKA-T146-CP TR,2SD1994A-S-TA -RD TR,2SD1994A-S-TA -RD TR,DTC143EKA-T146-CP TR,DTC124EKA-T146-CP TR ,CP.FMC2-99 TR ,CP.FMC2-99 TR,2SD1994A-S-TA -RD
24T25164Y21 24T16403W29 24T35286Y01 24T25164Y21 24T16271W13 24T95293W25 24T95293W25 24T95293W25 24T65053W18 24T65053W18 25T03094K01
IND,FSLM2520 4R7J-CP COI,IND.15R-M -CP IND,MG56 523J -DB IND,FSLM2520 4R7J-CP COIL,RCR875D-221K IND,RCH-875 102K + IND,RCH-875 102K + IND,RCH-875 102K + IND,LAL02VD 4R7K -R5 IND,LAL02VD 4R7K -R5 CHOKE,NCT18-451L1-DB
=======Filters CF002 91T75257W02 Z301 24T35072W03 Z302 24T35072W03 =======Crystals XL002 91T25806W18 XL601 91T55360Y03 =======Thermistors TH601 48T93439F06 TH602 48T25250Y01 ######Poly Switch PS001 48T95226W01 =======Surge Absorber SA002 48T81909F01 =======Switch SW601 40T16096W03
LPF,LPF11830KH-3C-DB FBI,BL02RN1R2P1A -R5 FBI,BL02RN1R2P1A -R5
XTL,4.332M -AT51-TP XTL,AT-51 12.288M-R5
TMT, 104 -R2 TMT,ERTJ1VV104J -CP
TMT,PTGL05BA1R8M1-R5
PTT,DSP-201M
-A1
SW ,TACT SKHHLW (RESET)
=======Capacitors C001 08S45677W60
CAP,CER 102J-CH1H-CP
CDM-9807RB
C071 C072 C073 C074 C075 C076 C077 C078 C079 C080 C081 C082 C083 C084 C085 C086 C087 C089 C090 C091 C092 C093 C094 C095 C096 C101 C115 C116 C117 C118 C119 C120 C200 C201 C202 C203 C204 C205 C207 C208 C209 C210 C211 C212 C213 C220 C221 C222 C224 C225 C226 C300 C301 C303 C304 C305 C306 C307 C308 08S45677W54 08S45676W85 08S45676W65 08S45677W36 08S45676W85 08S45677W48 08S45676W80 08S45676W65 08S45676W73 08S45676W73 08S45676W73 08S45676W80 08S45677W42 08S45677W22 08S45677W22 08S45677W36 08S45677W36 08S45677W60 08S45676W89 08S45676W73 08S45676W80 08S45676W80 08S45676W73 08S45676W85 08S45677W36 08S45676W67 08S45676W67 08S45676W80 08S45676W63 08S45677W38 08S60102F48 08S45676W80 08S60102F48 08S45676W74 08S45676W85 08S45677W60 08S45676W85 08S45677W36 08S45676W84 08S45677W12 08S45677W12 08S45677W12 08S45677W12 08S45677W12 08S45677W12 08S45677W60 08T65231Y01 08S60102F48 08T65231Y01 08T65231Y01 08S60102F48 08S60102F48 08S60102F48 08S60102F48 08S60102F48 08S60102F48 08S45676W85 08T35122W17 08T35122W17 CAP,CER 561J-CH1H-CP CAP,CER 104K-B1C -CP CAP,CER.222K-B1H -CP CAP,CER.101J-CH1H-CP CAP,CER 104K-B1C -CP CAP,CER.331J-CH1H-CP CAP,CER 223K-B1E -CP CAP,CER.222K-B1H -CP CAP,CER.103K-B1H -CP CAP,CER.103K-B1H -CP CAP,CER.103K-B1H -CP CAP,CER 223K-B1E -CP CAP,CER.181J-CH1H-CP CAP,CER.27RJ-CH1H-CP CAP,CER.27RJ-CH1H-CP CAP,CER.101J-CH1H-CP CAP,CER.101J-CH1H-CP CAP,CER 102J-CH1H-CP CAP,CER 473K-B1E -CP CAP,CER.103K-B1H -CP CAP,CER 223K-B1E -CP CAP,CER 223K-B1E -CP CAP,CER.103K-B1H -CP CAP,CER 104K-B1C -CP CAP,CER.101J-CH1H-CP CAP,CER.332K-B1H -CP CAP,CER.332K-B1H -CP CAP,CER 223K-B1E -CP CAP,CER 152K-B1H -CP CAP,CER 121J-CH1H-CP CAP,CER 105K-B1E -CP CAP,CER 223K-B1E -CP CAP,CER 105K-B1E -CP CAP,CER 123K-B1H -CP CAP,CER 104K-B1C -CP CAP,CER 102J-CH1H-CP CAP,CER 104K-B1C -CP CAP,CER.101J-CH1H-CP CAP,CER 683K-B1C -CP CAP,CER.10RD-CH1H-CP CAP,CER.10RD-CH1H-CP CAP,CER.10RD-CH1H-CP CAP,CER.10RD-CH1H-CP CAP,CER.10RD-CH1H-CP CAP,CER.10RD-CH1H-CP CAP,CER 102J-CH1H-CP CAP,CER 226K-BJ1A-CP CAP,CER 105K-B1E -CP CAP,CER 226K-BJ1A-CP CAP,CER 226K-BJ1A-CP CAP,CER 105K-B1E -CP CAP,CER 105K-B1E -CP CAP,CER 105K-B1E -CP CAP,CER 105K-B1E -CP CAP,CER 105K-B1E -CP CAP,CER 105K-B1E -CP CAP,CER 104K-B1C -CP CAP,MMTS-224-J -R5 CAP,MMTS-224-J -R5 C309 C310 C312 C314 C501 C602 C603 C604 C605 C606 C607 C608 C609 C610 C611 C612 C618 C628 C652 C653 C662 C800 C801 C802 C803 C804 C805 C806 E012 E013 E014 E015 E016 E017 E018 E019 E100 E101 E200 E201 E203 E205 E206 E207 E209 E210 E211 E212 E213 E214 E216 E217 E218 E220 E221 E222 E223 E224 E225 08T35122W17 08T35122W17 08S45676W89 08S60102F48 08S45677W60 08S65128F78 08S45676W65 08S35374W01 08S65128F90 08S65128F88 08S45676W73 08S45677W18 08S45677W18 08S45677W48 08S45676W80 08S45677W36 08S60102F44 08S45676W85 08S45676W80 08S45676W85 08S45677W60 08S45539Y04 08S45539Y04 08S45676W80 08S45539Y04 08T35122W13 08S35374W01 08S35374W01 23S75373W14 23S75372W03 23S75373W03 23S75373W03 23S75373W03 23S75373W03 23T15765Y88 23S95415W07 23T55378W03 23S75373W06 23S75372W05 23S75372W05 23S75372W22 23S75372W22 23S75372W05 23S75373W02 23S75372W15 23S75372W15 23S75373W13 23S75373W13 23S75373W13 23S75373W13 23S75372W04 23S75372W15 23S75372W05 23S75372W15 23S75372W15 23S75372W15 23S75372W15 23S75372W15 23S75372W15 CAP,MMTS-224-J -R5 CAP,MMTS-224-J -R5 CAP,CER 473K-B1E -CP CAP,CER 105K-B1E -CP CAP,CER 102J-CH1H-CP CAP,CER.223K-B1H -CP CAP,CER.222K-B1H -CP CAP,CER 104K-B1E-CP CAP,CER 473K-B1H -CP CAP,CER 104K-B1H -CP CAP,CER.103K-B1H -CP CAP,CER.18RJ-CH1H-CP CAP,CER.18RJ-CH1H-CP CAP,CER.331J-CH1H-CP CAP,CER 223K-B1E -CP CAP,CER.101J-CH1H-CP CAP,CER 474K-B1E -CP CAP,CER 104K-B1C -CP CAP,CER 223K-B1E -CP CAP,CER 104K-B1C -CP CAP,CER 102J-CH1H-CP CAP,CER 103KX7R2J-CP CAP,CER 103KX7R2J-CP CAP,CER 223K-B1E -CP CAP,CER 103KX7R2J-CP CAP,MMTS-104-J -R5 CAP,CER 104K-B1E-CP CAP,CER 104K-B1E-CP CAP,ELY 2R2-1H -R2 CAP,ELY 221-1A -H2 CAP,ELY 22R-1C -R2 CAP,ELY 22R-1C -R2 CAP,ELY 22R-1C -R2 CAP,ELY 22R-1C -R2 CAP,TAN 10R-1E-E -E1 CAP,ELY 221-1C -R2 CAP,KMG 471-1A -R2 CAP,ELY 101-1C -R2 CAP,ELY 22R-1C -R2 CAP,ELY 22R-1C -R2 CAP,ELY 47R-1E -R2 CAP,ELY 47R-1E -R2 CAP,ELY 22R-1C -R2 CAP,ELY 10R-1C -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 10R-1C -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 22R-1C -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 1R0-1H -R2
CDM-9807RB
E226 E227 E228 E229 E230 E231 E232 E233 E234 E235 E236 E237 E300 E301 E302 E304 E305 E306 E307 E308 E309 E310 E312 E313 E601 E602 E604 E651 E801 E804 E805 E806 E807 E808 E809 E810 E812 23S75373W13 23S75373W13 23S75373W13 23S75373W13 23S75373W06 23S75373W06 23S75372W16 23S75372W16 23S75372W16 23S75372W16 23S75372W16 23S75372W16 23T75427W01 23T75346W04 23T75479W38 23S75372W04 23S75372W04 23S75372W04 23S75372W04 23S75372W04 23S75373W14 23S95415W03 23S95415W17 23T75346W03 23S75372W05 23S75372W03 23S75373W02 23S75373W04 23S75372W02 23S75373W13 23S75372W15 23S75372W03 23S75373W04 23S75373W06 23S75373W06 23S75372W07 23S75372W04 CAP,ELY 1R0-1H -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 101-1C -R2 CAP,ELY 101-1C -R2 CAP,ELY 2R2-1H -R2 CAP,ELY 2R2-1H -R2 CAP,ELY 2R2-1H -R2 CAP,ELY 2R2-1H -R2 CAP,ELY 2R2-1H -R2 CAP,ELY 2R2-1H -R2 CAP,ELY 471-1C -H5 CAP,X-PRO 252-1D + CAP,VZ 102-1E -H5 CAP,ELY 10R-1C -R2 CAP,ELY 10R-1C -R2 CAP,ELY 10R-1C -R2 CAP,ELY 10R-1C -R2 CAP,ELY 10R-1C -R2 CAP,ELY 2R2-1H -R2 CAP,ELY 10R-1C -R2 CAP,ELY 1R0-1H -R2 CAP,X-PRO 332-1C + CAP,ELY 22R-1C -R2 CAP,ELY 221-1A -H2 CAP,ELY 10R-1C -R2 CAP,ELY 33R-1C -R2 CAP,ELY 101-1A -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 1R0-1H -R2 CAP,ELY 221-1A -H2 CAP,ELY 33R-1C -R2 CAP,ELY 101-1C -R2 CAP,ELY 101-1C -R2 CAP,ELY 47R-1C -R2 CAP,ELY 10R-1C -R2 R031 R032 R033 R035 R036 R038 R039 R040 R041 R042 R043 R044 R046 R047 R050 R103 R104 R105 R106 R107 R108 R109 R110 R200 R205 R206 R207 R208 R209 R210 R212 R213 R214 R215 R216 R217 R224 R225 R226 R227 R228 R229 R230 R231 R232 R233 R234 R235 R236 R237 R238 R239 R240 R241 R244 R245 R246 R247 R248 06S15593Y76 06S45675W43 06S15593Y57 06S45674W57 06S45674W57 06S45674W49 06S45674W49 06S45674W57 06S45674W81 06S45674W81 06S45674W09 06S35095Y08 06S45674W09 06S70072F05 06S45674W57 06S70072F50 06S70072F50 06S70072F29 06S70072F47 06S70072F47 06S45675W02 06S35084Y41 06S35084Y33 06S45674W90 06S45674W77 06S45674W65 06S45674W95 06S45675W22 06S45674W57 06S45674W57 06S45675W02 06S45675W02 06S45675W02 06S45675W02 06S45675W02 06S45675W02 06S55365Y95 06S55365Y95 06S55365Y95 06S55365Y95 06S55365Y95 06S55365Y95 06S55365Y97 06S55365Y97 06S55365Y97 06S55365Y97 06S55365Y97 06S55365Y97 06S45674W33 06S45674W33 06S45674W33 06S45674W33 06S45674W33 06S45674W33 06S45674W97 06S45674W97 06S45674W97 06S45674W97 06S45674W97 RES,RK 133F 1/10 -CP RES,RK JUMPER1/10-CP RES,RK 222F 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 471J 1/10 -CP RES,RK 471J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 103J 1/10 -CP RES,RK 103J 1/10 -CP RES,RK 10RJ 1/10 -CP RES,RK JUMPER 1/4-CP RES,RK 10RJ 1/10 -CP RES,CP .10R-J-1/4-CP RES,RK 102J 1/10 -CP RES,CP .751-J-1/4-CP RES,CP .751-J-1/4-CP RES,CP .101-J-1/4-CP RES,CP .561-J-1/4-CP RES,CP .561-J-1/4-CP RES,RK 683J 1/10 -CP RES,RK 223F 1/8 -CP RES,RK 472F 1/8 -CP RES,RK 243J 1/10 -CP RES,RK 682J 1/10 -CP RES,RK 222J 1/10 -CP RES,RK 393J 1/10 -CP RES,RK 474J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 683J 1/10 -CP RES,RK 683J 1/10 -CP RES,RK 683J 1/10 -CP RES,RK 683J 1/10 -CP RES,RK 683J 1/10 -CP RES,RK 683J 1/10 -CP RES,RK 183J 1/10 -CP RES,RK 183J 1/10 -CP RES,RK 183J 1/10 -CP RES,RK 183J 1/10 -CP RES,RK 183J 1/10 -CP RES,RK 183J 1/10 -CP RES,RK 223J 1/10 -CP RES,RK 223J 1/10 -CP RES,RK 223J 1/10 -CP RES,RK 223J 1/10 -CP RES,RK 223J 1/10 -CP RES,RK 223J 1/10 -CP RES,RK 101J 1/10 -CP RES,RK 101J 1/10 -CP RES,RK 101J 1/10 -CP RES,RK 101J 1/10 -CP RES,RK 101J 1/10 -CP RES,RK 101J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 473J 1/10 -CP
=======Resistors R003 06S45675W43 R004 06S45675W43 R005 06S45675W43 R006 06S45675W43 R013 06S45674W75 R014 06S45674W75 R015 06S45674W57 R017 06S45674W69 R018 06S45675W22 R020 06S45674W73 R021 06S45674W57 R022 06S45675W43 R023 06S45675W43 R024 06S45675W43 R025 06S45675W43 R026 06S45675W43 R027 06S45674W89 R028 06S45674W57 R029 06S45674W57 R030 06S45674W57
RES,RK JUMPER1/10-CP RES,RK JUMPER1/10-CP RES,RK JUMPER1/10-CP RES,RK JUMPER1/10-CP RES,RK 562J 1/10 -CP RES,RK 562J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 332J 1/10 -CP RES,RK 474J 1/10 -CP RES,RK 472J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK JUMPER1/10-CP RES,RK JUMPER1/10-CP RES,RK JUMPER1/10-CP RES,RK JUMPER1/10-CP RES,RK JUMPER1/10-CP RES,RK 223J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP
CDM-9807RB
R249 R250 R251 R252 R253 R254 R255 R261 R262 R263 R264 R269 R272 R300 R301 R302 R307 R308 R309 R600 R604 R605 R606 R607 R608 R609 R611 R612 R613 R614 R615 R616 R617 R618 R619 R620 R621 R623 R624 R625 R626 R628 R629 R630 R631 R632 R633 R634 R635 R636 R639 R640 R641 R642 R644 R645 R646 R647 R648 06S45674W97 06S45674W33 06S45674W33 06S45674W33 06S45674W33 06S45674W33 06S45674W33 06S45675W43 06S45675W43 06S45675W43 06S45675W43 06S45675W08 06S45675W08 06S55362Y27 06S55362Y36 06S45674W97 06S70072F77 06S45675W43 06S45674W41 06S45674W97 06S45674W89 06S45674W97 06S45674W57 06S45674W81 06S64995F77 06T45541Y01 06S70072F69 06S70072F29 06S45674W57 06S64995F53 06S64995F53 06S64995F53 06S45674W57 06S45675W43 06S45674W57 06S45674W57 06S64995F53 06S45674W57 06S45674W57 06S45674W81 06S45674W81 06S45674W69 06S45674W97 06S45674W89 06S70072F98 06S70072F37 06S45674W65 06S45674W43 06S45674W97 06S35095Y03 06S45675W43 06S45675W22 06S70072F98 06S45674W57 06S45674W97 06S45674W43 06S45674W73 06S45674W73 06S45674W89 RES,RK 473J 1/10 -CP RES,RK 101J 1/10 -CP RES,RK 101J 1/10 -CP RES,RK 101J 1/10 -CP RES,RK 101J 1/10 -CP RES,RK 101J 1/10 -CP RES,RK 101J 1/10 -CP RES,RK JUMPER1/10-CP RES,RK JUMPER1/10-CP RES,RK JUMPER1/10-CP RES,RK JUMPER1/10-CP RES,RK 124J 1/10 -CP RES,RK 124J 1/10 -CP RES,RK 364J 1/4 -CP RES,RK 824J 1/4 -CP RES,RK 473J 1/10 -CP RES,CP .103-J-1/4-CP RES,RK JUMPER1/10-CP RES,RK 221J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 223J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 103J 1/10 -CP RES,RK 103J 1/8 -CP RES,RS 12RJ 2W RES,CP .472-J-1/4-CP RES,CP .101-J-1/4-CP RES,RK 102J 1/10 -CP RES,RK 102J 1/8 -CP RES,RK 102J 1/8 -CP RES,RK 102J 1/8 -CP RES,RK 102J 1/10 -CP RES,RK JUMPER1/10-CP RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 102J 1/8 -CP RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 103J 1/10 -CP RES,RK 103J 1/10 -CP RES,RK 332J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 223J 1/10 -CP RES,RK 223J 1/4 -CP RES,CP .221-J-1/4-CP RES,RK 222J 1/10 -CP RES,RK 271J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 473J 1/4 -CP RES,RK JUMPER1/10-CP RES,RK 474J 1/10 -CP RES,RK 223J 1/4 -CP RES,RK 102J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 271J 1/10 -CP RES,RK 472J 1/10 -CP RES,RK 472J 1/10 -CP RES,RK 223J 1/10 -CP R649 R650 R651 R654 R655 R656 R657 R658 R659 R660 R662 R663 R664 R666 R667 R668 R670 R671 R672 R673 R674 R675 R676 R681 R682 R683 R684 R686 R691 R800 R803 R807 R808 R820 R821 R822 R823 R824 R825 R826 R827 R833 R834 R835 R836 R837 R838 R839 R877 R878 R879 R882 R883 06S45674W89 06S45674W89 06S45674W99 06S70072F69 06S70072F69 06S64996F14 06S15593Y99 06S45675W06 06S70072F77 06S70072F77 06S45674W83 06S45674W89 06S35095Y03 06S45675W43 06S45675W43 06S45675W43 06S45674W89 06S45674W89 06S45674W57 06S45674W81 06S15593Y63 06S15593Y73 06S70072F63 06S64995F53 06S64995F53 06S45674W57 06S45674W57 06S45674W65 06S55365Y65 06S70072F29 06S45675W06 06S70072F71 06S70072F51 06S70072F77 06S55366Y33 06S70072F46 06S70072F58 06S70072F58 06S70072F57 06S35095Y15 06S70072F57 06S45674W90 06S70072F59 06S70072F59 06S70072F53 06S45674W81 06S45674W81 06S70072F77 06S15593Y55 06S15593Y53 06S45674W89 06S55361Y57 06S45674W57 RES,RK 223J 1/10 -CP RES,RK 223J 1/10 -CP RES,RK 563J 1/10 -CP RES,CP .472-J-1/4-CP RES,CP .472-J-1/4-CP RES,RK 334J 1/8 -CP RES,RK 124F 1/10 -CP RES,RK 104J 1/10 -CP RES,CP .103-J-1/4-CP RES,CP .103-J-1/4-CP RES,RK 123J 1/10 -CP RES,RK 223J 1/10 -CP RES,RK 473J 1/4 -CP RES,RK JUMPER1/10-CP RES,RK JUMPER1/10-CP RES,RK JUMPER1/10-CP RES,RK 223J 1/10 -CP RES,RK 223J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 103J 1/10 -CP RES,RK 392F 1/10 -CP RES,RK 103F 1/10 -CP RES,CP .272-J-1/4-CP RES,RK 102J 1/8 -CP RES,RK 102J 1/8 -CP RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 222J 1/10 -CP RES,RK 102J 1/10 -CP RES,CP .101-J-1/4-CP RES,RK 104J 1/10 -CP RES,CP .562-J-1/4-CP RES,CP .821-J-1/4-CP RES,CP .103-J-1/4-CP RES,RK 624J 1/10 -CP RES,CP .511-J-1/4-CP RES,CF .162-J-1/4-CP RES,CF .162-J-1/4-CP RES,CP .152-J-1/4-CP RES,RK 243J 1/4 -CP RES,CP .152-J-1/4-CP RES,RK 243J 1/10 -CP RES,CP .182-J-1/4-CP RES,CP .182-J-1/4-CP RES,CP .102-J-1/4-CP RES,RK 103J 1/10 -CP RES,RK 103J 1/10 -CP RES,CP .103-J-1/4-CP RES,RK 182F 1/10 -CP RES,RK 152F 1/10 -CP RES,RK 223J 1/10 -CP RES,RK 471J 1/4 -CP RES,RK 102J 1/10 -CP
=======Connectors CB201 09T25436Y03 CB802 09T25436Y02 CH101 09T25684Y22
WTB,53253-0310 -DB WTB,53253-0210 -DB FFC,SLW22R-1C7 -DB
CDM-9807RB
*******FRONT P.W.Board =======IC's IC401 IC402 SW406 51T02347K01 51T55628Y01 PT6583LQ -QT RS-671 -NE2 SW407 SW408 TR ,CP.2SD1328-T -TX SW410 =======Diodes D401 48T85357W01 D402 48T85357W01 D403 48T85357W01 D404 48T85357W01 D405 48T85357W01 D406 48T85357W01 D415 48T81063F01 D416 48T81063F01 D417 48T81063F01 ZD401 48T62934F26 ZD451 48T15541Y23 ZD452 48T15541Y23 =======LED's LD451 48T65176Y02 LD452 48T25534Y01 LD453 48T25534Y01 LD455 48T25534Y01 LD456 48T25534Y01 LD458 48T25534Y01 LD459 48T65176Y02 LD461 48T45280Y01 LD462 48T45280Y01 LD463 48T65176Y02 LD464 48T25534Y01 LD465 48T25534Y01 LD466 48T25534Y01 LD467 48T25534Y01 LD469 48T25534Y01 LD470 48T25534Y01 LD471 48T25534Y01 LD472 48T25534Y01 LD473 48T25534Y01 LD474 48T65176Y02 LD478 48T45280Y01 LD479 48T45280Y01 LD480 48T65176Y02 LD481 48T65176Y02 LD482 48T25534Y03 =======Switches SW401 SW402 SW404 SW405 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 SW,TACT SKRPACE010E2 (FWD/UP) SW,TACT SKRPACE010E2 (BWD/DN) SW,TACT SKRPACE010E2 (5/M.I.X.) SW,TACT SKRPACE010E2 (SOURCE/POWER) DIO,1PS226 -CP DIO,1PS226 -CP DIO,1PS226 -CP DIO,1PS226 -CP DIO,1PS226 -CP DIO,1PS226 -CP DIO,CP.MA159 / TX-CP DIO,CP.MA159 / TX-CP DIO,CP.MA159 / TX-CP DIO,ZEN.RD6.2MB3 -CP DIO,ZEN MAZS180 -CP DIO,ZEN MAZS180 -CP SW411 SW412 SW413 SW414 SW416 SW418 SW419 SW420 LED,BLU DB1111C -CP LED,GRN BG1111C -CP LED,GRN BG1111C -CP LED,GRN BG1111C -CP LED,GRN BG1111C -CP LED,GRN BG1111C -CP LED,BLU DB1111C -CP LED,WHT NSCWS405T-E2 LED,WHT NSCWS405T-E2 LED,BLU DB1111C -CP LED,GRN BG1111C -CP LED,GRN BG1111C -CP LED,GRN BG1111C -CP LED,GRN BG1111C -CP LED,GRN BG1111C -CP LED,GRN BG1111C -CP LED,GRN BG1111C -CP LED,GRN BG1111C -CP LED,GRN BG1111C -CP LED,BLU DB1111C -CP LED,WHT NSCWS405T-E2 LED,WHT NSCWS405T-E2 LED,BLU DB1111C -CP LED,BLU DB1111C -CP LED,AMB AA1111C -CP SW422 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 40T65353Y01 SW,TACT SKRPACE010E2 (1/AF) SW,TACT SKRPACE010E2 (6/SCAN) SW,TACT SKRPACE010E2 (PLAY/PAUSE/TUNE/A.ME) SW,TACT SKRPACE010E2 (2/NEWS) SW,TACT SKRPACE010E2 (F/SETUP) SW,TACT SKRPACE010E2 (T.INFO) SW,TACT SKRPACE010E2 (3/PTY) SW,TACT SKRPACE010E2 (MUTE) SW,TACT SKRPACE010E2 (BAND) SW,TACT SKRPACE010E2 (4/REPEAT) SW,TACT SKRPACE010E2 (EJECT) SW,TACT SKRPACE010E2 (DISP/B.OUT) SW,TACT SKRPACE010E2 (CENTER f)
=======Transistor Q451 48T63788F04
=======Capacitors C404 08S45677W58 C405 08S45676W89 C406 08S45676W89 C407 08S45676W89 C408 08T81833F08 C409 08S45676W80 C410 08S45676W80 =======Resistors R401 06S64995F86 R402 06S45674W57 R403 06S45674W57 R404 06S45674W57 R405 06S45674W57 R406 06S45674W57 R407 06S45674W97 R408 06S64995F53 R409 06S64995F77 R410 06S64995F77 R411 06S64995F77 R412 06S64995F53 R413 06S64995F77 R414 06S64995F86 R419 06S45674W73 R420 06S45675W06 R421 06S45674W57 R422 06S45674W57 R423 06S45674W57 R424 06S45674W57 R425 06S45674W57 R426 06S45674W57 R427 06S45674W57
CAP,CER 821J-CH1H-CP CAP,CER 473K-B1E -CP CAP,CER 473K-B1E -CP CAP,CER 473K-B1E -CP CAP,CER 475K-B1A -CP CAP,CER 223K-B1E -CP CAP,CER 223K-B1E -CP
RES,RK 243J 1/8 -CP RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 473J 1/10 -CP RES,RK 102J 1/8 -CP RES,RK 103J 1/8 -CP RES,RK 103J 1/8 -CP RES,RK 103J 1/8 -CP RES,RK 102J 1/8 -CP RES,RK 103J 1/8 -CP RES,RK 243J 1/8 -CP RES,RK 472J 1/10 -CP RES,RK 104J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP
CDM-9807RB
R428 R429 R430 R446 R451 R452 R455 R456 R457 R458 R461 R462 R463 R464 R465 R466 R467 R468 R469 R472 R473 R474 R475 R476 R477 R480 R481 R482 R483 R484 R487 06S45674W57 06S45674W57 06S45674W57 06S45674W33 06S70072F49 06S70072F49 06S70072F36 06S70072F37 06S70072F37 06S70072F37 06S70072F36 06S70072F37 06S70072F36 06S70072F37 06S70072F39 06S70072F49 06S70072F48 06S70072F41 06S70072F41 06S70072F23 06S70072F23 06S70072F31 06S70072F31 06S64995F55 06S70072F35 06S70072F49 06S70072F49 06S70072F39 06S70072F49 06S70072F47 06S70072F34 RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 102J 1/10 -CP RES,RK 101J 1/10 -CP RES,CP .681-J-1/4-CP RES,CP .681-J-1/4-CP RES,CP .201-J-1/4-CP RES,CP .221-J-1/4-CP RES,CP .221-J-1/4-CP RES,CP .221-J-1/4-CP RES,CP .201-J-1/4-CP RES,CP .221-J-1/4-CP RES,CP .201-J-1/4-CP RES,CP .221-J-1/4-CP RES,CP .271-J-1/4-CP RES,CP .681-J-1/4-CP RES,CP .621-J-1/4-CP RES,CP .331-J-1/4-CP RES,CP .331-J-1/4-CP RES,CP .56R-J-1/4-CP RES,CP .56R-J-1/4-CP RES,CP .121-J-1/4-CP RES,CP .121-J-1/4-CP RES,RK 122J 1/8 -CP RES,CP .181-J-1/4-CP RES,CP .681-J-1/4-CP RES,CP .681-J-1/4-CP RES,CP .271-J-1/4-CP RES,CP .681-J-1/4-CP RES,CP .561-J-1/4-CP RES,CP .161-J-1/4-CP C308 C310 C311 C314 C315 C318 C319 C320 C321 C322 C323 C324 C325 C326 C327 C328 C330 C331 C332 C334 C336 C341 C345 C346 C409 C449 C450 E239 E301 E303 E310 E316 E317 E329 E331 E333 E337 E338 E407 08S45676W85 08S45676W85 08S45676W73 08S45676W65 08S45676W65 08S45676W73 08S45676W85 08S45676W85 08S45676W85 08S45676W87 08S45676W85 08S45676W85 08S45676W68 08S45676W93 08S45677W20 08S45677W03 08S45677W30 08S45677W26 08S45676W85 08S45676W85 08S45676W85 08S45677W20 08S45677W60 08S45677W60 08S45676W85 08S45677W40 08S45677W54 23T45152Y02 23T45152Y02 23S55311W35 23S55311W35 23T45152Y02 23T45152Y03 23S55311W28 23S55311W31 23T45152Y04 23T45152Y02 23S55311W35 23T45152Y04 CAP,CER 104K-B1C -CP CAP,CER 104K-B1C -CP CAP,CER.103K-B1H -CP CAP,CER.222K-B1H -CP CAP,CER.222K-B1H -CP CAP,CER.103K-B1H -CP CAP,CER 104K-B1C -CP CAP,CER 104K-B1C -CP CAP,CER 104K-B1C -CP CAP,CER 333K-B1E -CP CAP,CER 104K-B1C -CP CAP,CER 104K-B1C -CP CAP,CER.392K-B1H -CP CAP,CER 224K-B1A -CP CAP,CER.22RJ-CH1H-CP CAP,CER 1R5C-CH1H-CP CAP,CER.56RJ-CH1H-CP CAP,CER.39RJ-CH1H-CP CAP,CER 104K-B1C -CP CAP,CER 104K-B1C -CP CAP,CER 104K-B1C -CP CAP,CER.22RJ-CH1H-CP CAP,CER 102J-CH1H-CP CAP,CER 102J-CH1H-CP CAP,CER 104K-B1C -CP CAP,CER.151J-CH1H-CP CAP,CER 561J-CH1H-CP CAP,RA 47R-05 -E5 CAP,RA 47R-05 -E5 CAP,TAN 10R-1C-B -CP CAP,TAN 10R-1C-B -CP CAP,RA 47R-05 -E5 CAP,RA 22R-OJ -E5 CAP,TAN 22R-1A-B -CP CAP,TAN.2R2-1C-A -CP CAP,RA 10R-1C -E5 CAP,RA 47R-05 -E5 CAP,TAN 10R-1C-B -CP CAP,RA 10R-1C -E5
*******DP-S MAIN P.W.Board =======IC's IC201 IC301 IC302 IC401 51T55329Y02 51